Lipase catalysed synthesis of propanediol monoesters in biphasic aqueous medium

The 1,3-regiospecific lipase from Candida deformanscatalysed the esterification of oleic acid and propanediol in biphasic aqueous/lipid medium without organic solvent. The highest conversion of oleic acid into 1,2-propanediol ester was 74% in 24 h with 6.25 mol/l 1,2-propanediol and 0.08 mol/l oleic acid, and produced 100% monoester. The esterification of 1,3-propanediol converted up to 98% of oleic acid into esters in 24 h (with 7.5 mol/l 1,3-propanediol and 0.08 mol/l oleic acid) and formed 35-90% monoester depending on 1,3-propanediol initial concentration (2.5-10 mol/l).     

Effect of glucose on glycerol metabolism by Clostridium butyricum DSM 5431

The levels of 1,3-propanediol dehydrogenase and of the glycerol dehydrogenase in Clostridium butyricum grown on glucose–glycerol mixtures were similar to those found in extracts of cells grown on glycerol alone, which can explain the simultaneous glucose–glycerol consumption. On glycerol, 43% of glycerol was oxidized to organic acids to obtain energy for growth and 57% to produce 1,3-propanediol. With glucose–glycerol mixtures, glucose catabolism was used by the cells to produce energy through the acetate–butyrate production and NADH, whereas glycerol was used chiefly in the utilization of the reducing power since 92–93% of the glycerol flow was converted through the 1,3-propanediol pathway. The apparent K _ms for the glycerol dehydrogenase was 16-fold higher for the glycerol than that for the glyceraldehyde in the case of the glyceraldehyde-3-phosphate dehydrogenase and fourfold higher for the NAD⁺, providing an explanation for the shift of the glycerol flow toward 1,3-propanediol when cells were grown on glucose–glycerol mixtures.     

Evaluation of liquid extraction potentials for downstream separation of 1,3-propanediol

The application of liquid-liquid extraction for the downstream separation of 1,3-propanediol from dilute aqueous solutions has been tested. Preliminary solvent screening was performed using the group contribution method. Experimental verification of the predictions revealed that the distribution of 1,3-propanediol into organic solvents is not good enough to make simple extraction efficient.     

Studies on purification of 1,3-propanediol by molecular distillation

The separation of 1,3-propanediol using molecular distillation has been studied. The effects of operating temperature and feed flow rate through a sequential distillation strategy were investigated. The optimal experimental temperature was at 70°C for separating 1,3-propanediol and the by-product 2,3-butanediol. Meanwhile, the volume flow rate was 10 mL/min. As a result, the recovery of 1,3-propanediol and 2,3-butanediol were 87.6 and 87.5%, respectively. Furthermore, the integrated separation characteristic of 1,3-propanediol was evaluated through macrolevel and micro-level models. The separation factors of 1,3-propanediol versus 2,3-butanediol and glycerol were 0.11 and 1.07, respectively, affirming that the separation of 1,3-propanediol by molecular distillation was feasible.     

Enhanced 1,3-propanediol production in recombinant <Emphasis Type="Italic">Klebsiella pneumoniae</Emphasis> carrying the gene <Emphasis Type="Italic">yqh</Emphasis>D encoding 1,3-propanediol oxidoreductase isoenzyme

The yqhD gene from Escherichia coli encoding 1,3-propanediol oxidoreductase isoenzyme (PDORI) and the tetracycline resistant gene (tetR) from plasmid pHY300PLK were amplified by PCR. They were inserted into vector pUC18, yielding the recombinant expression vector pUC18-yqhD-tetR. The recombinant vector was then cloned into Klebsiella pneumoniae ME-308. The overexpression of PDORI in K. pneumoniae surprisingly led to higher 1,3-propanediol production. The final 1,3-propanediol concentration of recombinant K. pneumoniae reached 67.6 g/l, which was 125.33% of that of the original strain. The maximum activity of recombinant PDORI converting 3-HPA to 1,3-PD reached 110 IU/mg after induction by IPTG at 31°C during the fermentation, while it was only 11 IU/mg under the same conditions for the wild type strain. The K _m values of the purified PDORI for 1,3-propanediol and NADP were 12.1 mM and 0.15 mM, respectively. Compared with the original strains, the concentration of the toxic intermediate 3-hydroxypropionaldehyde during the fermentation was also reduced by 22.4%. Both the increased production of 1,3-propanediol and the reduction of toxic intermediate confirmed the significant role of 1,3-propanediol oxidoreductase isoenzyme from E. coli in converting 3-hydroxypropionaldehyde to 1,3-propanediol for 1,3-PD production.     

