Purification and Characterization of a Thermostable Alkaline Protease from Alkalophilic Thermoactinomyces sp. H8682

Protease secreted into the culture medium by alkalophilic Thermoactinomyces sp. HS682 was purified to an electrophoretically homogeneous state through only two chromatograhies using Butyl-Toyopearl 650M and SP-Toyopearl 650S columns. The purified enzyme has an apparent relative molecular mass of 25, 000 according to gel filtration on a Sephadex G-75 column and SDS-PAGE and an isoelectric point above 11.0.

Its proteolytic activity was inhibited by active-site inhibitors of serine protease, DFP and PMSF, and metal ions, Cu²⁺ and Hg²⁺. The enzyme was stable toward some detergents, sodium perborate, sodium triphosphate, sodium-n-dodecylbenzenesulfonate, and sodium dodecyl sulfate, at a concentration of 0.1% and pH 11.5 and 37°C for 60 min. The optimum pH was pH 11.5–13.0 at 37°C and the optimum temperature was 70°C at pH 11.5. Calcium divalent cation raised the pH and heat stabilities of the enzyme. In the presence of 5 mM CaCl₂, it showed maximum proteolytic activity at 80°C and stability from pH 4–12.5 at 60°C and below 75°C at pH 11.5. The stabilization by Ca²⁺ was observed in secondary conformation deduced from the circular dichroic spectrum of the enzyme. The protease hydrolyzed the ester bond of benzoyl leucine ester well. The amino acid terminal sequence of the enzyme showed high homology with those of Microbiol serine protease, although alanine of the NH₂-terminal amino acid was deleted.     

Production and Purification of a New Chillproofing Enzyme and Its Properties

Chillproofing enzyme was obtained from broth cultures of Serratia marcescens B–103. This extracellular enzyme, tentatively, named the S-enzyme was highly purified from the culture supernatant by ammonium sulfate precipitation, ethanol fractionation, gel filtration on Sephadex G–200 and column chromatography on DEAE-Sephadex A–50.

The purified preparation appeared homogeneous on a ultracentrifugation with a sedimentation coefficient of 3.14 S and a molecular weight of 38,000~45,000 determined by the method of Whitaker.

The S-enzyme hydrolyzed various proteins at pH 4~6 and at low temperature hydrolyzed nitrogenous substances which may cause chill haze in beer. So the chillproofing activity of the S-enzyme may be due to its proteolytic activity.

The S-enzyme was stable at 4°C at pH 5~10.5. It was completely inactivated by heating at 60°C for 10 min, and was inactivated by Hg²⁺ and Pb²⁺ and activated by Mn²⁺, Ca²⁺. Mg²⁺ and Zn²⁺     

Microbial Production of L-Tyrosine by an n-Paraffin-grown Bacterium

Four mannanases (Mannanases I, II, III, and IV) were isolated from the culture filtrate of a Streptomyces sp. by ion exchange chromatography. Mannanase IV was the main component and accounted for 64.4% of the total activity of the four mannanases. Mannanase IV was further purified by gel filtration, and the purified Mannanase IV was homogeneous on disc-gel electrophoretic analysis.

Optimum pH and temperature for the activity of Mannanase IV were 6.8 and 57°C, respectively. It was stable at temperatures up to 45°C when examined at pH 6.8 for 30min, and lost only 15% of its activity at 70°C for 30min at pH 6.8. The isoelectric point and molecular weight were pH 3.65 and 42,900, respectively. The enzyme was strongly inactivated by Al³⁺, Hg²⁺, Fe²⁺, Fe³⁺, Cd²⁺, Ag⁺, Sn²⁺, and Cu²⁺, and completely inhibited by iodoacetic acid and N-bromosuccinimide. The enzyme hydrolyzed mannotriose to mannose and mannobiose, but did not hydrolyze mannobiose.     

