Purification and properties of a novel raw starch degrading-cyclodextrin glycosyltransferase from Klebsiella pneumoniae AS- 22

A novel raw starch degrading α-cyclodextrin glycosyltransferase (CGTase; E.C. 2.4.1.19), produced by Klebsiella pneumoniae AS-22, was purified to homogeneity by ultrafiltration, affinity and gel filtration chromatography. The specific cyclization activity of the pure enzyme preparation was 523 U/mg of protein. No hydrolysis activity was detected when soluble starch was used as the substrate. The molecular weight of the pure protein was estimated to be 75 kDa with SDS-PAGE and gel filtration. The isoelectric point of the pure enzyme was 7.3. The enzyme was most active in the pH range 5.5–9.0 whereas it was most stable in the pH range 6–9. The CGTase was most active in the temperature range 35–50°C. This CGTase is inherently temperature labile and rapidly loses activity above 30°C. However, presence of soluble starch and calcium chloride improved the temperature stability of the enzyme up to 40°C. In presence of 30% (v/v) glycerol, this enzyme was almost 100% stable at 30°C for a month. The K_m and k_cat values for the pure enzyme were 1.35 mg ml⁻¹ and 249 μM mg⁻¹ min⁻¹, respectively, with soluble starch as the substrate. The enzyme predominantly produced α-cyclodextrin without addition of any complexing agents. The conditions employed for maximum α-cyclodextrin production were 100 g l⁻¹ gelatinized soluble starch or 125 g l⁻¹ raw wheat starch at an enzyme concentration of 10 U g⁻¹ of starch. The α:β:γ-cyclodextrins were produced in the ratios of 81:12:7 and 89:9:2 from gelatinized soluble starch and raw wheat starch, respectively.     

Production of an amylase-degrading raw starch by Gibberella pulicaris

An endophytic fungus, Gibberella pulicaris, produced an amylase which degraded raw starches from cereals and other crops including raw potato, sago, tapioca, corn, wheat and rice starch. In each case, glucose was the main product. Among the raw starches used, raw potato starch gave the highest enzyme activity (85 units mg^–1 protein) and raw wheat starch the lowest (49 units mg^–1 protein). The highest amylase production (260 units mg^–1 protein) was achieved when the concentration of raw potato starch was increased to 60 g l^–1. Optimum hydrolysis was at 40°C and pH 5.5.     

Identification of three proteins up-regulated by raw starch in Cytophaga sp.

Raw starch-digesting amylases (RSDAs) in many microorganisms convert starch granules into maltodextrins and simple sugars. We cloned and sequenced from Cytophaga sp. an RSDA with an excellent raw starch digestion activity. This RSDA was highly inducible by raw starch, but not by other sugars, suggesting that an unknown signal transduction mechanism is involved in the degradation of raw starch. We used a proteomic approach to investigate the effect of raw starch on protein expression in Cytophaga sp. Using MALDI–TOF MS protein analysis, we have identified three proteins up-regulated by raw starch, i.e., a 60-kDa chaperonin (cpn60), glutaminase, and pyruvate phosphate dikinase (PPDK). Subsequent time-course studies detected an increased expression of RSDA as well as the highest expression of PPDK occurring 6 h post-incubation with raw corn starch, implying that the latter enzyme may work along with RSDA on the digestion of raw starch. Finding these proteins up-regulated by raw starch may provide an insight into how Cytophaga sp. cells respond to raw starch stimulation.     

Improved production of an enzyme that hydrolyses raw yam starch by Penicillium sp. S-22 using fed-batch fermentation

A newly isolated strain, Penicillium sp. S-22, was used to produce an enzyme that hydrolyses raw yam starch [raw yam starch digesting enzyme (RYSDE)]. The enzyme activity and overall enzyme productivity were respectively 16 U/ml and 0.19 U/ml h in the batch culture. The enzyme activity increased to 85 U/ml by feeding of partially hydrolyzed raw yam starch. When a mixture containing partially hydrolyzed raw yam starch and peptone was fed by a pH-stat strategy, the enzyme activity reached 366 U/ml, 23-fold of that obtained in the batch culture, and the overall productivity reached 3.4 U/ml h, which was 18-fold of that in the batch culture.     

