Color removal ability of <Emphasis Type="Italic">Phanerochaete chrysosporium</Emphasis> in relation to lignin peroxidase and manganese peroxidase produced in molasses wastewater

Decolorization of molasses wastewater (MWW) from an ethanolic fermentation plant by Phanerochaete chrysosporium was studied. By diluting MWW properly (10%v/v) and incubating it with an appropriate concentration of the spores (2.5 × 10⁶/ml), extensive decolorization occurred (75%) on day 5 of the incubation. The colour removal ability was found to be correlated to the activity of ligninolytic enzyme system: lignin peroxidase (LiP) activity was 185 U/l while manganese peroxidase (MnP) activity equaled 25 U/l. Effects of some selected operating variables were studied: manganese(II), veratryl alcohol (VA), glucose as a carbon source and urea and ammonium nitrate, each as a source of nitrogen. Results showed that the colour reduction and LiP activity were highest (76% and 186 U/l, respectively) either when no Mn(II) was added or added at the lowest level tested (0.16 mg/l to provide 0.3 mg/l). Activity of MnP was highest (25 U/l) when Mn(II) added to the diluted MWW at the highest level (100 ppm) while activity of LiP was lowest (7.1 U/l) at this level of added Mn(II). The colour reduction in the presence of the added VA was shown to be little less than in its absence (70 vs. 75%). When urea as an organic source of nitrogen for the fungus, was added to the MWW, the decolorizing activity of P. chrysosporium decreased significantly (15 vs. 75%) and no activities were detected for LiP and MnP. Use of ammonium nitrate as an inorganic source of nitrogen did not show such a decelerating effects, although no improvements in the metabolic behavior of the fungus (i.e., LiP and MnP activities) deaccelerating was observed. Effects of addition of glucose was also discussed.     

Optimized production of lignolytic manganese peroxidase in immobilized cultures of <Emphasis Type="Italic">Phanerochaete chrysosporium</Emphasis>

Manganese peroxidase (MnP) is a key enzyme involved in the lignolysis of white-rot fungi. The purpose of this study is to investigate the effect of immobilization and culture conditions on MnP production in cultures of Phanerochaete chrysosporium grown on polyurethane foam. Higher concentrations of foam and lower levels of spore inoculums resulted in the formation of scattered mycelial pellets, increased autolysis of chlamydospore-like cells (a reservoir of MnP), and a higher activity of MnP. Even though MnP was a secondary metabolite, the addition of 5 times more glucose and diammonium tartrate, as carbon and nitrogen sources, resulted in a 4 fold increase in the dry cell mass. However, MnP activity decreased under these conditions to less than half, due to the formation of increasingly dense pellets and the inhibited lysis of chlamydospore-like cells.     

Enhanced production of manganese peroxidase from immobilized <Emphasis Type="Italic">Phanerochaete chrysosporium</Emphasis> due to the increased autolysis of chlamydospore-like cells

The autolysis of chlamydospore-like cells in Phanerochaete chrysosporium immobilized in polyurethane foam correlated with the production of manganese peroxidase (MnP). The maximum specific activity of MnP was 1055 U g dry mycelium^–1 in the immobilized culture, compared with 260 U g dry mycelium^–1 in the submerged culture. Scattered mycelial pellets were formed in the immobilized culture in which almost all of the chlamydospore-like cells were subject to autolysis. However, highly crowded pellets were formed in the free culture, in which only the chlamydospore-like cells in the exterior were subject to autolysis. We propose that the enhanced production of MnP in immobilized cultures of P. chrysosporium is due to increased autolysis of the chlamydospore-like cells.     