Purification and partial characterization οf a new β-xylosidase from Humicola grisea var. thermoidea

Summary The thermophilic fungus Humicola grisea var. thermoidea produces a mycelium-associated β-xylosidase activity when grown in liquid-state cultures on media containing oat spelt xylan as the carbon source. The β-xylosidase was purified to apparent homogeneity by gel filtration and anion exchange chromatography. Its molecular weight was 37 and 50 kDa, as determined by MALDI/TOF mass spectrometry and SDS-PAGE, respectively. The purified enzyme exhibited maximum activity at 55 °C and pH 6.5. It was also active at pH 8.8, retaining 60% of its activity after 6 h of incubation at 50 °C. β-xylosidase was strongly inactivated by NBS and slightly activated by DTT and β-mercaptoethanol. The enzyme was highly specific for PNPX as the substrate. The purified β-xylosidase showed K _m and V _max values of 1.37 mM and 12.98 IU ml⁻¹, respectively.     

Induction of an Increase in Nerve Growth Factor Content in the Cell-conditioned Medium of Mouse L-M Cells by Basic Peptides

Thermostable trehalose synthase, which catalyzes the conversion of maltose into trehalose by intramolecular transglucosylation, was purified from a cell-free extract of the thermophilic bacterium Thermus aquaticus ATCC 33923 to an electrophoretically homogeneity by successive column chromatographies. The purified enzyme had a molecular weight of 105,000 by SDS-polyacrylamide gel electrophoresis and a pI of 4.6 by gel isoelectrofocusing. The N-terminal amino acid of the enzyme was methionine. The optimum pH and temperature were pH 6.5 and 65°C, respectively. The enzyme was stable from pH 5.5 to 9.5 and up to 80°C for 60min. The trehalose synthase from Thermus aquaticus is more thermoactive and thermostable than that from Pimelobacter sp. R48. The yield of trehalose from maltose by the enzyme was independent of the substrate concentration, and tended to increase at lower temperatures. The maximum yield of trehalose from maltose by the enzyme reached 80–82% at 30–40°C. The activity was inhibited by Cu²⁺ , Hg²⁺, Zn²⁺, and Tris.     

Purification and Properties of Phospholipase D from Actinomadura sp. Strain No. 362

An extracellular phospholipase D from Actinomadura sp. Strain No. 362 was purified about 430-fold from the culture filtrate. The purified enzyme preparation was judged to be homogeneous on polyacrylamide gel electrophoresis. The molecular weight and isoelectric point of the enzyme were estimated to be about 50,000—60,000 and 6.4, respectively. The enzyme was most active at pH 5.5 and 50°C in the presence of Triton X-100, but showed the highest activity at pH 7.0 and 60 — 70°C in its absence. The enzyme was stable up to 30°C at pH 7.2 and also stable in the pH range of 4.0 to 8.0 on 2 hr incubation at 25°C. With regard to substrate specificity, this enzyme hydrolysed lecithin best among the phospholipids tested. It was activated by Fe^{3 +}, Al³⁺, Mn^{2 +}, Ca^{2 +}, diethyl ether, sodium deoxycholate and Triton X-100, but was inhibited by cetyl pyridinium chloride and dodecylsulfate.     

Immobilization of Bacillus licheniformis 5A1 milk-clotting enzyme and characterization of its enzyme properties

Milk-clotting enzyme from Bacillus licheniformis 5A1 was immobilized on Amberlite IR-120 by ionic binding. Almost all the enzyme activity was retained on the support. The immobilized milk-clotting enzyme was repeatedly used to produce cheese in a batch reactor. The production of cheese was repeated 5 times with no loss of activity. The specific activity calculated on a bound-protein basis was slightly higher than that of free enzyme. The free and immobilized enzyme were highly tolerant to repeated freezing and thawing. The optimum temperature for milk-clotting activity was 70 °C with the free enzyme whereas, it was ranged from 70 to 80 °C with the immobilized milk-clotting enzyme. The activation energy (E _A) of the immobilized milk-clotting enzyme was lower than the free enzyme (E _A = 1.59 and 1.99 Kcal mol⁻¹ respectively). The immobilized milk-clotting enzyme exhibited great thermal stability. The milk-clotting optimum pH was 7.0 for both free and immobilized enzyme. The Michaelis constant K _m of the immobilized milk-clotting enzyme was slightly lower than the free enzyme.     

