Physiological regulation and optimization of lipase activity in Pseudomonas aeruginosa EF2.

Physiological regulation of extracellular lipase activity by a newly-isolated, thermotolerant strain of Pseudomonas aeruginosa (strain EF2) was investigated by growing the organism under various conditions in batch, fed-batch and continuous culture. Lipase activity, measured as the rate of olive oil (predominantly triolein) hydrolysis, was weakly induced by general carbon and/or energy limitation, strongly induced by a wide range of fatty acyl esters including triglycerides, Spans and Tweens, and repressed by long-chain fatty acids including oleic acid. The highest lipase activities were observed during the stationary phase of batch cultures grown on Tween 80, and with Tween 80-limited fed-batch and continuous cultures grown at low specific growth rates. The lipase activity of Tween 80-limited continuous cultures was optimized with respect to pH and temperature using response surface analysis; maximum activity occurred during growth at pH 6.5, 35.5 degrees C, at a dilution rate of 0.04 h-1. Under these conditions the culture exhibited a lipase activity of 39 LU (mg cells)-1 and a specific rate of lipase production (qLipase) of 1.56 LU (mg cells)-1 h-1 (1 LU equalled 1 mumol fatty acid released min-1). Esterase activity, measured with p-nitrophenyl acetate as substrate, varied approximately in parallel with lipase activity under all growth conditions, suggesting that a single enzyme may catalyse both activities.     

Extracellular and cell-bound lipase activity in relation to growth of Geotrichum candidum

Summary The imperfect fungus Geotrichum candidum produced extracellular lipase in a basic peptone-salt medium. By adding olive oil or Tween 80 to the basic medium the lipase yields could be enhanced and the maximal yields were found with Tween 80, which resulted in a sixfold increase in extracellular lipase activity as compared with basic medium. During the early phase of growth in medium with olive oil the proportion of cell-bound activity was higher than that of extracellular activity, and a delay in the secretion of extracellular lipase was found. The proportion of cell-bound activity from growth in basic medium and in basic medium with Tween 80 was lower than that of extracellular activity during the entire growth phase. Analyses by polyacrylamide gel electrophoresis showed that the lipase activity from growth in all three media could be ascribed to equivalent protein bands at 57 000 and 61 000 daltons. Immunodiffusion showed that the cell-bound preparation contained lipase that was immunologically identical with purified extracellular lipase from G. candidum.     

Purification and properties of extracellular lipase from Pseudomonas aeruginosa EF2.

Extracellular lipase was purified from a Tween 80-limited continuous culture of Pseudomonas aeruginosa EF2 by ultrafiltration of the culture supernatant followed by anion-exchange and gel-filtration FPLC. The lipase was composed of a single subunit (Mr 29,000, pI 4.9), which was capable of a variable degree of aggregation, and which exhibited both lipase activity, measured with the insoluble substrate olive oil (predominantly triolein), and esterase activity, measured with the soluble substrates p-nitrophenyl acetate and Tween 80. Lipase activity was approximately eight times higher than either type of esterase activity (kcat approximately 3000 s-1 for the hydrolysis of olive oil). The enzyme showed a marked regiospecificity for the 1,3-oleyl residues of radiolabelled triolein, was relatively stable at moderate temperatures (exhibiting a biphasic loss of activity with an initial t1/2 of 17.5 min at 60 degrees C) and was very stable to freezing and thawing. Lipase activity was only weakly inhibited by the serine-active reagent 3,4-dichloroisocoumarin, and was not inhibited by the chelating agent EDTA (1 mM). The N-terminal amino acid sequence of the Ps. aeruginosa EF2 lipase showed a marked similarity to those of several other bacterial lipases.     

Lipase and esterase formation by psychrophilic and mesophilic Acinetobacter species.

