实验室模拟高负荷SPAC厌氧反应器运行

采用模拟废水, 对新型高负荷螺旋式自循环(Spiral automatic circulation, SPAC)厌氧反应器的运行性能进行了实验室模拟研究。结果表明: 在30oC, 水力停留时间(HRT)为12 h, 进水COD浓度从8000 mg/L升至20 000 mg/L的条件下, 反应器的COD去除率为91.1%~95.7%, 平均去除率为93.6％。在进水浓度为20 000 mg/L, HRT由5.95 h缩短至1.57 h的工况下, COD去除率从96.0%降低至78.7%, 反应器达到最高容积负荷率306 g COD/(L·d), 最大容积COD去除率240 g/(L·d), 最高容积产气率131 L/(L·d)。该反应器对基质浓度的连续提升具有良好的适应能力。进水COD浓度由8000 mg/L提升至20 000 mg/L时, 出水COD浓度一直处在较低水平(平均为852?mg/L), 容积COD去除率和容积产气率分别提高162%和119%。该反应器对HRT的连续缩短也有良好的适应能力。HRT由5.95 h缩短至1.57 h时,反应器容积COD去除率和容积产气率分别升高191%和195%。     

Use of the UASB reactor for the anaerobic treatment of stillage from sugar cane molasses

The feasibility of applying the UASB concept for the anaerobic treatment of stillage of distilleries in the sugar producing area of Argentina was subject to study. Results obtained in a 100-L UASB reactor treating stillages with COD values between 35 and 100 g COD/L are presented. Loading rates of up to 24 g COD/L/day were applied with an average COD removal of 75% and a biogas production of more than 9 L/L/day, with an average methane content of 58%. The settling velocity distribution of sludge particles would indicate a good formation of biomass pellets. System interruptions of months without feed and at ambient temperature (20-24 degrees C) were well tolerated.     

Anaerobic filter treatment of wastewater from mushroom cultivation on coffee pulp

Wastewater from the pre-treatment of coffee pulp for mushroom cultivation was treated in an anaerobic filter reactor at laboratory scale. The digester was fed semicontinuously with 300 to 500 ml of fresh medium per day. Organic loading rates (OLR) applied ranged widely during the study, from 0.48 to 62.93 g chemical oxygen demand (COD)/1 d. Treating wastewater from the pasteurization of pulp, the highest strength studied, a COD removal efficiency of up to 87% was attained at a high OLR of 42.868 g COD/I d; while a high biogas production rate (BPR) of 2.89 I/I d was also achieved. However, the average organic matter removal efficiency was 53% at an OLR of 23.921 g COD/1 d, which indicates that process efficiency should be improved to achieve a good quality effluent. BPR averaged 1.72 1/1 d, which shows that with technical-scale reactors, high biogas production could be obtained for further use in the pasteurizing process itself (energy recycling).     

Specific biogas production and role of packing medium in the treatment of rubber thread manufacturing industry wastewater

Wastewater from three rubber thread manufacturing industries collected from three different sampling points was characterised. The acidic wastewater (pH = 3.6 to 4.7) contains high levels of COD, BOD, nitrogen and zinc. The average COD:N:P ratio was 100:3.8:0.4 whereas the BOD:N:P ratio was 100:4.5:0.4 with more than sufficient amounts of N and P for anaerobic digestion using the up-flow anaerobic filter. The specific biogas yield ranged between 0.250 to 0.069 l CH₄/g COD added when the organic loading rate was altered from 2.0 to 14.0 g COD/l/d respectively. The biogas production rate and the biogas yield rate increased from 8.2 to 42.7 l/d and 0.97 to 1.50 l CH₄/l/d respectively, for the same organic loading rate. The N and P utilised ranged between 1.53 to 1.20 and 0.3 to 0.26 mg per 100 mg COD consumed respectively when the organic loading rate was increased from 2.0 to 14.0 g COD/l/d. The optimum COD:N:P ratio obtained for steady state operation of the up-flow anaerobic filter in this study for the rubber thread manufacturing wastewater was 100:1.3:0.3. Attached biomass was responsible for the removal of more than 70% of the COD in the wastewater when PU foam was used as the packing media.     

