Comparison of the rates of enzymatic hydrolysis of pretreated rice straw and bagasse with celluloses

The rates of enzymatic hydrolysis of pretreated rice straw and bagasse have been studied and compared with the hydrolysis rates of microcrystalline cellulose powder (MCCP) and Solka Floc. The effects of particle size reduction and enzyme loading on the rates of hydrolysis of rice straw and bagasse were also studied. It was found that the rates of hydrolysis of pretreated rice straw and bagasse are much higher than that of MCCP and Solka Floc. For both rice straw and bagasse, particle size reduction had very little effect in enhancing the rate of hydrolysis. Lignin present at <10% did not seem to hinder the accessibility of the enzyme to the cellulose surface. An enzyme loading > 40 Ug^?1 had no effect on the hydrolysis rate of rice straw or bagasse.     

Comparative evaluations of cellulosic raw materials for second generation bioethanol production

Aims: To evaluate sugar recoveries and fermentabilities of eight lignocellulosic raw materials following mild acid pretreatment and enzyme hydrolysis using a recombinant strain of Zymomonas mobilis. Methods and Results: Dilute acid pretreatment (2% H₂SO₄) with 10% (w/v) substrate loading was performed at 134°C for 60 min followed by enzyme hydrolysis at 60°C. The results demonstrated that hydrolysis of herbaceous raw materials resulted in higher sugar recoveries (up to 60–75%) than the woody sources (<50%). Fermentation studies with recombinant Z. mobilis ZM4 (pZB5) demonstrated that final ethanol concentrations and yields were also higher for the herbaceous hydrolysates. Significant reduction in growth rates and specific rates of sugar uptake and ethanol production occurred for all hydrolysates, with the greatest reductions evident for woody hydrolysates. Further studies on optimization of enzyme hydrolysis established that higher sugar recoveries were achieved at 50°C compared to 60°C following acid pretreatment. Conclusions: Of the various raw materials evaluated, the highest ethanol yields and productivities were achieved with wheat straw and sugarcane bagasse hydrolysates. Sorghum straw, sugarcane tops and Arundo donax hydrolysates were similar in their characteristics, while fermentation of woody hydrolysates (oil mallee, pine and eucalyptus) resulted in relatively low ethanol concentrations and productivities. The concentrations of a range of inhibitory compounds likely to have influence the fermentation kinetics were determined in the various hydrolysates. Significance and Impact of the Study: The study focuses on lignocellulosic materials available for second generation ethanol fermentations designed to use renewable agricultural/forestry biomass rather than food‐based resources. From the results, it is evident that relatively good sugar and ethanol yields can be achieved from some herbaceous raw materials (e.g. sugarcane bagasse and sorghum straw), while much lower yields were obtained from woody biomass.     

Characterization of enzymatic saccharification for acid-pretreated lignocellulosic materials with different lignin composition

The enzymatic saccharification of three different feedstocks, rice straw, bagasse and silvergrass, which had been pretreated with different dilute acid concentrations, was studied to verify how enzymatic saccharification was affected by the lignin composition of the raw materials. There was a quantitatively inverse correlation between lignin content and enzymatic digestibility after pretreatment with 1%, 2% and 4% sulfuric acid. The lignin accounted for about 18.8–21.8% of pretreated rice straw, which was less than the 23.1–26.5% of pretreated bagasse and the 21.5–24.1% of pretreated silvergrass. The maximum glucose yield achieved, under an enzyme loading 6.5 FPU g^?1 DM for 72 h, was close to 0.8 g glucose/g glucan from the enzymatic hydrolysis of the pretreated rice straw; this was twice that from bagasse and silvergrass. A decrease in initial rate of glucose production was observed in all cases when the raw materials underwent enzymatic saccharification with 4% sulfuric acid pretreatment. It is suggested that the higher acid concentration led to an inhibition of β-glucosidase activity. Fourier transform infrared (FTIR) spectroscopy further indicated the chemical properties of the rice straw and silvergrass become more hydrophilic after pretreatment using 2% of sulfuric acid, but the pretreated bagasse tended to become more hydrophobic. The hydrophilic nature of the pretreated solid residues may increase the inhibitive effects of lignin on the cellulase and this could become very important for raw materials such as silvergrass that contain more lignin.     

