Inhibitory effect of cocoa powder on the growth of a variety of bacteria in different media.

The inhibitory effect of cocoa powder on 102 organisms belonging to 13 genera was determined. All organisms tested were inhibited by 5% cocoa. Shigella, Staphylococcus, Micrococcus, and Bacillus were the most sensitive. The degree of inhibition depended on the organism, temperature of incubation, and the medium in which the cocoa powder was suspended. Of six media tested, lactose broth and nutrient broth were the most inhibitory, while non-fat dry milk was the least inhibitory. Supplementing NB with tryptone or casein reduced the toxicity of cocoa.     

Isolation of Salmonellae From Food Samples: VI. Comparison of Methods for the Isolation of Salmonella From Egg Products

The recovery of salmonellae from egg products was studied, by use of three different enrichment procedures: (i) selenite broth, (ii) selenite broth containing 10% sterile feces, and (iii) the lactose pre-enrichment procedure. Brilliant Green Agar was used throughout as the recovery medium. Although the lactose pre-enrichment methodology promoted Salmonella recovery from samples containing small numbers of dormant organisms, the efficiency of this enrichment method is adversely affected by unfavorable coliform-Salmonella ratios. Under such conditions, early subculture of lactose broth into selenite broth is indicated. Selenite broth containing 10% sterile feces was more efficient than the lactose pre-enrichment methodology in promoting the growth of “dormant” salmonellae. Albumen adversely affected recovery of salmonellae from selenite broth, whereas whole egg and egg yolk enhanced Salmonella recovery from this medium. The selenite-feces medium presents a solution to the major problems encountered in the detection of salmonellae in egg products and offers an approach to a single medium in which food-borne salmonellae will manifest themselves with a minimum of laboratory manipulation.     

Salmonella Testing of Pooled Pre-Enrichment Broth Cultures for Screening Multiple Food Samples

A method has been described for testing multiple food samples for Salmonella without loss in sensitivity. The method pools multiple pre-enrichment broth cultures into single enrichment broths. The subsequent stages of the Salmonella analysis are not altered. The method was found applicable to several dry food materials including nonfat dry milk, dried egg albumin, cocoa, cottonseed flour, wheat flour, and shredded coconut. As many as 25 pre-enrichment broth cultures were pooled without apparent loss in the sensitivity of Salmonella detection as compared to individual sample analysis. The procedure offers a simple, yet effective, way to increase sample capacity in the Salmonella testing of foods, particularly where a large proportion of samples ordinarily is negative. It also permits small portions of pre-enrichment broth cultures to be retained for subsequent individual analysis if positive tests are found. Salmonella testing of pooled pre-enrichment broths provides increased consumer protection for a given amount of analytical effort as compared to individual sample analysis.     

Timed-Release Capsule Method for the Detection of Salmonellae in Foods and Feeds

A new method was developed for the detection of injured and uninjured salmonellae in foods and feeds. The steps of pre-enrichment in a nonselective broth and selective enrichment in a selective medium were combined into a single procedure. This was achieved by the gradual release of selective agents from wax-coated gelatin capsules added at the time of inoculation of nonselective basal broths. Pre-enrichment in lactose broth was combined with selective enrichment in tetrathionate or selenite-cystine broth by using timed-release capsules containing iodine or selenite. Five different categories of foods and feeds, naturally contaminated with salmonellae, were examined to compare the efficiencies of the capsule methods with conventional procedures. Combination of the separate steps of pre-enrichment and selective enrichment into a single procedure was feasible and resulted in substantial savings of labor and materials.     

Increased recovery of salmonellae from environmental samples enriched with buffered peptone water.

The incidence and persistence of salmonellae in weather pools on the top of Stone Mountain were investigated with lactose and buffered peptone water used as pre-enrichment broths. A total of 162 samples were collected from 16 weather pools over a 3-month period. The use of buffered peptone water increased the recovery of salmonellae by approximately 25%. The combined use of direct enrichment in tetrathionate broth containing brilliant green dye and pre-enrichment in buffered peptone water followed by enrichment in tetrathionate broth made it possible to detect all 37 of the contaminated samples. All of the isolates were Salmonella bareilly, the only serotype recovered in a previous study. All but one of the isolations were made from moist or wet samples. S. bareilly was isolated from rabbit dung and litter collected near the weather pools, but attempts to trap rabbits for study were unsuccessful. Random samples taken along a side of the mountain yielded S. bareilly in weather pools within the upper third of the mountain; below this level, S. weslaco and S. memphis were recovered, but not S. bareilly.     

Increased recovery of salmonellae from environmental samples enriched with buffered peptone water.

