Use of Phanerochaete chrysosporium biomass for the removal of textile dyes from a synthetic effluent

Summary The use of Phanerochaete chrysosporium biomass for the removal of Reactofix Golden Yellow from aqueous solution and eight textile dyes (four azo and four anthraquinone) from a synthetic effluent (0.6 g/l) at different pH, temperature and biomass concentrations was studied. Adsorption was maximum at pH 2.0 and 40 °C using 2.45 g mycelial biomass. The rate constant of adsorption was 1.95×10⁻¹/min for Reactofix Golden Yellow and 1.64×10⁻¹/min for synthetic effluent. In both cases, the equilibrium data fitted well in the Langmuir but not the Freundlich model of adsorption, and the adsorption was biphasic. Adsorption decreased the COD of Reactofix Golden Yellow and synthetic effluent by 54 and 57%, respectively. Desorption (80–84%) of dyes from P. chrysosporium mycelial surface occurred as the pH increased from 2 to 10.     

Kinetics of endosulfan degradation by Phanerochaete chrysosporium

The chlorinated pesticide, endosulfan, could be degraded by Phanerochaete chrysosporium under non-ligninolytic conditions, and this did not require direct contact with mycelium. The major metabolites formed were endosulfan sulfate and endosulfan diol. The rate of degradation depended on the initial concentration. With 2.5 mg endosulfan l^–1, degradation was at 0.23 mg l^–1 day^–1. The degradation could be described using a nonlinear rate expression that was similar to the Michaelis–Menten equation.     

Secretome analysis of Phanerochaete chrysosporium strain CIRM-BRFM41 grown on softwood

Proteomic analysis was performed to determine and differentiate the composition of the secretomes of Phanerochaete chrysosporium CIRM-BRFM41, a peroxidase hypersecretory strain grown under ligninolytic conditions and on softwood chips under biopulping conditions. Extracellular proteins from both cultures were analyzed by bidimensional gel electrophoresis and matrix-assisted laser desorption/ionization time-of-flight tandem mass spectrometry. A total of 37 spots were identified. The secretome in liquid synthetic medium comprised mainly peroxidases, while several wood-degrading enzymes and enzymes involved in fungal metabolism were detected in biopulping cultures on softwood. This prompted an analysis of the impact of secretome modulation in the presence of softwood chips. Biotreated wood was submitted to kraft cooking and chemical bleaching using chlorine dioxide. The fungal pre-treatment led to a significant increase in pulp yield and a better bleachability of the pulp. This bleachability improvement could be explained by the production of specific lignocellulose-degrading enzymes.     

A scalable membrane gradostat reactor for enzyme production using Phanerochaete chrysosporium

This is the first demonstration of process scale-up of a membrane gradostat reactor for continuous enzyme production using Phanerochaete chrysosporium ME446. The fungus was immobilised by reverse filtration on to externally unskinned, ultrafiltration capillary membranes and then nutrient gradients were induced across the biofilm. A 10-fold scale-up from a single capillary bioreactor to a 2.4 l multi-capillary unit resulted in a 7-fold increase in enzyme productivity with a peak at 209 U l^–1 d^–1. Subsequent scale effects on the spore distribution, continuous manganese peroxidase production profile and biofilm development are discussed.     

Vanillate hydroxylase from the white rot basidiomycete Phanerochaete chrysosporium

A soluble enzyme fraction from Phanerochaete chrysosporium catalyzed the oxidative decarboxylation of vanillic acid to methoxy-p-hydroquinone. The enzyme, partially purified by ammonium sulfate precipitation, required NADPH and molecular oxygen for activity. NADH was not effective. Optimal activity was displayed between pH 7.5–8.5. Neither EDTA, KCN, NaN₃, nor o-phenanthroline (5 mM) were inhibitory. The enzyme was inducible with maximal activity displayed after incubation of previously grown cells with 0.1% vanillate for 30h.Abbreviations MHQ Methoxy-p-hydroquinone - GLC gas liquid chromatography - TMSi trimethylsilane - TLC thin layer chromatography     