Acinetobacter O16, a psychrophilic species, produced extracellular lipase (measured by hydrolysis of olive oil, tributyrin, or beta-naphthyl laurate) when grown on a complex medium (peptone plus yeast extract). Most lipase was produced during the logarithmic phase of growth. Very little cell-bound lipase was formed. These cells also produced an esterase (measured by the hydrolysis of beta-naphthyl acetate). At first, all esterase was cell bound; significant amounts appeared in the external medium late in growth. Breaking the cells did not increase cell-bound lipase activity. After breaking of the cells, most of the cell-bound lipase and esterase activity was solubilized, even after very high speed centrifugation. No appreciable amounts of these enzymes were released by osmotic shock. Lipase formation was greatly affected by nutrient conditions. Lowering either the yeast extract of the peptone content of the normal complex medium lowered or abolished lipase formation. Esterase activity was lowered to a lesser extent. Cells growing in synthetic amino acid plus vitamin medium or in acid-hydrolyzed casein produced substantial amounts of esterase but no cell-free or cell-bound lipase. However, if sodium taurocholate was added to these media, lipase was produced. Greatest production occurred if a mixture of di- and poly-peptides was also present. Taurocholate also stimulated lipase production in the normal complex medium. Adding Tween 80 or ethanol to the normal complex medium inhibited lipase production. Sodium acetate, oleic acid, olive oil, or Tween 20 added to synthetic media did not affect lipase production. The psychrophile grew more quickly at 30 degrees C than at 15 or 20 degrees C but produced more lipase at the lower temperatures. Esterase production was about the same at 20 and 30 degrees C. A mesophilic Acinetobacter species produced the same amount of lipase and esterase at 20 and 30 degrees C. The best production of lipase by the psychrophile occurred in standing cultures.     

High-level heterologous expression and properties of a novel lipase from Ralstonia sp. M1

The mature lipase LipA and its 56aa-truncated chaperone DeltaLipBhis (with 6xhis-tag) from Ralstonia sp. M1 were over-expressed in Escherichia coli BL21 under the control of T7 promoter with a high level of 70 and 12mg protein per gram of wet cells, respectively. The simply purified lipase LipA was effectively refolded by Ni-NTA purified chaperone DeltaLipBhis in molar ratio 1:1 at 4 degrees C for 24 hours in H2O. The in vitro refolded lipase LipA had an optimal activity in the temperature range of 50-55 degrees C and was stable up to 45 degrees C with more than 84% activity retention. The maximal activity was observed at pH 10.75 for hydrolysis of olive oil and found to be stable over alkaline pH range 8.0-10.5 with more than 52% activity retention. The enzyme was found to be highly resistant to many organic solvents especially induced by ethanolamine (remaining activity 137-334%), but inhibited by 1-butanol and acetonitrile (40-86%). Metal ions Cu2+, Sn2+, Mn2+, Mg2+, and Ca2+ stimulated the lipase slightly with increase in activity by up to 22%, whereas Zn2+ significantly inhibited the enzyme with the residual activity of 30-65% and Fe3+ to a lesser degree (activity retention of 77-86%). Tween 80, Tween 60, and Tween 40 induced the activation of the lipase LipA (222-330%) and 0.2-1% (w/v) of Triton X-100, X-45, and SDS increased the lipase activity by up to 52%. However, 5% (w/v) of Triton X-100, X-45, and SDS inhibited strongly the activity by 31-89%. The inhibitors including DEPC, EDTA, PMSF, and 2-mercaptoethanol (0.1-10mM) inhibited moderately the lipase with remaining activity of 57-105%. The lipase LipA hydrolyzed a wide range of triglycerides, but preferentially short length acyl chains (C4 and C6). In contrast to the triglycerides, medium length acyl chains (C8 and C14) of p-nitrophenyl (p-NP) esters were preferential substrates of this lipase. The enzyme preferentially catalyzed the hydrolysis of cottonseed oil (317%), cornoil (227%), palm oil (222%), and wheatgerm oil (210%) in comparison to olive oil (100%).     

Specificity of a Tween-Lipase in Hydrolysis of Olive Oil

A specific lipase for the hydrolysis of Tween present in a Sclerotinia lipase preparation was fractionated by various extraction procedures, ion-change resin treatment and dialysis. The activity of the Tween-lipase on olive oil was significant in Increasing the hydrolysis of the olive oil by combination with various other lipases. Also, it seemed to develop with the change in the state of emulsion of the reaction mixture during hydrolysis.     

Differential induction, purification and characterization of cold active lipase from Yarrowia lipolytica NCIM 3639

The production, purification and characterization of cold active lipases by Yarrowia lipolytica NCIM 3639 is described. The study presents a new finding of production of cell bound and extracellular lipase activities depending upon the substrate used for growth. The strain produced cell bound and extracellular lipase activity when grown on olive oil and Tween 80, respectively. The organism grew profusely at 20 °C and at initial pH of 5.5, producing maximum extracellular lipase. The purified lipase has a molecular mass of 400 kDa having 20 subunits forming a multimeric native protein. Further the enzyme displayed an optimum pH of 5.0 and optimum temperature of 25 °C. Peptide mass finger printing reveled that some peptides showed homologues sequence (42%) to Yarrowia lipolytica LIP8p. The studies on hydrolysis of racemic lavandulyl acetate revealed that extracellular and cell bound lipases show preference over the opposite antipodes of irregular monoterpene, lavandulyl acetate.     

