Manganese peroxidase production by immobilized Phanerochaete chrysosporium BKM-F-1767 in a cell bioreactor

Manganese-dependent peroxidase (MnP) production was performed in an immobilized cell bioreactor in which Phanerochaete chrysosporium BKM-F-1767 was immobilized on polystyrene foam. The immobilized cell culture yielded significantly greater MnP activity than the conventional stationary liquid culture. Cultivation was carried out in batch mode; the effect of glucose concentration was investigated and growth kinetics parameters were found as, micromax=0.59 day(-1), Ks=0.33 g/L and Kss=14.5. Batch operation led to maximum MnP (770.82 U/L) in the culture medium containing 0.05% Tween 80, 10 g/L glucose, and 174 microM Mn2+ at 37 degrees C and pH 4.5. Enzyme productivity was obtained as 110.12 U/day/L.     

Effect of veratryl alcohol and manganese (IV) oxide on ligninolytic activity in semi solid cultures of Phanerochaete chrysosporium

An inert carrier (nylon sponge), a non-inert carrier (barley straw) and the addition of veratryl alcohol or manganese (IV) oxide to the cultures were used to study the production of ligninolytic enzymes by Phanerochaete chrysosporium BKM-F-1767 (ATCC 24725) during semi solid state fermentation conditions. By supplementing the medium with these compounds we could stimulate the ligninolytic system of this fungus. The different carriers employed and the effect of adding veratryl alcohol or manganese (IV) oxide to the cultures were compared in order to determine the best system to produce high activities of ligninolytic enzymes. Lignin peroxidase (LiP) activities higher than 500 U/L and manganese-dependent peroxidase (MnP) activities about 1100 U/L were achieved.     

Manganese peroxidase production in submerged cultures by free and immobilized mycelia of Nematoloma frowardii

The agaric basidiomycete Nematoloma frowardii has been suggested as a good alternative for production of the extracellular ligninolytic enzyme, manganese-dependent peroxidase (MnP). Some cultural and environmental factors influencing the enzymatic activity in shaken flasks and aerated fermenter cultures were evaluated to improve the yields of the process. A low nitrogen medium (1.36 mM N added as ammonium tartrate), containing 16 g/l glucose (C/N ratio=65.3), 2mM Mn2+ and inoculated with immobilized polyurethane foam mycelium, made it possible to obtain a MnP yield of 2304 nkat/l in 8 days. Under these operational conditions, the enzyme productivity in the immobilized cells of N. frowardii was 1.4 times higher than that obtained with the free fungus. In the procedure with the reusable immobilized mycelium (semi-continuous culture) as many as three subsequent 10 day batches could be fermented by using the same carrier with no loss of MnP activity.     

Manganese Peroxidase, Produced by Trametes versicolor during Pulp Bleaching, Demethylates and Delignifies Kraft Pulp

Previous work has shown that Trametes (Coriolus) versicolor bleaches kraft pulp brownstock with the concomitant release of methanol. In this work, the fungus is shown to produce both laccase and manganese peroxidase (MnP) but not lignin peroxidase during pulp bleaching. MnP production was enhanced by the presence of pulp and/or Mn(II) ions. The maximum level of secreted MnP was coincident with the maximum rate of fungal bleaching. Culture filtrates isolated from bleaching cultures produced Mn(II)- and hydrogen peroxide-dependent pulp demethylation and delignification. Laccase and MnP were separated by ion-exchange chromatography. Purified MnP alone produced most of the demethylation and delignification exhibited by the culture filtrates. On the basis of the methanol released and the total and phenolic methoxyl contents of the pulp, it appears that MnP shows a preference for the oxidation of phenolic lignin substructures. The extensive increase in brightness observed in the fungus-treated pulp was not found with MnP alone. Therefore, either the MnP effect must be optimized or other enzymes or compounds from the fungus are also required for brightening.     

