Principles of insecticide action on mushroom cropping: incorporation into casing

The incorporation of organophosphorous insecticides into the casing layer of mushroom beds reduces the numbers of mushrooms, according to a logistic relationship with log₁₀ (dose). The cumulative numbers at any flush are affected in this way, and the response of individual flushes may, therefore, be represented by the difference between two logistic curves. This explains the observed increases in numbers in the second and third flushes following diazinon treatment and in the fourth following thionazin, pirimiphos-methyl and pirimiphos-ethyl. No compensation in numbers followed chlorfenvinphos treatment. This decreasing response pattern reflected the increasing residual action of the insecticides. Mushroom size was inversely related to numbers but even when numbers in any flush were unaffected by the treatment, there was usually an increase in size. Thus yield increases occurred in most flushes at commercial concentrations of four insecticides (thionazin compensated only in the fourth flush) and total yields were increased by 8 to 13%.     

Effects of the paedogenetic mushroom cecid, Heteropeza pygmaea (Diptera:Cecidomyiidae) on cropping of the cultivated mushroom (Agaricus bisporus)

When introduced into a mushroom crop at rates of 2, 20 or 200 larvae/tray (0.56 m²), the mushroom cecid, Heteropeza pygmaea, caused significant reductions in both yield and number of mushrooms in relation to the infestation level. The reductions were greater when the larvae were introduced at spawning rather than at casing. The yield and number of infested (unmarketable) mushrooms increased significantly in relation to the initial infestation level. Just two H. pygmaea larvae, introduced at spawning, resulted in cecid populations that caused a 12% loss in total yield in addition to a 7% loss due to spoilage. Loss assessment in the future, therefore, should take into account both yield suppression and spoilage. There was little effect of cecid infestation on flush timing and mushroom size was only affected in the fourth flush, when a significant reduction (27%) was shown at the highest infestation rate at spawning.     

Effects of bendiocarb and diflubenzuron on mushroom cropping

When mixed into the casing or compost layers of a mushroom bed in the absence of pests, bendiocarb decreased yield and number of mushrooms according to concentration. The most severe effects were on mushroom number at the two highest rates used (100 and 1000 μg/g), and there were large increases in mushroom size. Effects of bendiocarb incorporation in the compost diminished with time, and there was partial compensation in yield and numbers at the fourth flush. The action of bendiocarb persisted when it was mixed into the casing. Diflubenzuron showed some opposite effects at lower concentrations. When either mixed into, or drenched onto the casing at the commercial rate (30 μg/g), yield and size were both increased and the timing of the flushes was unaffected. At the two higher concentrations (180 and 1080 μg/g), reductions in yield and number and an increase in mushroom size were shown. However, these effects became more severe with time, especially those on mushroom number, possibly due to the accumulation of a toxic breakdown product.     

Comparative effects of Steinernema feltiae (Nematoda: Steinernematidae) and insecticides on yield and cropping of the mushroom Agaricus bisporus

In a mushroom crop (Agaricus bisporus) affected by a very low level of sciarid fly (Lycoriella auripila) infestation, the effects of an indigenous isolate of insect-parasitic nematode (Steinernema feltiae) and of two commonly used insecticides (diazinon and diflubenzuron) were studied. When compared with untreated plots, nematodes applied to the casing had no adverse effects on mushroom yields whereas insecticides decreased yields. At a rate of 3 × 10⁶ infective juveniles per tray (surface area = 0.56 m²), S. feltiae elicited increases of 28.5% and 19% in the mean total numbers and weights of mushrooms respectively. Treatment only with diflubenzuron resulted in 14.6% and 6% reductions in mean total numbers and weights of mushrooms, respectively; treatment with both diazinon and diflubenzuron caused 18.5% and 9.4% losses. Application of nematodes generally reduced the mean weight per mushroom whereas insecticides increased it; nematodes delayed the onset of mushroom production (first flush) whereas diflubenzuron delayed the third and fourth flushes. Nematode contamination of sporophores was minimal when S. feltiae was applied at casing. Although their numbers declined with time, the nematodes persisted, in the casing layer, throughout the cropping period of seven weeks. It is concluded that yield benefits associated with nematode application can result mainly from nematode effects on A. bisporus and not solely from suppression of a damaging pest population.     

