Optimization of fermentation medium for amidase production by response surface methodology

采用响应面分析方法,对阿萨希丝孢酵母(Trichosporon asahii)ZZB-1产酰胺酶的发酵培养基进行了优化.运用单因子试验筛选出麦芽糖和酵母浸膏为最适碳源、氮源,金属离子Ca2+、Mn2+可提高发酵酰胺酶产量;通过最陡爬坡实验逼近以上4个因子的最大响应区域后,采用Box-Behnken响应面分析法,确定产酰胺酶最佳发酵培养基为麦芽糖18.84 g/L、酵母浸膏9.55 g/L、NaCl 5g/L、KH2 PO41g/L、MgSO4·7H2O 0.2 g/L、FeSO40.001g/L、CaCO370.84 μmol/L、MnSO4 65.39 μmol/L(1％丙烯酸诱导),NH4·H2O调节pH至7.0.培养基优化后酰胺酶产量由初始2554U/L提高到4156 U/L,为原始发酵培养基配方酶活产量的1.63倍.     

脱落酸产生菌的筛选及其产酸条件优化

利用马丁-孟加拉红培养基由20份土壤样品和2份植物病叶样品中分离出57株真菌,分别对其进行液体培养,通过各菌株发酵液抑制莴苣种子发芽的方法筛选得到一株脱落酸产生菌NX-53,通过L9(34)正交实验对其产酸条件进行了优化,该菌株产脱落酸的培养基配方和培养条件如下:葡萄糖25g/L,维生素B11.25mg/L,谷氨酸单钠盐3.0g/L,MgSO4·7H2O 0.2 g/L,KCl 0.5 g/L,CaCO3 5 g/L,KH2PO4 0.8 g/L,FeSO4·7H2O 0.5mg/L, ZnSO4·7H2O 2.5mg/L,CuSO4·5H2O 4mg/L,250mL摇瓶装液量50mL,28℃、150r/min培养7d.优化条件下菌株NX-53的脱落酸产量可达276 mg/L.     

益生菌Lactobacillus casei Zhang增殖培养基的优化

Lactobacillus casei Zhang 是一株分离自传统酸马奶中的益生菌.本文研究了不同碳源、氮源、碳氮比例、微量元素及缓冲盐对 Lactobacillus casei Zhang 增殖培养的效果,并采用响应面法对优选的碳源、氮源和缓冲盐类的组成含量进行优化,得到 Lactobacillus casei Zhang 的增殖培养基为:葡萄糖20.9 g/L、大豆蛋白胨10.45 g/L、酵母粉10.45 g/L、K2HPO4 3.5 g/L、醋酸钠14.6 g/L、柠檬酸钠2.3 g/L、MgSO4·7H2O 1 g/L,MnSO4·5H2O 54 mg/L、CuSO4·5H2O 10 mg/L、吐温80为1 g/L.Lactobacillus casei Zhang 在此增殖培养基中经37℃ 18 h培养活茵数可达到4.78×109 CFU/mL,比在MRS中(4.8×108 CFU/mL)提高近10倍.     

Cry1Ac和Cry2Ab杀虫蛋白对粘虫幼虫生长发育的影响

【目的】为探究Bt杀虫蛋白对次要靶标害虫粘虫Mythimna separata (Walker)(鳞翅目:夜蛾科)的杀虫活性及对其生长发育的影响。【方法】本文通过浸叶法饲喂初孵及2龄末粘虫不同剂量的Cry1Ac及Cry2Ab杀虫蛋白后,观察其死亡率,称量幼虫重,并统计了幼虫历期、化蛹率、蛹重、蛹期、蛹的羽化率、畸形率等指标。【结果】初孵幼虫取食浸泡含16、64、128μg/mLCry1Ac及Cry2Ab的玉米叶片后,随着时间的延长及浓度的增加,死亡率逐渐增加,且Cry1Ac杀虫蛋白对粘虫的生物活性高于Cry2Ab蛋白,在128μg/mL浓度下,取食Cry1Ac和Cry2Ab蛋白13d时的死亡率分别达到了65%及60%。取食两种蛋白后,初孵幼虫和2龄末幼虫重量均受到显著抑制,短期取食两种蛋白对幼虫历期、化蛹率、蛹重、蛹期、蛹的羽化率、畸形率没有影响。【结论】取食Cry1Ac和Cry2Ab杀虫蛋白后,对初孵幼虫有很好的杀虫活性,且Cry1Ac杀虫活性高于Cry2Ab杀虫蛋白;短期饲喂两种杀虫蛋白时,对2龄粘虫后期生长影响不大。本文结果为转Bt基因作物更好的应用于粘虫的防治提供了理论基础。     

