Production of polyols and ethanol by the osmophilic yeastZygosaccharomyces rouxii

Summary The yeastZygosaccharomyces rouxii ATCC 12572 was selected for its ability to produce appreciable levels of ethanol and of various polyols from concentrated glucose media (20 %, w/v).Z. rouxii was shown to yield large quantities of glycerol and of the mixture arabitol + mannitol. Good agitation combined with appropriate aeration (1 vvm) allowedZ. rouxii to utilize glucose readily leading to high polyol production. Depending on the fermentation conditions used,Z. rouxii ATCC 12572 will give either ethanol or various polyols as main fermentation product(s).     

Stability of the Plasma Membrane in Saccharomyces rouxii and Its Relationship to Glucose Tolerance

The stability of spheroplasts from the osmotrophic yeast Saccharomyces rouxii was studied in buffered solutions of mannitol and glucose. The plasma membranes from cells grown in high glucose concentrations were more stable to osmotic lysis than were membranes from cells grown in lower glucose concentrations. Mannitol was a better osmotic stabilizer than glucose, except when the cells were grown in a high glucose concentration. Spheroplasts from a glucose tolerant-deficient mutant were much less stable than the corresponding spheroplasts from the parent strain, especially when suspended in glucose solutions. These results suggest an involvement of the plasma membrane in the glucose-tolerant mechanism of S. rouxii.     

鲁氏接合酵母对酱油中氨基甲酸乙酯前体物的代谢

【目的】研究鲁氏接合酵母氮源代谢特性,确定鲁氏接合酵母氮源代谢与酱油中氨基甲酸乙酯前体物瓜氨酸和尿素积累的关系。【方法】通过单一氮源培养、偏好型氮源培养和盐胁迫培养,检测不同条件下鲁氏接合酵母对精氨酸、瓜氨酸和尿素的代谢能力。【结果】通过对鲁氏接合酵母氨基酸利用能力的分析,确定了甘氨酸、丙氨酸和天冬酰胺3种氨基酸为鲁氏接合酵母的偏好型氮源。在偏好型氮源存在时,鲁氏接合酵母对尿素和瓜氨酸的利用并不受到抑制,丙氨酸和甘氨酸还能够促进对二者的利用。鲁氏接合酵母在单一氮源培养条件下不会降解精氨酸而积累尿素和瓜氨酸,反而可以大量利用氨基甲酸乙酯的前体物尿素和瓜氨酸。但在盐胁迫下,鲁氏接合酵母利用尿素和瓜氨酸受到阻遏,从而造成酱油中氨基甲酸乙酯前体物不能被充分利用而积累。【结论】盐胁迫阻遏了鲁氏接合酵母对瓜氨酸和尿素的利用,从而造成酱油发酵过程中耐盐细菌所产生的氨基甲酸乙酯前体物的积累。     

Orientation and integrity of plasma membrane vesicles obtained from carrot protoplasts

Two fractions enriched in plasma membrane derived from suspension-cultured carrot (Daucus carota L.) cells were examined to determine if they differed from each other either in physical nature or in orientation. Parameters studied included the protein composition of purified membranes derived from trypsinized and nontrypsinized protoplasts as well as from trypsinized purified plasma membranes, the effect of inhibitors and membrane perturbants on ATPase activity, the binding of [acetyl-¹⁴C]concanavalin A to purified membrane fractions, and the competitive removal of [acetyl-¹⁴C]concanavalin A from purified membranes derived from [acetyl-¹⁴C]concanavalin A-labeled protoplasts. One fraction (at density of 1.102 grams per cubic centimeter on Renografin gradients) appears to be a mixed population of `tightly' sealed vesicles with the majority being rightside-out vesicles of plasma membrane, and the other fraction (density 1.128 grams per cubic centimeter) apparently is a population of predominantly `leaky' vesicles and/or nonvesicular fragments of plasma membrane, a large portion of which appear to be `leaky' inside-out vesicles. In addition, it is shown that plasma membrane-enriched fractions can be distinguished from cellular endomembranes on the basis of protein and glycoprotein composition.     

