Hydrolysis of cellulose in fed-batch culture by Cl. thermocellum: A way to increase speed of cellulose hydrolysis

Summary Fed batch fermentation ofClostridium thermocellum gives improved conversion rates and high ethanol concentration in the broth; 8.5 g/l of ethanol were obtained in 60 hours with a maximum ethanol productivity of 1.0 g/l h.     

The effect of aeration on D-xylose fermentation byPachysolen tannophilus,Pichia stipitis,Kluyveromyces marxianus andCandida shehatae

Summary The fermentation of D-xylose byPachysolen tannophilus Y2460,Pichia stipitis Y7124,Kluyveromyces marxianus Y2415 andCandida shehatae Y12878 was investigated in aerobic, anaerobic and microaerophilic batch cultures. The aeration rate greatly influenced the fermentations; growth, rate of ethanol production and oxidation of ethanol are affected. Of the strains tested,Pichia stipitis appears superior; under anaerobic conditions it converts D-xylose (20 g/l) to ethanol with a yield of 0.40 g/l and it exhibits the highest ethanol specific productivity (3.5 g of ethanol per g dry cell per day) under microaerophilic conditions.     

Vertical Rotating Immobilized Cell Reactor of the bacteriumZymomonas mobilis for stable long-term continuous ethanol production

Summary Vertical Rotating Immobilized Cell Reactor was designed and built for glucose conversion into ethanol. Immobilized biomass units withZ. mobilis cells attached into polyurethane foam discs were fixed along a rotating shaft inside the bioreactor. The effect of rotation speed on the concentration of immobilized biomass was studied. Stability of the bioreactor over long-term operation was dependent on the concentration of the immobilized biomass. With fermentation carried out at 6 rpm a constant active immobilized cell concentration of only 34.5 g/l was maintained and used to convert up to 140 g glucose/l into more than 70 g ethanol/l with a volumetric ethanol productivity of 63 g/l/h.     

Ethanol production byClostridium thermocellum SS8, a newly isolated thermophilic bacterium

Summary Clostridium thermocellum SS8, has a broad substrate spectrum. It produced 0.25–0.29 g. of ethanol per g. of cellulose consumed. Cellulose fermentation was repressed by both glucose and cellobiose. pH had an effect on ethanol productivity at high substrate concentration. Best results were obtained at 30 g/l with an E/S and E/A ratios of 0.29 and 2.4 respectively.     

Behaviors of southern red oak hemicelluloses and lignin in a mild sulfuric acid hydrolysis

Removal and modification of southern red oak hemicelluloses and lignin in a 0.05%(w/v) sulfuric acid hydrolysis were investigated. The hydrolysis profile was to raise the reaction from room temperature to 150 degrees C for in 38 min and to extend the hydrolysis at 150 degrees C for 1 h. At the end of the hydrolysis, 25.5% of red oak components were dissolved, of which 58% was xylose and 17% lignin. As the hydrolysis proceeded from room temperature to 150 degrees C, a part of red oak xylan was removed to yield an oligomer fraction having maximal yield and average molecular weight of 3460 at 150 degrees C. This fraction and the bulk xylan extracted during the first 30 min at 150 degrees C were further degraded to give a lower molecular weight oligomer fraction, of which the yield and average molecular weight (2610) were highest at the end of the bulk removal of xylan. Red oak lignin, syringyl and guaiacyl units in particular, was increasingly removed with the progress of the hydrolysis. Lignin derivatives and a part of red oak extractives soluble in the hydrolysate were identified.     

Ethanol and sugar tolerance of Candida shehatae

Summary Candida shehatae ATCC 22984 fermented solutions of up to 260 g/L sugars derived by hydrolysis of whole barley. These solutions contained hexose: pentose 7030, the hexose being mainly glucose from the barley starch and the pentose being mainly xylose. At sugar concentrations of 180 g/L, fermentation was complete in 72 h, yielding 84 g/L ethanol, 0.47 g ethanol/g sugar. At 260 g/L, fermentation ceased when ethanol concentration reached 100 g/L, but resumed when the ethanol was removed by vacuum distillation, to yield finally 0.50 g ethanol/g sugar.     

Ethanol production from Jerusalem artichoke juice using flocculent cells of Kluyveromyces marxianus

Summary Flocculent cells ofKluyveromyces marxianus SM 16-10 were used for batch production of ethanol from the inulin sugars derived from Jerusalem artichoke tubers. Using 20% initial sugar concentration, a maximum ethanol concentration of 92 g/l was achieved in 7 h, when the flocculent cell concentration was 30 g dry wt./l bioreactor volume. The same flocculent cells were used repeatedly for 7 batch runs starting with fresh medium at the beginning of each run. The ethanol yield was found to be almost constant at about 94% of the theoretical for all the 7 batch cycles, while the maximum ethanol production rate increased from 17.21 g ethanol/1/h during the first batch run to 21 g ethanol/1/h during the last batch run.     