响应面法优化革耳Panus rudis FG-35菌株产漆酶培养基

采用Plackett-Burman设计和响应面分析相结合的方法,对革耳Panus rudis FG-35菌株产漆酶的液体培养基配方进行优化。单因素试验结果显示,发酵培养基中的最优碳源为可溶性淀粉,最优氮源为蛋白胨;Plackett-Burman设计筛选出影响漆酶产量的3个重要因素为可溶性淀粉、金属Ca2+离子和吐温-40,在此基础上运用最陡爬坡试验逼近最大响应值区域,最后利用Box-Behnken试验设计及响应面分析法进行回归分析,获得最佳培养基配方为:可溶性淀粉10.040 4 g/L、蛋白胨0.2 g/L、K2HPO41.00g/L、ZnSO4·7H2O 0.008 g/L、MgSO4·7H2O 0.5 g/L、CuSO4·7H2O 0.007 g/L、FeSO4·7H2O 0.005 g/L、MnSO40.035 g/L、CaCl20.0816 g/L、VB10.1 g/L、吐温-40 0.428%。在优化后的条件下摇瓶发酵产漆酶酶活力为263.31 U/mL,与模型预测值接近,发酵产酶量比优化前提高1.07倍,同时优化后的发酵液对木质素降解进行试验发现,优化后漆酶对木质素降解率提高了14.34%。     

Response surface optimization of fermentation conditions for xylanase production by recombinant Pichia pastoris

研究不同碳源、氮源和无机盐对毕赤酵母AX181菌株产木聚糖酶的影响.实验表明,分别采用葡萄糖和玉米浆干粉为碳源和氮源可以明显提高木聚糖酶的产量.无机盐单因子优化实验显示添加适量的(NH4)2SO4、KH2 PO4、MnSO4·H2O、FeSO4·7H2O也可以部分提高木聚糖酶产量.在此基础上利用响应面法优化毕赤酵母产木聚糖酶培养基,利用12次实验的Plackett - Burman设计实验筛选出影响产木聚糖酶的3个主要因素,即玉米浆干粉、MrSO4 ·H2O和FeSO4·7H2O.并进一步通过最陡爬坡路径逼近最大响应区域,采用中心组合实验设计确定最佳条件.优化后的产木聚糖酶培养基组分为(g/L):葡萄糖40.00,玉米浆干粉80.84,(NH4)2SO4 6.25,KH2PO4 1.25、MnSO4·H2O 0.35,FeSO4 ·7H2O 1.31.培养基优化后,实际产酶2 883.86 U/mL,是优化前YPD培养基产酶的2.51倍.     

棉铃虫中肠氨肽酶APN4与Cry1Ac、Cry2Aa结合能力的比较

【目的】Bt杀虫蛋白(Bacillus thuringiensis)具有高度的靶标特异性,已经被广泛用于农业害虫防治。Bt杀虫蛋白要发挥杀虫活性,必须首先与其受体蛋白结合,氨肽酶N(Aminopeptidase N)是一类重要的Bt受体蛋白。因此,分析该受体与Bt杀虫蛋白的结合能力,可为进一步明确不同Bt的分子作用机制、Bt的抗性治理以及新Bt的开发应用等提供借鉴。【方法】本文利用Ligand blot和Elisa方法比较了棉铃虫Helicoverpa armigera中肠APN4(Aminopeptidase N4,APN4)与Cry1Ac、Cry2Aa的结合能力。【结果】原核表达的APN4片段与活化的Cry1Ac、Cry2Aa都可以结合,解离常数(Kd)分别是48.59 nmol/L和21.73 nmol/L。【结论】APN4片段与Cry1Ac、Cry2Aa的结合能力在数量级上不存在显著性差异。     