Heterologous expression of lignin peroxidase of Phanerochaete chrysosporium in Pichia methanolica

The cDNA encoding for lignin peroxidase of Phanerochaete chrysosporium was expressed in the Pichia methanolica under the control of the alcohol oxidase (AUG1) promoter which was followed by either the lignin peroxidase leader peptide of Phanerochaete chrysosporium or the Saccharomyces cerevisiae alpha-factor signal peptide. Both peptides efficiently directed the secretion of lignin peroxidase from the recombinant yeast cell. The extracellular lignin peroxidase activity in two recombinants was 932 U l(-1) and 1933 U l(-1). The purity of the recombinant product was confirmed by SDS-PAGE.     

Extracellular ligninolytic enzyme production by Phanerochaete chrysosporium in a new solid-state bioreactor

The production of manganese-dependent peroxidase (MnP) and lignin peroxidase (LiP) by the fungus Phanerochaete chrysosporium (ATCC 24725) in a new bioreactor, the Immersion Bioreactor, which grows cells under solid-state conditions, was studied. Maximum MnP and LiP activities were 987 U l^–1 and 356 U l^–1, respectively. The polymeric dye, Poly R-478, was degraded at 2.4 mg l^–1 min^–1 using the extracellular culture filtrate.     

Utilisation of lignocellulosic wastes for lignin peroxidase production by semi-solid-state cultures of Phanerochaete chrysosporium

In the present work, the production of ligninolytic enzymes by semi-solid-statecultures of Phanerochaete chrysosporium BKM-F-1767 (ATCC 24725),employing different lignocellulosic wastes as support, was investigated. Thewaste materials employed were grape seeds, wheat straw and wood shavings.Maximum lignin peroxidase activities of 1620 ± 123 U/l, 364 ± 35 U/l and 571 ± 42 U/l were attained, respectively. Nevertheless, lowmanganese-dependent peroxidase activities were found, being insignificantin the grape seed cultures. Moreover, the in vivo decolourisation of a model dye compound, the polymeric dye Poly R-478 (polyvinylamine sulfonateanthrapyridone), by the above-mentioned cultures was monitored to assessthe degrading capability of the extracellular liquid secreted by such cultures.The percentage of biological decolourisation attained by grape seed and woodshaving cultures was around 74% and 63%, respectively, whereas it was ratherlow (40%) in the wheat straw ones.     

Ligninolytic system of Phanerochaete chrysosporium: Inhibition by o-Phthalate

The degradation rate of [synthetic-¹⁴C]-lignin to ¹⁴CO₂ by Phanerochaete chrysosporium in cultures buffered with 0.01 M 2,2-dimethylsuccinate (DMS) was twice that in 0.01 M o-phthalate-buffered cultures. This difference could be totally accounted for by o-phthalate inhibition of the activity of the ligninolytic system. ¹⁴CO₂ production from ring-, sidechain-, and methoxyl-labeled lignins was inhibited, the degree of inhibition being dependent on o-phthalate concentration. Oxidations of ¹⁴C-glucose, ¹⁴C-acetovanillone, and ¹⁴C-apocynol were not inhibited; thus o-phthalate is not a general inhibitor, and might inhibit activities involved in attack of the lignin polymer. DMS is a suitable buffer for the ligninolytic system. Degradation rates of ring-labeled lignin to ¹⁴CO₂ of 10–15% in 24 h were obtained consistently over the pH range 3.6–4.5, with an optimum near pH 4.0.Non-Standard Abbreviations DMS dimethylsuccinate     

Production and characterization of cellulolytic and xylanolytic enzymes from the ligninolytic white-rot fungus Phanerochaete chrysosporium grown on sugarcane bagasse

