Isoleucine uptake in Corynebacterium glutamicum ATCC 13032 is directed by the brnQ gene product

By complementation analysis of an isoleucine-uptake-deficient Escherichia coli strain, it was shown that a 1.6-kb HindIII-StuI fragment of Corynebacterium glutamicum ATCC 13032, located downstream of the aecD gene, encodes an isoleucine uptake system. Sequence analysis revealed that the complementing fragment carried an open reading frame, termed brnQ, that encodes a protein with sequence similarities to branched-chain amino acid carriers of gram-positive and gram-negative bacteria. The brnQ gene specifies a predominantly hydrophobic protein of 426 amino acid residues with a calculated molecular mass of 44.9 kDa. A topology prediction by neural network computer analysis suggests the existence of 12 hydrophobic segments that most probably form transmembrane α-helices. A C. glutamicum mutant strain harboring a defined deletion of brnQ in the chromosome showed a considerably lower isoleucine uptake rate of 0.04 nmol min^–1 mg (dry mass)^–1 as compared to the wild-type strain rate of 1.2 nmol min^–1 mg (dry mass)^–1. Overexpression of brnQ by means of a tac promotor resulted in an elevated uptake rate for isoleucine of 11.3 nmol min^–1 mg (dry mass)^–1. Evidently, the brnQ gene encodes the only transport system in C. glutamicum directing isoleucine uptake. Received: 16 October 1997 / Accepted: 27 November 1997     

Metabolic changes in a pyruvate kinase gene deletion mutant of Corynebacterium glutamicum ATCC 13032

To investigate primary effects of a pyruvate kinase (PYK) defect on glucose metabolism in Corynebacterium glutamicum, a pyk-deleted mutant was derived from wild-type C. glutamicum ATCC13032 using the double-crossover chromosome replacement technique. The mutant was then evaluated under glutamic acid-producing conditions induced by biotin limitation. The mutant showed an increased specific rate of glucose consumption, decreased growth, higher glutamic acid production, and aspartic acid formation during the glutamic acid production phase. A significant increase in phosphoenolpyruvate (PEP) carboxylase activity and a significant decrease in PEP carboxykinase activity occurred in the mutant, which suggested an enhanced overall flux of the anaplerotic pathway from PEP to oxaloacetic acid in the mutant. The enhanced anaplerotic flux may explain both the increased rate of glucose consumption and the higher productivity of glutamic acid in the mutant. Since the pyk-complemented strain had similar metabolic profiles to the wild-type strain, the observed changes represented intrinsic effects of pyk deletion on the physiology of C. glutamicum.     

Cloning and nucleotide sequence of the phosphoenolpyruvate carboxylase-coding gene of Corynebacterium glutamicum ATCC13032

As a first step in determining the importance of the anaplerotic function of phosphoenolpyruvate carboxylase (PEPC) in amino acid biosynthesis, the ppc gene coding for PEPC of Corynebacterium glutamicum ATCC13032 has been cloned by complementation of an Escherichia coli ppc mutant strain. PEPC activity encoded by the cloned gene is not affected by acetyl-CoA under conditions where the E. coli enzyme is strongly activated, whereas acetyl-CoA is able to relieve inhibition by L-aspartate used singly or in combination with alpha-ketoglutarate. Amplification of the ppc gene in a C. glutamicum lysine-excreting strain resulted in increased PEPC-specific activity and lysine productivity. The nucleotide sequence of a DNA fragment of 4885 bp encompassing the ppc gene has been determined. At the amino acid level, PEPC from C. glutamicum presents overall a high degree of similarity with corresponding enzymes from three different organisms. The location of some strictly conserved regions may have important implications for PEPC activity and allostery.     

