A new Tunisian strain of <Emphasis Type="Italic">Bacillus thuringiensis</Emphasis><Emphasis Type="Italic">kurstaki</Emphasis> having high insecticidal activity and δ-endotoxin yield

BLB1 is a new Bacillus thuringiensis kurstaki strain, isolated from a Tunisian soil sample. Assay of toxicity of BLB1 crystal proteins resulted in an LC50 of 70.32 ng of toxin per mg of flour against third instar Ephestia kuehniella with confidence limits of (31.6–109.04 ng). This LC50 is less than that of the commercial strains HD1 used as a reference. The characterization of this strain by scanning transmission electron microscopy, analysis of its cry genes content by PCR-sequencing, and analysis of its δ-endotoxin patterns demonstrate that it belongs to the same subgroup than HD1, but ruled out the involvement of cry gene content or protoxin activation in the hypertoxicity of this strain. Taking into account the δ-endotoxin/spore ratio for each strain, and by allowing the estimation of the production level per spore, it might be concluded that BLB1 production is the highest, when compared with that of HD1. On the basis of its toxicity, BLB1 could be considered as a strain of great interest and would allow the production of quantities of bioinsecticides at low cost.     

Evidence of the Involvement of E358, A498 and C571 of a New Cry1Ac δ-endotoxin of <Emphasis Type="Italic">Bacillus thuringiensis</Emphasis> in its High Insecticidal Activity Against <Emphasis Type="Italic">Ephestia kuehniella</Emphasis>

A new cry1Ac-type gene was cloned from Bacillus thuringiensis strain BLB1, sequenced and expressed. The deduced amino acid sequence of the polypeptide has a predicted molecular mass of 132.186 kDa. The amino acid sequence alignment of BLB1 Cry1Ac with those of the published ones showed that this is a new delta-endotoxin. When compared with Cry1Ac of Bacillus thuringiensis strain HD1, it was found that BLB1 Cry1Ac harbours three mutations: V358E localized in domain II and V498A and Y571C localized in domain III. When the BLB1 Cry1Ac toxin was expressed in an acrystalliferous strain of B. thuringiensis (HD1CryB), bipyramidal crystals were produced. The spore–crystal mixture of this recombinant strain was at least two-fold more active against larvae of the lepidopteran Ephestia kuehniella than that of the recombinant strain expressing Cry1Ac of HD1. The study of the structural effect of these mutations suggested that they may stabilize key regions involved in the binding of the domains II and III to insect receptors.     

Isolation and characterization of a new Bacillus thuringiensis strain Lip harboring a new cry1Aa gene highly toxic to Ephestia kuehniella (Lepidoptera: Pyralidae) larvae

The aim of this study was to characterize new Bacillus thuringiensis strains that have a potent insecticidal activity against Ephestia kuehniella larvae. Strains harboring cry1A genes were tested for their toxicity, and the Lip strain showed a higher insecticidal activity compared to that of the reference strain HD1 (LC₅₀ of Lip and HD1 were 33.27 and 128.61 μg toxin/g semolina, respectively). B. thuringiensis Lip harbors and expresses cry1Aa, cry1Ab, cry1Ac, cry1Ad and cry2A. DNA sequencing revealed several polymorphisms in Lip Cry1Aa and Cry1Ac compared to the corresponding proteins of HD1. The activation process using Ephestia kuehniella midgut juice showed that Lip Cry1A proteins were more stable in the presence of larval proteases. Moreover, LipCry1A proteins exhibited higher insecticidal activity against these larvae. These results indicate that Lip is an interesting strain that could be used as an alternative to the worldwide used strain HD1.     

Investigation of the steps involved in the difference of susceptibility of Ephestia kuehniella and Spodoptera littoralis to the Bacillus thuringiensis Vip3Aa16 toxin

