Treatability of cheese whey for single-cell protein production in nonsterile systems: Part II. The application of aerobic sequencing batch reactor (aerobic SBR) to produce high biomass of Dioszegia sp. TISTR 5792

This study aimed to investigate the efficiency of an aerobic sequencing batch reactor (aerobic SBR) in a nonsterile system using the application of an experimental design via central composite design (CCD). The acidic whey obtained from lactic acid fermentation by immobilized Lactobacillus plantarum sp. TISTR 2265 was fed into the bioreactor of the aerobic SBR in an appropriate ratio between acidic whey and cheese whey to produce an acidic environment below 4.5 and then was used to support the growth of Dioszegia sp. TISTR 5792 by inhibiting bacterial contamination. At the optimal condition for a high yield of biomass production, the system was run with a hydraulic retention time (HRT) of 4 days, a solid retention time (SRT) of 8.22 days, and an acidic whey concentration of 80% feeding. The chemical oxygen demand (COD) decreased from 25,230 mg/L to 6,928 mg/L, which represented a COD removal of 72.15%. The yield of biomass production and lactose utilization by Dioszegia sp. TISTR 5792 were 13.14 g/L and 33.36%, respectively, with a long run of up to 180 cycles and the pH values of effluent were rose up to 8.32 without any pH adjustment.     

Optimization of probiotic and lactic acid production by Lactobacillus plantarum in submerged bioreactor systems

Biomass and lactic acid production by a Lactobacillus plantarum strain isolated from Serrano cheese, a microorganism traditionally used in foods and recognized as a potent probiotic, was optimized. Optimization procedures were carried out in submerged batch bioreactors using cheese whey as the main carbon source. Sequential experimental Plackett–Burman designs followed by central composite design (CCD) were used to assess the influence of temperature, pH, stirring, aeration rate, and concentrations of lactose, peptone, and yeast extract on biomass and lactic acid production. Results showed that temperature, pH, aeration rate, lactose, and peptone were the most influential variables for biomass formation. Under optimized conditions, the CCD for temperature and aeration rate showed that the model predicted maximal biomass production of 14.30 g l⁻¹ (dw) of L. plantarum. At the central point of the CCD, a biomass of 10.2 g l⁻¹ (dw), with conversion rates of 0.10 g of cell g⁻¹ lactose and 1.08 g lactic acid g⁻¹ lactose (w/w), was obtained. These results provide useful information about the optimal cultivation conditions for growing L. plantarum in batch bioreactors in order to boost biomass to be used as industrial probiotic and to obtain high yields of conversion of lactose to lactic acid.     

Effect of malic acid on the growth kinetics of<Emphasis Type="Italic"> Lactobacillus plantarum</Emphasis>

The fermentation kinetics of Lactobacillus plantarum were studied in a specially designed broth formulated from commercially available, dehydrated components (yeast extract, trypticase, ammonium sulfate) in batch and continuous culture. During batch growth in the absence of malic acid, the specific growth rate was 0.20 h^–1. Malic acid in the medium, at 2 mM or 10 mM, increased the specific growth rate of L. plantarum to 0.34 h^–1. An increase in the maximum cell yield due to malic acid also was observed. Malic acid in the medium (12 mM) reduced the non-growth-associated (maintenance energy) coefficient and increased the biomass yield in continuous culture, based on calculations from the Luedeking and Piret model. The biomass yield coefficient was estimated as 27.4 mg or 34.3 mg cells mmol^–1 hexose in the absence or presence of malic acid, respectively. The maintenance coefficient was estimated as 3.5 mmol or 1.5 mmol hexose mg^–1 cell h^–1 in the absence or presence of malic acid. These results clearly demonstrate the energy-sparing effect of malic acid on the growth- and non-growth-associated energy requirements for L. plantarum. The quantitative energy-sparing effect of malic acid on L. plantarum has heretofore not been reported, to our knowledge.     