Nitrogen regulation of lignin peroxidase and manganese-dependent peroxidase production is independent of carbon and manganese regulation in Phanerochaete chrysosporium

In this study, a N-deregulated mutant (der8-5) of Phanerochaete chrysosporium was used as a tool to investigate the interrelationships between N, C, and Mn(II) regulation of LIP and MNP production in this organism. The results showed that LIP and MNP production by der8-5 was blocked in excess C medium but not in excess N medium. Furthermore, LIP and MNP production in this organism was subject to Mn(II) regulation regardless of the fact whether it is grown in low N medium or in high N medium. These and other results indicate that N regulation of LIP and MNP production in P. chrysosporium is independent of C and Mn(II) regulation.Abbreviations LIP lignin peroxidase - MNP manganese-dependent peroxidase - WT wild-type - der8-5 nitrogen-deregulated mutant     

Heterologous expression of lignin peroxidase of Phanerochaete chrysosporium in Pichia methanolica

The cDNA encoding for lignin peroxidase of Phanerochaete chrysosporium was expressed in the Pichia methanolica under the control of the alcohol oxidase (AUG1) promoter which was followed by either the lignin peroxidase leader peptide of Phanerochaete chrysosporium or the Saccharomyces cerevisiae alpha-factor signal peptide. Both peptides efficiently directed the secretion of lignin peroxidase from the recombinant yeast cell. The extracellular lignin peroxidase activity in two recombinants was 932 U l(-1) and 1933 U l(-1). The purity of the recombinant product was confirmed by SDS-PAGE.     

Evaluation of the environmental conditions for the continuous production of lignin peroxidase by Phanerochaete Chrysosporium in fixed-bed bioreactors

A new system to produce lignin peroxidase (LiP) continuously by Phanerochaete chrysosporium is described. A fixed-bed bioreactor with a pulsing device was used as the optimal bioreactor configuration. Addition of veratryl alcohol (1 mM), tryptophan (1 mM), no Mn²⁺ addition, low glucose addition rate (60–70 mg l^–1 h) and an atmosphere of O₂ gave maximum LiP activities of 700 U l^–1, which are higher than those previously reported.     

Effect of culture conditions on the production of ligninolytic enzymes by white rot fungi Phanerochaete chrysosporium (ATCC 20696) and separation of its lignin peroxidase

The present work was carried out to determine the optimum culture conditions of Phanerochaete chrysosporium (ATCC 20696) for maximizing ligninolytic enzyme production. Additionally, separation of its lignin peroxidase was conducted. After experiments, an optimized culture medium/condition was constructed (per liter of Kirk’s medium): dextrose 10 g, ammonium tartrate 0.11 g, Tween-80 0.5 g, MnSO₄ 7 mg, and veratryl alcohol 0.3 g in 10 mM acetic acid buffer pH 4.5. Under the optimized experimental condition, both lignin peroxidase (LiP) and manganese peroxidase (MnP) were detected and reach the highest yield at 30°C on the 8th day culture. Salt precipitation methods was used in the extraction and purification processes. Results show that salt precipitation with 60% (NH₄)₂SO₄ yielded the best result, especially toward LiP. Enzyme separation was conducted and two fractions with LiP activity. LiP1 and LiP2 were produced using three columns sequentially: desalting column, Q FF ion exchange column and Sepharyl S-300 HR gel filtration. LiP1 and LiP2 had been purified by 9.6- and 7.6-fold with a yield of 22.9% and 18.6%, respectively. According to the data of sodium dodecyl sulfate polyacrilamide gel electrophoresis (SDS-PAGE), the molecular weights of the enzymes are 38 kDa and 40 kDa, respectively.     

Decolorization of melanin by lignin peroxidase from<Emphasis Type="Italic">Phanerochaete chrysosporium</Emphasis>

Melanin was decolorized by lignin peroxidase fromPhanerochaete chrysosporium. This decolorization reaction showed a Michaelis-Mentens type relationship between the decolorization rate and concentration of two substrates: melanin and hydrogen peroxide. Kinetic constants of the decolorization reaction were 0.1 OD₄₇₅/min (V _max) and 99.7 mg/L (K _m) for melanin and 0.08 OD₄₇₅/min (V _max) and 504.9 μM (K _m) for hydrogen peroxide, respectively. Depletion of hydrogen peroxide interrupted the decolorization reaction, indicating the essential requirement of hydrogen peroxide. Pulsewise feeding of hydrogen peroxide continued the decolorizing reaction catalyzed by lignin peroxidase. These results indicate that enzymatic decolorization of melanin has applications in the development of new cosmetic whitening agents.     

