Purification and Characterization of Three Chitosanase Activities from Bacillus megaterium P1

Bacillus megaterium P1, a bacterial strain capable of hydrolyzing chitosan, was isolated from soil samples. Chitosan-degrading activity was induced by chitosan but not by its constituent d-glucosamine. Extracellular secretion of chitosanase reached levels corresponding to 1 U/ml under optimal conditions. Three chitosan-degrading proteins (chitosanases A, B, and C) were purified to homogeneity. Chitosanase A (43 kilodaltons) was highly specific for chitosan and represented the major chitosan-hydrolyzing species. Chitosanases B (39.5 kilodaltons) and C (22 kilodaltons) corresponded to minor activities and possessed comparable specific activities toward chitosan, chitin, and cellulose. Chitosanase A was active from pH 4.5 to 6.5 and was stable on the basis of activity up to 45 degrees C. The optimum temperature for enzymatic chitosan hydrolysis was 50 degrees C. Kinetic studies on chitosanase A suggest that the enzyme is substrate inhibited. The apparent K(m) and V(max) determined at 22 degrees C and pH 5.6 were 0.8 mg/ml and 280 U/mg, respectively. End products of chitosan hydrolysis by each of the three chitosanases were identified as glucosamine oligomers, similar to those obtained for previously reported chitosanase digestions.     

球孢白僵菌Bb174固态发酵产几丁质酶产酶及酶学特征研究

对球孢白僵菌(Beauveria bassiana)Bb174产几丁质酶进行了固态发酵条件及酶学特征的研究．结果表明,以4：1麸皮：蚕蛹粉、蛋白胨1g·L^-1作为产酶最适培养基,在7．5g培养基中接种3ml液态种子,自然pH下28℃培养2d,酶活可达最高,为126U·g^-1(干培养基)．粗酶液的最适反应温度为40℃,最适反应pH5．0,在30-70℃保温1h,得半失活温度48℃．在30--40℃、pH4～6范围内,酶的性质最稳定．根据Lineweaver-Burk作图法,得到该酶的动力学参数Km为0．52mg·ml^-1,Vm为0．7△E680·h^-1．     

Improved production of alkaline protease from a mutant of alkalophilic Bacillus pantotheneticus using molasses as a substrate

An alkalophilic bacterial isolate identified as Bacillus pantotheneticus, isolated from saline-alkali soils of Avadh region of UP, India, was studied for the production of alkaline protease. The mutant of the isolated species showed 44% improved production over the parent strain. Organic nitrogen sources supported better protease production than the inorganic sources. The production of alkaline protease was (242 U/ml) in the medium containing molasses, which was comparable with molasses and wheat bran (285 U/ml) as carbon and nitrogen sources, respectively. Protease production was best at pH 10 and temperature 30 degrees C. The Km (for casein) was 11 mg/ml and Vmax was 380-microg tyrosine/ml/min. The enzyme was stable between pH 7 and 10.7 and temperature between 30 and 60 degrees C with a pH and temperature optimum at 8.4 and 40 degrees C, respectively. The results indicated that molasses was an optimal substrate for alkaline protease production.     

Fermentation of starch for enhanced alkaline protease production by constructing an alkalophilic Bacillus pumilus strain

A new engineering strain, Bacillus pumilus c172-14 (pBX 96), was obtained by introducing the pBX 96 plasmid, which carries the alpha-amylase amy gene, into the host strain of alkalophilic Bacillus pumilus c172 via transformation. The newly constructed strain was found to express the amy gene and could use starch instead of glucose or starch hydrolysate as carbon source for its fermentation of alkaline protease. The pBX 96 plasmid in the new host was found to be segregationally and structurally stable. The expression of amy gene did not affect the host strain's resistance to bacteriophages. Moreover, the level of alkaline protease was improved significantly compared with the parent strain. The constructed strain gave a maximum alkaline protease activity of 14,014 U/ml in shaking flask after 48 h cultivation when growing in a medium containing 6% corn meal, 4% soybean flour, 0.4% Na2HPO4, 0.03% KH2PO4, 0.02% MgCl2, 0.3% CaCl2, 0.25% Na2CO3, 0.1% glucose, and 20 microg/ml kanamycin (pH 7.0). The optimal pH value and temperature of the alkaline protease were 11.0 and 40 degrees C, respectively. This enzyme was stable over a pH range of 8-11. Its residual activity remained at 100% when treated under a temperature of less than 45 degrees C for 30 min. The corresponding residual activity reduced to 65% of its optimal value at 60 degrees C for 30 min. The alkaline protease was a kind of serine protease, which was demonstrated by the complete inactivation by PMSF (1 mM). This newly constructed strain will be useful in the alkaline protease industry.     