The proteins (12 and 15 kDa) isolated from heat‐killed Lactobacillus plantarum L67 induces apoptosis in HT‐29 cells

A number of scientific studies have revealed that Lactobacillus strains have beneficial bioactivities in the gastrointestinal tract. In this study, the production of intracellular reactive oxygen species (ROS) and the amounts of intracellular calcium, protein kinase C activity, cytochrome c, Bid, Bcl‐2, Bax and the apoptosis‐mediated proteins [caspase‐8, caspase‐3 and poly ADP ribose polymerase (PARP)] were evaluated to understand the induction of programmed cell death in HT‐29 cells by Lactobacillus plantarum L67. The results obtained from this study indicated that the relative intensities of the apoptotic‐related factors (intracellular ROS and intracellular calcium) and of apoptotic signals (Bax and t‐Bid) increased with increasing concentrations of the membrane proteins isolated from heat‐killed L. plantarum L67, whereas the relative intensities of cytochrome c, Bcl‐2, caspase‐8, caspase‐3 and PARP decreased. This study determines whether proteins (12 and 15 kDa) isolated from heat‐killed L. plantarum L67 induce programmed cell death in HT‐29 cells. Proteins isolated from L. plantarum L67 can stimulate the apoptotic signals and then consequently induce programmed cell death in HT‐29 cells. The results in this study suggest that the proteins isolated from L. plantarum L67 could be used as an antitumoural agent in probiotics and as a component of supplements or health foods. Copyright © 2015 John Wiley & Sons, Ltd.     

Treatability of cheese whey for single-cell protein production in nonsterile systems: Part I. Optimal condition for lactic acid fermentation using a microaerobic sequencing batch reactor (microaerobic SBR) with immobilized Lactobacillus plantarum TISTR 2265 and microbial communities

Cheese whey contains a high organic content and causes serious problems if it is released into the environment when untreated. This study aimed to investigate the optimum condition of lactic acid production using the microaerobic sequencing batch reactor (microaerobic SBR) in a nonsterile system. The high production of lactic acid was achieved by immobilized Lactobacillus plantarum TISTR 2265 to generate an acidic pH condition below 4.5 and then to support single-cell protein (SCP) production in the second aerobic sequencing batch reactor (aerobic SBR). A hydraulic retention time (HRT) of 4 days and a whey concentration of 80% feeding gave a high lactic acid yield of 12.58 g/L, chemical oxygen demand (COD) removal of 62.38%, and lactose utilization of 61.54%. The microbial communities in the nonsterile system were dominated by members of lactic acid bacteria, and it was shown that the inoculum remained in the system up to 330 days.     

Multistrain probiotic production by co‐culture fermentation in a lab‐scale bioreactor

Most commercial probiotic products intended for pharmaceutical applications consist of combinations of probiotic strains and are available in various forms. The development of co‐culture fermentation conditions to produce probiotics with the correct proportion of viable microorganisms would reduce multiple operations and the associated costs. The aim of this study was to develop a fermentation medium and process to achieve biomass comprising the desired proportion of two probiotic strains in co‐culture. Initially, a quantification medium was developed, and the method was optimized to allow the quantification of each strain's biomass in a mixture. The specific growth rates of Lactobacillus delbrueckii spp. bulgaricus and Lactobacillus plantarum were determined in media with different carbon sources. The inoculum volume was optimized to achieve equal proportion of biomass in co‐culture fermentation in test tubes. Next, fermentation was carried out in a 3‐L bioreactor. A biomass concentration of 2.06 g/L, with L. delbrueckii spp. bulgaricus and L. plantarum in the ratio of 47%:53% (by weight), was achieved with concomitant production of 12.69 g/L of lactic acid in 14 h. The results show that with careful manipulation of process conditions, it is possible to achieve the desired proportion of individual strains in the final biomass produced by co‐culture fermentation. This process may serve as a model to produce multistrain probiotic drugs at industrial scale.     

