T-2 and HT-2 toxin analysis in cereals and cereal products following IAC cleanup and determination via GC-ECD after derivatization

The authors present a new and sensitive method for the determination of T-2- und HT-2 Toxin in cereals and cereal products in the low ppb level. A representative part of the cereal sample is extracted with a mixture of methanol-water (90:10) and the extract is cleaned on the commercially available immunoaffinity column T-2test™ (IAC), eluted with methanol, derivatized by pentafluorpropionic anhydride (PFPA) and measured on a GC-ECD. The method has been successfully validated on wheat, rye and oats. The recovery rates with wheat and rye endowed on a level of 50 ppb and with 85 ppb naturally contaminated oats were 71–115% with a coefficient of variation of 5.7–19.5%. The detection limits of the method with a signal to noise level of 3:1 were 1.5–2.3 μg/kg for HT-2 and 1.1–1.7 μg/kg for T-2 toxin. Financial support: Federal Ministry of Food and Agriculture (part of the project 05HS 001 — Improvement and validation of type A trichothecene (T-2 toxin and HT-2 toxin) analysis and occurrence of these mycotoxins in food marketed in Germany)     

Large-scale production of selected type A trichothecenes: the use of HT-2 toxin and T-2 triol as precursors for the synthesis of <Emphasis Type="Italic">d</Emphasis><Subscript>3</Subscript>-T-2 and <Emphasis Type="Italic">d</Emphasis><Subscript>3</Subscript>-HT-2 toxin

The type A trichothecenes T-2 and HT-2 toxins are toxic secondary metabolites produced by fungi of the Fusarium genus. Their occurrence in cereals, especially in oats, implies health risks for the consumer. Therefore, it is an important task to develop selective and sensitive methods for the analysis of T-2 and HT-2 toxins, and to undertake further studies on their stability and toxicity. Although most toxins are commercially available, their high prices are the limiting factor on the realization of these experiments. Thus, we developed a method for large-scale production of T-2 and HT-2 toxin as well as T-2 triol and T-2 tetraol. T-2 toxin was obtained in gram quantities by biosynthetic production with cultures of F. sporotrichioides. As HT-2 toxin was only formed as a by-product, and T-2 triol and T-2 tetraol were not generated, these compounds were produced by alkaline hydrolysis of T-2 toxin. Separation and isolation of crude toxins was achieved by fast centrifugal partition chromatography (FCPC), which is an efficient tool for the large-scale purification of natural products. Using this fast and yield effective technique, several hundred milligrams of HT-2 toxin, T-2 triol, and T-2 tetraol were obtained. Subsequent, HT-2 toxin and T-2 triol were used for the large-scale synthesis of isotope-labeled T-2 and HT-2 toxin, respectively. Using these standards, an isotope dilution-(ID)-HPLC-MS/MS method for the quantification of T-2 and HT-2 toxin in different matrices was developed.     

Intestinal metabolism of T-2 toxin in the pig cecum model

T-2 toxin, a toxic member of the group A trichothecenes, is produced by various Fusarium species that can potentially affect human health. As the intestine plays an important role in the metabolism of T-2 toxin for animals and humans, the degradation and metabolism of T-2 toxin was studied using the pig cecum in vitro model system developed in the author??s group. In order to study the intestinal degradation of T-2 toxin by pig microbiota, incubation was performed with the cecal chyme from four different pigs in repeat determinations. A large variation in the intestinal degradation of T-2 toxin was observed for individual pigs. T-2 toxin was degraded almost completely in one out of four pigs, in which only 3.0?±?0.1?% of T-2 toxin was left after 24?h incubation. However, in the other three incubations with pig cecal suspension, 54.1?±?11.7?C68.9?±?16.1?% of T-2 toxin were still detectable after 24?h incubation time. The amount of HT-2 toxin was increased along with the incubation time, and HT-2 toxin accounted for 85.2?±?0.7?% after 24?h in the most active cecum. HT-2 toxin was the only detectable metabolite formed by the intestinal bacteria. This study suggests that the toxicity of T-2 toxin for pigs is caused by the combination of T-2 and HT-2 toxins.     

