Comparative analysis of astaxanthin and its esters in the mutant E1 of Haematococcus pluvialis and other green algae by HPLC with a C30 column

A gradient reversed-phase high-performance liquid chromatography (HPLC) method using a C30 column was developed for the simultaneous determination of astaxanthin, astaxanthin monoesters and astaxanthin diesters in the green algae Chlorococcum sp., Chlorella zofingiensis, Haematococcus pluvialis and the mutant E1, which was obtained from the mutagenesis of H. pluvialis by exposure to UV-irradiation and ethyl methanesulphonate (EMS) with subsequent screening using nicotine. The results showed that the contents of total astaxanthins including free astaxanthin and astaxanthin esters ranged from 1.4 to 30.9 mg/g dry biomass in these green algae. The lower total astaxanthin levels (< 2 mg/g dry biomass) were detected in the green algae Chlorococcum sp. and C. zofingiensis. The higher total astaxanthin levels (>16 mg/g dry biomass) were found in the green alga H. pluvialis and its mutant E1. It is notable that the mutant E1 is found to have considerably higher amounts of total astaxanthin (30.9 mg/g) as compared to the wild strain of H. pluvialis (16.1 mg/g). This indicates that UV-irradiation and EMS compound mutagenesis with subsequent screening using nicotine is an effective method for breeding of a high-producing astaxanthin strain of H. pluvialis. In addition, the green alga C. zofingiensis had a remarkably higher percentage of astaxanthin diesters (76.3% of total astaxanthins) and a remarkably lower percentage of astaxanthin monoesters (18.0% of total astaxanthins) in comparison with H. pluvialis (35.5% for diesters and 60.9% for monoesters), the mutant E1 (49.1% and 48.1%) and Chlorococcum sp. (18.0% and 58.6%). Supported by the Frontier Research Grant of the SCSIO, the Hundred Talents program of Chinese Academy of Sciences, and National Natural Sciences of China projects (Grant No. 40776087)     

Singlet oxygen quenching ability of astaxanthin esters from the green alga Haematococcus pluvialis

The singlet oxygen quenching activities of carotenoids, -carotene, free astaxanthin, its monoester and its diester, were examined in vitro by a simple and rapid method for the measurement of Methylene Blue-sensitized photooxidation of linoleic acid in the hexane/ethanol solvent system. The concentrations of carotenoids, -carotene, free astaxanthin, its mono- and di-ester, required for 50% inhibition of lipid oxidation were 40, 8, 9, and 0 M in 100% ethanol and, 14, 16, 10, and 7 M in 50% (v/v) hexane in ethanol, respectively. Astaxanthin esters function as powerful antioxidant agents under both hydrophobic and hydrophilic conditions.     

Production of astaxanthin by Haematococcus pluvialis: taking the one-step system outdoors

The feasibility of a one-step method for the continuous production of astaxanthin by the microalga Haematococcus pluvialis has been verified outdoors. To this end, influence of dilution rate, nitrate concentration in the feed medium, and irradiance on the performance of continuous cultures of H. pluvialis was firstly analyzed indoors in bubble column reactors under daylight cycles, and then outdoors, using a tubular photobioreactor. At the laboratory scale, the behavior of the cultures agreed with that previously recorded in continuous illumination experiences, and attested that the major factors determining biomass and astaxanthin productivity were average irradiance and specific nitrate supply. The rate of astaxanthin accumulation was proportional to the average irradiance inside the culture, provided that a nitrate limiting situation had been established. The accumulation of astaxanthin under daylight cycles was maximal for a specific nitrate input of 0.5 mmol/g day. The recorded performance has been modeled on the basis of previously developed equations, and the validity of the model checked under outdoor conditions. Productivity values for biomass and astaxanthin of 0.7 g/L day and 8.0 mg/L day respectively, were obtained in a pilot scale tubular photobioreactor operating under continuous conditions outdoors. The magnitude of the experimental values, which matched those simulated from the obtained model, demonstrate that astaxanthin can be efficiently produced outdoors in continuous mode through a precise dosage of the specific nitrate input, taking also into consideration the average irradiance inside the culture.     

