Yield and protein quality of thermophilic Bacillus spp. biomass related to thermophilic aerobic digestion of agricultural wastes for animal feed supplementation

Bacillus spp. responsible for thermophilic aerobic digestion (TAD) of agricultural wastes were studied for their growth rate, yield and protein quality (amino acid profile) under conditions that approximate full-scale waste digestion as pointers to the capacity of TAD to achieve protein enrichment of wastes for reuse in animal feeding. Specific growth rates of the thermophiles varied with temperature and aeration rates. For Bacillus coagulans, the highest specific growth rate was 1.98 muh(-1); for Bacillus licheniformis 2.56 muh(-1) and for Bacillus stearothermophilus 2.63 muh(-1). Molar yield of B. stearothermophilus on glucose increased with temperature to a peak of 0.404 g g(-1) at 50 degrees C before declining. Peak concentration of overflow metabolite (acetate) increased from 10 mmol at 45 degrees C to 34 mmol at 65 degrees C before declining. Accumulation of biomass in all three isolates decreased with increase in temperature while protein content of biomass increased. Highest biomass protein (79%) was obtained in B. stearothermophilus at 70 degrees C. Content of most essential amino acids of the biomass improved with temperature. Amino acid profile of the biomass was comparable to or superior to the FAO standard for SCP intended for use in animal feeding. Culture condition (waste digestion condition) may be manipulated to optimize protein yield and quality of waste digested by TAD for recycling in animal feed.     

Diversity of thermophilic populations during thermophilic aerobic digestion of potato peel slurry

Aims:  To study the diversity of thermophiles during thermophilic aerobic digestion (TAD) of agro-food waste slurries under conditions similar to full-scale processes.
Methods and Results:  Population diversity and development in TAD were studied by standard microbiological techniques and the processes monitored by standard fermentation procedures. Facultative thermophiles were identified as Bacillus coagulans and B. licheniformis, while obligate thermophiles were identified as B. stearothermophilus . They developed rapidly to peaks of 10⁷ to 10⁸ in ≤48 h. Stability of obligate thermophiles increased with process temperatures. Thermophiles were unstable at process pH above or below neutral, but developed rapidly at all aeration rates. Peak populations were higher in the median than at extremes of aeration rates. Obligate thermophiles were unstable at low aeration rates. Process self-heating was higher at lower than at higher aeration rate. Beyond 96 h most thermophiles were present as spores.
Conclusions:  Limited range of indigenous thermophiles drives TAD of slurry. They develop rapidly and are stable at most digestion conditions.
Significance and Impact of the Study:  Development and stability of thermophiles in TAD suggest that the process may be operated in a wide range of conditions; and even at short HRT in continuous processes without compromising efficiency.     

Effect of natural zeolite on methane production for anaerobic digestion of ammonium rich organic sludge

The effect of an inorganic additive on the methane production from NH(4+)-rich organic sludge during anaerobic digestion was investigated using different kinds of inorganic adsorbent zeolites (mordenite, clinoptilolite, zeolite 3A, zeolite 4A), clay mineral (vermiculite), and manganese oxides (hollandite, birnessite). The additions of inorganic materials resulted in significant NH4+ removals from the natural organic sludge ([NH4+]=1, 150 mg N/l), except for the H-type zeolite 3A and birnessite. However, an enhanced methane production was only achieved using natural mordenite. Natural mordenite also enhanced the methane production from the sludge with a markedly high NH4+ concentration (4500 mg N/l) during anaerobic digestion. Chemical analyses of the sludge after the digestion showed considerable increases in the Ca2+ and Mg2+ concentrations in the presence of natural mordenite, but not with synthetic zeolite 3A. The effect of Ca2+ or Mg2+ addition on the methane production was studied using Na(+)-exchanges mordenite and Ca2+ or Mg(2+)-enriched sludge. The simultaneous addition of Ca2+ ions and Na(+)-exchanged mordenite enhanced the methane production; the amount of produced methane was about three times greater than that using only the Na(+)-exchanged mordenite. In addition, comparing the methane production by the addition of natural mordenite or Ca2+ ions, the methane production with natural mordenite was about 1.7 times higher than that with only Ca2+ ions. The addition of 5% and 10% natural mordenite were suitable condition for obtaining a high methane production. These results indicated that the Ca2+ ions, which are released from natural mordenite by a Ca2+/NH4+ exchange, enhanced the methane production of the organic waste at a high NH4+ concentration. Natural mordenite has a synergistic effect on the Ca2+ supply as well on the NH4+ removal during anaerobic digestion, which is effective for the mitigation of NH4+ inhibition against methane production.     