Mannosyl transferases inSaccharomyces cerevisiae: Evidence for the occurrence of ectomannosyltransferase activity

The subcellular distribution of mannosyltransferases inSaccharomyces cerevisiae was studied following the separation of the plasma membrane from other intracellular membranous systems. Most of the activity was linked to internal membranes, and the rest was located at the level of the plasma membrane. Yeast plasma membranes coated on their external face with concanavalin A when incubated with GDP-[U-¹⁴C]mannose incorporated 20% less [U-¹⁴C]mannose in glycoproteins and 110% more in glycolipids than plasma membranes alone. This suggested that part of the total mannosyltransferase activity of the plasma membrane is located on its outer surface. A significant incorporation of radioactive mannose into trichloroacetic-acid-precipitable material was detected in incubations of protoplasts with GDP-[U-¹⁴C]mannose when incorporation of free mannose did not occur. Characterization of a product synthesized by the ectotransferase(s) was achieved after treatment of the radioactive plasma membranes by Triton X-100, which preserved the concanavalin A-mannoprotein complexes and removed a large amount of other plasma membrane components. A radioactive glycoprotein band with an apparent molecular weight of 94, 000 was identified as a product of the ectomannosyltransferase(s).     

CHARACTERIZATION AND TOPOGRAPHY OF THE GLYCOPROTEINS OF ADRENAL CHROMAFFIN GRANULES

The glycoproteins of the membranes of bovine chromaffin granules were characterized by two polyacrylamide gel electrophoresis systems. Five components (I-V) were demonstrated with apparent molecular weights ranging in the unreduced form from 45,000 to 150,000. Glycoprotein I was identified as the enzyme dopamine β-hydroxylase. Four of these glycoproteins (with the exception of component IV) were apparently also present in the membranes of pig and horse chromaffin granules. The soluble proteins of chromaffin granules contained at least three glycoproteins. Only glycoprotein I (dopamine β-hydroxylase) was present both in the soluble content and in the membranes of chromaffin granules. Affinity chromatography with lectins demonstrated that from the soluble proteins only dopamine β-hydroxylase was adsorbed by concanavalin A, whereas none of these proteins reacted with wheat germ lectin and Ricinus communis agglutinin. Three membrane proteins including dopamine β-hydroxylase and glycoprotein II as major components were adsorbed by concanavalin A, whereas wheat germ lectin bound only component II and a small amount of component III. By electron microscopy it was demonstrated that concanavalin A did not bind to intact chromaffin granules whereas ruthenium red and cationized ferritin did. Isotope labelling after galactose oxidase treatment revealed that at least the carbohydrate portion of the major glycoproteins is present on the inner side of the granule membranes facing the content.     

Separation of right-side-out-oriented subfractions from purified thymocyte plasma membranes by affinity chromatography on concanavalin A-sepharose

A method is described for the subfractionation of plasma membranes from thymus lymphocytes by means of affinity chromatography on concanavalin A-Sepharose. Thymus lymphocytes were disrupted by nitrogen cavitation, microsomal membranes isolated by differential centrifugation, and plasma membranes purified from microsomes by sucrose gradient ultracentrifugation. Plasma membranes were highly purified as indicated by marker enzymes and chemical analysis. To obtain membrane preparations suited for lectin-dependent affinity chromatography, sucrose was removed slowly by gradient dialysis. Plasma membranes were then equilibrated for 20 min at 4°C with concanavalin A-Sepharose, which allowed the separation of membranes into a fraction eluting freely (MF1) and a second fraction binding to the affinity absorbent (MF2), with a total recovery of about 90%. Increasing the temperature or binding time did not alter the fractionation of the plasma membrane into the two subfractions. Fractionation required the binding of matrix-bound concanavalin A to plasma membrane binding sites. Both plasma membrane subfractions proved to have preserved their original orientation (right-side out). The method described is suited to isolate different domains of the lymphocyte plasma membrane.     