BUPM95 is a Bacillusthuringiensis subsp. kurstaki strain producing the Vip3Aa16 toxin with an interesting insecticidal activity against the Lepidopteran larvae Ephestia kuehniella. Study of different steps in the mode of action of this Vegetative Insecticidal Protein on the Mediterranean flour moth (E. kuehniella) was carried out in the aim to investigate the origin of the higher susceptibility of this insect to Vip3Aa16 toxin compared to that of the Egyptian cotton leaf worm Spodoptera littoralis. Using E. kuehniella gut juice, protoxin proteolysis generated a major band corresponding to the active toxin and another band of about 22 kDa, whereas the activation of Vip3Aa16 by S. littoralis gut juice proteases generated less amount of the 62 kDa active form and three other proteolysis products. As demonstrated by zymogram analysis, the difference in proteolysis products was due to the variability of proteases in the two gut juices larvae. The study of the interaction of E. kuehniella BBMV with biotinylated Vip3Aa16 showed that this toxin bound to a putative receptor of 65 kDa compared to the 55 and 100 kDa receptors recognized in S. littoralis BBMV. The histopathological observations demonstrated similar damage caused by the toxin in the two larvae midguts. These results demonstrate that the step of activation, mainly, is at the origin of the difference of susceptibility of these two larvae towards B. thuringiensis Vip3Aa16 toxin.     

Correlation between delta-endotoxin and proteolytic activities produced by Bacillus thuringiensis var. kurstaki growing in an economic production medium

Abstract

Bacillus thuringiensis is a Gram positive bacterium that produces an insecticidal crystalline protein making it one of the most important biocontrol agents for pest management. Bioinsecticides based on B. thuringiensis were produced by fermentation processes in liquid media. Cultural conditions controlling proteolytic activities in different culture media were investigated to study the possible correlations between B. thuringiensis production of proteases and delta-endotoxins in a low-cost complex medium. Aeration appeared to play an important role in delta-endotoxin production. The correlation between proteolytic activity and aeration does not seem to be reliable. A negative correlation (correlation coefficient =? 0.774) was established between protease activity and delta-endotoxin production. In order to prove this correlation, protease hypo-producing and overproducing mutants were isolated through random mutagenesis of two wild strains, BUPM13 and BUPM5, by using nitrous acid. Interestingly, delta-endotoxin production of BUPM13-1, BUPM13-2 and BUPM13-3 was markedly improved when compared to the wild strain BUPM 13, reaching 2.1-fold, 3.69-fold and 8.13-fold, respectively. Maximal protease activity (540-2468 UI) obtained by BUPM5-1 and BUPM5-2 was 2.34-fold and 10.7-fold, respectively, more than that obtained by the wild strain BUPM5 with a drastic decrease of their delta-endotoxin production. Study of delta-endotoxin production by the selected mutants confirmed that insecticidal crystal protein stability in the culture strongly depends on the level of endogenous protease activity. This was also confirmed by bioassays measuring the LC₅₀ using larvae of Ephestia kuehniella. Determining protease activity in fermentation culture could be useful in indirectly predicting the potency of B. thuringiensis strains with high insecticidal activities. This would allow low-cost selection of overproducing wild isolates or mutants in the screening programmes for the reduction of production cost, which is important from a practical point of view.     

The synergic and antagonistic activity of Cry1Ab and Cry2Aa proteins against lepidopteran pests

Cry1Ab and Cry2Aa were overexpressed in Escherichia coli BL21(DE3), and their proportions were determined for evaluating their synergic and antagonistic interactions on Ephestia kuehniella and Plodia interpunctella. Results indicated antagonistic interaction on both lepidopteran pests, and it was concluded that 1 : 1 combination of Cry1Ab:Cry2Aa should be avoided in control programmes for these larvae.     

Assessment of protoxin composition of <Emphasis Type="Italic">Bacillus thuringiensis</Emphasis> strains by use of polyacrylamide gel block and mass spectrometry

Assessment of protoxin composition in Bacillus thuringiensis parasporal crystals is principally hampered by the fact that protoxins in a single strain usually possess high sequence homology. Therefore, new strategies towards the identification of protoxins have been developed. Here, we established a powerful method through embedding solubilized protoxins in a polyacrylamide gel block coupled to liquid chromatography-tandem mass spectrometry (LC-MS/MS) analysis of in-gel-generated peptides for protoxin identification. Our model study revealed that four protoxins (Cry1Aa, Cry1Ab, Cry1Ac and Cry2Aa) and six protoxins (Cry4Aa, Cry4Ba, Cry10Aa, Cry11Aa, Cyt1Aa, and Cyt2Ba) could be rapidly identified from B. thuringiensis subsp. kurstaki HD1 and subsp. israelensis 4Q2-72, respectively. The experimental results indicated that our method is a straightforward tool for analyzing protoxin expression profile in B. thuringiensis strains. Given its technical simplicity and sensitivity, our method might facilitate the present screening program for B. thuringiensis strains with new insecticidal properties. Electronic supplementary material  The online version of this article (doi:) contains supplementary material, which is available to authorized users. Zujiao Fu and Yunjun Sun contributed equally to this work.     