Purification and characterization of a calcium-activated neutral protease from monkey cardiac muscle

A calcium-activated neutral protease (CANP) was purified from monkey cardiac muscle by a method involving column chromatography on DEAE-cellulose, Sepharose CL-6B, DEAE-Sephacel, organomercurial-Sepharose 4B, and Sephadex G-150 in succession. This protease required both millimolar concentration of Ca2+ and the SH-group for activation, and it was maximally active around pH 8.0. It was strongly inhibited by thiol protease inhibitors such as iodoacetic acid, antipain, leupeptin, and epoxysuccinic acid derivatives. The molecular weight of this protease was estimated to be 110,000 by gel filtration. Upon nondenaturing electrophoresis the purified protease gave two bands, both of which were active at millimolar concentration of Ca2+, indicating the existence of two forms of the protease. The less acidic band (form I CANP) contained two components with molecular weights of 74,000 and 28,000 and the more acidic one (form II CANP) contained components with molecular weights of 74,000 and 26,000. The protease was synergistically activated by Mn2+ and Ca2+ at a concentration where Mn2+ or Ca2+ alone was not effective. In the presence of millimolar level of Ca2+, limited autolysis reduced the Ca2+-requirement of this protease. The proteolysis of myofibrils by this protease resulted in the production of a component with a molecular weight of 30,000 as well as various other higher and lower molecular weight peptide fragments.     

Ca2+-sensitivity of actomyosin ATPase purified from Physarum polycephalum.

A contractile protein closely resembling natural actomyosin (myosin B) of rabbit skeletal muscle was extracted from plasmodia of the slime mold, Physarum polycephalum, by protecting the SH-groups with beta-mercaptoethanol or dithiothreitol. Superprecipitation of the protein induced by Mg2+-ATP at low ionic strength was observed only in the presence of very low concentrations of free Ca2+ ions, and the Mg2+-ATPase [EC 3.6.1.3] reaction was activated 2- to 6-fold by 1 muM of free Ca2+ ions. Crude myosin and actin fractions were separated by centrifuging plasmodium myosin B in the presence of Mg2+-PPi at high ionic strength. The crude myosin showed both EDTA- and Ca2+-activated ATPase activities. The Mg2+-ATPase activity of crude myosin from plasmodia was markedly activated by the addition of pure F-actin from rabbit skeletal muscle. Addition of the F-action-regulatory protein complex prepared from rabbit skeletal muscle as well as the actin fraction of plasmodium caused the same degree of activation as the addition of pure F-actin only in the presence of very low concentrations of Ca2+ ion     

添加厨余垃圾对剩余污泥厌氧消化产沼气过程的影响

为提高剩余污泥厌氧消化的沼气产量和甲烷含量,研究了厨余垃圾的不同添加量对剩余污泥厌氧消化性能的影响。结果表明,在35℃下,随着剩余污泥中厨余垃圾添加量的增加,厌氧消化系统中碳氮质量比（C／N）、胞外多聚物（EPS）等生理生化指标均有不同程度的改善。其中当剩余污泥与厨余垃圾质量比为2：1时,混合有机废弃物中沼气产量和甲烷含量均达到最大值,每克挥发性固体（VS）产生了156．56mL沼气,甲烷体积分数为67．52％,分别比剩余污泥单独厌氧消化时的产气量提高了5倍和1．5倍。     

The effect of acid pretreatment on the anaerobic digestion and dewatering of waste activated sludge

Waste activated sludge (WAS) is difficult to degrade in anaerobic digestion systems and pretreatments have been shown to speed up the hydrolysis stage. Here the effects of acid pretreatment (pH 6-1) using HCl on subsequent digestion and dewatering of WAS have been investigated. Optimisation of acid dosing was performed considering digestibility benefits and level of acid required. Pretreatment to pH 2 was concluded to be the most effective. In batch digestion this yielded the same biogas after 13 days as compared to untreated WAS at 21 days digestion. In semi-continuous digestion experiments (12 day hydraulic retention time at 35 °C) it resulted in a 14.3% increase in methane yield compared to untreated WAS, also Salmonella was eradicated in the digestate. Dewatering investigations suggested that the acid pretreated WAS required 40% less cationic polymer addition to achieve the same cake solid content. A cost analysis was also carried out.     