Detoxification of aflatoxin B1 by manganese peroxidase from the white-rot fungus Phanerochaete sordida YK-624

Aflatoxin B(1) (AFB(1) ) is a potent mycotoxin with mutagenic, carcinogenic, teratogenic, hepatotoxic, and immunosuppressive properties. In order to develop a bioremediation system for AFB(1) -contaminated foods by white-rot fungi or ligninolytic enzymes, AFB(1) was treated with manganese peroxidase (MnP) from the white-rot fungus Phanerochaete sordida YK-624. AFB(1) was eliminated by MnP. The maximum elimination (86.0%) of AFB(1) was observed after 48 h in a reaction mixture containing 5 nkat of MnP. The addition of Tween 80 enhanced AFB(1) elimination. The elimination of AFB(1) by MnP considerably reduced its mutagenic activity in an umu test, and the treatment of AFB(1) by 20 nkat MnP reduced the mutagenic activity by 69.2%. (1) H-NMR and HR-ESI-MS analysis suggested that AFB(1) is first oxidized to AFB(1) -8,9-epoxide by MnP and then hydrolyzed to AFB(1) -8,9-dihydrodiol. This is the first report that MnP can effectively remove the mutagenic activity of AFB(1) by converting it into AFB(1) -8,9-dihydrodiol.     

Purification and partial characterization of manganese peroxidase from immobilized Phanerochaete chrysosporium

Solid-state culture of the white-rot fungus Phanerochaete chrysosporium BKMF-1767 (ATCC 24725) has been carried out, using an inert support, polystyrene foam. Suitable medium and culture conditions have been chosen to favor the secretion of manganese peroxidase (MnP). The enzyme was isolated and purified from immobilized P. chrysosporium and partially characterized. Partial protein precipitation in crude enzyme was affected using ammonium sulphate, polyethylene glycol, methanol, and ethanol methods. Fractionation of MnP was performed by DEAE-Sepharose ion exchange chromatography followed by Ultragel AcA 54 gel filtration chromatography. This purification attained 23.08% activity yield with a purification factor of 5.8. According to data on gel filtration chromatography and sodium dodecyl sulphate polyacrylamide gel electrophoresis (SDS-PAGE), the molecular weight of the enzyme was 45 000±1000 Da. The optimum pH and temperature of purified MnP were 4.5 and 30 °C, respectively. This enzyme was stable in the pH range 4.5–6.0, at 25 °C and also up to 35 °C at pH 4.5 for 1 h incubation period. MnP activity was inhibited by 2 mM NaN₃, ascorbic acid, β-mercaptoethanol and dithreitol. The K_m values of MnP for hydrogen peroxide and 2.6-dimetoxyphenol were 71.4 and 28.57 μM at pH 4.5, respectively. The effects of possible inhibitors and activators of enzyme activity were investigated.     

Immobilization of a Thermostable Cellobiose 2-Epimerase from Rhodothermus marinus JCM9785 and Continuous Production of Epilactose

Previous study has shown that a crude manganese peroxidase (MnP) preparation from the fungus could bleach oxygen-alkaline treated hardwood kraft pulp (OKP) with manganese, glucose, and glucose oxidase. Using purified MnP instead of the crude one also did OKP bleaching with Tween 20. We conclude that MnP is important in this fungal bleaching system.     

Rapid decolorization of azo dyes by crude manganese peroxidase from Schizophyllum sp. F17 in solid-state fermentation

The production of ligninolytic enzymes by the fungus Schizophyllum sp. F17 using a cost-effective medium comprised of agro-industrial residues in solid-state fermentation (SSF) was optimized. The maximum activities of the enzymes manganese peroxidase (MnP), laccase (Lac), and lignin peroxidases (LiP) were 1,200, 586, and 109 U/L, respectively, on day 5 of SSF. In vitro decolorization of three structurally different azo dyes by the extracellular enzymes was monitored to determine its decolorization capability. The results indicated that crude MnP, but not LiP and Lac, played a crucial role in the decolorization of azo dyes. After optimization of the dye decolorization system with crude MnP, the decolorization rates of Orange IV and Orange G, at an initial dye concentration of 50 mg/L, were enhanced to 76 and 57%, respectively, after 20 min of reaction at pH 4 and 35°C. However, only 8% decolorization of Congo red was observed. This enzymatic reaction system revealed a rapid decolorization of azo dyes with a low MnP activity of 24 U/L. Thus, this study could be the basis for the production and application of MnP on a larger scale using a low-cost substrate.     

