Production of poly-β-hydroxybutyrate by Alcaligenes eutrophus transformants harbouring cloned phbCAB genes

Summary Three transformants of Alcaligenes eutrophus harbouring the recombinant plasmids containing phbCAB, phbAB, and phbC genes, were cultivated to investigate the effect of cloned genes on cell growth and poly--hydroxybutyrate accumulation. Both in the nutrient-rich and minimal media, the increased PHB accumulation in the transformants was observed compared to the parent strain, and this was the result of the increased enzyme activities in the transformants. Low carbon concentration and high C/N molar ratio favored higher PHB accumulations in the transformants. The transformant harbouring the phbC gene showed the highest PHB accumulation, which indicated that PHB synthase was the most critical enzyme for PHB biosynthesis in the transformant.     

Production of poly-β-hydroxybutyrate by Alcaligenes eutrophus on different carbon sources

Poly--hydroxybutyrate was produced in shake cultures by Alcaligenes eutrophus H16 on fructose, xylose, and fumaric, itaconic, lactic and propionic acids in a three-stage process. The maximum polymer concentration of 6.9 g l^–1 (69% of cell dry matter) was obtained with 20g l^–1 of fructose with a volumetric productivity of about 0.22 g l^–1 h^–1 at 24h. Up to about 3 g l^–1 (about 50% of cell dry matter) of polymer was also produced on lactic and propionic acids as the sole carbon source during the production phase. In multivatiate optimization employing an orthogonal 2³-factorial central composite experimental design with fructose as the substrate in a single-stage process, the optimal initial fructose concentration decreased from 35 g l^–1 to 24 g l^–1 when the incubation time was increased from about 35 h to 96 h. The optimal shaking speed range was 90–113 rpm. Correspondence to: S. Linko     

Effects of environmental conditions on cell growth and poly-β-hydroxybutyrate accumulation in Alcaligenes eutrophus

Influences of the control of glucose and oxygen concentrations on cell growth and poly--hydroxybutyrate (PHB) accumulation in Alcaligenes eutrophus were studied. Glucose affects both biosynthesis and glycolysis directly and the other pathways indirectly. PHB accumulation could also be stimulated under oxygen limitation conditions, but the final PHB content within the cells was less than in the case of nitrogen limitation. When the culture was shifted from the PHB accumulation state to balanced growth conditions, PHB degradation occurred in the cells. The cell growth was inhibited by high PHB content within the cells.     

Production and characterization of poly-β-hydroxybutyrate (PHB) polymer from Aulosira fertilissima

Biopolymers such as polyhydroxyalkanoates (PHAs) are a class of secondary metabolites with promising importance in the field of environmental, agricultural, and biomedical sciences. To date, high-cost commercial production of PHAs is being carried out with heterotrophic bacterial species. In this study, a photoautotrophic N₂-fixing cyanobacterium, Aulosira fertilissima, has been identified as a potential source for the production of poly-β-hydroxybutyrate (PHB). An accumulation up to 66% dry cell weight (dcw) was recorded when the cyanobacterium was cultured in acetate (0.3%) + citrate (0.3%)-supplemented medium against 6% control. Aulosira culture supplemented with 0.5% citrate under P deficiency followed by 5?days of dark incubation also depicted a PHB accumulation of 51% (dcw). PHB content of A. fertilissima reached up to 77% (dcw) under P deficiency with 0.5% acetate supplementation. Optimization of process parameters by response surface methodology resulted into polymer accumulation up to 85% (dcw) at 0.26% citrate, 0.28% acetate, and 5.58?mg?L^?1 K₂HPO₄ for an incubation period of 5?days. In the A. fertilissima cultures pre-grown in fructose (1.0%)-supplemented BG 11 medium, when subjected to the optimized condition, the PHB pool boosted up to 1.59?g?L^?1, a value ～50-fold higher than the control. A. fertilissima is the first cyanobacterium where PHB accumulation reached up to 85% (dcw) by manipulating the nutrient status of the culture medium. The polymer extracted from A. fertilissima exhibited comparable material properties with the commercial polymer. As compared with heterotrophic bacteria, carbon requirement in A. fertilissima for PHB production is lower by one order magnitude; thus, low-cost PHB production can be envisaged.     