Influence of phenol additions on the efficiency of an anaerobic hybrid digester treating landfill leachate

Summary A hybrid digester with leachate as substrate was used to determine the influence of the addition of phenol. The phenol was increased stepwise from 2 to 25 mg/l and then to 30, 40, 50 and 60 mg/l leachate. Within 24 h the addition caused a significant decrease in the COD removal and biogas production while the methane content increased. Phenol loading was characterised by the accumulation of volatile fatty acids. With the continuous addition of phenol, a recovery time of 28 d was required for the performance to reach the control values. As the concentration was increased, the recovery time shortened to 8 d at 20 mg/l. At higher concentrations (>50 mg/l) the recovery time was found to increase to >60 d.     

Effect of initial COD concentration, nutrient addition, temperature and microbial acclimation on anaerobic treatability of broiler and cattle manure

In this study, anaerobic treatability and biogas generation potential of broiler and cattle manure were investigated. For this purpose, seven sets of anaerobic batch reactor experiments were performed using broiler and cattle manure and their mixtures in five different ratios (100% broiler; 75% broiler, 25% cattle; 50% broiler, 50% cattle; 25% broiler, 75% cattle; 100% cattle). These manure mixtures had two different initial chemical oxygen demand (COD) (12,000 and 53,500 mg/l) concentrations. The effects of initial COD concentration, nutrient and trace metal supplementation, microbial acclimation and digestion temperature were investigated. Results revealed that the efficiency of total COD removal was 32.0-43.3% and 37.9-50% for initial COD concentrations of 12,000 and 53,500 mg/l, respectively. The biogas yields observed for initial COD concentrations of 12,000 and 53,500 mg/l were 180-270 and 223-368 ml gas/g COD added, respectively. A decrease in biogas yield was observed as the fraction of broiler manure increased in mixture of broiler and cattle manure at initial COD values of 53,500 mg/l.     

Characteristics of the bioreactor landfill system using an anaerobic-aerobic process for nitrogen removal

A sequential upflow anaerobic sludge blanket (UASB) and air-lift loop sludge blanket (ALSB) treatment was introduced into leachate recirculation to remove organic matter and ammonia from leachate in a lab-scale bioreactor landfill. The results showed that the sequential anaerobic-aerobic process might remove above 90% of COD and near to 100% of NH4+ -N from leachate under the optimum organic loading rate (OLR). The total COD removal efficiency was over 98% as the OLR increased to 6.8-7.7 g/l d, but the effluent COD concentration increased to 2.9-4.8 g/l in the UASB reactor, which inhibited the activity of nitrifying bacteria in the subsequent ALSB reactor. The NO3- -N concentration in recycled leachate reached 270 mg/l after treatment by the sequential anaerobic-aerobic process, but the landfill reactor could efficiently denitrify the nitrate. After 56 days operation, the leachate TN and NH4+ -N concentrations decreased to less than 200 mg/l in the bioreactor landfill system. The COD concentration was about 200 mg/l with less than 8 mg/l BOD in recycled leachate at the late stage. In addition, it was found that nitrate in recycled leachate had a negative effect on waste decomposition.     

Cotton yarn and fabric finishing wastewater treatment in upflow anaerobic filter

Summary Wastewater from cotton yarn and fabric finishing was successfully treated in an upflow anaerobic filter at 35°C up to a COD loading of 1 Kgr COD/m³ · day; the COD removal varied from 50 to 90% and production of biogas was 0,2–0.4 L/g influent COD, having 70–80% CH₄. At higher COD loading biogas production stopped although COD removal remainedca 50%.     

Anaerobic filter treatment of fishery wastewater

Anaerobic treatment of wastewater from a selected seafood processing plant was conducted at organic loading rates (OLR) ranging from 0.3 to 1.8 kg chemical oxygen demand (COD)/m³.day and hydraulic retention times (HRT) ranging from 36 to 6 days. COD reduction decreased with increasing OLR. More than 75% COD reduction could be maintained up to an OLR of about 1 kg COD/m³.day with an HRT of 11 days. An OLR of 1.3 kg COD/m³.day corresponding to an HRT of 6.6 days gave maximal biogas productivity of 1.5 m³/m³.day or 1.3 m³ biogas/kg COD with a 65% COD reduction. If the HRT was kept constant at 11 days, an OLR of 1.3 kg COD/m³.day achieved maximal biogas productivity (1.1 m³/m³.day) and yield (0.75 m³/kg COD) and a 60% COD reduction for treatment of tuna condensate.P. Prasertsan and S. Jung are with the Department of Agro-Industry, Faculty of Natural Resources, Prince of Songkla University, Hatyai 90110, Thailand. K.A. Buckle is with the Department of Food Science and Technology, University of New South Wales, Kensington, NSW 2033, Australia.     

