Metabolic fluxes in Corynebacterium glutamicum during lysine production with sucrose as carbon source

Metabolic fluxes in the central metabolism were determined for lysine-producing Corynebacterium glutamicum ATCC 21526 with sucrose as a carbon source, providing an insight into molasses-based industrial production processes with this organism. For this purpose, 13C metabolic flux analysis with parallel studies on [1-(13C)Fru]sucrose, [1-(13C)Glc]sucrose, and [13C6Fru]sucrose was carried out. C. glutamicum directed 27.4% of sucrose toward extracellular lysine. The strain exhibited a relatively high flux of 55.7% (normalized to an uptake flux of hexose units of 100%) through the pentose phosphate pathway (PPP). The glucose monomer of sucrose was completely channeled into the PPP. After transient efflux, the fructose residue was mainly taken up by the fructose-specific phosphotransferase system (PTS) and entered glycolysis at the level of fructose-1,6-bisphosphate. Glucose-6-phosphate isomerase operated in the gluconeogenetic direction from fructose-6-phosphate to glucose-6-phosphate and supplied additional carbon (7.2%) from the fructose part of the substrate toward the PPP. This involved supply of fructose-6-phosphate from the fructose part of sucrose either by PTS(Man) or by fructose-1,6-bisphosphatase. C. glutamicum further exhibited a high tricarboxylic acid (TCA) cycle flux of 78.2%. Isocitrate dehydrogenase therefore significantly contributed to the total NADPH supply of 190%. The demands for lysine (110%) and anabolism (32%) were lower than the supply, resulting in an apparent NADPH excess. The high TCA cycle flux and the significant secretion of dihydroxyacetone and glycerol display interesting targets to be approached by genetic engineers for optimization of the strain investigated.     

Comparative 13C metabolic flux analysis of pyruvate dehydrogenase complex-deficient, L-valine-producing Corynebacterium glutamicum

L-Valine can be formed successfully using C. glutamicum strains missing an active pyruvate dehydrogenase enzyme complex (PDHC). Wild-type C. glutamicum and four PDHC-deficient strains were compared by (13)C metabolic flux analysis, especially focusing on the split ratio between glycolysis and the pentose phosphate pathway (PPP). Compared to the wild type, showing a carbon flux of 69% ± 14% through the PPP, a strong increase in the PPP flux was observed in PDHC-deficient strains with a maximum of 113% ± 22%. The shift in the split ratio can be explained by an increased demand of NADPH for l-valine formation. In accordance, the introduction of the Escherichia coli transhydrogenase PntAB, catalyzing the reversible conversion of NADH to NADPH, into an L-valine-producing C. glutamicum strain caused the PPP flux to decrease to 57% ± 6%, which is below the wild-type split ratio. Hence, transhydrogenase activity offers an alternative perspective for sufficient NADPH supply, which is relevant for most amino acid production systems. Moreover, as demonstrated for L-valine, this bypass leads to a significant increase of product yield due to a concurrent reduction in carbon dioxide formation via the PPP.     

Metabolic network analysis of lysine producing Corynebacterium glutamicum at a miniaturized scale

We present a straightforward approach comprising (13)C tracer experiments at 200-microL volume in 96-well microtiter plates with on-line measurement of dissolved oxygen for quantitative high-throughput metabolic network analysis at a miniaturized scale. This method was successfully applied for cultivation and (13)C metabolic flux analysis of two mutants of lysine producing Corynebacterium glutamicum (ATCC 13287 and ATCC 21543). Microtiter-plate cultivations showed excellent accordance in kinetics and stoichiometry of growth and product formation as well as in intracellular flux distributions as compared with parallel shake-flask experiments. These cultivations further allowed clear identification of strain-specific flux differences such as increased flux toward lysine, increased flux through the pentose phosphate pathway (PPP), decreased flux through the tricarboxylic (TCA) cycle, and increased dihydroxyacetone formation in C. glutamicum ATCC 21543 compared with ATCC 13287. The present approach has strong potential for broad quantitative screening of metabolic network activities, especially those involving high-cost tracer substrates.     

