胰蛋白酶的固定化及其性质研究

 以自制的脱乙酰壳多糖作载体,戊二醛为交联剂,对胰蛋白酶的固定化条件及其固定化酶的性质进行了研究。考查了交联剂的用量、pH值、以及载体与酶的比例等因素对胰蛋白酶固定化的影响。在所选择的固定化条件下,固定化酶的活性回收可达50％以上。同时研究了固定化胰蛋白酶的一些性质;最适温度60℃,最适PH8.0,Km值比可溶性酶升高,热稳定性、pH贮存稳定性以及在乙醇水溶液中的稳定性明显高于可溶性胰蛋白酶。在柱式反应器内,以2％酪蛋白为底物对,操作半衰期为40天。     

Enzyme-based high-performance liquid chromatography supports as probes of enzyme activity and inhibition: the immobilization of trypsin and alpha-chymotrypsin on an immobilized artificial membrane high-performance liquid chromatography support.

Immobilized artificial membrane (IAM) HPLC supports have been used to immobilize the enzymes alpha-chymotrypsin and trypsin. The enzymes were trapped in hydrophobic cavities on the support and were not covalently attached to the IAM surface. The resulting IAM-enzyme supports retained the hydrolytic activity of the immobilized enzymes: the IAM-trypsin support catalyzed the hydrolysis of N alpha-benzoyl-DL-arginine-p-nitroanilide (BAPNA), and the IAM-alpha-chymotrypsin support (IAM-ACHT) catalyzed the hydrolysis of a number of substrates, including tryptophan methyl ester. The activities of both supports were decreased by known enzyme inhibitors and the activity of the IAM-ACHT was affected by changes in pH and temperature. When a substrate was chromatographed on an IAM-ACHT HPLC, the hydrolytic activity of the immobilized enzyme could be determined from the resulting substrate/product ratios. These data were obtained either directly from the IAM-ACHT chromatogram or from the chromatogram produced by a coupled column system. The results of this study indicate that IAM-immobilized alpha-chymotrypsin and trypsin can be used as chromatographic probes for the qualitative determination of enzyme/substrate and enzyme/inhibitor interactions.     

三乙醇胺基强碱性聚苯乙烯树脂共价固定胰酶的研究

用多孔强碱型三乙醇胺基聚苯乙烯阴离子交换树脂做为载体,用CNBr与载体上的多羟基作用共价偶联了胰酶。红外光谱表明:其共价偶联反应机理与用CNBr活化多糖类载体并接酶的机理相类似。最适偶联条件研究表明:CNBr用量增多,酶蛋白载量增加。但比活下降。偶联pH为10时,固定化酶有适宜的载量和较高的比活。由于胰酶水解蛋白反应释放出H~+质子,这些质子在载体内积累,使微环境内H~+质子浓度增加,进而使得固定化胰酶的pH—活性曲线在pH9～11范围内未出现下降。在变温和60℃恒温下对固定化酶的热稳定性测试表明:固相酶的热稳定性比天然酶的热稳定性有所提高。     

Immobilization of trypsin on chitosan gels: use of different activation protocols and comparison with other supports

Trypsin was immobilized on chitosan gels coagulated with 0.1 or 1 M NaOH and activated with glutaraldehyde or glycidol. The derivatives were characterized by their recovered activity, thermal (40, 55 and 70 degrees C) and alkaline (pH 11) stabilities, amount of enzyme immobilized on gels for several enzyme loads (8-14 mg(protein)/g(Gel)) and compared to agarose derivatives. Enzyme loads higher than 14 mg(protein)/g(Gel) can be immobilized on glutaraldehyde derivatives, which showed 100% immobilization yield and, for loads up to 8 mg(protein)/g(Gel), 100% recovered activity. Activation with glycidol led to lower immobilization yields than the ones obtained with glutaraldehyde, 61% for agarose-glyoxyl (AgGly) with low grade of activation and 16% for the chitosan-glyoxyl (ChGly), but allowed obtaining the most stable derivative (ChGly), that was 660-fold more stable than the soluble enzyme at 55 and 70 degrees C-approximately threefold more stable than AgGly. The ChGly derivative presented also the highest stability during incubation at pH 11. Analyses of lysine residue contents in soluble and immobilized trypsin indicated formation of multipoint bonds between enzyme and support, for glyoxyl derivatives.     

