Production of human serum albumin by sugar starvation induced promoter and rice cell culture

Human serum albumin (HSA) is the most widely used clinical serum protein. Currently, commercial HSA can only be obtained from human plasma, due to lack of commercially feasible recombinant protein expression systems. In this study, inducible expression and secretion of HSA by transformed rice suspension cell culture was established. Mature form of HSA was expressed under the control of the sucrose starvation-inducible rice α Amy3 promoter, and secretion of HSA into the culture medium was achieved by using the α Amy3 signal sequence. High concentrations of HSA were secreted into culture medium in a short time (2–4 days) by sucrose depletion after cell concentrations had reached a peak density in culture medium containing sucrose. The recombinant HSA had the same electrophoretic mobility as commercial HSA and was stable and free from apparent proteolysis in the culture medium. In a flask scale culture with repeated sucrose provision-depletion cycles, HSA was stably produced with yields up to 11.5% of total medium proteins or 15 mg/L per cycle after each sucrose provision-depletion cycle. A bubble column type bioreactor was designed for production of HSA. In the bioreactor scale culture, HSA was produced with yields up to 76.4 mg/L 4 days after sucrose depletion. HSA was purified from the culture medium to high purity by a simple purification scheme. Enrichment of HSA in culture medium simplifies downstream purification, minimizes protease degradation, and may reduce production cost. The combination of a DNA construct containing the α Amy3 promoter and signal sequence, and the use of a rice suspension cell culture can provide an effective system for the production of recombinant pharmaceutical proteins.     

Improved expression and purification of recombinant human serum albumin from transgenic tobacco suspension culture

Most human serum albumin (HSA) for medical applications is derived from human plasma due to the lack of suitable heterologous expression systems for recombinant HSA (rHSA). To determine whether plant cell cultures could provide an alternative source, we employed the hyper-translatable cowpea mosaic virus protein expression system (CPMV-HT) to stably express rHSA in tobacco Bright Yellow-2 (BY-2) cells. rHSA was stably produced with yield up to 11.88 μg/ml in the culture medium, accounting for 0.7% of total soluble protein, in a 25-ml flask. Cultivation of transgenic cells in modified Murashige and Skoog medium with a pH of 8.0 improved the yield of rHSA two-fold, which may be the result of reduced proteolytic activity in the modified medium. A simple purification scheme was developed to purify the rHSA from culture medium, resulting in a recovery of 48.41% of the secreted rHSA. Matrix-assisted laser desorption/ionization time-of-flight mass spectrometry and N-terminal sequence analysis of the purified rHSA revealed that plant cell-derived rHSA is identical to that of the plasma-derived HSA. Our results show that the CPMV-HT system, which was originally developed as a transient expression system for use in whole plants, can also be used for high-level expression of rHSA, a protein highly susceptible to proteolysis, in transgenic tobacco cells.     

Production of biologically active recombinant human factor H in Physcomitrella

The human complement regulatory serum protein factor H (FH) is a promising future biopharmaceutical. Defects in the gene encoding FH are associated with human diseases like severe kidney and retinal disorders in the form of atypical haemolytic uremic syndrome (aHUS), membranoproliferative glomerulonephritis II (MPGN II) or age‐related macular degeneration (AMD). There is a current need to apply intact full‐length FH for the therapy of patients with congenital or acquired defects of this protein. Application of purified or recombinant FH (rFH) to these patients is an important and promising approach for the treatment of these diseases. However, neither protein purified from plasma of healthy individuals nor recombinant protein is currently available on the market. Here, we report the first stable expression of the full‐length human FH cDNA and the subsequent production of this glycoprotein in a plant system. The moss Physcomitrella patens perfectly suits the requirements for the production of complex biopharmaceuticals as this eukaryotic system not only offers an outstanding genetical accessibility, but moreover, proteins can be produced safely in scalable photobioreactors without the need for animal‐derived medium compounds. Transgenic moss lines were created, which express the human FH cDNA and target the recombinant protein to the culture supernatant via a moss‐derived secretion signal. Correct processing of the signal peptide and integrity of the moss‐produced rFH were verified via peptide mapping by mass spectrometry. Ultimately, we show that the rFH displays complement regulatory activity comparable to FH purified from plasma.     