On-line culture fluorescence measurement during the batch cultivation of poly-β-hydroxybutyrate producing Alcaligenes eutrophus

Estimation of biomass concentration by on-line fluorimetry was examined during batch cultivations of Alcaligenes eutrophus ATCC 17697, a poly-β-hydroxybutyric acid (PHB) producer. The results obtained revealed a linear correlation between total culture fluorescence and total biomass concentration. The total fluorescence level was attributed to cellular fluorescence and to the fluorescence of compounds presumably produced by the cells and secreted into the culture medium. An increase in the specific cellular fluorescence during the course of the experiments indicated a shift in metabolism that favored the production of PHB.     

Production of poly-(β-hydroxybutyrate) from saponified Vernonia galamensis oil by Alcaligenes eutrophus

Saponified vernonia oil was converted exclusively to poly(β-hydroxybutyrate) (PHB) by Alcaligenes eutrophus in a single-stage batch culture. After harvesting, centrifugation followed by lyophilization, the resulting dried cells contained up to 42.8 wt% PHB having a peak molecular mass of 381 863 Da, weight-average molecular mass of 308 390 Da, and a polydispersity of 1.1. The PHB had a melting point (T_m) range of 163–174°C with a maximum at 172°C (lit. T_m, 175°C), and heat of fusion of 18.43 cal g⁻¹. Fermentation performed under varying conditions of nitrogen limitation indicated that there was no significant effect of nitrogen concentration on the molecular mass of PHB produced from vernonia oil by A. eutrophus. Received 27 March 1998/ Accepted in revised form 17 July 1998     

Metabolite concentrations in Alcaligenes eutrophus H 16 and a mutant defective in poly-β-hydroxybutyrate synthesis

Intracellular concentrations of hexose phosphates, phosphoenolpyruvate, pyruvate, NAD(H) and NADP(H) as well as the protein and poly--hydroxybutyrate (PHB) content were measured in suspensions of autotrophically grown cells of Alcaligenes eutrophus H 16 and compared with those in a mutant unable to synthesize poly--hydroxybutyrate. The parent strain was subjected to successive changes in conditions, and new steady states were rapidly (20 min) attained. When the parent strain was provided with carbon and energy but no nitrogen source, it fixed CO₂ and accumulated large amounts of PHB. When the mutant PHB^-4 was exposed to identical conditions, no accumulation of PHB occurred, but pyruvate, malate and citrate were excreted, and a 6-fold accumulation of hexose monophosphate (over the levels in the parent) was observed: in contrast, cofactors in intermediates between fructose-1,6-phosphate and phosphoenolpyruvate reached steady state as in the parent strain. When ammonium ion was then supplied, growth started and the metabolite concentrations in the mutant returned to the levels observed in the parent strain.     

Transport of poly-β-hydroxybutyrate in human plasma

Poly-β-hydroxybutyrate (PHB) is an amphiphilic lipid that has been found to be a ubiquitous component of the cellular membranes of bacteria, plants and animals. The distribution of PHB in human plasma was investigated using chemical and immunological methods. PHB concentrations proved highly variable; in a random group of 24 blood donors, total plasma PHB ranged from 0.60 to 18.2 mg/l, with a mean of 3.5 mg/l. In plasma separated by density gradient ultracentrifugation, lipoproteins carried 20–30% of total plasma PHB; 6–14% in the very low density lipoproteins (VLDL), 8–16% in the low density lipoproteins (LDL), and < 3% in the high density lipoproteins (HDL). The majority of plasma PHB (70–80%) was found in protein fractions of density > 1.22 g/ml. Western blot analysis of the high density fractions with anti-PHB F(ab')₂ identified albumin as the major PHB-binding protein. The affinity of albumin for PHB was confirmed by in vitro studies which demonstrated transfer of ¹⁴C-PHB from chloroform into aqueous solutions of human and bovine serum albumins. PHB was less tightly bound to LDL than to other plasma components; the polymer could be isolated from LDL by extraction with chloroform, or by digestion with alkaline hypochlorite, but it could not similarly be recovered from VLDL or albumin. PHB in the LDL correlated positively with total plasma cholesterol and LDL cholesterol, and negatively with HDL cholesterol. The wide concentration range of PHB in plasma, its presence in VLDL and LDL and absence in HDL, coupled with its physical properties, suggest it may have important physiological effects.     