Principles of insecticide action on mushroom cropping: incorporation into compost

A series of cropping experiments has demonstrated that mushroom yields show an approximate logistic response to a range of insecticide concentrations incorporated in the compost. This principle applies only to the cumulative yield at any flush, and the response of an individual flush is, therefore, related to the difference between two logistic curves. Increases in crop can thus occur in later flushes, partially compensating for earlier losses. With diazinon treatments, but not thionazin, some of this compensation was due to increases in the size of mushrooms. It is concluded that commercial applications of 50 ppm diazinon could cause up to 2–5 % reduction in crop and that 10 ppm thionazin may cause a 6% loss which must be weighed against the advantages of treatment. Suggestions are made for the design and interpretation of future trials.     

Relative contribution of nematodes (Caenorhabditis elegans) and bacteria towards the disruption of flushing patterns and losses in yield and quality of mushrooms (Agaricus bisporus)

Laboratory tests of bacteria isolated from the body surface, or from the gut, of a saprophagous rhabditid nematode Caenorhabditis elegans infesting mushrooms (Agaricus bisporus) showed that some bacteria enhanced nematode reproduction and that others inhibited it. As some bacteria were shown to inhibit mycelial growth of the mushroom, the effects of Acinetobacter calcoaceticus var. anitratus, Enterobacter cloacae and Serratia liquefaciens, either alone or in combination with C. elegans, on the flushing patterns, quality and yield of A. bisporus (strain Horst U3) were studied. Bacteria alone had little effect on flushing patterns whereas C. elegans delayed the onset of mushroom production and significantly disrupted the growth pattern of crops, with mushrooms appearing more regularly and not within obvious flushes. Inoculation with bacteria resulted in ‘browning’ of mushrooms that was even more pronounced in C. elegans treatments. Characteristic distortion of sporophores was observed only in the presence of C. elegans. Nematodes commonly colonised sporophores. Bacteria affected the size of nematode populations both on the sporophores and in the casing. Significant yield loss occurred; up to 10% when bacteria were inoculated, up to 27.8% when C. elegans was inoculated, and up to 35% with both bacteria and nematodes. Synergism between C. elegans and A. calcoaceticus var. anitratus was observed; the combination resulted in significantly greater reduction in mushroom yield than any other treatment. It is concluded that bacteria contribute to yield loss and quality deterioration in A. bisporus but that the effects are far greater in the presence of C. elegans.     

Influence of Steinernema feltiae and Diflubenzuron on Yield and Economics of the Cultivated Mushroom Agaricus bisporus in Dutch Mushroom Culture

The insect pathogenic nematode Steinernema feltiae (Nematoda: Steinernematidae) was shown to offer an alternative to the use of diflubenzuron for the control of the mushroom fly Lycoriella auripila (Diptera: Sciaridae). The influence of diflubenzuron and S. feltiae treatments on the yield and numbers of the mushroom, Agaricus bisporus , was studied. Applications of diflubenzuron after casing significantly reduced total mushroom yields by 10-13%. The greatest yield reductions were observed in the first flush. In the second flush, high yields were found despite significantly lower numbers of mushrooms. These high yields, however, could not compensate for the yield loss of the first flush. Some of the treatments with S. feltiae significantly increased yields, but these were not associated with a particular time of application. As nematodes did not reduce mushroom yields they were able to compete with diflubenzuron. Although the purchase costs of nematodes were high, their use was more economical than that of diflubenzuron when the yield losses of 10% due to casing treatments were taken into account.     

