Color mutants of Aspergillus flavus and Aspergillus parasiticus in a study of preharvest invasion of peanuts.

A comparison of the invasion of flowers, aerial pegs, and kernels by wild-type and mutant strains of Aspergillus flavus or A. parasiticus along with aflatoxin analyses of kernels from different drought treatments have supported the hypothesis that preharvest contamination with aflatoxin originates mainly from the soil. Evidence in support of soil invasion as opposed to aerial invasion was the following. A greater percentage of invasion of kernels rather than flower or aerial pegs by either wild-type A. flavus or mutants. Significant invasion by an A. parasiticus color mutant occurred only in peanuts from soil supplemented with the mutant, whereas adjacent plants in close proximity but in untreated soil were only invaded by wild-type A. flavus or A. parasiticus. Aflatoxin data from drought-stressed, visibly undamaged peanut kernels showed that samples from soil not supplemented with a mutant strain contained a preponderance of aflatoxin B's (from wild-type A. flavus) whereas adjacent samples from mutant-supplemented soil contained a preponderance of B's plus G's (from wild-type and mutant A. parasiticus). Preliminary data from two air samplings showed an absence of propagules of A. flavus or A. parasiticus in air around the experimental facility.     

Influence of Fungicides and Irrigation Practice on Aflatoxin in Peanuts Before Digging

Peanuts grown under dryland conditions where drought stress occurred accumulated more aflatoxin before digging than peanuts grown under irrigation. Kernels became more susceptible to Aspergillus flavus and A. parasiticus invasion when the soil moisture in the pod zone approached levels at which moisture moved from the pod into the soil and the kernel moisture dropped below 31%. Isolation frequencies of these aspergilli from fresh-dug kernels were lowest in 1968 (maximum of 3%). In 1967 and 1969, maximum percentages of 100 and 74, respectively, were noted. Kernel infestation was correlated with degree of aflatoxin contamination. Dryland fresh-dug kernels contained a maximum of 35,800 parts per billion aflatoxin while a maximum of 50 parts per billion was detected in kernels from irrigated plots. In 1969 A. flavus infestation was as high as 59% in peanuts from irrigated plots; however, no aflatoxin was detected. Absence of aflatoxin in these samples is attributed to the higher kernel moisture content which reduced the aflatoxin-producing potential of A. flavus. Statistical analysis of the data revealed no significant differences in degree of fungal infestation, production levels, and grade factors between any fungicide treatments.     

Effect of pyridazinone herbicides on growth and aflatoxin release by Aspergillus flavus and Aspergillus parasiticus

The influence of pyridazinone herbicides on aflatoxin production by Aspergillus flavus and A. parasiticus was studied in liquid media. Mycelia production was not affected by 20, 40, or 60 micrograms of herbicide per ml; however, aflatoxin production by A. parasiticus was higher in media with herbicide, whereas A. flavus produced lower aflatoxin levels.     

Effect of pyridazinone herbicides on growth and aflatoxin release by Aspergillus flavus and Aspergillus parasiticus.

The influence of pyridazinone herbicides on aflatoxin production by Aspergillus flavus and A. parasiticus was studied in liquid media. Mycelia production was not affected by 20, 40, or 60 micrograms of herbicide per ml; however, aflatoxin production by A. parasiticus was higher in media with herbicide, whereas A. flavus produced lower aflatoxin levels.     

