Isolation of mutants of Penicillium purpurogenum with enhanced xylanase and β-xylosidase production

Penicillium purpurogenum was mutated with u.v. light to increase xylanase production. The best mutant, UV-64, was treated with N-methyl-N'-nitro-N-nitrosoguanidine and a second generation of mutants was obtained (NG-188 and NG-737). NG-737 produced 125 U of xylanase/ml when grown on oat spelts xylan supplemented with wheat bran compared with 69 U/ml for the wild-type strain. The mutants also showed a 2.2-fold increase in -xylosidase as compared with the wild-type.     

Isolation and properties of mutants of the fungus Penicillium pinophilum with enhanced cellulase and β-glucosidase production

A number of mutant strains overproducing cellulase, β-glucosidase and xylanase enzyme were isolated from the cellulolytic fungus Penicillium pinophilum 87160iii after mutagenesis by u.v. irradiation and/or chemical treatment. Selection was carried out using either an agar-plate or an enrichment technique. Cellulase (filter paper-hydrolysing activity) production by some of the mutants in shake flask cultures was approximately four-fold higher than the wild-type strain; improvements in β-glucosidase production were of the order of eight- to-ninefold. The morphology of the mycelium of the mutants was quite different from that of the wild type. The mutants, for example, produced mycelium which was highly branched and thicker in cross section. In several of the mutants synthesis of xylanase and β-glucosidase was completely derepressed in the presence of glycerol, which was a known repressor of the synthesis of these enzymes. Several of the mutants produced β-glucosidase enzyme which showed altered kinetics of hydrolysis in the presence of inhibitors.     

Purification and some properties of Aspergillus pulverulentus β-xylosidase with transxylosylation capacity

Two β-xylosidases [EC 3.2.1.37], β-Xyl I (molecular mass 180 kDa, pI 4.7) and β-Xyl II (molecular mass 190 kDa, pI 3.5), derived from Aspergillus pulverulentus were separated and purified by successive chromatographies and their characterization and transxylosylation were studied. β-Xyl I and β-Xyl II were stable at temperatures up to 50°C and from pH 1.5 to 6.5 and 2.5 to 7.0, respectively, while their highest activities were in the pH ranges 2.5–3.5 and 4.0–5.0 at 60°C. Although both enzymes were strongly inhibited by N-bromosuccinimide, the inhibitory effect of HgCl₂ was not significant on either. The two enzymes exhibited different resistances against AgNO₃, glucono 1,5-lactone and nojirimycin. They were shown to have broad acceptor specificity in transferring the xylosyl residue of xylooligosaccharides to various alcohol and phenolic compound acceptors. In the presence of 25% or more 2-propanol, the synthesis of the transfer product, 2-propyl β-xyloside, was closely consistent with the theoretical yield.     

Isolation ofEscherichia coli mutants with simultaneous hyperproduction of d-serine deaminase and β-galactosidase

Summary Double mutants ofE. coli hyperproducing D-serine deaminase and -galactosidase were isolated by two successive selection procedures in the chemostat. The specific activity of D-serine deaminase is 10 times higher and -galactosidase 5 times higher compared with the fully induced original strain B 28.     

Isolation and properties of β-xylosidase from Aspergillus niger GS1 using corn pericarp upon solid state fermentation

There is growing interest in developing high-yield and low-cost production of xylanolytic enzymes for industrial applications using agroindustrial byproducts. A native strain of Aspergillus niger GS1 was used to produce β-xylosidase (EC 3.2.1.37) on solid state fermentation using corn pericarp (CP) with innovative alkaline electrolyzed water (AEW) pretreatment at room temperature. β-xylosidase was purified by ammonium sulfate fractionation followed by anion exchange and hydrophobic interaction chromatographies. β-Xylosidase showed a molecular weight of 111 kDa, isoelectric point of 5.35 and specific activity of 386.7 U (mg protein)^?1, using p-nitrophenyl-β-d-xylopyranoside as substrate, at pH 5 and 60 °C, and optimal activity at pH 4.5. Optimal temperature was 65 °C, showing full activity after 1 h at 60 °C. Activity was reduced by 1 mM β-mercaptoethanol (55.6 ± 0.1%), and enhanced by 1 mM SDS (11.0 ± 0.03%). K_m and V_max were 6.1 ± 0.9 mM and 1364 ± 105 U (mg protein)^?1, respectively, whereas k_cat was 5.1 s^?1. A predominant α-helix (41%) was determined from circular dichroism on β-xylosidase, while thermal transition profiles produced a T_m of 54.1 ± 5.8 °C, enthalpy change for unfolding of 67.4 ± 6.7 kJ/mol, and onset temperature of 37 °C. Pre-treatment of CP using AEW is an ecologically friendly alternative to chemical and heat treatments for the production of relatively high levels of β-xylosidase.     

