Assessment of Pediococcus acidilactici as a Potential Silage Inoculant

Eighteen Pediococcus strains were screened for their potential as silage inoculants. Pediococcus acidilactici G24 was found to be the most suitable, exhibiting a short lag phase on both glucose and fructose, a rapid rate of acid production, a high sugar-to-lactate conversion efficiency, no detectable breakdown of proteins or lactic acid, and the ability to grow within a broad range of pH and temperature. When tested in laboratory silos using grass with a water-soluble carbohydrate content of 24 g/kg of aqueous extract, P. acidilactici G24 stimulated the natural Lactobacillus plantarum population and accelerated the rates of lactic acid production and pH decrease. After 6 days of fermentation, the inoculated silage exhibited a 12% decrease in ammonia nitrogen and an 11% increase in crude protein levels compared with uninoculated controls. The use of an L. plantarum inoculant at a rate of 10⁴ bacteria per g of grass in conjunction with P. acidilactici G24 produced no additional beneficial effect. Inoculation of grass with a water-soluble carbohydrate level of 8 g/kg of aqueous extract with P. acidilactici G24 led to no acceleration in the rate of L. plantarum growth or pH decrease. However, after 7 days of fermentation the inoculated silage had a 14% lower ammonia nitrogen protein content than did uninoculated controls. The results suggest that P. acidilactici G24 may be useful as a silage inoculant for crops with a sufficiently high water-soluble carbohydrate level.     

Expression of fungal cellulase gene in <Emphasis Type="Italic">Lactococcus lactis</Emphasis> to construct novel recombinant silage inoculants

The facultative anaerobic bacterium Lactococcus lactis has been used as a host for expression of a gene isolated from the anaerobic rumen fungus Neocallimastix sp. The coding region of the cellulase gene was obtained from the fungus with the aid of polymerase chain reaction amplification. The gene was then transformed into pCT vector system and the constructed recombinant plasmid was introduced into two L. lactis strains (IL403 and MG1363) by electroporation. The gene encoding the fungal originated cellulase was expressed in both strains successfully although the expression level was relatively lower in comparison with the original enzyme activity. Genetically modified L. lactis strains were used as silage inoculants for pre-biodegradation of the plant biomass during ensiling. That treatment resulted in a notable reduction of the acid detergent fiber (ADF) and neutral detergent fiber (NDF) contents of the plant biomass used as silage material. Inoculation with recombinant strain IL1043 resulted in 4.8 and 9.7 % decrease in NDF and ADF contents, respectively while the inoculation of silage with strain MG1363 decreased the ADF content by >5 %.     

Efficient transient expression of human GM-CSF protein in Nicotiana benthamiana using potato virus X vector

The human granulocyte macrophage colony-stimulating factor (GM-CSF) is a glycoprotein with important clinical applications for the treatment of neutropenia and aplastic anemia and reducing infections associated with bone marrow transplants. We evaluated the potential for using a potato virus X (PVX) viral vector system for efficient expression of the biologically functional GM-CSF protein in Nicotiana benthamiana leaves. The GM-CSF gene was cloned into PVX viral expression vector, driven with the CaMV 35S promoter. Gene transfer was accomplished by inoculating N. benthamiana leaves with the plasmid DNA of PVX vector containing the GM-CSF gene. The expression level of the recombinant GM-CSF protein was determined with ELISA and its size was confirmed by Western blot analysis. The results showed that: (1) leaf age significantly affects GM-CSF protein concentration with younger leaves accumulating 19.8 mg g⁻¹ soluble protein which is 2.6 times the concentration in older leaves, (2) recombinant protein accumulation within a given leaf declined slightly over time but was not significantly different between 7 and 11 days post-inoculation (dpi), and (3) the two leaves immediately above the inoculated leaves play an important role for GM-CSF accumulation in the younger leaves. Protein extracts of infected N. benthamiana leaves contained recombinant human GM-CSF protein in concentrations of up to 2% of total soluble protein, but only when the pair of leaves immediately above the inoculated leaves remained intact. The recombinant protein actively stimulated the growth of human TF-1 cells suggesting that the recombinant human GM-CSF expressed via PVX viral vector was biologically active.     