Substrate-induced lipase gene expression and aflatoxin production in Aspergillus parasiticus and Aspergillus flavus

AIMS: To establish a relationship between lipase gene expression and aflatoxin production by cloning the lipA gene and studying its expression pattern in several aflatoxigenic and nontoxigenic isolates of Aspergillus flavus and A. parasiticus. METHODS AND RESULTS: We have cloned a gene, lipA, that encodes a lipase involved in the breakdown of lipids from aflatoxin-producing A. flavus, A. parasiticus and two nonaflatoxigenic A. flavus isolates, wool-1 and wool-2. The lipA gene was transcribed under diverse media conditions, however, no mature mRNA was detected unless the growth medium was supplemented with 0.5% soya bean or peanut oil or the fungus was grown in lipid-rich medium such as coconut medium. The expression of the lipase gene (mature mRNA) under substrate-induced conditions correlated well with aflatoxin production in aflatoxigenic species A. flavus (SRRC 1007) and A. parasiticus (SRRC 143). CONCLUSIONS: Substrate-induced lipase gene expression might be indirectly related to aflatoxin formation by providing the basic building block 'acetate' for aflatoxin synthesis. No direct relationship between lipid metabolism and aflatoxin production can be ascertained, however, lipase gene expression correlates well with aflatoxin formation. SIGNIFICANCE AND IMPACT OF THE STUDY: Lipid substrate induces and promotes aflatoxin formation. It gives insight into genetic and biochemical aspects of aflatoxin formation.     

Cloning of the afl-2 gene involved in aflatoxin biosynthesis from Aspergillus flavus.

Aflatoxins are extremely potent carcinogens produced by Aspergillus flavus and Aspergillus parasiticus. Cloning of genes in the aflatoxin pathway provides a specific approach to understanding the regulation of aflatoxin biosynthesis and, subsequently, to the control of aflatoxin contamination of food and feed. This paper reports the isolation of a gene involved in aflatoxin biosynthesis by complementation of an aflatoxin-nonproducing mutant with a wild-type genomic cosmid library of A. flavus. Strain 650-33, blocked in aflatoxin biosynthesis at the afl-2 allele, was complemented by a 32-kb cosmid clone (B9), resulting in the production of aflatoxin. The onset and profile of aflatoxin accumulation was similar for the transformed strain and the wild-type strain (NRRL 3357) of the fungus, indicating that the integrated gene is under the same control as in wild-type strains. Complementation analyses with DNA fragments from B9 indicated that the gene resides within a 2.2-kb fragment. Because this gene complements the mutated afl-2 allele, it was designated afl-2. Genetic evidence obtained from a double mutant showed that afl-2 is involved in aflatoxin biosynthesis before the formation of norsolorinic acid, the first stable intermediate identified in the pathway. Further, metabolite feeding studies with the mutant, transformed, and wild-type cultures and enzymatic activity measurements in cell extracts of these cultures suggest that afl-2 regulates gene expression or the activity of other aflatoxin pathway enzymes. This is the first reported isolation of a gene for aflatoxin biosynthesis in A. flavus.     

Quantification of conidial density of Aspergillus flavus and A. parasiticus in soil from almond orchards using real-time PCR

Aims:  To design the Aspergillus flavus and Aspergillus parasiticus -specific primers and a real-time PCR assay for quantification of the conidial density in soil.
Methods and Results:  Aspergillus flavus and A. parasiticus -specific DNA primers were designed based on internal transcribed spacer sequences to distinguish these two species and from other Aspergillus and other fungal species. A method of pathogen DNA extraction directly from soil samples was developed. Using the designed primers, a real-time PCR assay was developed to quantitatively determine the conidial density of each A. flavus and A. parasiticus in soil, after generating corresponding standard curves. Known conidial densities of each A. flavus or A. parasiticus in soil significantly correlated with those tested with the real-time PCR.
Conclusions:  This study demonstrated the applicability of the real-time PCR assay in studies of quantifying A. flavus and A. parasiticus in soil as inoculum sources.
Significance and Impact of the Study:  The A. flacus and A. parasitic -specific primers can be widely used in aflatoxin research. The real-time PCR assay developed in this study provides a potential approach to quantify the plant pathogen density from not only soil but also other sources in relation to aflatoxin contamination from environment, food and feed commodities.     

Effect of corn and peanut cultivation on soil populations of Aspergillus flavus and A. parasiticus in southwestern Georgia.