Efficient transformation of Bacillus thuringiensis and B. cereus via electroporation: Transformation of acrystalliferous strains with a cloned delta-endotoxin gene

Summary Electroporation was used as a method to transform intact cells of Bacillus thuringiensis and B. cereus. With our optimized method a range of plasmid vectors could be transformed into strains of B. thuringiensis at frequencies of up to 10⁷ transformants/g DNA. This high frequency allows cloning experiments to be bone directly in B. thuringiensis. A bifunctional vector capable of replicating in Escherichia coli and in Bacillus spp. was constructed. The kurhd1 protoxin gene was cloned into this shuttle vector to produce plasmid pXI93, then transformed into B. thuringiensis HDl cryB and B. cereus 569K. The cloned protoxin gene was expressed in sporulating cultures of both strain HD1 cryB (pXI93) and 569K (pXI93), producing crystal protein active in biotests against larvae of Heliothis virescens. This demonstrates the usefulness of the electroporation method for the introduction of cloned toxin genes, in either their native or modified form, into a variety of host strains.     

New Bacillus thuringiensis strain isolated from the gut of Malabari goat is effective against Tetranychus macfarlanei

This study illustrates a novel strain (designated as BPU5) of Bacillus thuringiensis (Bt) isolated from the rumen of Malabari goat, capable of producing polymorphic δ‐endotoxin crystals concomitantly with sporulation in Luria–Bertani medium (LB), and the δ‐endotoxin was efficient to combat Tetranychus macfarlanei, a devastating mite. Polymorphic δ‐endotoxin crystals produced were assessed by scanning electron microscopy and monitored its production concomitantly with sporulation in LB with or without sugar supplements. Toxicity of the δ‐endotoxin was assessed on T. macfarlanei using leaf disc bioassay method. Mortality rate was determined by comparing the survival of mites on the diet (prepared in 10% sucrose and powdered rice husk) containing different concentrations (1–10 mg/ml) of 72‐h‐old crude pellet (dried mixture of δ‐endotoxin (17 mg/g pellet), endospores and a few vegetative cells) or control diet with autoclaved pellet. The maximum production (1.39 mg/ml) of δ‐endotoxin was observed at 72 h in LB. Among the sugars (glucose, sucrose, maltose or lactose) tested as additional carbon source, glucose (8 g/l) enhanced (1.82 mg/ml) the production of δ‐endotoxin by 30%. The lethal concentration (LC₅₀) required to kill 50% mites was estimated as 8.024 mg/ml. The δ‐endotoxin produced by B. thuringiensis BPU5 is shown to efficiently combat T. macfarlanei, a devastating mite infesting agricultural fields.     

Interactions of Bacillus thuringiensis bioinsecticides and the predatory stink bug Podisus nigrispinus to control Plutella xylostella

The diamondback moth (DBM), Plutella xylostella (L.), is a major pest of brassica crops worldwide. Control of this pest is difficult because it rapidly develops resistance to synthetic and biological insecticides and because of the effects of insecticides on its natural enemies. Podisus nigrispinus (Dallas) is a predator that feeds on its prey, as well as on the host plants of its prey, and is an important biological control agent of DBMs. The aim of this study was to determine the susceptibility of P. xylostella larvae to two bioinsecticides: the HD1 strain of Bacillus thuringiensis (B. thuringiensis var. kurstaki) and the commercial product Agree^® (B. thuringiensis var. aizawai CG 91). In addition, the impact of these bioinsecticides on the P. nigrispinus consumption of DBM larvae and phytophagy was evaluated. Both the HD1 strain and Agree^® caused 100% mortality in P. xylostella larvae. P. nigrispinus nymphs fed only with kale leaves (Brassica oleracea var. acephala) sprayed with water, the HD1 strain, or Agree^® did not complete their nymphal development. When prey was also available, P. nigiripinus fed on kale leaves to obtain water. Both nymphs and adults of P. nigrispinus consumed greater numbers of DBM larvae, and fed less on kale leaves, when sprayed with the HD1 strain or Agree^®. These results suggest a positive interaction of B. thuringiensis‐based products and the predator P. nigrispinus in the control of P. xylostella larvae.     