Anaerobic treatment of cassava starch extraction wastewater using a horizontal flow filter with bamboo as support

Small-scale sour starch agroindustry in Colombia suffer from absence of water treatment. Although starch processing plants produce diluted wastewater, it is a source of pollution and cause environmental problems to the nearby rural population. A laboratory scale anaerobic horizontal flow filter packed with bamboo pieces was evaluated for the treatment of cassava starch extraction wastewater. The wastewater used in the experimentation was the draining water of the starch sedimentation basin. The reactor was operated for 6 months. It was inoculated with a semi-granular sludge from an anaerobic UASB reactor of a slaughterhouse. Maximum organic loading rate (OLR) applied was 11.8g COD/L d without dilution of the wastewater. At steady state and maximum OLR applied, 87% of the COD was removed and a gas productivity of 3.7L/L d was achieved. The average biogas yield was 0.36L/g COD removed. Methane content in the biogas was in the range of 69-81%. The total suspended solids (TSS) removed were 67%. The relative high lactic acid content did not negatively influence the performance of the reactor. No perturbation due to cyanide (3-5mg/L) was observed during the reactor operation. The results obtained indicated that the anaerobic horizontal flow filter could be used efficiently for the treatment of wastewater from Colombian starch processing small-scale agroindustry.     

Impact of leachate recirculation and recirculation volume on stabilization of municipal solid wastes in simulated anaerobic bioreactors

The effects of leachate recirculation and the recirculation rate on the anaerobic treatment of domestic solid waste was investigated in three simulated landfill anaerobic bioreactors. A single pass reactor was operated without leachate recirculation while the other two reactors were operated with leachate recirculation. The leachate recirculation rate was 9 l/day (13% of the reactor volume) in Reactor₉, while the recirculation rate was 21 l/day (30% of the reactor volume), in Reactor₂₁. pH, chemical oxygen demand (COD), volatile fatty acids (VFA), ammonium–nitrogen (NH₄–N) total and methane gas measurements in leachate samples were regularly monitored. After 220 days of anaerobic incubation, it was observed that the pH, COD, VFA concentrations, methane gas productions and methane percentages in Reactor₉ were better than the single pass reactor and Reactor₂₁. When the leachate recirculation rate was increased to three times a decrease in pH, and an increase in VFA and COD concentrations were observed in Reactor₂₁. The COD values were measured as 47 000, 39 000 and 52 000 mg/l while the VFA concentrations were 15 000, 13 000 and 21 000 mg/l, respectively, in single pass, Reactor₉ and Reactor₂₁ after 220 days of anaerobic incubation. The values of pH were 5.89, 6.44 and 6.16, respectively, after anaerobic incubation. The mean methane percentages of single pass reactor, Reactor₉ and Reactor₂₁ were 30, 50 and 40%, respectively, after 50 days of incubation. Leachate recirculation reduced the waste stabilization time and was effective in enhancing methane gas production and improving leachate. However, leachate recirculation was not effective in removing ammonia from the leachate. The amounts of COD recovered by methane were 62.9, 162.3 and 94.6 g for single pass, Reactor₉ and Reactor₂₁, respectively, at the end of 220 days of anaerobic incubation.     

Effective anaerobic treatment of fresh leachate from MSW incineration plant and dynamic characteristics of microbial community in granular sludge

We investigated the treatment of fresh leachate from municipal solid waste incineration plants with high-strength organics using a lab-scale expanded granular sludge bed (EGSB) reactor. The reactor was operated at a mesophilic temperature (33 °C) for 118 days. The influent chemical oxygen demand (COD) of the leachate gradually increased to over 70,000 mg/L, and the organic loading rate increased to 18 kg COD/(m³?day). An average COD removal efficiency of 86.7 % was achieved when the reactor was fed with raw leachate, which suggests the feasibility of the EGSB process for leachate treatment. The microbial communities in the sludge from the reactor during the trial operation were constructed by denaturing gradient gel electrophoresis, clone libraries, and real-time quantitative polymerase chain reaction. The dominant group for archaea was Methanosaeta, with 68.4 % proportion at the start of the operation, and then changed to Methanosarcina, with a proportion of 62.3 %, after 118 days of operation. The dominant group of eubacteria was confirmed to be Firmicutes throughout the operation process, with the proportion increasing from >50 to 81.2 %. Almost all the operational taxonomic units of Firmicutes belonged to the order Clostridiales, with characteristic spore formation. The microbial diversity of the population was low under raw leachate as feed in the reactor. The dynamics of the microbial community in the anaerobic granular sludge was discussed relating with the operating status of the EGSB reactor.     