响应面分析优化产木聚糖酶毕赤酵母基因工程菌培养条件

研究不同碳源、氮源和无机盐对毕赤酵母AX181菌株产木聚糖酶的影响。实验表明,分别采用葡萄糖和玉米浆干粉为碳源和氮源可以明显提高木聚糖酶的产量。无机盐单因子优化实验显示添加适量的（NH4）2SO4、KH2PO4、MnSO4·H2O、FeSO4·7H2O也可以部分提高木聚糖酶产量。在此基础上利用响应面法优化毕赤酵母产木聚糖酶培养基,利用12次实验的Plackett—Burman设计实验筛选出影响产木聚糖酶的3个主要因素,即玉米浆干粉、MnSO4·H2O和FeSO4·7H20。并进一步通过最陡爬坡路径逼近最大响应区域,采用中心组合实验设计确定最佳条件。优化后的产木聚糖酶培养基组分为（g/L）：葡萄糖40．00,玉米浆干粉80．84,（NH4）2SO46．25,KH2PO41．25、MnSO4·H2O0．35,FeS04-7H2O1．31。培养基优化后,实际产酶2883．86u／mL,是优化前YPD培养基产酶的2．51倍。     

鬼伞0901纤维素酶液体发酵条件研究

纤维素酶的低成本生产是第二代燃料乙醇产业化的关键.以农业废弃生物质为原料的液体发酵是纤维素酶规模化制备的发展趋势.利用实验室保藏的鬼伞0901 菌株,采用单因子比较的方法,初步考察了其发酵产纤维素酶的培养基组分和培养条件,培养基组分为(100mL 发酵液):菜籽饼1.2g,尿素0.09g,麸皮0.72g,蔗糖0.025g,MgSO4 · 7H2O 0.03 g,CaCl2 0.03g, FeSO4 · 7H2O 0.5 mg,MnSO4 ·H2O 0.16mg,ZnSO4 · 7H2O 0.14mg,CoCl2 0.2mg,KH2PO4 0.2g,;且培养条件初始pH 值为5,250mL 三角瓶中装液量为30mL,发酵周期为163h,菌株0901 的CMC 酶活最高达199.684U/mL.     

苏云金芽胞杆菌杀虫晶体蛋白Cry1Ba结构域Ⅱ中Loops结构与功能关系研究

为了明确杀虫晶体蛋白中各个Loop的结构与功能的关系,以及Loop突变对Cry1Ba蛋白杀虫活性的影响,首先通过三维结构模拟以及同源序列分析的方法,找到Cry1Ba蛋白三个结构域及三个Loop相对应的氨基酸片段:然后通过重叠引物PCR将编码Cry1Ba蛋白结构域Ⅱ中的三个Loop进行了相应的突变,共获得了5个突变体M1(Loop1:340WSNTR344-缺失(Cry1A))、M2(Loop2:402Y-G)、M3(Loop2:400GIYLEP405-PSAV(Cry3A)),M4(400GIYLEPIH407-ILGS(Cry1A)),M5(Loop3:472LQSRV476-AGAVYTL(Cry1A)).将这些突变体在大肠杆菌BL21中进行了诱导表达,提取蛋白,分别对小菜蛾进行了生物活性测定.生测结果表明,Loop1的缺失突变M1的毒力,与Cry1Ba(LC50 0.96μg/mL)相比,显著降低,LC50为35.51 μg/mL;在Loop2的突变中,单个氨基酸的突变M2(Y/G)的毒力略有下降(LC50为1.31 μg/mL);而另两种突变(M3和M4)时小菜蛾的毒力明显下降,LC50值分别为11.56 μg/mL、34.81 μg/mL;Loop3的突变M5对小菜蛾的毒力略有提高(LC50 0.81 μg/mL),但差异不显著.对Cry1Ba蛋白突变前后结构与功能之间关系的分析结果表明,Loop区突变对Cry1Ba蛋白的结构和功能影响非常显著;Loop1和Loop2在决定Cry1Ba对小菜蛾的毒性方面起着重要作用.     