Enhanced lignin peroxidase synthesis by Phanerochaete Chrysosporium in solid state bioprocessing of a lignocellulosic substrate

Summary A solid state fermentation (SSF) process for the production of lignin peroxidase was optimized to enhance enzyme production by Phanerochaete chrysosporium. Optimization of the corncob SSF medium caused a significant reduction in fermentation time to give maximum lignin peroxidase yield. Supplementation of the SSF medium by low concentrations of peptone, yeast extract and Tween-80 enhanced lignin peroxidase production. Maximum yield of lignin peroxidase was 13.7 U/gds (units per gram dry substrate) noted after 5 days of SSF with 70% moisture and 20% (v/w) inoculum.     

Influence of primary and secondary proteases produced by free or immobilized cells of the white-rot fungus Phanerochaete chrysosporium on lignin peroxidase activity

Primary and secondary extracellular proteases produced by free or immobilized cells of the white-rot fungus Phanerochaete chrysosporium have been studied in relation to lignin peroxidase (LiP) decay. Proteases produced during primary metabolism exhibited a maximum activity on day 2; they could totally inactivate LiP activity and partially fragment LiP. Proteases produced during secondary metabolism did not inactivate or decay LiP.These proteases most likely are aspartic- and thiol-proteases.     

Impact of pellet size on growth and lignin peroxidase activity of Phanerochaete chrysosporium

We investigated the influence of pellet size on the growth and lignin peroxidase (LiP) productivity of Phanerochaete chrysosporium. Different pellet sizes were obtained by varying the vessel diameter under constant shaking conditions. Under these varying conditions the pellet size was in the range of 2–18 mm, while the number of pellets in a single vessel varied from around 1,200 in the Erlenmeyer flask to around 6 in the narrowest vessel. A correlation between the final pellet size and the shear rate was obtained, demonstrating that the pellet size is mainly affected by hydrodynamics. The growth of large pellets was described by a cubic growth model. Despite different pellet sizes, LiP activity appeared in all vessels, but the onset of LiP activity showed a delay based upon the pellet size, while maximal LiP activities varied by only 15%, being around 850 U/l.     

Optimization of lignin peroxidase production and stability by <Emphasis Type="Italic">Phanerochaete chrysosporium</Emphasis> using sewage-treatment-plant sludge as substrate in a stirred-tank bioreactor

A laboratory-scale study was carried out to produce lignin peroxidase (ligninase) by white rot fungus (Phanerochaete chrysosporium) using sewage-treatment-plant (STP) sludge as the major substrate. The optimization was done using full-factorial design (FFD) with agitation and aeration as the two parameters. Nine experiments indicated by the FFD were fermented in a stirred-tank bioreactor for 3 days. A second-order quadratic model was developed using the regression analysis of the experimental results with the linear, quadratic, and interaction effects of the parameters. Analysis of variance (ANOVA) showed a high coefficient of determination (R ²) value of 0.972, thus indicating a satisfactory fit of the quadratic model with the experimental data. Using statistical analysis, the optimum aeration and agitation rates were determined to be 2.0 vvm and 200 rpm, respectively, with a maximum activity of 225 U l⁻¹ in the first 3 days of fermentation. The validation experiment showed the maximum activity of lignin peroxidase was 744 U l⁻¹ after 5 days of fermentation. The results for the tests of the stability of lignin peroxidase showed that the activity was more than 80% of the maximum for the first 12 h of incubation at an optimum pH of 5 and temperature of 55°C.     

