A chemically-defined medium for production of compactin by Penicillium citrinum

A mutant strain of Penicillium citrinum grown in a chemically-defined production medium, yielded 145 mg compactin l^–1. The medium also facilitated spectrophotometric analysis of compactin. Addition of KH₂PO₄in the production medium did not increase the compactin production, while addition of a surfactant, Tween 80, increased compactin to 175 mg l^–1. Inoculation with 10⁷ spores ml^–1 and initial pH of 6.5–7 were the most suitable for compactin production.     

Optimization of glycerol feeding for clavulanic acid production by Streptomyces clavuligerus with glycerol feeding

Glycerol at 10–20 g l^–1 increased clavulanic acid production by Streptomyces clavuligerus in shake-flask culture. The biosynthesis of clavulanic acid continued for longer by feeding glycerol and production increased to 250 mg l^–1 compared with 115 mg l^–1 without feeding. In fermenter batch culture, degradation of clavulanic acid began after 72 h. With glycerol feeding in fed-batch culture, clavulanic acid production was not only increased further to about 280 mg l^–1 but also remained stable up to 130 h.     

Intermittent maltose feeding enhances paclitaxel production in suspension culture of Taxus chinensis cells

High paclitaxel production (26 mg l^–1) was achieved through the intermittent feeding of 3, 1, and 2% (w/v) sucrose at days 0, 7, and 21, respectively, to a suspension culture of Taxus chinensis cells. Intermittent feedings of 1 and 2% (w/v) maltose at days 7 and 21, respectively, to the culture increased the paclitaxel production up to 67 mg l^–1.     

Improved Taxol production in suspension cultures of Taxus chinensis var. mairei by in situ extraction combined with precursor feeding and additional carbon source introduction in an airlift loop reactor

Taxus chinensis var. mairei was grown in two-liquid-phase culture in a 2.5 l airlift external loop reactor for production of Taxol. A mixture of oleic acid and dibutyl phthalate (1:1, v/v) in a volume ratio of 8:92 to the culture medium gave higher production of Taxol (up to 12 mg l^–1) with an aeration rate of 1 vvm. By combination of the in situ extraction, precursor feeding and additional sugar introduction, Taxol production (16.7 mg l^–1) was 5 times higher than that in the case without any additives (3.4 mg l^–1) and 1.4 times of that in the case with only thein situ extraction (12 mg l^–1). Taxol was extracted from the organic solvents with water and methanol (1:1:1.4, by vol.) and lyophilized giving a total yield of ca. 90%.     

Production potential of eicosapentaenoic acid by the diatom Nitzschia laevis

To investigate the production potential of eicosapentaenoic acid (EPA) by the diatom Nitzschia laevis, the growth characteristics and fatty acid composition of the cells were studied under photoautotrophic, mixotrophic and heterotrophic conditions of growth. The specific growth rate and maximum biomass concentration were respectively 0.466 d^–1 and 2.27 g l^–1 for mixotrophic culture, 0.344 d^–1 and 2.04 g l^–1 for heterotrophic culture, and 0.167 d^–1 and 0.5 g l^–1 for photoautotrophic culture, respectively. As for EPA production, the yield and productivity were respectively 52.32 mg l^–1 and 10.46 mg l^–1 d for mixotrophic culture, 35.08 mg l^–1 and 6.37 mg l^–1 d for heterotrophic culture, and 6.78 mg l^–1 and 3.39 mg l^–1 d for photoautotrophic culture, respectively. Results suggest that mixotrophic culture is the most suitable growth mode for the production of EPA by the diatom Nitzschia laevis. The results are useful for the development of a cost-effective fermentation process for EPA production by Nitzschia laevis.     