Characterization of an adenylate cyclase gene (cyaB) deletion mutant of Corynebacterium glutamicum ATCC 13032

Genome analysis of C. glutamicum ATCC 13032 has showed one putative adenylate cyclase gene, cyaB (cg0375) which encodes membrane protein belonging to class III adenylate cyclases. To characterize the function of cyaB, a deletion mutant was constructed, and the mutant showed decreased level of intracellular cyclic AMP compared to that of wild-type. Interestingly, the cyaB mutant displayed growth defect on acetate medium, and this effect was reversed by complementation with cyaB gene. Similarly, it showed growth defect on glucose-acetate mixture minimal medium, and the utilization of glucose was retarded in the presence of acetate. The deletion mutant retained the activity of glyoxylate bypass enzymes. Additionally, the mutant could grow on ethanol but not on propionate medium. The data obtained from this study suggests that adenylate cyclase plays an essential role in the acetate metabolism of C. glutamicum, even though detailed regulatory mechanisms involving cAMP are not yet clearly defined. The observation that glyoxylate bypass enzymes are derepressed in cyaB mutant indicates the involvement of cAMP in the repression of aceB and aceA.     

The gene encoding the alternative thymidylate synthase ThyX is regulated by sigma factor SigB in Corynebacterium glutamicum ATCC 13032

Both ThyA and ThyX proteins catalyze the transfer of the methyl group from methylenetetrahydrofolate (CH(2) H(4) -folate) to dUMP, forming dTMP. To estimate the relative steady state expression levels of ThyA and ThyX, Western blot analysis was performed using ThyA or ThyX antiserum on total protein from the wild-type, ΔthyX, and thyX-complemented strains of Corynebacterium glutamicum. The level of ThyA decreased gradually during the stationary growth phase but that of ThyX was maintained steadily. Whereas the expression level of ThyA in a ΔsigB strain was comparable to that of the wild-type, the level of ThyX was significantly diminished in the deletion mutant and was restored to that of the wild-type in the complemented strain, indicating that the level of ThyX was regulated by SigB. Growth of the C.?glutamicum ΔsigB strain was dependent upon coupling activity of dihydrofolate reductase (DHFR) with ThyA for the synthesis of thymidine, and thus showed sensitivity to the inhibition of DHFR by the experimental inhibitor, WR99210-HCl. These results suggested that the relative levels of ThyA and ThyX differ in response to different growth phases and that SigB is necessary for maintenance of the level of ThyX during transition into the stationary growth phase.     

Low target site specificity of an IS6100-based mini-transposon, Tn1792, developed for transposon mutagenesis of antibiotic-producing Streptomyces

To improve transposon mutagenesis of antibiotic-producing Streptomyces, a mini-transposon, Tn1792, was constructed, based on IS6100, originally isolated from Mycobacterium fortuitum. Easily manageable transposition assays were developed to demonstrate inducible transposition of Tn1792 into the Streptomyces genome from a temperature-sensitive delivery plasmid. Introduction of the selectable aac1 gene between the inverted repeats in Tn1792 allowed for both reliable identification of transposition events in Streptomyces, and also subsequent cloning of transposon-tagged sequences in Escherichia coli. This enabled the target site specificity of Tn1792 to be determined at nucleotide resolution, revealing no significant shared homology between different target sites. Consequently, Tn1792 is well suited for random mutagenesis of Streptomyces.     

Analyses of enzyme II gene mutants for sugar transport and heterologous expression of fructokinase gene in Corynebacterium glutamicum ATCC 13032

Corynebacterium glutamicum ATCC 13032 has four enzyme II (EII) genes of the phosphotransferase system in its genome encoding transporters for sucrose, glucose, fructose, and an unidentified EII. To analyze the function of these EII genes, they were inactivated via homologous recombination and the resulting mutants characterized for sugar utilization. Whereas the sucrose EII was the only transport system for sucrose in C. glutamicum, fructose and glucose were each transported by a second transporter in addition to their corresponding EII. In addition, the ptsF ptsG double mutant carrying deletions in the EII genes for fructose and glucose accumulated fructose in the culture broth when growing on sucrose. As no fructokinase gene exists in the C. glutamicum genome, the fructokinase gene from Clostridium acetobutylicum was expressed in C. glutamicum and resulted in the direct phosphorylation of fructose without any fructose efflux. Accordingly, since fructokinase could direct fructose flux to the pentose phosphate pathway for the supply of NADPH, fructokinase expression may be a potential strategy for enhancing amino acid production.     

