Determination of the intracellular concentration of ethanol in Saccharomyces cerevisiae during fermentation.

Considerable controversy exists concerning the intracellular concentration of ethanol in Saccharomyces cerevisiae during fermentation. This controversy results from problems in the measurement of the intracellular concentration of compounds like ethanol, which are being produced rapidly by metabolism and potentially diffuse rapidly from the cell. We used a new method for the determination of intracellular ethanol based on the exclusion of [14C]sorbitol to estimate the aqueous cell volume. This method avoided many of the technical problems in previous reports. Our results indicate that the extracellular concentrations of ethanol in fermenting suspensions of S. cerevisiae are less than or equal to those in the intracellular environment and do not increase to the high levels previously reported even during the most active stages of batch fermentation.     

Intracellular ethanol accumulation in Saccharomyces cerevisiae during fermentation

An intracellular accumulation of ethanol in Saccharomyces cerevisiae was observed during the early stages of fermentation (3 h). However, after 12 h of fermentation, the intracellular and extracellular ethanol concentrations were similar. Increasing the osmotic pressure of the medium caused an increase in the ratio of intracellular to extracellular ethanol concentrations at 3 h of fermentation. As in the previous case, the intracellular and extracellular ethanol concentrations were similar after 12 h of fermentation. Increasing the osmotic pressure also caused a decrease in yeast cell growth and fermentation activities. However, nutrient supplementation of the medium increased the extent of growth and fermentation, resulting in complete glucose utilization, even though intracellular ethanol concentrations were unaltered. These results suggest that nutrient limitation is a major factor responsible for the decreased growth and fermentation activities observed in yeast cells at higher osmotic pressures.     

Intracellular ethanol accumulation in Saccharomyces cerevisiae during fermentation.

An intracellular accumulation of ethanol in Saccharomyces cerevisiae was observed during the early stages of fermentation (3 h). However, after 12 h of fermentation, the intracellular and extracellular ethanol concentrations were similar. Increasing the osmotic pressure of the medium caused an increase in the ratio of intracellular to extracellular ethanol concentrations at 3 h of fermentation. As in the previous case, the intracellular and extracellular ethanol concentrations were similar after 12 h of fermentation. Increasing the osmotic pressure also caused a decrease in yeast cell growth and fermentation activities. However, nutrient supplementation of the medium increased the extent of growth and fermentation, resulting in complete glucose utilization, even though intracellular ethanol concentrations were unaltered. These results suggest that nutrient limitation is a major factor responsible for the decreased growth and fermentation activities observed in yeast cells at higher osmotic pressures.     

Efficient extraction of intracellular reduced glutathione from fermentation broth of Saccharomyces cerevisiae by ethanol

Reduced glutathione (GSH) from fermentation broth of Saccharomyces cerevisiae was extracted with ethanol without disruption of the cells. The effects of ethanol concentration, extraction temperature and extraction time were assessed by using 2(3) full factorial designs (FFD). Preliminary studies showed that ethanol concentration had the most influence on GSH yield by ethanol extraction, based on the first order regression coefficients derived using MINITAB software, and an optimal ethanol concentration (25%, v/v) was obtained. However, compared to the conventional extraction technique (hot water extraction), there was no significant advantage in yield of GSH from yeast cells using ethanol extraction under these optimized conditions. But ethanol extraction has several advantages, such as lower energy consumption and lower protein concentration of extraction broth, which may reduce the complexity and cost of the purification process. Hence, ethanol extraction which does not disrupt yeast cells could be an inexpensive, simple and efficient alternative to conventional extraction techniques in the GSH industry.     

Increasing ethanol productivity during xylose fermentation by cell recycling of recombinant Saccharomyces cerevisiae

The influence of cell recycling of xylose-fermenting Saccharomyces cerevisiae TMB3001 was investigated during continuous cultivation on a xylose-glucose mixture. By using cell recycling at the dilution rate ( D) of 0.05 h(-1), the cell-mass concentration could be increased from 2.2 g l(-1) to 22 g l(-1). Consequently, the volumetric ethanol productivity increased ten-fold, from 0.5 g l(-1) h(-1) to 5.35 g l(-1) h(-1). By increasing the biomass concentration, the xylose consumption rate increased from 0.75 g xylose l(-1) h(-1) without recycling to 1.9 g l(-1) h(-1) with recycling. The specific ethanol productivity was in the range of 0.23-0.26 g g(-1) h(-1) with or without cell recycling, showing that an increased cell-mass concentration did not influence the efficiency of the yeast.     