Dynamics and stability analysis of the growth and astaxanthin production system of Haematococcus pluvialis

This paper investigated high cell density cultivation of Haematococcus pluvialis for astaxanthin production in 3.7-L bioreactors. A biomass concentration of 2.74 g L⁻¹and an astaxanthin yield of 64.4 mg L⁻¹ were obtained. Based on the experimental results, a new and simple dynamic model is proposed, differing from Monod kinetics, to describe cell growth, product formation and substrate consumption. Good agreement was found between the model predictions and experimental data. The model revealed that there was cell growth inhibition on product formation and product feedback compensation for substrate consumption, but no substrate inhibition or product inhibition of cell growth. Stability analysis demonstrated that no multiplicity of steady states was observed; the unique positive steady state was locally asymptotically stable; and the effect of dilution rate on steady states was greater than that of the initial substrate concentration. Received 23 February 1999/ Accepted in revised form 08 June 1999     

光诱导雨生红球藻虾青素积累的信号通路转录组分析

雨生红球藻Haematococcus pluvialis在逆境胁迫条件下可大量积累虾青素,被认为自然界最理想的虾青素生产者.高光能有效诱导其虾青素的合成与积累,但藻细胞感知和转导光信号进而调控虾青素积累的机制尚不清楚.文中采用Illumina Hiseq 2000高通量测序技术分别获得正常、高白光及高蓝光处理组4.0 ...     

On the relative efficiency of two- vs. one-stage production of astaxanthin by the green alga Haematococcus pluvialis

Haematococcus pluvialis under stress conditions overproduces the valuable red ketocarotenoid astaxanthin. Two proposed strategies for commercial production are under current analysis. One separates in time the production of biomass (optimal growth, green stage) and pigment (permanent stress, red stage), while the other uses an approach based on continuous culture under limiting stress at steady state. The productivities, efficiencies and yields for the pigment accumulation in each case have been compared and analyzed in terms of the algal basic physiology. The two-stage system indoors yields a richer astaxanthin product (4% of dry biomass) with a final astaxanthin productivity of 11.5 mg L(-1) day(-1), is more readily upscalable and amenable to outdoors production. Furthermore, each stage can be optimized for green biomass growth and red pigment accumulation by adjusting independently the respective ratio of effective irradiance to cell density. We conclude that the two-stage system performs better (by a factor of 2.5-5) than the one-stage system, and the former is best fit in an efficient mass production setup.     

The synthesis of astaxanthin esters,independent of the formation of cysts,highly correlates with the synthesis of fatty acids in Haematococcus pluvialis

The compositions and contents of astaxanthin esters and fatty acids in four types of Haematococcus pluvialis cells were studied by HPLC and GC-MS. Results showed that the synthesis and accumulation of astaxanthin was independent of the formation of cysts, but was highly correlated with the synthesis and accumulation of fatty acids, though it is an well known phenomenon that the accumulation of astaxanthin is usually accompanied by the formation of cyst. The red cysts contain more than 30% of fatty acids, with 81% of the unsaturated fatty acids. Taken together, besides a resource of astaxanthin, H. pluvialis would be a good resource of valuable fatty acids.     

Kinetic models for astaxanthin production by high cell density mixotrophic culture of the microalga Haematococcus pluvialis

High cell density cultivation of Haematococcus pluvialis for astaxanthin production was carried out in batch and fed-batch modes in 3.7-L bioreactors with stepwise increased light intensity control mode. A high cell density of 2.65 g L⁻¹ (batch culture) or 2.74 g L⁻¹ (fed-batch culture) was obtained, and total astaxanthin production in the fed-batch culture (64.36 mg L⁻¹) was about 20.5% higher than in the batch culture (53.43 mg L⁻¹). An unstructured kinetic model to describe the microalga culture system including cell growth, astaxanthin formation, as well as sodium acetate consumption was proposed. Good agreement was found between the model predictions and experimental data. The models demonstrated that the optimal light intensity for mixotrophic growth of H. pluvialis in batch or fed-batch cultures in a 3.7-L bioreactor was 90–360 μmol m⁻² s⁻¹, and that the stepwise increased light intensity mode could be replaced by a constant light intensity mode. Received 24 December 1998/ Accepted in revised form 23 April 1999     

