木薯粉同步糖化发酵(SSF)产丁二酸

【目的】通过优化产琥珀酸放线杆菌GXAS137同步糖化发酵木薯粉产丁二酸的发酵培养基,提高丁二酸产量,降低生产成本。【方法】在单因素试验的基础上,先利用Plackett-Burman试验设计筛选出影响丁二酸发酵的重要参数,再采用正交试验确定重要参数的最佳水平。【结果】价格低廉玉米浆可用作氮源,影响丁二酸产量的重要参数是木薯粉、玉米浆、碱式碳酸镁和糖化酶浓度。最佳条件为(g/L):木薯粉100,玉米浆14,糖化酶2.0 AGU/g底物,碱式碳酸镁75。优化后丁二酸产量达到69.31 g/L,丁二酸得率为90.01%,生产强度为1.44 g/(L·h)。与初始条件(52.34 g/L)相比,丁二酸浓度提高了32.42%。并利用1.3 L发酵罐对SSF与SHF两种发酵工艺进行了比较,SSF丁二酸产量(72.21 g/L)远高于SHF(56.86 g/L)。【结论】产琥珀酸放线杆菌同步糖化发酵木薯粉丁二酸产量高,生产成本低,具有较好的工业化应用前景。     

一株丁二酸高产菌株的筛选和鉴定

从瘤胃中筛选到一株高产丁二酸生产菌株,为革兰氏阴性菌,短杆状,无芽孢,不运动,兼性厌氧.经形态学、生理生化鉴定和基于16S rRNA序列的系统发育分析,该菌株为巴斯德菌科的产琥珀酸放线杆菌,是产琥珀酸放线杆菌CCUG 43843的变种,二者的序列相似性为99.93%,命名为产琥珀酸放线杆菌A3.5L发酵罐分批发酵实验表明,当发酵培养基中葡萄糖浓度为50g/L时,产琥珀酸放线杆菌A3可以产25.8g/L丁二酸,具有较好的丁二酸生产潜力.     

酶水解菊芋糖浆发酵生产琥珀酸的初步研究

用产菊粉酶的一株黑曲霉菌株进行产酶发酵条件和水解条件研究,在30℃,pH 6.0,摇床转速200 r/min,发酵时间为3 d的最适产酶条件下,酶活可以达到45.9 U/mL.以总糖含量为85.2 g/L的菊芋粉为初始底物,最适酶水解条件为温度50℃,加黑曲霉培养液的量为10%(v/v),水解12 h后,水解率达到99.6%.用此酶解液在5 L搅拌发酵罐中进行琥珀酸发酵,初始还原糖浓度53.5 g/L,36 h发酵产琥珀酸43.8 g/L,琥珀酸产率0.83 g/g,糖利用率99.0%,琥珀酸生产强度1.22 g/(L·h).     

稀酸水解玉米芯制备丁二酸

利用正交设计得到稀H2SO4水解玉米芯制备混合糖液的优化工艺:玉米芯料液比1∶5(质量体积比),物料粒径250~380μm、H2SO4用量3%(体积分数)、水解温度126℃、反应时间2.5 h。此工艺条件下的总糖收率达90%,总糖质量浓度为60 g/L,发酵抑制物糠醛含量为0.87 g/L,5-羟甲基糠醛含量为0.68 g/L。在此基础上利用活性炭吸附和Ca(OH)2中和对玉米芯混合糖液进行脱毒及脱盐处理,SO42-脱除率达96%,色素脱除率为96%,糠醛、5-羟甲基糠醛及多酚类物质脱除率均高于50%。处理后的玉米芯多组分糖液作为产琥珀酸放线杆菌(Actinobacillus succino-genes)NJ113的发酵C源,当培养基中初始总糖质量浓度为50 g/L时,丁二酸收率为61.68%,丁二酸质量浓度为30.8 g/L;初始总糖质量浓度为70 g/L时,丁二酸收率仍可达50%以上,丁二酸质量浓度为35.2 g/L。发酵实验表明,将经过脱毒脱盐处理的玉米芯多组分糖液替代葡萄糖作为C源发酵制备丁二酸具有可行性。     