Amplified expression of fructose 1,6-bisphosphatase in Corynebacterium glutamicum increases in vivo flux through the pentose phosphate pathway and lysine production on different carbon sources

The overexpression of fructose 1,6-bisphosphatase (FBPase) in Corynebacterium glutamicum leads to significant improvement of lysine production on different sugars. Amplified expression of FBPase via the promoter of the gene encoding elongation factor TU (EFTU) increased the lysine yield in the feedback-deregulated lysine-producing strain C. glutamicum lysCfbr by 40% on glucose and 30% on fructose or sucrose. Additionally formation of the by-products glycerol and dihydroxyacetone was significantly reduced in the PEFTUfbp mutant. As revealed by 13C metabolic flux analysis on glucose the overexpression of FBPase causes a redirection of carbon flux from glycolysis toward the pentose phosphate pathway (PPP) and thus leads to increased NADPH supply. Normalized to an uptake flux of glucose of 100%, the relative flux into the PPP was 56% for C. glutamicum lysCfbr PEFTUfbp and 46% for C. glutamicum lysCfbr. The flux for NADPH supply was 180% in the PEFTUfbp strain and only 146% in the parent strain. Amplification of FBPase increases the production of lysine via an increased supply of NADPH. Comparative studies with another mutant containing the sod promoter upstream of the fbp gene indicate that the expression level of FBPase relates to the extent of the metabolic effects. The overexpression of FBPase seems useful for starch- and molasses-based industrial lysine production with C. glutamicum. The redirection of flux toward the PPP should also be interesting for the production of other NADPH-demanding compounds as well as for products directly stemming from the PPP.     

Metabolic pathway analysis of glycerol metabolism in Klebsiella pneumoniae incorporating oxygen regulatory system

It is well known that environmental and genetic perturbations have major effects on the metabolic behavior of cells. In this work, a model that utilizes existing knowledge of oxygen and redox sensing/regulatory system to assist elementary flux modes (EFMs) has been developed and was carried out to predict the metabolic potential of Klebsiella pneumoniae for the production of 1,3‐propanediol (1,3‐PD) under anaerobic and aerobic conditions. It was found that the theoretical optimal 1,3‐PD yield could reach to 0.844 mol mol^?1 if the pentose phosphate pathway (PPP), and transhydrogenase had a high flux under anaerobic condition. However, PPP had little influence on the theoretical 1,3‐PD yield, and the flux through tricarboxylic acid (TCA) cycle was high under aerobic conditions. In addition, the effect of oxygen level on the 1,3‐PD and biomass was further analyzed. © 2009 American Institute of Chemical Engineers Biotechnol. Prog., 2009     

Genealogy profiling through strain improvement by using metabolic network analysis: metabolic flux genealogy of several generations of lysine-producing corynebacteria

A comprehensive approach of metabolite balancing, (13)C tracer studies, gas chromatography-mass spectrometry, matrix-assisted laser desorption ionization-time of flight mass spectrometry, and isotopomer modeling was applied for comparative metabolic network analysis of a genealogy of five successive generations of lysine-producing Corynebacterium glutamicum. The five strains examined (C. glutamicum ATCC 13032, 13287, 21253, 21526, and 21543) were previously obtained by random mutagenesis and selection. Throughout the genealogy, the lysine yield in batch cultures increased markedly from 1.2 to 24.9% relative to the glucose uptake flux. Strain optimization was accompanied by significant changes in intracellular flux distributions. The relative pentose phosphate pathway (PPP) flux successively increased, clearly corresponding to the product yield. Moreover, the anaplerotic net flux increased almost twofold as a consequence of concerted regulation of C(3) carboxylation and C(4) decarboxylation fluxes to cover the increased demand for lysine formation; thus, the overall increase was a consequence of concerted regulation of C(3) carboxylation and C(4) decarboxylation fluxes. The relative flux through isocitrate dehydrogenase dropped from 82.7% in the wild type to 59.9% in the lysine-producing mutants. In contrast to the NADPH demand, which increased from 109 to 172% due to the increasing lysine yield, the overall NADPH supply remained constant between 185 and 196%, resulting in a decrease in the apparent NADPH excess through strain optimization. Extrapolated to industrial lysine producers, the NADPH supply might become a limiting factor. The relative contributions of PPP and the tricarboxylic acid cycle to NADPH generation changed markedly, indicating that C. glutamicum is able to maintain a constant supply of NADPH under completely different flux conditions. Statistical analysis by a Monte Carlo approach revealed high precision for the estimated fluxes, underlining the fact that the observed differences were clearly strain specific.     