Expression of alr gene from Corynebacterium glutamicum ATCC 13032 in Escherichia coli and molecular characterization of the recombinant alanine racemase

We constructed the high-expression system of the alr gene from Corynebacterium glutamicum ATCC 13032 in Escherichia coli BL 21 (DE3) to characterize the enzymological and structural properties of the gene product, Alr. The Alr was expressed in the soluble fractions of the cell extract of the E. coli clone and showed alanine racemase activity. The purified Alr was a dimer with a molecular mass of 78 kDa. The Alr required pyridoxal 5'-phosphate (PLP) as a coenzyme and contained 2 mol of PLP per mol of the enzyme. The holoenzyme showed maximum absorption at 420 nm, while the reduced form of the enzyme showed it at 310 nm. The Alr was specific for alanine, and the optimum pH was observed at about nine. The Alr was relatively thermostable, and its half-life time at 60 degrees C was estimated to be 26 min. The K(m) and V(max) values were determined as follows: l-alanine to d-alanine, K(m) (l-alanine) 5.01 mM and V(max) 306 U/mg; d-alanine to l-alanine, K(m) (d-alanine) 5.24 mM and V(max) 345 U/mg. The K(eq) value was calculated to be 1.07 and showed good agreement with the theoretical value for the racemization reaction. The high substrate specificity of the Alr from C. glutamicum ATCC 13032 is expected to be a biocatalyst for d-alanine production from the l-counter part.     

Modification of histidine biosynthesis pathway genes and the impact on production of l-histidine in Corynebacterium glutamicum

Histidine biosynthesis in Corynebacterium glutamicum is regulated not only by feedback inhibition by the first enzyme in the pathway, but also by repression control of the synthesis of the histidine enzymes. C. glutamicum histidine genes are located and transcribed in two unlinked loci, hisEG and hisDCB-orf1-orf2-hisHA-impA-hisFI. We constructed plasmid pK18hisDPtac to replace the native hisD promoter with the tac promoter, and overexpressed phosphoribosyl-ATP-pyrophosphohydrolase, encoded by hisE, and ATP-phosphoribosyltransferase, encoded by hisG. The l-histidine titer at 0.85 g l^?1 was 80 % greater in the transformed bacterium and production of byproducts, l-alanine and l-tryptophan, was significantly decreased. However, accumulation of glutamic acid increased by 58 % (2.8 g l^?1). This study represents the first attempt to substitute the histidine biosynthesis pathway promoter in the chromosome with a stronger promoter to increase histidine production.     

Functional analysis of the twin-arginine translocation pathway in Corynebacterium glutamicum ATCC 13869

Compared to those of other gram-positive bacteria, the genetic structure of the Corynebacterium glutamicum Tat system is unique in that it contains the tatE gene in addition to tatA, tatB, and tatC. The tatE homologue has been detected only in the genomes of gram-negative enterobacteria. To assess the function of the C. glutamicum Tat pathway, we cloned the tatA, tatB, tatC, and tatE genes from C. glutamicum ATCC 13869 and constructed mutants carrying deletions of each tat gene or of both the tatA and tatE genes. Using green fluorescent protein (GFP) fused with the twin-arginine signal peptide of the Escherichia coli TorA protein, we demonstrated that the minimal functional Tat system required TatA and TatC. TatA and TatE provide overlapping function. Unlike the TatB proteins from gram-negative bacteria, C. glutamicum TatB was dispensable for Tat function, although it was required for maximal efficiency of secretion. The signal peptide sequence of the isomaltodextranase (IMD) of Arthrobacter globiformis contains a twin-arginine motif. We showed that both IMD and GFP fused with the signal peptide of IMD were secreted via the C. glutamicum Tat pathway. These observations indicate that IMD is a bona fide Tat substrate and imply great potential of the C. glutamicum Tat system for industrial production of heterologous folded proteins.     

The mobile element IS1207 of Brevibacterium lactofermentum ATCC21086: isolation and use in the construction of Tn5531, a versatile transposon for insertional mutagenesis of Corynebacterium glutamicum

IS1207 is the insertion most frequently found among the spontaneous mutations that abolish the activity of an Escherichia coli phage lambda cI gene integrated in the Corynebacterium Brevibacterium lactofermentum ATCC21086 genome. We examined the transposition of transposon-like structures composed of a selective kanamycin resistance gene (aph3), and one or two IS1207 sequences. One of these, the Tn5531 transposon, transposed efficiently in Corynebacterium glutamicum. A replicative and a non-replicative Tn5531 delivery vector were used in Tn5531 mutagenesis. As IS1207, transposon Tn5531 shows a high frequency of transposition and mutagenesis, and a low target specificity. These features make of Tn5531 an adequate choice for gene identification and gene tagging experiments.     