High-level expression of secreted complex glycosylated recombinant human erythropoietin in the Physcomitrella Delta-fuc-t Delta-xyl-t mutant

The highly glycosylated peptide hormone erythropoietin (EPO) plays a key role in the regulation of erythrocyte maturation. Currently, marketed EPO is produced by recombinant technology in mammalian cell cultures. The complementary DNA (cDNA) for human EPO (hEPO) was transiently and stably expressed in the moss Physcomitrella patens wild-type and Δ-fuc-t Δ-xyl-t mutant, the latter containing N -glycans lacking the plant-specific, core-bound α1,3-fucose and β1,2-xylose. New expression vectors were designed based on a Physcomitrella ubiquitin gene-derived promoter for the expression of hEPO cDNA. Transient expression in protoplasts was much stronger at 10 than at 20 °C. In Western blot analysis, the molecular size of moss-produced recombinant human EPO (rhEPO) was identified to be 30 kDa, and it accumulated in the medium of transiently transformed protoplasts to high levels around 0.5 µg/mL. Transgenic Physcomitrella Δ-fuc-t Δ-xyl-t mutant lines expressing EPO cDNA showed secretion of rhEPO through the cell wall to the culture medium. In 5- and 10-L photobioreactor cultures, secreted rhEPO accumulated to high levels above 250 µg/g dry weight of moss material after 6 days. Silver staining of rhEPO on sodium dodecylsulphate-polyacrylamide gel electrophoresis (SDS-PAGE) taken from the bioreactor culture demonstrated a high purity of the over-expressed secreted rhEPO, with a very low background of endogenous moss proteins. Peptide mapping of rhEPO produced by the Physcomitrella Δ-fuc-t Δ-xyl-t mutant indicated correct processing of the plant-derived signal peptide. All three N -glycosylation sites of rhEPO were occupied by complex-type N -glycans completely devoid of the plant-specific core sugar residues fucose and xylose.     

α-1,6-甘露糖转移酶基因敲除的毕赤酵母菌株构建及其用于融合蛋白HSA/GM-CSF 表达的研究

酵母对蛋白的糖基化修饰过程不同于哺乳动物,其特点为产生高甘露糖型糖基且易发生过度糖基化。本研究通过两步基因重组敲除目标基因的方法成功敲除了毕赤酵母中的α-1,6-甘露糖转移酶(och1p)基因,获得了och1敲除的菌株。以此为基础,构建了高效表达人血清白蛋白与粒细胞-巨噬细胞集落刺激因子融合蛋白(HSA/GM-CSF)的工程酵母,与野生型毕赤酵母表达的过度糖基化HSA/GM-CSF不同,och1敲除菌表达的该融合蛋白糖基化程度明显降低,这为该融合蛋白的开发提供了重要基础。och1敲除菌株的构建不仅提供了一个对糖蛋白进行低糖基化修饰的毕赤酵母表达系统,而且为进一步的酵母糖基工程改造提供了基础。     

Efficient expression of stable recombinant human insulin-like growth factor-1 fusion with human serum albumin in Chinese hamster ovary cells

Insulin-like growth factor-1 (IGF-1) plays a crucial role in cell development, differentiation, and metabolism, and has been a potential therapeutic agent for many diseases. Chinese hamster ovary (CHO) cells are widely used for production of recombinant therapeutic proteins, but the expression level of IGF-1 in CHO cells is very low (1,500?µg/L) and the half-life of IGF-1 in blood circulation is only 4.5?min according to previous studies. Therefore, IGF-1 was fused to long-circulating serum protein human serum albumin (HSA) and expressed in CHO cells. After 8-day fed-batch culture, the expression level of HSA–IGF-1 reached 100?mg/L. The fusion protein HSA–IGF-1 was purified with a recovery of 35% using a two-step chromatographic procedure. According to bioactivity assay, the purified HSA–IGF-1 could stimulate the proliferation of NIH3T3 cells in a dose-dependent fashion and promote the cell-cycle progression. Besides this, HSA–IGF-1 could bind to IGF-1 receptor on cell membrane and activate the intracellular PI3K/AKT signaling pathway. Our study suggested that HSA fusion technology carried out in CHO cells not only provided bioactivity in HSA–IGF-1 for further research but also offered a beneficial strategy to produce other similar cytokines in CHO cells.     