Sepharose-bound trypsin and activated sepharose-bound trypsinogen. Studies with small and large substrates

Several enzymic and physical properties of Sepharose-bound trypsin and activated Sepharose-bound trypsinogen have been compared to those of the soluble enzyme. Sepharose-bound trypsinogen could be activated to the same extent as soluble trypsinogen; the release of the activation peptide and formation of the active site occurred as expected in the presence of catalytic amounts of trypsin. With synthetic substrates, the relative activity and pH dependence of both immobilized trypsin preparations were essentially identical and nearly the same as the soluble enzyme. Sepharose-trypsin also formed an inactive complex with soybean trypsin inhibitor, with 85% of the active sites participating. In contrast, the activity of Sepharose-trypsin with chymotrypsinogen and with trypsinogen as substrates was only 40% that of soluble trypsin. There is evidence for some catalytic heterogeneity of active sites of bound trypsin; probably those sites buried within the gel have a limited catalytic efficiency with macromolecular substrates. The immobilized enzyme is more stable than the soluble enzyme at elevated temperatures and to concentrated urea, and denaturation by urea at pH 8 is fully reversible since the loss of molecules by autolysis is eliminated.     

Studies on the immobilization of trypsin on sand

Trypsin was immobilized on sand using five different methods. Attempts were made to attach amino-functional groups onto sand using 3-aminopropyltriethoxysilane, hexamethylenetetramine, hexamethylenediamine, and melamine. Glutaraldehyde was used as a bifunctional agent in all the methods. Methods for the estimation of the proteolytic 1activity and protein content of immobilized trypsin were standardized. The maximum retained activity was observed for trypsin immobilized on sand via 3-aminopropytriethoxysilane and glutaraldehyde. Immobilized trypsin showed a shift in the pH optimum toward the acidic side over that of soluble trypsin in all five cases. The optimum temperature for both native and immobilized trypsin prepared by the silane-glutaraldehyde method was found to be 45°C. However, the pH and thermal stabilities of immobilized trypsin were observed to be better than that of the native enzyme.     

Co-immobilization of different enzyme activities to non-woven polyester surfaces

Co-immobilization was applied to combine complementary enzyme reactions. Therefore, trypsin was co-immobilized together with both, lipase and alpha-amylase, onto the surface of non-woven polyester material. The progress of the immobilization reaction was directly monitored by investigating covalent fixation of the enzymes to the polyester flees using (1)H-MAS-NMR. Co-immobilization of the different types of enzymes to the polyester support showed retained enzymatic activity. However, a competition of binding to the support was observed. Increasing amounts of one type of enzyme reduced the degree of immobilization for the other type. In order to investigate the distribution of trypsin and alpha-amylase on the polyester support, the flees was treated with a mixture of rhodamine isothiocyanate labeled with anti-trypsin antibodies and fluorescein isothiocyanate labeled with anti-alpha-amylase antibodies. Using fluorescence microscopy, the co-immobilization was analyzed by selective excitation of both chromophores at 480 and 530 nm, respectively. In addition, fluorescence spectroscopy was applied by direct labeling of trypsin and lipase prior to co-immobilization to the polyester support. A special prism of plexiglass was constructed, which fit into a 10 x 10 mm fluorescence cuvette in that way that a diagonal plane was formed within the cuvette. The non-woven support was fixed in the cuvette and fluorescence spectra were obtained to characterize the amount of different enzymes linked to the support. Using FRET it was demonstrated that a uniform distribution of the various enzyme species was achieved, where the different enzyme activities are bound on the support in close neighborhood to one another.     