A novel downstream process for 1,3-propanediol from glycerol-based fermentation

In this paper, a downstream process for purification of 1,3-propanediol from glycerol-based fermentation broth was investigated. The purification of 1,3-propanediol from fermentation broth was achieved by a process combining microfiltration, charcoal treatment, vacuum distillation, and silica gel chromatography. The broth was first filtered through hollow fiber cartridge, wherein 98.7% of biomass was removed. Soluble proteins and other color impurities in the broth were removed by the use of activated charcoal at optimal concentration of 30 g l⁻¹ where the soluble proteins in the broth decreased to 0.1 g l⁻¹ (96.0% protein loss). The obtained broth when concentrated by vacuum distillation resulted in the crystallization of inorganic salts. Subsequently, 1,3-propanediol was purified by gradient chromatography using silica gel as a stationary phase and mixture of chloroform and methanol as a mobile phase. Finally, with the optimal flow rate of 10 ml min⁻¹ and loading amount of 80 ml, the yield of 1,3-propanediol achieved was 89%. The overall yield of 1,3-propanediol using the proposed procedure was 75.47%. The developed method was found to be a simple, rapid, and efficient procedure for the purification of 1,3-propanediol from fermentation broth.     

产1,3-丙二醇菌株的诱变和筛选

为提高克雷伯氏肺炎杆菌产1,3-丙二醇的能力,以离子束、紫外线和氯化锂为复合诱变法,建立了产酸圈和产物耐受相结合的平板筛选方法,获得可耐受高浓度1,3-丙二醇并且副产物中乙醇含量较少的优良突变菌株2株。与出发菌株相比,两株高产突变菌株Klebsiella pneumoniae LM 03和Klebsiella pneumoniae LM05的1,3-丙二醇产量分别提高了33% 和30% ,达到66.74 g/L和65.12 g/L;乙醇产量分别降低了38% 和24% ,降低为6.59 g/L和8.05 g/L。同时测定了诱变前后还原途径中甘油脱水酶（GDHt）和1,3-丙二醇氧化还原酶（PDOR）的酶活变化,研究表明诱变对GDHt有明显的促进作用,而对PDOR的影响不明显。该诱变和筛选方法目标明确、易操作、效率高,在1,3-PD工业规模的生物法生产中将具有良好的应用价值,而且对于其他具有工业应用价值的菌株筛选工作也具有一定的借鉴意义。     

聚羟基丁酸路径在克雷伯氏菌中的构建

以生物柴油的副产物甘油生产高附加值的1,3-丙二醇,现已成为提升生物柴油产业链经济性的重要途径,而中间代谢产物3-羟基丙醛积累造成细胞死亡,发酵异常终止是生物法生产1,3-丙二醇过程中的关键问题。不同于传统的降低3-羟基丙醛积累的思路,本文从增强克雷伯氏菌对3-羟基丙醛的抗逆性出发,改善克雷伯氏菌1,3-丙二醇的生产性能,首次将聚羟基丁酸路径引入克雷伯氏菌中,构建了新型基因工程菌,并对其1,3-丙二醇发酵性能及聚羟基丁酸代谢进行了初步的研究。经IPTG诱导,工程菌中检测到聚羟基丁酸,其含量随IPTG浓度增加而增大。优化的IPTG浓度为0.5 mmol/L。初始甘油50 g/L时,野生菌可正常发酵生产1,3-丙二醇,1,3-丙二醇浓度达到22.1 g/L,其质量得率为46.4%。当初始甘油达到70 g/L时,由于高浓度3-HPA积累,野生菌发酵终止,而工程菌可正常发酵生产1,3-丙二醇,PDO产量可达31.3 g/L,其质量得率为43.9%。同时检测到聚羟基丁酸积累。研究结果有助于加深对克雷伯氏菌1,3-丙二醇代谢机理的认识,为克雷伯氏菌的进一步优化提供了新的思路。     