The incidence and persistence of salmonellae in weather pools on the top of Stone Mountain were investigated with lactose and buffered peptone water used as pre-enrichment broths. A total of 162 samples were collected from 16 weather pools over a 3-month period. The use of buffered peptone water increased the recovery of salmonellae by approximately 25%. The combined use of direct enrichment in tetrathionate broth containing brilliant green dye and pre-enrichment in buffered peptone water followed by enrichment in tetrathionate broth made it possible to detect all 37 of the contaminated samples. All of the isolates were Salmonella bareilly, the only serotype recovered in a previous study. All but one of the isolations were made from moist or wet samples. S. bareilly was isolated from rabbit dung and litter collected near the weather pools, but attempts to trap rabbits for study were unsuccessful. Random samples taken along a side of the mountain yielded S. bareilly in weather pools within the upper third of the mountain; below this level, S. weslaco and S. memphis were recovered, but not S. bareilly.     

Isolation of Salmonellae from Foods Samples: V. Determination of the Method of Choice for Enumeration of Salmonella

Comparison of three methods by which salmonellae may be isolated and enumerated from dried albumen, direct inoculation of enrichment media, centrifugation of samples, and pre-enrichment in noninhibitory media, reveals pre-enrichment to be the method of choice.

The superiority of pre-enrichment manifests itself in replicate aliquots of the same sample by producing a statistically significant increase in numbers of isolations of salmonellae and in empirical use with various albumen samples by consistently higher values of most probable numbers (MPN).

The primary factor involved in this superiority appears to be the greater ability of small numbers of salmonellae to initiate growth in the nonselective mannitol purple sugar broth than in the inhibitory enrichment media.

The method of analysis recommended entails inoculation of mannitol broth pre-enrichment medium, transfer of 24-hr culture aliquots to tetrathionate broth, and streaking on brilliant green agar for isolation of salmonellae.

     

Automated detection of Salmonella spp. in foods.

An automated method to detect salmonellae in foods was developed and tested in food samples intentionally contaminated with the test organisms. Liquid eggs, shell eggs, dry eggs, skim milk and chicken were spiked with Salmonella enteritidis, S. typhimurium or S. newport to yield 2 to 25 CFU per 25 g or ml of sample. Following pre-enrichment in universal pre-enrichment broth at 42 degrees C for 6 h (eggs and milk) or 16 h (chicken), Salmonella cells were captured by immunomagnetic beads coated with Salmonella antibody (Vicam, Watertown, MA). The beads were transferred to selective liquid media containing carbohydrate (dulcitol or xylose), amino acid (lysine or ornithine), and H2S indicator, and incubated at 42 degrees C in the BioSys instrument (MicroSys, Ann Arbor, MI). Salmonella positive samples were identified by black discoloration of the media during incubation, while negative samples remained colorless. These color changes were recorded by the instrument. All the artificially contaminated samples tested positive within 15-18 h, while control samples remained negative during 24 h incubation. The results agreed with standard identification procedures. A total of 24 h was required to detect 2 to 25 CFU of the pathogen in 25 g or ml of eggs and milk, and up to 36 h in chicken, compared to 72 h in the standard methods.     

Minimal Medium Recovery of Thermally Injured Salmonella senftenberg 4969

Exposure of Salmonella senftenberg 4969 to sublethal heating in phosphate buffer, pH 7·0, at 52· produced thermally injured cells characterized by their relative inability to form colonies on trypticase soy yeast extract agar compared to minimal medium (M9) agar. During subsequent incubation at 37· in liquid media, more injured cells were capable of repair in M9 than in nutrient media used for pre-enrichment purposes. M9 was superior to lactose broth as a liquid holding medium to restore the ability of injured cells to grow on both rich and selective agar media. The addition of food products produced a more favourable environment for the repair of thermally injured cells in M9 rather than lactose broth. Pre-enrichment in M9 was 100 times more effective than using lactose broth as the preliminary step in the detection of S. senftenberg in laboratory pasteurized liquid egg albumen.     

A Comparison of Methods for the Enrichment of Salmonellae from Sheep Faeces

S ummary : A 10-tube MPN technique was used to test the efficiency of nutrient, tetrathionate, mannitol-selenite and mannitol-selenite-cystine broths as enrichment media for detecting salmonellae. Small numbers of broth grown salmonellae could be detected in all 4 media in the presence of 5% of sheep faeces. In naturally infected sheep faeces small numbers of salmonellae were not detected with either nutrient or tetrathionate broths. With mannitol-selenite the sensitivity of salmonella detection increased with both incubation temperature (37–43°) and the addition of faeces. The most sensitive and reliable medium for detecting salmonellae in naturally infected sheep faeces was mannitol-selenite-cystine broth. Neither incubation temperature (37–43°) nor the addition of faeces had a statistically significant effect on its sensitivity.     