The cytosolic, cell surface and extracellular proteomes of the biotechnologically important soil bacterium Corynebacterium efficiens YS-314 in comparison to those of Corynebacterium glutamicum ATCC 13032

Reference maps of the cytosolic, cell surface and extracellular proteome fractions of the amino acid-producing soil bacterium Corynebacterium efficiens YS-314 were established. The analysis window covers a pI range from 3 to 7 along with a molecular mass range from 10 to 130 kDa. After second-dimensional separation on SDS-PAGE and Coomassie staining, computational analysis detected 635 protein spots in the cytosolic proteome fraction, whereas 76 and 102 spots were detected in the cell surface and extracellular proteomes, respectively. By means of MALDI-TOF-MS and tryptic peptide mass fingerprinting, 164 cytosolic proteins, 49 proteins of the cell surface and 89 extracellular protein spots were identified, representing in total 177 different proteins. Additionally, reference maps of the three cellular proteome fractions of the close phylogenetic relative Corynebacterium glutamicum ATCC 13032 were generated and used for comparative proteomics. Classification according to the Clusters of Orthologous Groups of proteins scheme and abundance analysis of the identified proteins revealed species-specific differences. The high abundance of molecular chaperones and amino acid biosynthesis enzymes in C. efficiens points to environmental adaptations of this recently discovered amino acid-producing bacterium.     

Identification and characterization of the last two unknown genes,dapC and dapF,in the succinylase branch of the L-lysine biosynthesis of Corynebacterium glutamicum

The inspection of the complete genome sequence of Corynebacterium glutamicum ATCC 13032 led to the identification of dapC and dapF, the last two unknown genes of the succinylase branch of the L-lysine biosynthesis. The deduced DapF protein of C. glutamicum is characterized by a two-domain structure and a conserved diaminopimelate (DAP) epimerase signature. Overexpression of dapF resulted in an 8-fold increase of the specific epimerase activity. A defined deletion in the dapF gene led to a reduced growth of C. glutamicum in a medium with excess carbon but limited ammonium availability. The predicted DapC protein of C. glutamicum shared 29% identical amino acids with DapC from Bordetella pertussis, the only enzymatically characterized N-succinyl-aminoketopimelate aminotransferase. Overexpression of the dapC gene in C. glutamicum resulted in a 9-fold increase of the specific aminotransferase activity. A C. glutamicum mutant with deleted dapC showed normal growth characteristics with excess carbon and limited ammonium. Even a mutation of the two genes dapC and ddh, interrupting both branches of the split pathway, could be established in C. glutamicum. Overexpression of the dapF or the dapC gene in an industrial C. glutamicum strain resulted in an increased L-lysine production, indicating that both genes might be relevant targets for the development of improved production strains.     

Phosphatase activity of the histidine kinases ensures pathway specificity of the ChrSA and HrrSA two‐component systems in Corynebacterium glutamicum

The majority of bacterial genomes encode a high number of two‐component systems controlling gene expression in response to a variety of different stimuli. The Gram‐positive soil bacterium Corynebacterium glutamicum contains two homologous two‐component systems (TCS) involved in the haem‐dependent regulation of gene expression. Whereas the HrrSA system is crucial for utilization of haem as an alternative iron source, ChrSA is required to cope with high toxic haem levels. In this study, we analysed the interaction of HrrSA and ChrSA in C. glutamicum. Growth of TCS mutant strains, in vitro phosphorylation assays and promoter assays of P_hrtBA and P_hmuO fused to eyfp revealed cross‐talk between both systems. Our studies further indicated that both kinases exhibit a dual function as kinase and phosphatase. Mutation of the conserved glutamine residue in the putative phosphatase motif DxxxQ of HrrS and ChrS resulted in a significantly increased activity of their respective target promoters (P_hmuO and P_hrtBA respectively). Remarkably, phosphatase activity of both kinases was shown to be specific only for their cognate response regulators. Altogether our data suggest the phosphatase activity of HrrS and ChrS as key mechanism to ensure pathway specificity and insulation of these two homologous systems.