Production of β-Mannanase and β-Mannosidase from Aspergillus awamori K4 and Their Properties

β-Mannanase and β-mannosidase from Aspergillus awamori K4 was produced by solid culture with coffee waste and wheat bran. The optimum composition for enzyme production was 40% coffee waste–60% wheat bran. Two enzymes were partially purified. Optimum pH was about 5 for both enzymes, and optimum temperature was around 80°C for β-mannanase and 60–70°C for β-mannosidase. These enzymes produced some oligosaccharides from glucomannan and galactomannan by their hydrolyzing and transferring activities. β-Mannanase hydrolyzed konjak and locust bean gum 39.1% and 15.8%, respectively. Oligosaccharides of various molecular size were released from glucomannan of konjak, but on the addition of cellulase, mannobiose was released selectively. In locust bean gum, tetra-, tri-, and disaccharides (mannobiose) were mainly released by K4 β-mannanase. Tetra- and trisaccharides were heterooligosaccharides consisting of galactose and mannose residues. K4 β-mannosidase had a transglycosylation action, transferring mannose residue to alcohols and sugars like fructose. Received: 24 April 2000/Accepted: 20 October 2000     

Isolation and divalent-metal activation of a β-xylosidase,RUM630-BX

The gene encoding RUM630-BX, a β-xylosidase/arabinofuranosidase, was identified from activity-based screening of a cow rumen metagenomic library. The recombinant enzyme is activated as much as 14-fold (k_cat) by divalent metals Mg²⁺, Mn²⁺ and Co²⁺ but not by Ca²⁺, Ni²⁺, and Zn²⁺. Activation of RUM630-BX by Mg²⁺ (t_0.5 144 s) is slowed two-fold by prior incubation with substrate, consistent with the X-ray structure of closely related xylosidase RS223-BX that shows the divalent-metal activator is at the back of the active-site pocket so that bound substrate could block its entrance. The enzyme is considerably more active on natural substrates than artificial substrates, with activity (k_cat/K_m) of 299 s⁻¹ mM⁻¹ on xylotetraose being the highest reported.     

Production of xylanase and β-xylosidase from autohydrolysis liquor of corncob using two fungal strains

Agroindustrial residues are materials often rich in cellulose and hemicellulose. The use of these substrates for the microbial production of enzymes of industrial interest is mainly due to their high availability associated with their low cost. In this work, corncob (CCs) particles decomposed to soluble compounds (liquor) were incorporated in the microbial growth medium through autohydrolysis, as a strategy to increase and undervalue xylanase and β-xylosidase production by Aspergillus terricola and Aspergillus ochraceus. The CCs autohydrolysis liquor produced at 200 °C for 5, 15, 30 or 50 min was used as the sole carbon source or associated with untreated CC. The best condition for enzyme synthesis was observed with CCs submitted to 30 min of autohydrolysis. The enzymatic production with untreated CCs plus CC liquor was higher than with birchwood xylan for both microorganisms. A. terricola produced 750 total U of xylanase (144 h cultivation) and 30 total U of β-xylosidase (96-168 h) with 0.75% untreated CCs and 6% CCs liquor, against 650 total U of xylanase and 2 total U of β-xylosidase in xylan; A. ochraceus produced 605 total U of xylanase and 56 total U of β-xylosidase (168 h cultivation) with 1% untreated CCs and 10% CCs liquor against 400 total U of xylanase and 38 total U of β-xylosidase in xylan. These results indicate that the treatment of agroindustrial wastes through autohydrolysis can be a viable strategy in the production of high levels of xylanolytic enzymes.     