Metabolic network analysis on Phaffia rhodozyma yeast using 13C-labeled glucose and gas chromatography-mass spectrometry

Carotenoid production by microorganisms, as opposed to chemical synthesis, could fulfill an ever-increasing demand for 'all natural' products. The yeast Phaffia rhodozyma has received considerable attention because it produces the red pigment astaxanthin, commonly used as an animal feed supplement. In order to have a better understanding of its metabolism, labeling experiments with [1-(13)C]glucose were conducted with the wildtype strain (CBS5905T) and a hyper-producing carotenoid strain (J4-3) in order to determine their metabolic network structure and estimate intracellular fluxes. Amino acid labeling patterns, as determined by GC-MS, were in accordance with a metabolic network consisting of the Embden-Meyerhof-Parnas pathway, the pentose phosphate pathway, and the TCA cycle. Glucose was mainly consumed along the pentose phosphate pathway ( approximately 65% for wildtype strain), which reflected high NADPH requirements for lipid biosynthesis. Although common to other oleaginous yeast, there was no, or very little, malic enzyme activity for carbon-limited growth. In addition, there was no evidence of phosphoketolase activity. The central carbon metabolism of the mutant strain was similar to that of the wildtype strain, though the relative pentose phosphate flux was lower and the TCA cycle flux in accordance with the biomass yield being lower.     

Metabolic flux analysis in Escherichia coli by integrating isotopic dynamic and isotopic stationary 13C labeling data

The novel concept of isotopic dynamic 13C metabolic flux analysis (ID-13C MFA) enables integrated analysis of isotopomer data from isotopic transient and/or isotopic stationary phase of a 13C labeling experiment, short-time experiments, and an extended range of applications of 13C MFA. In the presented work, an experimental and computational framework consisting of short-time 13C labeling, an integrated rapid sampling procedure, a LC-MS analytical method, numerical integration of the system of isotopomer differential equations, and estimation of metabolic fluxes was developed and applied to determine intracellular fluxes in glycolysis, pentose phosphate pathway (PPP), and citric acid cycle (TCA) in Escherichia coli grown in aerobic, glucose-limited chemostat culture at a dilution rate of D = 0.10 h(-1). Intracellular steady state concentrations were quantified for 12 metabolic intermediates. A total of 90 LC-MS mass isotopomers were quantified at sampling times t = 0, 91, 226, 346, 589 s and at isotopic stationary conditions. Isotopic stationarity was reached within 10 min in glycolytic and PPP metabolites. Consistent flux solutions were obtained by ID-13C MFA using isotopic dynamic and isotopic stationary 13C labeling data and by isotopic stationary 13C MFA (IS-13C MFA) using solely isotopic stationary data. It is demonstrated that integration of dynamic 13C labeling data increases the sensitivity of flux estimation, particularly at the glucose-6-phosphate branch point. The identified split ratio between glycolysis and PPP was 55%:44%. These results were confirmed by IS-13C MFA additionally using labeling data in proteinogenic amino acids (GC-MS) obtained after 5 h from sampled biomass.     

