Appraising freeze-drying for storage of bacteria and their ready access in a rapid toxicity assessment assay

Direct toxicity assessment (DTA) techniques seek to measure the impact of toxic chemicals on biological materials resident in the environment. This study features the use of freeze-dried bacterial cells in combination with a rapid DTA analyser, SciTOX^?. The effects of three factors—cryoprotectant type, bacterial strain, and storage temperature—were tested in order to validate the shelf life of the freeze-dried cells. Three freeze-dried Gram-negative bacterial strains, Acinetobacter calcoaceticus, Escherichia coli and Pseudomonas putida, were tested by using the bacteria in the SciTox^? DTA assay and recording their responses to two standard toxicants: 2,4-dicholorophenol and 3,5-dichlorophenol. Each freeze-dried strain of bacteria was prepared in two forms—either pre-treatment with polyethylene glycol (PEG) or with sucrose/Tween 80—prior to storing at either 4 or ?20 °C for three different storage periods (1, 2 or 3 months). While the sucrose/Tween 80 pre-treated freeze-dried cells exhibited better cell viability, we concluded that PEG was a more suitable cryoprotectant for the bacteria used in the DTA assay because of EC₅₀ parity with fresh cell and zero-time freeze-dried cell assays. The results showed that freeze-dried cells, with appropriate materials and conditions, can give reproducible DTA results for up to 3 months. The availability of a biocomponent that can be activated by simple rehydration makes the deployment of this technology much easier for an end user.     

Arylsulfatase activity of Mycobacterium avium, M. intracellulare, and M. scrofulaceum

A rapid (3-h) arylsulfatase assay for cell suspensions of mycobacteria, in which p-nitrophenyl sulfate is used as the substrate, was developed. Arylsulfatase activity was found in cell suspensions of representative strains of Mycobacterium avium, Mycobacterium intracellulare, and Mycobacterium scrofulaceum grown without the substrate in either Middlebrook 7H9 medium containing 0.2% (wt/vol) glucose and 0.05% (vol/vol) Tween 80 or Dubos broth medium, but was absent in cells grown in a low-pH, minimal medium containing 1% (vol/vol) Tween 80 as the sole carbon source. The levels of arylsulfatase activity of representatives of all three species were equal whether the activity was measured at pH 5.5, 6.5, or 7.5 and whether the cells were suspended in phosphate or Tris buffer. The addition of high levels of sulfate (present in the low-pH, Tween 80-containing medium) to Middlebrook 7H9 medium resulted in significantly lower levels of arylsulfatase activity in strains of M. scrofulaceum, but did not affect the levels in either M. avium or M. intracellulare. The levels of arylsulfatase activity were highest in M. avium, intermediate in M. intracellulare, and lowest in M. scrofulaceum strains. Polyacrylamide gel electrophoresis of crude extracts from late-log-phase cells of representatives of each species produced activity bands of unique mobility (one in M. avium, three in M. intracellulare [82, 5, and 13%], and two in M. scrofulaceum [60 and 40%]).     

Efficacy of dry powders from Bacillus sphaericus: RB 80, a potent reference preparation for biological titration

Larvicidal potency of three primary powders based on Bacillus sphaericus strains 1593 and 1881 was studied on mosquito larvae. Two acetone powders, P 1593 and P 1881, were very toxic for Anopheles stephensi larvae. The potency of a third lyophilized powder RB 80 made from 1593 strain compared even better when tested against Anopheles stephensi and Culex pipiens pipiens larvae. LC₅₀'s after 48 hr were 0.15 and 0.003 mg/ml, respectively. After storage of RB 80 aqueous suspensions over 2 years or after heat exposure of RB 80 powder, larvicidal potency was still high, indicating an excellent stability. The use of RB 80, because of all its qualities, is suggested as a first experimental standard for titration of B. sphaericus preparations.     