Alkaline-sulfite pretreatment and use of surfactants during enzymatic hydrolysis to enhance ethanol production from sugarcane bagasse

Sugarcane bagasse is a by-product from the sugar and ethanol industry which contains approximately 70 % of its dry mass composed by polysaccharides. To convert these polysaccharides into fuel ethanol it is necessary a pretreatment step to increase the enzymatic digestibility of the recalcitrant raw material. In this work, sugarcane bagasse was pretreated by an alkaline-sulfite chemithermomechanical process for increasing its enzymatic digestibility. Na₂SO₃ and NaOH ratios were fixed at 2:1, and three increasing chemical loads, varying from 4 to 8 % m/m Na₂SO₃, were used to prepare the pretreated materials. The increase in the alkaline-sulfite load decreased the lignin content in the pretreated material up to 35.5 % at the highest chemical load. The pretreated samples presented enhanced glucose yields during enzymatic hydrolysis as a function of the pretreatment severity. The maximum glucose yield (64 %) was observed for the samples pretreated with the highest chemical load. The use of 2.5 g l^?1 Tween 20 in the hydrolysis step further increased the glucose yield to 75 %. Semi-simultaneous hydrolysis and fermentation of the pretreated materials indicated that the ethanol yield was also enhanced as a function of the pretreatment severity. The maximum ethanol yield was 56 ± 2 % for the sample pretreated with the highest chemical load. For the sample pretreated with the lowest chemical load (2 % m/m NaOH and 4 % m/m Na₂SO₃), adding Tween 20 during the hydrolysis process increased the ethanol yield from 25 ± 3 to 39.5 ± 1 %.     

Major improvement in the rate and yield of enzymatic saccharification of sugarcane bagasse via pretreatment with the ionic liquid 1-ethyl-3-methylimidazolium acetate ([Emim] [Ac])

In this study, sugarcane bagasse was pretreated by six ionic liquids (ILs) using a bagasse/IL ratio of 1:20 (wt%). The solubilization of bagasse in the ILs was followed by water precipitation. On using 1-ethyl-3-methylimidazolium acetate [Emim] [Ac] at 120 °C for 120 min, 20.7% of the bagasse components remained dissolved and enzymatic saccharification experiments resulted on 80% glucose yield within 6h, which evolved to over 90% within 24 h. Moreover, FE-SEM analysis of the precipitated material indicated a drastic lignin extraction and the exposure of nanoscopic cellulose microfibrils with widths of less than 100 nm. The specific surface area (SSA) of the pretreated bagasse (131.84 m2/g) was found to be 100 times that of untreated bagasse. The ability of [Emim] [Ac] to simultaneously increase the SSA and to decrease the biomass crystallinity is responsible for the improved bagasse enzymatic saccharification rates and yields obtained in this work.     

Comparative efficiency of wheat straw and sugarcane bagasse biochar reduces the cadmium bioavailability to spinach and enhances the microbial activity in contaminated soil

Abstract

Biochar is considered a novel soil amendment for cadmium (Cd) stabilization in contaminated soils. A pot experiment was conducted to examine the efficiency of wheat straw and sugarcane bagasse induced biochar on Cd mobility in soil and its bioavailability to spinach in contaminated soil. Soil pH, Cd contents in plant tissues and microbial biomass were examined. Results showed that Cd was significantly decreased by 30.95% and 20.83% with wheat straw and sugarcane bagasse biochar at 2% application rate respectively, relative to the control. Similarly, Cd contents were decreased in plants shoots by 15.41 and 14.33%, while in roots by 48.3 and 35.54%, when wheat straw and sugarcane biochar were added at 2% application rate respectively. Moreover, soil microbial biomass was significantly increased with the application of all biochar types and their applications rates. Finally, wheat straw biochar at 2% application rate can be considered as an effective approach for Cd stabilization in contaminated soils.     

Study of kinetic parameters in a mechanistic model for enzymatic hydrolysis of sugarcane bagasse subjected to different pretreatments

The goal of this work is to evaluate the influence of different pretreatments in the kinetics of enzymatic hydrolysis of sugarcane bagasse and to propose a reliable methodology to easily perform sensitivity analysis and updating kinetic parameters whenever necessary. A kinetic model was modified to represent the experimental data of the batch enzymatic hydrolysis of sugarcane bagasse pretreated with alkaline hydrogen peroxide. The simultaneous estimation of kinetic parameters of the mathematical model was performed using the Pikaia genetic algorithm using batch hydrolysis experimental data obtained with different enzymatic loads. Subsequently, Plackett–Burman designs were used to identify the kinetic parameters with the higher influence on the dynamic behavior of the process variables, which were re-estimated to describe experimental data of the hydrolysis of bagasse pretreated with phosphoric acid + sodium hydroxide. The methodology was accurate and straightforward and can be used whenever there are changes in pretreatment conditions and/or fluctuations in biomass composition in different harvests.     