Interacting climate change environmental factors effects on Fusarium langsethiae growth,expression of Tri genes and T-2/HT-2 mycotoxin production on oat-based media and in stored oats

This study examined the effect of climate change (CC) abiotic factors of temperature (20, 25, 30 °C), water activity (a_w; 0.995, 0.98) and CO₂ exposure (400, 1000 ppm) may have on (a) growth, (b) gene expression of biosynthetic toxin genes (Tri5, Tri6, Tri16), and (c) T-2/HT-2 toxins and associated metabolites by Fusarium langsethiae on oat-based media and in stored oats. Lag phases and growth were optimum at 25 °C with freely available water. This was significantly reduced at 30 °C, at 0.98 a_w and 1000 ppm CO₂ exposure. In oat-based media and stored oats, Tri5 gene expression was reduced in all conditions except 30 °C, 0.98 a_w, elevated CO₂ where there was a significant (5.3-fold) increase. The Tri6 and Tri16 genes were upregulated, especially in elevated CO₂ conditions. Toxin production was higher at 25 °C than 30 °C. In stored oats, at 0.98 a_w, elevated CO₂ led to a significant increase (73-fold) increase in T2/HT-2 toxin, especially at 30 °C. Nine T-2 and HT-2 related metabolites were detected, including a new dehydro T-2 toxin (which correlated with T-2 production) and the conjugate, HT-2 toxin, glucuronide. This shows that CC factors may have a significant impact on growth and mycotoxin production by F. langsethiae.     

Different sample treatment approaches for the analysis of T-2 and HT-2 toxins from oats-based media

A LC-DAD method is proposed for the determination of the T-2 and HT-2 toxins in cultures of Fusarium langsethiae in oat-based and other in vitro media. Test media consisted of freshly prepared milled oats to which T-2 and HT-2 toxin stock solutions were added. Different mixtures of extraction solvent (acetonitrile:water and methanol:water), extraction times (30′, 60′ or 90′) and drying methods were investigated. Results showed that extraction with methanol:water (80:20, v/v) for 90 min, drying with N₂ and subsequent analysis by LC-DAD was the fastest and most user friendly method for detecting HT-2 and T-2 toxins production by F. langsethiae strains grown on oat-based media at levels of 0.459 and 0.508 mg of toxin/kg of agar, respectively. The proposed method was used to investigate toxin production of 6 F. langsethiae strains from northern Europe and provided clear chromatograms with no interfering peaks in media with and without glycerol as water activity modifier.     

Simultaneous determination of type A-& B-trichothecenes and zearalenone in cereals by High Performance Liquid Chromatography — Tandem Mass Spectrometry

A rapid quantitative method for the simultaneous determination of the majorFusarium mycotoxins nivalenol, deoxynivalenol, fusarenon-X, 3-acetyl-deoxynivalenol, 15-acetyl-deoxynivalenol, diacetoxyscirpenol, HT-2 toxin, T-2 toxin and zearalenone in maize and wheat was developed. Raw extracts (acetonitrile/water 84/16) are cleaned-up with MycoSep^® columns., Chromatographic separation and end determination is carried out by HPLC-APCI-MS/MS.HPLC run times of 10 minutes considerably increases sample throughput and make this method suitable for routine analysis. The use of a triple quadrupole mass spectrometer allows the selective detection of the mycotoxins and their quantification in the low μg/kg-range.     

Glucosylation and Other Biotransformations of T-2 Toxin by Yeasts of the Trichomonascus Clade

Trichothecenes are sesquiterpenoid toxins produced by Fusarium species. Since these mycotoxins are very stable, there is interest in microbial transformations that can remove toxins from contaminated grain or cereal products. Twenty-three yeast species assigned to the Trichomonascus clade (Saccharomycotina, Ascomycota), including four Trichomonascus species and 19 anamorphic species presently classified in Blastobotrys, were tested for their ability to convert the trichothecene T-2 toxin to less-toxic products. These species gave three types of biotransformations: acetylation to 3-acetyl T-2 toxin, glycosylation to T-2 toxin 3-glucoside, and removal of the isovaleryl group to form neosolaniol. Some species gave more than one type of biotransformation. Three Blastobotrys species converted T-2 toxin into T-2 toxin 3-glucoside, a compound that has been identified as a masked mycotoxin in Fusarium-infected grain. This is the first report of a microbial whole-cell method for producing trichothecene glycosides, and the potential large-scale availability of T-2 toxin 3-glucoside will facilitate toxicity testing and development of methods for detection of this compound in agricultural and other products.     