Glycans of synaptosomal plasma membrane glycoproteins from adult rat forebrain: Characterization after fractionation by concanavalin A-Sepharose affinity chromatography

Glycopeptides obtained by exhaustive proteolytic digestion of synaptosomal plasma membranes from adult rat forebraini were separated by affinity chromatography on concanavalin A-Sepharoe. Concanavalin A-binding glycopeptides are essentially made up of mannose and N-acetylglucosamine in a molar ration of 3.45:1, whereas glycopeptides not bound to concanavalin A have a complex monosaccharide composition. By gel filtration on Bio-Gel P-30, concanavalin A-binding glycopeptides appear as low-molecular-weight glycopeptides (migrating like ovalbumin glycopeptides), whereas glycopeptides not bound to concanavalin A behave as high-molecular-weight glycopeptides (migrating like fetuin glycopeptides). Comparison of concanavalin A-binding glycopeptides from rat brain synaptosomal plasma membranes with concanavalin A-binding glycoproteins isolated from the same membrane fraction shows clear differences in monosccharide composition. We demonstrate here that this discrepancy is due to the presence on most concanavalin A-binding glycoprotein subunits of at least two different types of glycan: in addition to the concanavalin A-binding glycans, these glycoprotein subunits carry other glycans which do not interact with concanavalin A. Biological implications of the presence of two (or more) types of glycan on the same polypeptide are discussed.     

Glycoconjugate pattern of membranes in the acinar cell of the rat pancreas

Summary Lectin-binding studies were performed at the ultrastructural level to characterize glycoconjugate patterns on membrane systems in pancreatic acinar cells of the rat. Five lectins reacting with different sugar moieties were applied to ultrathin frozen sections: concanavalin A (ConA): glucose, mannose; wheat-germ agglutinin (WGA): N-acetylglucosamine, sialic acid; Ricinus communis agglutinin I (RCA I): galactose; Ulex europaeus agglutinin I (UEA I): l-fucose; soybean agglutinin (SBA): N-acetylgalactosamine). Binding sites of lectins were visualized either by direct conjugation to colloidal gold or by the use of a three-step procedure involving additional immune reactions. The rough endoplasmic reticulum and the nuclear envelope of acinar cells was selectively labelled for ConA. The membranes of the Golgi apparatus bound all lectins applied with an increasing intensity proceeding from the cis-to the trans-Golgi area for SBA, UEA I and WGA. In contrast RCA I selectively labelled the trans-Golgi cisternae. The membranes of condensing vacuoles and zymogen granules were labelled for all lectins used although the density of the label differed between the lectins. In contrast the content of zymogen granules failed to bind SBA and WGA. Lysosomal bodies (membranes and content) revealed binding sites for all lectins used. The plasma membranes were heavily labelled by all lectins except for SBA which showed only a weak binding to the lateral and the apical plasma membrane. These results are in accordance to current biochemical knowledge of the successive steps in the glycosylation of membrane proteins. It could be demonstrated, that the cryo-section technique is suitable for the fine structural localisation of surface glycoconjugates of plasma membranes and internal membranes in pancreatic acinar cells using plant lectins.     

Evaluation of inoculum performance for enhancing gamma-linolenic acid production from Mucor rouxii

Aims: To facilitate a cost‐effective preparation of spore inoculum with good capacity for gamma‐linolenic acid (GLA) production from Mucor rouxii. Methods and Results: Sporangiospore production, mycelial growth ability and fatty acid composition of M. rouxii were determined. Compared with fungal cultivation on solid semi‐synthetic media, high spore production was achieved from M. rouxii grown on rice grains, particularly polished rice (30·7 g kg^?1 initial substrate). Variations in the fatty acid profiles were found in the spores grown on different types of solid media, whereas the spores obtained at different ages from cultivated polished rice showed a similar fatty acid profile. Using the inocula from different spore‐forming media and culture ages, and low temperature storage, not much change in the vegetative growth of submerged cultures or fatty acid composition of mycelia was observed. Conclusion: The spores generated on polished rice exhibited a high performance for GLA production. Age of spore and timing of spore storage at low temperature did not affect on fatty acid profile of the mycelial cultures. Significance and Impact of the Study: The simple, low cost method of inoculum preparation can be applied for large‐scale production of GLA‐rich oils, which reduce a time constraint and variation in fatty acid composition.     

