Hydrolysis of organophosphate insecticides by an immobilized-enzyme system.

An enzyme preparation that could detoxify parathion and eight other organophosphate pesticides was covalently bound to either porous glass or porous silica beads. This immobilized-enzyme system was examined for its use in detoxification of pesticides in production wastewaters. The kinetics of parathion hydrolysis were examined at flow rates up to 96 liter/hr and at influent substrate concentrations ranging from 10--250 mg/liter. The enzyme reactor was able to hydrolyze 95% or more of the parathion added to industrial wastewaters generated during its production, thus reducing the effluent parathion concentration to below 500 ppb. Laboratory continuous-flow experiments were conducted for 70 days with industrial wastewater and indicated no loss in immobilized-enzyme activity. The influence of pH, temperature, solvents, and detergents on enzyme stability and activity and enzyme reactor kinetics will be discussed.     

Detoxification of organophosphate pesticides using an immobilized phosphotriesterase from Pseudomonas diminuta

A purified phosphotriesterase was successfully immobilized onto trityl agarose in a fixed bed reactor. A total of up to 9200 units of enzyme activity was immobilized onto 2.0 mL of trityl agarose (65 mumol trityl groups/mL agarose), where one unit is the amount of enzyme required to catalyze the hydrolysis of one micromole of paraoxon in one min. The immobilized enzyme was shown to behave chemically and kinetically similar to the free enzyme when paraoxon was utilized as a substrate. Several organophosphate pesticides, methyl parathion, ethyl parathion, diazinon, and coumaphos were also hydrolyzed by the immobilized phosphotriesterase. However, all substrates exhibited an affinity for the trityl agarose matrix. For increased solubility and reduction in the affinity of these pesticides for the trityl agarose matrix, methanol/water mixtures were utilized. The effect of methanol was not deleterious when concentrations of less than 20% were present. However, higher concentrations resulted in elution of enzyme from the reactor. With a 10-unit reactor, a 1.0 mM paraoxon solution was hydrolyzed completely at a flow rate of 45 mL/h. Kinetic parameters were measured with a 0.1-unit reactor with paraoxon as a substrate at a flow rate of 22 mL/h. The apparent K(m) for the immobilized enzyme was 3-4 times greater than the K(m) (0.1 mM) for the soluble enzyme. Immobilization limited the maximum rate of substrate hydrolysis to 40% of the value observed for the soluble enzyme. The pH-rate profiles of the soluble and immobilized enzymes were very similar. The immobilization of phosphotriesterase onto trityl agarose provides an effective method esterase onto trityl agarose provides an effective method for hydrolyzing and thus detoxifyuing organophosphate pesticides and mammalian acetylcholinesterase inhinbitors.     

Isolation of a methyl parathion-degrading Pseudomonas sp. that possesses DNA homologous to the opd gene from a Flavobacterium sp

Two mixed bacterial cultures isolated by soil enrichment were capable of utilizing methyl parathion (O,O-dimethyl O-p-nitrophenylphosphorothioate) and parathion (O,O-diethyl O-p-nitrophenylphosphorothioate) as a sole source of carbon. Four isolates from these mixed cultures lost their ability to utilize the pesticides independently in transfers subsequent to the initial isolation. One member of the mixed cultures, a Pseudomonas sp., however, hydrolyzed the pesticides to p-nitrophenol but required glucose or another carbon source for growth. The crude cell extracts prepared from this bacterium showed an optimum pH range from 7.5 to 9.5 for the enzymatic hydrolysis. Maximum enzymatic activity occurred between 35 and 40 degrees C. The enzyme activity was not inhibited by heavy metals, EDTA, or NaN3. Another isolate from the mixed cultures, a Flavobacterium sp., used p-nitrophenol for growth and degraded it to nitrite. Nitrite was assimilated into the cells under conditions during which the nitrogen source was excluded from the minimal growth medium. The hybridization data showed that the DNAs from a Pseudomonas sp. and from the mixed culture had homology with the opd (organophosphate degradation) gene from a previously reported parathion-hydrolyzing bacterium, Flavobacterium sp. The use of the opd gene as a probe may accelerate progress toward understanding the complex interactions of soil microorganisms with parathions.     