产1,3-丙二醇基因工程菌发酵条件的研究

利用途径工程的方法,将来源于克雷伯氏菌(Klebsiella pneumoniae)的甘油脱水酶基因dhaB和1,3-丙二醇氧化还原酶基因dhaT构建成多顺反子重组质粒pSE-dhaB-dhaT并在大肠杆菌JM 109中进行表达,在大肠杆菌中构建一条新的产1,3-丙二醇代谢途径。研究表明,重组菌株JM 109/pSE-dhaB-dhaT在微好氧条件下,尝试用廉价的乳糖为诱导物、维生素B12为辅酶,可以将甘油转化为1,3-丙二醇,产量达15.34 g/L,甘油转化率为35.7%,对低成本生产1,3-丙二醇作了有益的探索。     

Cell physiology and metabolic flux response of Klebsiella pneumoniae to aerobic conditions

Cell physiology and metabolic flux distribution of Klebsiella pneumoniae under anaerobic, micro-aerobic and sufficient aerobic conditions were compared. Comparing with the anaerobic condition, the carbon flux flowed from glycerol to biomass increased 10.1% and 389.9%, while the flux flowed to 1,3-propanediol decreased 10.3% and 92.9% under micro-aerobic and sufficient aerobic conditions, respectively. Furthermore, the carbon flux flowed to TCA cycle increased 5.9% and 31.0% under such two conditions. The energy analysis results revealed that the oxygen was favorable for the NADH₂ synthesis, but excessive oxygen was disadvantage for the NADH₂ utilization in 1,3-propanediol synthesis process. So, the aeration control is significant for the aerobic 1,3-propanediol fermentation. This work is considered helpful for the further understanding of the glycerol metabolism by Klebsiella pneumoniae under aerobic condition and to establish a rational aeration control strategy for 1,3-propanediol aerobic fermentation in a large-scale bioreactor.     

Selective lipase-catalyzed preparation of diol monobenzoates by transesterification and alcoholysis reactions in organic solvents

Lipases from Mucor miehei (MML) and Candida antarctica (CAL) are able to catalyze the monobenzoylation of the primary hydroxy group of 1,2- 1,4- or 1,5-diols with vinyl benzoate in an organic solvent, the reaction proceeding with high regioselectivity and moderate enantioselectivity. The lipase-catalyzed debenzoylation of 1,2-propanediol dibenzoate by alcoholysis with 1-octanol most satisfactorily occurred with Pseudomonas cepacia lipase absorbed onto celite that allowed also to prepare (R)-1-benzoyloxy-2-methylpropan-3-ol from 2-methyl-1,3-propanediol dibenzoate, a result complementary to MML-catalyzed benzoylation of 2-methyl-1,3-propanediol that affords the (S)-monobenzoate.     

异源表达木糖异构酶基因对克雷伯氏菌合成1,3-丙二醇的影响

【目的】提高克雷伯氏菌胞内还原力以强化1,3-丙二醇合成。【方法】将来源于大肠杆菌的木糖异构酶基因在克雷伯氏菌中异源表达,构建重组菌。研究重组菌添加不同浓度木糖为辅底物与甘油共发酵过程中代谢产物和NADH的变化规律。【结果】与对照菌相比,重组菌细胞内还原力NADH提高了0.1?0.3倍,1,3-丙二醇产量达到23.31 g/L,提高20%,1,3-丙二醇转化率从0.60 mol/mol提高到0.73 mol/mol。【结论】木糖异构酶基因的表达强化了木糖代谢途径,经磷酸戊糖途径积累大量还原力,促进了1,3-丙二醇的生成。     