Comparison of the accumulation of astaxanthin in Haematococcus pluvialis and other green microalgae under N-starvation and high light conditions

Haematococcus pluvialis gave the highest astaxanthin accumulation rate (2.7 mg l^–1 day^–1) and total astaxanthin content ( 22.7 mg g^–1 biomass). Astaxanthin accumulation in Neochloris wimmeri, Protosiphon botryoides, Scotiellopsis oocystiformis, Chorella zofingiensis and Scenedesmus vacuolatus was, respectively, 19.2, 14.3, 10.9, 6.8 and 2.7 mg astaxanthin g^–1 biomass, respectively.     

Production of astaxanthin by Haematococcus pluvialis in a sequential heterotrophic-photoautotrophic culture

Production of astaxanthin by sequential heterotrophic-photoautotrophiccultivation of a green alga, Haematococcus pluvialis was investigated.This involved cultivating the cells heterotrophically to high cellconcentration, followed by illumination of the culture for astaxanthinaccumulation. The optimum pH and temperature for heterotrophic biomassproduction were 8 and 25 ^°C, respectively. There was no significantdifference in the specific growth rate of the cells when acetateconcentration was varied between 10 mM and 30 mM. However, cellgrowth was inhibited at higher acetate concentrations. A pH stat methodwas then used for fed-batch heterotrophic culture, using acetate as theorganic carbon source. A cell concentration of 7 g L^-1 wasobtained. Higher cell concentration could not be obtained because the cellschanged from vegetative to cyst forms during the heterotrophic cultivation.However, by using repeated fed-batch processes, the cells could bemaintained in the vegetative form, leading to more than two times increasein cell number output rate. When the vegetative cells were transferred tophotoautotrophic phase, there was a sharp decrease in the cell number andonly very few cells encysted and accumulated astaxanthin. On the otherhand, when the shift from heterotrophic to photoautotrophic condition wasdone when most of the cells had encysted, there was still a decrease in cellnumber but astaxanthin accumulation was very high. The astaxanthinconcentration (114 mg L^-1) and productivity (4.4 mg L^-1d^-1) obtained by this sequential heterotrophic-photoautotrophiccultivation method are very high compared to the data in the literature.     

Photon irradiance required to support optimal growth and interrelations between irradiance and pigment composition in the green alga Haematococcus pluvialis

The aim of the work was to find the optimal photon irradiance for the growth of green cells of Haematococcus pluvialis and to study the interrelations between changes in photochemical parameters and pigment composition in cells exposed to photon irradiances between 50 and 600?µmol?m^?2?s^?1 and a light:dark cycle of 12:12?h. Productivity of cultures increased with irradiance. However, the rate of increase was higher in the range 50–200?µmol?^?2?s^?1. The carotenoid content increased with increasing irradiance, while the chlorophyll content decreased. The maximum quantum yield of PSII (F_v/F_m) gradually declined from 0.76 at the lowest irradiance of 50?µmol?^?2?s^?1 to 0.66 at 600?µmol?^?2?s^?1. Photosynthetic activity showed a drop at the end of the light period, but recovered fully during the following dark phase. A steep increase in non-photochemical quenching was observed when cultures were grown at irradiances above 200?µmol?^?2?s^?1. A sharp increase in the content of secondary carotenoids also occurred above 200?µmol?m^?2?s^?1. According to our results, with H. pluvialis green cells grown in a 5-cm light path device, 200?µmol?^?2?s^?1 was optimal for growth, and represented a threshold above which important changes in both photochemical parameters and pigment composition occurred.     