环境因素对琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593发酵生产丁二酸的影响

琥珀酸放线杆菌是发酵生产有应用前景的生物基原料-丁二酸的微生物。本研究室从牛瘤胃中筛选获得一株琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593, 分析了环境气体、pH、氧化还原电位(ORP)环境因素对琥珀酸放线杆菌A. succinogenes CGMCC 1593发酵生产丁二酸的影响。结果表明: CO2不仅提供了A. succinogenes CGMCC 1593发酵生产丁二酸的最佳气体环境, 也是发酵生产丁二酸的底物之一; MgCO3是A. succinogenes CGMCC 1593发酵过程较好的pH调节剂, 发酵过程维持pH7.1~6.2, 可满足菌体生长与产酸的要求; 发酵液初始ORP过低, 不利于菌体生长, ORP在-270 mV时对丁二酸产生有利。在菌体对数生长期结束时, 通过Na2S·9H2O降低发酵液ORP到-270 mV, 发酵48 h时可产丁二酸37 g/L, 摩尔产率达到129%。这对深入研究A. succinogenes CGMCC 1593发酵生产丁二酸具有参考价值。     

环境因素对琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593发酵生产丁二酸的影响

琥珀酸放线杆菌是发酵生产有应用前景的生物基原料-丁二酸的微生物。本研究室从牛瘤胃中筛选获得一株琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593, 分析了环境气体、pH、氧化还原电位(ORP)环境因素对琥珀酸放线杆菌A. succinogenes CGMCC 1593发酵生产丁二酸的影响。结果表明: CO2不仅提供了A. succinogenes CGMCC 1593发酵生产丁二酸的最佳气体环境, 也是发酵生产丁二酸的底物之一; MgCO3是A. succinogenes CGMCC 1593发酵过程较好的pH调节剂, 发酵过程维持pH7.1~6.2, 可满足菌体生长与产酸的要求; 发酵液初始ORP过低, 不利于菌体生长, ORP在-270 mV时对丁二酸产生有利。在菌体对数生长期结束时, 通过Na2S·9H2O降低发酵液ORP到-270 mV, 发酵48 h时可产丁二酸37 g/L, 摩尔产率达到129%。这对深入研究A. succinogenes CGMCC 1593发酵生产丁二酸具有参考价值。     

一株丁二酸高产菌株的筛选鉴定及初步发酵研究

以牛胃内容物为菌源,利用富马酸钠为唯一碳源并加入高浓度丁二酸钠的选择培养基筛选到一株丁二酸产量较高,副产物较少的菌株。经形态学、生理生化鉴定和16S rDNA序列的系统发育分析,该菌株为巴斯德菌科的产琥珀酸放线杆菌,与琥珀酸放线杆菌S.JST序列相似性最高为98.98%,命名为琥珀酸放线杆菌GXAS137,保藏号为M2011399。利用正交试验对发酵条件进行了初步优化,该菌可发酵55 g/L葡萄糖产38.96 g/L丁二酸,具有较好的丁二酸生产潜力。     

琥珀酸放线杆菌的耐高浓度钠离子菌株选育

以琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593为出发菌,经过紫外线和甲基磺酸乙酯(EMS)诱变处理,选育出一株耐高浓度钠离子菌株SE-6.该菌株在5 L发酵罐中进行分批发酵,单独使用Na2CO3控制发酵过程pH,发酵48 h琥珀酸产量达到35.8g/L,较出发菌(26.0 g/L)提高了37.7%;若采用MgCO3和Na2CO3共同调控发酵过程pH,发酵48 h琥珀酸产量达到45.0 g/L,较出发菌(37.4g/L)提高了20.4%.     

萃取耦合技术对玉米秸秆水解液发酵产丁醇的影响

本研究以玉米秸秆水解液为原料,通过萃取发酵技术生产燃料丁醇,以提高丁醇产量,降低生产成本。通过对萃取剂的筛选与条件优化,确定纤维丁醇发酵的萃取剂为油醇,添加时间为发酵0 h,添加比例为1:1 (V/V)。该条件下发酵32 g/L糖浓度的玉米秸秆水解液,丁醇和总溶剂产量分别为3.28 g/L和4.72 g/L,比对照分别提高958.1%和742.9%。以D301树脂脱毒后5%总糖浓度的玉米秸秆水解液进行丁醇萃取发酵,丁醇和总溶剂产量分别达到10.34 g/L和14.72 g/L,发酵得率为0.31 g/g,与混合糖发酵结果相当。研究结果表明萃取发酵技术能够显著提高原料的利用率和丁醇产量,为纤维丁醇工业化生产提供了技术支撑。     

产琥珀酸工程菌株的发酵工艺条件优化

对实验室构建的产琥珀酸大肠杆菌工程菌株(E.coliQZ1111)进行发酵工艺条件研究。以AM1低盐培养基为基础,研究不同C、N源及其质量浓度,培养基初始pH和发酵温度等因素对琥珀酸的影响,并在5L发酵罐中进行了补料-分批发酵实验。优化后的发酵条件为葡萄糖20g/L,玉米浆10g/L,pH6.4,发酵温度37℃。在5L发酵罐中培养,琥珀酸产量达到47.9g/L。     