Cytotoxic and immunotoxic effects of Fusarium mycotoxins using a rapid colorimetric bioassay

A colorimetric MTT (tetrazolium salt) cleavage test was used to evaluate cytotoxicity of twenty-three Fusarium mycotoxins on two cultured human cell lines (K-562 and MIN-GL1) as well as their inhibitory effect on proliferation of phytohemagglutinin-stimulated human peripheral blood lymphocytes. The values of 50% inhibition of lymphocyte blastogenesis were very close to the 50% cytotoxic doses observed with the more sensitive cell line (MIN-GL1). T-2 toxin was the most cytotoxic with CD₅₀ and ID₅₀ values less than 1 ng/ml. Type A trichothecenes were the most cytotoxic followed by the type B trichothecenes; the non-trichothecenes were the least cytotoxic. The MTT cleavage test, in conjunction with cell culture, is a simple and rapid bioassay to evaluate cytotoxicity and immunotoxicity of Fusarium mycotoxins.Abbreviations Ac acetyl - ACU acuminatin - DAS diacetoxyscirpenol - DON deoxynivalenol - FUS fusarenon-X - HT-2 HT-2 toxin - MC mononuclear cell - MTT 3-(4,5-dimethylthiazol-2-yl)2,5-diphenyltetrazolium bromide - NEO neosolaniol - NIV nivalenol - NT-1 4,8-diacetoxy T-2 tetraol - PBS phosphate buffered saline - TAT-2T tetraacetoxy T-2 tetraol - T-2 T-2 toxin     

Influence of T-2 and HT-2 Toxin on the Blood-Brain Barrier In Vitro: New Experimental Hints for Neurotoxic Effects

The trichothecene mycotoxin T-2 toxin is a common contaminant of food and feed and is also present in processed cereal derived products. Cytotoxic effects of T-2 toxin and its main metabolite HT-2 toxin are already well described with apoptosis being a major mechanism of action. However, effects on the central nervous system were until now only reported rarely. In this study we investigated the effects of T-2 and HT-2 toxin on the blood-brain barrier (BBB) in vitro. Besides strong cytotoxic effects on the BBB as determined by the CCK-8 assay, impairment of the barrier function starting at low nanomolar concentrations were observed for T-2 toxin. HT-2 toxin, however, caused barrier disruption at higher concentrations compared to T-2 toxin. Further, the influence on the tight junction protein occludin was studied and permeability of both toxins across the BBB was detected when applied from the apical (blood) or the basolateral (brain) side respectively. These results clearly indicate the ability of both toxins to enter the brain via the BBB.     

Intake estimates for trichothecene toxins of the population in Southwest Germany in 1998 and in 1999

The intake of theFusarium toxins deoxynivalenol (DON), nivalenol (NIV), HT-2 and T-2 toxin (HT-2, T-2), 3-, 15-acetyldeoxynivalenol (3-, 15- ADON), and fusarenon-X (FUS-X) was calculated for adults, children and babies, for an area of southwest Germany and two years (1998, 1999). Estimates were based on consumption data of bread and pasta by both adults and children and of infant food by babies, reported for the German population in a study on behalf of the European Union, and on toxin contents of a total of 208 samples of these commodities. No exceeding of the tolerable daily intake (TDI) of DON, NIV and the sum of HT-2 and T-2, as stated by the EU, was found for adults (70 kg body weight (BW)) and for babies (10 kg BW), independent of year and level of consumption. For children (20 kg BW) the intake of DON exceeded the TDI in 1998 for high, and in 1999 for both mean and high consumers. For both years the intake of the sum of HT-2 and T-2 was below the TDI following mean but above this value following high consumption. The intake of NIV was far below the TDI for both levels of ingestion. The daily intake of each of the three toxins 3-, 15- ADON and FUS-X was below 0.03, 0.11 and 0.05 μg/kg/BW for adults, children and babies, respectively. Presented at the 27^th Mykotoxin-Workshop, Dortmund. Germany, June 13–15, 2005     

Production of neosolaniol monoacetate by an undescribedFusarium species resemblingF camptoceras