Uptake, retention, and efflux of Ca2+ by mitochondrial preparations from skeletal muscle

Functionally intact mitochondria, substantially free of contamination, were isolated from rabbit gastrocnemius muscle after protease digestion and their Ca2+-handling properties examined. When judged by their capacity to retain large Ca2+ loads and the magnitude of basal and Na+-stimulated Ca2+ effluxes, the most suitable isolation method was digestion of finely minced muscle in buffered isoosmotic KCl with low levels (0.4 mg/g) of trypsin or the bacterial protease nagarse, followed by differential centrifugation. Polytron disruption of skeletal muscle in both sucrose- and KCl-based media released mitochondria deficient in cytochrome c. Use of the divalent ion chelator EDTA rather than EGTA in the isolation medium sharply reduced Ca2+-dependent respiratory control and tolerance of the mitochondria to Ca2+ loads, probably by removing Mg2+ essential to membrane integrity. ADP-dependent respiratory control was not altered in mitochondria prepared in an EDTA-containing isolation medium. Purification of mitochondria on a Percoll density gradient did not improve their Ca2+-handling ability despite removal of minor contaminants. Mitochondria prepared by the protease method could accumulate micromole loads of Ca2+/mg while maintaining a low basal Ca2+ efflux. Addition of BSA to the assay medium slightly improved Ca2+ retention but was not essential either during isolation or assay. Ca2+-dependent state 3 respiration was maximal at pH 6.5-7.0 while respiratory control and Ca2+/O were optimal at pH 7.0-7.5. Neither Pi nor oxaloacetate induced Ca2+ release from loaded mitochondria when monitored for 30 min after ruthenium red addition. Na+-stimulated Ca2+ efflux had sigmoidal kinetics with a Hill coefficient of 3. Since skeletal muscle mitochondria can be isolated and assayed in simple media, functional deficiencies of mitochondria from diseased muscle are unlikely to be masked.     

Effects of metal oxide nanoparticles (TiO2, Al2O3, SiO2 and ZnO) on waste activated sludge anaerobic digestion

The effect of metal oxide nanoparticles (nano-TiO2, nano-Al2O3, nano-SiO2 and nano-ZnO) on anaerobic digestion was investigated by fermentation experiments using waste activated sludge as the substrates. Nano-TiO2, nano-Al2O3 and nano-SiO2 in doses up to 150 milligram per gram total suspended solids (mg/g-TSS) showed no inhibitory effect, whereas nano-ZnO showed inhibitory effect with its dosages increased. The methane generation was the same as that in the control when in the presence of 6 mg/g-TSS of nano-ZnO, however, which decreased respectively to 77.2% and 18.9% of the control at 30 and 150 mg/g-TSS. The released Zn2+ from nano-ZnO was an important reason for its inhibitory effect on methane generation. It was found that higher dosages of nano-ZnO inhibited the steps of sludge hydrolysis, acidification and methanation. Also, the activities of protease, acetate kinase (AK) and coenzyme F420 were inhibited by higher dosages of nano-ZnO during WAS anaerobic digestion.     

Inhibition of proteolytic activity of calcium activated neutral protease by leupeptin and antipain

The calcium activated neutral protease from bovine ventricular muscle requires milli-molar concentration of Ca ions for the activation of the proteolysis of troponin-T, troponin-I and tropomyosin. The exogenous protease inhibitors were examined concerning the blocking action of this enzyme. Both leupeptin and antipain were effective for the inhibition at the nearly same molar concentration as the protease. Lineweaver plot for both the protease alone and protease with leupeptin showed straight lines, and the mode of the inhibition was non-competitive type. Natural actomyosin, pretreated with this protease showed markedly reduced sensitivity to Ca ions. With the addition of leupeptin to the pretreatment, however, the Ca sensitivity was well preserved.     