壳聚糖酶产生菌的筛选及固定化细胞产酶

旨在筛选得到一株壳聚糖酶产生菌,并研究固定化细胞产酶的条件。在培养基中以壳聚糖为唯一碳源,对土壤样品进行筛选,获得一株无花果沙雷氏菌(Serratia ficaria CH-0203),该菌可被壳聚糖诱导产生壳聚糖酶。固定化细胞产酶的研究结果表明,多孔玻璃可以有效吸附CH—0203菌细胞。在最适发酵条件下(pH6．5,培养基与载体的总体积48ml,载体与培养基的比例为1．5g/4．0ml,吸附时间是20h-26h),发酵液酶活达到4．5U／ml,比游离细胞发酵提高了16％。采用半连续发酵的方式,固定化的细胞可以稳定发酵产酶120h左右。固定化细胞产酶的效率大大高于游离细胞。     

Production, purification and characterization of chitosanase produced by Gongronella sp. JG

AIMS: To optimize the production condition of chitosanases of Gongronella sp. JG and to characterize the major chitosanase. METHODS AND RESULTS: In the optimized medium and culturing condition, strain JG produced 800 micromol min(-1) l(-1) chitosanase activity at 72 h. The major chitosanase - csn1 was purified through three chromatography steps: CM (carboxymethyl)-Sepharose fast flow (FF), Sephacryl S200, SP (sulfopropyl)-Sepharose FF. The molecular weight and the pI value of csn1 were about 90,000 Da and 5 x 8, respectively. Its specific activity was 82 micromol min(-1) mg(-1). The optimal reaction pH for csn1 was between 4 x 6 and 4 x 8. The optimal reaction temperature was 50 degrees C. The half-life of csn1 at 50 degrees C was estimated to be about 65 min. Mn(2+) was a strong stimulator of csn1 activity, both at 1 and 10 mmol l(-1). csn1 showed its highest activity with chitosan of 85% degree of deacetylation, but did not hydrolyse colloidal chitin and carboxylmethyl cellulose. In 20 mmol l(-1) sodium acetate buffer (pH 4 x 8) and at 50 degrees C, the K(m) of csn1 was calculated to be 4 x 5 mg ml(-1). CONCLUSIONS: The production condition of chitosanases by Gongronella JG was optimized and the major chitosanase, csn1, was characterized. SIGNIFICANCE AND IMPACT OF THE STUDY: The present work for the first time reported the production, purification and characterization of chitosanases produced by fungus of Gongronella sp. These results provided us more information on fungal chitosanases.     

产胞外邻苯二酚1.2—双加氧酶的菌种筛选和发酵条件的研究

Two strains of Pseudomonus sp. having the extracellular catechol 1, 2-dioxygenase activity were selected from 112 bacterial strains. The conditions for enzyme production of the strains were examined. The optimal temperature and pH for enzyme formation were 30 degrees C and pH 6.8-7.0 respectively. Enzyme formation was enhanced by sodium benzoate, and was markedly inhibited by glucose, maltose and glycerol. Ammoniacal nitrogen sources were essential for cell growth and enzyme production. Sodium succinate was an effective inducer for enzyme formation. When the organism was grown in 0.15% sodium benzoate medium (pH 6.8-7.0) at 30 degrees C for 72 hours, about 10 units of catechol 1,2 dioxygenase per ml was obtained.     

Isolation and characterisation of chitosanase from Bacillus sp. 739 strain

The specific nature of the chitosanase activity of the strain Bacillus sp. 739 has been determined. Maximum enzyme activity was observed in a medium containing the biomass of the fruiting bodies of the fungus Macrolepiota procera. The chitosanase was purified to homogeneity using chromatography on DEAE-Sephadex A-50 and Toyopearl HW-50. The molecular weight of the enzyme, assessed by electrophoresis (the Laemmli procedure) approximated 46 kDa. Temperature and pH optima of the purified chitosanase were in the ranges 45-55 degrees C and 6.0-6.5, respectively. Time to half-maximum inactivation of the enzyme at 50 degrees C was equal to 1 h. With colloidal chitosan as the substrate, the value of K(M) of the purified chitosanase was equal to 25 mg/ml. The enzyme also exhibited a weak ability to hydrolyze colloidal chitin.     