Characterization of an organic solvent‐tolerant thermostable glucoamylase from a halophilic isolate,Halolactibacillus sp. SK71 and its application in raw starch hydrolysis for bioethanol production

A halophilic bacterium Halolactibacillus sp. SK71 producing extracellular glucoamylase was isolated from saline soil of Yuncheng Salt Lake, China. Enzyme production was strongly influenced by the salinity of growth medium with maximum in the presence of 5% NaCl. The glucoamylase was purified to homogeneity with a molecular mass of 78.5 kDa. It showed broad substrate specificity and raw starch hydrolyzing activity. Analysis of hydrolysis products from soluble starch by thin‐layer chromatography revealed that glucose was the sole end‐product, indicating the enzyme was a true glucoamylase. Optimal enzyme activity was found to be at 70°C, pH 8.0, and 7.5% NaCl. In addition, it was highly active and stable over broad ranges of temperature (0–100°C), pH (7.0–12.0), and NaCl concentration (0–20%), showing excellent thermostable, alkali stable, and halotolerant properties. Furthermore, it displayed high stability in the presence of hydrophobic organic solvents. The purified glucoamylase was applied for raw corn starch hydrolysis and subsequent bioethanol production using Saccharomyces cerevisiae. The yield in terms of grams of ethanol produced per gram of sugar consumed was 0.365 g/g, with 71.6% of theoretical yield from raw corn starch. This study demonstrated the feasibility of using enzymes from halophiles for further application in bioenergy production. © 2014 American Institute of Chemical Engineers Biotechnol. Prog., 30:1262–1268, 2014     

Supercritical carbon dioxide (scCO2) induced gelatinization of potato starch

The degree of gelatinization (DG) of potato starch after treatment with scCO₂ was investigated. A broad range of experimental conditions were applied, including variations in temperature (50–90 °C), pressure (0.1–25 MPa), and the starch water content (16.2–40% wt/wt). Changes in the DG were observed by in situ FT-IR measurements, DSC and confirmed by the XRD analysis. The DG increases at higher temperatures and pressures. A maximum DG of about 14% was achieved at the highest pressure (25 MPa) and temperature in the range (90 °C). A series of experiments under N₂ pressure confirms that scCO₂ plays a special role in the gelatinization process.     

Resistant glutarate starch from adlay: Preparation and properties

Reaction conditions were optimized to increase the content of resistant starch in adlay starch using esterification with glutaric acid, and the physicochemical properties of the prepared glutarate starches were investigated. Different amounts of glutaric acid (0.1–0.5 g/g starch, dry weight basis) were reacted with adlay starch at various temperatures (70–130 °C) and reaction times (3–9 h). The resistant starch levels increased with increased glutaric acid content, reaction temperature, and reaction time. The color difference was mainly affected by reaction time. The highest resistant starch content (RS 66%) was obtained using conditions of 0.4 g glutaric acid/g starch, 115 °C, and 7.5 h, with a color difference of 10.24. After digestion with α-amylase and amyloglucosidase, the water-soluble fraction of glutarate starch had more oligosaccharides than high-amylose maize starch (RS 43%). FT-IR and solid-state NMR detected carbonyl groups in the glutarate starch, indicating the formation of cross-linkages through esterification. The granular structure of the glutarate starches was not destroyed and they retained birefringence. After heating with an excess of water, the granules kept their shape but lost their birefringence. The glutarate starches had low solubility in both cold and hot water, and the resistant starch contents were unchanged after heating due to the restriction of swelling by cross-linking. The glutarate starches had a similar chain-length distribution to raw starch, indicating that acid hydrolysis took place at branching points in the amorphous region. Furthermore, the glutarate starches possessed a weaker crystalline region, more diverse double helical chains, and lower enthalpy than raw starch.     

Isolation and partial characterization of three isoamylases of Rhyzopertha dominica F. (Coleoptera: Bostrichidae)