发酵产丁二酸过程中废弃细胞的循环利用

对厌氧发酵产丁二酸后的废弃细胞进行破壁处理,考察了以细胞水解液作为有机氮源重新用于丁二酸发酵的可行性。比较了超声破碎、盐溶、酶解3种方法破碎细胞获得的水解液作为氮源发酵产丁二酸的效果,结果表明酶解制得的细胞水解液效果最佳。以总氮含量为1.11g/L的酶解液(相当于10g/L酵母膏)作为氮源发酵,丁二酸产量可达42.0g/L,继续增大酶解液用量对耗糖、产酸能力没有显著提高。将细胞酶解液与5g/L酵母膏联用发酵36h后,丁二酸产量达75.5g/L,且丁二酸生产强度为2.10g/(L·h),比使用10g/L酵母膏时提高了66.7%。因此,厌氧发酵产丁二酸结束后的废弃细胞酶解液可以替代原培养基中50%的酵母膏用于发酵。     

Fermentative production of succinic acid from straw hydrolysate by Actinobacillus succinogenes

In this work, straw hydrolysates were used to produce succinic acid by Actinobacillus succinogenes CGMCC1593 for the first time. Results indicated that both glucose and xylose in the straw hydrolysates were utilized in succinic acid production, and the hydrolysates of corn straw was better than that of rice or wheat straw in anaerobic fermentation of succinic acid. However, cell growth and succinic acid production were inhibited when the initial concentration of sugar, which was from corn straw hydrolysate (CSH), was higher than 60 g l^?1. In batch fermentation, 45.5 g l^?1 succinic acid concentration and 80.7% yield were attained after 48 h incubation with 58 g l^?1 of initial sugar from corn straw hydrolysate in a 5-l stirred bioreactor. While in fed-batch fermentation, concentration of succinic acid achieved 53.2 g l^?1 at a rate of 1.21 g l^?1 h^?1 after 44 h of fermentation. Our work suggested that corn straw could be utilized for the economical production of succinic acid by A. succinogenes.     

Fermentative production of succinic acid from glucose and corn steep liquor byAnaerobiospirillum succiniciproducens

Anaerobiospirillum succiniciproducens requires expensive complex nitrogen sources such as yeast extract and polypeptone for its growth and succinic acid production. It was found thatA. succiniciproducens was able to grow in a minimal medium containing glucose when supplemented with corn steep liquor (CSL) as the sole complex nitrogen source. The concentration of CSL had a significant effect on the glucose consumption byA. succiniciproducens. When 10–15 g/L of CSL was supplemented, cells were grown to an OD₆₆₀ of 3.5 and produced 17.8 g/L succinic acid with 20 g/L glucose. These results are similar to those obtained by supplementing yeast extract and polypeptone, thereby suggesting that succinic acid can be produced more economically using glucose and CSL.     

Acetate production from whey lactose using co-immobilized cells of homolactic and homoacetic bacteria in a fibrous-bed bioreactor

Acetate was produced from whey lactose in batch and fed-batch fermentations using co-immobilized cells of Clostridium formicoaceticum and Lactococcus lactis. The cells were immobilized in a spirally wound fibrous sheet packed in a 0.45-L column reactor, with liquid circulated through a 5-L stirred-tank fermentor. Industrial-grade nitrogen sources, including corn steep liquor, casein hydrolysate, and yeast hydrolysate, were studied as inexpensive nutrient supplements to whey permeate and acid whey. Supplementation with either 2.5% (v/v) corn steep liquor or 1.5 g/L casein hydrolysate was adequate for the cocultured fermentation. The overall acetic acid yield from lactose was 0.9 g/g, and the productivity was 0.25 g/(L h). Both lactate and acetate at high concentrations inhibited the homoacetic fermentation. To overcome these inhibitions, fed-batch fermentations were used to keep lactate concentration low and to adapt cells to high-concentration acetate. The final acetate concentration obtained in the fed-batch fermentation was 75 g/L, which was the highest acetate concentration ever produced by C. formicoaceticum. Even at this high acetate concentration, the overall productivity was 0.18 g/(L h) based on the total medium volume and 1.23 g/(L h) based on the fibrous-bed reactor volume. The cells isolated from the fibrous-bed bioreactor at the end of this study were more tolerant to acetic acid than the original culture used to seed the bioreactor, indicating that adaptation and natural selection of acetate-tolerant strains occurred. This cocultured fermentation process could be used to produce a low-cost acetate deicer from whey permeate and acid whey.     