Alkaline inulinase production by a newly isolated bacterium Marinimicrobium sp. LS–A18 and inulin hydrolysis by the enzyme

To date, all of microbial inulinases reported showed optimal activity at pH values ranging from 3.5 to 7.0. A bacterial strain, Marinimicrobium sp. LS-A18, showing high extracellular inulinolytic activity was isolated from a marine solar saltern of the Yellow Sea in China. Maximum enzyme activity was obtained at 55°C and pH 9.0, respectively. The inulinase activity was induced by inulin, but not by the other carbon sources employed. Under the optimal medium and culture condition, the highest inulinase activity, 14.6 U/ml, was obtained after 96 h of incubation at shake flask level. The optimal medium for inulinase production was MHI medium containing 4% inulin, 1% peptone and 5% NaCl, while the optimal culture condition for inulinase production were pH 7.5, temperature 37°C, agitation speed 210 rpm, medium volume 40 ml in 250 ml shake flask, and incubation time 96 h. A large amount of monosaccharides was released after inulin hydrolysis by the inulinase from strain LS-A18. This is the first report on alkaline inulinase production from microorganism.     

Pectin lyase from <Emphasis Type="Italic">Aspergillus giganteus</Emphasis>: Comparative study of productivity of submerged fermentation on citrus pectin and orange waste

The aim of this study was to investigate some of the factors affecting pectin lyase (PL) production by an Aspergillus giganteus strain, and to characterize this pectinolytic activity excreted into the medium. The highest activities were obtained with orange waste, citrus pectin and galacturonic acid as carbon sources. The highest activity, using citrus pectin as carbon source, was obtained in 11-day-old standing cultures, but the highest specific activity was obtained in 6.5-day-old shaken cultures, at pH 6.5 and 35°C. Using orange waste as carbon source, the highest activity was observed in 8-day-old standing cultures, at pH 7.0 and 30°C. Optimal assay conditions were pH 8.5–9.0 and 50°C. The PL activity showed thermal stability, with half-lives of 30 and 27 min when incubated at 45 and 50°C, respectively. High stability was observed at room temperature from pH 6.0 to 10.0; more than 85% of enzyme activity was preserved in this pH range. Under optimum conditions, the highest pectin lyase activity in the medium was 470 U/ml, with orange waste as carbon source.     

Optimization of alkaline protease production by <Emphasis Type="Italic">Aspergillus clavatus</Emphasis> ES1 in <Emphasis Type="Italic">Mirabilis jalapa</Emphasis> tuber powder using statistical experimental design

Medium composition and culture conditions for the bleaching stable alkaline protease production by Aspergillus clavatus ES1 were optimized. Two statistical methods were used. Plackett-Burman design was applied to find the key ingredients and conditions for the best yield. Response surface methodology (RSM) including full factorial design was used to determine the optimal concentrations and conditions. Results indicated that Mirabilis jalapa tubers powder (MJTP), culture temperature, and initial medium pH had significant effects on the production. Under the proposed optimized conditions, the protease experimental yield (770.66 U/ml) closely matched the yield predicted by the statistical model (749.94 U/ml) with R (2)=0.98. The optimum operating conditions obtained from the RSM were MJTP concentration of 10 g/l, pH 8.0, and temperature of 30 degrees C, Sardinella heads and viscera flour (SHVF) and other salts were used at low level. The medium optimization contributed an about 14.0-fold higher yield than that of the unoptimized medium (starch 5 g/l, yeast extract 2 g/l, temperature 30 degrees C, and pH 6.0; 56 U/ml). More interestingly, the optimization was carried out with the by-product sources, which may result in cost-effective production of alkaline protease by the strain.     