Metabolic phenotype of phosphoglucose isomerase mutants of Corynebacterium glutamicum

A series of experiments reported in the literature using fluxomics as an efficient functional genomics tool revealed that the L-lysine production of the Corynebacterium glutamicum strain MH20-22B correlates with the extent of intracellular NADPH supply. Some alternative metabolic engineering strategies to increase intracellular NADPH supply in the C. glutamicum strain DSM5715 were considered and finally the redirection of carbon flux through the pentose phosphate pathway with two NADPH generating enzymatic reactions was favored. Elsewhere, the construction of a phosphoglucose isomerase (Pgi) null mutant of the C. glutamicum strain DSM5715 has been described by utilizing genetic engineering as well as some aspects of its metabolic phenotype. Most interestingly, it was shown that not only could the L-lysine formation be increased by 1.7-fold but the by-product concentration for the null mutant strain was also able to be drastically reduced. In this publication we discuss this metabolic phenotype in detail and present additional data on by-product formation as well as yield considerations. Results from isotope based metabolic flux analysis in combination with considerations on NADPH metabolism clearly exclude the existence of Pgi isoenzymes in C. glutamicum strain DSM5715. The genome region containing the pgi gene was analyzed. It cannot be excluded that polar effects might have been caused by the disruption of the pgi gene and might have contributed to the observed metabolic phenotype of C. glutamicum Pgi mutants. We illustrate growth characteristics of a Pgi mutant of an industrial L-lysine production strain. A reduced growth rate and a biphasic growth behavior was observed. The importance of NADPH reoxidation for well balanced growth in Pgi mutants is discussed. Another phosphoglucose isomerase mutant of C. glutamicum has been described in literature with which an increase in L-lysine yield from 42 to 52% was observed. This finding highlights the general potential of metabolic flux redirection towards the pentose phosphate pathway, which could be used for metabolic engineering of the biotechnological synthesis of (1) aromatic amino acids and (2) chemicals whose synthesis depends on intracellular NADPH supply.     

谷氨酸棒杆菌SYPS-062合成L-丝氨酸的代谢通量分析

以一株由自然界筛选获得的能够利用糖质原料直接产L-丝氨酸的谷氨酸棒杆菌Corynebacterium glutamicum SYPS-062为研究对象,考察了一碳单元循环中的辅因子—叶酸和维生素B12对菌株生长、蔗糖消耗及L-丝氨酸生成的影响,同时对处于对数生长期的菌株进行了代谢流量分析。结果发现,添加扰动因子叶酸和维生素B12对磷酸戊糖途径(HMP)碳流影响较大,碳源主要用于细胞生长及合成能量,而流向目的产物L-丝氨酸的碳流减少。同时在添加维生素B12时,增大了G3P节点的L-丝氨酸合成途径的分流比,但造成三羧酸循环(TCA)的流量不足,需要大量回补,从而限制了产物合成速率的进一步提高。     

L-色氨酸生物合成的代谢流量分析

建立了谷氨酸棒杆菌合成L-色氨酸(L-Try)的代谢流量平衡模型,应用该模型计算出发酵中后期的代谢流分布并通过MATLAB软件线性规划得到Try理想代谢流分布。结果表明75．15％的碳架进入糖酵解,24．85％的碳架进入HMP途径;但与理想代谢流相比,应从遗传改造和发酵控制方面降低TCA循环的代谢流,减少副产氨基酸的生成,摸索最适的溶氧控制对提高Try产率至关重要。     

Comparative metabolic flux analysis of lysine-producing Corynebacterium glutamicum cultured on glucose or fructose