Isolation of a methyl parathion-degrading Pseudomonas sp. that possesses DNA homologous to the opd gene from a Flavobacterium sp.

Two mixed bacterial cultures isolated by soil enrichment were capable of utilizing methyl parathion (O,O-dimethyl O-p-nitrophenylphosphorothioate) and parathion (O,O-diethyl O-p-nitrophenylphosphorothioate) as a sole source of carbon. Four isolates from these mixed cultures lost their ability to utilize the pesticides independently in transfers subsequent to the initial isolation. One member of the mixed cultures, a Pseudomonas sp., however, hydrolyzed the pesticides to p-nitrophenol but required glucose or another carbon source for growth. The crude cell extracts prepared from this bacterium showed an optimum pH range from 7.5 to 9.5 for the enzymatic hydrolysis. Maximum enzymatic activity occurred between 35 and 40 degrees C. The enzyme activity was not inhibited by heavy metals, EDTA, or NaN3. Another isolate from the mixed cultures, a Flavobacterium sp., used p-nitrophenol for growth and degraded it to nitrite. Nitrite was assimilated into the cells under conditions during which the nitrogen source was excluded from the minimal growth medium. The hybridization data showed that the DNAs from a Pseudomonas sp. and from the mixed culture had homology with the opd (organophosphate degradation) gene from a previously reported parathion-hydrolyzing bacterium, Flavobacterium sp. The use of the opd gene as a probe may accelerate progress toward understanding the complex interactions of soil microorganisms with parathions.     

Bacterial cell surface display of organophosphorus hydrolase for selective screening of improved hydrolysis of organophosphate nerve agents

Organophosphorus hydrolase (OPH) is a bacterial enzyme that has been shown to degrade a wide range of neurotoxic organophosphate nerve agents. However, the effectiveness of degradation varies dramatically, ranging from highly efficient with paraoxon to relatively slow with methyl parathion. Sequential cycles of DNA shuffling and screening were used to fine-tune and enhance the activity of OPH towards poorly degraded substrates. Because of the inaccessibility of these pesticides across the cell membrane, OPH variants were displayed on the surface of Escherichia coli using the truncated ice nucleation protein in order to isolate novel enzymes with truly improved substrate specificities. A solid-phase top agar method based on the detection of the yellow product p-nitrophenol was developed for the rapid prescreening of potential variants with improved hydrolysis of methyl parathion. Two rounds of DNA shuffling and screening were carried out, and several improved variants were isolated. One variant in particular, 22A11, hydrolyzes methyl parathion 25-fold faster than does the wild type. Because of the success that we achieved with directed evolution of OPH for improved hydrolysis of methyl parathion, we believe that we can easily extend this method in creating other OPH variants with improved activity against poorly degraded pesticides such as diazinon and chlorpyrifos and nerve agents such as sarin and soman.     

Overexpression of methyl parathion hydrolase and its application in detoxification of organophosphates

The coding region of mpd gene corresponding to mature methyl parathion hydrolase (MPH) was heterologously overexpressed in Escherichia coli BL21 (DE3) by using pET expression system. The lactose-induced expression yield of MPH is increased 2-fold compared with IPTG as inducer. Furthermore, it was found that specific activity of MPH increased 48% by reducing the induction temperature to 22°C. The addition of 25 mM lactose at 22°C, the MPH activity of fermentation broth had a specific activity of 1.4 × 10⁴ U/mg protein. Plasmid was no significant decrease in the modified medium. The optimal pH and temperature of MPH were 8.0 and 30°C, respectively. Over a period of 5 months, the dried cells showed no significant decrease in the activity of the detoxifying enzymes. The crude enzymes in 50 mM citrate-phosphate buffer (pH 8.0) were able to degrade about 98% of the organophosphate pesticides sprayed on cabbage. The detoxification efficiency was superior to that of the treatments of water, detergent, and a commercially available enzyme product. Additionally, the products of pesticide hydrolysis generated by treatment with the enzyme extract were determined to be virtually nontoxic.     