Purification and characterization of polygalacturonase produced by thermophilic Thermoascus aurantiacus CBMAI-756 in submerged fermentation

An extracellular polygalacturonase was isolated from 5-day culture filtrates of Thermoascus aurantiacus CBMAI-756 and purified by gel filtration and ion-exchange chromatography. The enzyme was maximally active at pH 5.5 and 60–65°C. The apparent K _m with citrus pectin was 1.46 mg/ml and the V _max was 2433.3 μmol/min/mg. The apparent molecular weight of the enzyme was 30 kDa. The enzyme was 100% stable at 50°C for 1 h and showed a half-life of 10 min at 60°C. Polygalacturonase was stable at pH 5.0–5.5 and maintained 33% of initial activity at pH 9.0. Metal ions, such as Zn⁺², Mn⁺², and Hg⁺², inhibited 50, 75 and 100% of enzyme activity. The purified polygalacturonase was shown to be an endo/exo-enzyme, releasing mono, di and tri-galacturonic acids within 10 min of hydrolysis.     

Purification and Characterization of an Arylamine N-Acetyltransferase from the Bacteria Aeromonas hydrophilia

N-acetyltransferase from Aeromonas hydrophilia was purified by ultrafiltration, DEAE-Sephacel, gel filtration chromatography on Sephadex G-100, and DEAE-5pw on high performance liquid chromatography, as judged by sodium dodecyl sulfate-polyacrylamine gel electrophoresis (SDS-PAGE) on a 12.% (wt/vol) slab gel. The enzyme had a molecular mass 44.9 kDa. The purified enzyme was thermostable at 37°C for 1 h with a half-life 28 min at 37°C, and displayed optimum activity at 37°C and pH 7.0. The K _m and V _max values for 2-aminofluorene were determined to be 0.896 mM and 2.456 nmol/min/mg protein, respectively. Among a series of divalent cations and salts, Zn²⁺, Ca²⁺, and Fe²⁺ were demonstrated to be the most potent inhibitors. Received: 10 November 1997 / Accepted: 17 February 1998     

A Review of: “HPLC of Biological Macromolecules (Methods and Applications) K.M. Goodring F.E. Regnier,Eds Marcel Dekker,New York, 1990; hardbound, 676 pages, $150”

An ionically unbound and thermostable polyphenol oxidase (PPO) was extracted from the leaf of Musa paradisiaca. The enzyme was purified 2.54-fold with a total yield of 9.5% by ammonium sulfate precipitation followed by Sephadex G-100 gel filtration chromatography. The purified enzyme exhibited a clear single band on native polyacrylamide gel electrophoresis (PAGE) and sodium dodecyl sulfate (SDS) PAGE. It was found to be monomeric protein with molecular mass of about 40 kD. The zymographic study using crude extract as enzyme source showed a very clear band around 40 kD and a faint band at around 15 kD, which might be isozymes. The enzyme was optimally active at pH 7.0 and 50°C temperature. The enzyme was active in wide range of pH (4.0–9.0) and temperature (30–90°C). From the thermal inactivation studies in the range 60–75°C, the half-life (t_1/2) values of the enzyme ranged from 17 to 77 min. The inactivation energy (Ea) value of PPO was estimated to be 91.3 kJ mol^?1. It showed higher specificity with catechol (K_m = 8 mM) as compared to 4-methylcatechol (K_m = 10 mM). Among metal ions and reagents tested, Cu²⁺, Fe²⁺, Hg²⁺, Mn²⁺, Ni²⁺, protocatechuic acid, and ferrulic acid enhanced the enzyme activity, while K⁺, Na⁺, Co²⁺, kojic acid, ascorbic acid, ethylenediamine tetraacetic acid (EDTA), sodium azide, β-mercaptoethanol, and L-cysteine inhibited the activity of the enzyme.     