Insecticidal activity of spore-free mutants of Bacillus thuringiensis against the Indian meal moth and almond moth

Three oligosporogenic mutants of Bacillus thuringiensis were assayed for toxicity against larvae of the Indian meal moth, Plodia interpunctella, and the almond moth, Ephestia cautella. The results were compared with insecticidal activity obtained from the parent strain (HD-1) and two standard B. thuringiensis formulations (HD-1-S-1971 and HD-1-S-1980) against the same insect species. The toxicity of the sporeless mutant preparations was significantly diminished against the Indian meal moth (10- to 26-fold increase in LC₅₀) but exceeded the toxicity of the standards against the almond moth. The toxicities of the B. thuringiensis preparations toward the Indian meal moth were consistent with the number of spores in the test samples, but spores did not contribute to toxicity to E. cautella larvae. A rationale for basing dosage on soluble protein was demonstrated for use in situations where spores are not a contributing factor in toxicity.     

Increase in Insecticidal Toxicity by Fusion of the <Emphasis Type="Italic">cry1Ac</Emphasis> Gene from <Emphasis Type="Italic">Bacillus thuringiensis</Emphasis> with the Neurotoxin Gene <Emphasis Type="Italic">hwtx-I</Emphasis>

A fusion gene was constructed by combining the cry1Ac gene of Bacillus thuringiensis strain 4.0718 with a neurotoxin gene, hwtx-1, which was synthesized chemically. In this process, an enterokinase recognition site sequence was inserted in frame between two genes, and the fusion gene, including the promoter and the terminator of the cry1Ac gene, was cloned into the shuttle vector pHT304 to obtain a new expression vector, pXL43. A 138-kDa fusion protein was mass-expressed in the recombinant strain XL002, which was generated by transforming pXL43 into B. thuringiensis acrystalliferous strain XBU001. Quantitative analysis indicated that the expressed protein accounted for 61.38% of total cellular proteins. Under atomic force microscopy, there were some bipyramidal crystals with a size of 1.0 × 2.0 μm. Bioassay showed that the fusion crystals from recombinant strain XL002 had a higher toxicity than the original Cry1Ac crystal protein against third-instar larvae of Plutella xylostella, with an LC₅₀ (after 48 h) value of 5.12 μg/mL. The study will enhance the toxicity of B. thuringiensis Cry toxins and set the groundwork for constructing fusion genes of the B. thuringiensis cry gene and other foreign toxin genes and recombinant strains with high toxicity. LiQiu Xia and XiaoShan Long contributed equally to this work.     

Heterologous Expression of Bacillus thuringiensis Vegetative Insecticidal Protein-Encoding Gene vip3LB in Photorhabdus temperata Strain K122 and Oral Toxicity against the Lepidoptera Ephestia kuehniella and Spodoptera littoralis

Photorhabdus temperata and Bacillus thuringiensis are entomopathogenic bacteria exhibiting toxicities against different insect larvae. Vegetative Insecticidal Protein Vip3LB is a Bacillus thuringiensis insecticidal protein secreted during the vegetative growth stage exhibiting lepidopteran specificity. In this study, we focused for the first time on the heterologous expression of vip3LB gene in Photorhabdus temperata strain K122. Firstly, Western blot analyses of whole cultures of recombinant Photorhabdus temperata showed that Vip3LB was produced and appeared lightly proteolysed. Cellular fractionation and proteinase K proteolysis showed that in vitro-cultured recombinant Photorhabdus temperata K122 accumulated Vip3LB in the cell and appeared not to secrete this protein. Oral toxicity of whole cultures of recombinant Photorhabdus temperata K122 strains was assayed on second-instar larvae of Ephestia kuehniella, a laboratory model insect, and the cutworm Spodoptera littoralis, one of the major pests of many important crop plants. Unlike the wild strain K122, which has no effect on the larval growth, the recombinant bacteria expressing vip3LB gene reduced or stopped the larval growth. These results demonstrate that the heterologous expression of Bacillus thuringiensis vegetative insecticidal protein-encoding gene vip3LB in Photorhabdus temperata could be considered as an excellent tool for improving Photorhabdus insecticidal activities.     