Bacterial Cell Surface Display of Organophosphorus Hydrolase for Selective Screening of Improved Hydrolysis of Organophosphate Nerve Agents

Organophosphorus hydrolase (OPH) is a bacterial enzyme that has been shown to degrade a wide range of neurotoxic organophosphate nerve agents. However, the effectiveness of degradation varies dramatically, ranging from highly efficient with paraoxon to relatively slow with methyl parathion. Sequential cycles of DNA shuffling and screening were used to fine-tune and enhance the activity of OPH towards poorly degraded substrates. Because of the inaccessibility of these pesticides across the cell membrane, OPH variants were displayed on the surface of Escherichia coli using the truncated ice nucleation protein in order to isolate novel enzymes with truly improved substrate specificities. A solid-phase top agar method based on the detection of the yellow product p-nitrophenol was developed for the rapid prescreening of potential variants with improved hydrolysis of methyl parathion. Two rounds of DNA shuffling and screening were carried out, and several improved variants were isolated. One variant in particular, 22A11, hydrolyzes methyl parathion 25-fold faster than does the wild type. Because of the success that we achieved with directed evolution of OPH for improved hydrolysis of methyl parathion, we believe that we can easily extend this method in creating other OPH variants with improved activity against poorly degraded pesticides such as diazinon and chlorpyrifos and nerve agents such as sarin and soman.     

Altering the substrate specificity of organophosphorus hydrolase for enhanced hydrolysis of chlorpyrifos

Chlorpyrifos is one of the most popular pesticides used for agriculture crop protection, and widespread contamination is a potential concern. However, chlorpyrifos is hydrolyzed almost 1,000-fold slower than the preferred substrate, paraoxon, by organophosphorus hydrolase (OPH), an enzyme that can degrade a broad range of organophosphate pesticides. We have recently demonstrated that directed evolution can be used to generate OPH variants with up to 25-fold improvement in hydrolysis of methyl parathion. The obvious question and challenge are whether similar success could be achieved with this poorly hydrolyzed substrate, chlorpyrifos. For this study, five improved variants were selected from two rounds of directed evolution based on the formation of clear haloes on Luria-Bertani plates overlaid with chlorpyrifos. One variant, B3561, exhibited a 725-fold increase in the k(cat)/K(m) value for chlorpyrifos hydrolysis as well as enhanced hydrolysis rates for several other OP compounds tested. Considering that wild-type OPH hydrolyzes paraoxon at a rate close to the diffusion control limit, the 39-fold improvement in hydrolysis of paraoxon by B3561 suggests that this variant is one of the most efficient enzymes available to attack a wide spectrum of organophosphate nerve agents.     

Chitooligosaccharides enzymatic production by Metarhizium anisopliae

The products of chitosan hydrolysis are chitooligosaccharides and are used mainly for medical applications due to their specific biological activities. The objective of this study was to detect and identify the products of enzymatic hydrolysis of chitosan (dimers to hexamers) using a crude extract of chitosanolytic enzymes produced by the fungus Metarhizium anisopliae. These fungus was able to produce, during 48 h cultivation in a medium containing chitosan, chitooligosaccharides ranging from dimers, trimers, tetramers and pentamers at concentrations 0.2, 0.19, 0.06, 0.04 mg/mL, respectively, and the enzymatic activity was 2.5 U/L. Using the crude enzyme extract for chitosan hydrolysis, we detected the presence of dimers to hexamers at hydrolysis times of 10, 20, 30, 40, 50 and 60 min of enzymatic reaction, but the yields were higher at 10 min (54%). The hexamers was obtained only with 30 min of reaction with concentration of 0.004 mg/mL.     