Production of poly(3-hydroxybutyrate) from whey by cell recycle fed-batch culture of recombinant Escherichia coli

A new fermentation strategy using cell recycle membrane system was developed for the efficient production of poly(3-hydroxybutyrate) (PHB) from whey by recombinant Escherichia coli strain CGSC 4401 harboring the Alcaligenes latus polyhydroxyalkanoate (PHA) biosynthesis genes. By cell recycle, fed-batch cultivation employing an external membrane module, the working volume of fermentation could be constantly maintained at 2.3 l. The final cell concentration, PHB concentration and PHB content of 194 g l^–1, 168 g l^–1 and 87%, respectively, were obtained in 36.5 h by the pH-stat cell recycle fed-batch culture using whey solution concentrated to contain 280 g lactose l^–1 as a feeding solution, resulting in a high productivity of 4.6 g PHB l^–1 h^–1.     

Modelling the production of nisin by Lactococcus lactis in fed-batch culture

Nisin production in batch culture and fed-batch cultures (sucrose feeding rates were 6, 7, 8, and 10 g l^–1 h^–1, respectively) by Lactococcus lactis subsp. lactis ATCC 11454 was investigated. Nisin production showed primary metabolite kinetics, and could be improved apparently by altering the feeding strategy. The nisin titer reached its maximum, 4,185 IU ml^–1, by constant addition of sucrose at a feeding rate of 7 g l^–1 h^–1; an increase in 58% over that of the batch culture (2,658 IU ml^–1). Nisin biosynthesis was affected strongly by the residual sucrose concentration during the feeding. Finally, a mathematical model was developed to simulate the cell growth, sucrose consumption, lactic acid production and nisin production. The model was able to describe the fermentation process in all cases.     

L-Sorbose production in a continuous fermenter with and without cell recycle

The kinetics of continuous l-sorbose fermentation using Acetobacter suboxydans with and without cell recycle (100%) were investigated at dilution rates (D) of 0.05, 0.10, 0.15 and 0.3 h^–1. The biomass and sorbose concentrations for continuous fermentation without recycle increased as the dilution rate was increased from 0.05 to 0.10 h^–1. A maximum biomass concentration of 8.44 g l^–1 and sorbose concentration of 176.90 g l^–1 were obtained at D=0.10 h^–1. The specific rate of sorbose production and volumetric sorbose productivity at this dilution rate were 2.09 g g^–1 h^–1 and 17.69 g l^–1 h^–1. However, on further increasing the dilution rate to 0.3 h^–1, both biomass and sorbose concentrations decreased to 2.93 and 73.20 g l^–1 respectively, mainly due to washout of the reactor contents. However, the specific rate of sorbose formation and volumetric sorbose productivity at this dilution rate increased to 7.49 g g^–1 h^–1 and 21.96 g l^–1 h^–1 respectively. Continuous fermentation with 100% cell recycle served to further enhance the concentration of biomass and sorbose to 28.27 and 184.32 g l^–1 respectively (in the reactor at a dilution rate of 0.05 h^–1). Even though, there was a decline in the biomass and sorbose concentrations to 6.8 and 83.40 g l^–1 at a dilution rate of 0.3 h^–1, the specific rates of sorbose formation and volumetric sorbose productivity increased to 3.67 g g^–1h^–1 and 25.02 g l^–1 h^–1.     

Fed-batch fermentation of Lactobacillus lactis for hyper-production of l-lactic acid

A fed-batch fermentation of Lactobacillus lactis to produce l-lactic acid was developed in which the residual glucose concentration in the culture was used to control a continuous feeding strategy. Up to 210 g l-lactic acid l^–1 (97% yield) was obtained. The maximal dry cell was 2.7 g l^–1 and the average l-lactic acid productivity was 2.2 g l^–1 h^–1.     

Glycerol production by Candida krusei employing NaCl as an osmoregulator in batch and continuous fermentations

Addition of 40 g NaCl l^–1 to a chemically defined medium containing 140 g glucose l^–1 in shake-flask culture improved glycerol production by Candida krusei from 16.5 g l^–1 to 47.7 g l^–1. With 40 g NaCl l^–1 at a dilution rate of 0.065 h^–1, glycerol concentration, glycerol yield (based on glucose consumed), and productivity in a four-stage cascade bioreactor were higher by 240%, 27% and 28%, respectively, than in a single-stage continuous culture system.     