A comprehensive approach to (13)C tracer studies, labeling measurements by gas chromatography-mass spectrometry, metabolite balancing, and isotopomer modeling, was applied for comparative metabolic network analysis of lysine-producing Corynebacterium glutamicum on glucose or fructose. Significantly reduced yields of lysine and biomass and enhanced formation of dihydroxyacetone, glycerol, and lactate in comparison to those for glucose resulted on fructose. Metabolic flux analysis revealed drastic differences in intracellular flux depending on the carbon source applied. On fructose, flux through the pentose phosphate pathway (PPP) was only 14.4% of the total substrate uptake flux and therefore markedly decreased compared to that for glucose (62.0%). This result is due mainly to (i) the predominance of phosphoenolpyruvate-dependent phosphotransferase systems for fructose uptake (PTS(Fructose)) (92.3%), resulting in a major entry of fructose via fructose 1,6-bisphosphate, and (ii) the inactivity of fructose 1,6-bisphosphatase (0.0%). The uptake of fructose during flux via PTS(Mannose) was only 7.7%. In glucose-grown cells, the flux through pyruvate dehydrogenase (70.9%) was much less than that in fructose-grown cells (95.2%). Accordingly, flux through the tricarboxylic acid cycle was decreased on glucose. Normalized to that for glucose uptake, the supply of NADPH during flux was only 112.4% on fructose compared to 176.9% on glucose, which might explain the substantially lower lysine yield of C. glutamicum on fructose. Balancing NADPH levels even revealed an apparent deficiency of NADPH on fructose, which is probably overcome by in vivo activity of malic enzyme. Based on these results, potential targets could be identified for optimization of lysine production by C. glutamicum on fructose, involving (i) modification of flux through the two PTS for fructose uptake, (ii) amplification of fructose 1,6-bisphosphatase to increase flux through the PPP, and (iii) knockout of a not-yet-annotated gene encoding dihydroxyacetone phosphatase or kinase activity to suppress overflow metabolism. Statistical evaluation revealed high precision of the estimates of flux, so the observed differences for metabolic flux are clearly substrate specific.     

Metabolic flux profiling of Escherichia coli mutants in central carbon metabolism using GC-MS.

We describe here a novel methodology for rapid diagnosis of metabolic changes, which is based on probabilistic equations that relate GC-MS-derived mass distributions in proteinogenic amino acids to in vivo enzyme activities. This metabolic flux ratio analysis by GC-MS provides a comprehensive perspective on central metabolism by quantifying 14 ratios of fluxes through converging pathways and reactions from [1-13C] and [U-13C]glucose experiments. Reliability and accuracy of this method were experimentally verified by successfully capturing expected flux responses of Escherichia coli to environmental modifications and seven knockout mutations in all major pathways of central metabolism. Furthermore, several mutants exhibited additional, unexpected flux responses that provide new insights into the behavior of the metabolic network in its entirety. Most prominently, the low in vivo activity of the Entner-Doudoroff pathway in wild-type E. coli increased up to a contribution of 30% to glucose catabolism in mutants of glycolysis and TCA cycle. Moreover, glucose 6-phosphate dehydrogenase mutants catabolized glucose not exclusively via glycolysis, suggesting a yet unidentified bypass of this reaction. Although strongly affected by environmental conditions, a stable balance between anaplerotic and TCA cycle flux was maintained by all mutants in the upper part of metabolism. Overall, our results provide quantitative insight into flux changes that bring about the resilience of metabolic networks to disruption.     

Comparative study on central metabolic fluxes of <Emphasis Type="Italic">Bacillus megaterium</Emphasis> strains in continuous culture using <Superscript>13</Superscript>C labelled substrates

Fluxes of central carbon metabolism [glycolysis, pentose phosphate pathway (PPP), tricarboxylic acid cycle (TCA cycle), biomass formation] were determined for several Bacillus megaterium strains (DSM319, WH320, WH323, MS941) in C- and N-limited chemostat cultures by ¹³C labelling experiments. The labelling patterns of proteinogenic amino acids were analysed by GC/MS and therefrom flux ratios at important nodes within the metabolic network could be calculated. On the basis of a stoichiometric metabolic model flux distributions were estimated for the different B. megaterium strains used at various cultivation conditions. Generally all strains exhibited similar metabolic flux distributions, however, several significant changes were found in (1) the glucose flux entering the PPP via the oxidative branch, (2) the reversibilities within the PPP, (3) the relative fluxes of pyruvate and acetyl-CoA fed to the TCA cycle, (4) the fluxes around the pyruvate node involving a futile cycle.     