Induction of xylanase and β-xylosidase in Cellulomonas flavigena growing on different carbon sources

When Cellulomonas flavigena CDBB-531 was grown on glucose, xylose, glycerol, solka floc, sugarcane bagasse or xylan, xylanase activity was found only in the fermentation broth, while -xylosidase activity was always associated with the cells. Both enzymes were inducible, sugar-cane bagasse was the best inducer, solka floc and avicel were moderately good, while xylan was poor. A synergistic effect on xylanase and -xylosidase synthesis was observed when cellulose and hemicellulose were used together as carbon sources. When this strain was grown on glucose, cellobiose, arabinose or xylose, only low levels of both enzymes were detected. These results indicate that xylanase and -xylosidase were carbon-source-repressed by readily metabolizable substrates. The effect of glycerol on enzymes that were already induced was studied. The addition of glycerol caused a significant decrease in the levels of xylanases, while -xylosidase activity remained unchanged.     

Purification and characterization of an extracellular β-D-xylosidase from Aspergillus carbonarius

The production of an extracellular -D-xylosidase (-D-xyloside xylohydrolase, EC 3.2.1.37) by four Aspergillus strains (A. carbonarius, A. nidulans, A. niger and A. oryzae) grown on wheat bran medium was compared. The highest amount of the enzyme was found in the culture of A. carbonarius. The -D-xylosidase from A. carbonarius was purified to homogeneity by a rapid procedure, using hydrophobic interaction chromatography, chromatofocusing and affinity chromatography. The purified enzyme possessed not only -D-xylosidase activity, but also -L-arabinosidase activity. Mixed substrate experiments revealed that a single active centre was responsible for the splitting of the corresponding synthetic substrates. The molecular weight of the purified enzyme proved to be 100,000 Da, as estimated by SDS–PAGE. The isoelectric point was at pH 4.4. The pH and temperature optima were 4.0 and 60 °C, respectively. The enzyme remained stable over a pH range of 3.5–6.5 and up to 50 °C for 30 min. The Michaelis constant for p-nitrophenyl -D-xyloside was 0.198 mM. Kinetic studies demonstrated that the lack of the C-5 hydroxylmethyl group and the configuration of the C-4 hydroxyl group on the pyranoside ring play an important role in both substrate binding and splitting.     

Optimal conditions for enhanced β-mannanase production by recombinant Aspergillus sojae

Optimization of the growth conditions for maximum β-mannanase production in shake flasks by using recombinant Aspergillus sojae ATCC11906 (AsT1) was carried out by Box–Behnken design of response surface methodology. The highest β-mannanase activity on the fourth day of cultivation at 30 °C was obtained as 363 U/ml in the optimized medium consisting of 7% sugar beet molasses, 0.43% NH₄NO₃, 0.1% K₂HPO₄ and 0.05% MgSO₄ (by weight per volume) at 207 rpm. On the sixth day of cultivation under the optimized conditions, the highest β-mannanase activity was achieved as 482 U/ml which is 1.4-fold of 352 U/ml activity found on glucose medium previously.     

Induction of xylanase in Aspergillus tamarii by methyl β-d-xyloside

Aspergillus tamarii produced extracellular xylanase and intracellular β-xylosidase inductively in washed glucose-grown mycelia incubated with xylan and methyl β-d-xyloside, a synthetic glycoside. Methyl β-d-xyloside was a more effective inducer than xylan at the same concentration for both enzymes. Glucose and cycloheximide were found to inhibit xylanase production by methyl β-d-xyloside. Methyl β-d-xyloside was hydrolyzed to xylose by mycelial extract in vitro. Received: 23 May 1996 / Received revision: 5 September 1996 / Accepted: 13 October 1996     

Xylanase and β-xylosidase production byAspergillus niger NCIM 1207

Summary Aspergillus niger NCIM 1207 producing significantly high levels of -glucosidase was found to secrete hemicellulolytic enzymes (xylanase and -xylosidase) in the culture medium. High yields of -xylosidase were obtained when it was grown on either xylan (3%) or wheat bran (4%). Cellulose was a poor inducer of -xylosidase. The pH and temperature optima for-xylosidase were 4.5 and 65°C respectively.NCL Communication No. 3751     

Isolation and characterization of β-glucosidases from Aspergillus nidulans mutant USDB 1183

Two extracellular -glucosidases (cellobiase, EC 3.2.1.21), I and II, from Aspergillus nidulans USDB 1183 were purified to homogeneity with molecular weights of 240,000 and 78,000, respectively. Both hydrolysed laminaribiose, -gentiobiose, cellobiose, p-nitrophenyl--L-glucoside, phenyl--L-glucoside, o-nitrophenyl--L-glucoside, salicin and methyl--L-glucoside but not -linked disaccharides. Both were competitively inhibited by glucose and non-competitively (mixed) inhibited by glucono-1,5-lactone. -Glucosidase I was more susceptible to inhibition by Ag⁺ and less inhibited by Fe²⁺ and Fe³⁺ than -glucosidase II.     