Cultures of 12 South African isolates of an undescribedFusarium species resembling but distinct fromF camptoceras were analysed for the presence of diacetoxyscirpenol (DAS), neosolaniol monoacetate (NMA), and T-2 toxin, by capillary gas chromatography utilizing electron capture detection. No DAS or T-2 toxin could be detected in any of the cultures of the isolates. NMA was, however, detected in 10 of the 12 isolates at levels ranging from 310 to 2060 ng/g. The method used, was primarily developed for the determination of DAS and T-2 toxin in fungal cultures and grain samples but was found to be suitable for the coextraction of NMA at an average recovery of 80.8%, with a detection limit in the order of 100 ng/g. Supportive evidence for the presence of the NMA was obtained by capillary gas chromatography / mass spectrometry. Regarded as a relatively rare trichothecene, NMA has never been reported to occur naturally and has previously been shown to be produced by only a fewFusarium strains.     

Type A-trichothecenes — Quantitative analysis using LC-MS and occurrence in Austrian maize and oats

During this study a method was developed for the quantitative determination of diacetoxyscirpenol (DAS), T-2 toxin and HT-2 toxin using deuterated T-2 toxin (T-2 d3 toxin) as an internal standard. The described method involves a clean up step of maize extract by the use of Mycosep® 227 columns a chromatographic separation on a Zorbax® bonus-RP-column (2,1×150mm) and the detection and quantification step on a mass spectrometer in SIM (Selected Ion Monitoring) mode.Data on the occurrence of three type A trichothecenes in Austrian maize, maize silage and oats were collected. It could be shown that maize and silage samples harvested in 2002 were only contaminated to a small extent with T-2 toxin (8% of the maize, 0% of the silage) and with HT-2 toxin (30% of the maize, 18% of the silage). But most of the analysed oats samples showed significant levels of T-2 toxin (64%) or HT-2 toxin (82%).     

Effects of Fusariotoxin T-2 on Saccharomyces cerevisiae and Saccharomyces carlsbergensis

A Fusarium metabolite, T-2 toxin, inhibits the growth of Saccharomyces carlsbergensis and Saccharomyces cerevisiae. The growth inhibitory concentrations of T-2 toxin were 40 and 100 μg/ml, respectively, for exponentially growing cultures of the two yeasts. S. carlsbergensis was more sensitive to the toxin and exhibited a biphasic dose-response curve. Addition of the toxin at 10 μg/ml of S. carlsbergensis culture resulted in a retardation of growth as measured turbidimetrically, after only 30 to 40 min. This action was reversible upon washing the cells free of the toxin. The sensitivity of the yeasts to the toxin was dependent upon the types and concentrations of carbohydrates used in the growth media. The sensitivity of the cells to the toxin decreased in glucose-repressed cultures. These results suggest that T-2 toxin interferes with mitochondrial functions of these yeasts.     

Mycotoxin production of <Emphasis Type="Italic">Fusarium langsethiae</Emphasis> and <Emphasis Type="Italic">Fusarium sporotrichioides</Emphasis> on cereal-based substrates

The present study investigated and compared the mycotoxin production of two Fusarium species, F. sporotrichioides and F. langsethiae, isolated from grain samples. Fusarium strains were cultivated at 25°C for 7 days on two types of solid media, i.e. rice-flour and cereal-flour agar. Toxins produced were measured after the incubation period with a multi-mycotoxin method based on liquid chromatography–tandem mass spectrometry (LC-MS/MS). Both F. sporotrichioides and F. langsethiae synthesised type-A trichothecenes, i.e. T-2 and HT-2 toxins, diacetoxyscirpenol (DAS) and neosolaniol (NEO). In addition, both species could be verified as beauvericin producers. The toxin production occurred in both cereal-based assays but was more predominant on the carbohydrate-rich rice-flour medium. The two species were potent producers of T-2 toxin, the highest amounts measured being at a level of 20,000 μg/kg after 7 days’ incubation. Differences between the species were observed regarding the quantitative production of the other trichothecenes: F. sporotrichioides was a more prolific producer of HT-2 toxin and beauvericin, whereas F. langsethiae produced higher amounts of DAS and NEO. On rice-flour assay, the toxin production was monitored during the growth period. The production started rapidly at an early growth phase and several toxins could be detected already after the 1st day of incubation, the highest concentrations being at mg/kg level. The results also indicated that the biosynthesis by F. sporotrichioides and F. langsethiae shifted towards the other type-A trichothecenes at the expense of T-2 toxin at the end of the cultivation.     