Growth and survival of lactic acid bacteria in lucerne silage

A rifampicin-resistant variant of two strains of Lactobacillus plantarum, one strain of Pediococcus acidilactici, and one strain of Enterococcus faecium were used for the experimental production of lucerne silage. Laboratory silage without inoculants served as a control. Counts of total anaerobes, total lactic acid bacteria (LAB), lactobacilli, pediococci, and enterococci were determined on days 14, 21, 30, 49, and 60 of lucerne fermentation. LAB dominated in silage microflora, reaching a percentage between 59 and 95 % of total anaerobes. Lactobacilli were found as a predominant group of LAB during the whole study. Lactobacilli reached numbers 8.74 log CFU/g in treated silage and 8.89 log CFU/g in the control at the first observation. Their counts decreased to 4.23 and 4.92 log CFU/g in treated silage and the control, respectively, on day 63 of fermentation. Similar decreases were observed in all bacterial groups. The treated silage samples possessed lower pH (4.2 vs. 4.5 in control samples) and contained more lactic acid compared to control silage. The identity of re-isolated rifampicin-resistant bacteria with those inoculated to the lucerne was evaluated by fingerprinting techniques. The fingerprint profiles of re-isolated bacteria corresponded to the profiles of strains used for the treatment. It could be concluded that supplemented LAB dominated in laboratory silage and overgrew naturally occurring LAB.     

Effects of <Emphasis Type="Italic">Lactobacillus buchneri</Emphasis> and <Emphasis Type="Italic">Lactobacillus plantarum</Emphasis> on fermentation,aerobic stability,bacteria diversity and ruminal degradability of alfalfa silage

Silages are important feedstuffs. Homofermentative lactic acid bacterial inoculants are often used to control silage fermentation. However, some research pointed out those homofermentative lactic acid bacteria (LAB) impaired the aerobic stability of wheat, sorghum, and corn silages. Adding heterofermentative LAB can produce more acetic acid, thereby stabilizing silages during aerobic exposure. Alfalfa is difficult to ensile. The present work was to study the effects of L. buchneri (heterofermentative LAB), alone or in combination with L. plantarum (homofermentative LAB) on the fermentation, aerobic stability, bacteria diversity and ruminal degradability of alfalfa silage. After 90 days ensiling, the pH, NH₃-N/TN, butyric acid content and molds counts of control were the highest. The inoculated silages had more lactic acid, acetic acid content and more lactic acid bacteria than the control. Inoculating LAB inhibited harmful microorganisms, such as Enterobacterium and Klebsiella pneumoniae. The L. buchneri + L. plantarum-inoculated silage had more acetic acid and less yeasts than other three treatments (P < 0.05), and lower NH₃-N/TN than control (P < 0.05). The CO₂ production of L. buchneri + L. plantarum-inoculated silage was less than that of L. plantarum-inoculated silage (P < 0.05). Inoculating LAB in alfalfa silages can decrease pH, increase the production of lactic and acetic acids, reduce the number of yeasts and molds, and inhibit Enterobacterium and K. pneumoniae. Inoculating with L. buchneri or L. buchneri + L. plantarum can improve aerobic stability of alfalfa silages. A combination of L. buchneri and L. plantarum is preferable because it enhanced alfalfa silage quality and aerobic stability.     

Use of real time PCR to determine population profiles of individual species of lactic acid bacteria in alfalfa silage and stored corn stover

Real-time polymerase chain reaction (RT-PCR) was used to quantify seven species of lactic acid bacteria (LAB) in alfalfa silage prepared in the presence or absence of four commercial inoculants and in uninoculated corn stover harvested and stored under a variety of field conditions. Species-specific PCR primers were designed based on recA gene sequences. Commercial inoculants improved the quality of alfalfa silage, but species corresponding to those in the inoculants displayed variations in persistence over the next 96 h. Lactobacillus brevis was the most abundant LAB (12 to 32% of total sample DNA) in all of the alfalfa silages by 96 h. Modest populations (up to 10%) of Lactobacillus plantarum were also observed in inoculated silages. Pediococcus pentosaceus populations increased over time but did not exceed 2% of the total. Small populations (0.1 to 1%) of Lactobacillus buchneri and Lactococcus lactis were observed in all silages, while Lactobacillus pentosus and Enterococcus faecium were near or below detection limits. Corn stover generally displayed higher populations of L. plantarum and L. brevis and lower populations of other LAB species. The data illustrate the utility of RT-PCR for quantifying individual species of LAB in conserved forages prepared under a wide variety of conditions.Disclaimer: Mention of products is for informational purposes only and does not imply a recommendation or warranty by USDA over other products that may also be suitable     

