Optimization of thermostable lipase production from a thermophilic Geobacillus sp. using Box-Behnken experimental design

Thermostable lipase production by Geobacillus thermoleovorans was optimized in shake-flask cultures using Box-Behnken experimental design. An empirical model was developed through response surface methodology to describe the relationship between tested variables (Tween 80, olive oil, temperature and pH) and enzyme activity. Maximum enzyme activity (495 U l^–1) was attained with Tween 80 at 5 g l^–1; olive oil at 60 g l^–1; 70 °C and pH 9. Experimental verification of the model showed a validation of 95%, which is more than 4-fold increase compared to the basal medium.     

Physiological regulation and optimization of lipase activity in Pseudomonas aeruginosa EF2.

Physiological regulation of extracellular lipase activity by a newly-isolated, thermotolerant strain of Pseudomonas aeruginosa (strain EF2) was investigated by growing the organism under various conditions in batch, fed-batch and continuous culture. Lipase activity, measured as the rate of olive oil (predominantly triolein) hydrolysis, was weakly induced by general carbon and/or energy limitation, strongly induced by a wide range of fatty acyl esters including triglycerides, Spans and Tweens, and repressed by long-chain fatty acids including oleic acid. The highest lipase activities were observed during the stationary phase of batch cultures grown on Tween 80, and with Tween 80-limited fed-batch and continuous cultures grown at low specific growth rates. The lipase activity of Tween 80-limited continuous cultures was optimized with respect to pH and temperature using response surface analysis; maximum activity occurred during growth at pH 6.5, 35.5 degrees C, at a dilution rate of 0.04 h-1. Under these conditions the culture exhibited a lipase activity of 39 LU (mg cells)-1 and a specific rate of lipase production (qLipase) of 1.56 LU (mg cells)-1 h-1 (1 LU equalled 1 mumol fatty acid released min-1). Esterase activity, measured with p-nitrophenyl acetate as substrate, varied approximately in parallel with lipase activity under all growth conditions, suggesting that a single enzyme may catalyse both activities.     

Increase in the activity of Rhizopus delemar lipase on water-soluble esters by its binding with phosphatidylcholine

Rhizopus (Rh.) delemar (ATCC 34612) C-lipase was found to exhibit a slight activity towards water-soluble esters. The hydrolytic reaction of this lipase on alpha-naphthyl acetate was competitively inhibited by the presence of olive oil or Tween 80. This finding showed that both substrates, insoluble triglyceride and water-soluble ester, were hydrolyzed at the same site on the enzyme. The activities on water-soluble esters (alpha-naphthyl acetate, beta-naphthyl acetate, methyl acetylsalicylate and Tween 80) increased on binding of lipase with phosphatidylcholine (PC), although the activity on olive oil did not change. The increase in activity on water-soluble esters was due to the increase in the Vmax for its hydrolysis. It appears that local structural change of the catalytic site on lipase occurred on binding of PC to the lipase molecule and resulted in an increase in the activity on water-soluble esters. The temperature dependence of the hydrolysis of water-soluble esters demonstrated that the activation energy was lowered on binding of PC to the lipase molecule, and this resulted in an increase in the activity.     

Extracellular and cell-bound lipase activity in relation to growth of Geotrichum candidum

Summary The imperfect fungus Geotrichum candidum produced extracellular lipase in a basic peptone-salt medium. By adding olive oil or Tween 80 to the basic medium the lipase yields could be enhanced and the maximal yields were found with Tween 80, which resulted in a sixfold increase in extracellular lipase activity as compared with basic medium. During the early phase of growth in medium with olive oil the proportion of cell-bound activity was higher than that of extracellular activity, and a delay in the secretion of extracellular lipase was found. The proportion of cell-bound activity from growth in basic medium and in basic medium with Tween 80 was lower than that of extracellular activity during the entire growth phase. Analyses by polyacrylamide gel electrophoresis showed that the lipase activity from growth in all three media could be ascribed to equivalent protein bands at 57 000 and 61 000 daltons. Immunodiffusion showed that the cell-bound preparation contained lipase that was immunologically identical with purified extracellular lipase from G. candidum.     

