Repeated anaerobic microbial redox cycling of iron

Some nitrate- and Fe(III)-reducing microorganisms are capable of oxidizing Fe(II) with nitrate as the electron acceptor. This enzymatic pathway may facilitate the development of anaerobic microbial communities that take advantage of the energy available during Fe-N redox oscillations. We examined this phenomenon in synthetic Fe(III) oxide (nanocrystalline goethite) suspensions inoculated with microflora from freshwater river floodplain sediments. Nitrate and acetate were added at alternate intervals in order to induce repeated cycles of microbial Fe(III) reduction and nitrate-dependent Fe(II) oxidation. Addition of nitrate to reduced, acetate-depleted suspensions resulted in rapid Fe(II) oxidation and accumulation of ammonium. High-resolution transmission electron microscopic analysis of material from Fe redox cycling reactors showed amorphous coatings on the goethite nanocrystals that were not observed in reactors operated under strictly nitrate- or Fe(III)-reducing conditions. Microbial communities associated with N and Fe redox metabolism were assessed using a combination of most-probable-number enumerations and 16S rRNA gene analysis. The nitrate-reducing and Fe(III)-reducing cultures were dominated by denitrifying Betaproteobacteria (e.g., Dechloromonas) and Fe(III)-reducing Deltaproteobacteria (Geobacter), respectively; these same taxa were dominant in the Fe cycling cultures. The combined chemical and microbiological data suggest that both Geobacter and various Betaproteobacteria participated in nitrate-dependent Fe(II) oxidation in the cycling cultures. Microbially driven Fe-N redox cycling may have important consequences for both the fate of N and the abundance and reactivity of Fe(III) oxides in sediments.     

Leaching of Pyrites of Various Reactivities by Thiobacillus ferrooxidans

Wide variations were found in the rate of chemical and microbiological leaching of iron from pyritic materials from various sources. Thiobacillus ferrooxidans accelerated leaching of iron from all of the pyritic materials tested in shake flask suspensions at loadings of 0.4% (wt/vol) pulp density. The most chemically reactive pyrites exhibited the fastest bioleaching rates. However, at 2.0% pulp density, a delay in onset of bioleaching occurred with two of the pyrites derived from coal sources. T. ferrooxidans was unable to oxidize the most chemically reactive pyrite at 2.0% pulp density. No inhibition of pyrite oxidation by T. ferrooxidans occurred with mineral pyrite at 2.0% pulp density. Experiments with the most chemically reactive pyrite indicated that the leachates from the material were not inhibitory to iron oxidation by T. ferrooxidans.     

Biological leaching of sulfide minerals with the use of shake flask,aerated column,air-lift reactor,and percolation techniques

Four different experimental approaches were used to evaluate the microbiological leaching of ore material containing metal sulfides (Fe, Zn, Ni, Cu, Co) and aluminum silicates. A shake flask technique required the shortest contact time for the complete solubilization of the most readily leachable metals (Ni and Zn). Air-lift reactors and aerated column reactors required longer contact times and complete solubilization of either zinc or nickel was not achieved. The air-lift reactor approach was somewhat more effective than the aerated slurry technique. A percolation system was the least effective and yielded the lowest recoveries. Shake flasks (easily autoclavable) offered the advantage of comparison of the microbiological and solely chemical leaching. Aseptic conditions could not be maintained with the air-lift and aerated column reactors because of contamination via aerosol formation. In a relative scale the leaching patterns were similar in that the precipitation of Fe(III) occurred regardless of the technique; zinc and nickel sulfides were solubilized more quantitatively than those of copper and cobalt; aluminum concentrations, although high, indicated low leaching yields relative to aluminum silicates in the ore material; and the pH reached similar final values in the presence of bacteria.     

Microbiological leaching of a low-grade uranium ore byThiobacillus ferrooxidans

Summary The microbiological leaching of low-grade uranium ore has been investigated using a pure strain ofThiobacillus ferrooxidans. It has been shown that only minute quantities of iron are required to achieve a maximum effect on uranium release. The ore sample contained enough iron (3.23%) to produce this effect, consequently, very little influence has been observed on uranium solubilization by addition of either ferrous sulfate or pyrite to the leach suspensions. The highest uranium extraction rate derived in this study (57.1 mg/l/day) was realized with a 40% pulp density suspension containing 9.0 g/l of ferrous ion. The highest yield (100.0%) was obtained with a 5% pulp density suspension (initial mean particle diameter: 0.64 mm) and without addition of iron after ten days of treatment. The applicability of this method to industrial scale is proposed.     