Enzymatic Properties of Alkaline Proteinase from Aspergillus candidus

Some enzymatic properties were examined with the purified alkaline proteinase from Aspergillus candidus. The isoelectric point was determined to be 4.9 by polyacrylamide gel disc electrofocusing. The optimum pH for milk casein was around 11.0 to 11.5 at 30°C. The maximum activity was found at 47°C at pH 7.0 for 10 min. The enzyme was stable between pH 5.0 and 9.0 at 30°C and most stable at pH 6.0 at 50°C. The enzyme activity over 95% remained at 40°C, but was almost completely lost at 60°C for 10 min. Calcium ions protected the enzyme from heat denaturation to some extent. No metal ions examined showed stimulatory effect and Hg²⁺ ions inhibited the enzyme. The enzyme was also inhibited by potato inhibitor and diisopropylphosphorofluoridate, but not by metal chelating agent or sulfhydryl reagents. A. candidus alkaline proteinase exhibited immunological cross-reacting properties similar to those of alkaline proteinases of A. sojae and A. oryzae.     

Purification and enzymatic properties of α-galactosidase from Penicillium janthinellum

α-Galactosidase (E.C.3.2.1.22) from Penicillium janthinellum was purified by precipitation and fractionation with ammonium sulphate, cold acetone or ethanol, calcium phosphate gel, and column chromatographies on Sephadex G-100 and G-200. The enzyme was purified about 110.39-fold when Sephadex G-100 was used. α-Galactosidase exhibited the optimum pH and temperature at 4.5 and 60°C, respectively. The optimum enzyme stability was obtained at pH 3.5 for 24 h (at room temperature). The enzyme was found to be thermostable below 65°C up to 40 minutes and was gradually inactivated by increasing the temperature above this degree. The MICHAELIS constant was 0.55 mM for p-nitrophenyl-α-D-galactoside. The α-galactosidase activity was strongly inhibited by Hg⁺⁺ and slightly activated by Mn⁺⁺. The results show the possibility of producing a thermostable enzyme from a low-priced agricultural product, for instance, lupine.     

Purification and characterization of endoxylanase Xln-1 from <Emphasis Type="Italic">Aspergillus niger</Emphasis> B03

An extracellular endoxylanase was isolated from the xylanolytic complex of Aspergillus niger B03. The enzyme was purified to a homogenous form using consecutive ultrafiltration and anion exchange chromatography. The endoxylanase was a monomer protein with a molecular weight of 33,000 Da determined by sodium dodecyl sulfate-polyacrylamide gel electrophoresis, and 34,000 Da determined by gel filtration. The optimal pH and temperature values for the enzyme action were 6.0 and 60°C, respectively. Endoxylanase was stable at 40°C, pH 7.0 for 210 min. The thermal stability of the enzyme was significantly increased in the presence of glycerol and sorbitol. The enzyme activity was inhibited by Cu²⁺, Fe²⁺, Fe³⁺, and Ag¹⁺, and it was activated by Mn²⁺. The substrate specificity and kinetic parameters of the enzyme were determined with different types of xylans. Endoxylanase displayed maximum activity in the case of oat spelt xylan, with an apparent K _m value of 8.19 mg/ml. The substrate specificity and the product profile of the enzyme suggested it to be an endoxylanase.     

Serratia Protease

A strain of Serratia, isolated from an intestinal canal of a silkworm, produced a large quantity of protease. The enzyme was extracellular and was named Serratiopeptidase, tentatively. Protease production of this strain was over 3 times as much as that of Serratia marcescens which was known as a protease-producing organism. The highly purified enzyme was prepared from the culture supernatant through ammonium sulfate precipitation, acetone fractionation, DEAE-cellulose column chromatography and gel filtration on Sephadex G-75.

The purified enzyme moved homogeneously with a sedimentation constant, s_20,w of 3.8 S in ultracentrifugation and the molecular weight was determined to be 6.0 × 10₄ by the Archibald method. Determination of the ultraviolet absorption spectrum indicated the E^1%_{280 mμ,1 cm} was 13.0. Neither carbohydrate nor sulfur-containing amino acid was detected in the purified enzyme preparation. The enzyme showed maximal activity at pH 9.0 and at 40°C, and was stable under lower temperatures over the pH range from 5 to 10, whereas it was unstable at 37°C in alkaline conditions. The enzyme was completely inactivated by heating at 55°C for 15 min.     