The accumulation of bacteriochlorophyll precursors by mutant and wild-type strains of Rhodopseudomonas spheroides

1. Two mutant strains of Rhodopseudomonas spheroides, which are blocked in the synthesis of bacteriochlorophyll, accumulate pigments. These have been tentatively identified as magnesium 2,4-divinylphaeoporphyrin a₅ monomethyl ester and the magnesium derivative of 2-devinyl-2-hydroxyethyl-phaeophorbid a, formed by mutant 2/73 and 2/21 respectively. 2. Maximum extracellular production of these pigments occurs when suspensions of the organisms are incubated with low aeration in a growth medium containing iron and supplemented with glycine, succinate, methionine and Tween 80. 3. Concomitant protein synthesis is required for pigment production by the mutants from glycine and succinate but this requirement is less marked when δ-aminolaevulic acid is the substrate. 4. In the absence of Tween 80, a considerable proportion of the total pigment is retained within the cells and appears in the particulate fraction of cell-free extracts. 5. Suspensions of the parent strain containing δ-aminolaevulic acid can be made to accumulate extracellular pigments which are tentatively identified as magnesium protoporphyrin monomethyl ester and the magnesium derivative of 2-devinyl-2-hydroxyethyl-phaeophorbid a. 6. Maximum production occurs with cells incubated photosynthetically after a period of oxygen repression of bacteriochlorophyll synthesis. Formation of the phaeophorbid derivative is enhanced by 8-azaguanine or 5-fluorouracil, or by adenine deficiency in a nutritional mutant; Tween 80 is also needed and iron is essential. 7. Synthesis of bacteriochlorophyll might possibly involve the participation of lipoprotein-bound intermediates, which may be formed at the initial stage of condensation between glycine and succinyl-CoA to give δ-aminolaevulic acid.     

Relationship of Cellular Fatty Acid Composition to Survival of Lactobacillus bulgaricus in Liquid Nitrogen

Concentrated cultures of Lactobacillus bulgaricus were prepared by resuspending cells grown in semisynthetic media in sterile 10% non-fat milk solids. The concentrated cultures were frozen in liquid nitrogen for 24 h. The cell suspensions exhibited decreased viability after storage, and the amount of death varied among the different strains tested. Storage stability of all strains examined was improved by supplementing the growth medium with sodium oleate. Radioisotopes were used to study the fate of sodium oleate with L. bulgaricus NCS1. [1-(14)C]sodium oleate was incorporated solely into the lipid portion of the cells, including both neutral and polar lipids. The fatty acid composition of L. bulgaricus NCS1, NCS2, NCS3, and NCS4 grown with and without sodium oleate was studied. The major fatty acids of strains NCS1, NCS2, and NCS3 grown without sodium oleate were dodecanoic, tetradecanoic, hexadecanoic, hexadecenoic, and octadecenoic acids. In addition to these, strain NCS4 contained C(19) cyclopropane fatty acid. The major fatty acids of all strains grown with sodium oleate were tetradecanoic, hexadecanoic, hexadecenoic, octadecenoic, and C(19) cyclopropane fatty acids. All strains grown in broth containing sodium oleate contained larger amounts of octadecenoic and C(19) cyclopropane fatty acid, and less saturated fatty acids than when grown without sodium oleate. Statistical analyses indicated that C(19) cyclopropane fatty acid was most closely related to stability of the lactobacilli in liquid nitrogen. A negative regression line that was significant at P < 0.001 was obtained when the cellular content of this fatty acid was plotted against death.     

β-Galactosidase in immobilized cells of Daucus carota L.

The cell suspension culture Daucus carota L. was permeabilized by Tween 80 and immobilized by glutaraldehyde. β-Galactosidase showed an optimum pH of 4.7 and an optimum temperature of 55 °C. The enzyme hydrolysis was linear for 3 h, reaching a 65% conversion. A very good level of storage stability was achieved when using dry catalyst, or a solution of 0.15 M NaCl with the addition of chloramphenicol, (l-methyldodecyl)-dimethylamin-4-oxide (ATDNO), chlortetracycline hydrochloride (CLCTC) or by freezing the immobilized cells in 0.15 M NaCl. The cells characterized by high enzyme activity and stability in long-term storage showed convenient physicomechanical properties.     