Tobacco plastidial thioredoxins as modulators of recombinant protein production in transgenic chloroplasts

Thioredoxins (Trxs) are small ubiquitous disulphide proteins widely known to enhance expression and solubility of recombinant proteins in microbial expression systems. Given the common evolutionary heritage of chloroplasts and bacteria, we attempted to analyse whether plastid Trxs could also act as modulators of recombinant protein expression in transgenic chloroplasts. For that purpose, two tobacco Trxs (m and f) with different phylogenetic origins were assessed. Using plastid transformation, we assayed two strategies: the fusion and the co-expression of Trxs with human serum albumin (HSA), which was previously observed to form large protein bodies in tobacco chloroplasts. Our results indicate that both Trxs behave similarly as regards HSA accumulation, although they act differently when fused or co-expressed with HSA. Trxs-HSA fusions markedly increased the final yield of HSA (up to 26% of total protein) when compared with control lines that only expressed HSA; this increase was mainly caused by higher HSA stability of the fused proteins. However, the fusion strategy failed to prevent the formation of protein bodies within chloroplasts. On the other hand, the co-expression constructs gave rise to an absence of large protein bodies although no more soluble HSA was accumulated. In these plants, electron micrographs showed HSA and Trxs co-localization in small protein bodies with fibrillar texture, suggesting a possible influence of Trxs on HSA solubilization. Moreover, the in vitro chaperone activity of Trx m and f was demonstrated, which supports the hypothesis of a direct relationship between Trx presence and HSA aggregates solubilization in plants co-expressing both proteins.     

Identification of cell culture conditions to control protein aggregation of IgG fusion proteins expressed in Chinese hamster ovary cells

The presence of aggregated forms of proteins can be problematic for therapeutics due to the potential for immunogenic and pharmacokinetic issues. Although downstream processing can remove the aggregated forms, inhibiting aggregate formation upstream during the cell culture stage could reduce the burden on downstream processing and potentially improve process yields. This study first examined the effects of environmental factors (temperature, pH, and dissolved oxygen) and medium components (bivalent copper ion, cysteine, and cystine) on the aggregation of two different recombinant fusion proteins expressed by Chinese hamster ovary (CHO) cells. Any strategy to reduce protein aggregation upstream during cell culture must also consider potential effects on critical upstream parameters such as cell growth, harvest titer, and protein sialylation levels. Manipulating the culture temperature shift and cystine concentration in the medium were both identified as effective and practical strategies for reducing protein aggregation in both CHO-cell expression systems. Furthermore, a combination of both strategies was more effective in reducing protein aggregation levels compared to either approach individually; and without any negative effects on harvest titer and protein sialylation. This study demonstrates a practical methodology for decreasing protein aggregation during upstream processing and emphasizes the importance of process understanding to ensure production of recombinant glycoprotein therapeutics with consistent product quality.     

重组毕氏酵母中降解hIFNβ-HSA蛋白酶的鉴定及其活性控制

研究了重组毕赤酵母KM71／pPIC9K—IFNβ-HSA表达融合蛋白hIFNβ—HSA过程中产物降解的问题。十二烷基磺酸钠-聚丙烯酰胺凝胶电泳（SDS—PAGE）和Western—Blotting分析结果表明,发酵液中除了9．0×10^4的目的融合蛋白hIFNβ-HSA外,同时还出现了6．5×10^4的降解带,进一步结合HPLC分析证实该降解发生在融合蛋白hIFNβ—HSA的HSA区域。在此基础上,采用十二烷基磺酸钠-聚丙烯酰胺凝胶电泳（SDS—PAGE）活性电泳的方法,确定在融合蛋白hIFNβ-HSA表达的过程中,引起融合蛋白hIFNβ-HSA降解的蛋白酶为蛋白酶B（Proteinase B,PrB）。最后,确定了可以抑制融合蛋白hIFNβ-HSA降解的最佳的蛋白酶抑制剂EDTA,通过在诱导表达阶段添加不同浓度的蛋白酶抑制剂EDTA,使融合蛋白的表达量达到22．18mg/mL,与空白对照组相比增加了61％。     