Culture condition improvement for whole-cell lipase production in submerged fermentation by Rhizopus chinensis using statistical method

Rhizopus chinensis CCTCC M201021 was a versatile strain capable of producing whole-cell lipase with synthetic activity in submerged fermentation. In order to improve the production of whole-cell lipase and study the culture conditions systematically, the combination of taguchi method and response surface methodology was performed. Taguchi method was used for the initial optimization, and eight factors viz., maltose, olive oil, peptone, K2HPO4, agitation, inoculum size, fermentation volume and pH were selected for this study. The whole-cell lipase activity yield was two times higher than the control experiment under initial optimal conditions, and four significant factors (inoculum, olive oil, fermentation volume and peptone) were selected to test the effect on the lipase production using response surface methodology. The optimal fermentation parameters for enhanced whole-cell lipase yield were found to be: inoculum 4.25 x 10(8) spores/L, olive oil 2.367% (w/v), fermentation volume 18 mL/250 mL flask, peptone 4.06% (w/v). Subsequent experimental trails confirmed the validity of the model. These optimal culture conditions in the shake flask led to a lipase yield of 13875 U/L, which 120% increased compare with the non-optimized conditions.     

Optimization of mono and diacylglycerols production from enzymatic glycerolysis in solvent-free systems

This work reports solvent-free enzymatic glycerolysis of olive oil with an immobilized lipase (Novozym 435) using Tween 40, Tween 65, Tween 80, Tween 85, Triton X-100, and soy lecithin as surfactants. The first step was the screening of two potential surfactants for Monoacylglycerol (MAG) and Diacylglycerol (DAG) production with a pre-established operating condition and 2 h of reaction time. Afterwards, a sequential experimental design strategy was carried out in order to optimize MAG and DAG production using Tween 65 and Triton X-100 as surfactants. The operating conditions that optimized MAG and DAG yields were 70 °C, stirring rate of 600 rpm, glycerol:olive oil molar ratio of 6:1, 16 wt% of surfactant Tween 65 and 9.0 wt% of Novozym 435, leading to a content of 26 and 17 wt% of MAG and DAG, respectively.     

Specificity of a Tween-Lipase in Hydrolysis of Olive Oil

A specific lipase for the hydrolysis of Tween present in a Sclerotinia lipase preparation was fractionated by various extraction procedures, ion-change resin treatment and dialysis. The activity of the Tween-lipase on olive oil was significant in Increasing the hydrolysis of the olive oil by combination with various other lipases. Also, it seemed to develop with the change in the state of emulsion of the reaction mixture during hydrolysis.     

Isolation and characterization of a thermophilic lipase from Bacillus thermoleovorans ID-1

A thermophilic microorganism, Bacillus thermoleovorans ID-1, isolated from hot springs in Indonesia, showed extracellular lipase activity and high growth rates on lipid substrates at elevated temperatures. On olive oil (1.5%, w/v) as the sole carbon source, the isolate ID-1 grew very rapidly at 65 degrees C with its specific growth rate (2.50 h(-1)) and its lipase activity reached the maximum value of 520 U l(-1) during the late exponential phase and then decreased. In addition to this, isolate ID-1 could grow on a variety of lipid substrates such as oils (olive oil, soybean oil and mineral oil), triglycerides (triolein, tributyrin) and emulsifiers (Tween 20, 40). The excreted lipase of ID-1 was purified 223-fold to homogeneity by ammonium sulfate precipitation, DEAE-Sephacel ion-exchange chromatography and Sephacryl S-200 gel filtration chromatography. As a result, the relative molecular mass of the lipase was determined to be 34 kDa on sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE). The enzyme showed optimal activity at 70-75 degrees C and pH 7.5 and exhibited 50% of its original activity after 1 h incubation at 60 degrees C and 30 min at 70 degrees C and its catalytic function was activated in the presence of Ca(2+) or Zn(2+).     

Purification and properties of extracellular lipase from Pseudomonas aeruginosa EF2.

Extracellular lipase was purified from a Tween 80-limited continuous culture of Pseudomonas aeruginosa EF2 by ultrafiltration of the culture supernatant followed by anion-exchange and gel-filtration FPLC. The lipase was composed of a single subunit (Mr 29,000, pI 4.9), which was capable of a variable degree of aggregation, and which exhibited both lipase activity, measured with the insoluble substrate olive oil (predominantly triolein), and esterase activity, measured with the soluble substrates p-nitrophenyl acetate and Tween 80. Lipase activity was approximately eight times higher than either type of esterase activity (kcat approximately 3000 s-1 for the hydrolysis of olive oil). The enzyme showed a marked regiospecificity for the 1,3-oleyl residues of radiolabelled triolein, was relatively stable at moderate temperatures (exhibiting a biphasic loss of activity with an initial t1/2 of 17.5 min at 60 degrees C) and was very stable to freezing and thawing. Lipase activity was only weakly inhibited by the serine-active reagent 3,4-dichloroisocoumarin, and was not inhibited by the chelating agent EDTA (1 mM). The N-terminal amino acid sequence of the Ps. aeruginosa EF2 lipase showed a marked similarity to those of several other bacterial lipases.     