Porous zirconia: a new support material for enzyme immobilization

Four different proteases (trypsin, chymotrypsin, papain and pepsin) were covalently attached to the surface of a new type of porous zirconia, as well as a conventional porous silica, activated with 3-isothiocyanatopropyltriethoxy silane (NCS-silane). The immobilization efficiency onto the porous zirconia material was evaluated in terms of the amount of enzyme attached to the particles and from the biological activity remaining after the immobilization step. The results were compared with the corresponding experiments with a porous silica of similar surface area/g support material. In addition, the storage stability of the modified zirconia and silica biocatalysts were evaluated. These results indicated that specific immobilized enzyme biocatalysts can be achieved with this new zirconia support material which exhibits different properties to those observed with the more conventional silica-based materials. Moreover, the results with the enzyme-zirconia biocatalysts also indicate different characteristics when compared with data for the same enzymes immobilized under similar buffer conditions to organic support materials as previously described by various other investigators. The advantages of zirconia-based immobilized enzyme biocatalysts in terms of their density and chemical robustness are also described relative to other alternative support materials currently in use.     

Quantitative study of enzyme immunocytochemical reactions performed with enzyme conjugates immobilized on nitrocellulose

The nitrocellulose binding assay was used for quantitative studies on the cytochemical reactions for the three enzymes most frequently used in immunocytochemistry. The results show a linear relationship between the amount of enzyme immobilized on nitrocellulose and the amount of the enzyme reaction product. The similar course of the formation of the reaction product after DAB/H2O2 staining for peroxidase immobilized on nitrocellulose and for immunoperoxidase labeled cells indicates a linear relationship between the amount of enzyme-coupled antibodies bound to cells and the amount of enzyme reaction product. Furthermore, a mild acid treatment for the abolition of endogeneous peroxidase activity in tissues and cells applicable to immunoperoxidase staining procedures is proposed.     

Silanized silica bound trypsin as analytical probe.

Trypsin immobilized by covalent coupling to silanized silica shows significant activity (30-38%) and greater thermostability as compared to soluble trypsin. Proteolytic processing of albumin at varying periods suggest that the enzyme matrix can be used efficiently for limited proteolysis. Repeated use of the immobilized enzyme in protein digestion produces similar products as seen by electrophoretic analysis. Also, digestion of albumin by the immobilized enzyme follows similar pattern as that by soluble enzyme. The enzyme matrix can be easily removed from the incubation mixture. The results indicate the possibility of the immobilized enzyme for its effective application as analytical tool in peptide mapping and limited proteolytic processing.     

Modeling enzyme immobilization in porous solid supports

Enzymes are often immobilized on the internal surfaces of porous solid by immersing enzyme-free particles in a well mixed solution of enzyme. The ensuing impregnation process involves coupled transient mass transfer and surface attachment of enzyme. A mathematical model is employed to explore the influences of process parameters on the amount of enzyme loaded and the distribution of immobilized enzyme within the support particles. Nonuniform loading of the support occurs under some conditions. This is significant since the distribution of enzyme within the support particle influences the overall activity and stability of the immobilized enzyme catalyst. The model developed here may also be used to describe removal of reversibly immobilized enzyme during washing or utilization of the immobilized enzyme catalyst.     

Immobilization of adenosine deaminase onto agarose and casein

In the present study adenosine deaminase (ADA) was immobilized onto two different polymeric materials, agarose and casein. The factors affecting the amount of enzyme attachment onto the polymeric supports such as incubation time were investigated. The maximum amount of enzyme immobilized onto different polymeric supports occurred at incubation pH value 7.5 and ADA concentration 42 units/g and the incubation time needed for the maximum amount of enzyme attachment to the polymeric supports was found to be 8 h. Some phsicochemical properties of the free and immobilized ADA such as operational stability, optimum temperature and thermal stability, pH optimum and stability, storage stability, and the effect of gamma-radiation were studied. The operational stability of the free and immobilized enzyme showed that the enzyme immobilized by a cross-linking technique using gultaric dialdehyde showed poor durability and the relative activity decreased sharply due to the leakage after repeated washing, while the enzymes immobilized by covalent bonds to the carriers showed a slight decrease in most cases in the relative activity (around 20%) after being used 10 times. Storage for 4-6 months, showed that the free enzyme lost its activity, while the immobilized enzyme showed the opposite behavior. Subjecting the immobilized enzyme to a dose of gamma radiation of 0.5-10 Mrad showed complete loss in the activity of the free enzyme at a dose of 5 Mrad, while the immobilized enzymes showed relatively high resistance to gamma radiation up to a dose of 5 Mrad.     