Altering the Substrate Specificity of Organophosphorus Hydrolase for Enhanced Hydrolysis of Chlorpyrifos

Chlorpyrifos is one of the most popular pesticides used for agriculture crop protection, and widespread contamination is a potential concern. However, chlorpyrifos is hydrolyzed almost 1,000-fold slower than the preferred substrate, paraoxon, by organophosphorus hydrolase (OPH), an enzyme that can degrade a broad range of organophosphate pesticides. We have recently demonstrated that directed evolution can be used to generate OPH variants with up to 25-fold improvement in hydrolysis of methyl parathion. The obvious question and challenge are whether similar success could be achieved with this poorly hydrolyzed substrate, chlorpyrifos. For this study, five improved variants were selected from two rounds of directed evolution based on the formation of clear haloes on Luria-Bertani plates overlaid with chlorpyrifos. One variant, B3561, exhibited a 725-fold increase in the k_cat/K_m value for chlorpyrifos hydrolysis as well as enhanced hydrolysis rates for several other OP compounds tested. Considering that wild-type OPH hydrolyzes paraoxon at a rate close to the diffusion control limit, the 39-fold improvement in hydrolysis of paraoxon by B3561 suggests that this variant is one of the most efficient enzymes available to attack a wide spectrum of organophosphate nerve agents.     

有机磷农药在水生态系中生物净化机理研究——1.对硫磷的酶解

从氧化塘系统中分离出能降解对硫磷的细菌Pseudomonas sp.代号CTP-01,能将对硫磷分解成对硝基酚和二乙基硫代磷酸酯,并进一步分解对硝基酚。在有Cu++存在的情况下,酶比活可以达到1×104毫微克分子/毫克蛋白/分钟,Cu++对酶有激活作用,并对温度和pH影响有保护作用。对硫磷水解酶反应最适温度为40—50℃,超过50℃活性急剧降低,80℃完全失活。 CTP-01的对硫磷水解酶大部分是同膜片结合状态存在,超声破碎的无细胞酶制剂中,只有37.2%的活力存在于可溶性蛋白部分。       

Production of parathion hydrolase activity

Summary A mixed bacterial culture which was obtained in a previous enrichment grew on parathion, an organophosphate insecticide, as a sole carbon and energy source. A cell-free enzyme preparation from this culture detoxified by hydrolysis eight commercially used organophosphate insecticides.Fermentation procedures for the production of this parathion hydrolase activity were examined to determine if this enzyme activity could be produced economically. The mixed culture was grown using sterile or non-sterile procedures in 4 or 11 continuous and batch culture fermentations. A pure Pseudomonas sp isolated from the mixed culture expressed parathion hydrolase activity when grown under axenic fermentation conditions on industrially used media such as meat extract, soya bean meal, and corn extract. The optimal conditions for production of parathion hydrolase activity were determined for both pure and mixed cultures. The yield of parathion hydrolase activity/ of fermentation broth per hour was improved 22 fold by growing the pure culture on an industrial meat extract medium instead of the mixed culture on parathion.     

Whole cell-enzyme hybrid amperometric biosensor for direct determination of organophosphorous nerve agents with p-nitrophenyl substituent