Isolation of plasma membrane fractions from green wheat leaves by free-flow electrophoresis or two-phase partition alone or in combination

Plasma membrane vesicles were isolated from shoots of light-grown wheat seedlings by preparative free-flow electrophoresis, aqueous polymer two-phase partition or both. Plasma membrane vesicles were identified from staining of thin sections prepared for electron microscopy with phosphotungstic acid at low pH. The orientation of the plasma membrane vesicles was determined from latency and trypsin sensitivity of K⁺ Mg²⁺ATPase and of glucan synthase II, and concanavalin A-peroxidase binding and membrane asymmetry visualized by electron microscopy. The K⁺Mg²⁺ATPase and of glucan synthase II activities of plasma membrane fractions isolated by two-phase partition were latent and trypsin resistant. The vesicles bound concanavalin A-peroxidase strongly and exhibited a cytoplasmic side-in morphology. These fractions of cytoplasmic side-in vesicles were less than 10% contaminated by cytoplasmic side-out vesicles. By free-flow electrophoresis, two populations of vesicles which stained with phosphotungstic acid at low pH, designated D and E, were obtained. The vesicle population with the lower electrophoretic mobility, fraction E, contained plasma membrane vesicles with properties similar to those of the plasma membrane vesicles obtained after two-phase partition. The phosphotungstic-reactive vesicles with greater electrophoretic mobility, fraction D, were concanavalin A unreactive with the cytoplasmic membrane leaflet outwards. Less than 50% of the K⁺Mg²⁺-ATPase activity of this fraction was latent and trypsin sensitive. The vesicles of fraction D appeared to be preferentially cytoplasmic side-out. The electrophoretic mobilities of cytoplasmic side-out (non-latent glucan synthase II activity) and cytoplasmic side-in (latent glncan synthase II activity) plasma membrane vesicles isolated from a frozen and thawed wheat plasma membrane fraction, corresponded with the mobilities of fraction D and E, respectively, again showing that the plasma membrane vesicles with the lesser electrophoretic mobility were cytoplasmic side-in. The cytoplasmic side-in and cytoplasmic side-out vesicles therefore showed opposite eletrophoretic mobilities compared with a previous free-flow electrophoretic separation of soybean plasma membranes. The majorities of the plasma membrane vesicles of both fractions D and E entered the upper phase upon two-phase partition with the phase composition used for purification of wheat plasma membranes. Thus, neither electrophoretic mobility nor phase partitioning characteristics can be used as the only criteria for assignment of vesicle orientation.     

Human mononuclear leukocyte transglutaminase activity is enhanced by streptococcal erythrogenic toxin and a staphylococcal mitogenic factor associated with toxic shock syndrome

Transglutaminase activity in human peripheral lymphocytes is enhanced after incubation of the cells with concanavalin A. Streptococcal proliferative factor toxin (erythrogenic toxin) from Streptococcus pyogenes and Toxic shock syndrome toxin from Staphylococcus aureus were purified and tested for their ability to enhance transglutaminase activity. Mononuclear leukocyte transglutaminase activity was enhanced 3–5-fold 30 min after incubation with either toxin. Enhancement occurred only when toxin was incubated with intact cells; addition of toxin to cell lysates was without effect. Transglutaminase was not measurable extracellularly. Histamine and dansyl cadaverine, competitive substrates for transglutaminase, inhibited [³H]putrescine incoporation into casein and [³H]thymidine incorporation into DNA. Incubation of lymphocytes with cycloheximide and either toxin or concanavalin A did not inhibit enzyme activity. These bacterial toxins, like phytomitogens, may perturb the cellular membrane and mediate their effect by transglutaminase-mediated cross-linking of membrane proteins.     

