Role of Thiobacillus ferrooxidans and sulphur (sulphide)-dependent ferric-ion-reducing activity in the oxidation of sulphide minerals

 Thiobacillus ferrooxidans oxidized the sulphide minerals e.g., pyrite, pyrrhotite and copper concentrate under anaerobic conditions in the presence of ferric ion as sole electron acceptor. Copper and iron were solubilized from sulphide ores by the sulphur (sulphide)-dependent ferric-ion oxidoreductase activity. Treatment of resting cells of T. ferrooxidans with 0.5% phenol for 30 min completely destroyed the iron- and copper-solubilizing activity. The above treatment destroyed the sulphur(sulphide)-dependent ferric-ion-reducing activity completely but did not affect the iron-oxidizing activity. The results suggest that sulphur(sulphide)-dependent ferric-ion-reducing activity actively participates in the oxidation of sulphide minerals under anaerobic conditions. The activity of sulphur(sulphide)-dependent ferric ion reduction in the solubilization of iron and copper from the sulphide ores were also observed under aerobic conditions in presence of sodium azide (0.1 μmol), which completely inhibits the iron-oxidizing activity. Received: 23 May 1995/Received revision: 10 October 1995/Accepted: 16 October 1995     

Effect of pH on cell viability and product yields in d-xylose fermentations by Candida shehatae

 Candida shehatae were sequentially subjected to aerobic conditions for cellular growth, followed by anaerobic conditions for ethanol production from D-xylose at pH 2.5, 4.5 and 6.0. Ethanol yields increased from 0.25 g/g to 0.37 g/g and xylitol yields decreased from 0.33 g/g to 0.1 g/g as the pH was increased from 2.5 to 6.0. Cell viability, measured by plate counts and methylene blue staining, decreased in all of the fermentations, following the switch from aerobic to anaerobic conditions. However, pH 6.0 was shown to extend cell viability and increase the final ethanol concentration from 45 g/l to 55 g/l, compared to the yield at pH 4.5. Received: 25 April 1995/Received revision: 5 September 1995/Accepted: 20 September 1995     

Detection of anaerobic processes and microorganisms in immobilized activated sludge of a wastewater treatment plant with intense aeration

Attached activated sludge from the Krasnaya Polyana (Sochi) wastewater treatment plant was studied after the reconstruction by increased aeration and water recycle, as well as by the installation of a bristle carrier for activated sludge immobilization. The activated sludge biofilms developing under conditions of intense aeration were shown to contain both aerobic and anaerobic microorganisms. Activity of a strictly anaerobic methanogenic community was revealed, which degraded organic compounds to methane, further oxidized by aerobic methanotrophs. Volatile fatty acids, the intermediates of anaerobic degradation of complex organic compounds, were used by both aerobic and anaerobic microorganisms. Anaerobic oxidation of ammonium with nitrite (anammox) and the presence of obligate anammox bacteria were revealed in attached activated sludge biofilms. Simultaneous aerobic and anaerobic degradation of organic contaminants by attached activated sludge provides for high rates of water treatment, stability of the activated sludge under variable environmental conditions, and decreased excess sludge formation.     

Enhanced biodegradation of cyclotetramethylenetetranitramine (HMX) under mixed electron-acceptor condition

The biodegradation of cyclotetramethylenetetranitramine, commonly known as 'high melting explosive' (HMX), under various electron-acceptor conditions was investigated using enrichment cultures developed from the anaerobic digester sludge of Thibodaux sewage treatment plant. The results indicated that the HMX was biodegraded under sulfate reducing, nitrate reducing, fermenting, methanogenic, and mixed electron accepting conditions. However, the rates of degradation varied among the various conditions studied. The fastest removal of HMX (from 22 ppm on day 0 to < 0.05 ppm on day 11) was observed under mixed electron-acceptor conditions, followed in order by sulfate reducing, fermenting, methanogenic, and nitrate reducing conditions. Under aerobic conditions, HMX was not biodegraded, which indicated that HMX degradation takes place under anaerobic conditions via reduction. HMX was converted to methanol and chloroform under mixed electron-acceptor conditions. This study showed evidence for HMX degradation under anaerobic conditions in a mixed microbial population system similar to any contaminated field sites, where a heterogeneous population exists.     