In this paper, we reported the construction of a hybrid biosensor for direct, highly selective, sensitive, and rapid quantitative determination of organophosphate pesticides with p-nitrophenyl substituent using purified organophosphorus hydrolase (OPH) for the initial hydrolysis and Arthrobacter sp. JS443 for subsequent p-nitrophenol oxidation. The biocatalytic layer was prepared by co-immobilizing Arthrobacter sp. JS443 and OPH on a carbon paste electrode. OPH catalyzed the hydrolysis of organophosphorus pesticides with p-nitrophenyl substituent such as paraoxon and methyl parathion to release p-nitrophenol that was oxidized by the enzymatic machinery of Arthrobacter sp. JS443 to carbon dioxide through electroactive intermediates 4-nitrocatechol and 1,2,4-benzenetriol. The oxidization current of the intermediates was measured and correlated to the concentration of organophosphates. The best sensitivity and response time were obtained using a sensor constructed with 0.06 mg dry weight of cell and 965 IU of OPH operating at 400 mV applied potential (vs. Ag/AgCl reference) in 50 mM citrate-phosphate pH 7.5 buffer at room temperature. Using these conditions, the biosensor measured as low as 2.8 ppb (10 nM) of paraoxon and 5.3 ppb (20 nM) of methyl parathion without interference from phenolic compounds, carbamate pesticides, triazine herbicides, and organophosphate pesticides that do not have the p-nitrophenyl substituent. The biosensor had excellent operational life-time stability with no decrease in response for more than 40 repeated uses over a 12-h period when stored at room temperature, while its storage life was approximately 2 days when stored in the operating buffer at 4 degrees C.     

Hydrolysis of sphingomyelin and phosphatidylcholine by midgut homogenates of the stable fly

Qualitative and quantitative analyses were made to characterize the enzymatic degradation of sphingomyelin and phosphatidylcholine by midgut homogenates of the adult stable fly, Stomoxys calcitrans (L.). The results indicated that sphingomyelin was hydrolyzed by an enzyme with sphingomyelinase-like properties, and that phosphatidylcholine was hydrolyzed by an enzyme with properties similar to phospholipase C. The optimum pH for the sphingomyelinase was 7.6, and the rate of hydrolysis of sphingomyelin at that pH was linear from 1 to 4 nmol of substrate and 5 to 25 micrograms of enzyme preparation. Dialysis of the homogenates against Tris-HCl and imidazole buffers resulted in a decrease of sphingomyelinase activity by 59% and 98%, respectively, and the original activity was not restored with the addition of Ca++, Mg++, or Mn++.     

Amperometric microbial biosensor for direct determination of organophosphate pesticides using recombinant microorganism with surface expressed organophosphorus hydrolase.

An amperometric microbial biosensor for the direct measurement of organophosphate nerve agents is described. The sensor is based on a carbon paste electrode containing genetically engineered cells expressing organophosphorus hydrolase (OPH) on the cell surface. OPH catalyzes the hydrolysis of organophosphorus pesticides with p-nitrophenyl substituent such as paraoxon, parathion and methyl parathion to p-nitrophenol. The later is detected anodically at the carbon transducer with the oxidation current being proportional to the nerve-agent concentration. The sensor sensitivity was optimized with respect to the buffer pH and loading of cells immobilized using paraoxon as substrate. The best sensitivity was obtained using a sensor constructed with 10 mg of wet cell weight per 100 mg of carbon paste and operating in pH 8.5 buffer. Using these conditions, the biosensor was used to measure as low as 0.2 microM paraoxon and 1 microM methyl parathion with very good sensitivity, excellent selectivity and reproducibility. The microbial biosensor had excellent storage stability, retaining 100% of its original activity when stored at 4 degrees C for up to 45 days.     

Pathways of microbial metabolism of parathion.

A mixed bacterial culture, consisting of a minimum of nine isolates, was adapted to growth on technical parathion (PAR) as a sole carbon and energy source. The primary oxidative pathway for PAR metabolism involved an initial hydrolysis to yield diethylthiophosphoric acid and p-nitrophenol. A secondary oxidative pathway involved the oxidation of PAR to paraoxon and then hydrolysis to yield p-nitrophenol and diethylphosphoric acid. Under low oxgen conditions PAR was reduced via a third pathway to p-aminoparathion and subsequently hydrolyzed to p-aminophenol and diethylthiophosphoric acid. PAR hydrolase, an enzyme produced by an isolate from the mixed culture, rapidly hydrolyzed PAR and paraoxon (6.0 mumol/mg per min). This enzyme was inducible and stable at room temperature and retained 100% of its activity when heated for 55 C for 10 min.     

Pathways of microbial metabolism of parathion.