The effect of landfill age on municipal leachate composition

The influence of municipal landfill age on temporal changes in municipal leachate quality on the basis of elaboration of 4 years monitoring of leachate from landfill in Wysieka near Bartoszyce (Poland) is presented in this study. In leachate, concentrations of organic compounds (COD, BOD(5)), nutrients (nitrogen, phosphorus), mineral compounds, heavy metals and BTEX were investigated. It was shown that the principal pollutants in leachate were organics and ammonia - as landfill age increased, organics concentration (COD) in leachate decreased from 1,800 mg COD/l in the second year of landfill exploitation to 610 mg COD/l in the sixth year of exploitation and increase of ammonia nitrogen concentration from 98 mg N(NH)/l to 364 mg N(NH4) /l was observed. Fluctuation of other indexes (phosphorus, chlorides, calcium, magnesium, sulfate, dissolved solids, heavy metals, BTEX) depended rather on season of the year (seasonal variations) than landfill age. Moreover, the obtained data indicate that despite of short landfill's lifetime some parameters e.g. high pH (on average 7.84), low COD concentration (<2,000 mg COD/l), low BOD(5)/COD ratio (<0.4) and low heavy metal concentration, indicated that the landfill was characterized by methanogenic conditions already at the beginning of the monitoring period.     

Screening and degradation performances of dominant strains in high-salinity landfill leachate

In order to enhance the removal efficiency of chemical oxygen demand (COD) in the high-salinity landfill leachate, the dominant strains were isolated from high-salinity landfill leachate. The dominant strains and bacteria consortium were screened for COD treatment potential using an aerobic COD concentration decrease test. Ten strains, TJ01–TJ10, were isolated, of which six strains TJ02, TJ03, TJ05, TJ06, TJ07, and TJ09 were found to have higher COD removal when the single bacteria were added, all more than 20%. The most effective combination was TJ06 + TJ09; the COD removal efficiency reached 45.57%. 16S rDNA gene sequence analysis revealed that TJ06 and TJ09 belonged to the genus Bacillus. The effects of the dominant bacteria consortium on the high-salinity landfill leachate varied with pH value and the volume fraction of leachate. The COD removal efficiencies maintained higher when the pH value was 6–8 and the volume fractions of leachate were less than 80%. The result also suggested that there is little effect on the growth of TJ06 and TJ09 when the range of Cl⁻ concentration is 0–30,000 mg/L.     

Potential of biogas recirculation to enhance biomass accumulation on supporting media

Two lab-scale anaerobic hybrid reactors (AHR) were operated to investigate the effect of recirculated biogas on the development of biomass on supporting media during the start-up. The reactor comprised of two distinct zones; sludge bed on the bottom and packed bed using nylon fiber as the media on the upper half of the reactor. Both reactors were continuously fed with cassava starch wastewater. The organic loading rate (OLR) was increased from 0.3 to 5.5 g COD/L/day by gradually decreasing the hydraulic retention time (HRT) from 37 to 3.5 days in two months. The biogas at 2.6 L/L/day was recirculated merely in the first month of the operation in order to allow the attached biomass to grow according to the organic matters present in the reactor at the final stage of the start up. Chemical oxygen demand (COD) removal efficiency of over 80% was achieved throughout the study. The result demonstrated a better COD removal efficiency for the reactor with biogas recirculation, especially at low HRTs. The amounts of biomass accumulated on the media in both reactors were slightly different with 11.9 gVSS found on the one with biogas recirculation compared to 9.8 gVSS on the other. In addition, 16.3% increase of the sludge bed was achieved with biogas recirculation as opposed to 9% in the control one. The attached biomass activity test indicated a greater amount and more favorable ratio of the methanogenic bacterial group on the media with the recirculation correlating well to a relatively higher methane content in biogas. As a result, the recirculation of biogas has a potential of improving the characteristics of the AHR especially in terms of biomass accumulation.     