Cry29A and Cry30A: two novel delta-endotoxins isolated from Bacillus thuringiensis serovar medellin

Two novel crystal protein genes from a highly mosquitocidal Bacillus thuringiensis serovar medellin strain were cloned and sequenced. The corresponding proteins, Cry29A and Cry30A, were nontoxic when tested individually against the mosquito species bioassayed (Aedes aegypti, Culex pipiens and Anopheles stephensi). However, Cry29A synergized the toxicity of Cry11Bb against Aedes aegypti by a four-fold factor.     

苏云金芽孢杆菌Cry1Aa和Cry1Ca结构域交换对晶体形态和杀虫活性影响

通过体外重组的方法,实现了苏云金芽孢杆菌杀虫晶体蛋白Cry1Aa和Cry1Ca的功能性结构域Ⅰ、Ⅱ和Ⅲ的互换,得到了6株苏云金杆菌重组菌株BT-ACC,BT-AAC,BT-ACA,BT-CAA,BT-CCA和BT-CAC。SDS-PAGE和Westernblot分析表明,重组菌株BT-CAA和BT-CCA能表达产生135kDa左右的杂交晶体蛋白Cry1CAA和Cry1CCA,但其蛋白表达量较野生型Cry1Aa和Cry1Ca低。用牛胰蛋白酶对杂交晶体蛋白Cry1CAA、Cry1CCA及野生型Cry1Aa和Cry1Ca进行消化,证明所有晶体蛋白都能产生65kDa的活性毒素。电镜观察发现,野生菌株BT-Cry1Aa和BT-Cry1Ca形成典型的菱形晶体,而重组菌株BT-CCA和BT-CAA则形成球形或颗粒状杂交晶体。纯化晶体的生物测定显示,杂交晶体蛋白Cry1CAA和Cry1CCA对甜菜夜蛾的毒力比野生型晶体蛋白降低3~5倍,对棉铃虫的毒力比野生型晶体蛋白降低了190~260倍。研究结果表明,苏云金杆菌晶体蛋白不同结构域的相互作用会影响杂交晶体蛋白的表达、晶体形态和杀虫活性。     

The synergic and antagonistic activity of Cry1Ab and Cry2Aa proteins against lepidopteran pests

Cry1Ab and Cry2Aa were overexpressed in Escherichia coli BL21(DE3), and their proportions were determined for evaluating their synergic and antagonistic interactions on Ephestia kuehniella and Plodia interpunctella. Results indicated antagonistic interaction on both lepidopteran pests, and it was concluded that 1 : 1 combination of Cry1Ab:Cry2Aa should be avoided in control programmes for these larvae.     

Discovery of a novel Bacillus thuringiensis Cry8D protein and the unique toxicity of the Cry8D-class proteins against scarab beetles