β-Ketothiolase from Hydrogenomonas eutropha H16 and its significance in the regulation of poly-β-hydroxybutyrate metabolism

1. beta-Ketothiolase was purified 49-fold from fructose-grown cells of Hydrogenomonas eutropha H16 with a yield of 27%; the purification procedure involved precipitation by cetyltrimethylammonium bromide, DEAE-cellulose chromatography and exclusion chromatography on Sephadex G-200; the freeze-dried enzyme is stable. The molecular weight determined by sucrose-gradient centrifugation (8.2S) and by gel filtration is 147000-150000. The optimum pH for the cleavage reaction is 8.1, that for the condensation reaction 7.8, both measured in Tris-HCl buffer. 2. The kinetics of the cleavage reaction are described. Substrate-saturation curves were measured with both acetoacetyl-CoA and CoA as the variable substrates. The concentration of the second substrate was kept constant and was varied during successive experiments. The cleavage reaction is characterized by substrate inhibition by acetoacetyl-CoA, which is partially relieved by free CoA. Hill plots indicate two acetoacetyl-CoA-binding sites. 3. The substrate(acetyl-CoA)-saturation curve for the condensation reaction is hyperbolic. The K(m) was 3.9x10(-4)m-acetyl-CoA. In the presence of CoA sigmoidal curves were obtained, with an increasing sigmoidicity from 0.03 to 0.30mm-CoA. The inhibitory action of CoA on the beta-ketothiolase condensation reaction and its possible involvement in the regulation of poly-beta-hydroxybutyrate synthesis and degradation are discussed.     

Production of poly-β-hydroxybutyrate from methanol: characterization of a new isolate of Methylobacterium extorquens

Summary Poly--hydroxybutyric acid (PHB) and similar bacterial polyesters are promising candidates for the development of environment-friendly, totally biodegradable plastics. The use of methanol, one of the cheapest noble substrates available, may help to reduce the cost of producing such bioplastics. As a first step, a culture collection of 118 putative methylotrophic microorganisms was obtained from various soil samples without any laboratory enrichment step to favour culture diversity. The most promising culture was selected based on rapidity of growth and PHB accumulation and later identified as Methylobacterium extorquens. This isolate was obtained from soml contaminated regularly with used oil products for some 40 years. Concentrations of methanol greater than 8 g/l affected growth significantly and the methanol concentration was optimal at 1.7 g/l. PHB concentrations averaged 25–30% (w/v) of dry weight under non-optimized conditions. Controlling methanol concentration, using an open-loop configuration, led to biomass levels of 9–10 g/l containing 30–33% PHB while preventing methanol accumulation. The new isolate was also able to produce the co-polymer PHB/poly--hydroxyvalerate (PHV) using the mixture methanol + valerate. The PHV-to-PHB ratio was about 0.2 at the end of the fermentation. An average molecular mass varying between 2 and 3 × 10⁵ Da was obtained for three PHB samples using two different measurement methods.Publication number NRCC No. 33672 Offprint requests to: D. Groleau     

Rapid and simple analysis of poly-β-hydroxybutyrate content by capillary isotachophoresis

Summary We present a rapid method for the direct analysis of poly--hydroxybutyrate (PHB) content in the soil bacteria Alcaligenes eutrophus. PHB from the fresh cells was converted by sulfuric acid to the crotonic acid and measured by capillary isotachophoresis after the neutralization by CaCO₃. The method can be used for rapid and routine monitoring of the fermentation processes in samples containing 0.001 to 20 mg of PHB.     

Production of poly-β-hydroxybutyrate by fed-batch culture of recombinantEscherichia coli

Summary A recombinantEscherichia coli strain harboring the PHB biosynthesis genes fromAlcaligenes eutrophus was used to produce poly--hydroxybutyrate (PHB) by pH-stat fedbatch culture. Initial glucose concentration for optimal growth was found to be 20g/L from a series of flask cultures. A final PHB concentration of 88.8 g/L could be obtained after 42 hrs of cultivation.     

Stimulation of poly-β-hydroxybutyrate oxidation in Sphaerotilus discophorus by manganese and magnesium

Summary When grown with glucose, S. discophorus synthesized large amounts of poly--hydroxybutyrate which accumulated intracellularly as sudanophilic granules. The rate of endogenous oxygen consumption by such cells was markedly increased by Mn⁺⁺ and even more by Mg⁺⁺. It has been shown that these inorganic ions stimulate the oxidation of the intracellular poly--hydroxybutyrate.Dedicated by the senior author to Prof. C. B. van Niel on the occasion of his 70th birthday with gratitude for many unforgettable years of association, instruction and stimulation.     