Lipase production from a novel thermophilic Bacillus sp.: application of Plackett-Burman design for evaluating culture conditions affecting enzyme formation

A novel thermophilic Bacillus sp. capable of producing lipase was locally isolated. Phylogenetic analysis based on 16SrDNA sequence revealed its close relationship to Bacillus thermoleovorans. Plackett-Burman experimental design was used to evaluate cultural conditions affecting lipase production process. Fifteen variables and four dummy variables were examined in the experimental design. Tween 80, temperature, olive oil, aeration, beef extract and inoculum age were found to be the highest positive significant variables affecting lipase activity, whereas pH and calcium chloride were the highest negative significant variables. Moreover, Tween 80, temperature and olive oil positively affected lipase specific activity. On the other hand, gum arabic, inoculum size and calcium chloride had the highest negative effect on lipase specific activity. This study would improve the further optimization steps on the bioprocess development track.     

The esterase profile of a lipase from Candida cylindracea

A commercial preparation of a lipase produced by Candida cylindracea catalysed the hydrolysis of both long- and short-chain esters of p-nitrophenol. Six major bands of hydrolytic activity to alpha-naphthyl acetate were detected on polyacrylamide gel electrophoresis and two on isoelectric focusing. The esterase activity fractionated into two major peaks of activity on ion-exchange chromatography and into several peaks of activity on hydrophobic interaction chromatography. These esterase activities showed different substrate specificities to p-nitrophenyl esters, tributyrin and cetyl palmitate.     

Non-lipolytic and lipolytic sequence-related carboxylesterases: A comparative study of the structure–function relationships of rabbit liver esterase 1 and bovine pancreatic bile-salt-activated lipase

To differentiate esterases from lipases at the structure–function level, we have compared the kinetic properties and structural features of sequence-related esterase 1 from rabbit liver (rLE) and bile-salt-activated lipase from bovine pancreas (bBAL). In contrast to rLE, bBAL hydrolyses water-insoluble medium and long chain esters as vinyl laurate, trioctanoin and olive oil. Conversely, rLE and bBAL are both active on water-soluble short chain esters as vinyl acetate, vinyl propionate, vinyl butyrate, tripropionin, tributyrin and p-nitrophenyl butyrate. However, the enzymes show distinctive kinetic behaviours. rLE displays maximal activity at low substrate concentration, below the critical micelle concentration, whereas bBAL acts preferencially on emulsified esters, at concentration exceeding the solubility limit. Comparison of the 3D structures of rLE and bBAL shows, in particular, that the peptide loop at positions 116–123 in bBAL is deleted in rLE. This peptide segment interacts with a bile salt molecule thus inducing a conformational transition which gives access to the active site. Inhibition studies and manual docking of a bulky ester molecule as vinyl laurate in the catalytic pocket of rLE and bBAL show that the inability of the esterase to hydrolyse large water-insoluble esters is not due to steric hindrance. It is hypothesized that esterases lack specific hydrophobic structures involved both in the stabilization of the lipase–lipid adsorption complex at interfaces and in the spontaneous transfer of a single substrate molecule from interface to the catalytic site.     

Optimization of thermostable lipase production from a thermophilic Geobacillus sp. using Box-Behnken experimental design

Thermostable lipase production by Geobacillus thermoleovorans was optimized in shake-flask cultures using Box-Behnken experimental design. An empirical model was developed through response surface methodology to describe the relationship between tested variables (Tween 80, olive oil, temperature and pH) and enzyme activity. Maximum enzyme activity (495 U l^–1) was attained with Tween 80 at 5 g l^–1; olive oil at 60 g l^–1; 70 °C and pH 9. Experimental verification of the model showed a validation of 95%, which is more than 4-fold increase compared to the basal medium.     

Phospholipid and fatty acid enrichment of Phanerochaete chrysosporium INA-12 in relation to ligninase production

Summary Ligninase activity of Phanerochaete chrysosporium INA-12 was increased when vegetable oils emulsified with sorbitan polyoxyethylene monooleate (Tween 80) were added to growth medium. Maximal enzyme yield was 22.0 nkat·ml^-1 in olive oil cultures after 4 days incubation. P. chrysosporium INA-12 was also able to utilize tall oil fatty acids for ligninase synthesis. An extracellular lipase activity was detected during the primary phase of growth in culture containing vegetable oils. On the other hand, ligninase production was 1.5-fold enhanced when olive oil cultures were supplemented with soybean asolectin as a phospholipid source. In cultures supplied with olive oil plus asolectin, P. chrysosporium INA-12 mycelium exhibited a preferential enrichment of oleic acid (C18:1), phosphatidylcholine (PC) and lysophosphatidylcholine (LPC) as compared to lipid-free medium. PC and LPC enrichment was associated with an increased ratio of saturated versus unsaturated fatty acids of phospholipids.     