Isolation and functional identification of a novel cDNA for astaxanthin biosynthesis from Haematococcus pluvialis,and astaxanthin synthesis in Escherichia coli

We succeeded in isolating a novel cDNA involved in astaxanthin biosynthesis from the green alga Haematococcus pluvialis, by an expression cloning method using an Escherichia coli transformant as a host that synthesizes -carotene due to the Erwinia uredovora carotenoid biosynthesis genes. The cloned cDNA was shown to encode a novel enzyme, -carotene ketolase (-carotene oxygenase), which converted -carotene to canthaxanthin via echinenone, through chromatographic and spectroscopic analysis of the pigments accumulated in an E. coli transformant. This indicates that the encoded enzyme is responsible for the direct conversion of methylene to keto groups, a mechanism that usually requires two different enzymatic reactions proceeding via a hydroxy intermediate. Northern blot analysis showed that the mRNA was synthesized only in the cyst cells of H. pluvialis. E. coli carrying the H. pluvialis cDNA and the E. uredovora genes required for zeaxanthin biosynthesis was also found to synthesize astaxanthin (3S, 3S), which was identified after purification by a variety of spectroscopic methods.     

Characterization of astaxanthin esters in Haematococcus pluvialis by liquid chromatography-atmospheric pressure chemical ionization mass spectrometry

After first being analyzed by HPLC, 4 free carotenoids, 15 astaxanthin monoesters, 12 astaxanthin diesters, and 3 astacin monoesters in Haematococcus pluvialis were identified by liquid chromatography-atmospheric pressure chemical ionization mass spectrometry (LC-(APCI)MS). Identification of each compound was based on the characteristic fragment ions of the positive ion mode, negative ion mode, and MS(2). Astaxanthin esters were identified based on the loss of one or two fatty acids. In a positive ion mode, astaxanthin monoesters had characteristic fragment ions at m/z 597 [M+H-fatty acid](+) and m/z 579 and 561 that resulted from a continuous loss of water. The relative intensity of m/z 579 in MS(2) amounted to more than 80% of that of the molecular ion. In astaxanthin diesters, the intensity of m/z 561 occasionally was equal to that of m/z 579, but in general the former, amounting to 50 to 60% or more of the molecular ion, was stronger than the latter, which decreased to 20 to 30% of the molecular ion. In addition, a set of compounds with maximum absorbance at 400 nm, detected by high-performance liquid chromatography-diode array detector (HPLC-DAD), had strong characteristic fragment ions at m/z 871 and 593 in the positive ion mode MS(2). They were presumed to be linolenic acid or an isomer of omega-6-gamma-linolenic acid esters of astacin.     

Protective role of astaxanthin against u.v.-B irradiation in the green alga Haematococcus pluvialis

Cyst cells of the green alga Haematococcus pluvialis accumulate astaxanthin with maturation of the resting stage. To study the protective role of astaxanthin against u.v. damage, both immature (astaxanthin-poor) and mature (astaxanthin-rich) cyst cells were exposed to u.v.-A or u.v.-B irradiation, and the residual cell viability and astaxanthin levels were determined. u.v.-B decreased both cell viability and astaxanthin level of cyst cells to a greater extent than u.v.-A. Tolerance of mature cyst cells to u.v.-B was 6-fold higher than that of immature cyst cells. These results indicated that astaxanthin in cyst cells functions as a protective agent against u.v.-B irradiation.     

Efficient one-step production of astaxanthin by the microalga Haematococcus pluvialis in continuous culture

The performance of Haematococcus pluvialis in continuous photoautotrophic culture has been analyzed, especially from the viewpoint of astaxanthin production. To this end, chemostat cultures of Haematococcus pluvialis were carried out at constant light irradiance, 1,220 microE/m2.s, and dilution rate, 0.9/d, but varying the nitrate concentration in the feed medium reaching the reactor, from 1.7 to 20.7 mM. Both growth and biomass composition were affected by the nitrate supply. With saturating nitrate, the biomass productivity was high, 1.2 g/L.d, but astaxanthin accumulation did not take place, the C/N ratio of the biomass being 5.7. Under moderate nitrate limitation, biomass productivity was decreased, as also did biomass concentration at steady state, whereas accumulation of astaxanthin developed and the C/N ratio of the biomass increased markedly. Astaxanthin accumulation took place in cells growing and dividing actively, and its extent was enhanced in response to the limitation in nitrate availability, with a recorded maximum for astaxanthin cellular level of 0.8% of dry biomass and of 5.6 mg/L.d for astaxanthin productivity. The viability of a significant continued generation of astaxanthin-rich H. pluvialis cells becomes thus demonstrated, as also does the continuous culture option as an alternative to current procedures for the production of astaxanthin using this microalga. The intensive variable controlling the behavior of the system has been identified as the specific nitrate input, and a mathematical model developed that links growth rate with both irradiance and specific nitrate input. Moreover, a second model for astaxanthin accumulation, also as a function of irradiance and specific nitrate input, was derived. The latter model takes into account that accumulation of astaxanthin is only partially linked to growth, being besides inhibited by excess nitrate. Simulations performed fit experimental data and emphasize the contention that astaxanthin can be efficiently produced under continuous mode by adjustment of the specific nitrate input, predicting even higher values for astaxanthin productivity. The developed models represent a powerful tool for management of such an astaxanthin-generating continuous process, and could allow the development of improved systems for the production of astaxanthin-rich Haematococcus cells.     