Production and extraction of extracellular lipase from the entomopathogenic fungus Isaria fumosoroseus (Cordycipitaceae; Hypocreales)

Lipases are important cuticle degrading enzymes involved in the infection process of entomopathogens by hydrolysing the ester bonds of lipoproteins, fats and waxes present in the insect integument. Production of extracellular lipase by Isaria fumosoroseus (Cordycipitaceae; Hypocreales) isolate IF28.2 was investigated using different combinations of basal medium components. The effect of different vegetable oils added to a basal medium at different concentrations to improve enzyme production was evaluated. Maximum lipase activity (125.33±2.96 U/mL) as well as maximum biomass production (22.36±0.99 mg/mL) was observed for olive oil when used at a concentration of 2% (v/v) of the basal medium. In the presence of surfactants, the highest lipase activity occurred when SDS and Tween 80 were added at the time of fungal inoculation. SDS proved to be the best surfactant having 110.66±3.52 U/mL lipase activity. The effects of the divalent metal ions (iron and magnesium) on lipase activity were also studied. Iron inhibited, whereas magnesium slightly increased lipase activity. The optimum pH for lipase production was 5.7 while 32°C proved to be the best temperature for lipase production.     

Lipase production by free and immobilized protoplasts of Sporotrichum (Chrysosporium) thermophile Apinis

Summary Production of lipase by free and alginate-entrapped protoplasts was studied in batch culture. Cell-wall-degrading enzymes Novozym 234 and cellulase CP improved lipase secretion of normal mycelium by 25%–100%. The protoplast-regenerated mycelium exhibited several-fold higher lipase activity in batch replacements in TRIS buffer over normal spore-derived mycelium. The specific lipase activity of immobilized protoplasts was about four times higher than normal mycelial beads. Protoplasts beads were stable and retained high enzyme activity even after three buffer replacements lasting 120 h; TRIS buffer was better than acetate or normal glucose medium. A minimum of 8 h regeneration period was necessary for lipase synthesis. Triolein, olive oil, tributyrin and oleic acid butylester were able to induce lipase in immobilized protoplasts. Tween 80 enhanced lipase activity of the immobilized protoplasts. Partially degraded immobilized mycelium was nearly as effective as normal immobilized protoplasts for lipase secretion. Both free and immobilized protoplasts could be reused for up to 200 h with some loss in enzyme activity.     

Assaying lipase activity from oil palm fruit (Elaeis guineensis Jacq.) mesocarp.

The mesocarp of mature oil palm fruit undergoes intensive triglycerides hydrolysis upon abscission and bruising. This generates such a high amount of free fatty acids that the oil might become unfit for human consumption without appropriate refining. The lipase (EC 3.1.1.3) involved in the breakdown of the oil is not stable after homogenization of the tissue in aqueous buffers. In this study, we have devised a solvent-based procedure that allowed us to obtain fractions with stable lipase activity. Using these fractions, we have determined the optimal conditions for assaying mesocarp lipase activity. The activity was highest at a temperature of 35 degrees C and a pH of 9. The lipase was found to be strictly calcium dependent. The specific activity of the lipase measured in optimal conditions was found to be 33 mumol fatty acids released min(-1) mg(-1) protein using olive oil as substrate. The mesocarp contains about 190 U of lipase g(-1) fresh weight. This activity was found to be inhibited by the lipase inhibitor tetrahydrolipstatin (THL), suggesting that the lipase is a serine hydrolase.     

Thermostable lipase of Bacillus Stearothermophilus: high-level production, purification, and calcium-dependent thermostability