<Emphasis Type="Italic">Acinetobacter</Emphasis> sp. strain Ths,a novel psychrotolerant and alkalitolerant bacterium that utilizes hydrocarbon

A novel psychrotolerant, alkalitolerant bacterium, strain Ths, was isolated from a soil sample immersed in hot spring water containing hydrocarbons and grown on a chemically defined medium containing n-tetradecane as the sole carbon source. The isolate grew at 0 degrees C but not at temperatures higher than 45 degrees C; its optimum growth temperature was 27 degrees C. It grew in the pH range of 7-9. The strain utilized C(13)-C(30) n-alkane and fluorene at pH 9 and 4 degrees C. To our knowledge, this is the first report on the bacterium that utilizes a wide range of hydrocarbons at a high pH and a low temperature. Phylogenetic analysis based on 16S rRNA gene sequences showed that strain Ths is closely related to genomic species 6 ATCC 17979 (99.1% similarity), genomic species BJ13/TU14 ATCC 17905 (97.8% similarity), genomic species 9 ATCC 9957 (97.6% similarity) belonging to the genus Acinetobacter and to Acinetobacter calcoaceticus JCM 6842(T) (97.5% similarity). DNA-DNA hybridization revealed that the isolate has 62, 25, 18 and 19% relatedness, respectively, to genomic species 6 ATCC 17979, genomic species BJ13/TU14 ATCC 17905, genomic species 9 ATCC 9957 and A. calcoaceticus, respectively.     

Formation of glycosidases in batch and continuous culture of Bacteroides fragilis.

Nine strains of bacteroides fragilis were cultivated in stirred fermentors and tested for their ability to produce glycosidases. B. fragilis subsp. vulgatus B70 was used for optimizing the production of glycosidases. The highest bacterial yield was obtained in proteose peptone-yeast extract medium. The optimum pH for maximal bacterial yield was 7.0, and the optimum temperature for growth was 37 degrees C. The formation of glycosidases was optimal between pH 6.5 and 7.5, and the optimum temperature for synthesis of glycosidases was between 33 and 37 degrees C. Culture under controlled conditions in fermentors gave more reproducible production of glycosidases than static cultures in bottles. The strain was also grown in continuous culture at a dilution rate of 0.1 liter/h at pH 7.0 and 37 degrees C with a yield of 2.0 mg of dry weight per ml in the complex medium. The formation of glycosidases remained constant during the entire continuous process.     

Optimization of medium and cultivation conditions for alkaline protease production by the marine yeast Aureobasidium pullulans

A yeast strain, Aureobasidium pullulans, which could produce the high yield of protease was isolated from sediment of saltern in Qingdao, China. Maximum production of enzyme (623.1 U/mg protein; 7.2 U/ml) was obtained in a medium containing 2.5 g soluble starch and 2.0 g NaNO(3), 100ml seawater, initial pH 6.0, after fermentation at 24.5 degrees C for 30 h. The protease had the highest activity at pH 9.0 and 45 degrees C.     

Formation of glycosidases in batch and continuous culture of Bacteroides fragilis.

Nine strains of bacteroides fragilis were cultivated in stirred fermentors and tested for their ability to produce glycosidases. B. fragilis subsp. vulgatus B70 was used for optimizing the production of glycosidases. The highest bacterial yield was obtained in proteose peptone-yeast extract medium. The optimum pH for maximal bacterial yield was 7.0, and the optimum temperature for growth was 37 degrees C. The formation of glycosidases was optimal between pH 6.5 and 7.5, and the optimum temperature for synthesis of glycosidases was between 33 and 37 degrees C. Culture under controlled conditions in fermentors gave more reproducible production of glycosidases than static cultures in bottles. The strain was also grown in continuous culture at a dilution rate of 0.1 liter/h at pH 7.0 and 37 degrees C with a yield of 2.0 mg of dry weight per ml in the complex medium. The formation of glycosidases remained constant during the entire continuous process.     

Isolation, purification, and enzymatic characterization of extracellular chitosanase from marine bacterium Bacillus subtilis CH2

A Bacillus subtilis strain was isolated from the intestine of Sebastiscus marmoratus (scorpion fish) that was identified as Bacillus subtilis CH2 by morphological, biochemical, and genetic analyses. The chitosanase of Bacillus subtilis CH2 was best induced by fructose and not induced with chitosan, unlike other chitosanases. The strain was incubated in LB broth, and the chitosanase secreted into the medium was concentrated with ammonium sulfate precipitation and purified by gel permeation chromatography. The molecular mass of the purified chitosanase was detected as 29 kDa. The optimum pH and temperature of the purified chitosanase were 5.5 and 60°C, respectively. The purified chitosanase was continuously thermostable at 40°C. The specific acitivity of the purified chitosanase was 161 units/mg. The N-terminal amino acid sequence was analyzed for future study.     