Fuel ethanol from corn residue prehydrolysate by a patented ethanologenicEscherichia coli B

Summary The hemicellulose component of corn cobs was completely hydrolyzed by treatment with dilute sulphuric acid. HPLC analysis showed the prehydrolysate to contain 36g/L xylose; 7g/L arabinose; 6g/L glucose and 4.2g/L acetic acid. The patented genetically engineered ethanologenEscherichia coli B (ATCC 11303 pLOI 297) exhibited high performance characteristics with a synthetic model medium in which the pH was controlled at 7 in order to minimize sensitivity to acetic acid. With the synthetic medium, fermentation was completed in 36h and the process yield was 0.49g/g, equivalent to 96% max. theoretical conversion efficiency. However, with the supplemented corn cob prehydrolysate medium, about 20% of the sugar remained unfermented after 8 days, with a conversion efficiency of <40%. Treatment of the prehydrolysate with calcium hydroxide did not result in a significant improvement in fermentation performance. Based on the poor yield, it is concluded that, under the test conditions employed, this patented ethanologen does not qualify as a potential process biocatalyst for the production of fermentation fuel ethanol from corn residue hemicellulose hydrolysate prepared with dilute sulphuric acid.     

Conversion of sugar-beet particles to ethanol by the bacteriumZymomonas mobilis in solid-state fermentation

Summary The possibility of usingZymomonas mobilis as the microorganism, in solid-state fermentation of sugar-beet particles was investigated. The major factors affecting the process were investigated and related to ethanol yield and productivity. Ethanol yield of 0.48 g/g sugar, volumetric productivity of 12 g/L h, and final ethanol concentration of 130 g/L show the good performance ofZ.mobilis in a solid-state fermentation.     

The effect of temperature,pH, and initial glucose concentration on the kinetics of ethanol production by Zymomonas mobilis in batch fermentation

Summary Zymomonas mobilis, strain ATCC 10988, was used to evaluate the effects of pH (5.0 to 8.0), temperature (30°C to 40°C), and initial glucose concentration (75 g/l to 150 g/l) on the kinetics of ethanol production from glucose using batch fermentation. Specific ethanol production rate was maximum and nearly constant over a pH range of 6.0 to 7.5. End-of-batch ethanol yield and specific growth rate were insensitive to pH in the range of 5.0 to 7.5. End-of-batch ethanol yield was maximum and nearly constant between 30°C and 37°C but decreased by 24% between 37°C and 40°C. All other kinetic parameters are greatest at 34°C. End-of-batch ethanol yield is maximum at an initial glucose concentration of 100 g/l. Specific growth rate reaches a maximum at 75 g/l, but specific ethanol production rate decreases throughout the range. The optimum initial glucose concentration of 100 g/l gives the highest ethanol yield at a specific ethanol production rate less than 10% below the maximum observed.     

Could the improvements in the alcoholic fermentation of high glucose concentrations by yeast immobilization be explained by media supplementation?

Summary The maximal concentration of ethanol produced during the fermentation of 320 g/l glucose bySaccharomyces bayanus was higher when the yeast cells were immobilized either by adsorption on celite or by entrapment in k-carrageenan beads (from 10.5% with free cells up to 14.5% and 13.1% (v/v) respectively). This increase was due to medium supplementation with the compounds present in the immobilization supports.     

The kinetics of ethanol production by Zymomonas mobilis on fructose and sucrose media

Summary Z.mobilis is strain ZM4 was grown on 250 g/l fructose and sucrose media in batch culture and on 100 and 150 g/l sucrose media in continuous culture. With fructose, a significant reduction in the growth rate and the cell yield was apparent although the other kinetic parameters were similar to those previously reported for fermentation of glucose. With sucrose the major differences were a reduction in ethanol yield, (due to levan formation) and a lower final ethanol concentration. Ethanol inhibition of sucrose metabolism occurred at relatively low ethanol concentrations compared to those inhibiting glucose metabolism.     

Kinetics of repeated batch production of ethanol by immobilized growing yeast cells

Summary Kinetic and yield parameters for growth and ethanol production from sucrose (100 g/l) bySaccharomyces cerevisia entrapped in K-carrageenan and calcium alginate were identical to those of free cells. Cell leakage was minimum with calcium alginate gel. For the sixth batch, 4.51 g/lh ethanol productivity (94% conversion of sucrose) was obtained; 60.5 g/l of ethanol was obtained from 200 g/l sucrose with 83.2% conversion, indicating inhibition effects.     