Nisin production of Lactococcus lactis N8 with hemin‐stimulated cell respiration in fed‐batch fermentation system

In this study, nisin production of Lactococcus lactis N8 was optimized by independent variables of glucose, hemin and oxygen concentrations in fed‐batch fermentation in which respiration of cells was stimulated with hemin. Response surface model was able to explain the changes of the nisin production of L. lactis N8 in fed‐batch fermentation system with high fidelity (R² 98%) and insignificant lack of fit. Accordingly, the equation developed indicated the optimum parameters for glucose, hemin, and dissolved oxygen were 8 g L^?1 h^?1, 3 μg mL^?1 and 40%, respectively. While 1711 IU mL^?1 nisin was produced by L. lactis N8 in control fed‐batch fermentation, 5410 IU mL^?1 nisin production was achieved within the relevant optimum parameters where the respiration of cell was stimulated with hemin. Accordingly, nisin production was enhanced 3.1 fold in fed‐batch fermentation using hemin. In conclusion the nisin production of L. lactis N8 was enhanced extensively as a result of increasing the biomass by stimulating the cell respiration with adding the hemin in the fed‐batch fermentation. © 2015 American Institute of Chemical Engineers Biotechnol. Prog., 31:678–685, 2015     

Improved algal oil production from Botryococcus braunii by feeding nitrate and phosphate in an airlift bioreactor

To improve biomass and microalgal oil production of Botryococcus braunii, fed‐batch culture was investigated in an airlift photobioreactor. The optimal feeding time of the fed‐batch culture was after 15 days of cultivation, where 1.82 g/L of the microalgal biomass was obtained in the batch culture. Nitrate nutrient was the restrictive factor for the fed‐batch cultivation while phosphate nutrient with high concentration did not affect the microalgal growth. The optimal mole ratio of nitrate to phosphate was 34.7:1, where nitrate concentration reached the initial level and phosphate concentration was one quarter of its initial level. With one feeding, the biomass of B. braunii reached 2.56 g/L after 18 days. Two feedings in 2‐day interval enhanced the biomass production up to 2.87 g/L after 19 days of cultivation. The hydrocarbon content in dry biomass of B. braunii kept at high level of 64.3% w/w. Compared with the batch culture, biomass production and hydrocarbon productivity of B. braunii were greatly improved by the strategic fed‐batch cultivation.     

Conversion of lactose to methane by defined bacterial cocultures

The conversion of lactose — the main constituent of whey — to methane and carbon dioxide was studied using different defined constructed cultures, imploying strains of Methanosarcina barkeri, Methanobacterium bryantii, Escherichia coli, Acetobacterium woodii, Lactobacillus casei, and Lactobacillus plantarum. The following combinations of strains (food chains) were studied with respect to efficiency and yield of lactose conversion (methane yield in parentheses): E. coli and M. barkeri (4.5–7.6%), E. coli and M. bryantii (13.3%),E. coli, M. barkeri and M. bryantii (54%), L. casei, A. woodii and M. barkeri (93.3%). These conversions were carried out in pH controlled batch fermentations. A very efficient coculture was a combination of L. plantarum with A. woodii and M. barkeri: in chemostat cultures lactose was converted to methane and carbon dioxide with a yield of about 90%, at dilution rates of 0.27 d^-1to 0.37 d^-1.     

Simultaneous single-cell protein production and COD removal with characterization of residual protein and intermediate metabolites during whey fermentation by K. marxianus

Cheese whey fermentation with Kluyveromyces marxianus was carried out at 40 °C and pH 3.5 to examine simultaneous single-cell protein production and chemical oxygen demand (COD) removal, determine the fate of soluble whey protein and characterize intermediate metabolites. After 36 h of batch fermentation, the biomass concentration increased from 2.0 to 6.0 g/L with 55 % COD reduction (including protein), whereas soluble whey protein concentration decreased from 5.6 to 4.1 g/L. It was confirmed through electrophoresis (SDS-PAGE) that the fermented whey protein was different from native whey protein. HPLC and GC–MS analysis revealed a change in composition of organic compounds post-fermentation. High inoculum concentration in batch fermentation resulted in an increase in biomass concentration from 10.3 to 15.9 g/L with 80 % COD reduction (including protein) within 36 h with residual protein concentration of 4.5 g/L. In third batch fermentation, the biomass concentration increased from 7.3 to 12.4 g/L with 71 % of COD removal and residual protein concentration of 4.3 g/L after 22 h. After 22 h, the batch process was shifted to a continuous process with cell recycle, and the steady state was achieved after another 60 h with biomass yield of 0.19 g biomass/g lactose and productivity of 0.26 g/L h. COD removal efficiency was 78–79 % with residual protein concentration of 3.8–4.2 g/L. The aerobic continuous fermentation process with cell recycle could be applied to single-cell protein production with substantial COD removal at low pH and high temperature from cheese whey.     