香茅醛缩醛类化合物的合成及其对小黄家蚁的驱避活性

【目的】香茅醛类化合物具有较好的蚂蚁驱避活性,本研究旨在筛选具有良好驱避活性的新的萜类蚂蚁驱避剂。【方法】以香茅醛为原料合成了香茅醛二甲缩醛、香茅醛二乙缩醛、香茅醛二正丙缩醛、香茅醛二异丁缩醛、香茅醛乙二缩醛、香茅醛1,2-丙二缩醛和香茅醛1,3-丙二缩醛等化合物。所得产品经纯化后,用IR, MS, ¹H NMR及¹³C NMR进行结构表征,并在不同浓度下对小黄家蚁Monomorium pharaonis进行驱避活性测试。【结果】各化合物对小黄家蚁具有一定的驱避活性：在10 mg/mL的浓度下,除香茅醛二甲缩醛以外,其他化合物的驱避率均达到70%以上,其中香茅醛二乙缩醛、香茅醛乙二缩醛和香茅醛1,3-丙二缩醛对小黄家蚁的驱避率分别为87.47%,100%和97.53%。浓度为2.5 mg/mL时,其中5个化合物的驱避效果明显下降,但香茅醛乙二缩醛和香茅醛1,3-丙二缩醛仍然表现出很好的驱避活性,驱避率分别为85.33%和97.10%。方差分析也表明,香茅醛1,3-丙二缩醛在同一浓度下驱避效果最佳,其次是香茅醛乙二缩醛。【结论】结果说明,香茅醛二乙缩醛、香茅醛乙二缩醛和香茅醛1,3 丙二缩醛可以用作小黄家蚁驱避剂,而香茅醛乙二缩醛和香茅醛1,3-丙二缩醛可以达到更好的驱避效果,使用浓度为2.5 mg/mL即可。本研究为良好萜类蚂蚁驱避剂的筛选提供了参考依据。     

Production of trimethylolpropane esters of rapeseed oil fatty acids by immobilized lipase

The polyol, trimethylolpropane (2-ethyl-2-hydroxymethyl-1,3-propanediol), and a mixture of rapeseed oil fatty acid methyl esters were transesterified by immobilized lipases without additional organic solvent. The conversion to the polyol tri-ester with immobilized Rhizomucor mieheilipase Lipozyme IM 20 was about 75% after 24 h at 58°C, 5.3 kPa, with no added water, and the highest conversion of about 90% was reached in 66 h.     

1,3-丙二醇发酵液后提取技术研究进展

1,3-丙二醇是一种重要的化工原料,以甘油或葡萄糖为原料发酵法制备1,3-丙二醇具有原料可再生、反应条件温和等优点,是近年来国内外的研究热点。由微生物发酵获得的1,3-丙二醇发酵液是含多种强极性的醇及盐类的稀溶液,这使得采用传统的分离方法难以经济、有效地的将1,3-丙二醇从发酵液中纯化出来,后提取过程成为发酵法工业化生产1,3-丙二醇的瓶颈。1,3-丙二醇后提取过程主要包括微生物菌体等高分子物质的去除,盐的去除、回收,有机物的纯化和水的去除。以下对应用于以上分离过程的技术的研究进展进行讨论,提出在该领域应该重视的发展方向。     

利用PDOR同工酶基因yqhD对产1,3-丙二醇克雷伯氏杆菌进行基因工程改造

由于Klebsiella pneumoniae 1,3-丙二醇合成途径中,加强甘油脱水酶基因表达,导致因NADH供应不足使3-羟基丙醛累积,并对菌体生长及1,3-丙二醇合成造成负面影响。为改善Klebsiella pneumoniae 1,3-丙二醇合成途径,本文利用PCR技术从大肠杆菌(Escherichia coli)中扩增出以NADPH 为辅酶的1,3-丙二醇氧化还原酶同工酶编码基因yqhD,从克雷伯氏杆菌中扩增出2.66kb的甘油脱水酶基因（dhaB）,构建了产1,3-丙二醇关键酶基因的串联载体pEtac-dhaB-tac-yqhD,并将其转入到野生克雷伯氏杆菌(Klebsiella pneumoniae)中,重组载体得到了表达。通过初步发酵,重组后的克雷伯氏杆菌产量比原始菌高20%左右,副产物中乙酸和丁二醇分别下降30%左右。     