Integrated biological process for the treatment of a Chilean complex gold ore

Abstract: A process for gold recovery from a complex Chilean ore from Burladora (IV Region) which integrates concentration by flotation, bacterial leaching and cyanidation was studied at a laboratory scale. The chemical composition of the ore is 8.2% Fe, 0.78% Cu, 0.88% As and 3.5 g/t Au, with pyrite, hematite, covelite, arsenopyrite and chalcopyrite as the main metal-bearing minerals. The initial gold recovery by conventional cyanidation on a crushed ore sample was only 54%. The ore was ground and concentrated by flotation with a gold recovery of only 56%. The gold content of the concentrate is 17 g/I Au. Concentrate samples were leached in 1.5 l stirred reactors at 10% pulp density in 1000 ml of acid medium (pH 1.8). Some experiments were inoculated with harvested bacteria previously isolated from mining solutions. Dissolved metals, pH and bacteria concentration in the leaching solutions were periodically determined. In the presence of bacteria, oxidation of the ferrous ion produced by acid dissolution of the concentrate was observed, and after 4 days of leaching 100% of the dissolved iron was present as ferric ion. Gold recovery by cyanidation increased from 13% for the initial concentrate to 34% after 10 days of chemical acid leaching and 97% after 10 days of bacterial leaching. To increase the total gold recovery, the flotation tailings were submitted to cyanidation. A complete flowsheet of the process and a first economical evalualion are proposed. As a possible alternative process, heap bacterial leaching and further cyanidation of the ore are suggested.     

Chalcopyrite concentrate leaching with biologically produced ferric sulphate

Biological ferric iron production was combined with ferric sulphate leaching of chalcopyrite concentrate and the effects of pH, Fe3+, temperature and solids concentration on the leaching were studied. The copper leaching rates were similar at pH of 1.0-1.8 and in the presence of 7-90 g L-1 Fe3+ despite massive iron precipitation with 90 g L-1 Fe3+. Increase of the leaching temperature from 50 degrees C to 86 degrees C and solids concentration from 1% to 10% increased the copper leaching rate. Increase in solids concentration from 1% to 10% decreased the copper yields from 80% to 40%. Stepwise addition of ferric iron did not improve the copper yields. CuFeS2, Ag and Cu1.96S potentials indicated the formation of a passivating layer, which consisted of jarosite and sulphur precipitates and which was responsible for the decreased leaching rates.     

Microbiological leaching of sulfide minerals with different percolation regimes

Summary The microbiological leaching of Fe, Al, Zn, Cu, Ni and Co from sulfide ore material was evaluated with four percolation regimes involving trickle and flood leaching. Continuous circulation of the leach solution associated with flood leaching resulted in the highest rates of leaching of Ni (44% recovery), Zn (25%), Co (18%), and Cu (8%) over a period of about half a year. Iron and aluminum recoveries remained low because of their precipitation. Bacterial counts increased from 3.2×10⁶ to 4.8×10⁷ iron-oxidizers and from 6.6×10⁶ to 1.8×10⁷ glucose-oxidizers per ml leach solution. Microscopic counts reached a maximum of 4.9×10⁸ cells per ml. Neither microscopic nor viable counts reflected the time course and the progress of the leaching. However, both the microscopic and viable counts were highest with the continuous flooding technique which also yielded the fastest rates of metal solubilization.     

Tissue responses against Cladosporium trichoides and its parasitic forms in congenitally athymic nude mice and their heterozygous littermates

The tissue responses against Cladosporium trichoides and its parasitic forms were studied using nude (nu/nu) mice and their heterozygous (nu/+) littermates of BALB/c background.1.0,0.1 and 0.01% cell suspensions were prepared from a culture broth which had been inoculated with the C. trichoides and cultured with reciprocal shaking at 27 ° C for 7 days. Sixty nu/nu or 60 nu/+ mice were divided into three groups consisting of 20 each which was allotted to one of the three cell suspensions. Each mouse was inoculated intravenously with 0.1 ml of either the cell suspensions. Two mice from each of the six groups were sacrificed at adequate intervals until 30 days after inoculation and histopathologic sections stained with H & E or by PAS were prepared from their visceral organs.There were no characteristic findings in the nu/nu and nu/+ mice inoculated with the 0.01% cell suspension. When inoculated with the 1.0% cell suspension, the brain was the favorite target organ in both groups of mice and the kidney was the second. When inoculated with the 0.1% cell suspension, brain lesions were observed only in the nu/nu mice. The susceptibility of the nu/nu mice was higher than that of the nu/+ mice.The parasitic forms in the brain of the nu/nu and nu/+ mice were slender septate true hyphae with or without polymorphonuclear leucocyte infiltrate, while in the liver, spleen and lung of both groups of mice the parasitic forms were short thick hyphae, moniliform hyphae, chlamydospores or round cells (sclerotic cells). Many giant cells containing fungal elements appeared in the liver of the nu/nu mice.     