Overproduction of trehalose: heterologous expression of Escherichia coli trehalose-6-phosphate synthase and trehalose-6-phosphate phosphatase in Corynebacterium glutamicum

Trehalose is a disaccharide with potential applications in the biotechnology and food industries. We propose a method for industrial production of trehalose, based on improved strains of Corynebacterium glutamicum. This paper describes the heterologous expression of Escherichia coli trehalose-synthesizing enzymes trehalose-6-phosphate synthase (OtsA) and trehalose-6-phosphate phosphatase (OtsB) in C. glutamicum, as well as its impact on the trehalose biosynthetic rate and metabolic-flux distributions, during growth in a defined culture medium. The new recombinant strain showed a five- to sixfold increase in the activity of OtsAB pathway enzymes, compared to a control strain, as well as an almost fourfold increase in the trehalose excretion rate during the exponential growth phase and a twofold increase in the final titer of trehalose. The heterologous expression described resulted in a reduced specific glucose uptake rate and Krebs cycle flux, as well as reduced pentose pathway flux, a consequence of downregulated glucose-6-phosphate dehydrogenase and 6-phosphogluconate dehydrogenase. The results proved the suitability of using the heterologous expression of Ots proteins in C. glutamicum to increase the trehalose biosynthetic rate and yield and suggest critical points for further improvement of trehalose overproduction in C. glutamicum.     

Modeling and experimental design for metabolic flux analysis of lysine-producing Corynebacteria by mass spectrometry

Experimental design of (13)C-tracer studies for metabolic flux analysis with mass spectrometric determination of labeling patterns was performed for the central metabolism of Corynebacterium glutamicum comprising various flux scenarios. Ratio measurement of mass isotopomer pools of Corynebacterium products lysine, alanine, and trehalose is sufficient to quantify the flux partitioning ratios (i) between glycolysis and pentose phosphate pathways (Phi(PPP)), (ii) between the split pathways in the lysine biosynthesis (Phi(DH)), (iii) at the pyruvate node (Phi(PC)), and reversibilities of (iv) glucose 6-phosphate isomerase (zeta(PGI)), (v) at the pyruvate node (zeta(PC/PEPCK)), and (vi) of transaldolase and transketolases in the PPP. Weighted sensitivities for flux parameters were derived from partial derivatives to quantitatively evaluate experimental approaches and predict precision for estimated flux parameters. Deviation of intensity ratios from ideal values of 1 was used as weighting function. Weighted flux sensitivities can be used to identify optimal type and degree of tracer labeling or potential intensity ratios to be measured. Experimental design for lysine-producing strain C. glutamicum MH 20-22B (Marx et al., Biotechnol. Bioeng. 49, 111-129, 1996) and various potential mutants with different alterations in the flux pattern showed that specific tracer labelings are optimal to quantify a certain flux parameter uninfluenced by the overall flux situation. Identified substrates of choice are [1-(13)C]glucose for the estimation of Phi(PPP) and zeta(PGI) and a 1 : 1 mixture of [U-(12)C/U-(13)C]glucose for the determination of zeta(PC/PEPCK). Phi(PC) can be quantified by feeding [4-(13)C]glucose or [U-(12)C/U-(13)C]glucose (1 : 1), whereas Phi(DH) is accessible via [4-(13)C]glucose. The sensitivity for the quantification of a certain flux parameter can be influenced by superposition through other flux parameters in the network, but substrate and measured mass isotopomers of choice remain the same. In special cases, reduced labeling degree of the tracer substrate can increase the precision of flux analysis. Enhanced precision and flux information can be achieved via multiply labeled substrates. The presented approach can be applied for effective experimental design of (13)C tracer studies for metabolic flux analysis. Intensity ratios of other products such as glutamate, valine, phenylalanine, and riboflavin also sensitively reflect flux parameters, which underlines the great potential of mass spectrometry for flux analysis.     