Use of Phanerochaete chrysosporium Immobilized on Kissiris for Synthetic Dye Decolourization: Involvement of Manganese Peroxidase

The mineral Kissiris, which is formed from the thickened foam of volcanic lava, was tested to approximate its mineral composition using energy-dispersive X-ray (EDX) analysis. The solid mineral contains silicon dioxide at about 16 (w/w). The considerable surface roughness of Kissiris along with its extensive porosity made this natural solid cell support an attractive candidate for manganese peroxidase (MnP) production for synthetic dye decolourization, at low cost. The white rot fungus Phanerochaete chrysosporium immobilized on the mineral Kissiris was grown in both stationary and agitated cultures (rotary shaker, 100 rev/min) using either carbon- or nitrogen-limited growth medium to study the ability of the fungus to degrade the synthetic dye methylene blue (MB). The value of residual dye for MB used at 60 ppm was 6% within 8 days of the incubation of the nitrogen-limited culture under the shaken conditions. Production of (MnP) occurred simultaneously in nitrogen-limited culture medium with the added MnSO₄ at 100 ppm. The MnP activity was at relatively high level (170 U/l).     

Removal of estrogenic activity of endocrine-disrupting genistein by ligninolytic enzymes from white rot fungi

Endocrine-disrupting genistein was treated with the white rot fungus Phanerochaete sordida YK-624 under ligninolytic condition with low-nitrogen and high-carbon culture medium. Genistein decreased by 93% after 4 days of treatment and the activities of ligninolytic enzymes, manganese peroxidase (MnP) and laccase, were detected during treatment, thus suggesting that the disappearance of genistein is related to ligninolytic enzymes produced extracellularly by white rot fungi. Therefore, genistein was treated with MnP, laccase, and the laccase-mediator system with 1-hydroxybenzotriazole (HBT) as a mediator. HPLC analysis demonstrated that genistein disappeared almost completely in the reaction mixture after 4 h of treatment with either MnP, laccase, or the laccase-HBT system. Using the yeast two-hybrid assay system, it was also confirmed that three enzymatic treatments completely removed the estrogenic activity of genistein after 4h. These results strongly suggest that ligninolytic enzymes are effective in removing the estrogenic activity of genistein.     

Ligninolytic Enzymes of the White Rot Basidiomycete Trametes trogii

The white rot fungus Trametes trogii strain BAFC 463 produced laccase, manganese peroxidase, lignin peroxidase and cellobiose dehydrogenase, as well as two hydrogen peroxide‐producing activities: glucose oxidizing activity and glyoxal oxidase. In high‐N (40 mM N) cultures, the titres of laccase, MnP and GLOX were 27 (6.55 U/ml), 45 (403.00 mU/ml)and 8 (32,14 mU/ml) fold higher, respectively, than those measured in an N‐limited medium. This is consistent with the fact that the ligninolytic system of T. trogii is expressed constitutively. Lower activities of all the enzymes tested were recorded upon decreasing the initial pH of the medium from 6.5 to 4.5. Adding veratryl alcohol improved GLOX production, while laccase activity was stimulated by tryptophan. Supplying Tween 80 strongly reduced the activity of both MnP and GLOX, but increased laccase production. The titre of MnP was affected by the concentration of Mn in the culture medium, the highest levels were obtained with 90 μM Mn (II). LiP activity, as CDH activity, were detected only in the mediumsupplemented with sawdust. In this medium, laccase production reached a maximum of 4.75 U/ml, MnP 747.60 mU/ml and GLOX 117.11 mU/ml. LiP, MnP and GLOX activities were co‐induced, attaining their highest levels at the beginning of secondary metabolism, but while MnP, laccase, GLOX and CDH activities were also present in the primary growth phase, LiP activity appears to beidiophasic. The simultaneous presence of high ligninolytic and hydrogen peroxide producing activities in this fungus makes it an attractive microorganism for future biotechnological applications.     