Expression,Purification and Characterization of Recombinant Human Angiogenin in Pichia pastoris

The potential of angiogenin (Ang) for clinical use has been highlighted in view of its important roles in inducing angiogenesis, facilitating cell proliferation, and inhibiting cell apoptosis. To produce soluble, correctly folded recombinant protein with a high yield, a DNA fragment encoding human Ang was inserted into eukaryotic expression vector pPIC9 and transformed into Pichia pastoris. The expression of recombinant human Ang (rhAng) accounted for about 70% of total secreted proteins. Purifying the Ang from the culture supernatant yielded 30 mg/L at 90% purity by chromatography with a SP Sepharose FF column. Biological assays indicated that rhAng can induce new blood-vessel formation, promote HeLa cell proliferation, increase Erk1/2 phosphorylation, and upregulate c-myc expression. Preparation of bioactive rhAng might lay the basis for further functional study, and might provide an effective strategy for large-scale production of soluble human Ang.     

Vector-free cloning of a bacterial endo-1,4-β-glucanase in Lactobacillus plantarum and its effect on the acidifying activity in silage: Use of recombinant cellulolytic Lactobacillus plantarum as silage inoculant

In this research, the advantage of use of cellulolytic recombinant Lactobacillus plantarum as microbial inoculants for alfalfa silage fermentation was evaluated. To such purpose, two L. plantarum strains, one (L. plantarum Lp80) currently commercialised and the other (L. plantarum B41) suitable as silage microbial additive, were genetically modified by integration of celA gene, encoding an alkaline endo-1,4--glucanase from Bacillus sp., in the chromosome, by means of a vector-free cloning technique. The heterologous gene was cloned in two fashions: preceded by two promoters (AC1 modification) or in translational coupling with a partial upstream ORF (AC2 modification). Therefore two different genetically modified organisms (GMOs) per each wild-type (WT), producing 43–59 U/l cellulase in 16 h, were examined. Thirty-five micro-ensiling experiments were carried out by inoculating the WT or the derived GMOs. L. plantarum B41AC1 cellulolytic clone exhibited significantly increased acidification capacity in silage samples incubated at 37°C. No advantage of use was evident for the other GMOs.     

Cloning and analysis of bile salt hydrolase genes from Lactobacillus plantarum CGMCC No. 8198

Genes coding for bile salt hydrolase of Lactobacillus plantarum CGMCC 8198, a novel probiotic strain isolated from silage, were identified, analyzed and cloned. L. plantarum strongly resisted the inhibitory effects of bile salts and also decreased serum cholesterol levels by 20 % in mice with hypercholesterolemia. Using RT-PCR analysis, bsh2, bsh3 and bsh4 were upregulated by bile salts in a dose-dependent manner. All three bsh genes had high similarity with those of other Lactobacillus strains. All three recombinant BSHs had high activities for the hydrolysis of glycodeoxycholic acids and taurodeoxycholic acids.     

The effects of using lactic acid bacteria inoculants in maize silage on the formation of biogenic amines

Silages from five ripened varieties of silage maize with dry matter contents ranging between 275 and 410 g/kg were prepared in five laboratory experiments. Whole-plant maize was fermented at 22°C and silages were then stored at the same temperature for 4 months. Spontaneously fermented silages were prepared as control variants and compared with silages inoculated with commercial strains of Lactobacillus plantarum, Lactobacillus buchneri and a mixed preparation Microsil containing L. plantarum, Lactobacillus casei, Enterococcus faecium and Pediococcus pentosaceus. The starter cultures were applied at doses 5·10⁵ and 5·10⁶ CFU/g of chopped maize. Seven biogenic amines and polyamines were extracted from silages with perchloric acid and determined as N-benzamides by micellar electrokinetic capillary chromatography. Common chemical criteria of silage quality were also determined. All three inoculants, mainly at the higher dose, decreased significantly contents of tyramine, putrescine and cadaverine, three undesirable amines occurring at the highest levels. L. plantarum was the most effective. Contents of histamine and tryptamine were low in all experimental silages. Also relatively low were levels of polyamines spermidine and mainly of spermine.     