Immobilization of trypsin on polyurethane carriers]

A method of covalent immobilization of trypsin on polyurethanes containing residues of 2.4-toluene or hexamethylene diisocyanates in a side chain is developed. It is shown that the amount of the immobilized enzyme is independent of isocyanate nature, but its proteolytic activity is higher on carriers containing 2.4-toluene diisocyanate residues. This is accounted for by higher mobility of enzyme molecules due to a decrease in the number of chemical bonds between trypsin and the polymer matrix. The immobilized enzyme is stable for a long time and does not lose proteolytic activity being cyclically used for many times.     

Kinetics and stability of immobilized chicken liver xanthine dehydrogenase.

Xanthine dehydrogenase (EC 1.2.1.37) was isolated from chicken livers and immobilized by adsorption to a Sepharose derivative, prepared by reaction of n-octylamine with CNBr-activated Sepharose 4B. Using a crude preparation of enzyme for immobilization it was observed that relatively more activity was adsorbed than protein, but the yield of immobilized activity increased as a purer enzyme preparation was used. As more activity and protein were bound, relatively less immobilized activity was recovered. This effect was probably due to blocking of active xanthine dehydrogenase by protein impurities. The kinetics of free and immobilized xanthine dehydrogenase were studied in the pH range 7.5-9.1. The Km and V values estimated for free xanthine dehydrogenase increase as the pH increase; the K'm and V values for the immobilized enzyme go through a minimum at pH 8.1. By varying the amount of enzyme activity bound per unit volume of gel, it was shown that K'm is larger than Km are result of substrate diffusion limitation in the pores of the support material. Both free and immobilized xanthine dehydrogenase showed substrate activation at low concentrations (up to 2 microM xanthine). Immobilized xanthine dehydrogenase was more stable than the free enzyme during storage in the temperature range of 4-50 degrees C. The operational stability of immobilized xanthine dehydrogenase at 30 degrees C was two orders of magnitude smaller than the storage stability, t 1/2 was 9 and 800 hr, respectively. The operational stability was, however, better than than of immobilized milk xanthine oxidase (t 1/2 = 1 hr). In addition, the amount of product formed per unit initial activity in one half-life, was higher for immobilized xanthine dehydrogenase than for immobilized xanthine oxidase. Unless immobilized milk xanthine oxidase can be considerable stabilized, immobilized chicken liver xanthine dehydrogenase is more promising for application in organic synthesis.     

Highly efficient "tight fit" immobilization of alpha-chymotrypsin in mesoporous MCM-41: a novel approach using precursor immobilization and activation

The zymogen alpha-chymotrypsinogen A is bound to mesoporous silica MCM-41 with a protein loading of 170 mg/g solid (MCM-Z) by a simple stirring in aqueous tris-HCl buffer (pH 7.2). The bound zymogen is then activated with trypsin to obtain alpha-chymotrypsin immobilized on MCM-41 (MCM-E.I) that displays an effective enzyme activity corresponding to 65 mg protein/g of solid support (3250 BTEE units/g). A direct immobilization of commercially available alpha-chymotrypsin (MCM-E.II) gives lower loading (1250 BTEE units/g). Protein content of the solid support after immobilization is confirmed by thermogravimetric analysis (TGA). The enzyme is tightly bound to the support and can be used over 100 recycles over 1 week in aqueous as well as reverse micellar media. The immobilized enzyme (MCM-E.I) has been used for resolution of N-acetyl-dl-amino acid esters and racemic trans-4-methoxy-3-phenylglycidic acid (PGA) methyl ester.     