The ligninolytic white-rot fungus Phanerochaete chrysosporium BKM-F-1767 produced extracellular cellulolytic enzymes (carboxymethylcellulase, CMCase and -glucosidase) and xylanolytic enzymes (xylanase and -xylosidase) in liquid medium containing 1.0% sugarcane bagasse with or without 1.0% glucose. The changes in pH and soluble protein content were monitored in the culture filtrates. The results obtained showed that the pH decreased after 3 days and then increased. The soluble protein content increased and reached the maximum value after 12 days. The results showed that the activities of enzymes were higher in the case of sugarcane bagasse without glucose. The characterization study indicated that the optimum pH values were 4.6, 4.2, 5.0 and 5.0 for CMCase, -glucosidase, xylanase and -xylosidase, respectively and the optimum temperatures were 60, 70, 65 and 60 °C for the investigated enzymes, respectively. The results showed also that after prolonged heating (5 h) at 60 °C, CMCase, -glucosidase, xylanase and -xylosidase retained 81.2, 86.8, 51.5 and 27.4% activity, respectively.     

Degradation of pentachlorophenol by the white rot fungus Phanerochaete chrysosporium grown in ammonium lignosulphonate media

Removal and degradation of pentachlorophenol (PCP) by Phanerochaete chrysosporium in static flask cultures was studied using ammonium lignosulphonates (LS), a waste product of the papermill industry, as a carbon and nitrogen source. After 3 days, cultures of P. chrysosporium grown in either a 2% LS (nitrogen-sufficient) medium or a 0.23% LS and 2% glucose (nitrogen-deficient) medium removed 72 to 75% of PCP, slightly less than the 95% removal seen using nitrogen-deficient glucose and ammonia medium. PCP dehalogenation occurred despite the fact that extracellular enzyme (LiP) activity, measured by a veratryl alcohol oxidation assay and by PCP disappearance in cell-free extracts, was inhibited by LS. This inactivation of LiP likely contributed to the lower percent of PCP dehalogenation observed using the LS media. In order to better understand the relationship between PCP disappearance and dehalogenation, we measured the fate of the chlorine in PCP. After 13 days, only 1.8% of the initial PCP added was recoverable as PCP. The remainder of the PCP was either mineralized or transformed to breakdown intermediates collectively identified as organic halides. The largest fraction of the original chlorine (58%) was recovered as organic (non-PCP) halide, most of which (73%) was associated with the cell mass. Of the remaining chlorine, 40% was released as chloride ion, indicating a level of dehalogenation in agreement with previously reported values.     

Remediation of pentachlorophenol-contaminated soil by composting with immobilized Phanerochaete chrysosporium

Summary To reduce and eliminate the hazards of pentachlorophenol (PCP) to the soil, the method of inoculating free and immobilized white rot fungi, Phanerochaete chrysosporium to PCP-polluted soils was investigated. Three parallel beakers A, B, C are adopted with the same components of soil, yard waste, straw and bran for aerated composting to degrade the PCP in soil. A was with no inoculants as control, B was added with the inoculants of immobilized P.␣chrysosporium, C was inoculated with non-immobilized P. chrysosporium, and additionally D contained only PCP-contaminated soils also as control. By contrastive analyses, the feasibility of applying composting to the bioremediation of the PCP-polluted soil was discussed. From the experimental results, it could be seen that the degradation rate of PCP by the immobilized fungi exceeded 50% at day 9, while that of the non-immobilized fungi achieved the same rate at day 16. However, the final degradation rates of PCP for both of them were beyond 90% at day 60 and that the rate of A was much lower than the others. The above data have shown that the degradation effect of inoculating P. chrysosporium was better than that of no inoculation, and that of the immobilized fungi was better than that of non-immobilized ones. Meanwhile, shown by all the indicators the composts of A, B and C were mature and stabilized at the end of the experiment. Therefore, the method of composting with immobilized P.␣chrysosporium is effective for the bioremediation of PCP-contaminated soil.     