Microbial degradation of hydrocarbons in soil during aerobic/anaerobic changes and under purely aerobic conditions

Microbial hydrocarbon degradation in soil was studied during periodical aerobic/anaerobic switching and under purely aerobic conditions by using a pilot-scale plant with diesel-fuel-contaminated sand. The system worked according to the percolation principle with controlled circulation of process water and aeration. Periodical switching between 4 h of aerobic and 2 h of anaerobic conditions was achieved by repeated saturation of the soil with water. Whatever the cultivation mode, less than 50% of the diesel was degraded after 650 h because the hydrocarbons were adsorbed. Contrary to expectations, aerobic/anaerobic changes neither accelerated the rate of degradation nor reduced the residual hydrocarbon content of the soil. Obviously the pollutant degradation rate was determined mainly by transport phenomena and less by the efficiency of microbial metabolism. The total mass of oxygen consumed and carbon dioxide produced was greater under aerobic/anaerobic changing than under aerobic conditions, although the mass of hydrocarbons degraded was nearly the same. As shown by an overall balance of microbial growth and by a carbon balance, the growth yield coefficient was smaller during aerobic/anaerobic changes than under aerobic conditions. Received: 25 November 1997 /  Received revision: 15 January 1998 / Accepted: 18 January 1998     

Biodegradation of azo dyes in cocultures of anaerobic granular sludge with aerobic aromatic amine degrading enrichment cultures

A prerequisite for the mineralization (complete biodegradation) of many azo dyes is a combination of reductive and oxidative steps. In this study, the biodegradation of two azo dyes, 4-phenylazophenol (4-PAP) and Mordant Yellow 10 (4-sulfophenylazo-salicylic acid; MY10), was evaluated in batch experiments where anaerobic and aerobic conditions were integrated by exposing anaerobic granular sludge to oxygen. Under these conditions, the azo dyes were reduced, resulting in a temporal accumulation of aromatic amines. 4-Aminophenol (4-AP) and aniline were detected from the reduction of 4-PAP. 5-Aminosalicylic acid (5-ASA) and sulfanilic acid (SA) were detected from the reduction of MY10. Subsequently, aniline was degraded further in the presence of oxygen by the facultative aerobic bacteria present in the anaerobic granular sludge. 5-ASA and SA were also degraded, if inocula from aerobic enrichment cultures were added to the batch experiments. Due to rapid autoxidation of 4-AP, no enrichment culture could be established for this compound. The results of this study indicate that aerobic enrichment cultures developed on aromatic amines combined with oxygen-tolerant anaerobic granular sludge can potentially be used to completely biodegrade azo dyes under integrated anaerobic/aerobic conditions. Received: 16 September 1998 / Received revision: 14 December 1998 / Accepted: 21 December 1998     

High efficiency of a coupled aerobic-anaerobic recycling biofilm reactor system in the degradation of recalcitrant chloroaromatic xenobiotic compounds

Chloroaromatic compounds are xenobiotics that cause great concern. The degradation of a model molecule, 3,4-dichlorobenzoate (3,4-DCB), was studied using three aerobic (AE)-anaerobic (AN) biofilm reactor systems: a coupled aerobic-anaerobic recycle biofilm reactor (CAR) system, an in-series anaerobic-aerobic biofilm reactor (SAR) system; and an independent aerobic and anaerobic biofilm reactor (IAR) system. In all three systems the inlet substrate concentration was 2.0 g/l and the dilution rates ranged from 0.045 to 0.142 per hour. The results show that the degradation efficiency of the CAR system (expressed as dechlorination and xenobiotic disappearance efficiencies, and biomass yield), was higher at all dilution rates tested than in both SAR and IAR systems. Moreover, dechlorination and xenobiotic disappearance efficiencies for resting suspended aerobic and anaerobic cells or mixed aerobic-anaerobic growing cells under anaerobic conditions were higher than under aerobic conditions. These results suggest that a “cooperative metabolism” between aerobic and anaerobic bacteria (caused by an exchange of cells and metabolites between AE and AN reactors) in the CAR system overcame the metabolic and kinetic limitations of aerobic and anaerobic bacteria in the AE and AN reactors of IAR and SAR systems. Therefore, the degradation efficiency of persistent and recalcitrant chloroaromatic xenobiotic compounds could be enhanced by using a CAR system. Received: 1 March 1999 / Received revision: 11 May 1999 / Accepted: 16 May 1999     