A novel cry gene, cry8Db, highly toxic to scarab beetles such as the Japanese beetle, Popillia japonica Newman, was cloned from an isolate of Bacillus thuringiensis(Bt), BBT2-5. The cry8Db gene has 3525 bp nucleotides and codes for a protein of 1174 amino acid residues. The protein, Cry8Db, has typical Bt characteristics such as the 8-block, conserved sequences and the three-domain 3 D toxin structure as defined with Cry3Aa. When the amino acid sequence of Cry8Db was compared with that of Cry8Da whose gene was cloned and characterized in our laboratory earlier, substantial sequence diversities were found in their Domain III. The cry8Db gene was expressed in an acrystalliferous B. thuringiensis strain, BT51. BT51 expressing cry8Db formed a spherical crystal like the natural crystal of BBT2-5. The Cry8Db protein was assayed along with the other scarab active Cry8Da and Cry8Ca against the Japanese beetle. While Cry8Da and Cry8Db had toxicity against both adults and larvae of the Japanese beetle, Cry8Ca was toxic to only larvae. Cry8Ca showed no toxicity against the adult beetle up to 30 μg per 1 cm² of leaf discs on which the protein was applied. The activation process of Cry8Db by adult and larval gut juice was compared in vitro with the processes of Cry8Da and Cry8Ca. All three proteins, Cry8Db, Cry8Da and Cry8Ca, produced a toxic core of approximately 70 kDa equally indicating that the activation process does not inactivate the adult activity of Cry8Ca. We concluded that the adult activity of Cry8D proteins is encoded in Domain II. Further tests against other beetle species showed a significant difference between Cry8D’s and Cry8Ca but no difference between Cry8Da and Cry8Db. Comparison of 3D structural models of Cry8Ca, Cry8Da and Cry8Db, which were constructed by using Cry3Bb as the structural template, indicated significant structural differences, especially between Cry8Ca and Cry8D proteins, in three major surface-exposed loops of Domain II that may be involved in determining the adult beetle activity.     

Identification of Bacillus thuringiensis Cry1AbMod binding-proteins from Spodoptera frugiperda

Bacillus thuringiensis Cry toxins are currently used for pest control in transgenic crops but evolution of resistance by the insect pests threatens the use of this technology. The Cry1AbMod toxin was engineered to lack the alpha helix-1 of the parental Cry1Ab toxin and was shown to counter resistance to Cry1Ab and Cry1Ac toxins in different insect species including the fall armyworm Spodoptera frugiperda. In addition, Cry1AbMod showed enhanced toxicity to Cry1Ab-susceptible S. frugiperda populations. To gain insights into the mechanisms of this Cry1AbMod-enhanced toxicity, we isolated the Cry1AbMod toxin binding proteins from S. frugiperda brush border membrane vesicles (BBMV), which were identified by pull-down assay and liquid chromatography-tandem mass spectrometry (LC–MS/MS). The LC–MS/MS results indicated that Cry1AbMod toxin could bind to four classes of aminopeptidase (N1, N3, N4 y N5) and actin, with the highest amino acid sequence coverage acquired for APN 1 and APN4. In addition to these proteins, we found other proteins not previously described as Cry toxin binding proteins. This is the first report that suggests the interaction between Cry1AbMod and APN in S. frugiperda.     

转Cry1Ac+Cry2Ab棉对棉铃虫的控制作用及对天敌捕食烟粉虱功能反应的影响

文章以转Cry1Ac基因棉(中棉所41)和常规棉(中棉所49)为对照,研究了转Cry1Ac+Cry2Ab基因棉(639020)在棉花生长的关键时期——蕾期(二代棉铃虫发生期)、花期(三代棉铃虫发生期)和花铃期(四代棉铃虫发生期)对棉铃虫的控制作用,同时研究了639020棉田主要捕食性天敌(中华草蛉幼虫、龟纹瓢虫、小花蝽和草间小黑蛛)对烟粉虱的捕食功能,明确了639020棉花在生长的关键时期对棉铃虫的控制效果及对棉田主要捕食性天敌捕食功能反应的影响。结果表明,639020棉花对二代和三代棉铃虫具有良好的控制作用,抗虫性分别比中棉所41提高了52.85%和16.22%,其中前者差异达显著水平,后者差异不显著。在棉花蕾期、花期和花铃期,639020棉田棉铃虫落卵量都比中棉所41棉田和中棉所49棉田低(除二代棉铃虫发生期);棉铃虫幼虫数量都极显著低于常规棉,且都低于防治指标,但与中棉所41棉田无显著差异。639020棉田中华草蛉、龟纹瓢虫、小花蝽和草间小黑蛛对烟粉虱的捕食功能与中棉所41棉田和常规棉田相比无显著变化。研究结果以期为新型转基因棉花环境安全性研究及其外源基因的抗虫遗传效应和生产应用前景进行安全性评价。     