Purification and characterization of an endoxylanase from the culture broth of <Emphasis Type="Italic">Bacillus cereus</Emphasis> BSA1

An extracellular xylanase from the fermented broth of Bacillus cereus BSA1 was purified and characterized. The enzyme was purified to 3.43 fold through ammonium sulphate precipitation, DEAE cellulose chromatography and followed by gel filtration through Sephadex-G-100 column. The molecular mass of the purified xylanse was about 33 kDa. The enzyme was an endoxylanase as it initially degraded xylan to xylooligomers. The purified enzyme showed optimum activity at 55°C and at pH 7.0 and remained reasonably stable in a wide range of pH (5.0–8.0) and temperature (40–65°C). The K _m and V _max values were found to be 8.2 mg/ml and 181.8 μmol/(min mg), respectively. The enzyme had no apparent requirement of cofactors, and its activity was strongly inhibited by Cu²⁺, Hg²⁺. It was also a salt tolerant enzyme and stable upto 2.5 M of NaCl and retained its 85% activity at 3.0 M. For stability and substrate binding, the enzyme needed hydrophobic interaction that revealed when most surfactants inhibited xylanase activity. Since the enzyme was active over wide range of pH, temperature and remained active in higher salt concentration, it could find potential uses in biobleaching process in paper industries.     

Characterization of hyperthermostable α-amylase from Geobacillus sp. IIPTN

A newly isolated Geobacillus sp. IIPTN (MTCC 5319) from the hot spring of Uttarakhand's Himalayan region produced a hyperthermostable α-amylase. The microorganism was characterized by biochemical tests and 16S rRNA gene sequencing. The optimal temperature and pH were 60°C and 6.5, respectively, for growth and enzyme production. Although it was able to grow in temperature ranges from 50 to 80°C and pH 5.5–8.5. Maximum enzyme production was in exponential phase with activity 135 U ml⁻¹ at 60°C. Assayed with cassava as substrate, the enzyme displayed optimal activity 192 U ml⁻¹ at pH 5.0 and 80°C. The enzyme was purified to homogeneity with purification fold 82 and specific activity 1,200 U mg⁻¹ protein. The molecular mass of the purified enzyme was 97 KDa. The values of K _m and V _max were 36 mg ml⁻¹ and 222 μmol mg⁻¹ protein min⁻¹, respectively. The amylase was stable over a broad range of temperature from 40°C to 120°C and pH ranges from 5 to 10. The enzyme was stimulated with Mn²⁺, whereas it was inhibited by Hg²⁺, Cu²⁺, Zn²⁺, Mg²⁺, and EDTA, suggesting that it is a metalloenzyme. Besides hyperthermostability, the novelty of this enzyme is resistance against protease.     

Purification and Characterization of an Extracellular β-Glucosidase from the Wood-Grown Fungus Xylaria regalis

Xylaria regalis, a wood-grown ascomycete isolated in Taiwan, produces β-glucosidase (EC 3.2.1.21) extracellularly. The β-glucosidase was purified to homogeneity by ammonium sulfate precipitation, ion-exchange, and gel filtration chromatography. The molecular mass of the purified enzyme was estimated to be 85 kDa by sodium dodecyl sulfate–polyacrylamide gel electrophoresis. With p-nitrophenyl β-D-glucopyranoside (PNPG) as the substrate at pH 5.0 and 50°C, the K _m was 1.72 mM and V _max was 326 μmol/min/mg. Optimal activity with PNPG as the substrate was at pH 5.0 and 50°C. The enzyme was stable at pH 5.0 at temperatures up to 50°C. The purified β-glucosidase was active against PNPG, cellobiose, sophorose, and gentiobiose, but did not hydrolyze lactose, sucrose, Avicel, and o-nitrophenyl β-D-galactopyranoside. The activity of β-glucosidase was stimulated by Ca²⁺, Mg²⁺, Mn²⁺, Cd²⁺ and β-mercaptoethanol, and inhibited by Ag⁺, Hg²⁺, SDS, and p-chloromercuribenzoate (PCMB). Received: 30 March 1996 / Accepted: 3 May 1996     

Production and biochemical characterization of xylanase from an alkalitolerant novel species Aspergillus niveus RS2