The effect of corn and peanut cultivation on the proportion of Aspergillus flavus to A. parasiticus in soil was examined. Soil populations were monitored in three fields during three different years in southwestern Georgia. Each field was planted in both peanuts and corn, and soil was sampled within plots for each crop. A. flavus and A. parasiticus were present in similar proportions in plots from all fields at the beginning of the growing season. A. terreus, A. niger, and A. fumigatus were the other dominant aspergilli in soil. Fields A and B did not show drought stress in peanut or corn plants, and soil populations of A. flavus and A. parasiticus remained stable during the course of the year. In field C, drought stress in corn plants with associated A. flavus infection and aflatoxin contamination greatly increased soil populations of A. flavus relative to A. parasiticus upon dispersal of corn debris to the soil surface by a combine harvester. Colonization of organic debris after it has been added to the soil may maintain soil populations of A. parasiticus despite lower crop infection.     

Direct visual detection of aflatoxin synthesis by minicolonies of Aspergillus species

Single-spore colonies of Aspergillus flavus and Aspergillus parasiticus, grown for 4 to 5 days at 25 degrees C on a coconut extract agar containing sodium desoxycholate as a growth inhibitor, produced aflatoxin, readily detectable as blue fluorescent zones under long-wave (365 nm) UV light. Over 100 colonies per standard petri dish were scored for aflatoxin production by this procedure. Progeny from some strains remained consistently stable for toxin production after repeated subculture, whereas instability for toxin synthesis was revealed among progeny from other strains. Spore color markers were used to rule out cross-contamination in monitoring strains. A yellow-spored and nontoxigenic strain of A. flavus, reported previously to produce aflatoxin in response to cycloheximide treatment, proved to be toxin negative even after repeated exposure to cycloheximide. Extended series of progeny from another strain of A. flavus and from a strain of A. parasiticus were each compared by this plating procedure and by fluorometric analysis for aflatoxin when grown in a coconut extract broth. Both of these strains showed variation for toxin synthesis among their respective progeny, and specific progeny showed a good correlation for aflatoxin synthesis when examined by the two procedures.     

Direct visual detection of aflatoxin synthesis by minicolonies of Aspergillus species.

Single-spore colonies of Aspergillus flavus and Aspergillus parasiticus, grown for 4 to 5 days at 25 degrees C on a coconut extract agar containing sodium desoxycholate as a growth inhibitor, produced aflatoxin, readily detectable as blue fluorescent zones under long-wave (365 nm) UV light. Over 100 colonies per standard petri dish were scored for aflatoxin production by this procedure. Progeny from some strains remained consistently stable for toxin production after repeated subculture, whereas instability for toxin synthesis was revealed among progeny from other strains. Spore color markers were used to rule out cross-contamination in monitoring strains. A yellow-spored and nontoxigenic strain of A. flavus, reported previously to produce aflatoxin in response to cycloheximide treatment, proved to be toxin negative even after repeated exposure to cycloheximide. Extended series of progeny from another strain of A. flavus and from a strain of A. parasiticus were each compared by this plating procedure and by fluorometric analysis for aflatoxin when grown in a coconut extract broth. Both of these strains showed variation for toxin synthesis among their respective progeny, and specific progeny showed a good correlation for aflatoxin synthesis when examined by the two procedures.     

Aflatoxin production by entomopathogenic isolates of Aspergillus parasiticus and Aspergillus flavus