Integrated Strategies to Enhance Cellulolytic Enzyme Production Using an Instrumented Bioreactor for Solid-State Fermentation of Sugarcane Bagasse

The conversion of agro-industrial residues, such as sugarcane bagasse, into high-value products and renewable energy, within the biorefinery concept, is a potential alternative towards the sustainable management of these resources. This work evaluates the production of cellulolytic enzymes by a selected strain of Aspergillus niger cultivated in sugarcane bagasse under solid-state fermentation using an instrumented lab-scale bioreactor. The effects of environmental factors including the type of substrate and medium composition, as well as the operational conditions (air flow rate, inlet air relative humidity, and initial substrate moisture content) on the production of the enzymatic complex were evaluated using statistical design tools. Significant increases in FPase, endoglucanase, and xylanase activities were achieved under the optimized conditions predicted by the models, with values of 0.88, 21.77, and 143.85 IU/g of dry solid substrate, respectively, representing around ten-, four-, and twofold increases compared to the activities obtained under the initial growth conditions. This demonstrates the importance of evaluating environmental and operational criteria in order to achieve efficient enzyme production. The crude enzymatic extract obtained under optimized conditions was employed for enzymatic hydrolysis of pretreated sugarcane bagasse. Approximately 13 % of total reducing sugars, and a glucose concentration of 2.54 g/L, were obtained after 22 h of hydrolysis of steam exploded sugarcane bagasse, indicating that the enzymatic cocktail produced has good potential for use in the conversion of biomass.     

Efficient conversion of sugarcane stalks into ethanol employing low temperature alkali pretreatment method

An alternative route for bio-ethanol production from sugarcane stalks (juice and bagasse) featuring a previously reported low temperature alkali pretreatment method was evaluated. Test-tube scale pretreatment-saccharification experiments were carried out to determine optimal LTA pretreatment conditions for sugarcane bagasse with regard to the efficiency of enzymatic hydrolysis of the cellulose. Free fermentable sugars and bagasse recovered from 2 kg of sugarcane stalks were jointly converted into ethanol via separate enzymatic hydrolysis and fermentation (SHF). Results showed that 98% of the cellulose present in the optimally pretreated bagasse was hydrolyzed into glucose after 72-h enzymatic saccharification using commercially available cellulase and β-glucosidase preparations at relatively low enzyme loading. The fermentable sugars in the mixture of the sugar juice and the bagasse hydrolysate were readily converted into 193.5 mL of ethanol by Saccharomyces cerevisiae within 12h, achieving 88% of the theoretical yield from the sugars and cellulose.     

Use of lignocellulose biomass for endoxylanase production by Streptomyces termitum

Actinobacteria isolates from Brazilian Cerrado soil were evaluated for their ability to produce enzymes of the cellulolytic and xylanolytic complex using lignocellulose residual biomass. Preliminary semiquantitative tests, made in Petri plates containing carboxymethylcellulose and beechwood xylan, indicated 11 potential species producing enzymes, all belonging to the genus Streptomyces. The species were subsequently grown in pure substrates in submerged fermentation and analyzed for the production of enzymes endoglucanase, β-glucosidase, endoxylanase, and β-xylosidase. The best results were obtained for endoxylanase enzyme production with Streptomyces termitum(UFLA CES 93). The strain was grown on lignocellulose biomass (bagasse, straw sugarcane, and cocoa pod husk) that was used in natura or acid pretreated. The medium containing sugarcane bagasse in natura favored the production of the endoxylanase that was subsequently optimized through an experimental model. The highest enzyme production 0.387?U?mL^?1, (25.8 times higher), compared to the lowest value obtained in one of the trials, was observed when combining 2.75% sugar cane bagasse and 1.0?g?L^?1 of yeast extract to the alkaline medium (pH 9.7). This is the first study using S. termitum as a producer of endoxylanase.     