Enhancement of bile tolerance in lactococci by Tween 80

AIMS: The aim of this study is to clarify the effect of Tween 80 on bile tolerance of lactococci. METHODS AND RESULTS: Four out of the six strains of lactococci could grow in broth containing 0.3% bile in the presence of 1% Tween 80, but grew slightly or not at all in the absence of Tween 80. Growing with Tween 80 altered the fatty acid composition of all three strains tested, but it is not clear which fatty acid influences bile tolerance. Material that absorbed light at 260 nm leaked from the cells tested with bile, but the leakage was decreased by addition of 1% Tween 80. Coincidentally, the decrease in the cell count by exposure to bile was suppressed by addition of Tween 80. CONCLUSIONS: Tween 80 enhances bile tolerance of some strains of lactococci. SIGNIFICANCE AND IMPACT OF THE STUDY: It is clarified that Tween 80 in the broth contributes to the bile tolerance of lactococci by reducing the cellular leakage caused by bile.     

Antigenic Analysis of Rhizobium japonicum by Immunodiffusion

Immunodiffusion reactions were studied with seven strains of Rhizobium japonicum and three strains of the cowpea miscellany by using antisera against eight of the strains. Most strains yielded only weak precipitin bands when untreated cell suspensions were used as antigens in the diffusions. Ultrasonic disruption or heat treatment of the cells led to stronger bands, and immersion in boiling water for 20 min was used as the standard procedure for preparing these bacteria for immunodiffusion analysis. Heat-labile antigens were detected in only a few strains; the major antigens of all of the strains appeared to be heat-stable. Many of the strains cross-reacted, sometimes in a nonreciprocal manner; unheated cell suspensions cross-reacted more widely but more weakly than the heated suspensions. Heat-treated crushed nodule preparations reacted well in immunodiffusions. The antigens of cultured cell and nodule extract (bacteroid) forms of three strains were compared. In one of these strains, an antigen present in the cultured cells was absent from the bacteroids. Unknown strains present in soybean root nodules were readily identified by immunodiffusion.     

Effect of the Surfactant Tween 80 on the Detachment and Dispersal of Salmonella enterica Serovar Thompson Single Cells and Aggregates from Cilantro Leaves as Revealed by Image Analysis

Salmonella enterica has the ability to form biofilms and large aggregates on produce surfaces, including on cilantro leaves. Aggregates of S. enterica serovar Thompson that remained attached to cilantro leaves after rigorous washing and that were present free or bound to dislodged leaf tissue in the wash suspension were observed by confocal microscopy. Measurement of S. Thompson population sizes in the leaf washes by plate counts failed to show an effect of 0.05% Tween 80 on the removal of the pathogen from cilantro leaves 2 and 6 days after inoculation. On the contrary, digital image analysis of micrographs of single cells and aggregates of green fluorescent protein (GFP)-S. Thompson present in cilantro leaf washes revealed that single cells represented 13.7% of the cell assemblages in leaf washes containing Tween 80, versus 9.3% in those without the surfactant. Moreover, Tween 80 decreased the percentage of the total S. Thompson cell population located in aggregates equal to or larger than 64 cells from 9.8% to 4.4% (P < 0.05). Regression analysis of the frequency distribution of aggregate size in leaf washes with and without Tween 80 showed that the surfactant promoted the dispersal of cells from large aggregates into smaller ones and into single cells (P < 0.05). Our study underlines the importance of investigating bacterial behavior at the scale of single cells in order to uncover trends undetectable at the population level by bacterial plate counts. Such an approach may provide valuable information to devise strategies aimed at enhancing the efficacy of produce sanitization treatments.     