Effects of T-2 toxin and its congeners on membrane functions of cultured human fibroblasts

Cytotoxicity of T-2 toxin, HT-2 toxin, acetyl T-2, neosolaniol, and T-2 tetraol was compared between normal human fibroblasts and mutant I-cell human fibroblasts, which only produce 10 to 15% of lysosomal hydrolases present in normal fibroblasts. Both cleavage of 3-(4, 5-dimethyl-2-thiazolyl)-2,5-diphenyl-2H-tetrazolium bromide (MTT) and cell count by hemocytometer were used for evaluations. For all toxins, dose-related effects on both types of cultures were evident. Cytotoxicity of the above mycotoxins on both cell lines were similar, indicating that lysosomal enzymes were not involved in the toxicity of T-2 toxin and its congeners. An inhibitor of lysosomal cysteine proteases (E-64) did not alter the cytotoxicity of T-2 toxin. The decreasing order of toxicity was T-2 toxin, HT-2 toxin, neosolaniol, acetyl T-2 toxin, and T-2 tetraol in both cell lines. When normal human fibroblasts were loaded with the fluorescent dye Lucifer yellow CH (LY), a subsequent treatment of T-2 toxin did not disrupt lysosomal membranes. The uptake of LY was not affected by T-2 toxin, which indicated that T-2 toxin did not interfere with the endocytic pathway. Results indicate that T-2 toxin and its congeners do not exert their primary toxic effect through lysosomal enzymes, membranes, or via the endocytic pathway.     

A monoclonal antibody-based enzyme immunoassay for the detection of T-2 toxin at picogram levels

Thirteen monoclonal antibodies reactive with HT-2 were prepared by using a HT-2 hemisuccinate coupled to human serum albumin as antigen for the immunization of BALB/c mice. In a competitive enzyme immunoassay on a double antibody solid phase using HT-2 hemisuccinate coupled to horseradish peroxidase as enzyme linked toxin all antibodies reacted much better with T-2 toxin and acetyl T-2 than with HT-2. Eleven antibodies showed almost the same sensitivity and specificity, and one of these, designated 3E2, is extensively described. Its cross-reactivities with HT-2, T-2 toxin, acetyl T-2, iso T-2, T-2 tetraol tetraacetate and T-2 triol were 1·0, 140·2, 161·2, 0·32, 0·14 and 0·016, respectively. Two other antibodies, designated 2A4 and 2A5, behaved quite differently. The cross-reactivities of antibody 2A4 with these toxins were: 1·0, 113·9, 374·4, 1·35, 0·34 and 0·023, respectively; for antibody 2A5 they were 1·0, 46·1, 155·4, 8·31, 0·9 and 0·08, respectively. All antibodies proved to be IgGl. By using the antibody 3E2 a highly sensitive and very specific enzymc immunoassay for the detection of T-2 toxin was developed. The detection limit for T-2 toxin was 5 pg/ml (0·25 pg/assay).     

Production of T-2 toxin by a Fusarium resembling Fusarium poae

A Fusarium species with a micro morphology similar to F. poae and a metabolite profile resembling that of F. sporotrichioides has been identified. Like typical F. poae, the microconidia have a globose to pyriform shape, but the powdery appearance, especially on Czapek-Dox Iprodione Dichloran agar (CZID), less aerial mycelium and the lack of fruity odour on Potato Sucrose Agar (PSA) make it different from F. poae. The lack of macroconidia, polyphialides and chlamydospores differentiates it from F. sporotrichioides. All 18 isolates investigated, 15 Norwegian, two Austrian and one Dutch, produced T-2 toxin (25–400 μg/g) on PSA or Yeast Extract Sucrose agar (YES). In addition, neosolaniol, iso-neosolaniol, HT-2 toxin, 4- and 15-acetyl T-2 tetraol, T-2 triol and T-2 tetraol and4,15-diacetoxyscirpenol were formed in variable amounts. Neither nivalenol, 4- or 15-acetylnivalenolor 4,15-diacetylnivalenol were detected in any of the cultures, while these toxins were produced at least in small amounts by all the 12 typical F. poae isolates studied. The question of whether this Fusarium should be classified as F. poae or F. sporotrichioides or a separate taxon should be addressed. This revised version was published online in June 2006 with corrections to the Cover Date.     