Localization of chromatophore proteins of Rhodobacter sphaeroides. I. Rapid Ca(2+)-induced fusion of chromatophores with phosphatidylglycerol liposomes for proteinase delivery to the luminal membrane surface.

A protease delivery system was developed for the exclusive and controlled digestion of proteins exposed at the morphological inside (periplasmic surface) of Rhodobacter sphaeroides chromatophores. In this procedure, proteinase K is encapsulated within large unilamellar liposomes which are fused to the chromatophores in the presence of Ca2+ ions. The liposomes were prepared by a detergent dialysis procedure from native phosphatidylglycerol and found to undergo rapid bilayer fusion with purified chromatophore preparations above a threshold concentration of 12.5 mM CaCl2. The fusion process was complete within 10 min at 35 mM Ca2+ with about 80% of the pigment located in the fusion products. Electron micrographs of freeze-fracture replicas confirmed the intermixing of the lipid bilayers and the unilamellar structure of the fused membrane vesicles. The procedure did not affect the labile B800 chromophore of the B800-850 antenna complex, but reduced slightly the absorption due to the B875 core antenna. Emission from both light-harvesting complexes was increased in the fused membranes, suggesting a partial dissociation of photosynthetic units in the expanded bilayer. The results, together with those presented in the following paper (Theiler, R., and Niederman, R. A. (1991) J. Biol. Chem. 266, 23163-23168), demonstrate that this new method fulfills the stringent requirements for a successful delivery of macromolecules to the chromatophore interior.     

嗜热脂肪芽孢杆菌高温蛋白酶的产生条件及酶学性质

对嗜热脂肪芽孢杆菌(Bacillusstearothermophilis)WF146的产蛋白酶的条件进行了研究,在58℃条件下,WF146在pH值为75的Fd培养基中振荡发酵培养48h后,发酵液中高温蛋白酶产量可达600u/mL以上。对该酶性质的研究表明,酶分子量为34kD,最适作用pH为80,最适作用温度为80℃,具有良好的pH稳定性及热稳定性。Ca2+对该酶的稳定性具有重要影响,PMSF、DFP及IAA能强烈抑制酶活力,而DTT对该蛋白酶活力无影响     

Manganese induces apoptosis of human B cells: caspase-dependent cell death blocked by bcl-2.

Manganese ions block apoptosis of phagocytes induced by various agents. The prevention of apoptosis was attributed to the activation of manganous superoxide dismutase (Mn-SOD) and to the antioxidant function of free Mn2+ cations. However, the effect of Mn2+ on B cell apoptosis is not documented. In this study, we investigated the effects of Mn2+ on the apoptotic process in human B cells. We observed that Mn2+ but not Mg2+ or Ca2+, inhibited cell growth and induced apoptosis of activated tonsilar B cells, Epstein Barr virus (EBV)-negative Burkitt's lymphoma cell lines (BL-CL) and EBV-transformed B cell lines (EBV-BCL). In the same conditions, no apoptosis was observed in U937, a monoblastic cell line. Induction of B cell apoptosis by Mn2+ was time- and dose-dependent. The cell permeable tripeptide inhibitor of ICE family cysteine proteases, zVAD-fmk, suppressed Mn2+-induced apoptosis. Furthermore, Mn2+ triggered the activation of interleukin-1beta converting enzyme (ICE/caspase 1), followed by the activation of CPP32/Yama/Apopain/caspase-3. In addition, poly-(ADP-ribose) polymerase (PARP), a cellular substrate for CPP32 protease was degraded to generate apoptotic fragments in Mn2+-treated B cell lines. The inhibitor, zVAD-fmk suppressed Mn2+-triggered CPP32 activation and PARP cleavage and apoptosis. These results indicate that the activation of caspase family proteases is required for the apoptotic process induced by Mn2+ treatment of B cells. While the caspase-1 inhibitor YVAD was unable to block apoptosis, the caspase-3 specific inhibitor DEVD-cmk, partially inhibited Mn2+-induced CPP32 activation, PARP cleavage and apoptosis of cells. Moreover, Bcl-2 overexpression in BL-CL effectively protected cells from apoptosis and cell death induced by manganese. This is the first report showing the involvement of Mn2+ in the regulation of B lymphocyte death presumably via a caspase-dependent process with a death-protective effect of Bcl-2.     