稀酸和稀碱预处理对四种不同生物质资源制备还原糖的影响

本论文探讨了不同浓度的稀H_2SO_4和稀NaOH预处理对大豆秸秆、水稻秸秆、象草和狼尾草四种不同生物质酶解制备还原糖的影响。结果表明,大豆秸秆、水稻秸秆、象草和狼尾草具有较高的纤维素和半纤维素含量,是制备还原糖的理想原料。与稀H_2SO_4预处理相比,经稀NaOH预处理后的样品表现出较好的酶解性能。通过使用4%的NaOH对大豆秸秆和狼尾草进行预处理,还原糖产量分别为145.8 mg/mL和319.2 mg/mL。此外,以1%NaOH预处理后的水稻秸秆和象草为原料,可以分别获得385.2 mg/mL和231.6 mg/mL还原糖产量。     

Autohydrolysis extraction process as a pretreatment of lignocelluloses for their enzymatic hydrolysis

Autohydrolysis was studied as a pretreatment to enhance sugar yields from enzymatic hydrolysis of wheat and rape straw, beech, birch and poplar sawdust. Reaction temperatures were 185°C to 212°C and the reaction time 20 min. The pretreated slurries were hydrolyzed with “Novo” cellulase and Fusarium sp. 27 cellulase at 45°C and pH 4.8 for 24 h with addition of Fusarium sp. 27 cellbound cellobiase. From 85% to 90% sugar content of substrates were converted to reducing sugars after 24 h enzymatic hydrolysis, with exception of poplar wood. 10.8 g biomass was obtained after cultivation of Fusarium sp. 27 with water solution hemicellulose fraction from 100 g beech sawdust autohydrolyzed at 200°C during 20 min.     

Extraction and characterization of wax from sugarcane bagasse and the enzymatic hydrolysis of dewaxed sugarcane bagasse

Extraction of high-value products from agricultural wastes is an important component for sustainable bioeconomy development. In this study, wax extraction from sugarcane bagasse was performed and the beneficial effect of dewaxing pretreatment on the enzymatic hydrolysis was investigated. About 1.2% (w/w) of crude sugarcane wax was obtained from the sugarcane bagasse using the mixture of petroleum ether and ethanol (mass ratio of 1:1) as the extraction agent. Results of Fourier-transform infrared characterization and gas chromatography–mass spectrometry qualitative analysis showed that the crude sugarcane wax consisted of fatty fractions (fatty acids, fatty aldehydes, hydrocarbons, and esters) and small amount of lignin derivatives. In addition, the effect of dewaxing pretreatment on the enzymatic hydrolysis of sugarcane bagasse was also investigated. The digestibilities of cellulose and xylan in dewaxed sugarcane bagasse were 18.7 and 10.3%, respectively, compared with those of 13.1 and 8.9% obtained from native sugarcane bagasse. The dewaxed sugarcane bagasse became more accessible to enzyme due to the disruption of the outermost layer of the waxy materials.     

Comparison of SHF and SSF processes for the bioconversion of steam-exploded wheat straw

Two processes for ethanol production from wheat straw have been evaluated — separate hydrolysis and fermentation (SHF) and simultaneous saccharification and fermentation (SSF). The study compares the ethanol yield for biomass subjected to varying steam explosion pretreatment conditions: temperature and time of pretreatment was 200°C or 217°C and at 3 or 10 min. A rinsing procedure with water and NaOH solutions was employed for removing lignin residues and the products of hemicellulose degradation from the biomass, resulting in a final structure that facilitated enzymatic hydrolysis. Biomass loading in the bioreactor ranged from 25 to 100 g l⁻¹ (dry weight). The enzyme-to-biomass mass ratio was 0.06. Ethanol yields close to 81% of theoretical were achieved in the two-step process (SHF) at hydrolysis and fermentation temperatures of 45°C and 37°C, respectively. The broth required addition of nutrients. Sterilisation of the biomass hydrolysate in SHF and of reaction medium in SSF can be avoided as can the use of different buffers in the two stages. The optimum temperature for the single-step process (SSF) was found to be 37°C and ethanol yields close to 68% of theoretical were achieved. The SSF process required a much shorter overall process time (≈30 h) than the SHF process (96 h) and resulted in a large increase in ethanol productivity (0.837 g l⁻¹ h⁻¹ for SSF compared to 0.313 g l⁻¹ h⁻¹ for SHF). Journal of Industrial Microbiology & Biotechnology (2000) 25, 184–192. Received 02 December 1999/ Accepted in revised form 20 July 2000     