Economical succinic acid production from cane molasses by Actinobacillus succinogenes

In this work, production of succinic acid by Actinobacillus succinogenes CGMCC1593 using cane molasses as a low cost carbon source was developed. In anaerobic bottles fermentation, succinic acid concentration of 50.6+/-0.9 g l(-1) was attained at 60 h using an optimum medium containing molasses pretreated with sulfuric acid, resulting in a succinic acid yield of 79.5+/-1.1% and sugar utilization of 97.1+/-0.6%. When batch fermentation was carried out in a 5-l stirred bioreactor with pretreated molasses, 46.4 g l(-1) of succinic acid was attained at 48 h and faster cells growth was also observed. Fed batch fermentation was performed to minimize the substrate (sugar) inhibition effect, giving 55.2 g l(-1) of succinic acid and 1.15 g l(-1)h(-1) of productivity at 48 h. The present study suggests that the inexpensive cane molasses could be utilized for the economical and efficient production of succinic acid by A. succinogenes.     

Conversion of corn milling fibrous co-products into ethanol by recombinant Escherichia coli strains K011 and SL40

Corn hulls and corn germ meal were both evaluated as feedstocks for production of ethanol for biofuel. Currently, these fibrous co-products are combined with corn steep liquor and the fermentation bottoms (if available) and marketed as cattle feed. Samples were obtained from wet and dry corn mills. The corn hulls and germ meal were evaluated for starch and hemicellulose compositions. Starch contents were 12 to 32% w/w and hemicellulose (arabinoxylans) contents were 23 to 64% w/w. Corn fibrous samples were hydrolysed, using dilute sulphuric acid, into mixed sugar streams containing arabinose, glucose and xylose. Total sugar concentrations in the hydrolysate varied from 8.4 to 10.8% w/v. The hydrolysates were fermented to ethanol using recombinant E. coli strains K011 and SL40. Ethanol yields were 0.38 to 0.41g ethanol produced/g total sugars consumed and fermentations were completed in 60h or less. However, residual xylose was detected for each hydrolysate fermentation and was especially significant for fermentations using strain SL40. Strain K011 was a superior ethanologenic strain compared with strain SL40 in terms of both ethanol yield and maximum productivity.     

琥珀酸放线杆菌发酵培养基的优化

对琥珀酸放线杆菌(Actinobacillus succinogenes)CGMCC1593发酵产生琥珀酸培养基的主要成分,及其含量进行优化。通过单因素试验,得出发酵培养基中葡萄糖、酵母膏和玉米浆的含量对产生琥珀酸有显著影响;采用响应面法(RSM),得出多元二次回归方程拟合的三种因素与琥珀酸含量间的函数关系,并根据优化结果与实验,CGMCC1593产琥珀酸达到41.69g/L。     

耐铵型产琥珀酸放线杆菌的选育

以Actinobacillus succinogenes NJ113为出发菌株,经硫酸二乙酯(DES)诱变,在含8～20 g/L硫酸铵平板中筛选到一株耐铵型突变株YZ25,该菌株在含8 g/L硫酸铵培养基中厌氧发酵,琥珀酸产量达32.68 g/L,比出发菌提高了180.5%,对葡萄糖收率达65.4%,副产物乙酸、甲酸产量分别下降3.5%、28.7%,琥珀酸/乙酸比值由0.63提高到2.5。在7.5 L发酵罐中,用氨水调节pH分批实验,发酵34 h琥珀酸产量达27.13 g/L,较出发菌株提高了85.3%。     

Evaluation of Saccharomyces cerevisiae Y5 for ethanol production from enzymatic hydrolysate of non-detoxified steam-exploded corn stover

Saccharomyces cerevisiae Y5 was used to produce ethanol from enzymatic hydrolysate of non-detoxified steam-exploded corn stover, with and without a nitrogen source, and decreasing inoculum size. The results indicated that the ethanol concentration of 44.55 g/L, corresponding to 94.5% of the theoretical yield was obtained after 24 h, with an inoculum size of 10% (v/v) and nitrogen source (corn steep liquor, CSL) of 40 mL/L. With the same inoculum size, and without CSL, the ethanol concentration was 43.21 g/L, corresponding to 91.7% of the theoretical value after 60 h. With a decreased inoculum size of 5% (v/v), and without CSL, the ethanol concentration was 40.00 g/L, corresponding to 85.8% of the theoretical value after 72 h. The strain offers the potential to improve the economy of cellulosic ethanol production by simplifying the production process and reducing the costs associated with the process such as water, capital equipment and nutrient supplementation.