Effects of Zn2+ and Cu2+ on growth,lignin degradation and ligninolytic enzymes in Phanerochaete chrysosporium

The influence of Zn²⁺ (6.0 × 10^–3 –18.0 × 10^–3 M) and Cu²⁺ (4 × 10^–4 –1.2 × 10^–4 M) in the basal medium on mycelial growth (dry weight), activities of lignin peroxidase (Lip), manganese peroxidase (Mnp), solubilization, and mineralization (¹⁴CO₂ evolution) of lignin during a period of 3 weeks was studied in Phanerochaete chrysosporium strain MTCC-787. Highest mycelial growth was obtained at 0.6 M Zn²⁺ and 0.4 M Cu²⁺ levels. Enzyme activities were found to increase up to the highest levels of both the trace elements. However, Zn²⁺ had a relatively more stimulatory effect on Lip production and the reverse was true in case of Cu²⁺. [¹⁴C]Lignin solubilization was also promoted by higher levels of both trace elements. Mineralization of [¹⁴C]lignin was optimal at 6.0 M Zn²⁺ and 1.2 M Cu²⁺. The stimulatory effect of Zn²⁺ on Lip production was correlated with higher rates of [¹⁴C]lignin mineralization.     

Isolation and characterization of Mn(III) tartrate from Phanerochaete chrysosporium culture broth

High initial Mn(II) concentration results in accumulation of a Mn(III) tartrate complex in the growth medium of Phanerochaete chrysosporium. Since Mn(III) is the major oxidant in ligninolysis by manganese peroxidase, the role of accumulated complex should not be neglected when degradation experiments by a crude culture filtrate are performed. To study the Mn(III) complex oxidative potential it was isolated by absorption to polyamide followed by desorption with an alkaline methanol solution. High performance liquid chromatography analysis and atomic absorption spectroscopy confirmed that the isolate was Mn(III) tartrate. Oxidation of 2,2'-azino-bis(3-ethylbenz-thiazoline-6-sulfonate) was used for testing the temperature and pH stability of the isolate that also intensively oxidized 2,6-dimethoxyphenol. In comparison with the non-isolated complex in the culture filtrate, the isolate showed increased temperature and pH stability. The oxidative potential of the isolated Mn(III) tartrate was additionally tested by decolorization of the synthetic dye Indigo carmine.     

Degradation of the herbicide bentazon as related to enzyme production by Phanerochaete chrysosporium in two solid substrate fermentation systems

Enzyme production and degradation of the herbicide bentazon by Phanerochaete chrysosporium growing on straw (solid substrate fermentation, SSF) and the effect of nitrogen and the hydraulic retention time (HRT) were studied using a small bioreactor and batch cultures. The best degradation of bentazon was obtained in the low nitrogen treatments, indicating participation of the ligninolytic system of the fungus. The treatments that degraded bentazon also had manganese peroxidase (MnP) activity, which seemed to be necessary for degradation. Pure MnP (with Mn(II) and H₂O₂) did not oxidize bentazon. However, in the presence of MnP, Mn(II) and Tween 80, bentazon was slowly oxidized in a H₂O₂-independent reaction. Bentazon was a substrate of pure lignin peroxidase (LiP) and was oxidized significantly faster (22,000–29,000 times) as compared to the MnP-Tween 80 system. Although LiP was a better enzyme for bentazon oxidation in vitro, its role in the SSF systems remains unclear since it was detected only in treatments with high nitrogen and high HRT where no degradation of bentazon occurred. Inhibition of LiP activity may be due to phenols and extractives present in the straw.     

Free-radical polymerization of acrylamide by manganese peroxidase produced by the white-rot basidiomycete Bjerkandera adusta

Acrylamide was polymerized to give polyacrylamide using manganese peroxidase (MnP) produced by the basidiomycete Bjerkandera adusta. The molecular weight of the polymer synthesized by MnP was 155000, higher than those obtained with other reaction systems using horseradish peroxidase and a redox initiator. The ¹³C-NMR spectrum showed that polyacrylamide was atactic. Electron spin resonance analysis revealed that 2,4-pentanedione added as an initiator was first oxidized to generate a carbon-centered radical, which initiated radical additive polymerization of acrylamide.     