Respirometric 13C flux analysis--Part II: in vivo flux estimation of lysine-producing Corynebacterium glutamicum

A novel method for metabolic flux studies of central metabolism which is based on respirometric (13)C flux analysis, i.e., parallel (13)C tracer studies with online CO(2) labeling measurements is applied to flux quantification of a lysine-producing mutant of Corynebacterium glutamicum. For this purpose, 3 respirometric (13)C labeling experiments with [1-(13)C(1)], [6-(13)C(1)] and [1,6-(13)C(2)] glucose were carried out in parallel. All fluxes comprising the reactions of glycolysis, of TCA cycle, of C3- and C4-metabolite interconversion and of lysine biosynthesis as well as the net reactions in the pentose phosphate pathway could be quantified solely using experimental data obtained from CO(2) labeling and extracellular rate measurements. At key branch points, 68+/-5% of glucose 6-phosphate were observed to be metabolized into pentose phosphate pathway and 48+/-1% of pyruvate into TCA cycle via pyruvate dehydrogenase. The results showed a good agreement with the previous studies using (13)C tracer cultivation and GC/MS analysis of proteinogenic amino acids. Also, respiratory quotient calculated from flux estimates using redox balance showed a high accordance with the value determined directly from the measured specific rates of O(2) consumption and CO(2) production. The results strongly support that the respirometric (13)C metabolic flux analysis is suited as an alternative to the conventional methods to study functional and regulatory activities of cells. The developed method is applicable to study growing or non-growing cells, primary and secondary metabolism and immobilized cells. Due to the non-accumulating nature of CO(2) labeling and instantaneous nature of the resulting fluxes, the method can also be used for dynamic profiling of metabolic activities. Therefore, it is complementary to conventional methods for metabolic flux analysis.     

Metabolic flux engineering of L-lysine production in Corynebacterium glutamicum--over expression and modification of G6P dehydrogenase

In the present work, metabolic flux engineering of Corynebacterium glutamicum was carried out to increase lysine production. The strategy focused on engineering of the pentose phosphate pathway (PPP) flux by different genetic modifications. Over expression of the zwf gene, encoding G6P dehydrogenase, in the feedback-deregulated lysine-producing strain C. glutamicum ATCC 13032 lysC(fbr) resulted in increased lysine production on different carbon sources including the two major industrial sugars, glucose and sucrose. The additional introduction of the A243T mutation into the zwf gene and the over expression of fructose 1,6-bisphosphatase resulted in a further successive improvement of lysine production. Hereby the point mutation resulted in higher affinity of G6P dehydrogenase towards NADP and reduced sensitivity against inhibition by ATP, PEP and FBP. Overall, the lysine yield increased up to 70% through the combination of the different genetic modifications. Through strain engineering formation of trehalose was reduced by up to 70% due to reduced availability of its precursor G6P. Metabolic flux analysis revealed a 15% increase of PPP flux in response to over expression of the zwf gene. Overall a strong apparent NADPH excess resulted. Redox balancing indicated that this excess is completely oxidized by malic enzyme.     

Metabolic network analysis on Phaffia rhodozyma yeast using C–labeled glucose and gas chromatography-mass spectrometry

Carotenoid production by microorganisms, as opposed to chemical synthesis, could fulfill an ever-increasing demand for ‘all natural’ products. The yeast Phaffia rhodozyma has received considerable attention because it produces the red pigment astaxanthin, commonly used as an animal feed supplement. In order to have a better understanding of its metabolism, labeling experiments with [1-¹³C]glucose were conducted with the wildtype strain (CBS5905 T) and a hyper-producing carotenoid strain (J4-3) in order to determine their metabolic network structure and estimate intracellular fluxes.Amino acid labeling patterns, as determined by GC–MS, were in accordance with a metabolic network consisting of the Embden–Meyerhof–Parnas pathway, the pentose phosphate pathway, and the TCA cycle. Glucose was mainly consumed along the pentose phosphate pathway (65% for wildtype strain), which reflected high NADPH requirements for lipid biosynthesis. Although common to other oleaginous yeast, there was no, or very little, malic enzyme activity for carbon-limited growth. In addition, there was no evidence of phosphoketolase activity. The central carbon metabolism of the mutant strain was similar to that of the wildtype strain, though the relative pentose phosphate flux was lower and the TCA cycle flux in accordance with the biomass yield being lower.