Optimization of a cultural medium for bacteriocin production by Lactococcus lactis using response surface methodology.

The medium composition for bacteriocin production by Lactococcus lactis ATCC 11454 was optimized using response surface methodology. The selected six factors based on CM medium were sucrose, soybean peptone, yeast extract, KH(2)PO(4), NaCl, and MgSO(4).7H(2)O. Fractional factorial designs (FFD) and the path of steepest ascent were effective in searching for the main factors and approaching the optimum region of the response. By a 2(6-2) FFD, sucrose, soybean peptone, yeast extract, KH(2)PO(4) were found to be significant factors and had positive effects on cell growth, however, only soybean peptone and KH(2)PO(4) were shown to be the two significant factors for bacteriocin production and had negative and positive effects, respectively. The effects of the two main factors on bacteriocin production were further investigated by a central composite design and the optimum composition was found to be 1% sucrose, 0.45% soybean peptone, 1% yeast extract, 2.84% KH(2)PO(4), 0.2% NaCl, and 0.02% MgSO(4) x 7H(2)O. The optimal medium allowed bacteriocin yield to be doubled compared to CM medium.     

重组谷氨酸棒杆菌发酵L-苯丙氨酸培养基的优化

【目的】提高重组谷氨酸棒杆菌发酵L-苯丙氨酸(L-phenylalanine,L-Phe)的产量。【方法】使用正交试验设计以及响应面优化法分别对种子培养基及发酵培养基进行优化,确定了重组谷氨酸棒杆菌发酵L-Phe的最佳种子培养基及最佳发酵培养基。【结果】重组谷氨酸棒杆菌发酵L-Phe最佳种子培养基(g/L):葡萄糖25.0,玉米浆25.0,硫酸铵15.0,硫酸镁1.0,磷酸二氢钾2.0,尿素2.0,p H 6.8-7.0;最佳发酵培养基(g/L):葡萄糖110.0,玉米浆7.0,硫酸铵25.0,硫酸镁1.0,磷酸二氢钾1.0,柠檬酸钠2.0,谷氨酸1.0,碳酸钙25.0,p H 6.8-7.0;在最佳培养基条件下L-Phe产量最高达到9.14 g/L,较优化前的7.46 g/L提高了22.5%。【结论】通过正交试验和响应面分析对重组谷氨酸棒杆菌发酵L-Phe培养基进行优化,明显提高了L-Phe的产量,并确定了葡萄糖、玉米浆和硫酸铵为发酵培养基中影响L-Phe产量的3个关键因子。研究结果为L-Phe的发酵放大提供了依据。     

尖孢镰刀菌生产蒽醌色素的液体发酵条件研究

优化了尖孢镰刀菌液体发酵生产蒽醌类红色素的发酵条件。通过单因素实验和正交优化实验,确定最佳产色素发酵培养基为：可溶性淀粉30％,(NH4)2SO4 3％,MgSO4 0.3％,KH2PO4 4％,pH 6.0。产色素最适培养条件为：初始pH6.0,装液量20％,接种量10％,吐温-80添加量1％,温度28℃,摇床转速200r/min,发酵周期120h。此条件下,色素效价即可达到8.184U/ml,比优化前提高了1.8倍。国内首次对尖孢镰刀菌所产蒽醌色素进行研究,为其进一步应用奠定基础。     

Effect of the physiological conditions on alpha-amylase and glucoamylase formation by a selected strain of Aspergillus oryzae

The production of alpha-amylase and glucoamylase by a selected strain of Aspergillus oryzae was investigated using different carbon and nitrogen sources. The best and most economic fermentation medium for the production of the both amylases in submerged cultures had the following composition (in %): defatted rice brain, 8; corn steep liquor, 3; MgSO4 X 7H2O, 0.1; KH2PO4, 0.1; CaCl2, 0.1. The optimum pH was 5.0. The optimal conditions for biosynthesis of the amylases were as follows: cultivation at 28 degrees C for 96 h using the 0.5% mycelial suspension as an inoculum.     