Incidence ofFusaria and occurrence of selected Fusarium mycotoxins on Lolium spp. in Germany

Test plantings with varieties ofLolium multiflorum andL perenne were harvested 4 to 7 times a year in 1991 and 1992. Samples were checked for the presence ofFusaria, the mycotoxins zearalenone, T-2 toxin, and diacetoxyscirpenol (DAS). Spectrum of species and the incidence ofFusaria and fusariotoxins are discussed in relation to the influencing factors site, variety ofLolium, harvesting time and year. Depending on these factors, 41 % to 100 % of the samples wereFusarium positive. Differences in infestation with Fusarium among varieties ofLolium perenne were dependent on location and did not correlate with yield. The six species ofFusarium pathogenic toLolium spp. (F. graminearum, F. culmorum, F. avenaceum, F. oxysporum, F. solani, and F. acuminatum) totaled 35.7 % of all the isolated strains. 14 species could be isolated fromLolium samples (descending frequency):F. culmorum, F. sambucinum, F. equiseti, F. acuminatum, F. semitectum, F. oxysporum, F. subglutinans, F. avenaceum, F. sporotrichioides, F. proliferatum, F. tricinctum, F. anthophilum, F. dimerum and F. graminearum. For the detection ofFusaria a promising new immunological method is presented. It is based on the genus specific production of exopolysaccharides byFusarium species. Mycotoxin contents in grass ranged from 0.01 to 4.75 ppm for zearalenone with 67 % positive samples and 0.3 % samples above 1 ppm, 0.04 to 2.78 ppm for T-2 toxin with 25 % positive samples and 2.8 % samples above 1 ppm, and 0.003 to 0.06 for DAS with 21.6 % positive samples. In silages, no T-2 toxin was detectable. IsolatedFusarium strains were checked for the ability to produce the mycotoxins zearalenone, T-2 toxin and DAS in culture. Most of the strains were positive for at least one of the toxins.     

HPLC-MS-Method for A-Trichothecenes

Gaschromatography with electron capture detection belongs to the most important methods for analysing the A-trichothecenes T-2 toxin, HT-2 toxin and diacetoxyscirpenol. The need of a derivatisation for these mycotoxins prior detection is the main disadvantage of this method. In this paper a sensitive high performance liquid chromatography method to analyse the A-trichothecenes in grain is described. The clean up was performed with multifunctional columns (MycoSep^TM, Romer Labs, Inc., MO). The detection limits of these methods are 3.5 μg/kg for T-2 toxin, 6.1 μg/kg for HT-2 toxin and 4.1 μg/kg for diacetoxyscirpenol. Limits of quantification were 12.7 μg/kg for T-2, 21.9 μg/kg for HT-2 and 14.8 μg/kg for DAS, respectively recovery rates were about 100% for each compound.     

Metabolism of trichothecene mycotoxins. I. Microsomal deacetylation of T-2 toxin in animal tissues

In an attempt to elucidate the active form of T-2 toxin, one of trichothecene mycotoxins in vivo, the metabolism in animal tissues was studied in vitro by using gas liquid chromatography. T-2 toxin was selectively hydrolysed by the microsomal esterase at C-4, giving rise to HT-2 toxin as the only metabolite. This esterase activity was found mainly in the microsomes of liver, kidney, and spleen of laboratory animals. Since the enzymatic hydrolysis of T-2 toxin was inhibited by eserine, and diisopropylfluorophosphate, it is concluded that non-specific carboxyesterase [EC 3.1.1.1] of microsomal origin participates in this type of selective hydrolysis of T-2 toxin. The microsomal fraction from rabbit liver was proved to be a convinient material for the preparation of HT-2 toxin from T-2 toxin. From the evidence that the toxicity of HT-2 toxin is comparable to that of T-2 toxin and that the microsomal fraction of whole liver possesses the ability to biotransform the total lethal dose of T-2 toxin into HT-2 within a few minutes, T-2 toxin administered to animals is presumed to exhibit its toxicity partly as HT-2 toxin.