Statistical optimization of medium components to increase the manganese peroxidase productivity by Phanerochaete chrysosporium NCIM 1197

The production of manganese peroxidase (MnP) by the white-rot fungus Phanerochaete chrysosporium NCIM 1197 was investigated by the screening and optimization of the media constituents and physiological factors. MnP production by the fungus was used as the response to screen the media constituents with statistically valid Plackett-Burman (P-B) design. Response surface methodology (RSM) was applied to optimize the level of screened media constituents. Amongst the media constituents screened, glucose, maltose, ammonium chloride, and urea were selected as the most important for MnP enhancement. A five-level Central Composite Design (CCD) was used in optimizing the important media constituents for maximizing the MnP production. The optimal medium composition for maximum MnP production was 13.88 mM of glucose, 13.88 mM of maltose, 0.02 mM of ammonium chloride, and 0.02 mM of urea. The final experiment was conducted to validate the model, which was shown to produce 70.20 U/mL of MnP with a predicted value of 66.49 U/mL on the 8^th day of incubation.     

锰过氧化物酶的耦合固定化及其性质研究

分别采用海藻酸钠、明胶和壳聚糖为载体,并以戊二醛为交联剂,通过包埋-交联和吸附-交联两种耦合固定化方法制备固定化锰过氧化物酶。探讨了酶的不同固定化条件和固定化酶的部分性能。与游离酶相比,制备的3种固定化酶最适反应pH分别由7·0降低到5·0、5·0和3·0,最适反应温度分别由35℃升高到75℃、55℃和75℃。3种固定化酶的耐热性都显著提高,其中用壳聚糖制成的固定化酶在pH2·2~11的宽范围内表现出很好的酸碱耐受性。30℃连续测定6~9次酶活力,重复使用的3种固定化酶显示出良好的稳定性。将固定化酶应用在偶氮染料的脱色中,用明胶制成的固定化酶在静置和摇床条件下,以及用海藻酸钠制成的固定化酶在摇床条件下,均表现出与游离酶相近的脱色能力,并且在重复进行的摇床实验中,脱色能力未降低,反应前后的酶活力均没有损失。     

Optimized production of lignolytic manganese peroxidase in immobilized cultures of <Emphasis Type="Italic">Phanerochaete chrysosporium</Emphasis>

Manganese peroxidase (MnP) is a key enzyme involved in the lignolysis of white-rot fungi. The purpose of this study is to investigate the effect of immobilization and culture conditions on MnP production in cultures of Phanerochaete chrysosporium grown on polyurethane foam. Higher concentrations of foam and lower levels of spore inoculums resulted in the formation of scattered mycelial pellets, increased autolysis of chlamydospore-like cells (a reservoir of MnP), and a higher activity of MnP. Even though MnP was a secondary metabolite, the addition of 5 times more glucose and diammonium tartrate, as carbon and nitrogen sources, resulted in a 4 fold increase in the dry cell mass. However, MnP activity decreased under these conditions to less than half, due to the formation of increasingly dense pellets and the inhibited lysis of chlamydospore-like cells.     

Ligninolytic enzyme production and the ability of decolourisation of Poly R-478 in packed-bed bioreactors by Phanerochaete chrysosporium

The production of ligninolytic enzymes by the fungus Phanerochaetechrysosporium BKM-F-1767 (ATCC 24725) in packed-bed tubular bioreactors, operating in semi-solid-state conditions, was studied. Three types of carriers were assayed: cubes of polyurethane foam, cubes of nylon sponge and chopped corncob, in order to determine the more suitable one to produce ligninolytic enzymes by this fungus. The cultivations were carried out in discontinuous and in continuous mode. For discontinuous cultivation, maximum individual manganese-dependent peroxidase (MnP) activities of 1593, 1371 and 346 U/l were achieved in the bioreactors filled with cubes of nylon sponge, cubes of polyurethane foam and with corncob, respectively. On the other hand, lignin peroxidase (LiP) activities about 100 U/l were found in the two former and around 200 U/l in the latter. Moreover, laccase, was detected in all cultures, with average values of 30 U/l. Nonetheless, continuous mode cultivation led to lower ligninolytic enzyme activities than those produced in discontinuous, except in the case of the corncob. Furthermore, the decolourisation of the dye Poly R-478 by the above-mentioned cultures was investigated. The percentage of biological decolourisation reached was about 70% in the bioreactor filled with cubes of nylon sponge whereas it was rather low in the others (around 30%).     