Amelioration of ligninolytic enzyme production by Phanerochaete chrysosporium in airlift bioreactors

Maximum activities of manganese-dependent peroxidase (MnP) and lignin peroxidase (LiP) in free cultures of Phanerochaete chrysosporium (ATCC 24725) were 258 U l^–1 and 103 U l^–1, respectively, in an airlift bioreactor. Immobilisation of the fungus on an inert carrier as well as several design modifications of the bioreactor employed gave MnP activities around 500–600 U l^–1 during 9 days' operation. The continuous operation of the latter led to MnP and LiP activities about 140 U l^–1 and 100 U l^–1, respectively, for two months, without operational problems. Furthermore, the extracellular liquid secreted decolourised the polymeric dye Poly R-478 about 56%.     

Protoplast Fusion between Geotrichum candidium and Phanerochaete chrysosporium to Produce Fusants for Corn Stover Fermentation

Lignin impedes the digestion of corn stover when used as an animal feed. Phanerochaete chrysosporium is an efficient lignindegrader. Geotrichum candidum can be used to produce single-cell protein. In this study, protoplasts of the two fungi were prepared and fused. After screening, one of the fusants, Fusant R1, was selected for corn stover fermentation. It decreased lignin from 109 to 54 g/kg and increased protein from 48 to 67 g/kg in corn stover. Comparison with their parental strains indicated that the fusant obtained the lignin-degrading ability from P. chrysosporium and the protein-accumulating ability from G. candidium.     

Impact of pellet size on growth and lignin peroxidase activity of Phanerochaete chrysosporium

We investigated the influence of pellet size on the growth and lignin peroxidase (LiP) productivity of Phanerochaete chrysosporium. Different pellet sizes were obtained by varying the vessel diameter under constant shaking conditions. Under these varying conditions the pellet size was in the range of 2–18 mm, while the number of pellets in a single vessel varied from around 1,200 in the Erlenmeyer flask to around 6 in the narrowest vessel. A correlation between the final pellet size and the shear rate was obtained, demonstrating that the pellet size is mainly affected by hydrodynamics. The growth of large pellets was described by a cubic growth model. Despite different pellet sizes, LiP activity appeared in all vessels, but the onset of LiP activity showed a delay based upon the pellet size, while maximal LiP activities varied by only 15%, being around 850 U/l.     

Enhanced ligninolytic enzyme production and degrading capability of Phanerochaete chrysosporium and Trametes versicolor

Ligninolytic enzyme production by the white-rot fungi Phanerochaete chrysosporium and Trametes versicolor precultivated with different insoluble lignocellulosic materials (grape seeds, barley bran and wood shavings) was investigated. Cultures of Phanerochaete chrysosporium precultivated with grape seeds and barley bran showed maximum lignin peroxidase (LiP) and manganese-dependent peroxidase (MnP) activities (1000 and 1232 U/l, respectively). Trametes versicolor precultivated with the same lignocellulosic residues showed the maximum laccase activity (around 250 U/l). For both fungi, the ligninolytic activities were about two-fold higher than those attained in the control cultures. In vitro decolorization of the polymeric dye Poly R-478 by the extracellular liquid obtained in the above-mentioned cultures was monitored in order to determine the respective capabilities of laccase, LiP and MnP. It is noteworthy that the degrading capability of LiP when P. chrysosporium was precultivated with barley bran gave a percentage of Poly R-478 decolorization of about 80% in 100 s, whereas control cultures showed a lower percentage, around 20%, after 2 min of the decolorization reaction.     

Use of Phanerochaete chrysosporium Immobilized on Kissiris for Synthetic Dye Decolourization: Involvement of Manganese Peroxidase

The mineral Kissiris, which is formed from the thickened foam of volcanic lava, was tested to approximate its mineral composition using energy-dispersive X-ray (EDX) analysis. The solid mineral contains silicon dioxide at about 16 (w/w). The considerable surface roughness of Kissiris along with its extensive porosity made this natural solid cell support an attractive candidate for manganese peroxidase (MnP) production for synthetic dye decolourization, at low cost. The white rot fungus Phanerochaete chrysosporium immobilized on the mineral Kissiris was grown in both stationary and agitated cultures (rotary shaker, 100 rev/min) using either carbon- or nitrogen-limited growth medium to study the ability of the fungus to degrade the synthetic dye methylene blue (MB). The value of residual dye for MB used at 60 ppm was 6% within 8 days of the incubation of the nitrogen-limited culture under the shaken conditions. Production of (MnP) occurred simultaneously in nitrogen-limited culture medium with the added MnSO₄ at 100 ppm. The MnP activity was at relatively high level (170 U/l).     