休哈塔假丝酵母HDYXHT-01利用木糖生产乙醇的发酵工艺优化

采用Plackett-Burman (PB) 方法和中心组合设计 (Ccentral composit design,CCD) 对休哈塔假丝酵母Candida shehataeHDYXHT-01利用木糖发酵生产乙醇的工艺进行优化。PB试验设计与分析结果表明：硫酸铵、磷酸二氢钾、酵母粉和接种量是影响木糖乙醇发酵的4个关键因素,以乙醇产量为响应目标,采用CCD和响应面分析法 (Response surface methodology,RSM),确定了木糖乙醇发酵的最佳工艺为：硫酸铵1.73 g/L、磷酸二氢钾3.56 g/L、酵母粉2.62 g/L和接种量5.66％,其他发酵条件为：木糖80 g/L,MgSO4·7H2O 0.1 g/L,pH 5.0,培养温度30 ℃,装液量100 mL/250 mL,摇床转速140 r/min,发酵时间48 h,在该条件下发酵液中乙醇产量可以达到26.18 g/L,比未优化前提高了1.15倍。     

嗜线虫致病杆菌产生抗生素的培养基及条件

本对嗜线虫致病杆菌（Xenorhadbus nematophilus）产生抗生素的发酵培养基和发酵条件进行了研究,同时对该菌代谢过程pH值、还原糖、总糖、氨基氮与抗生素产量的关系进行了分析,通过筛选该菌对碳源和氮源的要求,用正交试验初步确定了该菌产素的最佳发酵培养基和条件为：玉米粉1％,大豆粉3％,蔗糖1％,蛋白胨1.5％,KH2PO40.02％,MgSO40.2％,活化剂T0.1％;发酵培养基的起始pH值在6.0－8.0,种龄16h,接种量4％,500mL摇瓶装量15－150mL的条件下培养72h可获得较高的抗生素产量;产素量与菌代谢过程中pH、还原糖、总糖和氨基氮的变化有一定关系,通过培养基和培养条件的研究使该菌的产抗生素能力提高了56.3％。     

生防菌Ⅲ-61抗真菌活性产物的摇瓶发酵

对生防链霉菌Ⅲ-61产生抗真菌活性物质的摇瓶发酵工艺进行了研究。利用正交试验设计优化了发酵培养基组分,其最适配方为黄豆粉1．5％,蛋白胨0．3％,蔗糖1．0％,淀粉1．3％,磷酸二氢钾0．02％,硫酸镁0．025％,氯化钠0．5％,配咸水溶液,调pH至7～7．4,加碳酸钙1％。通过单因素试验,筛选获得了最优培养条件组合：液体种龄24h,接种量5％～10％,500mL摇瓶培养基装量为80mL,摇床转速240r／min,培养温度31℃,发酵周期96～120h。此优化的发酵培养基与发酵条件的组合昕得菌株Ⅲ-61发酵液对主要靶标黄瓜灰霉病菌的抑菌圈直径达49．5mm,较优化前提高了45．59％。     

古尼拟青霉最佳镇痛活性培养基的筛选

以1株有镇痛活性的古尼拟青霉为试验材料,从5种培养基中筛选出使该株产生最佳镇痛活性成分的培养基。结果表明:产生镇痛活性成分的最佳发酵时间为6 d,最佳培养基为改良沙氏培养基Ⅰ,其成分为葡萄糖20 g,甘油5 g,可溶性淀粉5 g,KCl 0.5 g,MgSO4.7H2O 0.5 g,KH2PO4.3H2O 1 g,FeSO4.7H2O 0.5 g,pH 7～8。     

产低温脂肪酶菌株CZW001发酵培养基优化研究

【目的】研究产低温脂肪酶菌株CZW001发酵培养基。【方法】在单因素试验的基础上, 采用Plackett-Burman (P-B)设计, Box-Behnken (B-B)设计和响应面试验设计(RSM), 在20 °C、pH 8.0、160?r/min发酵2 d条件下, 对发酵培养基进行优化。【结果】该菌株最适产酶培养基为(g/L): 葡萄糖7.68, 橄榄油21.93, 硫酸铵2.0, 磷酸二氢钾1.0, 硫酸镁0.27, 氯化钙0.3, 氯化钠20.0, 吐温-80 1.0。其最高酶活为62.8 U/mL, 比优化前提高了3.14倍。【结论】通过对产低温脂肪酶菌株CZW001发酵培养基优化研究, 明显提高低温脂肪酶活力。     