Novel surface display system for heterogonous proteins on Lactobacillus plantarum

Aims: To establish a novel cell surface display system that would enable the display of target proteins on Lactobacillus plantarum. Methods and Results: Blast P analysis of the amino acids sequence data revealed that the N‐terminus of the putative muropeptidase MurO from L. plantarum contained two putative lysin motif (LysM) repeat regions, implying that the MurO was involved in bacterial cell wall binding. To investigate the potential of MurO for surface display, green fluorescent protein (GFP) was fused to MurO at its C‐terminus and the resulting fusion protein was expressed in Escherichia coli. After being mixed with L. plantarum cells in vitro, GFP was successfully displayed on the surfaces of L. plantarum cells. Increases in the fluorescence intensities of chemically pretreated L. plantarum cells compared to those of nonpretreated cells suggested that the peptidoglycan was the binding ligand for MurO. SDS sensitivity assay showed that the GFP fluorescence intensity was reduced after being treated with SDS. To demonstrate the applicability of the MurO‐mediated surface display system, β‐galactosidase from Bifidobacterium bifidium, in place of GFP, was functionally displayed on the surface of L. plantarum cells via MurO. Conclusions: The MurO was a novel anchor protein for constructing a surface display system for L. plantarum. Significance and Impact of Study: The success in surface display of GFP and β‐galactosidase opened up the feasibility of employing the cell wall anchor of MurO for surface display in L. plantarum.     

Behaviour of different Lactobacillus species in the production of lactic acid by the fermentation of whey

The behaviour of different Lactobacillus casei and Lactobacillus plantarum species in the fermentation of Manchego whey was experimentally studied and the results were statistically analyzed using a hypothesis contrast method. The steadiness of the velocity of the production of lactic acid during the fermentation process allowed the use of this variable to compare the different microorganisms. From this comparison it was inferred that the individuals of the same population behave alike and that the L. casei population produces lactic acid at a higher rate than the L. plantarum population. A competitive effect among the members of the L. casei population was also observed.     

植物乳杆菌CCFM8724抑制双菌生物膜的成分初探

【背景】植物乳杆菌是一种重要的益生菌,本实验室前期研究表明植物乳杆菌CCFM8724发酵液可抑制变异链球菌和白色念珠菌双菌生物膜,但植物乳杆菌发酵液中起作用的具体物质尚不清楚。【目的】评价植物乳杆菌CCFM8724发酵液抑菌成分的特性,初步探究其物质基础。【方法】探索温度、pH等因素对抑菌物质的影响,采用气相色谱-质谱(Gas Chromatography-Mass Spectrometry,GC-MS)联用技术分析植物乳杆菌代谢物的组成,进一步通过有机溶剂萃取、超滤等方法初步分离纯化发酵液中抑制双菌生物膜的成分,并采用液相色谱-质谱(Liquid Chromatography-Mass Spectrometry,LC-MS)联用技术进行鉴定。【结果】通过多元统计分析,发现植物乳杆菌发酵液的主要差异标志物为有机酸(如苯乳酸、乙酸、羟基己酸和甘油酸等),经过初步提取鉴定并进行功能验证,其中有效成分主要为有机酸和环肽类化合物。【结论】植物乳杆菌CCFM8724发酵液主要通过多种有机酸和环肽类的协同作用抑制变异链球菌和白色念珠菌生物膜,该研究为植物乳杆菌发酵液进一步的分离纯化和有效成分的生产...     