Metabolism of a phenylcoumaran substructure lignin model compound in ligninolytic cultures of Phanerochaete chrysosporium

The degradation of the phenylcoumaran substructure model compound methyl dehydrodiconiferyl alcohol by the white-rot wood decay fungus Phanerochaete chrysosporium was investigated using culture conditions optimized for lignin oxidation. Initial attack was in the cinnamyl alcohol side chain, which was oxidized to a glycerol structure. This was subsequently converted by loss of the two terminal carbon atoms, C and C, to yield a C-aldehyde structure, which was further oxidized to the C-acid compound. The next detected intermediate, a phenylcoumarone, was produced by double bond formation between C and C, and oxidation of the C-alcohol to an aldehyde group. Further oxidation of C to an acid yielded the next intermediate. The final identified degradation product was veratric acid. No products from the 5-substituted aromatic ring, and no phenolic products, were found. The initial glycerol-containing intermediate was a mixture of the threo and erythro forms, and no optical activity could be found, suggesting that its formation might have involved nonstereospecific C-C epoxidation followed by non-enzymatic hydrolysis of the epoxide.Abbreviations TLC thin layer chromatography - LDA lithium diisopropyl amide - DDQ 2,3-dichloro-5,6-dicyanobenzoquinone - MS mass spectrometry - UV ultraviolet spectroscopy     

Pyranosone dehydratase from the basidiomycete Phanerochaete chrysosporium: improved purification,and identification of 6-deoxy-d-glucosone and d-xylosone reaction products

Pyranose oxidase and pyranosone dehydratase (aldos-2-ulose dehydratase), enzymes which convert in coupled reactions d-glucose to -pyrone cortalcerone, peaked coincidently during idiophasic growth of Phanerochaete chrysosporium under agitated conditions. The enzymes were purified from mycelial extracts of the fungus and separated from each other by hydrophobic interaction chromatography on Phenyl-Sepharose and Phenyl-Superose. Two pyranosone dehydratase activity peaks, PD I and PD II, were resolved. The major PD I fraction, consisting about 74% of the total dehydratase activity, was further purified by anion exchange chromatography on Mono Q to yield apparently pure enzyme as judged by SDS-PAGE and gel filtration on Superose 12. Isoelectric focusing indicated microheterogeneity of the protein by the presence of at least five protein bands with pI 5.1–5.3. PD II had a pI of 5.75. Overall PD I purification was 60.7-fold with 50% yield. The enzyme acted on several osones (glycosuloses), with the preferred substrate being d-glucosone. d-Xylosone and 6-deoxy-d-glucosone were dehydrated at C-3-C-4 to give the corresponding 5-hydroxy-2,3-dioxoalcanals (4-deoxy-2,3-glycosdiuloses), new enzymatically produced sugar derivatives. The latter labile compounds were trapped as diphenylhydrazine or o-phenylenediamine derivatives and spectroscopically identified. The analogous d-glucosone dehydration product did not accumulate due to its further transformation. pH optimum of PD I activity was 6.0 and its pH stability was optimal at pH 7-11. The enzyme was sensitive to Me²⁺ chelating agents and some heavy metal ions (Hg²⁺, Cu²⁺).Abbreviations DMAB 3-dimethylaminobenzoic acid - DTT dithiothreitol - MBTH 3-methyl-2-benzothiazolinone hydrazone-hydrochloride - PD pyranosone dehydratase - PMSF phenylmethylsulfonyl fluoride - POD pyranose oxidase