Three isoamylases of Rhyzopertha dominica (termed RdA70, RdA79, and RdA90 according to their relative mobility in gel electrophoresis) were isolated by ammonium sulfate fractionation and hydrophobic interaction chromatography. RdA70 and RdA79 showed an optimal pH of 7.0, whereas for RdA90 the optimal pH was 6.5. The three isoamylases remained stable at 50 °C for 1 h, but at 60 °C, all lost 50% of their activity in 20 min and were completely inactivated in 1 h. RdA70 and RdA79 were inhibited by albumin extracts from wheat samples varying widely in amylase inhibitory activity; however, RdA90 was highly resistant to inhibition. β-Mercaptoethanol up to 30 mM increased the activity of the three isoamylases by 2.5-fold. The action pattern of the three isoamylases was typical of endoamylases; however, differences were observed on the hydrolytic efficiency rates measured as V_max/K_m ratio on starch, amylopectin, and amylose. The hydrolyzing action of RdA90 on starch and amylopectin (V_max/K_m = 90.4 ± 2.3 and 78.9 ± 6.6, respectively) was less efficient than that on amylose (V_max/K_m = 214 ± 23.2). RdA79 efficiently hydrolyzed both amylopectin and amylose (V_max/K_m = 260.6 ± 12.9 and 326.5 ± 9.4, respectively). RdA70 hydrolyzed starch and amylose at similar rates (V_max/K_m = 202.9 ± 5.5 and 215.9 ± 6.2, respectively), but amylopectin was a poor substrate (V_max/K_m = 124.2 ± 7.4). The overall results suggest that RdA70 and RdA79 appear to belong to a group of saccharifying isoamylases that breaks down long fragments of oligosaccharide chains produced by the hydrolytic action of RdA90. The simultaneous action of the three isoamylases on starch, aside from the high resistance of RdA90 to wheat amylase inhibitors, might allow R. dominica to feed and reproduce successfully on the wheat kernel.     

Crosslinked potato starch as an affinity adsorbent for bacterial α-amylase

Crosslinked potato starch was prepared as an affinity adsorbent for bacterial α-amylase. To this end, reaction parameters for crosslinking in an ethanol/water solvent were investigated. The degree of crosslinking, and consequently the suitability of crosslinked starch as an adsorbent for α-amylase, changed by altering these parameters. An increase in the degree of crosslinking of the adsorbent caused lower affinity for bacterial α-amylase which resulted in an unfavourable decrease in adsorption capacity and a favourable decrease in the degradation of the adsorbent by the enzyme. 1 g of a suitable adsorbent for bacterial α-amylase, prepared with an epichlorohydrin/glucose monomer ratio of 0·65 (starch concentration 150 mg/ml, ethanol/water ratio 2·0, sodium hydroxide/epichlorohydrin ratio 1·0), can adsorb 9·8 mg of an α-amylase from B. licheniformis at 4°C in 20 h.The equilibrium constant between bound and unbound α-amylase is dependent on the temperature. An effective desorption was possible by a shift to higher temperatures. Degradation values smaller than 0·1% were measured after an incubation of 1 h at 70°C in a desorption buffer with 20% glycerol.It was concluded that coulombic interactions and hydrogen bonds are of no or little importance in enzyme adsorption. Van der Waals forces, which are responsible for the large temperature effect, are the main forces in the interaction between α-amylase and crosslinked starch.     

Gelatinization mechanism of potato starch

The non-Newtonian behavior and dynamic viscoelasticity of potato starch (Jaga kids red ’90, 21.0% amylose content) solutions after storage at 25 and 4°C for 24 h were measured with a rheogoniometer. The flow curves, at 25°C, of potato starch showed plastic behavior >1.0% (w/v) after heating at 100°C for 30 min. A gelatinization of potato starch occurred above 1.0% at room temperature. A very large dynamic viscoelasticity was observed when potato starch solution (3.0%) was stored at 4°C for 24 h and stayed at a constant value with increasing temperature. A small dynamic modulus of potato starch was observed upon addition of urea (4.0 M) at low temperature (0°C) even after storage at 25 and 4°C for 24 h. A small dynamic modulus was also observed in 0.05 M NaOH solution. Possible models of gelatinization and retrogradation mechanism of potato starch were proposed.     

Performance of Aspergillus niger B 03 β-xylosidase immobilized on polyamide membrane support

The dynamics of β-xylosidase biosynthesis from Aspergillus niger B 03 was investigated in laboratory bioreactor. Maximum xylosidase activity 5.5 U/ml was achieved after 80 h fermentation at medium pH 4.0. The isolated β-xylosidase was immobilized on polyamide membrane support and the basic characteristics of the immobilized enzyme were determined. Maximum immobilization and activity yield obtained was 30.0 and 6.8%, respectively. A shift in temperature optimum and pH optimum was observed for immobilized β-xylosidase compared to the free enzyme. Immobilized enzyme exhibited maximum activity at 45 °C and pH 4.5 while its free counterpart at 70 °C and pH 3.5, respectively. Thermal stability at 40 and 50 °C and storage stability of immobilized β-xylosidase were investigated at pH 5.0. Kinetic parameters K_m, V_max and K_i were determined for both enzyme forms. Free and immobilized β-xylosidase were tested for xylose production from birchwood xylan. The substrate was preliminarily depolymerized with xylanase to xylooligosaccharides and the amount of xylose obtained after their hydrolysis with free and immobilized β-xylosidase was determined by HPLC analysis. Continuous enzyme hydrolysis of birchwood xylan was performed with xylanase and free or immobilized β-xylosidase. The maximum extent of hydrolysis was 25 and 30% with free and immobilized enzyme, respectively. Immobilized preparation was also examined for reusability in 20 consecutive cycles at 40 °C.     