Enzymatic hydrolysis of xylans I. A high xylanase and β-xylosidase producing strain of aspergillus niger

Summary Aspergillus niger, strain 110.42 (CBS), has been selected as a producer of high xylanolytic activities. The time course of xylanase and -xylosidase production as well as the effect of pH and temperature on the activity of these enzymes were studied. HPLC analysis of the enzymatic degradation of arabinoxylan showed a nearly complete conversion to pentose sugars. Aspects of using crude xylanase preparations for enzymatic saccharification of xylans are discussed.     

Purification and characterization of an extracellular β-xylosidase from a newly isolated Fusarium verticillioides

An extracellular β-xylosidase from a newly isolated Fusarium verticillioides (NRRL 26518) was purified to homogeneity from the culture supernatant by concentration by ultrafiltration using a 10,000 cut-off membrane, ammonium sulfate precipitation, DEAE Bio-Gel A agarose column chromatography and SP-Sephadex C-50 column chromatography. The purified β-xylosidase (specific activity, 57 U/mg protein) had a molecular weight (mol. wt.) of 94,500 and an isoelectric point at pH 7.8. The optimum temperature and pH for action of the enzyme were 65°C and 4.5, respectively. It hydrolyzes xylobiose and higher xylooligosaccharides but is inactive against xylan. The purified β-xylosidase had a K _m value of 0.85 mM (p-nitrophenol-β-D-xyloside, pH 4.5, 50°C) and was competitively inhibited by xylose with a K _i value of 6 mM. It did not require any metal ion for activity and stability. Journal of Industrial Microbiology & Biotechnology (2001) 27, 241–245. Received 20 May 2001/ Accepted in revised form 06 July 2001     

Optimization of β-glucosidase production from Aspergillus niger

本研究对Aspergillus niger Glu05生产β-葡萄糖苷酶的培养基组分及培养条件进行了优化.优化后的培养基组成和培养条件分别为:麸皮4％,tryptone 4％,1μmol MnSO4,1μmol NaCl,KH2PO40.2％,oH自然,摇床转速250 r/min,培养温度30℃,培养周期5d.优化后发酵液中酶活力达到44.11 IU/mL,与初始的产酶水平32.87 IU/mL相比,提高了36％.     

Comparative study of the production of extracellular β-glucosidase by four different strains of Aspergillus using submerged fermentation

Four strains of Aspergillus (Aspergillus niger CDBB-H-176, A. niger CDBB-H-175, A. niger ATCC 9642, and Aspergillus terreus CDBB-H-194) were used to produce extracellular β-glucosidase. Using an orthogonal experimental design (L₉), we optimized the parameters of culture medium to maximize the activity of β-glucosidase. The optimal conditions (same for the four strains) were as follows: temperature, 30°C; pH, 6.0; orbital agitation, 200?rpm; concentration of sucrose, 0.5% (w/v). The most productive strain was A. niger CDBB-H-175, with a yield of 701.2?U/mL. In a second stage, we optimized (L₁₈) the concentration of nutrients in the culture medium to determine whether this modification would increase the production of β-glucosidase. The optimal conditions for A. niger CDBB-H-175 were as follows (%, w/v): NaNO₃, 0.3; KCl, 0.3; KH₂PO₄, 0.15; NH₄NO₃, 0.1; NH₄H₂PO₄, 0.1; MgSO₄?·?7H₂O, 0.05; yeast extract, 0.1. The production of β-glucosidase under these conditions was 1207.9?U/mL. Enzymatic assays were used to characterize the enzyme; the optimum temperature and pH of β-glucosidase produced by the four selected micro-organisms were found to be 65°C and 5.0, respectively. We determined the Michaelis–Menten constants (K_m) only for A. niger CDBB-H-175 and CDBB-H-176; the values were 2.7 and 2.2?mM, respectively.