Evidence for microbial iron reduction in a landfill leachate-polluted aquifer (Vejen, Denmark).

Aquifer sediment samples obtained from the anaerobic part of a landfill leachate plume in Vejen, Denmark, were suspended in groundwater or in an artificial medium and incubated. The strictly anaerobic suspensions were tested for reduction of ferric iron [Fe(III)] oxides, which was measured as an increase in the concentration of dissolved Fe(II). Iron reduction did not occur when the medium was inoculated with inactive sediment and when the organisms in the inoculated medium were killed by formaldehyde, by chloroform, or by pasteurization, whereas the level of iron reduction was significant when living bacteria were present. Mixed cultures were obtained from the sediment samples, and differences in apparent iron reduction rates among the different cultures were maintained during several transfers. In addition, iron reduction was observed in unamended incubation mixtures containing whole sediment and groundwater. Synthetic amorphous Fe(III) oxides, as well as naturally occurring sediment-bound Fe(III) oxides, could be reduced by the cultures. Together, our results provide evidence that iron-reducing bacteria are present and microbial iron reduction occurs in the polluted aquifer sediments which we studied.     

Effect of chitosan on tobacco mosaic virus（TMV） accumulation,hydrolase activity,and morphological abnormalities of the viral particles in leaves of N. tabacum L. cv. Samsun

The effect of chitosan on the development of infection caused by Tobacco mosaic virus（TMV） in leaves of Nicotiana tabacum L. cv. Samsun has been studied. It was shown that the infectivity and viral coat protein content in leaves inoculated with a mixture of TMV（2 μg/mL） and chitosan（1 mg/mL） were lower in the early period of infection（3 days after inoculation）, by 63% and 66% respectively, than in leaves inoculated with TMV only. Treatment of leaves with chitosan 24 h before inoculation with TMV also caused the antiviral effects, but these were less apparent than when the virus and polysaccharide were applied simultaneously. The inhibitory effects of the agent decreased as the infection progressed. Inoculation of leaves with TMV together with chitosan considerably enhanced the activity of hydrolases（proteases, RNases） in the leaves, in comparison with leaves inoculated with TMV alone. Electron microscope assays of phosphotungstic acid（PTA）-stained suspensions from infected tobacco leaves showed that, in addition to the normal TMV particles（18 nm in diameter, 300 nm long）, these suspensions contained abnormal（swollen, “thin” and “short”） virions. The highest number of abnormal virions was found in suspensions from leaves inoculated with a mixture of TMV and chitosan. Immuno-electron microscopy showed that “thin” virus particles, in contrast to the particles of normal diameter, lost the ability to bind to specific antiserum. It seems that the chitosan-induced activation of hydrolases stimulates the intracellular degradation of TMV particles and hence hydrolase activation may be considered to be one of the polysaccharide-mediated cellular defense mechanisms that limit virus accumulation in cells.     

Cell-adhered conjugated linoleic acid regulates isomerization of linoleic acid by resting cells of Propionibacterium freudenreichii

The microbiological isomerization of linoleic acid (LA) to conjugated linoleic acid (CLA) was studied in resting cell suspensions of a propionibacterium and micellar LA to identify factors critical in the isomerization efficiency. These suspensions, containing cells 5x10(10) colony-forming units ml(-1) and 510 micro g LA ml(-1), isomerized about 90% of LA to CLA. However, the yield was not improved with higher amounts of micellar LA, suggesting that the cells had a fixed capacity to carry out the isomerization. This was explained by the fact that the CLA formed had a tendency to accumulate in the cell mass rather than in the aqueous micellar phase during the isomerization. Concomitantly, cell viability and isomerization rates were gradually reduced. Upon cessation of the reaction, about 46% of all the CLA formed was in the cell material. This accumulation to the cells was prevented by adding the detergent in excess to that required for micellization of LA. Then the cells remained viable, but the rate of isomerization was drastically lowered, due to impaired availability of LA from the fortified micellar phase to the cells. It was concluded that the phase distribution of substrate and product plays a critical role in the microbiological production of CLA.     