Re-supplementing and re-casing mushroom (<Emphasis Type="Italic">Agaricus bisporus</Emphasis>) compost for a second crop

Experiments were performed to determine the effect of adding nutrient supplements to colonized mushroom compost (MC) for the production of a second crop of mushrooms. Mushrooms were harvested for 1, 2 or 3 flushes, the casing removed and the MC then was fragmented and re-supplemented with delayed release supplements treated or non-treated with fungicide (thiophanate-methyl; Topsin M 70WP) and re-cased. Overall double-crop yields were higher when MC was re-supplemented after 1st flush (1st flush MC) as compared to re-supplementation after the 2nd or 3rd flushes. Mean double-crop BEs were 128, 119 and 109% when 1st-, 2nd- and 3rd-flush MCs were used, respectively. Treatment of delayed release supplement with thiophanate-methyl fungicide did not affect mushroom yields. Soluble salts and potassium concentrations increased 350 and 900%, respectively, in the casing overlay through three flushes suggesting that removal of the casing would help to alleviate the build up of these potential growth-limiting materials. Re-supplementing and re-casing of MC represents a potential opportunity for growers to increase revenues and reduce costs associated with preparation and disposal of compost. The ability to double-crop mushroom compost would provide growers a chance to increase yields by 40% or more, depending on whether they re-supplement and re-case after 1st, 2nd or 3rd flush.     

Effects of Caenorhabditis elegans (Nematoda: Rhabditidae) on yield and quality of the cultivated mushroom Agaricus bisporus

Thirteen species of saprobic rhabditid nematodes (11 genera) were identified from samples of compost and casing material collected from mushroom farms in the British Isles. Caenorhabditis elegans, the most frequently found saprobe, was mass-produced monoxenically and its effects on the cultivated mushroom, Agaricus bisporus (strain U3) were studied. C. elegans did not multiply in well-prepared, pasteurised, spawned compost, whereas casing material proved to be a highly suitable environment for its reproduction. An initial casing inoculum of 10⁶ nematodes/crate of compost (7.5 kg), caused a significant reduction in mushroom yield. Losses in total mushroom yields of 11%, 20% and 26% were caused by initial inoculum rates of 10⁶, 10⁷and 2 × 10⁷ nematodes/crate, respectively. Yields were negatively correlated with the initial nematode inoculation level and regression equations were derived. The nematode treatments caused fewer mushrooms to be produced and an absence of the usual distinctive flushing patterns. C. elegans caused considerable deterioration in mushroom quality and characteristic distortion of mushrooms. Individual sporophores were mis-shapen, notched and had brown or violet coloured grills. Up to 3.8%, 6.7% and 10.8% of total weight and 3.5%, 5.4% and 8% of total numbers of mushrooms were distorted at the three highest nematode inoculum rates tested. Weights and numbers of distorted mushrooms were positively correlated with the initial nematode population. C. elegans commonly colonised sporophores.     

Comparative effects of three insect growth regulator insecticides and a dipteran-active strain of Bacillus thuringiensis on cropping of the cultivated mushroom Agaricus bisporus

Three insect growth regulator insecticides and an entomopathogenic strain of Bacillus thuringiensis (GC327), products effective against the mushroom sciarid, Lycoriella auripila, were compared for their effect on mushroom cropping. Cyromazine and diflubenzuron were applied as a surface drench to mushroom compost before or after pasteurisation (at filling or spawning, respectively); admixed into casing material (at casing); or at a combination of these times. Hexaflumuron and GC327 were applied only at filling and casing, respectively. The presence of the target pest, L. auripila, had no effect on treatment trends, although it was accounted for in the analysis by use of a yield model. The trial was notable for the disparate effects that cyromazine and diflubenzuron casing treatments had on mushroom cropping. Cyromazine treatments that included application at casing resulted in increases in yield, compared to the untreated control whereas, with diflubenzuron, the opposite was true, with treatment at casing alone causing the greatest reduction overall (10%). GC327 applied at casing was also conspicuous for giving a 13% increase in yield. Treating the crop at casing with either cyromazine or GC327, therefore, resulted in a 15% or 24% increase in yield, respectively, compared to a similar treatment with diflubenzuron. Hexaflumuron applied at filling caused increases in yield compared to application of cyromazine at filling and cyromazine or diflubenzuron at spawning. There were also effects on crop timing. The addition of a cyromazine casing treatment normally caused the distinct flushes of mushrooms to be produced significantly earlier than the untreated control (up to 2.5 days), as did GC327. With diflubenzuron, the earlier flushes were only produced by those treatments that did not include a casing application. The combinations that included a casing treatment with diflubenzuron initially produced mushroom flushes earlier than the untreated control. They became either synchronous with the control or they were delayed. From the crop tolerance perspective, therefore, cyromazine and GC327 would be the sciarid control products of choice for a commercial mushroom grower.     