Co-immobilization of manganese peroxidase from Phlebia radiata and glucose oxidase from Aspergillus niger on porous silica beads

Manganese peroxidase (MnP) from Phlebia radiata and glucose oxidase from Aspergillus niger were co-immobilized on porous silica beads. Immobilization of both enzymes on the same carrier provided an integrated system in which H₂O₂ required by MnP was produced by glucose oxidase. The immobilization process resulted in a decrease of both enzymatic activities and substrate affinities. However, immobilization improved the stability of MnP against H₂O₂ or high pH, as well as the storage stability of this enzyme.     

Degradation of the insecticide Hydramethylnon byPhanerochaete chrysosporium

The decomposition of the amidinohydrazone-type insecticide Hydramethylnon (HMN) by soil fungi has been investigated. A simple spectrophotometric method was developed for the estimation of HMN in soil and fungal culture media. HMN was found to be degraded in soil with a half life of 14 to 25 days.Degradation of HMN by the lignolytic fungus,Phanerochaete chrysosporium yielded two major breakdown products;p-(trifluoromethyl)-cinnamic acid (TFCA) andp-(trifluoromethyl)-benzoic acid (TFBA). TFCA was converted to TFBA which was subsequently metabolised via themeta-fission pathway. Fluoride release from HMN could not be detected.Abbreviations BzDAc benzene, dioxane, acetic acid (60: 36: 4) - DCM dichloroethane - DNPH 2,4-dinitro-phenylhydrazine - HMN Hydramethylnon - TDAc toluene, dioxane, acetic acid (90: 30: 1) - TFCA p-(trifluoromethyl)-cinnamic acid - TFBA p-(trifluoromethyl)-benzoic acid - TFP 1,5-bis(trifluoro-p-tolyl)-1,4-pentadien-3-one - VA veratryl alcohol     

Amelioration of ligninolytic enzyme production by Phanerochaete chrysosporium in airlift bioreactors

Maximum activities of manganese-dependent peroxidase (MnP) and lignin peroxidase (LiP) in free cultures of Phanerochaete chrysosporium (ATCC 24725) were 258 U l^–1 and 103 U l^–1, respectively, in an airlift bioreactor. Immobilisation of the fungus on an inert carrier as well as several design modifications of the bioreactor employed gave MnP activities around 500–600 U l^–1 during 9 days' operation. The continuous operation of the latter led to MnP and LiP activities about 140 U l^–1 and 100 U l^–1, respectively, for two months, without operational problems. Furthermore, the extracellular liquid secreted decolourised the polymeric dye Poly R-478 about 56%.     

Utilisation of lignocellulosic wastes for lignin peroxidase production by semi-solid-state cultures of Phanerochaete chrysosporium

In the present work, the production of ligninolytic enzymes by semi-solid-statecultures of Phanerochaete chrysosporium BKM-F-1767 (ATCC 24725),employing different lignocellulosic wastes as support, was investigated. Thewaste materials employed were grape seeds, wheat straw and wood shavings.Maximum lignin peroxidase activities of 1620 ± 123 U/l, 364 ± 35 U/l and 571 ± 42 U/l were attained, respectively. Nevertheless, lowmanganese-dependent peroxidase activities were found, being insignificantin the grape seed cultures. Moreover, the in vivo decolourisation of a model dye compound, the polymeric dye Poly R-478 (polyvinylamine sulfonateanthrapyridone), by the above-mentioned cultures was monitored to assessthe degrading capability of the extracellular liquid secreted by such cultures.The percentage of biological decolourisation attained by grape seed and woodshaving cultures was around 74% and 63%, respectively, whereas it was ratherlow (40%) in the wheat straw ones.