Cloning and expression of cellulase and xylanase genes in Lactobacillus plantarum

Summary Eleven cellulase genes from Gram-positive bacteria were cloned in a Lactobacillus plantarum silage inoculum. Eight of these genes were expressed as active enzymes from their original promotors and translation signals. Where tested, the enzymes produced by transformed L.plantarum had the same temperature and pH optimum as enzymes produced in the original host, or in transformed Escherichia coli. Using chloramphenicol acetyltransferase as a cell-internal marker enzyme, it could be demonstrated that at least endoglucanase D from Clostridium thermocellum was actively secreted by transformed L. plantarum. In growing L. plantarum cultures, most of the enzymes were irreversibly inactivated when the pH decreased below 4.5. If the transformed strains were to be applied as an inoculum in silage, this pH inactivation might be useful in preventing overdigestion of the crop fibre. Offprint requests to: F. Michiels     

Different lactic acid bacteria and their combinations regulated the fermentation process of ensiled alfalfa: ensiling characteristics,dynamics of bacterial community and their functional shifts

The objectives of this study were to investigate the adaptation and competition of Lactobacillus plantarum, Pediococcus pentosaceus and Enterococcus faecalis inoculated in alfalfa silage alone or in combination on the fermentation quality, dynamics of bacterial community, and their functional shifts using single-molecule real-time (SMRT) sequencing technology. Before ensiling, alfalfa was inoculated with L. plantarum (Lp), P. pentosaceus (Pp), E. faecalis (Ef) or their combinations (LpPp, LpEf, LpPpEf) and sampled at 1, 3, 7, 14 and 60 days. After 60-days fermentation, the Lp-, Pp- and LpPp-inoculated silages had lower pH but greater concentrations of lactic acid were observed in Pp, LpEf and LpPpEf-inoculated silages. The inoculants altered the keystone taxa and the bacterial community dynamics in different manners, where L. plantarum, Weissella cibaria and L. pentosaceus dominated the bacterial communities after 14 days-fermentation in all treatments. The silages with better fermentation quality had simplified bacterial correlation structures. Moreover, different inoculants dramatically changed the carbohydrate, amino acid, energy, nucleotide and vitamin metabolism of bacterial communities during ensiling. Results of the current study indicate that effect of different inoculants on alfalfa silage fermentation was implemented by modulating the succession of bacterial community, their interactions and metabolic pathways as well during ensiling.     

Ensiling whole-crop wheat and corn in large containers with Lactobacillus plantarum and Lactobacillus buchneri

The effect of applying Lactobacillus buchneri, alone or in combination with Lactobacillus plantarum, at ensiling, on the aerobic stability of wheat and corn silages was studied in 50-l plastic containers. Treatments comprised control (no additives), L. plantarum, L. buchneri and a combination of L. plantarum+L. buchneri. After 3 months of storage, the wheat silages treated with L. buchneri had higher acetic acid contents than the control or L. plantarum-treated silages, and were free of mold, whereas the top layers of the control or L. plantarum-treated silages were moldy. In an aerobic stability test the L. buchneri-treated silages were stable, whereas those treated with L. plantarum deteriorated. In the corn silages the effects of L. buchneri were not as clear and the top layer was moldy in all silages. However, L. buchneri also improved the aerobic stability of the corn silage, as indicated by lower yeast numbers, less CO₂ production and stable pH. It is concluded that L. buchneri has a potential as a silage additive that protects the silage upon aerobic exposure. The 50-l plastic containers can serve as an appropriate model to test silage additives before conducting full-scale farm experiments. Journal of Industrial Microbiology & Biotechnology (2002) 28, 7–11 DOI: 10.1038/sj/jim/7000207 Received 17 April 2001/ Accepted in revised form 25 August 2001     

Biologically active and C-amidated hinnavinII-38-Asn produced from a Trx fusion construct in <Emphasis Type="Italic">Escherichia coli</Emphasis>