Variation of Pleurotus ostreatus (Jacq. Ex Fr.) P. Kumm. (1871) performance subjected to differentdoses and timings of nano-urea

Supplementation of the growing substrate by nitrogenous additives has been known to improve the production of oyster mushroom (Pleurotus ostreatus (Jacq. ex Fr.) P. Kumm. (1871)). However, the application of nano-additives has not been reported in such cultivation yet. The study investigated the effect of nano-urea added in two different doses (3 g and 5 g per kg substrate), once (at spawning or after first flush) or twice (at spawning and after first flush) to the growing substrate consisting of wheat straw and spent oyster substrate (1:1, w/w). Results showed that the application of nano-urea once has induced the highest number of mushroom flushes (four flushes) despite the dose applied. Contrarily to early findings, where high doses of nitrogen have caused inhibition of mushroom growth and production, nano-urea application has had better effects when applied twice. With 5 g/kg, it induced the shortest period between the first and the third flush (15 days). With 3 g/kg, it resulted in the highest biological and economic yields at the third flush (332.7 g/bag and 283.1 g/bag respectively), in total (973.4 g/bag and 854.0 g/bag respectively), the highest biological efficiency (109.6%), and pileus diameter/stipe length ratio (2.8). Experimental findings of the current study may be potentially applied at commercial scale.     

Pseudomonas tolaasii control by kasugamycin in cultivated mushrooms (Agaricus bisporus)

Pseudomonas tolaasii , causing brown blotch disease on the edible mushroom Agaricus bisporus , was effectively controlled by kasugamycin. An artificial infection was first established in the first flush, by inoculating the button-sized mushrooms of the first flush with a suspension of Ps. tolaasii. A 1% aqueous solution of kasugamycin supplied on the button-sized mushrooms of the second flush drastically reduced bacterial blotch symptoms on these mushrooms at picking stage. Disease incidence in the second flush in the control treatment (inoculated with Ps. tolaasii ) was composed of 18% lightly, 29% moderately and 10% heavily affected mushrooms, which totalled up to 57% affected. The 1% kasugamycin treatment significantly reduced total disease incidence to only 9% (lightly) affected. Single sodium hypochlorite treatments showed no result.     

Properties of peat-based casing soils and their influence on the water relations and growth of the mushroom (Agaricus bisporus)

Different combinations of peat and chalk or lime sources with differing moisture contents were used to determine how specific physical and chemical properties of the casing soil relate to the growth and water relations of the mushroom. The peat types varied in terms of decomposition and extraction method; the lime addition varied in terms of rate and type (chalk or sugar beet lime). During the colonisation of the casing soil before fruiting, the extension growth rate of mushroom mycelium was most closely correlated (negatively) with the volumetric moisture content of the casing soil. Scanning electron microscopy showed that mycelium growing at a lower casing soil matric potential (Ψ_m) had a much finer and branched structure than mycelium growing at a higher Ψ_m. Across all the peat and lime source treatments, a relationship was found between the mean Ψ_m of the casing soil and mushroom yield, with an optimum Ψ_m of -7.9 to -9.4 kPa. Mushrooms are produced in ‘flushes’ at about 8-day intervals and during the development of each flush of mushrooms, there was a significant decrease in casing soil Ψ_m . This decrease (to below -40 kPa) was greatest in the second flush, which was the highest yielding. There were no relationships between mushroom yield and casing soil osmotic potential Ψ_π within the range -93 to -154 kPa or any of the other chemical properties and water and air holding characteristics of the casing soils which were determined. Across different casing soil treatments, mushroom dry matter content was negatively correlated with mushroom yield and positively correlated with mushroom tissue osmotic potential. This revised version was published online in June 2006 with corrections to the Cover Date.     