Components of fermentation medium regulate bacteriocin synthesis by the recombinant strain Lactococcus lactis subsp. lactis F-116

The regulation of the synthesis of bacteriocin produced by the recombinant strain Lactococcus lactis subsp. lactis F-116 has been studied. The synthesis is regulated by the components of the fermentation medium, the content of inorganic phosphate (KH2PO4), yeast autolysate (source of amine nitrogen), and changes in carbohydrates and amino acids. The strain was obtained by fusion of protoplasts derived from two related L. lactis subsp. lactis strains, both exhibiting a weak ability to synthesize the bacteriocin nisin. Decreasing the content of KH2PO4 from 2.0 to 1.0 or 0.5% caused bacteriocin production to go down from 4100 to 2800 or 1150 IU/ml, respectively; the base fermentation medium contained 1.0% glucose, 0.2% NaCl, 0.02% MgSO4, and yeast autolysate (an amount corresponding to 35 mg % ammonium nitrogen). The substitution of sucrose for glucose (as the source of carbon) increased the antibiotic activity by 26%, and the addition of isoleucine, by 28.5%. Elevation of the concentration of yeast autolysate in the low-phosphate fermentation medium stimulated both the growth of the lactococci and the synthesis of bacteriocin. Introduction of 1% KH2PO4, yeast autolysate (in an amount corresponding to 70 mg % ammonium nitrogen), 2.0% sucrose, and 0.1% isoleucine increased the bacteriocin-producing activity of the strain by 2.4 times.     

内生真菌Preussia sp.液体发酵生产抗肿瘤活性产物Spiropreussione A 的研究

螺光黑壳菌酮A(Spiropreussione A,SP-A)是编号为AS-5的光黑壳属内生真菌Preussia sp.的代谢产物。体外实验表明SP-A对人卵巢癌细胞A2780和人肝癌细胞BEL-7404的半数抑制浓度(IC50)分别为2.4和3.0μmol/L。以SP-A的含量为主要指标,结合AS-5的生物量,通过单因素实验和正交实验,优化确定了适合SP-A积累的AS-5液体发酵培养基和培养条件。研究结果表明:AS-5发酵生产SP-A的最优培养基为葡萄糖2%,麦麸3%,磷酸二氢钾0.3%,硫酸镁0.15%,pH7.0;该菌株最佳摇瓶发酵条件为250mL摇瓶装125mL培养基,接种6片直径9mm的PDA菌片,培养温度25℃,发酵周期16d。在此条件下发酵,SP-A的含量可以达到(25.02±1.02)mg/瓶,比优化前的含量[(17.08±3.24)mg/瓶]提高了46.5%。     

响应面法优化枯草芽孢杆菌产脂肪酶的合成培养基

对枯草芽孢杆菌(Bacillus subtilis)CICC20034利用合成培养基液体发酵产脂肪酶的条件进行了优化。首先采用单因子实验筛选出最适诱导剂为三丁酸甘油酯,氮源为尿素,碳源为葡萄糖,无机盐为MgSO4。在此基础上,利用Plackett-Burman设计对影响产酶因素的效应进行评价,筛选出具有显著效应的三丁酸甘油酯、尿素、KH2PO4和培养基起始pH值4个最显著的因素。用最陡爬坡路径逼近最大产酶区域后,利用响应面中心组合设计对显著因素进行优化,获得最适合成培养基组分为:葡萄糖8g/L,尿素8.57g/L,三丁酸甘油酯2.62%,KH2PO42.59g/L,MgSO4.7H2O0.5g/L,TritonX-1000.5g/L,pH9.47。优化后的B.subtilis CICC 20034胞外脂肪酶活力达0.483U/ml,比初始酶活力0.072U/ml提高了6.7倍。     

假丝酵母E-2产生物表面活性剂摇瓶发酵条件的优化

从扬子石化的废水淤泥中筛选到1株能发酵液体石蜡产脂肽类生物表面活性剂的假丝酵母Candida E-2.通过单因子实验和正交试验,得到了最佳发酵培养基组成(g/L):牛肉膏3.0,蔗糖2.0,酵母膏0.25,KH2PO4 12.5,MgSO4 0.3,NaCl 1.5,CaCl,0.05,尿素0.5 5;液体石蜡10％(体积分数).最佳培养条件:初始pH7.0,接种量0.12g/L,装液量为200mL三角瓶30mL,培养时间为5 d.最终产量提高了2.7倍,达1.582g/L.     