IRES/polyA-promoter介导的Ang-1与VEGF165双基因表达效率的对比分析

目的:构建IRES及polyA-promoter介导人血管生成素-1(Angiogenin-1,Ang-1)和人血管内皮生长因子165(vascular endothelial growth factor165,VEGF165)双基因共表达的腺病毒载体,比较IRES与polyA-promoter不同表达模式及其对位于二者前后基因的表达效率和诱导兔角膜新生血管的形成功能,为今后构建双基因或多基因高效共表达载体提供实验依据。方法:以pAdTrack-CMV-Ang-1-IRES-VEGF165质粒为模板,PCR扩增人VEGF165及Ang-1基因片段,分别将其亚克隆至改建的 pAdTrack-CMV-PolyA-promoter及pAdTrack-CMV-IRES转移质粒中,构建pTrack-CMV-Ang-1-polyA-promoter-VEGF165、pTrack-CMV- VEGF165-polyA-promoter-Ang-1、pTrack-CMV-VEGF165-IRES-Ang-1基因重组转移质粒,再与腺病毒骨架质粒pAdeasy-1在BJ5183细菌中同源重组,然后经PacI线性化后转染QBI-293A人胚肾成纤维细胞(简称293A细胞),收获腺病毒重组病毒子Ad-Ang-1-polyA-promoter-VEGF165及Ad-VEGF165-polyA-promoter-Ang-1,Ad-VEGF165-IRES-Ang-1,RT-PCR检测Ang-1和VEGF165在QBI-293A细胞中的转录,ELISA法分别检测不同腺病毒载体目的基因的表达量,比较分析Ang-1与VEGF165基因在IRES和polyA-promoter介导的不同腺病毒表达载体中的表达能力,及在同一腺病毒表达载体中前后不同位置的表达效率。并进一步于兔角膜缘注射Ad-Ang-1-polyA-promoter-VEGF165,Ad-VEGF165-polyA-promoter-Ang-1,Ad-VEGF165-IRES-Ang-1,Ad-Ang-1-IRES-VEGF165,检测角膜新生血管的面积,并比较其诱导血管形成能力的差异。结果:测序显示Ang-1和VEGF165序列正确,不同重组腺病毒载体均获得成功包装,病毒效价可达2~5×10¹⁰pfu/ml,RT-PCR检测Ang-1和VEGF165均能有效转录,ELISA法检测结果表明Ang-1、VEGF165基因不仅均能在细胞中有效表达,而且IRES介导的Ang-1及VEGF165基因,无论在IRES上游或下游,其表达量均低于polyA-promoter相同位置的Ang-1及VEGF165基因表达量,大约降低60%~70%左右,同时Ang-1/VEGF165在同一载体上、下游不同位置,其下游基因的表达量均明显低于上游基因表达量,大约降低30%~40%左右。角膜血管形成动物实验的结果表明Ad-VEGF165-PolyA-promoter-Ang-1及Ad-VEGF165-IRES-Ang-1诱导角膜新生血管形成面积和血管密度的能力相对较强,且前者比后者效果更为显著。结论:在腺病毒表达载体中,由IRES/polyA-promoter介导的Ang-1与VEGF165双基因均能在细胞中成功表达,并具血管诱导性,但polyA-promoter比IRES介导的双基因表达效率高,诱导血管形成能力强;同时两者下游基因的表达量及血管诱导性能均明显低于上游基因。     

Rhizosecretion of recombinant proteins from plant hairy roots

Rhizosecretion of a target protein in the hydroponic medium provides an alternative manufacturing platform that simplifies the downstream purification procedure and increases protein yield. In order to increase the production rates of rhizosecreted proteins, we have exploited the ability of Agrobacterium rhizogenes to induce the formation of large amounts of root tissue on transgenic tobacco plants engineered to secrete a model recombinant protein, human secreted alkaline phosphatase (SEAP). The secretion of SEAP from hairy roots induced on the stems of transgenic tobacco plants was 5–7 times higher than that from adventitious transgenic roots.Abbreviations mRNA Messenger RNA - Ri Root-inducing - SEAP Secreted alkaline phosphataseCommunicated by W. Harwood     