The Ca2+ -activated protease (calpain) modulates Ca2+/calmodulin dependent activity of smooth muscle myosin light chain kinase

The Ca2+ -activated neutral protease can proteolyze both Ca2+ -dependent cyclic nucleotide phosphodiesterase and smooth muscle myosin light chain kinase. Ca2+ -dependent cyclic nucleotide phosphodiesterase from rat brain was converted to the Ca2+ -independent active form by Ca2+ -activated protease. The proteolytic effects on myosin light chain kinase of Ca2+-activated protease differed in the presence and absence of the Ca2+-calmodulin (CaM) complex. In the presence of bound CaM, myosin light chain kinase (130k dalton) was degradated to a major fragment of 62 kDa, which had Ca2+/CaM-dependent enzyme and CaM-binding activity. When digestion occurred in the absence of bound CaM, myosin light chain kinase cleaved to a fragment of 60 kDa. This peptide had no enzymatic activity in the presence or absence of the Ca2+-CaM complex. Available evidence suggests that the Ca2+-activated proteases may recognize the conformational change of smooth muscle myosin light chain kinase induced by Ca2+-CaM complex.     

A comparison of ATP-degrading enzyme activities in rat incisor odontoblasts.

In active odontoblasts from the rat incisor, used as a model system for biologic calcification, two distinguishable enzyme activities capable of degrading adenosine monophosphate (ATP) exist. Once can be inhibited ny 1-tetramisole, (+/-)-2,3,5,6,-tetrahydro-6-phenylimidazo (2.1B) THIAZOLE HYDROCHLORIDE (Levamisol) and (+/-)-6(m-bromophenyl)-5.6-dehydroimidazo (2.1-b) thiazole oxalate (R823) and is probably identical with nonspecific alkaline phosphatase (EC 3.1.3.1). The activity of the other enzyme, named Ca2+-ATPase, is dependent on the presence of Ca2+ or Mg2+ and is activated by these ions. The pH optimum of Ca2+-ATPase is 9.8. The Ca2+-ATPase is unaffected by Levamisole, R 8231, ouabain, ruthenium red, Na+ and K+ ions. Maximal activity was found against ATP, whereas adenosine diphosphate, guanosine triphosphate, inosine triphosphate and adensoine monophosphate were hydrolysed at lower rate. It may be speculated that the Ca2+-ATPase is concerned with the transmembranous transport of Ca2+ ions to the mineralization front.     

Differential activation of two protease-activated protein kinases from reticulocytes by a Ca2+-stimulated protease and identification of phosphorylated translational components

Two protein kinases have been partially purified from rabbit reticulocytes and shown to be activated by limited proteolysis with trypsin [S.M. Tahara and J.A. Traugh (1981) J. Biol. Chem. 256, 11558-11564; P.T. Tuazon, W.C. Merrick, and J.A. Traugh (1980) J. Biol. Chem. 255, 10954-10958]. Reticulocyte lysate was examined for protease activities which might be involved in activation of the protein kinases in vivo. Two neutral proteases, differentially activated by Fe2+ and Ca2+, were identified and partially purified. The Ca2+-stimulated protease specifically activated protease-activated kinase II; no effect was observed on protease-activated kinase I. The Fe2+-stimulated protease was not active on either protein kinase. The protease-activated kinases were examined using initiation factors (eIF) and 40-S ribosomal subunits as substrate. Protease-activated kinase I phosphorylated one subunit of eIF-3 (Mr 130000), eIF-4B and 40-S ribosomal protein S10. Protease-activated kinase II modified the beta subunit of eIF-2 (Mr 53000) and 40-S ribosomal protein S6. The substrate specificities are unique when compared with other cAMP-dependent and cAMP-independent protein kinases from reticulocytes.     