A mixed bacterial culture, consisting of a minimum of nine isolates, was adapted to growth on technical parathion (PAR) as a sole carbon and energy source. The primary oxidative pathway for PAR metabolism involved an initial hydrolysis to yield diethylthiophosphoric acid and p-nitrophenol. A secondary oxidative pathway involved the oxidation of PAR to paraoxon and then hydrolysis to yield p-nitrophenol and diethylphosphoric acid. Under low oxgen conditions PAR was reduced via a third pathway to p-aminoparathion and subsequently hydrolyzed to p-aminophenol and diethylthiophosphoric acid. PAR hydrolase, an enzyme produced by an isolate from the mixed culture, rapidly hydrolyzed PAR and paraoxon (6.0 mumol/mg per min). This enzyme was inducible and stable at room temperature and retained 100% of its activity when heated for 55 C for 10 min.     

Mutagenesis of organophosphorus hydrolase to enhance hydrolysis of the nerve agent VX

Organophosphorus hydrolase (OPH) is capable of hydrolyzing a wide variety of organophosphorus pesticides and chemical warfare agents. However, the hydrolytic activity of OPH against the warfare agent VX is less than 0.1% relative to its activity against parathion and paraoxon. Based on the crystal structure of OPH and the similarities it shares with acetylcholinesterase, eight OPH mutants were constructed with the goal of increasing OPH activity toward VX. The activities of crude extracts from these mutants were measured using VX, demeton-S methyl, diisopropylfluoro-phosphate, ethyl parathion, paraoxon, and EPN as substrates. One mutant (L136Y) displayed a 33% increase in the relative VX hydrolysis rate compared to wild type enzyme. The other seven mutations resulted in 55-76% decreases in the relative rates of VX hydrolysis. There was no apparent relationship between the hydrolysis rates of VX and the rates of the other organophosphorus compounds tested.     

Production, purification, and characterization of an extracellular chitosanase from Streptomyces.

The synthesis by Streptomyces sp. no. 6 of an extracellular chitosanase was induced by glucosamine. The enzyme was purified to homogeneity by Sephadex G-100, carboxymethyl-cellulose, and diethylaminoethyl-cellulose chromatography. The purified enzyme hydrolyzed chitosan (the beta-1,4-linked polymer of glucosamine) but not chitin nor carboxymethyl-cellulose. The only products of the hydrolysis detectable by paper chromatography were di- and triglucosamine. Sephadex G-100 chromatography and sodium dodecyl sulfate-polyacrylamide gel electrophoresis indicated that the molecular weight of the enzyme was between 29,000 and 26,000. Acid hydrolysates of the enzyme contained no cysteic acid or glucosamine or other carbohydrate. At 25 C, maximum activity was obtained between pH 4.5 and 6.5. The enzymatic hydrolysis of chitosan occurred over a wide range of temperatures and was maximal at 60 C. The rate of the reaction was inhibited by concentrations of soluble chitosan higher than 0.5 g/liter. The apparent Km calculated from a Lineweaver-Burke plot was 0.688 g/liter at pH 5.5. The enzyme prevented spore germination and caused a significant decrease in the turbidity of germinated spore suspensions of the Mucor strains tested. Such a decrease was the result of a partial lysis of the cell wall.     

Microbial Decontamination of Parathion and p-Nitrophenol in Aqueous Media

A mixed microbial culture was adapted to growth on parathion to determine the feasibility of using microorganisms to detoxify concentrated parathion in agricultural wastes. In a 600-ml chemostat, the culture was able to degrade 50 mg of parathion per liter per h. Para-nitrophenol, produced by enzymatic hydrolysis of parathion, caused delays in exponential growth which were directly proportional to its concentration. A pseudomonad, isolated from the mixed culture, exhibited optimal growth at 0.21 mM p-nitrophenol and grew in concentrations up to 3.5 mM. In metabolic studies using [(14)C]p-nitrophenol, the nitro group was removed in stoichiometric quantities as nitrite and hydroquinone was tentatively identified as a metabolite.