A Mathematical Model for Vegetative Growth of Bacillus Thuringiensis

A structured but unsegregated model was developed for the vegetative growth of Bacillus thuringiensis (Bt) cells. This model included cell growth, limiting‐substrate consumption, production and consumption of acetic acid, and production of poly‐β‐hydroxy butyric acid. The parameter estimation and model validation were conducted using data from carbon‐limited batch experiments. The model successfully predicted batch behavior of biomass and glucose concentrations.     

Characterization of a <Emphasis Type="Italic">Lactobacillus plantarum</Emphasis> Strain Able to Produce Tyramine and Partial Cloning of a Putative Tyrosine Decarboxylase Gene

The aim of this article was to analyze the ability of wine Lactobacillus plantarum strains to form tyramine. Preliminary identification of L. plantarum strains was performed by amplification of the recA gene. Primers pREV and PlanF, ParaF and PentF were used respectively as reverse and forward primers in the polymerase chain reaction tests as previously reported. Furthermore, the gene encoding for the tyrosine decarboxylase (TDC) was partially cloned from one strain identified as L. plantarum. The strain was further analyzed by 16S rDNA sequence and confirmed as belonging to L. plantarum species. The tyrosine decarboxylase activity was investigated and tyramine was determined by the high-performance liquid chromatography method. Moreover, a negative effect of sugars such as glucose and fructose and L-malic acid on tyrosine decarboxylase activity was observed. The results suggest that, occasionally, L. plantarum is able to produce tyramine in wine and this ability is apparently confined only to L. plantarum strains harboring the tdc gene.     

Simultaneous use of sodium nitrate and urea as nitrogen sources improves biomass composition of Arthrospira platensis cultivated in a tubular photobioreactor

Arthrospira platensis is widely cultivated in open ponds for industrial purposes. However, high‐protein A. platensis biomass produced in photobioreactors (PBRs) is recommended for pharmaceutical and cosmetic formulations. A. platensis was cultivated in a 3.5 L tubular airlift PBR using both sodium nitrate and urea as nitrogen sources. Sodium nitrate was added from the start of the cultivation using a batch process. Urea was supplied daily at exponentially increasing feeding rate using a fed‐batch process. The simultaneous optimization of the independent variables, namely, total quantity of sodium nitrate (m_T1) and total quantity of urea (m_T2), led to an optimal condition of m_T1 = 15.0 mmol/L and m_T2 = 7.5 mmol/L. Maximum biomass concentration (5183 ± 94 mg/L) corresponding to the highest biomass productivity (683 ± 13 mg/L/day) was obtained under such condition. The addition protocol of both nitrogen sources resulted in high productivities of protein (6.2 ± 0.4 mg/L/day) as well as chlorophyll‐a (372.2 ± 7.7 mg/L/day). Such innovative process could be applied in the large‐scale production of A. platensis using tubular PBR for novel applications.     

Lactobacillus plantarum CS24.2 prevents Escherichia coli adhesion to HT‐29 cells and also down‐regulates enteropathogen‐induced tumor necrosis factor‐α and interleukin‐8 expression

The aim of the present study was to evaluate the potential of Lactobacillus plantarum CS24.2 to antagonize Escherichia coli adhesion and modulate expression of the responses by HT‐29 cells of inflammatory molecules to E. coli adhesion. Experiments were performed under different adhesion conditions and findings compared with the responses of Lactobacillus rhamnosus GG. Tests of competitive adhesion, adhesion inhibition and displacement assays were performed for lactobacilli (L. rhamnosus GG and L. plantarum CS24.2) and E. coli O26:H11 to HT‐29 cells. Both the lactobacilli significantly reduced E. coli adhesion to HT‐29 cells (P < 0.05). The ability of lactobacilli to modulate tumor necrosis factor‐α and interleukin‐8 expression was analyzed in HT‐29 cells stimulated with E. coli using qRT‐PCR. L. plantarum CS24.2 significantly down regulated expression of both the genes induced by E. coli in HT‐29 cells at 6 hr as well as 24 hr, which was more significant than the corresponding findings for L. rhamnosus GG. The present findings suggest that L. plantarum CS24.2 inhibits pathogen adhesion to a similar extent as does the established probiotic strain L. rhamnosus GG. It may also attenuate tumor necrosis factor‐α and interleukin‐8 expression in HT‐29 cells stimulated with E. coli.     