Application of hydrophilic–lipophilic balance (HLB) number to optimize a compatible non-ionic surfactant for dried aerial conidia of Beauveria bassiana

The hydrophilic–lipophilic balance (HLB) number system was used to optimize a compatible non-ionic surfactant, TDA (polyoxyethylene tridecyl ether) in formulations for two Beauveria bassiana strains, NI8 and GHA. The optimal HLB number for TDA was determined on the basis of wetting times for conidial powders. The results indicated that optimal HLB number of TDA for B. bassiana strain NI8 was 8, while the optimum HLB number for strain GHA was 10. The optimized TDA surfactants required significantly less wetting times than the commonly used laboratory surfactants, Triton X-100, Span 80, and Tween 80. These optimized TDA surfactants were further characterized on their ability to produce conidial suspensions of the two strains after 5 min of mixing, TDA HLB 8 and TDA HLB 10 produced suspensions of 1.8 × 10⁸ and 1.6 × 10⁸ conidia/ml for NI8 and GHA, respectively. These conidial levels were significantly higher than those in Triton X-100, Span 80, and Tween 80 suspensions after the same mixing time. Germination assays showed that TDA HLB 8 promoted significantly higher germination rates of strain NI8 than those observed in other commonly used laboratory surfactants. However, the germination rates of the GHA strain were unaffected by any of the surfactants tested. The efficacy of the conidial suspensions was confirmed with assays against Lygus lineolaris. Bioassay results indicated that there were no significant differences in mortalities because of surfactants. These results suggest optimization based upon HLB number will not negatively impact parameters associated with efficacy, while providing desirable physical properties.     

Effect of tweens on the production of ergot alkaloids byAspergillus fumigatus

Tween 80, which caused increased biomass formation, also produced the highest increase in the uptake rate of all components of the medium. The fatty acid components of the respective Tweens,i.e. palmitic acid (Tween 40), stearic acid (Tween 60), and oleic acid (Tween 80), have no effect either on alkaloid production or on substrate uptake. The fatty acid composition was different in the cell membrane of the culture supplemented with Tween 60 and facilitated the transport of metabolites into the cells.     

Influence of lyophilization, fluidized bed drying, addition of protectants, and storage on the viability of lactic acid bacteria

Aims:  The present study focuses on the impact of two different drying technologies and the influence of protectants on process survival and storage stability of the two lactic acid bacterial strains Enterococcus faecium and Lactobacillus plantarum .
Methods and Results:  After incubation with the protectants glucose, sucrose, trehalose, and maltodextrin the concentrated bacterial suspensions were subjected to fluidized bed drying and lyophilization and subsequently stored at 4, 22, and 35°C for half a year. Lactobacillus plantarum turned out to be more sensitive to both drying methods than Ent. faecium . Without the addition of a protectant cells of both strains suffered higher losses during fluidized bed drying. Elevated storage temperatures correlate with a higher decline of viable bacterial cells.
Conclusions:  Although survival rates varied between the strains, the nonreducing disaccharides revealed overall best protection for both investigated lactic acid bacteria during processing and storage. The addition of protective carbohydrates can prevent the decline in viability during fluidized bed drying.
Significance and Impact of the Study:  The influence of protectants proved to be species specific and therefore needs to be determined on a case-to-case basis. Survival rates, duration, and energy consumption appear to be the crucial parameters to evaluate the economy of production processes for industrial starter cultures.     

An Improved Diluent for Rubella Hemagglutination and Hemagglutination-Inhibition Tests

Rubella hemagglutinating (HA) antigen was prepared in BHK-21 tissue as 5% cell suspensions and from unconcentrated and 20× concentrated infected supernatant fluids. In some instances, unconcentrated fluids were treated with Tween 80 and ether; cell suspensions were treated with ether alone. Preparations were tested for HA activity in dextrose-gelatin-Veronal (DGV) buffer solutions; 0.85% NaCl; Sorenson's phosphate-buffered saline, pH 7.2; and a diluent of 0.9% NaCl, 0.1% CaCl₂ (anhydrous), and 0.1% MgSO₄·7H₂O. HA titers were consistently two- to fourfold higher in the saline with added Ca⁺⁺ and Mg⁺⁺ than in DGV. Hemagglutination-inhibition titers of paired human sera were the same in either diluent. It is suggested that the interaction between rubella HA antigen and the red cells of young (less than 1-day-old) chicks may be at least partially ion dependent and that titers are enhanced by increased quantities of divalent cations.     