Effect of enclosing rocks and aeration on methanogenesis from coals

Two coals of different rank, mined in Russia, were treated by an anaerobic methanogenic enrichment culture. The addition of alkaline enclosing rock to the lower-rank coal increased the pH of the incubation medium and methane production above that of the higher-rank coal with addition of its enclosing rock. This effect was accompanied by the leaching of cations from the incubation medium. The coal was processed without a preliminary chemical treatment in a two-stage aerobic/anaerobic bioreactor containing an anaerobic methanogenic granulated enrichment culture. Received: 15 January 1998 / Received revision: 2 October 1998 / Accepted: 2 October 1998     

Detoxification and partial mineralization of the azo dye mordant orange 1 in a continuous upflow anaerobic sludge-blanket reactor

In batch toxicity assays, azo dye compounds were found to be many times more toxic than their cleavage products (aromatic amines) towards methanogenic activity in anaerobic granular sludge. Considering the ability of anaerobic microorganisms to reduce azo groups, detoxification of azo compounds towards methanogens can be expected to occur during anaerobic wastewater treatment. In order to test this hypothesis, the anaerobic degradation of one azo dye compound, Mordant orange 1 (MO1), by granular sludge was investigated in three separate continuous upflow anaerobic sludge-blanket reactors. One reactor, receiving no cosubstrate, failed after 50 days presumably because of a lack of reducing equivalents. However, the two reactors receiving either glucose or a volatile fatty acids (acetate, propionate, butyrate) mixture, could eliminate the dye during operation for 217 days. The azo dye was reductively cleaved to less toxic aromatic amines (1,4-phenylenediamine and 5-aminosalicylic acid) making the treatment of MO1 feasible at influent concentrations that were over 25 times higher than their 50% inhibitory concentrations. In the reactor receiving glucose as cosubstrate, 5-aminosalicylic acid could only be detected at trace levels in the effluent after day 189 of operation. Batch biodegradability assays with the sludge sampled from this reactor confirmed the mineralization of 5-aminosalicylic acid to methane. Received: 11 July 1996 / Received revision: 18 September 1996 / Accepted: 18 September 1996     

Diversity of anaerobic microbial processes in chlorobenzoate degradation: Nitrate,iron, sulfate and carbonate as electron acceptors

 The utilization of monochlorobenzoate isomers (2-, 3- and 4-chlorobenzoate) by anaerobic microbial consortia in River Nile sediments was systematically evaluated under denitrifying, Fe-reducing, sulfidogenic and methanogenic conditions. Loss of all three chlorobenzoates was noted in denitrifying cultures; furthermore, the initial utilization of chlorobenzoates was fastest under denitrifying conditions. Loss of 3-chlorobenzoate was seen under all four reducing conditions and the degradation of chlorobenzoates was coupled stoichiometrically to NO^- ₃ loss, Fe²⁺ production, SO^2- ₄ loss or CH₄ production, indicating that the chlorobenzoates were oxidized to CO₂. To our knowledge, this is the first observation of halogenated aromatic degradation coupled to Fe reduction. Received: 29 July 1994/Received revision: 22 November 1994/Accepted 16 December 1994     

Effects of electron donor and microbial concentration on the enhanced dechlorination of carbon tetrachloride by anaerobic consortia

 Reductive dechlorination of carbon tetra-chloride (CCl₄) by anaerobic bacterial communities from anaerobic digester sludge with the amendment of low concentrations of electron donors and microorganisms was undertaken to evaluate the influence of electron donors and microbial concentration on the rate of dechlorination of CCl₄. Humic acid, acetate, and glucose were selected to examine the feasibility of the electron donor with respect to the remediation of a contaminated subsurface. The addition of an electron donor and microorganisms significantly enhanced the dechlorination rate of carbon tetrachloride. The addition of an electron donor increased the cell numbers of anaerobic consortia, thereby increasing the rate of dechlorination. Glucose was a better electron donor than acetate and humic acid under reducing environments. The pseudo-first-order degradation rate constants of CCl₄ ranged from 0.0057 day^-1 to 0.135 day^-1, depending on the conditions of the electron donor and biomass supplemented. Furthermore, the addition of the electron donor in the batches amended with 0.56 mg volatile suspended solids (VSS)/l biomass had a higher enhanced efficiency than those with 1.7 mg VSS/l biomass. These results suggest that there is a potential for stimulating the dechlorinating capability of anaerobic consortia to remedy the chlorinated hydrocarbons in the oligotrophic environment if the conditions of the supplementing electron donor are properly selected. Received: 14 August 1995/Received last revision: 15 March 1996/Accepted: 15 April 1996     