灰树花发酵工艺及培养基研究

详细、系统地研究了碳源、氮源、无机盐、维生素以及种龄、接种量、摇床转速、摇瓶装液量和培养基 pH值等因素对灰树花液体深层发酵菌丝体产量的影响 ,结果表明 :玉米粉、葡萄糖为最佳碳源 ,豆饼粉为最佳氮源 ,KH2 PO4 ,MgSO4 以及少量VB1的添加均使菌丝体产量明显增加     

米根霉发酵生产L-乳酸

报道了Ｌ－乳酸菌株的分离与筛选,探讨了不同碳源、氮源、通气量、温度等发酵条件对产Ｌ－乳酸的影响,从７８株米根霉中筛选出１３株产Ｌ－乳酸较高的菌株,其中米根霉（Ｒｈｉｚｏｐｕｓ ｏｒｙｚａｅ）Ｒｓ９２８产Ｌ－乳酸最高,产酸最稳定。试验结果表明,该菌株最适发酵培养组成（％）：淀粉水解糖１６,ＭｇＳＯ４ ０．０８,ＫＨ２ＰＯ４ ０．０５,ＺｎＳＯ４ ０．０１,ＣａＣＯ３ ７,ｐＨ自然。在６０ｔ发酵罐中,     

Optimization of submerged culture requirements for the production of mycelial growth and exopolysaccharide by Cordyceps jiangxiensis JXPJ 0109

AIMS: The objective of the present study was to investigate the optimal culture requirements for mycelial growth and exopolysaccharide production by Cordyceps jiangxiensis JXPJ 0109 in submerged culture. METHODS AND RESULTS: The effects of medium ingredients (i.e. carbon and nitrogen sources, and growth factor) and other culture requirements (i.e. initial pH, temperature, etc.) on the production of mycelia and exopolysaccharide were observed using a one-factor-at-a-time method. More suitable culture requirements for mycelial growth and exopolysaccharide production were proved to be maltose, glycerol, tryptone, soya bean steep powder, yeast extract, medium capacity 200 ml in a 500-ml flask, agitation rate 180 rev min(-1), seed age 4-8 days, inoculum size 2.5-7.5% (v/v), etc. The optimal temperatures and initial pHs for mycelial growth and exopolysaccharide production were at 26 degrees C and pH 5 and at 28 degrees C and pH 7, respectively, and corresponding optimal culture age were observed to be 8 and 10 days respectively. According to the primary results of the one-factor-at-a-time experiments, the optimal medium for the mycelial growth and exopolysaccharide production were obtained using an orthogonal layout method to optimize further. Herein the effects of medium ingredients on the mycelial growth of C. jiangxiensis JXPJ 0109 were in the order of yeast extract > tryptone > maltose > CaCl2 > glycerol > MgSO4 > KH2PO4 and the optimal concentration of each composition was 15 g maltose (food-grade), 10 g glycerol, 10 g tryptone, 10 g yeast extract, 1 g KH2PO4, 0.2 g MgSO4, and 0.5 g CaCl2 in 1 l of distilled water, while the order of effects of those components on exopolysaccharide production was yeast extract > maltose > tryptone > glycerol > KH2PO4 > CaCl2 > MgSO4, corresponding to the optimal concentration of medium was as follows: 20 g maltose (food-grade), 8 g glycerol, 5 g tryptone, 10 g yeast extract, 1 g KH2PO4, and 0.5 g CaCl2 in 1 l of distilled water. CONCLUSIONS: Under the optimal culture requirements, the maximum exopolysaccharide production reached 3.5 g l(-1) after 10 days of fermentation, while the maximum production of mycelial growth achieved 14.5 g l(-1) after 8 days of fermentation. SIGNIFICANCE AND IMPACT OF THE STUDY: This is the first report on the submerged culture requirements for mycelial growth and exopolysaccharide in C. jiangxiensis, and this two-step optimization strategy in this study can be widely applied to other microbial fermentation processes.     