Direct production of L-lysine from raw corn starch by Corynebacterium glutamicum secreting Streptococcus bovis alpha-amylase using cspB promoter and signal sequence

Corynebacterium glutamicum is an important microorganism in the industrial production of amino acids. We engineered a strain of C. glutamicum that secretes α-amylase from Streptococcus bovis 148 (AmyA) for the efficient utilization of raw starch. Among the promoters and signal sequences tested, those of cspB from C. glutamicum possessed the highest expression level. The fusion gene was introduced into the homoserine dehydrogenase gene locus on the chromosome by homologous recombination. L-Lysine fermentation was conducted using C. glutamicum secreting AmyA in the growth medium containing 50 g/l of raw corn starch as the sole carbon source at various temperatures in the range 30 to 40°C. Efficient L-lysine production and raw starch degradation were achieved at 34 and 37°C, respectively. The α-amylase activity using raw corn starch was more than 2.5 times higher than that using glucose as the sole carbon source during L-lysine fermentation. AmyA expression under the control of cspB promoter was assumed to be induced when raw starch was used as the sole carbon source. These results indicate that efficient simultaneous saccharification and fermentation of raw corn starch to L-lysine were achieved by C. glutamicum secreting AmyA using the cspB promoter and signal sequence.     

Production of a novel raw-starch-digesting glucoamylase by <Emphasis Type="Italic">Penicillium</Emphasis> sp. X-1 under solid state fermentation and its use in direct hydrolysis of raw starch

Penicillium sp. X−1, isolated from decayed raw corn, produced high level of raw-starch-digesting glucoamylase (RSDG) under solid state fermentation (SSF). Maximum enzyme yield of 306.2 U g⁻¹ dry mouldy bran (DMB) was obtained after 36 h of culture upon optimized production. The enzyme could hydrolyse both small and large granule starches but did not adsorb on raw starch. The enzyme exhibited maximum activity at 65°C and pH 6.5, which provided an opportunity of synergism with α-amylase. It significantly hydrolysed 15% (w/v) raw corn starch slurry in synergism with the commercial α-amylase and a degree of hydrolysis of 92.4% was obtained after 2 h of incubation.     

Behaviour of Endomycopsis fibuligera glucoamylase towards raw starch

An extracellular glucoamylase [exo-1,4-α-d-glucosidase, 1,4-α-d-glucan glucohydrolase, EC 3.2.1.3] of Endomycopsis fibuligera has been purified and some of its properties studied. It had a very high debranching activity (0.63). The enzyme was completely adsorbed onto raw starch at all the pH values tested (pH 2.0–7.6). Amylase inhibitor from Streptomyces sp. did not prevent the adsorption of glucoamylase onto raw starch although the enzyme did not digest raw starch in the presence of amylase inhibitor. Sodium borate (0.1 m) eluted only 35% of the adsorbed enzyme from raw starch. The optimum pH for raw starch digestion was 4.5 whereas that of boiled soluble starch hydrolysis was 5.5. Waxy starches were more easily digested than non-waxy starches, and root starches were slowly digested by this enzyme.     

Purification and properties of a novel raw starch degrading cyclomaltodextrin glucanotransferase from Bacillus firmus

A novel raw starch degrading cyclomaltodextrin glucanotransferase (CGTase; E.C. 2.4.1.19), produced by Bacillus firmus, was purified to homogeneity by ultrafiltration, affinity and gel filtration chromatography. The molecular weight of the pure protein was estimated to be 78 000 and 82 000 Da, by SDS-PAGE and gel filtration, respectively. The pure enzyme had a pH optimum in the range 5.5–8.5. It was stable over the pH range 7–11 at 10 °C, and at pH 7.0 at 60 °C. The optimum temperature for enzyme activity was 65 °C. In the absence of substrate, the enzyme rapidly lost its activity above 30 °C. K _m and k _cat for the pure enzyme were 1.21 mg/ml and 145.17 μM/mg per minute respectively, with soluble starch as the substrate. For cyclodextrin production, tapioca starch was the best substrate used when gelatinized, while wheat starch was the best substrate used when raw. This CGTase could degrade raw wheat starch very efficiently; up to 50% conversion to cyclodextrins was obtained from 150 g/l starch without using any additives. The enzyme produced α-, β- and γ-cyclodextrins in the ratio of 0.2:9.2:0.6 and 0.2:8.6:1.2 from gelatinized tapioca starch and raw wheat starch with 150 g/l concentration respectively, after 18 h incubation. Received: 25 September 1998 / Received revision: 15 December 1998 / Accepted: 21 December 1998     