Engineered Penicillium funiculosum produces potent lignocellulolytic enzymes for saccharification of various pretreated biomasses

PfMig1⁸⁸, a catabolically derepressed engineered strain of the hyper-cellulolytic fungus Penicillium funiculosum NCIM1228, was investigated for the efficacy of its secretome for biomass saccharification. An inexpensive version of media containing microcrystalline cellulose, wheat bran and soya protein was optimized for producing a high-quality secretome from the PfMig1⁸⁸ strain in both shake flasks and in a 20-L bioreactor. The activities of four classes of core cellulolytic enzymes required for saccharification in the PfMig1⁸⁸ secretome, namely, cellobiohydrolase (Avicelase activity), endoglucanase (CMCase activity), β-glucosidase (PNPGase activity) and xylanase (xylanase activity), were found to be 2.29 U/mL, 28.24 U/mL, 150 U/mL and 76 U/mL, respectively. The saccharification potential of the PfMig1⁸⁸ secretome was evaluated on rice straw and sugarcane bagasse pretreated with nitric acid and/or ammonium hydroxide. Saccharification performed using a 15 % (w/v) biomass load and a 3% (w/w) enzyme load released >100 g/L sugar in the hydrolysate, irrespective of the type of biomass and pre-treatment, with >80 % hydrolysis. Furthermore, the presence of lignin in nitric acid-pretreated biomass only marginally affected saccharification. Overall, the results demonstrated that the PfMig1⁸⁸ secretome, having relatively broad substrate specificity, is a viable and efficient substitute for T. reesei-based secretomes for diverse biomass saccharification.     

Pretreatment of Siam weed stem by several chemical methods for increasing the enzymatic digestibility

Siam weed [Chromolaena odorata (L.) King & Robinson], an invasive exotic weed in China, was proposed as a feedstock for bioethanol production. This would be a promising way of using for an invasive weed that needs management and control. It was found that the glucan content of the weed stem was similar to that of sugarcane bagasse, but higher than those of corn stover and wheat straw. Several chemical pretreatment methods were applied to the weed stem to increase its enzymatic digestibility. Mild sulfuric acid (<120°C) or alkali pretreatment did not markedly increase the enzymatic digestibility. However, peracetic acid (PAA) pretreatment dramatically enhanced the enzymatic hydrolysis of the weed stem. Compared to some other common agricultural residues, the weed stem was more difficult to pretreat and digest by cellulase. Fourier transform infrared (FTIR) spectra analysis indicated that the cellulose-related bands became more intensive after pretreatment, especially for PAA-pretreated samples. According to X-ray diffraction spectra, the biomass solids had higher crystallinity indices after pretreatment, although these indices were similar for all of the pretreated samples.     

Synergistic effects of mixing hybrid poplar and wheat straw biomass for bioconversion processes

Background

Low cost of raw materials and good process yields are necessary for future lignocellulosic biomass biorefineries to be sustainable and profitable. A low cost feedstock will be diverse, changing as a function of seasonality and price and will most likely be available from multiple sources to the biorefinery. The efficacy of the bioconversion process using mixed biomass, however, has not been thoroughly investigated. Considering the seasonal availability of wheat straw and the year round availability of hybrid poplar in the Pacific Northwest, this study aims to determine the impact of mixing wheat straw and hybrid poplar biomass on the overall sugar production via steam pretreatment and enzymatic saccharification.

Results

Steam pretreatment proved to be effective for processing different mixtures of hybrid poplar and wheat straw. Following SO₂-catalyzed steam explosion pretreatment, on average 22 % more sugar monomers were recovered using mixed feedstock than either single biomass. Improved sugar recovery with mixtures of poplar and wheat straw continued through enzymatic hydrolysis. After steam pretreatment and saccharification, the mixtures showed 20 % higher sugar yields than that produced from hybrid poplar and wheat straw alone.

Conclusions

Blending hybrid poplar and wheat straw resulted in more monomeric sugar recovery and less sugar degradation. This synergistic effect is attributable to interaction of hybrid poplar’s high acetic acid content and the presence of ash supplied by wheat straw. As a consequence on average 20 % more sugar was yielded by using the different biomass mixtures. Combining hybrid poplar and wheat straw enables sourcing of the lowest cost biomass, reduces seasonal dependency, and results in increasing biofuels and chemicals productivity in a cellulosic biorefinery.