Enzyme production in continuous cultivation by the thermophilic fungus, Thermomyces lanuginosus

The production of extracellular enzymes by the thermophilic fungus Thermomyces lanuginosus was studied in chemostat cultures at a dilution rate of 0.08 h^–1 in relation to variation in the ammonium concentration in the feed medium. Under steady state conditions, three growth regimes were recognised and the production of several extracellular enzymes from T. lanuginosus was recorded under different nutrient limitations ranging from nitrogen limitation to carbon/energy limitation. The range and the production of carbohydrate hydrolysing enzymes and lipase increased from Regime I (NH₄Cl 600 mg l^–1) to Regime III (NH₄CI 1200 mg l^–1), whereas production of protease was highest in Regime II (600 mg l^–1 < NH₄Cl <1200 mg l^–1).     

Production of medium chain length polyhydroxyalkanoates by fed-batch culture of Pseudomonas oleovorans

Pseudomonas oleovorans was cultivated to produce medium chain length polyhydroxyalkanoates (MCL-PHAs) from octanoic acid and ammonium nitrate as carbon and nitrogen source, respectively, by a pH-stat fed-batch culture technique. The octanoate in the culture broth was maintained below 4 g l^–1 by feeding the mixture of octanoic acid and ammonium nitrate when the culture pH rose above 7.1. The final cell concentrations of 63, 55 and 9.5 g l^–1, PHA contents of 62, 75 and 67% of dry cell wt, and productivities of 1, 0.63 and 0.16 g l^–1 h^–1 were obtained when the C/N ratios in the feed were 10, 20 and 100 g octanoic acid g^–1 ammonium nitrate, respectively.     

Enhancement of paclitaxel production by abscisic acid in cell suspension cultures of Taxus chinensis

Addition of 5 mg abscisic acid l^–1 after 12 days' growth of Taxus chinensis suspension culture gave the greatest paclitaxel accumulation at 11 mg l^–1, which was almost 5 times that of the control culture. The highest paclitaxel production, 18 mg l^–1, was obtained using 5 mg abscisic acid l^–1 and 20 mg methyl jasmonate l^–1.     

Fungal biotransformation of p-coumaric acid into caffeic acid by Pycnoporus cinnabarinus: an alternative for producing a strong natural antioxidant

Fungal biotransformation of p-coumaric acid into caffeic acid, potentially a strong antioxidant, was evidenced in Pycnoporus cinnabarinus cultures grown with high feeding of p-coumaric acid. Preliminary experiments showed no toxicity of both p-coumaric and caffeic acids at concentrations ranging from 0 to 500 mg l^–1. Feeding 450 mg p-coumaric acid l^–1 into P. cinnabarinus cultures grown on 20 g l^–1 glucose medium resulted in the production of 257 mg caffeic acid l^–1with a molar yield of 21%.     

Two-phase extraction culture of Botryococcus braunii producing long-chain unsaturated hydrocarbons

Hydrocarbon recovery was 32% and the total production of hydrocarbon in a two-phase extraction culture of Botryococcus braunii was 675 mg l^–1, which was 19% higher than that of single-phase culture. Addition of 60 ml dihexyl ether at mid-growth phase gave the highest yield. Specific growth rate and recovery of hydrocarbon in this case were 0.022 h^–1 and 26%, respectively.     

Production of a recombinant, immunogenic protein, P64k, of Neisseria meningitidis in Escherichia coli in fed-batch fermenters

P64k is a Neisseria meningitidis high molecular weight protein present in meningococcal vaccine preparations. The lpdA gene, codifying for this protein, was cloned in Escherichia coli and the P64k protein was expressed in Escherichia coli K12 W3110 under the control of the tryptophan promoter. The recombinant bacteria were grown in batch or fed-batch cultures. P64k was expressed as an intracellular soluble form at about 40% of the total cellular protein. A final productivity of 215 mg l^–1 h^–1 and 11 g cell dry wt l^–1 were obtained when the fed-batch culture conditions were optimised, compared to 30% of total protein, and a productivity of 76 mg l^–1 h^–1 and 5.1 g cell dry wt l^–1 in batch cultivation.     