Synthesis and degradation of poly-β-hydroxybutyrate in a sequencing batch biofilm reactor

The aim of this work was the study of poly-β-hydroxybutyrate (PHB) formation and degradation in a sequencing batch biofilm reactor (SBBR). The SBBR was operated in cycles comprising three individual phases: mixed fill, aeration and draw. A synthetic substrate solution with acetate and ammonium was used.PHB was formed during the aeration phase immediately after acetate depletion, and was subsequently consumed for biomass growth, owing to the high oxygen concentration in the reactor. It was observed a combination of suspended and biofilm growth in the SBBR with predominance of the fixed form of biomass (506 Cmmol and 2102 Cmmol, respectively). Maximum PHB fraction of suspended biomass (0.13 Cmol/Cmol) was considerably higher than that of biofilm (0.01 Cmol/Cmol). This may possibly be explained by a combination of two factors: lower mass transfer limitation of acetate and higher fraction of heterotrophs in suspended biomass compared to the ones of biofilm.     

Poly-β-hydroxybutyrate biosynthesis and the regulation of glucose metabolism in Azotobacter beijerinckii

Azotobacter beijerinckii possesses the enzymes of both the Entner-Doudoroff and the oxidative pentose phosphate cycle pathways of glucose catabolism and both pathways are subject to feedback inhibition by products of glucose oxidation. The allosteric glucose 6-phosphate dehydrogenase utilizes both NADP(+) and NAD(+) as electron acceptors and is inhibited by ATP, ADP, NADH and NADPH. 6-Phosphogluconate dehydrogenase (NADP-specific) is unaffected by adenosine nucleotides but is strongly inhibited by NADH and NADPH. The formation of pyruvate and glyceraldehyde 3-phosphate from 6-phosphogluconate by the action of the Entner-Doudoroff enzymes is inhibited by ATP, citrate, isocitrate and cis-aconitate. Glyceraldehyde 3-phosphate dehydrogenase is unaffected by adenosine and nicotinamide nucleotides but the enzyme is non-specific with respect to NADP and NAD. Citrate synthase is strongly inhibited by NADH and the inhibition is reversed by the addition of AMP. Isocitrate dehydrogenase, a highly active NADP-specific enzyme, is inhibited by NADPH, NADH, ATP and by high concentrations of NADP(+). These findings are discussed in relation to the massive synthesis of poly-beta-hydroxybutyrate that occurs under certain nutritional conditions. We propose that synthesis of this reserve material, to the extent of 70% of the dry weight of the organism, serves as an electron and carbon ;sink' when conditions prevail that would otherwise inhibit nitrogen fixation and growth.     

Effect of phosphate supply and aeration on poly-β-hydroxybutyrate production in Azotobacter chroococcum

The effects of phosphate supply and aeration on cell growth and PHB accumulation were investigated in Azotobacter chroococcum 23 with the aim of increasing PHB production. Phosphate limitation favoured PHB formation in Azotobacter chroococcum 23, but inhibited growth. Azotobacter chroococcum 23 cells demonstrated intensive uptake of orthophosphate during exponential growth. At the highest phosphate concentration (1·5 g/litre) and low aeration the amount of intracellular orthophosphate/g residual biomass was highest. Under conditions of fed-batch fermentation the possibility of controlling the PHB production process by the phosphate level in the cultivation medium was demonstrated. A 36 h fed-batch fermentation resulted in a biomass yield of 110 g/litre with a PHB cellular concentration of 75% dry weight, PHB content 82·5 g/litre, PHB yield Y_P/S = 0·24 g/g and process productivity 2·29 g/litre·h.     

Quantitation of poly-β-hydroxybutyrate by fluorescence of bacteria and granules stained with Nile blue A

Summary Fluorescence from poly--hydroxybutyrate (PHB) inclusions inside Azotobacter vinelandii UWD cells stained with Nile blue A was shown to be proportional to PHB concentration. The intensity of the fluorescence was greatest in native, fluid inclusions and was the least in extracted, crystallized granules. However, isolated air-dried PHB granules also were proportionally stained with Nile blue A. The results show that Nile blue A can be used in the quantitative determination of PHB in a variety of cells.     

Functional role of granule-associated genes, phaP and phaR, in poly-β-hydroxybutyrate biosynthesis in recombinant E. coli harboring phbCAB operon

The expression characteristic of two granule-associated genes, phaP and phaR, in a recombinant E. coli harboring the phbCAB operon was investigated. Polybetamydroxybutyrate (PHB) accumulation increased up from 16% to 57% (w/w) after transformation of the granule-associated genes due to the stabilization of PHB granules rather than by a direct effect on PHB biosynthetic enzymes. The morphology of PHB granules also varied depending on the transformed phaP and phaR genes.