Electricity generation from young landfill leachate in a microbial fuel cell with a new electrode material

This study aims at evaluating the performance of a two-chambered continuously fed microbial fuel cell with new Ti–TiO₂ electrodes for bioelectricity generation from young landfill leachate at varying strength of wastewater (1–50 COD g/L) and hydraulic retention time (HRT, 0.25–2 days). The COD removal efficiency in the MFC increased with time and reached 45 % at full-strength leachate (50 g/L COD) feeding. The current generation increased with increasing leachate strength and decreasing HRT up to organic loading rate of 100 g COD/L/day. The maximum current density throughout the study was 11 A/m² at HRT of 0.5 day and organic loading rate of 67 g COD/L/day. Coulombic efficiency (CE) decreased from 57 % at feed COD concentration of 1 g/L to less than 1 % when feed COD concentration was 50 g/L. Increase in OLR resulted in increase in power output but decrease in CE.     

Impact of landfill leachate on the co-treatment of domestic wastewater

Landfill leachate and domestic wastewater were co-treated in batch activated sludge reactors and the ratio of leachate varied from 5 to 20% (v/v). The leachates had a non-biodegradable COD fraction of at least 20%. An increase in leachate adversely affected the co-treatment and it was concluded that the leachate ratio should never exceed 20% of the total wastewater or 50% of the initial COD. The initial Total Kjeldahl Nitrogen (TKN) and the free ammonia level were identified as factors influencing the completion of nitrification.     

Evaluation of a upflow anaerobic sludge blanket reactor with partial recirculation of effluent used to treat wastewaters from pulp and paper plants

The main purpose of this study was to evaluate the performance of a UASB reactor treating diluted black liquor from a Kraft pulp mill, which simulates an unbleached Kraft plant wastewater, under different operational conditions, including partial recycling of the effluent. The reactor's performance was evaluated from the standpoint of COD, pH, volatile acid concentration, alkalinity, concentration of methane in the biogas, and microbiological examinations of the sludge. Without recirculation the reduction of the HRT from 36 to 30h did not significantly affect the average COD removal efficiency. The parameter displaying the greatest variation was the average concentration of effluent volatile acids, which increased by 16%. With recirculation the reduction of the HRT from 30 to 24h increased the average COD removal efficiency from 75% to 78%. In this case, the average effluent alkalinity also showed an increase. The use of partial recirculation of the effluent did not improve significantly the COD removal under the operational conditions tested in this work, but it was possible to operate the reactor with lower hydraulic retention time without disintegration of the granules.     

Powdered activated carbon added biological treatment of pre-treated landfill leachate in a fed-batch reactor

Biological treatment of landfill leachate usually results in low treatment efficiencies because of high chemical oxygen demand (COD), high ammonium-N content and also presence of toxic compounds such as heavy metals. A landfill leachate with high COD content was pre-treated by coagulation-flocculation followed by air stripping of ammonia at pH = 12. Pre-treated leachate was biologically treated in an aeration tank operated in fed-batch mode with and without addition of powdered activated carbon (PAC). PAC at 2 g l^–1 improved COD and ammonium-N removals resulting in nearly 86% COD and 26% NH₄-N removal.     

Petroleum coke supplementation for enhanced biogas production and phosphate removal under mesophilic conditions

The use of carbon-based conductive materials has been shown to lead to an increase in biogas and methane yields during anaerobic digestion (AD). The effect of these additives on AD using synthetic substrates has been extensively studied, yet their significance for wastewater sludge digestion has not been adequately investigated. Therefore, the aim of this research was to optimize the concentration of petroleum coke (PC) that is a waste by-product of oil refineries, for the anaerobic digestion of wastewater sludge and investigation of phosphate removal in the AD process in the mesophilic temperature range. According to the results of the experiments, supplementing reactors with PC could significantly improve biogas and methane production. Supplementation of reactors with 1.5 g/L PC led to 23.40 ± 0.26% and 42.55 ± 3.97% increase in biogas production and methane generation, respectively. Moreover, the average volatile solids (VS), phosphate, and chemical oxygen demand (COD) removals were 43.43 ± 0.73, 46.74 ± 0.77%, and 60.40 ± 0.38%, respectively.