Beneficiation of iron ore slime using Aspergillus niger and Bacillus circulans

Studies were carried out on the removal of alumina from iron ore slime containing (%) Fe(2)O(3) 75.7, Al(2)O(3) 9.95, SiO(2) 6.1, Fe (total) 52.94 with the help of Bacillus circulans and Aspergillus niger. B. circulans and A. niger showed 39% and 38% alumina removal after six and 15 days of in situ leaching at 10% pulp density, respectively. Culture filtrate leaching with A. niger removed 20% alumina at 2% pulp density with 13 day old culture filtrate. B. circulans was more efficient than A. niger for selective removal of alumina. In case of A. niger in situ leaching rather than culture filtrate leaching was found to be more effective.     

Suppression by bone marrow cells of the level of specific IgE antibodies in the blood of mice and decrease in the production of IGE by bone marrow cells

Changes in the level of the specific IgE-antibodies to ovalbumin under the influence of syngeneic cells of a bone marrow were studied. The IgE-response was induced by ovalbumin in mice (CBA X C57Bl/6)F1. The bone marrow cells suspensions (20-30 X 10(6) cells per mouse) from syngeneic donors was inoculated simultaneously with the immunization. It was found that bone marrow cells suppressed both the level of IgE-antibodies in experimental mice serum and the production of IgE by the bone marrow cells of the recipient. The ability to suppress IgE-response remained when erythrocytes, monocytes and T-lymphocytes were removed from inoculated suspensions. The bone marrow cells taken from the mice immunized with ovalbumin, at the stage of a decreasing IgE-response, provided more pronounced suppression, than bone marrow cells taken from intact animals.     

Interactions of the tomato with two formae speciales of Fusarium oxysporum

Tomato cuttings were inoculated with Fusarium oxysporum f.sp. lycopersici (FL) and F. oxysporum f.sp. pisi (FP) by standing the cuttings in suspensions of bud-cells of the fungi. FP never induced external symptoms although the fungus persisted in the lower parts of the cutting. FL at concentrations from 10³ to 10⁶ spores per ml induced typical wilt symptoms but there was subsequent recovery of some cuttings with the production of uninvaded side shoots. When the cuttings were inoculated with mixed suspensions of bud cells of the two fungi there was marked reduction of symptoms. The extent of this reduction was related to the proportion of FP/FL bud cells for a fixed inoculum of FL in the mixture and was moderate at a rate of 1/3 and complete at ratios from 4/1 to 9/1. Mixed suspensions of heat-killed bud cells of FP with live bud cells of FL in the ratio of 4/1 induced normal symptoms and it was concluded that the symptom mitigation induced by FP was related to the presence of living cells of the fungus. Root inoculations with mixed suspensions also gave less wilt than with FL alone. Symptom mitigation was apparently associated with a reduction of the extent of invasion of the cuttings but in vitro tests failed to demonstrate that exudates or extracts from normal or invaded tomato tissue induced any reduction of growth of the tomato pathogen.     

Microbiological leaching of a chalcopyrite concentrate by Thiobacillus ferrooxidans

The microbiological leaching of a chalcopyrite concentrate has been investigated using a pure strain of Thiobacillus ferrooxidans. The optimum leaching conditions regarding pH, temperature, and pulp density were found to be 2.3, 35°C, and 22%, respectively. The energy of activation was calculated to be 16.7 kcal/mol. During these experiments the maximum rate of copper dissolution was about 215 mg/liters/hr and the final copper concentration was as high as 55 g/liter. This latter value is in the range of copper concentrations which may be used for direct electrorecovery of copper. Jarosite formation was observed during the leaching of the chalcopyrite concentrate. When the leach residue was reground to expose new substrate surface, subsequent leaching resulted in copper extractions up to about 80%. On the basis of this experimental work, a flow sheet has been proposed for commercial scale biohydrometallurgical treatment of high-grade chalcopyrite materials.     

The effects of Fe(II) and Fe(III) concentration and initial pH on microbial leaching of low-grade sphalerite ore in a column reactor

In this study the effects of initial concentration of Fe(II) and Fe(III) ions as well as initial pH on the bioleaching of a low-grade sphalerite ore in a leaching column over a period of 120 days with and without bacteria were investigated. Four different modifications of medium were used as column feed solutions to investigate the effects of initial concentration of Fe(II) and Fe(III) ions on zinc extraction. The experiments were carried out using a bench-scale, column leaching reactor, which was inoculated with mesophilic iron oxidizing bacteria, Acidithiobacillus ferrooxidans, initially isolated from the Sarcheshmeh chalcopyrite concentrate (Kerman, Iran). The effluent solutions were periodically analyzed for Zn, total Fe, Fe(II) and Fe(III) concentrations as well as pH values. Bacterial population was measured in the solution (free cells). Maximum zinc recovery in the column was achieved about 76% using medium free of initial ferrous ion and 11.4 g/L of ferric ion (medium 2) at pH 1.5. The extent of leaching of sphalerite ore with bacteria was significantly higher than that without bacteria (control) in the presence of ferrous ions. Fe(III) had a strong influence in zinc extraction, and did not adversely affect the growth of the bacteria population.     