酸性木聚糖酶产生菌的筛选及产酶条件

从１５０株真菌中筛选到８株产木聚糖酶活力在１００Ｕ／ｍＬ以上的菌株,其中活力最高的为黑曲霉（编号１４９）（Ａｓｐｅｒｇｉｌｕｓｎｉｇｅｒ）。该菌株产酶较适培养基为：麸皮半纤维素４％,ＮａＮＯ３１％,麸皮１％,用不加（ＮＨ４）２ＳＯ４和尿素的Ｍａｎｄｅｌｓ氏营养盐液配制。２８℃～３０℃振荡培养６０ｈ,酶活力最高可达３７５．２Ｕ／ｍＬ。该酶最适作用ｐＨ为４６,在ｐＨ３～１１之间基本稳定。该菌株发酵液中含有木聚糖酶（相对活力１００）外还有淀粉酶（１８）,甘露聚糖酶（０９８）,β木糖苷酶（０９４）和纤维素酶（０１７）。     

Production, characterization and application of keratinase from Streptomyces gulbargensis

A Streptomyces gulbargensis newly isolated, thermotolerant feather-degrading bacterial strain was investigated for its ability to produce keratinase enzyme. Maximum keratinolytic activity was observed at 45 degrees C and pH 9.0 at 120 h of incubation. Activity was completely stable (100%) between 30 and 45 degrees C and pH 7.0-9.0, respectively. Addition of starch to the growth medium affects the activity by means of increase in keratinase secretion. After seven days of cultivation, 10-fold increase (14.3 U ml(-1)) in keratinase activity was observed in the presence of 3g starch (per liter) of the medium. The enzyme was monomeric and had a molecular mass of 46 kDa. The enzyme activity was significantly inhibited by CaCl(2) and partly inhibited by EDTA, whereas, Na(2)SO(3) enhance the enzyme activity by 2.9 times more. In addition, native chicken feather was completely degraded at 96 h of incubation. The results obtained showed that newly isolated strain S. gulbargensis could be a useful in biotechnology in terms of valorization of keratin-containing wastes or in the leather industry.     

Purification and characterization of chitinases and chitosanases from a new species strain Pseudomonas sp. TKU015 using shrimp shells as a substrate

A chitinase (CHT1) and a chitosanase (CHS1) were purified from the culture supernatant of Pseudomonas sp. TKU015 with shrimp shell wastes as the sole carbon and nitrogen source. The optimized conditions of this new species strain (Gen Bank Accession Number EU103629) for the production of chitinases were found to be when the culture was shaken at 30 degrees C for 3 days in 100 mL of medium (pH 8) containing 0.5% shrimp shell powder (SSP) (w/v), 0.1% K2HPO4, and 0.05% MgSO(4).7H2O. The molecular weights of CHT1 and CHS1 determined by SDS-PAGE were approximately 68 kDa and 30 kDa, respectively. The optimum pH, optimum temperature, pH stability, and the thermal stability of CHT1 and CHS1 were pH 6, 50 degrees C, pH 5-7, <50 degrees C and pH 4, 50 degrees C, pH 3-9, <50 degrees C, respectively. CHT1 was inhibited completely by Mn2+ and Fe2+, and CHS1 was inhibited by Mn2+, Cu2+, and PMSF. CHT1 was only specific to chitin substrates, whereas the relative activity of CHS1 increased when the degree of deacetylation of soluble chitosan increased.     

L-苹果酸产生菌F-871变株合成延胡索酸酶的研究

温特曲霉AspergilluswentiiF-871是高效转化延胡索酸为L-苹果酸的变株,通过对其合成延胡索酸酶的因素进行研究,筛选了培养基主要营养元素有L-精氨酸、酪氨酸、丝氨酸、天冬氨酸、苏氨酸、赖氨酸及相应含量丰富的酵母粉、黄豆饼粉和玉米浆。该变株生长阶段条件为:pH6.0,温度2830℃,培养时间为24h,酶合成阶段最适条件:接种量15%,初始pH6.8,培养温度2830℃,装量8090ml/500ml,酶合成周期40h。在优化的培养条件下,F-871变株延胡索酸酶合成水平可达156.33u/g,100ml发酵液中的酶可将延胡索酸转化为L-苹果酸32.06g,比国内一步发酵法产酸88.5%提高约4倍,转化率由85%提高到106.87%,发酵周期由90h缩短至57h。