Fourteen isolates of Aspergillus parasiticus and 2 isolates of Aspergillus flavus isolated from the mealybug Saccharicoccus sacchari were analyzed for production of aflatoxins B1, B2, G1, and G2 in liquid culture over a 20-day period. Twelve Aspergillus isolates including 11 A. parasiticus and 1 A. flavus produced aflatoxins which were extracted from both the mycelium and culture filtrate. Aflatoxin production was detected at day 3 and was detected continually for up to day 20. Aflatoxin B1 production was greatest between 7 and 10 days and significantly higher quantities were produced by A. flavus compared to A. parasiticus. Aflatoxin production was not a stable trait in 1 A. parasiticus isolate passaged 50 times on agar. In addition to loss of aflatoxin production, an associated loss in sporulation ability was also observed in this passaged isolate, although it did maintain pathogenicity against S. sacchari. An aflatoxin B1 concentration of 0.16 micrograms/mealybug (14.2 micrograms/g wet wt) was detected within the tissues of infected mealybugs 7 days after inoculation. In conclusion, the ability of Aspergillus isolates to produce aflatoxins was not essential to the entomopathogenic activity of this fungus against its host S. sacchari.     

Aflatoxin contamination of developing corn kernels

Preharvest of corn and its contamination with aflatoxin is a serious problem. Some environmental and cultural factors responsible for infection and subsequent aflatoxin production were investigated in this study. Stage of growth and location of kernels on corn ears were found to be one of the important factors in the process of kernel infection with A. flavus & A. parasiticus. The results showed positive correlation between the stage of growth and kernel infection. Treatment of corn with aflatoxin reduced germination, protein and total nitrogen contents. Total and reducing soluble sugar was increase in corn kernels as response to infection. Sucrose and protein content were reduced in case of both pathogens. Shoot system length, seeding fresh weigh and seedling dry weigh was also affected. Both pathogens induced reduction of starch content. Healthy corn seedlings treated with aflatoxin solution were badly affected. Their leaves became yellow then, turned brown with further incubation. Moreover, their total chlorophyll and protein contents showed pronounced decrease. On the other hand, total phenolic compounds were increased. Histopathological studies indicated that A. flavus & A. parasiticus could colonize corn silks and invade developing kernels. Germination of A. flavus spores was occurred and hyphae spread rapidly across the silk, producing extensive growth and lateral branching. Conidiophores and conidia had formed in and on the corn silk. Temperature and relative humidity greatly influenced the growth of A. flavus & A. parasiticus and aflatoxin production.     

Colonization of wounded peanut seeds by soil fungi: selectivity for species from Aspergillus section Flavi

Soil is a source of primary inoculum for Aspergillus flavus and A. parasiticus, fungi that produce highly carcinogenic aflatoxins in peanuts. Aflatoxigenic fungi commonly invade peanut seeds during maturation, and the highest concentrations of aflatoxins are found in damaged seeds. A laboratory procedure was developed in which viable peanut seeds were wounded and inoculated with field soil containing natural populations of fungi, then incubated under different conditions of seed water activity and temperature. Densities of Aspergillus section Flavi in soil used for inoculating seeds were low relative to the total numbers of filamentous fungi (<1%). Aspergillus species from section Flavi present in soil included A. flavus morphotypes L and S strains, A. parasiticus, A. caelatus, A. tamarii and A. alliaceus. Wounding was required for high incidences of fungal colonization; viability of wounded seeds had little effect on colonization by Aspergillus species. Peanut seeds were colonized by section Flavi species as well as A. niger over broad ranges of water activity (0.82-0.98) and temperature (15-37 C), and the highest incidences of seed colonization occurred at water activities of 0.92-0.96 at 22-37 C. A. parasiticus colonized peanut seeds at lower temperatures than A. flavus, and cool soil temperatures relative to temperatures of aerial crop fruits might explain why A. parasiticus is found mostly in peanuts. Other fungi, dominated by the genera Penicillium, Fusarium and Clonostachys, colonized seeds primarily at water activities and temperatures suboptimal for section Flavi species and A. niger. Eupenicillium ochrosalmoneum frequently sporulated on the conidial heads of section Flavi species and showed specificity for these fungi. The inoculation of wounded viable peanut seeds with soil containing natural populations of fungi provides a model system for studying the infection process, the interactions among fungi and those factors important in aflatoxin formation.     