Lactobacillus reuteri beta-galactosidase activity and low milk acidification ability

Beta-galactosidase activity was studied as a possible cause of the low milk acidification ability observed in Lactobacillus reuteri NRRL 14171. Enzymatic activity was determined in MRS broth supplemented with either glucose or lactose and milk at the middle and final stage of the exponential phase, as well as at the stationary phase. Results were compared with beta-galactosidase activity in Lactobacillus casei NRRL-B1922, a strain that shows the milk acidification ability. The effects of the types of carbon and nitrogen sources were established by comparison of growth parameters (higher maximum cell concentration and specific growth rate) in broth culture and skim milk supplemented with 2% glucose or 1% casein peptone. In milk, L. reuteri showed higher beta-galactosidase activity in all growth phases compared with L. casei. Greater cell concentration maxima, specific growth rates, and acidification abilities were observed in L. reuteri when it was cultured in milk supplemented with 1% casein peptone compared with non-supplemented milk cultures. Results suggest that the poor milk acidification ability observed in L. reuteri may be more related to a weak proteolytic system than to deficient beta-galactosidase activity.     

Increased Sensitivity of Immunofluorescent Assay for Salmonella in Nonfat Dry Milk

The necessity of developing a quick, sensitive, and reliable test for Salmonella in nonfat dry milk (NDM) is evident from the recent tracing of Salmonella outbreaks to this product. Normally, coagulation of casein occurs when assaying NDM under regular cultural conditions, raising the possibility of trapped bacteria. After 20 hr of incubation of NDM in preenrichment lactose broth, enrichment was achieved by using Selenite-Cystine Broth. Smears from the enrichment broth were examined by the fluorescent-antibody technique (FAT) with a commercially available polyvalent O globulin conjugated with fluorescein. Standard cultural methods (SCM) were performed for comparison with FAT. Sensitivity of FAT was definitely improved by the use of trypsin. Casein coagulation of NDM can be avoided by addition of trypsin to samples during initial preenrichment in lactose broth. Samples containing approximately one Salmonella per 10 g were easily detected by FAT with the use of trypsin-treated samples. The method required only 42 hr to complete. Additionally, the use of trypsin enhanced recovery of Salmonella by use of SCM, as evidenced by alteration in the observed coliform to Salmonella ratios.     

The transfer of tritium-labeled organic material from grass into cow's milk

Two lactating cows were given tritiated hay containing organically bound tritium (OBT) only for about 4 weeks. Tritium activity was determined in milk fat, casein, lactose, milk water, and whole milk. In one cow, milk was sampled for approximately 450 days, covering two lactation periods. At steady state, specific tritium activities in casein, lactose, and milk water were 58, 10, and 11%, respectively, of those in milk fat. Some OBT was converted into THO during catabolism and entered the body water pool. This 3H source accounted for nearly 40% of tritium in lactose, but in casein and milk fat about 97% of tritium was derived from ingested OBT. Comparison of the specific activity of milk constituents with the specific activity of ingested hay showed the following values: 0.84 for milk fat, 0.49 for casein, 0.05 for lactose, 0.10 for milk water. About one-half of the tritium transferred to milk was found in organic milk constituents and the other half in milk water. Decrease of tritium activity with time could be represented by three components with different half-lives for the organic milk constituents. Those for milk fat and casein were quite similar, with a slow component of nearly 3 months.     

Immunodetection of added glycomacropeptide in milk formulas and milk powders

The present study aimed the detection of fraudulent manipulation of milk powder with a low cost component--whey powder, by applying the immunochromatographic assay to identify glycomacropeptide. Five commercial milk powder samples of various brands from the national market were analyzed: lactose enriched milk powder type 26, two whole milk powders, vitamin enriched milk powder and full cream milk powder. Our results showed additional whey (1-2%) in 60% of the selected samples after casein removal by precipitation with 20% trichloracetic acid. Another investigated sample--the enriched UHT milk for children aged 4-12 years--proved addition of whey. Other two commercial toddler formula milk powder samples of different brands were used for comparison for the presence of glycomacropeptide. The first sample which was regularly labeled as containing whey protein concentrate was found positive for glycomacropeptide in accordance with the label information, while the second one not containing whey proteins as specified by the product label, was found negative for glycomacropeptide, these two samples being in accordance with the actual legislation.     

Casein as a necessary factor in the production of stimulatory material for associative growth of lactic streptococci

Strains of Streptococcus cremoris KH and HC produced material that was stimulatory for S. cremoris R₆ in milk and in the dialyzable fraction of milk, but not in the dialysate fraction of milk, lactic acid whey, or lactose broth. The addition of casein to these latter media permitted the production of this stimulatory material to occur. Tryptone, peptone, and yeast extract could not be substituted for casein in producing the stimulatory material or in initiating associative growth in the lactic acid whey. The minimum concentration of casein required appeared to be from 2.0 to 2.5%.     