Evaluation of immobilized lipases on poly-hydroxybutyrate beads to catalyze biodiesel synthesis

Five microbial lipase preparations from several sources were immobilized by hydrophobic adsorption on small or large poly-hydroxybutyrate (PHB) beads and the effect of the support particle size on the biocatalyst activity was assessed in the hydrolysis of olive oil, esterification of butyric acid with butanol and transesterification of babassu oil (Orbignya sp.) with ethanol. The catalytic activity of the immobilized lipases in both olive oil hydrolysis and biodiesel synthesis was influenced by the particle size of PHB and lipase source. In the esterification reaction such influence was not observed. Geobacillus thermocatenulatus lipase (BTL2) was considered to be inadequate to catalyze biodiesel synthesis, but displayed high esterification activity. Butyl butyrate synthesis catalyzed by BTL2 immobilized on small PHB beads gave the highest yield (≈90 mmol L(-1)). In biodiesel synthesis, the catalytic activity of the immobilized lipases was significantly increased in comparison to the free lipases. Full conversion of babassu oil into ethyl esters was achieved at 72 h in the presence of Pseudozyma antarctica type B (CALB), Thermomyces lanuginosus lipase (Lipex(?) 100 L) immobilized on either small or large PHB beads and Pseudomonas fluorescens (PFL) immobilized on large PHB beads. The latter preparation presented the highest productivity (40.9 mg of ethyl esters mg(-1) immobilized protein h(-1)).     

Lipase production by free and immobilized protoplasts of Sporotrichum (Chrysosporium) thermophile Apinis

Summary Production of lipase by free and alginate-entrapped protoplasts was studied in batch culture. Cell-wall-degrading enzymes Novozym 234 and cellulase CP improved lipase secretion of normal mycelium by 25%–100%. The protoplast-regenerated mycelium exhibited several-fold higher lipase activity in batch replacements in TRIS buffer over normal spore-derived mycelium. The specific lipase activity of immobilized protoplasts was about four times higher than normal mycelial beads. Protoplasts beads were stable and retained high enzyme activity even after three buffer replacements lasting 120 h; TRIS buffer was better than acetate or normal glucose medium. A minimum of 8 h regeneration period was necessary for lipase synthesis. Triolein, olive oil, tributyrin and oleic acid butylester were able to induce lipase in immobilized protoplasts. Tween 80 enhanced lipase activity of the immobilized protoplasts. Partially degraded immobilized mycelium was nearly as effective as normal immobilized protoplasts for lipase secretion. Both free and immobilized protoplasts could be reused for up to 200 h with some loss in enzyme activity.     

Characteristics of immobilized lipase-catalyzed hydrolysis of olive oil of high concentration in reverse phase system

Candida rugosa lipase immobilized by adsorption on swollen Sephadex LH-20 could almost completely hydrolyze 60% (v/v) olive oil in isooctane. Kinetic analysis of the lipase-catalyzed hydrolysis reaction was found to be possible in this system. Amount of fatty acids produced was linearly proportional to the enzyme concentration of 720 mug/g wet gel. The specific enzyme activity was 217 units/mg protein at 60% (v/v) olive oil concentration. When the initial rate is plotted versus concentration of olive oil, this system did not follow Michaelis-Menten kinetics. Maximum activity was obtained at pH 7, but optimum temperature shifted towards higher one with the increase of olive oil concentration. Among the various chemical compounds tested, Hg(2+) and Fe(2+) inhibited the lipase seriously. As the concentration of olive oil increased, the rate of the hydrolysis also increased, but degree of the hydrolysis was observed to decrease. The supply of water from the inside of the gel to the surface of the gel was the main factor for the control of the rate of hydrolysis in batch hydrolysis. The immobilized lipase was used to hydrolyze olive oil two times. Achievement of chemical equilibrium took a longer time with the addition of water and the degree of hydrolysis decreased in the second consecutive trial. After the second hydrolysis trial, the gels were regenerated in a packed column first by eluting out both residual fatty acids around the gel particles and the accumulated glycerol with ethanol and then with 0.05M phosphate buffer, pH 7. The immobilized lipase on the regenerated gel showed the same hydrolysis activity as the original one.     

