玉米浆对Vc二步发酵产2-酮基-L-古龙酸影响的研究

通过在培养基中添加不同量的玉米浆,研究其对氧化葡萄糖酸杆菌（俗称小菌）生产Vc前体2-酮基-L-古龙酸的影响,并研究玉米浆成分中的12种主要氨基酸对小菌产酸的影响。结果表明：每100 mL发酵培养基中添加2.5 g左右过滤除菌玉米浆时,2-酮基-L-古龙酸产量高达26.84 mg/mL,小菌活菌数为不添加玉米浆时小菌单菌发酵下的9.74倍。过量玉米浆抑制小菌产酸。12种氨基酸单独与氧化葡萄糖酸杆菌发酵培养及全部混合后与氧化葡萄糖酸杆菌发酵培养对产酸及菌体生长无影响。     

玉米浆在产甘油假丝酵母甘油发酵中的作用机理

以复合培养基和合成培养基进行比较发酵,研究了玉米浆在产甘油假丝酵母甘油发酵过程中的作用机理。结果表明:玉米浆中的磷、氮和微量元素是影响产甘油假丝酵母甘油发酵的3个关键因素。当玉米浆磷浓度为121·75mg/L(玉米浆浓度为14g/L),最大甘油转化率达到53·44%。玉米浆磷可以调节EMP途径与HMP途径之间碳架代谢流的分布,随着玉米浆浓度进一步增加,过量磷能抑制HMP途径而激活EMP途径,因而复合培养基各项发酵参数的变化非常显著。玉米浆氮对磷的调节功能有协同作用,但并不是产甘油假丝酵母甘油发酵的理想氮源。玉米浆中的微量元素能够显著提高葡萄糖的消耗速率、促进菌体的生长和增加甘油的产量。     

Biochemical Effects of Fatty Acid and its Derivatives on l-Glutamic Acid Fermentation

It has been found that although Brevibacterium lactofermentum No. 2256 is incapable of accumulating l-glutamic acid in a biotin sufficient medium, it produces a large quantity of the acid in the presence of sucrose fatty acid ester. In a biotin deficient medium, however, the ester brought the unfavorable diminution of l-glutamic acid accumulation caused by the decrease of glucose consumption in an incubation period. The undesirable effects were practically lost when the ester was added to the culture medium after more than eight hours in the course of incubation. This fact suggests that the ester is concerned with the growth of microorganism. It is very interesting to elucidate the interrelation between sucrose fatty acid ester and biotin. For the maximum accumulation of l-glutamic acid corresponding increase in amount of the ester to the increasing concentration of biotin was necessary. The proportional relation did not extend to excedingly high levels of the two implicating factors. The further observations concerning the effects of the individual fatty acid esters such as sucrose stearate remain unsatisfactory.     

Utilization of Hydrocarbons by Microorganisms

As already reported, Corynebacterium hydrocarboclastus S10B1 was able to accumulate a good deal of l-glutamate in a thiamine-deficient medium at the sole expense of n-alkanes, but unable to form l-glutamate in a thiamine-sufficient medium though an abundant cell growth was observed.

α-Ketoglutaric acid and dl-alanine were found to be produced in the same thiamine-deficient medium in which l-glutamate was accumulated. Both products formed from n-tetradecane by this organism were isolated from culture broth, purified and identified. The optimum concentration of thiamine in the culture medium was 3 to 5 µg per liter for their production. The maximum yields of α-ketoglutaric acid and dl-alanine reached 16 g and 1.5 g per liter in the calcium carbonate-added medium, respectively. However, the addition of more than 30 μg per liter of thiamine extremely repressed their accumulation.     

Utilization of Hydrocarbons by Microorganisms

The accumulation of vitamin B₂ by Pichia guilliermondii Wickerham grown on hydrocarbon was investigated. Addition of the following materials stimulated vitamin B₂ production: metal ions such as ferrous, cobalt, manganese, and calcium ions; organic nutrients such as yeast extract and casamino acid; amino acids such as proline and arginine; vitamins such as B₁, nicotinic acid, inositol, and p-aminobenzoic acid. Optimal aeration rate for vitamin B2 production was obtained in a 500-ml shaking flask containing 75 ml of the medium.     