Applicability of Aeration and Delayed Addition of Selenite to the Isolation of Salmonellae

The effect of aeration combined with the delayed addition of selenite on the lag period of several strains of salmonellae and other enterobacteria is reported. A procedure has been developed involving shaking of the sample in a basal medium for 4 hr at 37 C, adding selenite and cystine, and continuing shaking for 20 hr. Confirmation by selective plating, biochemical tests, and serology gave results comparable to the standard lactose pre-enrichment method with the saving of 24 hr and elimination of one set of media. Confirmation by fluorescent-antibody tests showed that fewer positive fluorescent stains were obtained from the aerated procedure than from the lactose pre-enrichment procedure. Precautions in the application of this procedure are discussed.     

Fate of Salmonella in dry confectionery raw materials

Aims:  To study the behaviour of salmonellae inoculated in the dry, raw materials, related to chocolate confectionery manufacture, as affected by the strain, cell preparation method and storage temperature.
Methods and Results:  Outbreak and non outbreak-associated salmonellae were used for the inoculation of cocoa butter oil, crushed cocoa and hazelnut shells, cocoa beans and almond kernels. Dry matrices were inoculated with lawn-collected and broth-grown cells and were stored at 5 and 21°C for 21 days. Results demonstrated that all strains survived in all dry matrices. Lawn-collected cells survived considerably better than broth-collected cells, at either temperature, and outbreak-associated strains of Salmonella serotype Enteritidis PT30 and Salmonella serotype Oranienburg appeared to be among the best surviving strains.
Conclusions:  The work demonstrated that salmonellae can survive storage for 3–4 weeks in dry raw materials and that survival is dependent on the source of strains, cell preparation and inoculation methodology, and storage temperature.
Significance and Impact of the Study:  The data contributes to understanding the parameters to consider when assessing the risk of dry raw materials as the most likely source of salmonellae in chocolate processing plants. It also demonstrates the importance of implementing effective lethal processes and segregation procedures to prevent cross-contamination to ensure the safety of confectionery products regarding Salmonella .     

Indigestion in Young Calves

Increasing the lactose content of different milk replacers or milk diets by approx. 30 % of the dry matter increased the frequency of diarrhoea the first 10–12 days in young calves on all occasions in 5 experiments comprising 120 calves. For all diets taken together, this effect was highly significant. Total daily intakes of lactose amounted to 200–480 g. When lactose was given on top of the milk rations, the growth rate increased significantly, whereas the growth rate was usually insignificantly reduced when lactose replaced other nutrients in milk diets or milk replacers, their levels of protein and fat becoming low. Albumin and total protein in blood plasma were significantly lower when the dietary protein level was low. Milk replacers with 20 or 40 % whey powder, replacing skim milk powder, performed equally well, but gave significantly less growth than the old-fashioned feeding of whole milk-skim milk. Intake of hay and barley and a number of clinical and histological or pathological parameters did not vary consistently with dietary level of whey powder or lactose. Feeding whole milk all the time resulted in low intake of hay and barley and poorly developed forestomachs, but high dressing-out %. Substituting soya for part of the skim milk powder in milk replacers gave abomasal content with no curds. In most cases, pH in the rumen appeared to be nearly up to neutral until the calves ate ground barley, about 1 month old.     

Biopolymer production by a Klebsiella oxytoca isolate using whey as fermentation substrate

A strain of Klebsiella oxytoca was isolated from milk capable of completely utilising the lactose (3.5%, w/v) in whey and producing biopolymer. In a broth containing 5% (w/v) lactose, 6.1 g/l of extracellular biopolymer was produced in 72 h by the isolate. At a shear rate of 2 s, broth viscosities of greater than 400 cP were obtained in lactose rich (4%, w/v) media containing 0.2% (w/v) nitrogen concentration.     

A comparison of isolation procedures for salmonellas from polluted water using two forms of Rappaport's medium

F ricker , C.R. 1984. A comparison of isolation procedures for salmonellas from polluted water using two forms of Rappaport's medium. Journal of Applied Bacteriology 56 , 305–309.
The efficiency of Rappaport's broth (RB10) and Rappaport's broth containing novobiocin (NRB10) were compared for the isolation of salmonellas from polluted water, both as direct enrichment media and after pre-enrichment in buffered peptone water. Ninety samples were examined and 41 were found to contain salmonellas by at least one of the procedures used. Direct inoculation of the sample into RB10 resulted in the recovery of salmonellas from only 29.3% of the samples found to be positive. The use of NRB10 as a direct enrichment medium increased the percentage recovery to 78.0% of the total positive samples. Pre-enrichment in buffered peptone water allowed the recovery of salmonellas from a total of 41 samples whereas direct enrichment recovered them from only 32. No significant difference was demonstrated in the efficiencies of RB10 and NRB10 in recovering salmonellas after pre-enrichment in buffered peptone water. Three selective agars were used; no significant difference in their ability to recover salmonellae was demonstrated.