Seasonal dynamics, dispersion, sequential sampling plans and treatment thresholds for the citrus leafminer, Phyllocnistis citrella Stainton (Lepidoptera: Gracillariidae), in a mature lemon block in coastal New South Wales, Australia

Abstract  Studies of citrus leafminer in a coastal orchard in NSW, Australia indicated that an increase in abundance to about one mine per flush was followed during the midseason flush by a rapid increase in population that was related to an increase in the percentage of leaves infested within flushes and the number of mines per leaf. The fits of frequency distributions and Iwao's patchiness regression indicated that populations were highly contagious initially, and as the exponent k of the negative binomial distribution increased with increasing population density, the distribution approached random. Concurrently, the coefficient of variation of mines per flush (which was strongly related to the proportion of un-infested flushes) decreased to about unity as the proportion of un-infested flushes reached zero and fell further as the number of mines per flush increased. Both numerative and binomial sequential sampling plans were developed using a decision threshold based on 1.2 mines per flush. The binomial sampling plan was based on a closely fitting model of the functional relationship between mean density and proportion of infested flushes. Functional relationships using the parameters determined from Iwao's patchiness regression and Taylor's power law were equally satisfactory, and one based on the negative binomial model also fitted well, but the Poisson model did not. The three best fitting models indicated that a decision threshold of 1.2 mines per flush was equivalent to 50% of flushes infested. From a practical point of view, the transition from 25% infestation of flushes through 50% is so rapid that it may be prudent to take action when the 25% level is reached; otherwise, the 50% may be passed before the crop is checked again. For valuable nursery stock should infestation be detected in spring, it may be advisable to apply prophylactic treatment as the midseason flush starts.     

Cultivation of the oyster mushroom (Pleurotus ostreatus) on wood substrates in Hawaii

Summary Five non-native, aggressively growing trees, Falcataria moluccana (Miquel) Barneby & Grimes, Casuarina equisetifolia L. ex J. R. & G. Forst, Eucalyptus grandis Hill ex Maid, Psidium cattleianum Sabine, and Trema orientalis (L.) Blume, were evaluated for suitability as substrate for outdoor cultivation of the oyster mushroom, Pleurotus ostreatus (Jacq.: Fr.) Kumm., in Hawaii. An existing shade house was modified for mushroom production and proved to be an adequate fruiting site. Nitrogen-fixing trees (C. equisetifolia, T. orientalis, and F. moluccana) supported greater yield (275.5, 272.4 and 268.8 g/bag, respectively), biological efficiency (70.1, 78.5, and 74.0%, respectively), and flush number (3.0, 3.2, and 3.5) than non-fixers. P. cattleianum supported significantly lower yield (190.5 g/bag) and biological efficiency (44.2%). Mean crop period was 51 days and was not affected by the wood substrate. Similarly, substrate did not have a significant impact on the concentration of nutrients or moisture in fruit bodies. Taste preferences were noted in mushrooms grown on different substrates; those grown on C. equisetifolia were most flavourful and preferred in one taste test.     

Development and growth of fruit bodies and crops of the button mushroom, Agaricus bisporus

We studied the appearance of fruit body primordia, the growth of individual fruit bodies and the development of the consecutive flushes of the crop. Relative growth, measured as cap expansion, was not constant. It started extremely rapidly, and slowed down to an exponential rate with diameter doubling of 1.7 d until fruit bodies showed maturation by veil breaking. Initially many outgrowing primordia were arrested, indicating nutritional competition. After reaching 10 mm diameter, no growth arrest occurred; all growing individuals, whether relatively large or small, showed an exponential increase of both cap diameter and biomass, until veil breaking. Biomass doubled in 0.8 d. Exponential growth indicates the absence of competition. Apparently there exist differential nutritional requirements for early growth and for later, continuing growth. Flushing was studied applying different picking sizes. An ordinary flushing pattern occurred at an immature picking size of 8 mm diameter (picking mushrooms once a day with a diameter above 8 mm). The smallest picking size yielded the highest number of mushrooms picked, confirming the competition and arrested growth of outgrowing primordia: competition seems less if outgrowing primordia are removed early. The flush duration (i.e. between the first and last picking moments) was not affected by picking size. At small picking size, the subsequent flushes were not fully separated in time but overlapped. Within 2 d after picking the first individuals of the first flush, primordia for the second flush started outgrowth. Our work supports the view that the acquisition of nutrients by the mycelium is demand rather than supply driven. For formation and early outgrowth of primordia, indications were found for an alternation of local and global control, at least in the casing layer. All these data combined, we postulate that flushing is the consequence of the depletion of some unknown specific nutrition required by outgrowing primordia.     