Glycerol and propanediols degradation by Desulfovibrio alcoholovorans in pure culture in the presence of sulfate, or in syntrophic association with Methanospirillum hungatei

Abstract In a mineral medium containing sulfate as terminal electron acceptor, the sulfate-reducing bacterium Desulfovibrio alcoholovorans oxidized stoichiometrically 1 mol glycerol to 1 mol acetate and 1 mol 1,3-propanediol to 1 mol acetate with the concomitant reduction of 0.75 and 1 mol sulfate, respectively; 1 mol 1,2-propanediol was degraded to 0.8 mol acetate and 0.1 mol proprionate, with the reduction of approximately 1 mol sulfate. The maximum specific growth rates (μ_max in h⁻¹) were 0.22, 0.086 and 0.09 with glycerol, 1,3-propanediol and 1,2-propanediol, respectively. The growth yields were 12.7 g, 11.1 g and 7.2 g dry weight/mol 1,3-propanediol, glycerol and 1,2-propanediol degraded, respectively. The growth yields and maximum specific growth rates of the H₂-transferring associations were also calculated. In the absense of sulfate, all these reduced substrates were degraded to acids and methane when D. alcoholovorans was cocultured with Methanospirillum hungatei . Changes in the metabolic pathway were observed in the degradation of 1,2- and 1,3-propanediol. The metabolic efficiency of D. alcoholovorans to degrade glycerol, 1.2- and 1,3-propanediol is discussed.     

Structural and biochemical characterisation of a NAD+-dependent alcohol dehydrogenase from Oenococcus oeni as a new model molecule for industrial biotechnology applications

Alcohol dehydrogenases are highly diverse enzymes catalysing the interconversion of alcohols and aldehydes or ketones. Due to their versatile specificities, these biocatalysts are of great interest for industrial applications. The adh3-gene encoding a group III alcohol dehydrogenase was isolated from the gram-positive bacterium Oenococcus oeni and was characterised after expression in the heterologous host Escherichia coli. Adh3 has been identified by genome BLASTP analyses using the amino acid sequence of 1,3-propanediol dehydrogenase DhaT from Klebsiella pneumoniae and group III alcohol dehydrogenases with known activity towards 1,3-propanediol as target sequences. The recombinant protein was purified in a two-step column chromatography approach. Crystal structure determination and biochemical characterisation confirmed that Adh3 forms a Ni²⁺-containing homodimer in its active form. Adh3 catalyses the interconversion of ethanol and its corresponding aldehyde acetaldyhyde and is also capable of using other alcoholic compounds as substrates, such as 1,3-propanediol, 1,2-propanediol and 1-propanol. In the presence of Ni²⁺, activity increases towards 1,3-propanediol and 1,2-propanediol. Adh3 is strictly dependent on NAD⁺/NADH, whereas no activity has been observed with NADP⁺/NADPH as co-factor. The enzyme exhibits a specific activity of 1.1 U/mg using EtOH as substrate with an optimal pH value of 9.0 for ethanol oxidation and 8.0 for aldehyde reduction. Moreover, Adh3 exhibits tolerance to several metal ions and organic solvents, but is completely inhibited in the presence of Zn²⁺. The present study demonstrates that O. oeni is a group III alcohol dehydrogenase with versatile substrate specificity, including Ni²⁺-dependent activity towards 1,3-propanediol.     

1,3-丙二醇产生菌的诱变育种及培养基优化

以实验室自然筛选的克雷伯氏杆菌(Klebsiella sp.)为出发株,采用紫外诱变及亚硝基胍和超声波协同处理获得一株1,3-丙二醇高产突变株。在摇瓶发酵中,其产1,3-丙二醇产量由17.39 g/L提高到24.11 g/L,提高38.64%。变异株经10次传代培养,发酵能力稳定。对发酵培养基成分进行了优化,优化后1,3-丙二醇产量为30.05g/L,为优化前的1.25倍。