Mixed-acid fermentation and polysaccharide production by Lactobacillus helveticus in milk cultures

Lactobacillus helveticus grown in milk with pH control at 6.2 had a slower growth rate (=0.27 h^–1) and produced less exopolysaccharide (49 mg l^–1) but increased lactic acid production (425 mM) compared to cultures without pH control (=0.5 h^–1, 380 mg exopolysaccharide l^–1, and 210 mM lactate), respectively. Both cultures displayed a mixed-acid fermentation with formation of acetate, which is linked not only to citrate metabolism, but also to alternative pathways from pyruvate.     

Production of xylitol in cell recycle fermentations of Candida tropicalis

Xylitol was produced a in two-substrate, batch fermentation with cell recycling of Candida tropicalis ATCC 13803. A series of cell-recycle experiments showed that the feeding of xylose, glucose and yeast extract in the xylitol production phase was most effective in enhancing xylitol productivity. The optimized cell recycle fermentation resulted in 0.82 g xylitol/g xylose yield, 4.94 g xylitol l^–1 h^–1 productivity, and final xylitol concentration of 189 g l^–1. These results were 1.3 times higher in volumetric xylitol productivity and 2.2 times higher in final product concentration compared with the corresponding values of the optimized two-substrate batch culture.     

Establishment of Orthosiphon stamineus Cell Suspension Culture for Cell Growth

Callus of Orthosiphon stamineus could be induced successfully from petiole, leaf and stem tissues but not roots when cultured on MS medium containing different concentration of NAA (0–4.0 mg l^–1) and 2,4-D (0–2.0 mg l^–1). Highest fresh weight callus production was obtained from leaf explants and those with best friability were obtained on MS medium plus 1.0 mg l^–1 2,4-D plus 1.0 mg l^–1 NAA. Cell suspension cultures were established from these cultures. The appropriate cell inoculum size for the best cell growth was 0.75 g of cells in 20 ml culture medium. Cell suspension culture using MS medium supplemented with 1.0 mg l^–1 2,4-D promoted the best cell growth with maximum biomass of 8.609 g fresh weight and 0.309 g dry weight 24 days after inoculation. Cells that grew in MS medium supplemented with 1.0 mg l^–1 2,4-D reached the stationary growth phase in 15 days as compared to the cells that grew in MS medium supplemented with 1.0 mg l^–1 2,4-D + 1.0 mg l^–1 NAA reached the stationary phase in 24 days. MS medium supplemented with 1.0 mg l^–1 2,4-D was considered as the maintenance medium for maintaining the optimum cell growth of O. stamineus in the cell suspension cultures with 2-week interval subculture.     

The Effects of Food Concentration and Quality on the Feeding Rates of Three Size Classes of the Greenshell<Superscript>TM</Superscript> Mussel, <Emphasis Type="Italic">Perna canaliculus</Emphasis>

In order to calibrate carrying capacity models, investigations were conducted into the effects of food concentration and food quality on the feeding rates of small (25–50 mm), medium (60–85 mm) and large (90–115 mm) Greenshell mussels (Perna canaliculus). Experimental diets varying from 3.3 to 6.0 μg l⁻¹ chlorophyll a concentration and 12–25% organic content were fed to mussels housed in individual flow through chambers. Not surprisingly, this study found that the main factor affecting feeding rates is mussel size. Small mussels were observed to maintain a constant filtration rate of approximately 20 mg h⁻¹ irrespective of food concentration or quality, whereas mussels of greater than 60 mm length had more variable filtration rates between 30 and 80 mg h⁻¹. The filtration rates of these large mussels were also observed to increase positively with organic content, and showed no sign of levelling out, even at the highest organic content tested (25%). Highest rejection rates (50–70 mg h⁻¹) were observed when the organic content of the available seston was low, suggesting that P. canaliculus are able to selectively reject organic material, thereby organically enriching their diet. It appears that the organic content of the seston is the primary determinant of the net efficiency with which food is selected from the available seston by the mussel. The present study shows that P. canaliculus of all sizes are capable of adapting their feeding behaviour to compensate for changes in the food supply, which may occur over relatively short time periods, in the culture environment.