The effect of some microphagous saprobic nematodes on mushroom culture

When added to spawned mushroom compost the microphagous saprobic nematodes Pelodera cylindrica, Mesorhabditis spiculigera and Acrobeloides bütschlii did not affect mycelial growth or compost pH. The eelworms multiplied at first but their numbers declined as the mycelium colonized the compost. In contrast, the fungal-feeding Aphelenchoides composticola increased rapidly and destroyed the mycelium. Excess water, and the presence of the fungal competitor of mushroom, Chaetomium olivaceum, allowed some increase of the microphagous forms. Different numbers of Mesorhabditis spiculigera added to the ‘casing’ had no effect on mushroom yield but the mushroom ‘flushes’ seemed less pronounced. Reasons for the failure of the saprobic eelworms to affect mushroom, and the possibility of synergistic pathogenicity by these eelworms and bacteria, are discussed.     

Cultivation of the Dible Mushroom Lentinula edodes (Shiitake) in Pasteurized Wheat Straw – Alternative Use of Georthermal Energy in Mexico

Five edible Lentinula edodes strains were evaluated. The mushrooms were cultivated on a wheat straw substrate that was previously pasteurized by immersion in water heated by residual geothermal vapor, which was also used to warm incubation and production rooms. Finely chopped wheat straw (Triticum aestivum L.) was pasteurized and then spawned with supplemented spawn capable of supplying nutrients and enriching the substrate, with the expectation of yield improvement. The samples were incubated for 60 days before the production started and thus, the mushrooms produced had pileus diameters ranging from 5 to 20 cm. The yields fluctuated from 6.2 to 13.9 % (fresh weight of mushrooms/fresh weight of substrate). Biological efficiency ranged from 24.8 to 55.6 % (fresh weight of mushrooms/dry weight of substrate), while the production rate reached varied from 0.19 to 0.55 % (biological efficiency/production time starting from inoculation). The cultivation system evaluated here offers the possibility of lowering production costs by cultivating the mushroom on easily obtainable substrate and shortening the culture cycle. The efficiency of this use of geothermal energy and supplemented spawn for shiitake mushroom cultivation on non‐sterilized substrates was proven.     

Oyster mushroom cultivation with rice and wheat straw

Cultivation of the oyster mushroom, Pleurotus sajor-caju, on rice and wheat straw without nutrient supplementation was investigated. The effects of straw size reduction method and particle size, spawn inoculation level, and type of substrate (rice straw versus wheat straw) on mushroom yield, biological efficiency, bioconversion efficiency, and substrate degradation were determined. Two size reduction methods, grinding and chopping, were compared. The ground straw yielded higher mushroom growth rate and yield than the chopped straw. The growth cycles of mushrooms with the ground substrate were five days shorter than with the chopped straw for a similar particle size. However, it was found that when the straw was ground into particles that were too small, the mushroom yield decreased. With the three spawn levels tested (12%, 16% and 18%), the 12% level resulted in significantly lower mushroom yield than the other two levels. Comparing rice straw with wheat straw, rice straw yielded about 10% more mushrooms than wheat straw under the same cultivation conditions. The dry matter loss of the substrate after mushroom growth varied from 30.1% to 44.3%. The straw fiber remaining after fungal utilization was not as degradable as the original straw fiber, indicating that the fungal fermentation did not improve the feed value of the straw.