Effects of soil moisture and temperature on preharvest invasion of peanuts by the Aspergillus flavus group and subsequent aflatoxin development

Four soil temperature and moisture treatment regimens were imposed on Florunner peanuts 94 days after planting in experimental plots in 1980. At harvest (145 days after planting), the incidence of the Aspergillus flavus group and the aflatoxin concentration were greatest in damaged kernels. Extensive colonization of sound mature kernels (SMK) by the A. flavus group occurred with the drought stress treatment (56% kernels colonized); colonization was less in the irrigated plot (7%) and the drought stress plot with cooled soil (11%) and was intermediate in the irrigated plot with heated soil (26%). Aflatoxin was virtually absent from SMK with the last three treatments, but it was found at an average concentration of 244 ppb (ng/g) in drought-stressed SMK. Colonization of SMK by the A. flavus group and aflatoxin production were greater with hot dry conditions. Neither elevated temperature alone nor drought stress alone caused aflatoxin contamination in SMK. When the ratio of SMK colonized by A. flavus compared with A. niger was greater than 19:1, there was aflatoxin contamination, but there was none if this ratio was less than 9:1. Irrigation caused a higher incidence of A. niger than drought did. This may have prevented the aflatoxin contamination of undamaged peanuts.     

Effects of soil moisture and temperature on preharvest invasion of peanuts by the Aspergillus flavus group and subsequent aflatoxin development.

Four soil temperature and moisture treatment regimens were imposed on Florunner peanuts 94 days after planting in experimental plots in 1980. At harvest (145 days after planting), the incidence of the Aspergillus flavus group and the aflatoxin concentration were greatest in damaged kernels. Extensive colonization of sound mature kernels (SMK) by the A. flavus group occurred with the drought stress treatment (56% kernels colonized); colonization was less in the irrigated plot (7%) and the drought stress plot with cooled soil (11%) and was intermediate in the irrigated plot with heated soil (26%). Aflatoxin was virtually absent from SMK with the last three treatments, but it was found at an average concentration of 244 ppb (ng/g) in drought-stressed SMK. Colonization of SMK by the A. flavus group and aflatoxin production were greater with hot dry conditions. Neither elevated temperature alone nor drought stress alone caused aflatoxin contamination in SMK. When the ratio of SMK colonized by A. flavus compared with A. niger was greater than 19:1, there was aflatoxin contamination, but there was none if this ratio was less than 9:1. Irrigation caused a higher incidence of A. niger than drought did. This may have prevented the aflatoxin contamination of undamaged peanuts.     

Cloning of the Aspergillus parasiticus apa-2 gene associated with the regulation of aflatoxin biosynthesis.

An Aspergillus parasiticus gene, designated apa-2, was identified as a regulatory gene associated with aflatoxin biosynthesis. The apa-2 gene was cloned on the basis of overproduction of pathway intermediates following transformation of fungal strains with cosmid DNA containing the aflatoxin biosynthetic genes nor-1 and ver-1. Transformation of an O-methylsterigmatocystin-accumulating strain, A. parasiticus SRRC 2043, with a 5.5-kb HindIII-XbaI DNA fragment containing apa-2 resulted in overproduction of all aflatoxin pathway intermediates analyzed. Specific enzyme activities associated with the conversion of norsolorinic acid and sterigmatocystin were increased approximately twofold. The apa-2 gene was found to complement an A. flavus afl-2 mutant strain for aflatoxin production, suggesting that apa-2 is functionally homologous to afl-2. Comparison of the A. parasiticus apa-2 gene DNA sequence with that of the A. flavus afl-2 gene (G. A. Payne, G. J. Nystorm, D. Bhatnagar, T. E. Cleveland, and C. P. Woloshuk, Appl. Environ. Microbiol. 59:156-162, 1993) showed that they shared > 95% DNA homology. Physical mapping of cosmid subclones placed apa-2 approximately 8 kb from ver-1.     