Virulence of some native Bacillus thuringiensis isolates against Ephestia kuehniella (Zeller) (Lep., Pyralidae) and Pieris brassicae (Lep., Pieridae) larvae isolated from stored products of Urmia city

Bacillus thuringiensis isolates were recovered from numerous sources including soil, grain dust, plant leaves, diseased insect larvae from insectariums and sericulture environments. B. thuringiensis strains were isolated using acetate selection method with 0.025?M. concentration. The morphology of crystals was studied using light microscopy. Bioassay tests were conducted on Ephestia kuehniella (Zeller) (L.) as well as Pieris brassicae (L.). Based on the results, 35 B. thuringiensis strains were isolated from 140 samples. Majority of strains (%31.42) had bipyramidal crystals. There was a significant difference in toxicity to insects among B. thuringiensis isolates; 28.57 and 14.28% of the isolates were toxic to the larvae of P. brassicae and E. kuehniella, respectively, causing more than 50% mortality. Results indicated that B. thuringiensis isolates with insecticidal activity could be used in integrated pest management to control farm and stored product pests.     

Isolation and characterization of a Serratia marcescens with insecticidal activity from Polyphylla olivieri (Col.: Scarabaeidae)

Members of the genus Serratia are known for their abilities to infect insects. In this study, a red‐pigmented S. marcescens was isolated and characterized from the infected larvae of Polyphylla olivieri using bacterial cultivation, phylogenetic analysis as well as bioassays against larvae of the two insect pests, Plodia interpunctella and Ephestia kuehniella. Comparative 16S rRNA and groEL gene sequence BLAST analyses strongly suggested that the isolated strain should be placed in the genus Serratia, sharing high sequence similarities with several strain of S. marcescens associated with insects. Phylogenetic analysis placed the isolated bacterium with other S. marcescens bacteria in a clade with high bootstrapping values. To assess pathogenicity of the S. marcescens isolate, the bacterial cells were either injected into the haemolymph of the fifth‐instar larvae or added to the diets of insects. Survival curves of the control insects and those challenged with six different concentrations of S. marcescens showed that the S. marcescens isolate significantly reduced survival rates of the larvae. The LC₅₀s of the bacterium on P. interpunctella and E. kuehniella were 1992.26 and 1.09 × 10⁴ (CFU/μl) for injection bioassays at 6 h post‐injection, and 4.48 × 10⁴ and 1.96 × 10⁵ (CFU/10 μl) for feeding bioassays at 24 h post‐feeding, respectively. Injection of the bacterial culture supernatant into the larvae led to continuous bleeding from the site of injection, while injection of heat‐treated culture supernatant of the bacterium did not cause continuous bleeding. Together, our results showed the possibility of using this S. marcescens isolate in microbial control of the insect pests after addressing the safety concerns. Moreover, it might be considered as a source of useful bioactive molecules and genes with application in insect control and biotechnology via developing insect‐resistant plants.     

Sensitivity of polyphagous (Plodia interpunctella) and stenophagous (Ephestia kuehniella) storage moths to residual insecticides: effect of formulation and larval age

Pyralid moths, Ephestia kuehniella and Plodia interpunctella, are prevalent stored product pests. The insecticides are the main tool to control these moths in the stores. The data describing the response of these moths to insecticides are scarce. The lethal effect of the organophosphate, pyrethroid, and halogenated-pyrrole on moths larvae were compared in laboratory test. The hypothesis was that the very polyphagous P. interpunctella would have generally higher insecticide tolerance than that of the stenophagous E. kuehniella. Different insecticide concentrations were applied onto the inner surface of glass tube vials. Ten larvae of 14 or 21 d old of E. kuehniella and 7 or 14 d old of P. interpunctella were used by treatment. The larval mortality was checked after 24 h of exposure. The mortality was significantly influenced by age of larvae and the groups of chemicals. No differences among the efficacies of the tested formulations with identical active compounds were found, except significant different mortality of E. kuehniella on deltamethrin formulations. A comparison of analytical standards showed that P. interpunctella was less susceptible to the active ingredient pirimiphos-methyl than E. kuehniella, while E. kuehniella was less susceptible to deltamethrin than P. interpunctella. No differences between the two species were observed for chlorfenapyr. We therefore rejected the hypothesis that polyphagy/stenophagy can be a general predictor of insecticide tolerance in the two tested storage moths. The most important finding for effective use was that the young larvae of both species were more susceptible to tested insecticides than older larvae.     