Utilization of Hydrocarbons by Microorganisms

Corynebacterium hydrocarboclastus S10BI or S489BI can accumulate a good deal of Lglutamate in a thiamine-deficient medium at the expence of hydrocarbon, but can not form L-glutamate in a thiamine-sufficient medium in spite of rapid cell growth, as already reported. In order to establish the optimal culture condition for L-glutamate formation, the influence of the following factors was first studied: hydrocarbon concentration, pH control, nitrogen sources, temperature, aeration and supplement of metal ions or amino acids. Then L-glutamate production from a variety of hydrocarbons or petroleum fractions was examined. Sodium oleate was found to stimulate growth remarkably instead of thiamine. Ferrous ion was found to be obligatory for L-glutamate formation and was suggested to have taken part in the earliest step of n-alkane oxidation.     

Utilization of Hydrocarbons by Microorganisms

As already reported, strain S1OB1 was found to accumulate l-glutamic acid in a thiamine-deficient medium at the sole expense of hydrocarbon. In order to elucidate the biosynthetic pathway of l-glutamic acid, first of all, the incorporation of molecular oxygen into l-glutamic acid was examined. l-Glutamic acid accumulated under ¹⁸O-enriched atmosphere was separated, purified, identified and found to have been enriched with ¹⁸O. This results indicate the occurrence of oxygenase reaction involving addition of molecular oxygen. From a postulated biosynthetic pathway of l-glutamic acid, theoretical ¹⁸O content was calculated and compared with experimental one. ¹⁸O content of cells grown on n-alkane or glucose was also examined.     

Biochemical Effects of Fatty Acid and its Derivatives on l-Glutamic Acid Fermentation

Tween 60 (polyoxyethylene sorbitan monostearate) has been found to be the most effective derivative of fatty acid in accumulating l-glutamic acid in biotin-sufficient medium. The effect was exceedingly subject to the influence of the addition time of the ester, and this was observed also on the growth curve of Brev. lactofermentum. Changes of the growth curve caused by the varied addition time of the ester corresponded to those by the concentration of biotin in the medium that did not contain Tween 60. The patterns of fermentation course in the two corresponding conditions, such as biotin 3 μg/l and biotin 20 μg/l-Tween 60 mg/ml, agreed closely with each other. It seemed that identical cells were grown on the conditions. The only difference between the cells was observed as to the contents of intracellular biotin. Although l-glutamic acid was not accumulated by biotin-sufficient cells, cells with sufficient biotin and capable of accumulating l-glutamic acid were obtained in the presence of Tween 60, in which case the ester neither prevented the cells from taking up biotin nor controlled the level of intracellular biotin.     

Biochemical Effects of Fatty Acid and its Derivatives on l-Glutamic Acid Fermentation

Brev. lactofermentum rapidly took up biotin from culture medium and stored it in the cells. The saturation level of the stored biotin (3.8 × 10⁴ molecules/cell) exceeded the level required for the maximum growth by ten times, and the minimum level (1.3 × 10³ molecules/cell) was the most adequate to the accumulation of l-glutamic acid. The stored cellular biotin over the minimum level was metabolically available in the subsequent culture lacking in supplemented biotin. The cellular biotin was gradually reduced to the minimum level with the multiplication of the cells, and them the accumulation of l-glutamic acid was observed. This relation between the level of cellular biotin and the accumulation of l-glutamic acid was impaired by the addition of Tween 60 or some saturated fatty acid. In the presence of biotin and Tween 60 the biotin-saturated cells turned into cells capable of accumulating l-glutamic acid keeping the maximum level; and in the same medium the cells having the minimum amount of biotin took up biotin and then were saturated with it, and yet the cells preserved the acid-accumulating property. It was confirmed with the use of bioautographic technique and avidin test that the biotin released from the cells by acid hydrolysis was identical with authentic d-biotin.     

Biochemical Effects of Fatty Acid and its Derivatives on l-Glutamic Acid Fermentation

In the preceding paper on the interrelation between sucrose ester of fatty acid and biotin, the fatty acid being a mixture of C₁₀ to C₁₈ acid, it was described that carbon chain length of fatty acid has a great influence on the accumulation of l-glutamic acid. Fatty acids with C₁₂ to C₁₈ chain length, particularly myristic, palmitic and margaric acids were effective on the accumulation of l-glutamic acid in the culture medium containing sufficient biotin, whereas lower and higher length acids were ineffective. In the form of polyoxyethylene sorbitan or polyethylene glycol ester, C₁₆ and C₁₈ acids were remarkably effective. However, the ester of C₁₂ acid and polyoxyethylene ethers of C₁₂ to C₁₈ alcohols had little or no effect.     