The cabbage butterfly (Artogeia rapae) antimicrobial peptide hinnavinII as a member of cecropin family is synthesized as 37 residues in size with an amidated lysine at C-terminus and shows the humoral immune response to a bacterial invasion. In this work, a synthetic gene for hinnavinII-38-Asn (HIN) with an additional amino acid asparagine residue containing amide group at C-terminus was cloned into pET-32a(+) vector to allow expression of HIN as a Trx fusion protein in Escherichia coli strain BL21 (DE3) pLysS. The resulting expression level of the fusion protein Trx-HIN could reach 15–20% of the total cell proteins and more than 70% of the target proteins were in soluble form. The fusion protein could be purified successfully by HiTrap Chelating HP column and a high yield of 15 mg purified fusion protein was obtained from 80 ml E. coli culture. Recombinant HIN was readily obtained by enterokinase cleavage of the fusion protein followed by FPLC chromatography, and 3.18 mg pure active recombinant HIN was obtained from 80 ml culture. The molecular mass of recombinant HIN determined by MALDI-TOF mass spectrometer is 4252.084 Da which matches the theoretical mass (4252.0 Da) of HIN. Comparing the antimicrobial activities of the recombinant hinnavinII with C-amidated terminus to that without an amidated C-terminus, we found that the amide of asparagine at C-terminus of hinnavinII improved its potency on certain microorganism such as E. coli, Enterobacter cloacae, Bacillus megaterium, and Staphylococcus aureus.     

Expression and purification of a soluble B lymphocyte stimulator mutant modified with the T-helper cell epitope

The DNA encoding soluble B lymphocyte stimulator (134–285 amino acids, sBLyS) mutant with residues 217–224 replaced by two glycines (named msBLyS) was constructed. The sequence encoding a foreign immunodominant T-helper epitope from ovalbumin (OVA) was then coupled to the 5′-end of msBLyS cDNA. After being sequenced, the recombinant DNA was ligated into the prokaryotic expression vector pQE-80L. The recombinant protein was produced in E. coli DH5α after induction with IPTG with the yield of more than 40% of total bacterial protein. The recombinant protein was purified with Ni-NTA chromatography and Sepharcryl S200 chromatography to a purity of more than 98%. The BALB/c mice, immunized with the recombinant protein, produced anti-BLyS antibodies at a high level, which indicated that the recombinant BLyS mutant modified with T-helper epitope elicited polyclonal antibodies with cross-reactivity with BLyS in vivo. This recombinant protein may therefore be used as immune inhibitor of BLyS for treating BLyS -associated autoimmune diseases.     

Fusion expression of Escherichia coli prlC gene and preparation of PrlC proteinase affinity column

Escherichia coli PrlC is a trypsin-like proteinase regulating the cell cycle. The Escherichia coli prlC gene has been cloned into the pET28a prokaryotic expression vector. The recombinant fusion protein was produced mostly in the soluble, active form and the expression level amounted to approximately 70% of total protein. The recombinant proteinase was efficiently adsorbed to a resin containing immobilized Ni²⁺ via its amino terminal fusion hexahistidine tail to give a PrlC proteinase affinity column. The adsorbed fusion proteinase hydrolyzed 4-methylcoumaryl-7-amide of tert-butoxycarbonyl-l-valyl-l-prolyl-l-arginine (Boc-Val-Pro-Arg-NH-Mec), the specific substrate for the trypsin-like proteinase activity of E. coli PrlC.     

The effects of Propionibacterium acidipropionici and Lactobacillus plantarum, applied at ensiling, on the fermentation and aerobic stability of low dry matter corn and sorghum silages