An efficient expression system was developed for the production of the thermostable lipase from Bacillus stearothermophilus L1 in an Escherichia coli system. A structural gene corresponding to mature lipase was subcloned in the pET-22b(+) expression vector and its expression was induced by IPTG at 30 degrees C in E. coli cells. The lipase activity in a cell-free extract was as high as 448,000 units/g protein, which corresponds to as much as 26% of the total cellular protein and is 77 times higher than that of E. coli RR1/pLIP1. Based on its pI (7.4) and pH stability data reported previously, the L1 lipase was efficiently purified to homogeneity with CM (at pH 6.0) and DEAE (at pH 8.8) column chromatographies with a recovery yield of 62%. The specific activity of the purified enzyme was 1700 units/mg protein when olive oil emulsion was used as a substrate. Its optimum temperature for the hydrolysis of olive oil was 68 degrees C and it was stable up to 55 degrees C for 30 min-incubation. The thermostability increased by about 8-10 degrees in the presence of calcium ions. This calcium-dependent thermostability was confirmed by the tryptophan fluorescence emission kinetics showing that the enzyme starts to unfold at 66 degrees C in the presence of calcium ions but at 58 degrees C in the absence of calcium ions, implying that the calcium ions bind to the thermostable enzyme and stabilize the protein tertiary structure even at such high temperatures.     

High-level heterologous expression and properties of a novel lipase from Ralstonia sp. M1

The mature lipase LipA and its 56aa-truncated chaperone DeltaLipBhis (with 6xhis-tag) from Ralstonia sp. M1 were over-expressed in Escherichia coli BL21 under the control of T7 promoter with a high level of 70 and 12mg protein per gram of wet cells, respectively. The simply purified lipase LipA was effectively refolded by Ni-NTA purified chaperone DeltaLipBhis in molar ratio 1:1 at 4 degrees C for 24 hours in H2O. The in vitro refolded lipase LipA had an optimal activity in the temperature range of 50-55 degrees C and was stable up to 45 degrees C with more than 84% activity retention. The maximal activity was observed at pH 10.75 for hydrolysis of olive oil and found to be stable over alkaline pH range 8.0-10.5 with more than 52% activity retention. The enzyme was found to be highly resistant to many organic solvents especially induced by ethanolamine (remaining activity 137-334%), but inhibited by 1-butanol and acetonitrile (40-86%). Metal ions Cu2+, Sn2+, Mn2+, Mg2+, and Ca2+ stimulated the lipase slightly with increase in activity by up to 22%, whereas Zn2+ significantly inhibited the enzyme with the residual activity of 30-65% and Fe3+ to a lesser degree (activity retention of 77-86%). Tween 80, Tween 60, and Tween 40 induced the activation of the lipase LipA (222-330%) and 0.2-1% (w/v) of Triton X-100, X-45, and SDS increased the lipase activity by up to 52%. However, 5% (w/v) of Triton X-100, X-45, and SDS inhibited strongly the activity by 31-89%. The inhibitors including DEPC, EDTA, PMSF, and 2-mercaptoethanol (0.1-10mM) inhibited moderately the lipase with remaining activity of 57-105%. The lipase LipA hydrolyzed a wide range of triglycerides, but preferentially short length acyl chains (C4 and C6). In contrast to the triglycerides, medium length acyl chains (C8 and C14) of p-nitrophenyl (p-NP) esters were preferential substrates of this lipase. The enzyme preferentially catalyzed the hydrolysis of cottonseed oil (317%), cornoil (227%), palm oil (222%), and wheatgerm oil (210%) in comparison to olive oil (100%).     

Production and activity of extracellular lipase from Luteibacter sp.

Microbial lipases are widely used in industrial applications due to their versatility, and the characterization of new lipase-producing microorganisms could provide new sources of these enzymes, with different specificities and better activities. In this context, we have improved lipase production by Luteibacter sp. by using basal medium supplemented with 2 % olive oil, a pH of 6 and a growth temperature of 37 °C. The enzyme extraction process with the addition of 0.25 % Tween 80 increased lipase activity. Implementation of these modifications increased lipase activity by approximately 430 %. The lipase activities produced in the culture supernatant (LCS) and extracted with Tween 80 (LCST80) were characterized. Both extracts hydrolyzed ρ-nitrophenyl (ρNP) esters with different acyl chain lengths, with a preference for short acyl lengths, and had optimum activity at 45 °C. The LCS was stable at acidic and alkaline pH, but LCST80 was only stable at alkaline pH. Methanol, SDS, Triton X-100, EDTA, and EGTA did not affect lipase activity, while divalent cations (Ca²⁺, Zn²⁺, Mg²⁺) - with the exception of Co²⁺— increased lipase activity. Both extracts showed transesterification activity on ρNP ester substrates, and both were able to hydrolyze different natural lipids. The characterization of lipase produced by Luteibacter sp. introduces this recently described genus as a new source of lipases with great biotechnological potential.     