Studies on l-Glutamic Acid Fermentation by Microbacterium ammoniaphilum

The present investigation is concerned with the effects of biotin and glucose on glutamic acid fermenation by Microbacterium ammoniaphilum. Both optimal amounts of biotin necessary for maximum growth and maximum accumulation of glutamic acid were determined under the conditoin of various concentration of glucose. As the glucose concentratin was increased, the amounts of biotin required for maximum growth also increased proportionally to the glucose concentrations. The optimal amounts of biotin for maximum accumulation of glutamic acid were smaller than those for maximum growth of cells at any glucose concentration. It is suggested that the process of glutamic acid accumulation is inevitably associated with the process of cell multiplication by both experiments of successive culture of cells grown under the dose of biotin sufficient and deficient for maximum growth.     

Studies on the Utilization of Hydrocarbons by Microorganisms

Taxonomical studies on ten strains of hydrocarbon-utilizing bacteria reported in previous paper, which produced various kinds of amino acid, were carried out. They were Achromo-bacter cycloclastes, Achromobacter delmarvae, Bacillus species, Corynebacterium species, Micrococcus species. Many of them were not identical with the species which are described in Bergey’s Manual of 7th Edition.     

Studies on the Utilization of Hydrocarbons by Microorganisms

In the course of investigation of alicyclic hydrocarbon-utilizing microorganisms, five strains of ethylcyclohexane-utilizing bacteria were isolated from soil samples.

Among those bacteria, the strain S6B1 that was identified as Alcaligenes faecalis, showed the best growth in shaking culture.

The strain S6B1 was found to produce 4-ethylcyclohexanol from ethylcyclohexane.

This substance separated from culture broth was purified and identified to be trans-4-ethylcyclohexanol by the use of NMR.     

Studies on the Utilization of Hydrocarbons by Microorganisms

The production of microbial cell substances from hydrocarbons has become the object of commercial attention. We have tested hydrocarbon-utilizing bacterial strains for cell production, and found out one strain of high cell yield, which is very similar to Pseudomonas aeruginosa. The effect of medium composition on cell yield and the utilization of individual hydrocarbons by this strain were investigated. Sixty percent of the added kerosene was converted into cell materials in the following medium of optimum composition: kerosene 2.5%, urea 0.13%, dipotassium phosphate 0.25%, magnesium sulfate 7 aq. 0.1% and tap water. Aliphatic series lower than C₁₀, aromatic and naphthenic hydrocarbons were not or very slightly assimilated. However, aliphatic members higher than C₁₂ were utilized with increasing case. Especially, n-docosane and octadecene-1 were utilized very effectively, and 70% of them were converted into cell substances.     

Studies on the Utilization of Hydrocarbons by Microorganisms

Many strains of the hydrocabon-utilizing yeasts were isolated from various kinds of natural sources by accumulation culture.

Among those yeasts, two strains, S315YI and S131YI, which were identified with Candida tropilcais, assimilated hydrocarbons abundantly. As for type cultures, it was found that many strains of them could utilize hydrocarbons too, especially the strains which belonged to Genus Candida. However, as regards to the ability in utilizing hydrocarbons, no yeast from type culture collections utilized hydrocarbons better than the yeasts newly isolated from nature. Addition of the natural nutrients such as corn steep liquor to the cultural broth of Strain S315Y1 showed no effect on the production of yeast cells.

The yeast Strain S315Y1 assimilated the higher boiling points fraction of n-paraffins in comparison with the hydrocarbon-utilizing bacterium, Pseudomonas aeruginosa S7B1, which had been reported by the authors. Ribonucleic acid contents of dried cells of the yeast Strain S315Y1 and S131Y1 were 5.3 and 4.4% respectively by Schmidt-Thannhauser-Schneider method.     

Studies on the Utilization of Hydrocarbons by Microorganisms

During the course of an investigation of the microbial assimilation of aromatic hydrocarbons, several strains were found to produce a large amount of cumic acid from p-cymene.

Five strains, S449B1, B2, B3, B4 and B6, were isolated from soil with the aromatic hydrocarbon substrates. They all assimilated both p-cymene and cumene. The strain S449B3 grew also on p-xylene, and S449B6 on p-xylene, toluene, and ethylbenzene.