Estimation of Parameters in Plasma Albumin Turnover by a Modified Double Isotope Method

Zygosaccharomyces rouxii contains at least two copies of the glyceraldehyde-3-phosphate dehydrogenase gene (GAP-DH). We cloned one of them, which is situated on a 9.5 kb Hindlll fragment, after detecting a sequence which is hybridizable with the GAP-DH gene of Saccharomyces cerevisiae. The amino acid sequence of the GAP-DH gene of Z. roxii deduced from its nucleotide sequence was compared with that of the GAP-DH genes of S. cerevisiae. The Z. rouxii enzyme is longer than the S. cerevisiae enzyme by one amino acid. 65, 66 or 71 amino acid changes were detected, depending on which GAP-DH gene of S. cerevisiae was compared with that of the Z. rouxii enzyme. The codon usage in the coding region of the GAP-DH gene of Z. rouxii is biased, as found in the case of the S.cerevisiae enzyme.     

1,3‐propanediol production from glucose by mixed‐culture fermentation of Zygosacharomyces rouxii and Klebsiella pneumonia

1,3‐propanediol is an important chemical widely used in polymer production. In this study, two strains, Zygosacharomyces rouxii JL2011 and Klebsiella pneumoniae S6, were used as a mixed culture for 1,3‐propanediol production directly from glucose. Two important parameters including inoculation time of K. pneumoniae S6 at stage of mixed culture and initial cell ratio of Z. rouxii JL2011 to K. pneumoniae S6 in mixed fermentation were optimized in culture flasks. In those experiments, the best results were obtained with a yield of 6.8 g/L 1,3‐propanediol from glucose when K. pneumoniae S6 was inoculated after 48 h in the culture of Z. rouxii JL2011 by mixed culture of Z. rouxii JL2011 and K. pneumoniae S6 with initial cell ratio of 1:200. In a 7‐L bioreactor, the maximum 1,3‐propanediol production could reach up to 15.2 g/L. Thus, this study presents an effective process for 1,3‐propanediol microbial production from glucose by using mixed culture of Z. rouxii JL2011 and K. pneumoniae S6. This work does not only demonstrate a new way to produce 1,3‐propanediol from a low‐cost feedstock, but may also make a valuable contribution to the development of a cost‐effective fermentation based on renewable resources.     

Distribution of ferritin-conjugated lectins on sialidase-treated membranes of human erythrocytes

The labeling of sialidase-treated, human erythrocyte membranes with ferritin-conjugates of four plant lectinss, concanavalin A, Ricinus communis hemagglutinin, Bauhinia purpurea hemagglutinin and Arachis hypogoea hemagglutinin, is reported. Among these ferritin-conjugated lectins, ferritin-conjugated concanavalin A and ferritin-conjugated R. communis hemagglutinin were found in clusters on the sialidase-treated membranes, whereas ferritin-conjugated B. pupurea hemagglutinin and ferritin-conjugated A. hypogoea hemagglutinin were found in a random distribution on the membranes. Furthermore, when the membranes were labeled with a mixture of concanavalin A and ferritin-conjugated B. purpurea hemagglutinin, ferritin particles were found in clusters, indicating that the membrane receptors for B. purpurea hemagglutinin were forced to move together with those for concanavalin A. A method for thentitative estimation of the clustering of ferritin particles on the membranes was also devised and applied to the labeling of sialidase-treated, human erythrocyte membranes with the above four ferritin-conjugated lectins.     

Two glycerol uptake systems contribute to the high osmotolerance of Zygosaccharomyces rouxii