Enhancing granulocyte colony-stimulating factor expression in Pichia pastoris through fusion with human serum albumin

Protein fusion technology has emerged as one of the important strategies to increase the level of expression and half-life of therapeutic proteins in heterologous expression systems. Granulocyte colony-stimulating factor (G-CSF) is a hematopoietic growth factor and is clinically used against neutropenia. Enhanced expression and stability of G-CSF were achieved in Pichia pastoris by the way of constructing a fusion protein with human serum albumin (HSA). The strategy involved polymerase chain reaction (PCR) amplification of fragments corresponding to codon-optimized G-CSF and domain 3 of HSA. Overlapping PCR was used to obtain the full-length fused gene (1,184?bp) with a 15-bp linker sequence comprising of 4 Gly and 1 Ser residues. Extracellular expression was carried out downstream of α-factor secretion signal sequence under the control of alcohol oxidase 1 promoter using pPICZαB. Excreted protein in the range of 110–380?mg?L^?1 was observed among the transformants. Effect of aeration and temperature was investigated in one of the transformants (35) overexpressing fusion protein and levels of G-CSF enhanced by 1.8-fold and 2.3-fold, respectively. Assay of biological activity indicated the fusion protein to retain similar cell proliferation activity as the commercial G-CSF preparation.     

Unique characteristics of human mesenchymal stromal/progenitor cells pre-activated in 3-dimensional cultures under different conditions

Background aimsHuman mesenchymal stromal cells (MSCs) are being used in clinical trials, but the best protocol to prepare the cells for administration to patients remains unclear. We previously demonstrated that MSCs could be pre-activated to express therapeutic factors by culturing the cells in 3 dimensions (3D). We compared the activation of MSCs in 3D in fetal bovine serum containing medium and in multiple xeno-free media formulations.MethodsMSC aggregation and sphere formation was studied with the use of hanging drop cultures with medium containing fetal bovine serum or with various commercially available stem cell media with or without human serum albumin (HSA). Activation of MSCs was studied with the use of gene expression and protein secretion measurements and with functional studies with the use of macrophages and cancer cells.ResultsMSCs did not condense into tight spheroids and express a full complement of therapeutic genes in α-minimum essential medium or several commercial stem-cell media. However, we identified a chemically defined xeno-free media, which, when supplemented with HSA from blood or recombinant HSA, resulted in compact spheres with high cell viability, together with high expression of anti-inflammatory (prostaglandin E2, TSG-6 TNF-alpha induced gene/protein 6) and anti-cancer molecules (TRAIL TNF-related apoptosis-inducing ligand, interleukin-24). Furthermore, spheres cultured in this medium showed potent anti-inflammatory effects in a lipopolysaccharide-stimulated macrophage system and suppressed the growth of prostate cancer cells by promoting cell-cycle arrest and cell death.ConclusionsWe demonstrated that cell activation in 3D depends critically on the culture medium. The conditions developed in the present study for 3D culture of MSCs should be useful in further research on MSCs and their potential therapeutic applications.     

A chloroplast transgenic approach to hyper-express and purify Human Serum Albumin, a protein highly susceptible to proteolytic degradation

Human Serum Albumin (HSA) accounts for 60% of the total protein in blood serum and it is the most widely used intravenous protein in a number of human therapies. HSA, however, is currently extracted only from blood because of a lack of commercially feasible recombinant expression systems. HSA is highly susceptible to proteolytic degradation in recombinant systems and is expensive to purify. Expression of HSA in transgenic chloroplasts using Shine-Dalgarno sequence (SD), which usually facilitates hyper-expression of transgenes, resulted only in 0.02% HSA in total protein (tp). Modification of HSA regulatory sequences using chloroplast untranslated regions (UTRs) resulted in hyper-expression of HSA (up to 11.1% tp), compensating for excessive proteolytic degradation. This is the highest expression of a pharmaceutical protein in transgenic plants and 500-fold greater than previous reports on HSA expression in transgenic leaves. Electron micrographs of immunogold labelled transgenic chloroplasts revealed HSA inclusion bodies, which provided a simple method for purification from other cellular proteins. HSA inclusion bodies could be readily solubilized to obtain a monomeric form using appropriate reagents. The regulatory elements used in this study should serve as a model system for enhancing expression of foreign proteins that are highly susceptible to proteolytic degradation and provide advantages in purification, when inclusion bodies are formed.     