不同来源植物乳杆菌基因组结构和功能差异的比较研究

[目的] 本试验研究不同来源植物乳杆菌（Lactobacillus plantarum）基因特点以及在不同环境下其基因多样性,探究2株L.plantarum A8和P9在肠道生境及植物表面适应性的异同,为优良菌株的开发提供理论基础。[方法] 本研究对从动物肠道和植物表面分离获得的L.plantarum A8和L.plantarum P9的基因组进行分析,利用第二代测序技术（NextGeneration Sequencing,NGS）,基于Illumina NovaSeq测序平台,同时利用第三代单分子测序技术,基于PacBio Sequel测序平台,对L.plantarum A8和L.plantarum P9进行测序。采用Carbohydrate-active enzymes（CAZy）、Koyto encyclopedia of genes and genomes（KEGG）和Clusters of orthologous genes（COG）数据库对基因组进行功能注释;采用CGView软件绘制菌株的基因组环形图谱。应用比较基因组学与已经公开发表的其他L.plantarum基因组进行比较分析。[结果] 由研究可知L.plantarum A8和L.plantarum P9基因组大小存在差异,通过构建系统发育树发现2株菌与其他来源的L.plantarum分在同一分支,并且L.plantarum P9与母乳来源的L.plantarum WLPL04菌株距离最近,而L.plantarum A8与L.paraplantarum DSM10667距离最近。通过基因家族分析可知,2株菌共有基因为2643个,其中包括一些抗应激蛋白如热休克蛋白、冷休克蛋白。L.plantarum A8和P9独特基因分别为321和336个,L.plantarum A8中独特基因主要参与DNA复制、ABC转运系统（ABC transfer system）、PTS系统（phosphotransferase system）、磺酸盐转运系统、氨基酸生物合成等代谢通路;L.plantarum P9的独特基因以参与碳水化合物的运输和代谢基因居多,例如rpiA基因、lacZ基因、FruA基因等。[结论] 通过比较基因组学方法解析L.plantarum的基因组信息,发现动物肠道来源的L.plantarum具有较好的氨基酸转运能力,植物表面附着的L.plantarum菌株具有较好碳水化合物利用能力,从而为益生菌的开发与利用提供理论依据。     

Phenotypic and genomic diversity of Lactobacillus plantarum strains isolated from various environmental niches

Lactobacillus plantarum is a ubiquitous microorganism that is able to colonize several ecological niches, including vegetables, meat, dairy substrates and the gastro‐intestinal tract. An extensive phenotypic and genomic diversity analysis was conducted to elucidate the molecular basis of the high flexibility and versatility of this species. First, 185 isolates from diverse environments were phenotypically characterized by evaluating their fermentation and growth characteristics. Strains clustered largely together within their particular food niche, but human fecal isolates were scattered throughout the food clusters, suggesting that they originate from the food eaten by the individuals. Based on distinct phenotypic profiles, 24 strains were selected and, together with a further 18 strains from an earlier low‐resolution study, their genomic diversity was evaluated by comparative genome hybridization against the reference genome of L. plantarum WCFS1. Over 2000 genes were identified that constitute the core genome of the L. plantarum species, including 121 unique L. plantarum‐marker genes that have not been found in other lactic acid bacteria. Over 50 genes unique for the reference strain WCFS1 were identified that were absent in the other L. plantarum strains. Strains of the L. plantarum subspecies argentoratensis were found to lack a common set of 24 genes, organized in seven gene clusters/operons, supporting their classification as a separate subspecies. The results provide a detailed view on phenotypic and genomic diversity of L. plantarum and lead to a better comprehension of niche adaptation and functionality of the organism.