The aim of this work was to study the effects of applying a strain of Propionibacterium acidipropionici, with or without Lactobacillus plantarum, on the fermentation and aerobic stability characteristics of low dry matter (DM) corn (Zea mays L.) and sorghum (Sorghum bicolor L.) silages. Corn at the dent stage and sorghum at the flowering stage were harvested. Treatments comprised control (no additives), P. acidipropionici, L. plantarum and a combination of P. acidipropionici and L. plantarum. Fresh forages were sampled prior to ensiling. Bacterial inoculants were applied to the fresh forage at 1.0×10⁶ colony-forming units per gram. After treatment, the chopped fresh materials were ensiled in 1.5-l anaerobic glass jars equipped with a lid that enabled gas release only. Three jars per treatment were sampled on days 2, 4, 8, 16 and 60 after ensiling, for chemical and microbiological analysis. At the end of the ensiling period, 60 days, the silages were subjected to an aerobic stability test. The L. plantarum inoculated silages had significantly higher levels of lactic acid than the controls, P. acidipropionici and combination of P. acidipropionici and L. plantarum inoculated silages (P<0.05). The P. acidipropionici did not increase propionic and acetic acid levels of the silages. After the aerobic exposure test, the L. plantarum and combination of P. acidipropionici and L. plantarum had produced more CO₂ than the controls and the silages inoculated with P. acidipropionici (P<0.05). All silages had high levels of CO₂ and high numbers of yeasts and molds in the experiment. Therefore, all silages were deteriorated under aerobic conditions. The P. acidipropionici and combination of P. acidipropionici and L. plantarum were not able to improve the aerobic stability of fast-fermenting silages, because they could not work well in this acidic environment. The results showed that P. acidipropionici and combination of P. acidipropionici and L. plantarum did not improve the aerobic stability of low DM corn and sorghum silages, which are prone to aerobic deterioration.     

Growth and Survival of Genetically Manipulated Lactobacillus plantarum in Silage

The growth and persistence of two genetically manipulated forms of Lactobacillus plantarum NCDO (National Collection of Dairy Organisms) 1193 have been monitored in grass silage. Both recombinants contained pSA3, a shuttle vector for gram-positive organisms that encodes erythromycin resistance. In one of the recombinants, pSA3 was integrated onto the chromosome, whereas in the other, a pSA3 derivative designated pM25, which contains a Clostridium thermocellum cellulase gene cloned into pSA3, was maintained as an extrachromosomal element. This extrachromosomal element is a plasmid. Rifampin-resistant mutants were selected for the recombinants and the parent strain. When applied to minisilos at a rate of 10⁶ CFU/g of grass, both the recombinants and the parent strain proliferated to dominate the epiphytic microflora and induced an increase in the decline in pH compared with that of the noninoculated silos. The presence of extra genetic material did not appear to disadvantage the bacterium in comparison with the parent strain. The selective recovery of both strains by using rifampin and erythromycin was confirmed by Southern hybridization. Interestingly, the free plasmid (pM25) appeared more stable in silage than was expected from studies in MRS broth. The plasmid was retained by 85% of the rifampin-resistant L. plantarum colonies isolated from a day 30 silo. These data answer an important question by showing that genetically manipulated recombinants of L. plantarum can proliferate and compete with epiphytic lactic acid bacteria in silage.     

Investigation into the Potential of Bacteriocinogenic Lactobacillus plantarum BFE 5092 for Biopreservation of Raw Turkey Meat

The bacteriocin-producing Lactobacillus plantarum BFE 5092 was assessed for its potential as a protective culture in the biopreservation of aerobically stored turkey meat. This strain produces three bacteriocins, i.e. plantaricins EF, JK and N. The absolute expression of Lactobacillus plantarum BFE 5092 16S rRNA housekeeping gene, as well as l-ldh, plnEF and plnG genes as determined by quantitative, real-time-PCR, revealed that these genes were expressed to similar levels when the strain was grown at 8 and 30 °C in MRS broth. On turkey meat, Lactobacillus plantarum BFE 5092 did not grow but survived, as indicated by similar viable cell numbers during a 9-day storage period at 8 °C. When inoculated at 1 × 10⁷ CFU/g on the turkey meat and subsequently stored at 10 °C, the culture did again not show good growth. Lactobacillus plantarum BFE 5092 could not inhibit the growth of naturally occurring listeriae or Gram-negative bacteria on the turkey meat at 10 °C, or that of Listeria monocytogenes when it was co-inoculated at a level of 1 × 10⁵ CFU/g. Gene expression analyses showed that the bacteriocin genes were expressed on turkey meat stored at 10 °C. Moreover, the investigation into the absolute expression of the three plantaricin genes of Lactobacillus plantarum BFE 5092 in co-culture with Listeria monocytogenes on turkey meat by qRT-PCR showed that the plantaricin genes were indeed expressed during the low-temperature storage condition. The Lactobacillus plantarum BFE 5092 strain overall could not effectively inhibit L. monocytogenes and therefore it would not make a suitable protective culture for biopreservation of turkey meat stored aerobically at low temperature.