Optimization of manganese peroxidase production by the white rot fungus Bjerkandera sp. strain BOS55

Manganese dependent peroxidase (MnP) is the most ubiquitous peroxidase produced by white rot fungi. MnP is known to be involved in lignin degradation, biobleaching and in the oxidation of hazardous organopollutants. Bjerkandera sp. strain BOS55 is a nitrogen-unregulated white rot fungus which produces high amounts of MnP in the excess of N-nutrients due to increased biomass yield. Therefore, the strain is a good candidate for use in large scale production of this enzyme. The objective of this study was to optimize the MnP production in N-sufficient cultures by varying different physiological factors such as Mn concentration, culture pH, incubation temperature and the addition of organic acids. The fungus produced the highest level of MnP (up to 900 U 1⁻¹) when the Mn concentration was 0.2 to 1 mM, the pH value was 5.2, and the incubation temperature was 30°C. A noteworthy finding was that MnP was also produced at lower levels in the complete absence of Mn. The addition of organic acids like glycolate, malonate, glucuronate, gluconate, 2-hydroxybutyrate to the culture medium increased the peak titres of MnP up to 1250 U 1⁻¹. FPLC profiles indicated that the organic acids stimulated the production of all MnP isoenzymes present in the extracellular fluid of the fungus.     

A Possible Role of Manganese Peroxidase during Biobleaching by the Pulp Bleaching Fungus SKB-1152

The fungus SKB-1152 bleaches oxygen-alkaline treated hard wood kraft pulp (OKP) rapidly. In the initial phase of fungal treatment, maximum production of manganese peroxidase (MnP) was observed. The filtrate from a 1-day fungal treatment could bleach OKP when manganese, glucose, and glucose oxidase were added. A possible role of MnP in the initial fungal bleaching process is suggested.     

Selenium Induces Manganese-dependent Peroxidase Production by the White-Rot Fungus Bjerkandera adusta (Willdenow) P. Karsten

In this study, selenium (Se) induction of the ligninolytic enzyme manganese-dependent peroxidase (MnP) production, and the effects on the oxidative state in the white-rot fungus Bjerkandera adusta (Willdenow) P. Karsten were demonstrated. Low concentration of Se (0.5 mM) caused up to a twofold increase in MnP production (0.81 +/- 0.05 U/ml) when compared to control (0.39 +/- 0.07 U/ml), whereas higher concentrations of Se (200 mM) inhibited (0.03 +/- 0.01 U/ml) MnP production. Addition of high concentration of Se also caused up to a twofold increase in lipid peroxidation levels. These results demonstrate for the first time that Se may induce or reduce MnP production and lipid peroxidation levels which play a significant role in lignin degradation by white-rot fungi.     

Amelioration of ligninolytic enzyme production by Phanerochaete chrysosporium in airlift bioreactors

Maximum activities of manganese-dependent peroxidase (MnP) and lignin peroxidase (LiP) in free cultures of Phanerochaete chrysosporium (ATCC 24725) were 258 U l^–1 and 103 U l^–1, respectively, in an airlift bioreactor. Immobilisation of the fungus on an inert carrier as well as several design modifications of the bioreactor employed gave MnP activities around 500–600 U l^–1 during 9 days' operation. The continuous operation of the latter led to MnP and LiP activities about 140 U l^–1 and 100 U l^–1, respectively, for two months, without operational problems. Furthermore, the extracellular liquid secreted decolourised the polymeric dye Poly R-478 about 56%.     

Production of manganese peroxidase and laccase in laboratory-scale bioreactors by Phanerochaete chrysosporium

The production of ligninolytic enzymes by the fungus Phanerochaete chrysosporium BKM-F-1767 (ATCC 24725) in laboratory-scale bioreactors was studied. One bioreactor was filled with cubes of polyurethane foam and the other with cubes of nylon sponge, in order to determine the more suitable carrier to produce high ligninolytic enzyme activities by this fungus. Both cultivations were carried out in batch. Manganese-dependent peroxidase activities about 600 U l^у were achieved in the bioreactor filled with cubes of nylon sponge, while up to 500 U l^у were detected in that filled with cubes of polyurethane foam. Furthermore, quite high levels of laccase appeared in both cultures: maximum activities of 114 U l^у and 62 U l^у were obtained on nylon and polyurethane supports, respectively.