The effects of electrolysis at room temperature on retrogradation of sweet potato starch

The effects of electrolysis at room temperature on formation of sweet potato retrograded starch were studied by photographic method in the paper. The optimal parameters of electrolytic preparation of sweet potato retrograded starch were determined. The ratio between sweet potato starch and water was 10 g/100 mL with addition of NaCl 1.0 g/100 mL, pH value of the solution was 6.0 and the solution was electrolyzed for 30 min at 90 V at room temperature, then it was stored at 4 °C for 24 h after being autoclaved for 30 min at 120 °C, the retrogradation rate of sweet potato starch at this condition was 33.1%, which is 138% higher than that of control group. Four possible reasons are put forward to explain the results.     

Characterization and wash performance analysis of an SDS-stable alkaline protease from a Bacillus sp.

An alkaline, SDS-stable protease optimally active at pH 11 from a Bacillus sp. RGR-14 was produced in a complex medium containing soybean meal, starch and calcium carbonate. The protease was active over a wide temperature range of 20–80 °C with major activity between 45 and 70 °C. The protease was completely stable for 1 h in 0.1% SDS and retained 70% of its activity in the presence of 0.5% SDS after 1 h of incubation. The enzyme was active in presence of surfactants (ionic and non-ionic) with 29% enhancement in activity in Tween-85 and was also stable in various oxidizing agents with 100 and 60% activity in presence of 1% sodium perborate and 1% H₂O₂, respectively. The enzyme was also compatible with commercial detergents (1% w/v) such as Surf, Ariel, Wheel, Fena and Nirma, retaining more than 70% activity in all the detergents after 1 h. Wash performance analysis of grass and blood stains on cotton fabric showed an increase in reflectance (14 and 25% with grass and blood stains, respectively) after enzyme treatment. However, enzyme in conjunction with detergent proved best, with a maximum reflectance change of 46 and 34% for grass and blood stain removal, respectively, at 45 °C. Stain removal was also effective after protease treatment at 25 and 60 °C.     

Alkaline proteases and thermostable α-amylase co-produced by Bacillus licheniformis NH1: Characterization and potential application as detergent additive

Alkalophilic Bacillus licheniformis NH1 strain produced at least five major extracellular proteases and a unique amylase as showed by zymography technique. The optimum pH and temperature for the proteolytic activity were 10.0 and 70 °C, respectively, while those of amylolytic activity were 6.5 and 90 °C, respectively. The alkaline proteases and thermostable α-amylase showed extreme stability towards non-ionic and anionic surfactants after pre-incubation for 1 h at 40 °C, and relative stability towards oxidizing agents. Additionally, the crude enzyme showed excellent stability and compatibility with various solid and liquid detergents. Wash performance analysis revealed that the NH1 crude enzyme could effectively remove a variety of stains, such as blood, chocolate and barbecue sauce. Considering its promising properties, B. licheniformis NH1 crude enzyme containing both α-amylase and proteases activities may be considered a potential candidate for future use in detergent processing industries.     

A novel raw starch digesting alpha-amylase from a newly isolated Bacillus sp. YX-1: purification and characterization

This study reports the purification and characterization of a novel raw starch digesting alpha-amylase from a newly isolated Bacillus sp. YX-1. Maximum alpha-amylase activity (53 U mL(-1)) was obtained at 45 degrees C after 44 h of incubation. The enzyme was purified using ammonium sulfate precipitation, ion exchange and gel filtration chromatography, and showed a molecular weight of 56 kDa by SDS-PAGE. This enzyme exhibited maximum activity at pH 5.0, performed stability over a broad range of pH 4.5-11.0, and was optimally active at 40-50 degrees C. The enzyme preparation had a strong digesting ability towards various raw starches and efficiently hydrolyzed raw corn starch at a concentration of 20% and pH 5.0, which were normally used in the starch industries, in a period of 12h. By analyzing its partial amino acid sequences, the enzyme was proposed to be a novel alpha-amylase.