The efficiency of the action of alpha-tocopherol and its homologs on luminol-dependent chemiluminescence induced by (Fe2+ + NADP.H) and (Fe2+ + ascorbate) systems in rat liver microsomes]

The effects of alpha-tocopherol (C16) and its homologues with different chain length (6-hydroxychromanes-C1, C6, C11) on lipid peroxidation induced luminol-dependent chemiluminescence in rat liver microsomal suspensions were studied. It was shown that C1, C6 and C11 inhibited the (Fe(2+) + ascorbate)-and (Fe(2+) + NADP.H)-induced chemiluminescence. The inhibitory effect was decreased in the order: C1 C6 C11, C16 was not influenced chemiluminescence. The possible reason underlying these differences was discussed: different efficiency of interaction of C16 and its homologues with hydroxyl and superoxide radicals, which initiate the luminol-dependent chemiluminescence. It was concluded that C16 (in concentration below 0.5 mM) was not interacted with hydroxyl and superoxide free radicals, generated in microsomal suspensions under (Fe(2+) + ascorbate)- and (Fe(2+) + NADP.H)-dependent lipid peroxidation.     

Bioleaching of spent fluid catalytic cracking catalyst using Aspergillus niger

The use of the fungus Aspergillus niger for the bioleaching of heavy metals from spent catalyst was investigated, with fluid catalytic cracking (FCC) catalyst as a model. Bioleaching was examined in batch cultures with the spent catalysts at various pulp densities (1-12%). Chemical leaching was also performed using mineral acids (sulphuric and nitric acids) and organic acids (citric, oxalic and gluconic acids), as well as a mixture of organic acids at the same concentrations as that biogenically produced. It was shown that bioleaching realised higher metal extraction than chemical leaching, with A. niger mobilizing Ni (9%), Fe (23%), Al (30%), V (36%) and Sb (64%) at 1% pulp density. Extraction efficiency generally decreased with increased pulp density. Compared with abiotic controls, bioleaching gave rise to higher metal extractions than leaching using fresh medium and cell-free spent medium. pH decreased during bioleaching, but remained relatively constant in both leaching using fresh medium and cell-free spent medium, thus indicating that the fungus played a role in effecting metal extraction from the spent catalyst.     

A rapid method for enumerating Salmonella in milk powders

A one-day procedure for enumerating Salmonella in milk powder is described. Milk powder suspension was treated with a mixture of trypsin and Tween 80, then centrifuged to give a sediment of microbial cells that was plated on the xylose lysine desoxycholate agar for the direct enumeration of Salmonella. Known populations (1–200 cfu/25 g of sample) of salmonellas inoculated into milk powder suspensions were recovered with almost 100% efficiency in each of 152 trials of the method, covering 17 different serotypes.     

Humoral immunity in experimental syphilis: the demonstration of IgG as a treponemicidal factor in immune rabbit serum

The neutralizing activity present in immune rabbit serum (IRS) against virulent Treponema pallidum was shown to be mediated by IgG and complement. IgG was isolated and purified from both IRS and nonimmune rabbit serum (NRS) by the use of an affinity system in which staphylococcal protein A was conjugated to Sepharose 4B. The purity of the isolated IgG fractions was demonstrated by both immunoelectrophoresis and SDS-polyacrylamide gel electrophoresis. Fractions of IgG were tested for specific neutralizing activity as measured by an in vitro-in vivo neutralization test. Lesions failed to develop at 80% of the sites inoculated with treponemal suspensions containing IgG from IRS in the presence of unheated NRS as a source of complement; delayed atypical lesions were observed at the remaining sites. In contrast, typical lesions developed at all sites inoculated with suspensions containing IgG from IRS in the presence of heated NRS. They were significantly delayed, however, as compared with lesion development at control sites inoculated with suspensions containing IgG from NRS. These results provide the first direct evidence for an IgG complement-mediated treponemicidal mechanism operative in immune serum from rabbits with latent syphilis.