Biosynthetic origin of aflatoxin G1: confirmation of sterigmatocystin and lack of confirmation of aflatoxin B1 as precursors

The origin of aflatoxin G1 was studied using mutant strains of Aspergillus parasiticus blocked early in the pathway and by tracing 14C-labelled aflatoxin B1 (AFB1) in wild-type A. flavus and A. parasiticus strains. Sterigmatocystin (ST) was a precursor of AFB1, AFG1 and AFG2 in the four mutants examined. The identity of AFG1 was confirmed by mass spectrometry. No evidence for conversion of AFB1 to AFG1 was found. A rigorously controlled study of conversions of radioactivity based on preparative thin-layer chromatography of aflatoxins demonstrated that low levels of aflatoxin interconversions previously reported in the literature might actually be artifacts.     

Intrafungal distribution of aflatoxins among conidia and sclerotia of Aspergillus flavus and Aspergillus parasiticus

This research examines the distribution of aflatoxins among conidia and sclerotia of toxigenic strains of Aspergillus flavus Link and Aspergillus parasiticus Speare cultured on Czapek agar (21 days, 28 degrees C). Total aflatoxin levels in conidia and sclerotia varied considerably both within (intrafungal) and among strains. Aspergillus flavus NRRL 6554 accumulated the highest levels of aflatoxin (conidia: B1, 84000 ppb; G1, 566000 ppb; sclerotia: B1, 135000 ppb; G1, 968000 ppb). Substantial aflatoxin levels in conidia could place at risk those agricultural workers exposed to dust containing large numbers of A. flavus conidia. Cellular ratios of aflatoxin B1 to aflatoxin G1 were nearly identical in conidia and sclerotia even though levels of total aflatoxins in these propagule types may have differed greatly. Aflatoxin G1 was detected in sclerotia of all A. flavus strains but in the conidia of only one strain. Each of the A. parasiticus strains examined accumulated aflatoxin G1 in both sclerotia and conidia. These results are examined in the context of current evolutionary theory predicting an increase in the chemical defense systems of fungal sclerotia, propagules critical to the survival of these organisms.     

Systemic invasion of developing peanut plants by Aspergillus flavus

When grown under glasshouse conditions, peanut plants can be invaded by Aspergillus flavus and A. parasiticus from soil or seed as early as the time of emergence from the soil. Systemic infections may become established. The fungi can spread throughout the plants, though prevalence is higher in parts nearer the soil. Aspergillus flavus is more invasive than A. parasiticus under these conditions.     

Inhibition of Aspergillus growth and aflatoxin release by derivatives of benzoic acid.

A study was conducted to determine the effects of o-nitrobenzoate, p-aminobenzoate, benzocaine (ethyl aminobenzoate), ethyl benzoate, methyl benzoate, salicylic acid (o-hydroxybenzoate), trans-cinnamic acid (beta-phenylacrylic acid), trans-cinnamaldehyde (3-phenylpropenal), ferulic acid (p-hydroxy-3-methoxycinnamic acid), aspirin (o-acetoxy benzoic acid), and anthranilic acid (o-aminobenzoic acid) upon growth and aflatoxin release in Aspergillus flavus NRRL 3145 and A. parasiticus NRRL 3240. A chemically defined medium was supplemented with various concentrations of these compounds and inoculated with spores, and the developing cultures were incubated for 4, 6, and 8 days at 27 degree C in a mechanical shaker. At the beginning of day 8 of incubation, aflatoxins were extracted from cell-free filtrates, separated by thin-layer chromatography, and quantitated by ultraviolet spectrophotometry. The structure of these aromatic compounds appeared to be critically related to their effects on mycelial growth and aflatoxin release. At concentrations of 2.5 and 5.0 mg per 25 ml of medium, methyl benzoate and ethyl benzoate were the most effective in reducing both mycelial growth and aflatoxin release by A. flavus and A. parasiticus. Inhibition of mycelial growth and aflatoxin release by various concentrations of the above-named aromatic compounds may indicate the possibility of their use as fungicides.