Physiological difference during ethanol fermentation between calcium alginate-immobilized Candida tropicalis and Saccharomyces cerevisiae

Calcium alginate-immobilized Candida tropicalis and Saccharomyces cerevisiae are compared for glucose fermentation. Immobilized C. tropicalis cells showed a slight morphological alteration during ethanol production at 40 degrees C, but their fermentation capacity was reduced by 25%. Under immobilization conditions, the two species demonstrated two different mathematical patterns when the relationship between growth rate, respiration rate, and ethanol tolerance was assessed. The interspecific difference in behavior of immobilized yeast cells is mainly due to their natural metabolic preference. The production of CO(2) by calcium alginate-immobilized C. tropicalis, as well as the lower supply of oxygen to the cells, are the major factors that reduce ethanol production.     

酿酒酵母 L-阿拉伯糖转化乙醇代谢工程的研究进展简

L-阿拉伯糖是木质纤维素原料中一种重要的五碳糖组分,但传统的乙醇生产菌株酿酒酵母（ Saccharomyces cerevisiae）不能利用L 阿拉伯糖。通过代谢途径工程手段,在酿酒酵母中引入L 阿拉伯糖初始代谢途径可以获得能利用L 阿拉伯糖乙醇发酵的重组菌株。并且,通过代谢途径的疏通以及吸收系统的优化可以强化重组菌株代谢L 阿拉伯糖的能力。笔者从以上角度综述了近年来酿酒酵母转化L 阿拉伯糖生产乙醇的研究进展。     

Reconstruction of ethanol fermentation in permeabilized cells of the yeast Saccharomyces cerevisiae

Saccharomyces cerevisiae cells from a stationary culture were permeabilized with 1% toluene, 4% ethanol and 0.075% Triton X-100. Not only sugars but also ATP, NAD⁺, magnesium and inorganic phosphate must be simultaneously added to initiate the ethanol fermentation. The optimal pH for the fermentation was between 6.9 to 7.0. Sucrose was a better substrate than glucose. Ethanol fermentation was greatly stimulated by the addition of 1 mM arsenate. Under this condition, permeabilized cells continued to produce ethanol for more than one hour at the rate of 0.141 mmol ethanol/min/mg protein. Methanol inhibited the fermentation with intact cells but did not inhibit the one using permeabilized cells. In contrast, propanol inhibited fermentations both with intact and permeabilized cells.     

Growth and growth estimation of Saccharomyces cerevisiae in solid-state ethanol fermentation

The anaerobic growth of a respiration-deficient mutant of Saccharomyces cerevisiae on solid medium was estimated by the CO₂ evolution rate (CER). The cell growth and ethanol production were calculated by a growth-model associated with CER. The estimated cell growth agreed with the observed data. The calculation and the observed CER suggested that the maximum ethanol production and maximum cell groth are restricted by the initial moisture content of the solid medium.     

Stress-related challenges in pentose fermentation to ethanol by the yeast Saccharomyces cerevisiae

Conversion of agricultural residues, energy crops and forest residues into bioethanol requires hydrolysis of the biomass and fermentation of the released sugars. During the hydrolysis of the hemicellulose fraction, substantial amounts of pentose sugars, in particular xylose, are released. Fermentation of these pentose sugars to ethanol by engineered Saccharomyces cerevisiae under industrial process conditions is the subject of this review. First, fermentation challenges originating from the main steps of ethanol production from lignocellulosic feedstocks are discussed, followed by genetic modifications that have been implemented in S. cerevisiae to obtain xylose and arabinose fermenting capacity per se. Finally, the fermentation of a real lignocellulosic medium is discussed in terms of inhibitory effects of furaldehydes, phenolics and weak acids and the presence of contaminating microbiota.     

Trehalose metabolism in Saccharomyces cerevisiae during alcoholic fermentation

Strains of Saccharomyces cerevisiae accumulated intracellular trehalose up to 105 mg/g cell dry wt with 90% survival. Viability could be correlated to trehalose levels during ethanol fermentation albeit the disaccharide did not seem to contribute to fermentation yields. Trehalose-6-phosphate synthase showed high activity (up to 279 mu/mg protein) even at high residual sucrose concentration (115 g/l) in the wort suggesting to be a response of yeast cells to the osmotic stress conditions.     