Preparation and characterization of a novel exendin-4 human serum albumin fusion protein expressed in Pichia pastoris.

A novel recombinant exendin-4 human serum albumin fusion protein (rEx-4/HSA) expressed in Pichia pastoris was prepared and characterized. Ex-4 is a 39-amino acid peptide isolated from the salivary gland of the lizard Heloderma suspectum and is thought to be a novel therapeutic agent for type 2 diabetes. But to gain a continued effect, the peptide has to be injected twice a day owing to its short plasma half-life (t(1/2) = 2.4 h). To extend the half-life of Ex-4 molecule in vivo, we designed a genetically engineered Ex-4/HSA fusion protein. Between Ex-4 and HSA, a peptide linker GGGGS was inserted and the fusion protein was expressed in methylotrophic yeast P. pastoris with native HSA secretion signal sequence. The recombinant protein was secreted correctly and was obtained with high purity (typically > 98%) by a three-step purification procedure. cAMP assay demonstrated that the fusion protein had a bioactivity similar to Ex-4 for interaction with GLP-1 receptors in vitro. Results from oral glucose tolerance test indicated that rEx-4/HSA could effectively improve glucose tolerance in diabetic db/db mice. Pharmacokinetics studies in cynomologus monkeys also showed that rEx-4/HSA had a much longer plasma half-life. Therefore, rEx-4/HSA fusion protein could potentially be used as a new recombinant biodrug for type 2 diabetes therapy.     

Induction of apoptosis by tumor suppressor FHIT via death receptor signaling pathway in human lung cancer cells

FHIT is a novel tumor suppressor gene located at human chromosome 3p14.2. Restoration of wild-type FHIT in 3p14.2-deficient human lung cancer cells inhibits cell growth and induces apoptosis. In this study, we analyzed potential upstream/downstream molecular targets of the FHIT protein and found that FHIT specifically targeted and regulated death receptor (DR) genes in human non-small-cell lung cancer (NSCLC) cells. Exogenous expression of FHIT by a recombinant adenoviral vector (Ad)-mediated gene transfer upregulated expression of DR genes. Treatment with a recombinant TRAIL protein, a DR-specific ligand, in Ad-FHIT-transduced NSCLC cells considerably enhanced FHIT-induced apoptosis, further demonstrating the involvement of DRs in FHIT-induced apoptosis. Moreover, we also found that FHIT targeted downstream of the DR-mediated signaling pathway. FHIT overexpression disrupted mitochondrial membrane integrity and activated multiple pro-apoptotic proteins in NSCLC cell. These results suggest that FHIT induces apoptosis through a sequential activation of DR-mediated pro-apoptotic signaling pathways in human NSCLC cells.     

Proteolytic stability of recombinant human serum albumin secreted in the yeast Saccharomyces cerevisiae

 In order to direct the persistent expression of recombinant human serum albumin (HSA) from the GAL10 promoter in the yeast Saccharomyces cerevisiae, we carried out periodic feeding of galactose during shake-flask cultures. Unexpectedly, the recombinant protein secreted was observed to undergo rapid degradation, which was apparently accelerated by carbon-source feeding. The extracellular degradation of HSA occurred even in the strain deficient in the major vacuolar proteases PrA and PrB, and in the strain lacking the acidic protease Yap3p (involved in the generation of HSA-truncated fragments). Interestingly, the degradation correlated closely with the acidification of extracellular pH and thus was significantly overcome either by buffering the culture medium above pH 5.0 or by adding amino acid-rich supplements to the culture medium, which could prevent the acidification of medium pH during cultivation. Addition of arginine or ammonium salt also substantially minimized the degradation of HSA, even without buffering. The extracellular degradation activity was not detected in the cell-free culture supernatant but was found to be associated with intact cells. The results of the present study strongly suggest that the HSA secreted in S. cerevisiae is highly susceptible to the pH-dependent proteolysis mediated by cell-bound protease(s) whose activity and expression are greatly affected by the composition of the medium. Received: 23 August 1999 / Received revision: 8 November 1999 / Accepted: 12 December 1999