Total reductive dechlorination of chlorobenzenes to benzene by a methanogenic mixed culture enriched from Saale river sediment

 A methanogenic mixed culture enriched from Saale river sediment was able to transform all chlorobenzenes by reductive dechlorination via monochlorobenzene to unsubstituted benzene after a short lag phase of only 1 week. The formation of benzene was confirmed by GC/MS in pentane extracts of the sludge samples, as well as in the headspace gas of the batch cultures. The spectra of substrate utilization of the adapted cultures depended mainly on the substrates used for adaptation. Sediment microbes that had been adapted with a mixture of the three isomers of trichlorobenzene offered the widest spectrum for the utilization of chlorobenzenes in all chlorine stages. Reductive dechlorination was stimulated when the mixed cultures were supplemented with pyruvate and methanol. Received: 17 July 1995/Received revision: 11 December 1995/Accepted: 18 December 1995     

Effect of feed composition and upflow velocity on aggregate characteristics in anaerobic upflow reactors

Two upflow anaerobic hybrid reactors treated lactose and a mixture of ethanol, propionate and butyrate, respectively, at a volumetric loading rate of 3.7 kg chemical oxygen demand (COD) m⁻³day⁻¹, a hydraulic retention time of 5 days and a liquid upflow velocity of 0.01 m/h. Under steady-state conditions, the lactose-fed sludge had much higher (20%–100%) specific methanogenic conversion rates than the volatile-fatty acid␣(VFA)/ethanol-fed sludge for all substrates tested, including VFA. In both reactors, a flocculant sludge developed, although a much higher content of extracellular polysaccharide was measured in the lactose-fed sludge [1900 μg compared to 305 μg uronic acid/g volatile suspended solids (VSS)]. When the liquid upflow velocity of a third, VFA/ethanol-fed reactor was increased to 0.5 m/h, granulation of the sludge occurred, accompanied by a large increase (200%–500%) in the specific methanogenic conversion rates for the syntrophic and methanogenic substrates studied. Granulation reduced the susceptibility of the sludge to flotation. Glucose was degraded at a high rate (100 mg glucose gVSS⁻¹h⁻¹) by the sludge from the third reactor, despite not having been exposed to a sugar-containing influent for 563␣days. Received: 7 June 1996 / Received revision: 23 September 1996 / Accepted: 29 September 1996     

Fate and transformation of thiocyanate and cyanate under methanogenic conditions

The fate of thiocyanate (SCN⁻) and cyanate (OCN⁻) under methanogenic conditions was investigated at 35 °C. Thiocyanate and cyanate were added to mixed methanogenic cultures along with an organic mixture. Thiocyanate was stable under these conditions, and had no adverse effect on methanogenesis at a concentration as high as 2.5 mM. In contrast, cyanate at a concentration as low as 0.3 mM initially inhibited methanogenesis but, after the complete removal of cyanate, methanogenesis gradually recovered. The inhibitory effect of cyanate on methanogenesis became more profound with repeated additions of cyanate. The transformation of cyanate followed the hydrolytic route to ammonia and bicarbonate under anaerobic conditions and its hydrolysis rate was enhanced by microbial activity. Cyanide was not detected as a cyanate transformation product under the methanogenic conditions of this study. Received: 13 June 1997 / Received revision: 29 August 1997 / Accepted: 15 September 1997     

Anaerobic biodegradability of alkylphenols and fuel oxygenates in the presence of alternative electron acceptors