Molecular cloning of a thermostable neutral protease gene from Bacillus stearothermophilus in a vector plasmid and its expression in Bacillus stearothermophilus and Bacillus subtilis.

The structural gene for a thermostable protease from Bacillus stearothermophilus was cloned in plasmid pTB90. It is expressed in both B. stearothermophilus and Bacillus subtilis. B. stearothermophilus carrying the recombinant plasmid produced about 15-fold more protease (310 U/mg of cell dry weight) than did the wild-type strain of B. stearothermophilus. Some properties of the proteases that have been purified from the transformants of B. stearothermophilus and B. subtilis were examined. No significant difference was observed among the enzyme properties studied here despite the difference in host cells. We found that the protease, neutral in pH characteristics and with a molecular weight of 36,000, retained about 80% of its activity even after treatment of 65 degrees C for 30 min.     

Synthesis of peptidoglycan by high molecular weight penicillin-binding proteins of Bacillus subtilis and Bacillus stearothermophilus

The high molecular weight penicillin-binding proteins (PBP(s) ) Bacillus subtilis PBPs 1, 2, and 4 and Bacillus stearothermophilus PBPs 1-4 were shown to catalyze peptidoglycan synthesis from the undecaprenol-containing lipid intermediate substrate in two assay systems. In a filter paper assay system, high levels of substrate polymerization occurred when reaction mixtures were incubated on Whatman 3MM filter paper. The pH optimum for peptidoglycan synthesis was 7.5 for B. subtilis PBPs 1, 2, and 4 and 8.5 for B. stearothermophilus PBPs 1-4. Polymerization was Mg2+-independent and was unaffected by sulfhydryl reagents. Reconstitution with membrane lipids or addition of detergent (optimal concentration, 0.1%) was necessary for synthesis to occur. Bacitracin, penicillin, and cephalothin did not affect polymerization while vancomycin, ristocetin, moenomycin, and macarbomycin were strong inhibitors. In a test tube assay system, optimal synthesis occurred either in the presence of 10% ethylene glycol, 10% glycerol, and 8% methanol or in the presence of 10% N-acetylglucosamine. The products of lysozyme digestion of the synthesized peptidoglycan were analyzed by gel filtration and paper chromatography. B. stearothermophilus PBPs 1-4 synthesized a peptidoglycan product that was 5-7% cross-linked. No evidence for cross-linking was apparent in the peptidoglycan product of B. subtilis PBPs 1, 2, and 4.     

α-Synuclein increases the cellular level of phospholipase Cβ1

α-Synuclein is a conserved protein that is a key component in neurodegenerative plaques [1,2]. α-Synuclein binds strongly to phospholipase Cβ (PLCβ) and promotes Ca2+ release in cells. Here, we show that expression of α-synuclein increases the cellular level of PLCβ1 in two neuronal cell lines: PC12 and SK-N-S-SH. The increase in PLCβ1 is not accompanied by changes in the level of RNA or in ubiquitination. Instead, we find that α-synuclein protects PLCβ1 from trypsin digestion and from degradation by the Ca(+2) activated protease calpain. Calpain removes the C-terminal region of the enzyme which mediates activation by Gα(q). We find that in SK-N-SH cells, α-synuclein reduced degradation of PLCβ1 by calpain during Ca2+ signaling allowing the enzyme to remain sensitive to Gα(q) activation. Taken together, our studies show that α-synuclein protects the integrity of PLCβ1 and its ability to be activated by Gα(q), which may in turn impact Ca2+ signaling.     

Minimization of excess sludge production by in-situ activated sludge treatment processes — A comprehensive review

The widespread application of conventional activated sludge treatment process has been employed to deal with a variety of municipal and industrial sewage. While the generation of waste activated sludge (WAS) was considerably huge, the management and disposal expenses were substantially costly. A promising process aimed for WAS reduction during the operation process is urgently needed. Thus, increasing attentions emphasizing on the improved or novel sludge reduction processes should be intensively recommended in the future. This review presents the current and emerging technologies for excess sludge minimization within the process of sewage treatment. The ultimate purpose of this paper is to guide or inspire researchers who are seeking feasible and promising technologies (or processes) to tackle the severe WAS problem.