α-Galactosidase in immobilized cells of Papaver somniferum L.

A poppy cell suspension culture was permeabilized by Tween 80 and immobilized by glutaraldehyde. The α-Galactosidase in these cells showed an optimum pH level at 5.2 and an optimum temperature at 70 °C. Enzyme hydrolysis was linear for 3 h, reaching 86% conversion. A very good level of storage stability was achieved when using dry catalyst and immobilized cells in 0.15 M NaCl solution (with the addition of chloramphenicol, [1-methyldodecy1)-dimethylamin-4-oxide (ATDNO), chlortetracycline hydrochloride (CLCTC)] or by freezing them in 0.15 M NaCl solution.     

Effect of tween series surfactants on alkaloid production by submerged cultures of Claviceps species

Supplementation of Tween surfactants promoted alkaloid production by submerged cultured of Claviceps sp. strain SD-58. Tween 80 (0.5%) exhibited the maximum (2-fold) stimulatory effect when added to the medium at the initial stage of cultivation. The stimulation of alkaloid production by Tween 80 was found to be associated with the increase in cell mass, higher consumption of nutrients and enhanced excretion of alkaloids from the cells. The results are discussed in relation to the physiology of alkaloid production in Claviceps sp. strain SD-58.     

吐温80对体外HeLa细胞的杀伤抑制

研究吐温80对体外培养HeLa细胞的杀伤抑制。通过MTT法检测并观察了不同浓度吐温80、大肠杆菌内毒素(LPS)及前列腺素E1(PGEI)对体外培养HeLa细胞作用后细胞抑制率;将作用后细胞裂解液经SDS-PAGE及Western-blotting法测定其热休克蛋白70(Heat Shock Protein70,HSP70)表达。结果:0.02％吐温80具有明显杀伤HeLa细胞的作用,且作用后的HeLa细胞几乎无HSP70蛋白表达(正常HeLa细胞有一定量HSP70蛋白表达),但却有一种分子量为70kDa的蛋白高表达,表明吐温80显著抑制HSP70表达,以至HeLa细胞死亡,同时促使某一种蛋白大量堆积。大肠杆菌内毒素、前列腺素E1对HeLa细胞无明显抑制杀伤作用,且与吐温80无明显协同效应,同时亦对HeLa细胞HSP70表达无显著影响。推测:吐温80对HeLa细胞HSP70表达的显著抑制作用可能是其杀伤HeLa细胞的 作用机制之一,为理想的温热治疗肿瘤的协同合并作用药物,但其使细胞内大量某70kDa蛋白堆积现象有待进一步探讨。     

Predicting the stabilities of freeze-dried suspensions of Lactobacillus acidophilus by the accelerated storage test

The elevated temperatures of 50 ° C, 60 ° C, and 70 ° C were used in an accelerated storage test for predicting the stability of freeze-dried suspensions of L. acidophilus. The logarithmic death of bacteria at the above temperatures and the Arrhenius relationship obtained permitted predicting the rate of death at any storage temperature. The values predicted for storage stability of freeze-dried suspensions of L. acidophilus at 4 ° C and 20 ° C were confirmed by the actual values obtained after storage at these temperatures for 6, 15, and 19 mo.     