Changes of Saccharomyces cerevisiae cell membrane components and promotion to ethanol tolerance during the bioethanol fermentation

During bioethanol fermentation process, Saccharomyces cerevisiae cell membrane might provide main protection to tolerate accumulated ethanol, and S. cerevisiae cells might also remodel their membrane compositions or structure to try to adapt to or tolerate the ethanol stress. However, the exact changes and roles of S. cerevisiae cell membrane components during bioethanol fermentation still remains poorly understood. This study was performed to clarify changes and roles of S. cerevisiae cell membrane components during bioethanol fermentation. Both cell diameter and membrane integrity decreased as fermentation time lasting. Moreover, compared with cells at lag phase, cells at exponential and stationary phases had higher contents of ergosterol and oleic acid (C_18:1) but lower levels of hexadecanoic (C_16:0) and palmitelaidic (C_16:1) acids. Contents of most detected phospholipids presented an increase tendency during fermentation process. Increased contents of oleic acid and phospholipids containing unsaturated fatty acids might indicate enhanced cell membrane fluidity. Compared with cells at lag phase, cells at exponential and stationary phases had higher expressions of ACC1 and HFA1. However, OLE1 expression underwent an evident increase at exponential phase but a decrease at following stationary phase. These results indicated that during bioethanol fermentation process, yeast cells remodeled membrane and more changeable cell membrane contributed to acquiring higher ethanol tolerance of S. cerevisiae cells. These results highlighted our knowledge about relationship between the variation of cell membrane structure and compositions and ethanol tolerance, and would contribute to a better understanding of bioethanol fermentation process and construction of industrial ethanologenic strains with higher ethanol tolerance.     

Overexpression of the OLE1 gene enhances ethanol fermentation by Saccharomyces cerevisiae

 The fermentation characteristics of Saccharomyces cerevisiae strains which overexpress a constitutive OLE1 gene were studied to clarify the relationship between the fatty acid composition of this yeast and its ethanol productivity. The growth yield and ethanol productivity of these strains in the medium containing 15% dextrose at 10 °C were greater than those of the control strains under both aerobic and anaerobic conditions but this difference was not observed under other culture conditions. During repeated-batch fermentation, moreover, the growth yield and ethanol productivity of the wild-type S. cerevisiae increased gradually and then were similar to those of the OLE1-overexpressing transformant in the last batch fermentation. However, the unsaturated fatty acid content (77.6%) of the wild-type cells was lower than that (86.2%) of the OLE1-recombinant cells. These results suggested that other phenomena caused by the overexpression of the OLE1 gene, rather than high unsaturated fatty acid content, are essential to ethanol fermentation by this yeast. Received: 11 June 1999 / Received last revision: 12 November 1999 / Accepted: 28 November 1999     

Construction of lactose-consuming Saccharomyces cerevisiae for lactose fermentation into ethanol fuel

Two lactose-consuming diploid Saccharomyces cerevisiae strains, AY-51024A and AY-51024M, were constructed by expressing the LAC4 and LAC12 genes of Kluyveromyces marxianus in the host strain AY-5. In AY-51024A, both genes were targeted to the ATH1 and NTH1 gene-encoding regions to abolish the activity of acid/neutral trehalase. In AY-51024M, both genes were respectively integrated into the MIG1 and NTH1 gene-encoding regions to relieve glucose repression. Physiologic studies of the two transformants under anaerobic cultivations in glucose and galactose media indicated that the expression of both LAC genes did not physiologically burden the cells, except for AY-51024A in glucose medium. Galactose consumption was initiated at higher glucose concentrations in the MIG1 deletion strain AY-51024M than in the corresponding wild-type strain and AY-51024A, wherein galactose was consumed until glucose was completely depleted in the mixture. In lactose medium, the Sp. growth rates of AY-51024A and AY-51024M under anaerobic shake-flasks were 0.025 and 0.067 h^?1, respectively. The specific lactose uptake rate and ethanol production of AY-51024M were 2.50 g lactose g CDW^?1 h^?1 and 23.4 g l^?1, respectively, whereas those of AY-51024A were 0.98 g lactose g CDW^?1 h^?1 and 24.3 g lactose g CDW^?1 h^?1, respectively. In concentrated cheese whey powder solutions, AY-51024M produced 63.3 g l^?1 ethanol from approximately 150 g l^?1 initial lactose in 120 h, conversely, AY-51024A consumed 63.7 % of the initial lactose and produced 35.9 g l^?1 ethanol. Therefore, relieving glucose repression is an effective strategy for constructing lactose-consuming S. cerevisiae.     

Accelerated ethanol fermentation by Saccharomyces cerevisiae with addition of activated carbon

Fermentation with the addition of activated carbon at 100 g l^–1 promoted the glucose consumption and ethanol production rates of Saccharomyces cerevisiae by 1.3 and 1.1 times, respectively. With fermentation using spent medium, the consumption rate was maintained at 90% of that in the fresh medium with the addition of activated carbon, while the rate without any addition decreased to about 70%.