Alkylphenols and fuel oxygenates are important environmental pollutants produced by the petrochemical industry. A batch biodegradability test was conducted with selected ortho-substituted alkylphenols (2-cresol, 2,6-dimethylphenol and 2-ethylphenol), fuel oxygenates (methyl tert-butyl ether, ethyl tert-butyl ether and tert-amylmethyl ether) and tert-butyl alcohol (TBA) as model compounds. The ortho-substituted alkylphenols were not biodegraded after 100 days of incubation under methanogenic, sulfate-, or nitrate-reducing conditions. However, biodegradation of 2-cresol and 2-ethylphenol (150 mg l⁻¹) was observed in the presence of Mn (IV) as electron acceptor. The biodegradation of these two compounds took place in less than 15 days and more than 90% removal was observed for both compounds. Mineralization was indicated since no UV-absorbing metabolites accumulated after 23 days of incubation. These alkylphenols were also slowly chemically oxidized by Mn (IV). No biodegradation of fuel oxygenates or TBA (1 g l⁻¹) was observed after 80 or more days of incubation under methanogenic, Fe (III)-, or Mn (IV)-reducing conditions, suggesting that these compounds are recalcitrant under anaerobic conditions. The fuel oxygenates caused no toxicity towards acetoclastic methanogens activity in anaerobic granular sludge. Received: 8 February 2000 / Received revision: 15 May 2000 / Accepted: 19 May 2000     

The effect of low temperature (5–29 °C) and adaptation on the methanogenic activity of biomass

The influence of low temperature (5–29 °C) on the methanogenic activity of non-adapted digested sewage sludge and on temperature/leachate-adapted biomass was assayed by using municipal landfill leachate, intermediates of anaerobic degradation (propionate) and methane precursors (acetate, H₂/CO₂) as substrates. The temperature dependence of methanogenic activity could be described by Arrhenius-derived models. However, both substrate and adaptation affected the temperature dependence. The adaptation of biomass in a leachate-fed upflow anaerobic sludge-blanket reactor at approximately 20 °C for 4 months resulted in a sevenfold and fivefold increase of methanogenic activity at 11 °C and 22 °C respectively. Both acetate and H₂/CO₂ were methanized even at 5 °C. At 22 °C, methanogenic activities (acetate 4.8–84 mM) were 1.6–5.2 times higher than those at 11 °C. The half-velocity constant (K _s) of acetate utilization at 11 °C was one-third of that at 22 °C while a similar K _i was obtained at both temperatures. With propionate (1.1–5.5 mM) as substrate, meth‐anogenic activities at 11 °C were half those at 22 °C. Furthermore, the residual concentration of the substrates was not dependent on temperature. The results suggest that the adaptation of biomass enables the achievement of a high treatment capacity in the anaerobic process even under psychrophilic conditions. Received: 23 December 1996 / Received last revision: 18 June 1997 / Accepted: 23 June 1997     

Complete degradation of tetrachloroethene by combining anaerobic dechlorinating and aerobic methanotrophic enrichment cultures

 Degradation of tetrachloroethene (perchloroethylene, PCE) was investigated by combining the metabolic abilities of anaerobic bacteria, capable of reductive dechlorination of PCE, with those of aerobic methanotrophic bacteria, capable of co-metabolic degradation of the less-chlorinated ethenes formed by reductive dechlorination of PCE. Anaerobic communities reductively dechlorinating PCE, trichloroethene (TCE) and dichloroethenes were enriched from various sources. The maximum rates of dechlorination observed for various chloroethenes in these batch enrichments were: PCE to TCE (341 μmol l^-1 day^-1), TCE to cis-dichloroethene (159 μmol l^-1 day^-1), cis-dichloroethene to chloroethene (99 μmol l^-1 day^-1) and trans-dichloroethene to chloroethene (22 μmol l^-1 day^-1). A mixture of these enrichments was inoculated into an anoxic fixed-bed upflow column. In this column PCE was converted mainly into cis-1, 2-dichloroethene, small amounts of TCE and chloroethene, and chloride. Enrichments of aerobic methanotrophic bacteria were grown in an oxic fixed-bed downflow column. Less-chlorinated ethenes, formed in the anoxic column, were further metabolized in this oxic methanotrophic column. On the basis of analysis of chloride production and the disappearance of chlorinated ethenes it was demonstrated that complete degradation of PCE was possible by combining these two columns. Operation of the two-column system under various process conditions indicated that the sensitivity of the methanotrophic bacteria to chlorinated intermediates represented the bottle-neck in the sequential anoxic/oxic degradation process of PCE. Received: 24 October 1994 / Received revision: 20 January 1995 / Accepted: 23 January 1995     