Influence of carbon and nitrogen sources on lipase production by a newly isolated Candida viswanathii strain

Microorganisms can produce lipases with different biochemical characteristics making necessary the screening of new lipase-producing strains for different industrial applications. In this study, 90 microbial strains were screened as potential lipase producers using a sensitive agar plate method with a suitable medium supplemented with Tween 20 and also a liquid culture supplemented with olive oil. The highest cell growth and lipase production for Candida viswanathii were observed in triolein and oleic acid when used as the only pure carbon source. Renewable low-cost triacylglycerols supported the best cell growth, and olive oil was found to be the best inducer for lipase production (19.50 g/L and 58.50 U). The selected conditions for enzyme production were found with yeast extract as nitrogen source and 1.5 % (w/v) olive oil (85.70 U) that resulted in a good cell growth yield (Y_X/S?=?1.234 g/g) and lipase productivity (1.204 U/h) after 72 h of shake-flask cultivation. C. viswanathii lipase presented high hydrolytic activity on esters bonds of triacylglycerols of long-chain, and this strain can be considered an important candidate for future applications in chemical industries.     

Utilization of powdered pig bone as a support for immobilization of lipase

Pig bone was examined for its suitability as a support material for lipase immobilization. It was observed that pig bone (PB) particles dispersed readily in both polar and nonpolar solvents, and lipase was easily adsorbed. In particular lipase adsorbed on olive oil-soaked pig bone (OPB) particles exhibited a higher hydrolytic activity than that in lipase adsorbed on a selection of other representative supports, regardless of removing the presoaked olive oil from the particles after immobilization of lipase. The optimum pH and temperature for hydrolytic activity of OPB-adsorbed lipase were the same as those for free lipase, although thermal resistance was increased by immobilization. When OPB-adsorbed lipase was used for repeated batch reactions of olive oil hydrolysis, an activity of more than 80% of the initial activity of each run could he retained after 46 h reaction. The results suggest that PB is an excellent support material.     

Mycelium-bound carboxylesterase from Aspergillus oryzae: an efficient catalyst for acetylation in organic solvent

Dry mycelium of a strain of Aspergillus oryzae efficiently catalyzed the esterification between free acetic acid and primary alcohols (geraniol and ethanol) in organic solvent. The growth conditions to obtain high activity of mycelium-bound enzymes were firstly evaluated. A medium containing Tween 80 as carbon source furnished mycelium with the highest activity in the hydrolysis of alpha-naphthyl esters (alpha-N-acetate, butyrate, caprylate). Dry mycelium was employed to select suited conditions for an efficient acetylation of ethanol and geraniol in heptane. Maximum productions were obtained using 30 g l(-)(1) of lyophilized cells: 12.4 g l(-)(1) of geranyl acetate were produced at 80 degrees C starting from 75 mM geraniol and acetic acid (84% molar conversion) and 4.1 g l(-)(1) of ethyl acetate at 50 degrees C from 50 mM ethanol and acetic acid (94% molar conversion) after 24 h. The stability of the mycelium-bound carboxylesterases are notable since only 10-30% loss of activity was observed after 14 days at temperatures between 30 and 50 degrees C.     

Production and activity of extracellular lipase from Luteibacter sp.

Microbial lipases are widely used in industrial applications due to their versatility, and the characterization of new lipase-producing microorganisms could provide new sources of these enzymes, with different specificities and better activities. In this context, we have improved lipase production by Luteibacter sp. by using basal medium supplemented with 2 % olive oil, a pH of 6 and a growth temperature of 37 °C. The enzyme extraction process with the addition of 0.25 % Tween 80 increased lipase activity. Implementation of these modifications increased lipase activity by approximately 430 %. The lipase activities produced in the culture supernatant (LCS) and extracted with Tween 80 (LCST80) were characterized. Both extracts hydrolyzed ρ-nitrophenyl (ρNP) esters with different acyl chain lengths, with a preference for short acyl lengths, and had optimum activity at 45 °C. The LCS was stable at acidic and alkaline pH, but LCST80 was only stable at alkaline pH. Methanol, SDS, Triton X-100, EDTA, and EGTA did not affect lipase activity, while divalent cations (Ca²⁺, Zn²⁺, Mg²⁺) - with the exception of Co²⁺— increased lipase activity. Both extracts showed transesterification activity on ρNP ester substrates, and both were able to hydrolyze different natural lipids. The characterization of lipase produced by Luteibacter sp. introduces this recently described genus as a new source of lipases with great biotechnological potential.