Controlling and Defence‐related Mechanisms of Bacillus Strains Against Bacterial Leaf Blight of Rice

Bacillus strains are broadly studied for their beneficial role in plant growth and biological control of plant disease and pest; however, little is known about their underlying mechanisms. In this study, we assessed the controlling and defence‐related mechanisms of three Bacillus strains including rice seed‐associated strain B. subtilis A15, rhizobacterial strains B. amyloliquefaciens D29 and B. methylotrophicus H8, all of which are against bacterial leaf blight (BLB) caused by Xanthomonas oryzae pv. oryzae. Results indicated that all three strains showed strong biofilm formation ability. The culture filtrates of each strain significantly suppressed the growth and biofilm formation of X. oryzae, while changes in bacterial cell morphology such as cell swell and severe cell wall alterations were observed through the transmission electron microscopy images. PCR analysis revealed that all three strains harbour the antimicrobial‐associated genes that are responsible for biosynthesis of bacillomycin, fengycin, iturin and surfactin. Subsequent real‐time qPCR analysis revealed the upregulated expression of fenD and srfAA genes in D29 and H8, and fenD and ituC genes in A15 during their in vitro interaction with X. oryzae. It suggests that the antibacterial mechanisms of the three strains may be at least partially associated with their ability to secrete corresponding lipopeptides. Interestingly, the applications of the three strains in greenhouse conditions were found to be effective in controlling the BLB disease, which was achieved through the activation of inducing systemic resistance resulted from the enhanced activities of defence‐related enzymes. This is the first report of demonstration of the mode of antibacterial effect of Bacillus strains against X. oryzae. Overall, data from the current study provide valuable information for biological control of BLB disease in rice.     

Characterization of the cry1Ac17 Gene from an Indigenous Strain of Bacillus thuringiensis subsp. kenyae

An indigenously isolated strain of Bacillus thuringiensis subsp. kenyae exhibited toxicity against lepidopteran as well as dipteran insects. The lepidopteran active cry1Ac protoxin gene coding sequence of 3.5 kb from this strain was cloned into vector pET28a(+). However, it could not be expressed in commonly used Escherichia coli expression hosts, BL21(DE3) and BL21(DE3)pLysS. This gene is classified as cry1Ac17 in the B. thuringiensis toxic nomenclature database. The coding sequence of this gene revealed that it contains about 3% codons, which are not efficiently translated by these expression hosts. Hence, this gene was expressed in a modified expression host, Epicurian coli BL21-Codonplus (DE3)-RIL. The expression of gene yielded a 130-kDa Cry1Ac17 protein. The protein was purified and its toxicity was tested against economically important insect pests, viz., Helicoverpa armigera and Spodoptera litura. LC₅₀ values obtained against these insects were 0.1 ng/cm³ and 1231 ng/cm², respectively. The higher toxicity of Cry1Ac17 protein, compared to other Cry1Ac proteins, toward these pests demonstrates the potential of this isolate as an important candidate in the integrated resistance management program in India.     

Evidence of DNA rearrangements in the 128-kilobase pBtoxis plasmid of Bacillus thuringiensis israelensis

BUPM97 is a novel Tunisian isolate of Bacillus thuringiensis israelensis presenting insecticidal activity against Culex pipiens larvae. The δ-endotoxins pattern of this strain was different from that of the reference strain B. thuringiensis israelensis H14. Therefore, the study of its cry genes content was carried out by restriction-fragment-length-polymorphism (RFLP) using specific cry genes probes and by DNA sequencing. It was clearly demonstrated that in the strain BUPM97 the cry4A and cry10A genes were deleted from the B. thuringiensis israelensis 128-kb pBtoxis plasmid. In addition, a strong DNA sequence polymorphism was evidenced in the same plasmid downstream from the cry4B gene. This very particular DNA dynamic evidenced in this new strain of B. thuringiensis israelensis should be taken into consideration, regarding the strain stability during the industrial production of B. thuringiensis bioinsecticides.