Long-term storage and safe retrieval of DNA from microorganisms for molecular analysis using FTA matrix cards

We assessed the potential use of Whatman FTA paper as a device for archiving and long-term storage of bacterial cell suspensions of over 400 bacterial strains representing 61 genera, the molecular applications of immobilised DNA on FTA paper, and tested its microbial inactivation properties. The FTA paper extracted bacterial DNA is of sufficiently high quality to successfully carryout the molecular detection of several key genes including 16S rRNA, esp (Enterococcus surface protein), Bft (Bacteroides fragilis enterotoxin) and por (porin protein) by PCR and for DNA fingerprinting by random amplified polymorphic DNA-PCR (RAPD-PCR). To test the long-term stability of the FTA immobilised DNA, 100 of the 400 archived bacterial samples were randomly selected following 3 years of storage at ambient temperature and PCR amplification was used to monitor its success. All of the 100 samples were successfully amplified using the 16S rDNA gene as a target and confirmed by DNA sequencing. Furthermore, the DNA was eluted into solution from the FTA cards using a new alkaline elution procedure for evaluation by real-time PCR-based assays. The viability of cells retained on the FTA cards varied among broad groups of bacteria. For the more fragile gram-negative species, no viable cells were retained even at high cell densities of between 10(7) and 10(8) colony forming units (cfu) ml(-1), and for the most robust species such as spore-formers and acid-fast bacteria, complete inactivation was achieved at cell densities ranging between 10(1) and 10(4) cfu ml(-1). The inactivation of bacterial cells on FTA cards suggest that this is a safe medium for the storage and transport of bacterial nucleic acids.     

Fluorene biodegradation and identification of transformation products by white-rot fungus Armillaria sp. F022

A diverse surfactant, including the nonionic Tween 80 and Brij 30, the anionic sodium dodecyl sulphate, the cationic surfactant Tetradecyltrimethylammonium bromide, and biosurfactant Rhamnolipid were investigated under fluorine-enriched medium by Armilaria sp. F022. The cultures were performed at 25 °C in malt extract medium containing 1 % of surfactant and 5 mg/L of fluorene. The results showed among the tested surfactants, Tween-80 harvested the highest cell density and obtained the maximum specific growth rate. This due Tween-80 provide a suitable carbon source for fungi. Fluorane was also successfully eliminated (>95 %) from the cultures within 30 days in all flasks. During the experiment, laccase production was the highest among other enzymes and Armillaria sp. F022-enriched culture containing Non-ionic Tween 80 showed a significant result for laccase activity (1,945 U/L). The increased enzyme activity was resulted by the increased biodegradation activity as results of the addition of suitable surfactants. The biotransformation of fluorene was accelerated by Tween 80 at the concentration level of 10 mg/L. Fluorene was initially oxidized at C-2,3 positions resulting 9-fluorenone. Through oxidative decarboxylation, 9-fluorenone subjected to meta-cleavage to form salicylic acid. One metabolite detected in the end of experiment, was identified as catechol. Armillaria sp. F022 evidently posses efficient, high effective degrader and potential for further application on the enhanced bioremediation technologies for treating fluorene-contaminated soil.     

Growth of Peptococcus and Peptostreptococcus: effect of variations of culture media on efficiency of recovery.

Reference strains and clinical isolates of Peptococcus and Peptostreptococcus spp. were evaluated for their growth response in supplemented thioglycolate-yeast extract media. Supplements used included various combinations of hemin, menadione, sodium bicarbonate, and Tween 80. Parallel studies were done to compare the efficiency of recovery of viable cells grown in thioglycolate-based media and Wilkins-Chalgren broth and agar. In addition, the effects of age of the medium and medium storage on viable cell yields for reference strains were determined. Reference strains grown in freshly prepared thioglycolate-yeast extract medium supplemented with sodium bicarbonate produced a 10-fold greater increase in the number of viable cells recovered after 24 h of incubation than did the same organisms cultivated in Wilkins-Chalgren medium. The efficiency of recovery of organisms when either mid-logarithmic- or mid-stationary-phase cells were used to prepare standardized inocula was similar. The results suggest that thioglycolate-yeast extract medium supplemented with sodium bicarbonate is more productive than Wilkins-Chalgren medium for the cultivation of anaerobic gram-positive cocci and may represent a suitable alternative for antimicrobial susceptibility testing of these organisms.