Medium optimization for the production of thermal stable beta-glucanase by Bacillus subtilis ZJF-1A5 using response surface methodology

Polysaccharides, such as barley flour, dextrin and soluble starch, were better carbon sources than monosaccharides and disaccharides, such as glucose and maltose, for cell growth of Bacillus subtilis ZJF-1A5 and beta-glucanase production. beta-Glucanase produced by B. subtilis ZJF-1A5 was associated partially with cell growth and increased significantly when cells entered stationary phase; yeast extract was the best nitrogen source, followed by soybean flour. All inorganic nitrogen sources chosen in the experiments were not favorable for cell growth and enzyme production. A fractional factorial design (2(6-2)) was applied to elucidate medium components that significantly affect beta-glucanase production. The concentration of barley flour, corn flour and soybean flour in medium were significant factors. The steepest ascent method was used to locate the optimal domain and a central composite design was used to estimate the quadratic response surface from which the factor levels for maximum production of beta-glucanase were determined. The composition of fermentation medium optimized with response surface methodology was (g/l): barley flour, 63.5; corn flour, 44.8; KH2PO4, 1.0; MgSO4 x 7H2O, 0.1; CaCl2, 0.1. beta-Glucanase activity was 251 U/ml at 48 h using optimized medium, 1.4 times higher than that in original medium.     

杂色云芝产漆酶的发酵条件研究*

本文对杂色云芝（Coriolus versicolor）产漆酶的发酵条件作了研究。结果表明摇瓶实验产漆酶（Laccase）的最佳培养基成分为：可溶性淀粉 2g/L, NH4Cl 24mmol/L, 微量元素混合液 7ml/L, pH3.0柠檬酸—Na2HPO4缓冲溶液 0.01mol/L, KH2PO4 1.4×10-2 mol/L, MgSO4·7H2O 2.03×10-3mol/L, CaCl2·2H2O 6.8×10-4 mol/L, VB1 2.97×10-6 mol/L, 吐温80 4.0g/L, 愈创木酚0.01mmol/L, CuSO4 ·5H2O 0.005mmol/L,最佳发酵条件为培养基初始pH3.0, 菌体生长6d,培养基装量为250ml三角瓶中25ml培养液,25℃条件下振荡培养(150r/min)9d。     

高产纤维素酶枯草芽胞杆菌S-16的筛选及其发酵工艺优化

利用刚果红鉴别培养基及基础液体筛选培养基进行菌种筛选,从新疆盐碱地分离得到的16株菌株中筛选获得一株产纤维素酶活力较高的菌株S-16,对该菌株进行16SrDNA鉴定,确定该菌为枯草芽胞杆菌(Bacillus subtilis)。对S-16发酵产纤维素酶的主要影响因素进行研究,分别考察了碳源、氮源、培养基初始pH和接种量等因素对发酵产纤维素酶的影响。结合单因素影响实验得到优化后的培养基配方为:羧甲基纤维素钠1.5%,酵母粉1%,NaCl 1%,MgSO_4·7H_2O 2‰,KH_2PO_4·3H_2_O 1‰。优化后的发酵条件为:初始pH为8,接种量1%,种龄8h,培养时间48h。经过发酵工艺优化,S-16产生的羧甲基纤维素酶活(CMCase)和滤纸酶活(FPase)分别达到4.64IU/mL和0.46IU/mL,与初始培养条件下的酶活相比分别提高了3.14倍和1.30倍。本研究得到的枯草芽胞杆菌S-16及其优化发酵工艺为秸秆的快速腐熟和高产纤维素酶的应用奠定了基础。     

桦褐孔菌菌丝体及甾类化合物的发酵条件优化

对桦褐孔菌深层发酵培养基进行了筛选,以菌丝体及甾类化合物产量为目标对发酵条件进行了优化,确定最佳发酵条件为：30g/L葡萄糖,2.5g/L黄豆粉,2.5g/L蛋白胨,3g/L KH2PO4,0.8g/L MgSO4,0.8g/L CaSO4,初始pH4.0,接种量15%,装液量100mL/500mL,转速150r/min,28℃恒温培养。此条件下培养11d,菌丝体干重达12.52g/L,甾体类化合物的产量达112.44mg/L。