Marginal cross-resistance to mosquitocidal Bacillus thuringiensis strains in Cry11A-resistant larvae: presence of Cry11A-like toxins in these strains

Culex quinquefasciatus mosquito larvae resistant to the Cry11A toxin showed marginal cross-resistance to the multiple toxin crystals from B. thuringiensis subsp. israelensis and also to toxin crystals from three other mosquitocidal strains, i.e. B. thuringiensis subsp. fukuokaensis, subsp. jegathesan, and subsp. kyushuensis. Cross-resistance patterns of the Cry11A-resistant larvae to mosquitocidal strains of B. thuringiensis together with the immunological screening using antisera raised against Cry11A indicated the presence of Cry11A-like toxins in these strains and could be used as a screening tool for the identification of novel toxins. The Cry11A-resistant larvae had significantly less resistance to the Cry11B toxin from B. thuringiensis subsp. jegathesan. The occurrence of cytolytic toxins in all of these mosquitocidal strains partially explains the marginal cross-resistance observed with multiple toxin crystals since each of these crystals also contains cytolytic toxins.     

转Cry1Ac+Cry2Ab棉花生长势及其对棉田节肢动物物种丰富度的影响

【背景】转基因棉花在商业化种植之前,必须评价其环境安全性。其中新型棉花材料的生存竞争能力和对物种丰富度的影响是评价的重要内容。【方法】以转Cry1Ac＋Cry2Ab基因棉为试验材料,转Cry1Ac棉花中棉所41和非转基因棉花中棉所49为对照品种,分别于2014年5~9月对棉花株高、主茎叶片数、叶绿素含量、比叶面积、果枝数、蕾铃数等生长参数进行比较,同时对二代、三代和四代棉铃虫发生期棉田物种丰富度进行系统调查。【结果】转Cry1Ac＋Cry2Ab棉花的生长势与转Cry1Ac棉花和非转基因棉花基本相当,没有表现出明显的竞争优势;产量构成参数在成铃和脱落等方面比非转基因棉表现出良好的优势。对棉田节肢动物物种丰富度的影响表明,转Cry1Ac＋Cry2Ab棉花对靶标害虫棉铃虫具有良好的控制效果,对主要刺吸性害虫棉蚜、棉蓟马、烟粉虱、绿盲蝽与天敌龟纹瓢虫、草间小黑蛛、草蛉和小花蝽等的种群丰富度在个别时期有所影响,但总体上与转Cry1Ac棉田和非转基因棉田没有显著性差异。【结论与意义】转Cry1Ac＋Cry2Ab棉花无竞争优势,但目标性状优势较好;对棉田节肢动物物种丰富度无明显影响。研究结果为新型转Cry1Ac＋Cry2Ab棉花对棉田环境安全方面的研究进一步补充了内容,为转基因棉花的环境安全评价提供科学数据。     

转Cry1Ac+Cry2Ab基因棉对棉蚜生命表参数及种群动态的影响

为研究新型转Cry1Ac+Cry2Ab基因棉对棉蚜Aphis gossypii Glover生命表参数及种群动态的影响。2010—2011年以常规棉中棉所49为对照,对新型转Cry1Ac+Cry2Ab基因棉在室内进行了生物测定和田间进行了系统的调查。结果表明,和常规棉相比,转Cry1Ac+Cry2Ab基因棉花上棉蚜的净增值率降低81.69%,差异达显著水平;内禀增长率和周限增长率分别降低65.00%和13.01%,但差异不显著;平均世代周期和种群加倍时间分别增加5.54%和154.19%,后者差异达显著水平。和常规棉相比,2010年转Cry1Ac+Cry2Ab基因棉花百株苗蚜、伏蚜和秋蚜的数量分别降低10.79%、37.18%和17.49%,差异均未达显著水平;2011年转Cry1Ac+Cry2Ab基因棉花百株苗蚜的数量增加2.03%,伏蚜和秋蚜的数量分别降低37.41%和64.03%,差异均未达显著水平。