The novel fungus Aspergillus niveus RS2 isolated from rice straw showed relatively high xylanase production after 5 days of fermentation. Of the different xylan-containing agricultural by-products tested, rice husk was the best substrate; however, maximum xylanase production occurred when the organism was cultured on purified xylan. Yeast extract was found to be the best nitrogen source for xylanase production, followed by ammonium sulfate and peptone. The optimum pH for maximum enzyme production was 8 (18.2 U/ml); however, an appreciable level of activity was obtained at pH 7 (10.9 U/ml). Temperature and pH optima for xylanase were 50°C and 7.0, respectively; however the enzyme retained considerably high activity under high temperature (12.1 U/ml at 60°C) and high alkaline conditions (17.2 U/ml at pH 8 and 13.9 U/ml at pH 9). The enzyme was strongly inhibited by Hg²⁺, while Mn²⁺ was slight activator. The half-life of the enzyme was 48 min at 50°C. The enzyme was purified by 5.08-fold using carboxymethyl-sephadex chromatography. Zymogram analysis suggested the presence of a single candidate xylanase in the purified preparation. SDS-PAGE revealed a molecular weight of approximately 22.5 kDa. The enzyme had K _m and V _max values of 2.5 and 26 μmol/mg per minute, respectively.     

An extracellular glucoamylase produced by endophytic fungus EF6

A strain of endophytic fungus EF6 isolated from Thai medicinal plants was found to produce higher levels of extracellular glucoamylase. This strain produced glucoamylase of culture filtrate when grown on 1% soluble starch. The enzyme was purified and characterized. Purification steps involved (NH₄)₂SO₄ precipitation, anion exchange, and gel filtration chromatography. Final purification fold was 14.49 and the yield obtained was 9.15%. The enzyme is monomeric with a molecular mass of 62.2 kDa as estimated by SDS-PAGE, and with a molecular mass of 62.031 kDa estimated by MALDI-TOF spectrometry. The temperature for maximum activity was 60°C. After 30 min for incubation, glucoamylase was found to be stable lower than 50°C. The activity decrease rapidly when residual activity was retained about 45% at 55°C. The pH optimum of the enzyme activity was 6.0, and it was stable over a pH range of 4.0–7.0 at 50°C. The activity of glucoamylase was stimulated by Ca²⁺, Co²⁺, Mg²⁺, Mn²⁺, glycerol, DMSO, DTT and EDTA, and strongly inhibited by Hg²⁺. Various types of starch were test, soluble starch proved to be the best substrate for digestion process. The enzyme catalyzes the hydrolysis of soluble starch and maltose as the substrate, the enzyme had K _m values of 2.63, and 1.88 mg/ml and V _max, values of 1.25, and 2.54 U/min/mg protein, and V _max/K _m values of 0.48 and 1.35, respectively. The internal amino acid sequences of endophytic fungus EF6 glucoamylase; RALAN HKQVV DSFRS have similarity to the sequence of the glucoamylase purified form Thermomyces lanuginosus. From all results indicated that this enzyme is a glucoamylase (1,4-α-D-glucan glucanohydrolase).     

Purification, immobilization and characterization of linoleic acid isomerase on modified palygorskite

Linoleic acid isomerase from Lactobacillus delbrueckii subsp. bulgaricus 1.1480 was purified by DEAE ion-exchange chromatography and gel filtration chromatography. An overall 5.1% yield and purification of 93-fold were obtained. The molecular weight of the purified protein was ~41 kDa which was analyzed by SDS-PAGE. The purified enzyme was immobilized on palygorskite modified with 3-aminopropyltriethoxysilane. The immobilized enzyme showed an activity of 82 U/g. The optimal temperature and pH for the activity of the free enzyme were 30 °C and pH 6.5, respectively; whereas those for the immobilized enzyme were 35 °C and pH 7.0, respectively. The immobilized enzyme was more stable than the free enzyme at 30–60 °C, and the operational stability result showed that more than 85% of its initial activity was retained after incubation for 3 h. The K _m and V _max values of the immobilized enzyme were found to be 0.0619 mmol l⁻¹ and 0.147 mmol h⁻¹ mg⁻¹, respectively. The immobilized enzyme had high operational stability and retained high enzymatic activity after seven cycles of reuse at 37 °C.