Utilization of powdered pig bone as a support for immobilization of lipase

Pig bone was examined for its suitability as a support material for lipase immobilization. It was observed that pig bone (PB) particles dispersed readily in both polar and nonpolar solvents, and lipase was easily adsorbed. In particular lipase adsorbed on olive oil-soaked pig bone (OPB) particles exhibited a higher hydrolytic activity than that in lipase adsorbed on a selection of other representative supports, regardless of removing the presoaked olive oil from the particles after immobilization of lipase. The optimum pH and temperature for hydrolytic activity of OPB-adsorbed lipase were the same as those for free lipase, although thermal resistance was increased by immobilization. When OPB-adsorbed lipase was used for repeated batch reactions of olive oil hydrolysis, an activity of more than 80% of the initial activity of each run could he retained after 46 h reaction. The results suggest that PB is an excellent support material.     

Effects of lipidic carbon sources on the extracellular lipolytic activity of a newly isolated strain of Bacillus subtilis

An isolate exhibiting high extracellular lipolytic activity was identified as Bacillus subtilis by 16S rRNA gene sequence analysis. The enzyme activity of the isolate was improved by using different concentrations of lipidic carbon sources such as vegetable oils, fatty acids and triglycerides. Lipolytic activity was assayed spectrophotometrically using p-nitrophenyl palmitate. One percent (v/v) of sesame oil provided the highest activity with 80 and 98% enhancements with respect to 1% (v/v) concentrations of linoleic acid and triolein as the favored fatty acid and triglyceride, respectively. Glucose presented a repressive effect on lipase production. Lipase secreted by B. subtilis was partially purified by ultrafiltration and anion exchange chromatography; and the purified enzyme was tested for its residual activity in the presence of EDTA, SDS, Triton X-100, Tween 20, Tween 80 and protease. The present work reports, for the first time, that the lipolytic activity of a B. subtilis strain can be improved by using inexpensive vegetable oils; and also that B. subtilis lipase is suitable for use in detergents.     

Optimization of extracellular lipase production from the biocontrol fungus Nomuraea rileyi

Lipases are important cuticle-degrading enzymes that hydrolyze the ester bonds of waxes, fats and lipoproteins during the infection of insects by the fungus Nomuraea rileyi. Lipase production by the N. rileyi strain MJ was optimized by varying environmental and nutritional conditions in culture medium containing different vegetable oils at various concentrations with shaking at 150 rpm for 8 days at 25°C. The maximum lipase production was obtained using castor oil (30.5±0.6 U mL^?1), followed in order by coconut oil (20.8±0.4 U mL^?1), olive oil (20.8±0.4 U mL^?1) and cottonseed oil (20.6±0.4 U mL^?1). The highest lipase activity (37.7±0.4 U mL^?1) was obtained when castor oil was used at a concentration of 4% (v/v) of basal medium. When the surfactant Tween 80 was added at the fourth day rather than at the beginning of incubation, a maximum lipase activity of 44.9±3.5 U mL^?1 was obtained. The optimal temperature and pH for lipase production were 25°C and pH 8.0, respectively. This is the first report on lipase production by the biocontrol fungus N. rileyi.     

Optimization of medium composition for lipase production by Candida rugosa NCIM 3462 using response surface methodology

A sequential optimization approach using statistical design of experiments was employed to enhance the lipase production by Candida rugosa in submerged batch fermentation. Twelve medium components were evaluated initially using the Plackett-Burman 2-level factorial design. The significant variables affecting lipase production were found to be glucose, olive oil, peptone, (NH4)2SO4, and FeCl3.6H2O. Various vegetable oils were tested in the second step, and among them, groundnut oil was found to be the best inducer for lipase production by C. rugosa. The third step was to identify the optimal values of the significant medium components with groundnut oil as the inducer using response surface methodology. The regression equation obtained from the experimental data designed using a central composite design was solved, and analyzing the response surface contour plots, the optimal concentrations of the significant variables were determined. A maximum lipase activity of 5.95 U.mL-1, which is 1.64 times the maximum activity obtained in the Plackett-Burman experimental trials, was observed. The optimum combination of medium constituents contained 19.604 g.L-1 glucose, 13.065 mL.L-1 groundnut oil, 7.473 g.L-1 peptone, 0.962 g.L-1 (NH4)2SO4, 0.0019 g.L-1 FeCl3.6H2O, and other insignificant components at the fixed level. A predictive model of the combined effects of the independent variables using response surface methodology and an artificial neural network was proposed. The unstructured kinetic models, logistic model, and Luedeking-Piret model were used to describe cell mass and lipase production. The parameters of the models were evaluated and the lipase production by C. rugosa was found to be growth associated.