Inhibition of Biogas Production by Alkyl Benzene Sulfonates (LAS) in a Screening Test for Anaerobic Biodegradability

The effect of the inoculum source on the digestion of linear alkylbenzene sulfonates (LAS) under anaerobic conditions has been investigated. The potential for primary and ultimate LAS biodegradation of anaerobic sludge samples obtained from wastewater treatment plants (WWTPs) of different geographical locations was studied applying a batch test system. It was found that only 4–22% of the LAS added to the batch anaerobic digesters was primarily transformed suggesting a poor primary degradation of the LAS molecule in anaerobic discontinuous systems. Regarding ultimate biodegradation, the addition of LAS to the batch anaerobic digesters caused a reduction on the extent of biogas production. Significant differences in the inhibition extent of the biogas production were observed (4–26%) depending on the sludge used as inoculum. Effect of the surfactant on the anaerobic microorganisms was correlated with its concentration in the aqueous phase. Sorption of LAS on anaerobic sludge affects its toxicity by depletion of the available fraction of the surfactant. LAS content on sludge was related to the total amount of calcium and magnesium extractable ions. The presence of divalent cations promote the association of LAS with anaerobic sludge reducing its bioavailability and the extent of its inhibitory effect on the biogas production.     

Gratuitous dechlorination of chloroethanes by methanogenic granular sludge

The dechlorinating activity of a methanogenic granular sludge from a methanol-fed upflow anaerobic sludge blanket reactor was investigated with chlorinated ethanes. This unadapted methanogenic consortium degraded all chloroethanes tested. The product formation rates decreased with the number of chlorine substituents. The more highly chlorinated ethanes were also converted, although at a lower rate, in the presence of autoclaved (dead) sludge, indicating the involvement of reduced heat-stable cofactors like vitamin B₁₂ and F₄₃₀. Direct chemical dechlorination of hexa-, penta- and tetrachloroethanes was also observed in medium without sludge, although at a much lower rate. The results show the importance of cometabolic and abiotic (chemical) conversions for the transformation of chlorinated ethanes by the methanogenic consortium. The types of reaction and the products formed were correlated with the Gibbs free-energy change (ΔG ^0′). Reductive hydrogenolysis and dichloroelimination were important dechlorinating mechanisms. Generally, these reactions have a higher ΔG ^0′ value than dehydrochlorination reactions, which occurred less frequently during the transformation of chloroethanes by the methanogenic granular sludge. Received: 8 June 1998 / Received revision: 7 September 1998 / Accepted: 13 September 1998     

Anaerobic degradation of fluorinated aromatic compounds

Anaerobic enrichment cultures with sediment from an intertidal strait as inoculum were established under denitrifying, sulfate-reducing, iron-reducing and methanogenic conditions to examine the biodegradation of mono-fluorophenol and mono-fluorobenzoate isomers. Both phenol and benzoate were utilized within 2–6 weeks under all electron-accepting conditions. However, no degradation of the fluorophenols was observed within 1 year under any of the anaerobic conditions tested. Under denitrifying conditions, 2-fluorobenzoate and 4-fluorobenzoate were depleted within 84 days and 28 days, respectively. No loss of 3-fluorobenzoate was observed. All three fluorobenzoate isomers were recalcitrant under sulfate-reducing, iron-reducing, and methanogenic conditions. The degradation of the fluorobenzoate isomers under denitrifying conditions was examined in more detail using soils and sediments from different geographic regions around the world. Stable enrichment cultures were obtained on 2-fluorobenzoate or 4-fluorobenzoate with inoculum from most sites. Fluoride was released stoichiometrically, and nitrate reduction corresponded to the values predicted for oxidation of fluorobenzoate to CO₂ coupled to denitrification. The 2-fluorobenzoate-utilizing and 4-fluorobenzoate-utilizing cultures were specific for fluorobenzoates and did not utilize other halogenated (chloro-, bromo-, iodo-) benzoic acids. Two denitrifying strains were isolated that utilized 2-fluorobenzoate and 4-fluorobenzoate as growth substrates. Preliminary characterization indicated that the strains were closely related to Pseudomonas stutzeri. Received: 1 September 1999 / Accepted in revised form: 30 September 1999