They were all shown to be capable of producing an ultraviolet-absorbing substance from p-cymene. This substance was isolated in crystalline form and identified as cumic acid by infrared absorption spectrum and other observations.

The superior strain, S449B6, produced the acid as much as 1000 mg/1 in shaking culture at 30°C after 24 hours. The yields were increased up to approximately 1700 mg/1 after further investigations. Addition of calcium carbonate and considerable agitation were favorable conditions for the acid production.

The taxonomical studies of these strains were carried out, and they were all identified as closely resembling Pseudomonas desmolytica.     

Effects of Corn Steep Liquor on Growth Rate and Pyrene Degradation by Pseudomonas strains

The growth rates and pyrene degradation rates of Pseudomonas sp. LP1 and Pseudomonas aeruginosa LP5 were increased in corn steep liquor (CSL) supplemented. On pyrene alone the highest specific growth rate of LP1 was 0.018 h⁻¹, while on CSL-supplemented pyrene MSM, the value was 0.026 h⁻1. For LP5 the highest growth rate on CSL-supplemented pyrene-MSM was 0.034 h⁻¹. Conversely, on pyrene alone the highest rate was 0.024 h⁻¹. CSL led to marked reduction in residual pyrene. In the case of Pseudomonas sp. LP1 values of residual pyrene were 58.54 and 45.47%, respectively, for the unsupplemented and supplemented broth cultures, showing a difference of 13.09%. For LP5 the corresponding values were 64.01 and 26.96%, respectively, showing a difference of 37.05%. The rate of pyrene utilization by LP1 were 0.08 and 0.11 mg l⁻¹ h⁻¹ on unsupplemented and supplemented media, respectively. The corresponding values for LP5 were 0.07 and 0.015 mg l⁻¹ h⁻¹, respectively. These results suggest that CSL, a cheap and readily available waste product, could be very useful in the bioremediation of environments contaminated with pyrene.     

Studies on the Utilization of Hydrocarbons by Microorganisms

It is well known that a good many microorganisms can utilize hydrocarbons as a sole carbon source. We have as yt little information, however, as to what kinds of intermediate or end products are produced by the microbial dissimilation of hydrocarbons. Above all, the formation of amino acids from hydrocarbons has not been reported. We have isolated many strains of microorganisms from soil samples by selective culture techniques in a medium containing kerosene and mineral salts, in order to examine if the products of economical value such as amino acids, organic acids, fatty acids, steroids, nucleic acids and their related compounds, can be produced by those microorganisms. Shaking cultures of those microorganisms were carried out in the medium containing 3.5% kerosene, 3.5% liquid paraffin and mineral salts (K₂HPO₄ 0.25%; MgSO₄·7H₂O 0.1%; NH₄MO₈ 0.5% or urea 0.3%); we found that 55 strains out of 127 strains tested produced amino acids in their broths, after 4 days cultivation at 26.5°C. The kinds and maximum yields of amino acids were as follows: alanine 50mg/l, aspartic acid 23mg/l, glutamic acid 485 mg/1, glycine 8.5mg/l, isoleucine 15 mg/1, lysine 23.9 mg/1, and valine 38 mg/1.     

Studies on the Utilization of Hydrocarbons by Microorganisms

In the course of study on the utilization of methyl-substituents of mono-cyclic aromatic hydrocarbons by Pseudomonas aeruginosa S668B2, some organic acids and phenolic compounds were found to be produced in culture broth.

Strain S668B2 was capable of producing ultraviolet absorbing and fluorescent substances from m-xylene. These substances were isolated in the form of crystal and identified as 3-methyl salicylic acid and m-toluic acid.

Strain S668B2 also produced ultraviolet absorbing and fluorescent substances from pseudocumene (1,2,4-trimethyl benzene). These substances were isolated in the crystalline form and identified as 3,4-dimethyl benzoic acid and 3,4-dimethyl phenol.

Strain S668B″ did not attack o-xylene. Under the similar conditions Pseudomonas desmolytica S449B3, which produced a large amount of cumic acid from p-cymene, did not oxidize o-xylene, but grew on p-xylene, m-xylene and 1,2,4-trimethyl benzene.

None out of 364 soil samples gave microorganisms which utilize o-xylene as a sole carbon source.