The accumulation of glycerol is essential for yeast viability upon hyperosmotic stress. Here we show that the osmotolerant yeast Zygosaccharomyces rouxii has two genes, ZrSTL1 and ZrSTL2, encoding transporters mediating the active uptake of glycerol in symport with protons, contributing to cell osmotolerance and intracellular pH homeostasis. The growth of mutants lacking one or both transporters is affected depending on the growth medium, carbon source, strain auxotrophies, osmotic conditions and the presence of external glycerol. These transporters are localised in the plasma membrane, they transport glycerol with similar kinetic parameters and besides their expected involvement in the cell survival of hyperosmotic stress, they surprisingly both contribute to an efficient survival of hypoosmotic shock and to the maintenance of intracellular pH homeostasis under non‐stressed conditions. Unlike STL1 in Sa. cerevisiae, the two Z. rouxii STL genes are not repressed by glucose, but their expression and activity are downregulated by fructose and upregulated by non‐fermentable carbon sources, with ZrSTL1 being more influenced than ZrSTL2. In summary, both transporters are highly important, though Z. rouxii CBS 732^T cells do not use external glycerol as a source of carbon.     

Co-culture with Tetragenococcus halophilus changed the response of Zygosaccharomyces rouxii to salt stress

Zygosaccharomyces rouxii and Tetragenococcus halophilus exhibit remarkable salt tolerance and play roles in high-salt fermented food production. This study investigated the effect of co-culture with T. halophilus on Z. rouxii based on analysis of the viability of Z. rouxii in high-salt environments, the plasma membrane integrity, Na⁺, K⁺-ATPase activity, amino acid content of Z. rouxii cell after salt stress and organic acids assay. The results showed both T. halophilus broth supernatant and intracellular component of T. halophilus increased the viability of Z. rouxii in the 12 % environment. Co-cultured Z. rouxii cells maintained better plasma membrane integrity and lowered Na⁺, K⁺-ATPase activity than single-cultured after salt stress. Co-cultured Z. rouxii cells exhibited higher contents of aspartic acid, threonine, serine, asparagine, glutamic acid, alanine, α-amino-n-butyric acid, methionine, homo-cystine, arginine and proline compared with single-cultured after salt stress. More contents of propionic acid, lactic acid and L-pyroglutamic acid and lower contents of L-malic acid and citric acid were detected in co-culture broth. This study shows preculture of T. halophilus and then co-culture with Z. rouxii enhanced the viability of Z. rouxii in high-salt environment. The results may contribute to further understand the interactions between Z. rouxii and T. halophilus in high-salt environments.     

Characterization of plasma membrane domains of mouse EL4 lymphoma cells obtained by affinity chromatography on concanavalin A-Sepharose

Purified plasma membranes of mouse EL₄ lymphoma cells were fractionated by means of affinity chromatography on concanavalin A-Sepharose into two subfractions; one (MF1) eluted freely from the affinity column, the second (MF2) adhered specifically to Con A-Sepharose. Both membrane subfractions proved to be of plasma membrane origin, as evidenced by the following criteria. (i) The ratio of cholesterol to phospholipid was nearly identical in plasma membrane and both subfractions. (ii) When isolated plasma membranes were labelled with tritiated NaBH₄, both subfractions exhibited identical specific radioactivities. (iii) After enzymatic radioiodination of the cells, the total content of labelled proteins was very similar in isolated plasma membranes and in both subfractions. (iv) Some plasma membrane marker enzymes exhibited nearly identical specific activities in plasma membranes, MF1 or MF2 including γ-glutamyl transpeptidase, 5′-nucleotidase and Mg²⁺-ATPase. Both subfractions exhibited characteristic differences. Thus the specific activities of (Na⁺ + K⁺)-ATPase, Ca²⁺-ATPase and lysophosphatidylcholine acyltransferase were several-fold enriched in MF2 compared to MF1. SDS-polyacrylamide gel electrophoresis revealed a different polypeptide composition of the two subfractions. Polypeptides of apparent molecular mass of 116, 95, 42, 39, 30 and 28 kDa were highly enriched in MF2, whereas MF1 contained another set of proteins, of apparent molecular mass of 70, 55 and 24 kDa. The phospholipid fatty acid composition of the subfractions proved to be different, as well, MF2 contained more saturated fatty acids than MF1. The data suggest the existence of plasma membrane domains in the plasma membranes of the mouse EL₄ lymphoma cells, containing a set of polypeptides, among others membrane bound enzymes, embedded in a different phospholipid milieu.