Lignin and extractives derived inhibitors in the 2,3-butanediol fermentation of mannose-rich prehydrolysates

Summary Mannose, the predominant sugar in southern pine water prehydrolysates, has been fermented to 2,3-butanediol by Klebsiella pneumoniae AU-1-d3. Lignin derivatives and extractives soluble in the water prehydrolysates, however, hindered the butanediol fermentation. Treatments with sequential lime-sulfuric acid or mixed bed ion resins facilitated the butanediol fermentation of the water prehydrolysates. Fermentation inhibitors derived from southern pine lignin and extractives were identified.     

Fermentation of cellobiose and wood sugars to ethanol byCandida shehatae andPichia stipitis

Summary Three pentose fermenting yeast strains ofCandida shehatae and three ofPichia stipitis were examined for their ability to produce ethanol from cellobiose and from sugars liberated by hydrolysis of lignocellulosic biomass. All of thePichia strains tested produced some ethanol;P. stipitis CBS 5776 gave the highest yield: 10.3 g/L on complete fermentation of 25 g/L cellobiose within 48 hours. This yeast also produced considerably more ethanol from the wood sugar mixture.     

Continuous production of ethanol from a glucose,xylose and arabinose mixture by a flocculent strain ofPichia stipitis

Summary Enhanced rates of continuous ethanol production by a flocculent strain ofPichia stipitis from a sugar mixture (xylose 75%, glucose 20%, arabinose 5%) were attained using a single-stage gas lift tower fermentor. With a substrate feed of 50g/l, the biomass accumulated at a level near 50g/l, showed a maximum and stable ethanol productivity of 10.7 g/l.h, with a substrate conversion of 80%; the ethanol yield reached 0.41g/g. In these operating conditions, similar performances were obtained when D.xylose alone was supplied.     

Comparative evaluation of ethanol production by xylose-fermenting yeasts presented high xylose concentrations

Summary Three strains ofPichia stipitis and three ofCandida shehatae were compared withPachysolen tannophilus in their abilities to ferment xylose at concentrations as high as 200 g/L when subjected to both aerobic and microaerophilic conditions. Evaluations based on accumulated ethanol concentrations, ethanol productivities, xylose consumption, and ethanol and xylitol yields were determined from batch culture time courses. Of the strains considered,P.stipitis NRRL Y-7124 seemed most promising since it was able to utilize all but 7 g/L of 150 g/L xylose supplied aerobically to produce 52 g/L ethanol at a yield of 0.39 g per gram xylose (76% of theoretical yield) and at a rate comparable to the fastest shown byC.shehatae NRRL Y-12878. For all strains tested, fermentation results from aerobic cultures were more favorable than those from microaerophilic cultures.The mention of firm names or trade products does not imply that they are endorsed or recommended by the U.S. Department of Agriculture over other firms or similar products not mentioned.     

Kinetic studies on alac-containing strain ofZymomonas mobilis

Summary Batch and continuous culture studies have been carried out on a strain ofZ.mobilis (ZM6306) which can convert lactose directly to ethanol. Previous strain development has established that thelac operon encoded on the transposon Tn951 can be expressed inZ.mobilis. Using a medium containing 80 g/l glucose and 40 g/l lactose, it was found that strain ZM6306 could convert about 13 g/l lactose to 4 g/l ethanol and 6 g/l galactose in continuous culture. Further lactose conversion is likely with increased cell concentration using a cell recycle system.     

Ethanol production from cassava and sago starch using Zymomonas mobilis

Summary Cassava and sago starch were evaluated for their feasibilities as substrates for ethanol production using Zymomonas mobilis ZM4 strain. Before fermentation, the starch materials were pretreated employing two commercial enzymes, Termamyl (thermostable -amylase) and AMG (amyloglucosidase). Using 2 l/g of Termamyl and 4 l/g of AMG, effective conversion of both cassava and sago starch into glucose was found with substrate concentration up to 30%(w/v) dry substances. Fermentation study performed using these starch hydrolysates as substrates resulted in ethanol yield at an average of 0.48g/g by Z. Mobilis ZM4.     

Fed-batch fermentation of glucose to acetate by an improved strain ofClostridium thermoaceticum

The fed-batch approach to the production of acetate from glucose by an improved strain ofClostridium thermoaceticum resulted in better performance than the batch fermentation, especially in media containing an excess (3X) of nutrients and trace salts. At pH 6.6, 46 g/l acetic acid was produced in 192 hours with 93% substrate utilization. In contrast, batch fermentation under similar conditions resulted in a maximum of 35 g/l acetic acid with less than 82% substrate utilization.