磁性固定化胰蛋白酶的催化特性及应用的研究

详细研究了磁性固定化胰蛋白酶的催化特性,并与溶液酶进行比较,发现胰蛋白酶经固定化后最适pH值向碱性方向移动了1．0个pH单位,最适温度提高了5℃,K值略有增大。对该固化酶的热稳定性和操作稳定性也进行了研究,结果表明,胰蛋白酶经固定化后热稳定性明显提高,操作稳定性也得到了一定的改善,经3次重复使用后,活性保持43．8％,对啤酒澄清和裸皮软化显示较好的应用前景。     

Quantitative study of enzyme immunocytochemical reactions performed with enzyme conjugates immobilized on nitrocellulose

Summary The nitrocellulose binding assay was used for quantitative studies on the cytochemical reactions for the three enzymes most frequently used in immunocytochemistry. The results show a linear relationship between the amount of enzyme immobilized on nitrocellulose and the amount of the enzyme reaction product. The similar course of the formation of the reaction product after DAB/H₂O₂ staining for peroxidase immobilized on nitrocellulose and for immunoperoxidase labeled cells indicates a linear relationship between the amount of enzyme-coupled antibodies bound to cells and the amount of enzyme reaction product. Furthermore, a mild acid treatment for the abolition of endogeneus peroxidase activity in tissues and cells applicable to immunoperoxidase staining procedures is proposed.In honour of Prof. P. van Duijn     

Influence of the conditions of trypsin immobilization onto Spherosil on coupling efficiency

Summary The effect of several parameters (pH, time of reaction, temperature, enzyme concentration) on trypsin immobilization onto glutaraldehyde-activated amine-Spherosil was investigated. This activated support could be stored over long periods of time without any important loss of capacity for trypsin coupling. When increasing the amount of trypsin bound to the carrier, enzymatic activity shows an optimal value, beyond which an augmentation of Spherosil enzyme content results in a lowered activity. The influence of the number of available reactive aldehyde groups on silica was investigated by coupling L-lysine to activated support either prior to or simulataneously with trypsin immobilization. In both cases, the activity of trypsin derivatives is decreased when L-lysine concentration is increased, yet the activity of trypsin derivatives is never equal to zero, even in presence of a large excess of L-lysine. This suggests the presence of two types of reactive groups on the activated support.     

Production of L-lysine by immobilized trypsin. Study of DL-lysine methyl ester resolution

The possibility of producing L-lysine from chemically synthesized DL-lysine has been investigated. Optical resolution of racemic DK-lysine may be achieved by using the stereospecific esterasic activity of trypsin on DL-lysine methyl ester, which gives L-lysine and unchanged D-lysine methyl ester. SL-lysine methyl ester spontaneous hydrolysis may be neglected when operating at pH 5.5 and 30 degrees C. Effect of pH and substrate concentration on hydrolysis rate has been investigated when using as a catalyst either soluble or immobilized trypsin. For this purpose, trypsin was coupled onto an amine porous silica, Spherosil, activated with glutaraldehyde. The optimal pH is 5.8 for soluble trypsin and 6.0 for immobilized trypsin. It was yet possible to lower the parent optimal pH of immobilized trypsin, and thus increase its activity at 5.5, by co-grafting onto Spherosil an aminosilane, for enzyme coupling via glutaraldehyde activation and a positively charged diethyl amino ethyl (DEAE) silane, for decreasing the pH of trypsin microenvironment.     

Immobilization of Candida rugosa lipase to nylon fibers using its carbohydrate groups as the chemical link

The aim of this study was to evaluate the immobilization of lipase from Candida rugosa on a nylon support by methods used to attach biomolecules to solid supports through their carbohydrate moieties. The carbohydrate groups were converted to dialdehydes by treatment with sodium periodate. The length of exposure and the periodate amount were optimized to the point where almost total activity retention was obtained. Tests of the immobilized enzyme showed the expressed activity to be significantly higher than the activity obtained with the unimmobilized enzyme. The use of reverse micelles as a way of delivering water to the enzyme was tested and found to give significantly higher activities. The immobilized enzyme activity was also tested with other substrates, one of which was a chiral ester. The immobilized enzyme was found to have high stereoselective efficiency and activity toward racemic methyl methoxyphenyl glycidate, a chiral intermediate used in the manufacture of the drug diltiazem. (c) 1996 John Wiley & Sons, Inc.