The synthesis of astaxanthin esters, independent of the formation of cysts, highly correlates with the synthesis of fatty acids in Haematococcus pluvialis

The compositions and contents of astaxanthin esters and fatty acids in four types of Haematococcus pluvialis cells were studied by HPLC and GC-MS. Results showed that the synthesis and accumulation of astaxanthin was independent of the formation of cysts, but was highly correlated with the synthesis and accumulation of fatty acids, though it is an well known phenomenon that the accumulation of astaxanthin is usually accompanied by the formation of cyst. The red cysts contain more than 30% of fatty acids, with 81% of the unsaturated fatty acids. Taken together, besides a resource of astaxanthin, H. pluvialis would be a good resource of valuable fatty acids. Supported by the National Natural Science Foundation of China (Grant No. CNSF30570183), Chinese Academy of Science (KSCX2-YW-G-027) and Yunnan Provincial Sciences and Technology Department, China (2007AD009)     

Presence of a Nonhydrolyzable Biopolymer in the Cell Wall of Vegetative Cells and Astaxanthin-Rich Cysts of Haematococcus pluvialis (Chlorophyceae)

The green alga Haematococcus pluvialis accumulates massive amounts of the red pigment astaxanthin in response to stimuli inducing it to form cysts. During the encystment process the cell wall undergoes a clear hardening and thickening. In this work, a cell wall fraction withstanding successive acid and basic hydrolysis was isolated and proves to be algaenan by Fourier transform infrared spectroscopy. This compound is equally abundant in nonmotile vegetative cells and astaxanthin-rich cysts. This finding indicates that the synthesis of algaenan does not require the activation of the machinery for the massive production of secondary carotenoids. We conclude that algaenan cannot cause the changes occurring in the cell wall during the encystment process without the involvement of other cell wall components. Received November 7, 2000; accepted April 3, 2001.     

Molecular cloning and evolutionary analysis of the calcium-modulated contractile protein,centrin, in green algae and land plants

Centrin (= caltractin) is a ubiquitous, cytoskeletal protein which is a member of the EF-hand superfamily of calcium-binding proteins. A centrin-coding cDNA was isolated and characterized from the prasinophyte green alga Scherffelia dubia. Centrin PCR amplification primers were used to isolate partial, homologous cDNA sequences from the green algae Tetraselmis striata and Spermatozopsis similis. Annealing analyses suggested that centrin is a single-copy-coding region in T. striata and S. similis and other green algae studied. Centrin-coding regions from S. dubia, S. similis and T. striata encode four colinear EF-hand domains which putatively bind calcium. Phylogenetic analyses, including homologous sequences from Chlamydomonas reinhardtii and the land plant Atriplex nummularia, demonstrate that the domains of centrins are congruent and arose from the two-fold duplication of an ancestral EF hand with Domains 1+3 and Domains 2+4 clustering. The domains of centrins are also congruent with those of calmodulins demonstrating that, like calmodulin, centrin is an ancient protein which arose within the ancestor of all eukaryotes via gene duplication. Phylogenetic relationships inferred from centrin-coding region comparisons mirror results of small subunit ribosomal RNA sequence analyses suggesting that centrin-coding regions are useful evolutionary markers within the green algae.