     

Characterization of commercial cellulases and their use in the saccharification of a sugarcane bagasse sample pretreated with dilute sulfuric acid

This study aimed to correlate the efficiency of enzymatic hydrolysis of the cellulose contained in a sugarcane bagasse sample pretreated with dilute H₂SO₄ with the levels of independent variables such as initial content of solids and loadings of enzymes and surfactant (Tween 20), for two cellulolytic commercial preparations. The preparations, designated cellulase I and cellulase II, were characterized regarding the activities of total cellulases, endoglucanase, cellobiohydrolase, cellobiase, β-glucosidase, xylanase, and phenoloxidases (laccase, manganese and lignin peroxidases), as well as protein contents. Both extracts showed complete cellulolytic complexes and considerable activities of xylanases, without activities of phenoloxidases. For the enzymatic hydrolyses, two 2³ central composite full factorial designs were employed to evaluate the effects caused by the initial content of solids (1.19–4.81%, w/w) and loadings of enzymes (1.9–38.1 FPU/g bagasse) and Tween 20 (0.0–0.1 g/g bagasse) on the cellulose digestibility. Within 24 h of enzymatic hydrolysis, all three independent variables influenced the conversion of cellulose by cellulase I. Using cellulase II, only enzyme and surfactant loadings showed significant effects on cellulose conversion. An additional experiment demonstrated the possibility of increasing the initial content of solids to values much higher than 4.81% (w/w) without compromising the efficiency of cellulose conversion, consequently improving the glucose concentration in the hydrolysate.     

Effect of antioxidant extraction on the enzymatic hydrolysis and bioethanol production of the extracted steam-exploded sugarcane bagasse

Ethyl acetate extraction (EAE) of the steam exploded sugarcane bagasse may be an effective and economic way to extract antioxidants as well as enhance the enzymatic hydrolysis and bioethanol yield from the extracted residue. Therefore, the effects of EAE on steam-exploded sugarcane bagasse (SESB) were studied. Under boiling solvent extraction (BSE), the efficiency of EAE for obtaining phenolics from SESB was approximately 20%. EA extracts obtained under BSE showed an H₂O₂ scavenging activity (210 μL) of 99%. The IC₅₀ values for 2,2-diphenyl-1-picrylhydrazyl radical scavenging activity and reducing power of BSE40 were 50.89 and 256.38 μg/mL, respectively, while those of vitamin C were 24 and 112 μg/mL, respectively. EAE improved the glucose yield by 30% but had no significant effect on the xylose yield during the enzymatic hydrolysis obtained using Celluclast 1.5L and Novozym 188. EAE also increased the ethanol yield by 8.78% by employing simultaneous saccharification and fermentation. The present study may be of great importance in industrial bioethanol production from steam-exploded biomass environmentally friendly and economically.     

Xylanase production by endophytic Aspergillus niger using pentose-rich hydrothermal liquor from sugarcane bagasse

Fungal xylanases have been widely studied and various production methods have been proposed using submerged and solid-state fermentation. This class of enzyme is used to supplement cellulolytic enzyme cocktails in order to enhance the enzymatic hydrolysis of plant cell walls. The present work investigates the production of xylanase and other accessory enzymes by a recently isolated endophytic Aspergillus niger DR02 strain, using the pentose-rich liquor from hydrothermal pretreatment of sugarcane bagasse as carbon source. Batch and fed-batch submerged cultivation approaches were developed in order to minimize the toxicity of the liquor and increase enzyme production. Maximum xylanase activities obtained were 458.1 U/mL for constant fed-batch, 428.1 U/mL for exponential fed-batch, and 264.37 U/mL for pulsed fed-batch modes. The results indicated that carbon-limited fed-batch cultivation can reduce fungal catabolite repression, as well as overcome possible negative effects of toxic compounds present in the pentose-rich liquor. Enzymatic panel and mass spectrometric analyses of the fed-batch A. niger secretome showed high levels of xylanolytic enzymes (GH10, GH11, and GH62 Cazy families), together with cellobiohydrolase (G6 and GH7), β-glucosidase, β-xylosidase (GH3), and feruloyl esterase (CE1) accessory enzyme activities. The yields of glucose and xylose from enzymatic hydrolysis of hydrothermally pretreated sugarcane bagasse increased by 43.7 and 65.3%, respectively, when a commercial cellulase preparation was supplemented with the A. niger DR02 constant fed-batch enzyme complex.