Grape skins as a natural support for yeast immobilization

Grape skins were used to immobilize Saccharomyces cerevisiae. In repeated batch fermentations of grape by immobilized and free cells, the maximum specific rate of alcohol production on glucose decreased from 7.98 h^–1 at 25 °C to 0.7 h^–1 at 5 °C. The rate was approximately twice as high as that on fructose. The rates for free cells were very low. The maximum alcohol yield (0.45 g g^–1) was obtained at 5 °C when the immobilized biocatalyst was used.     

Alexandrium ostenfeldii growth and spirolide production in batch culture and photobioreactor

Growth and spirolide production of the toxic dinoflagellate Alexandrium ostenfeldii (Danish strain CCMP1773) were studied in batch culture and a photobioreactor (continuous cultures). First, batch cultures were grown in 450 mL flasks without aeration and under varying conditions of temperature (16 and 22 °C) and culture medium (L1, f/2 and L1 with addition of soil extract). Second, cultures were grown at 16 °C in 8 L aerated flat-bottomed vessels using L1 with soil extract as culture medium. Finally, continuous cultures in a photobioreactor were conducted at 18 °C in L1 with soil extract; pH was maintained at 8.5 and continuous stirring was applied.This study showed that A. ostenfeldii growth was significantly affected by temperature. At the end of the exponential phase, maximum cell concentration and cell diameter were significantly higher at 16 °C than at 22 °C. In batch culture, maximum spirolide quota per cell (approx. 5 pg SPX 13-desMeC eq cell⁻¹) was detected during lag phase for all conditions used. Spirolide quota per cell was negatively and significantly correlated to cell concentration according to the following equation: y = 4013.9x^−0.858. Temperature and culture medium affected the spirolide profile which was characterized by the dominance of 13,19-didesMeC (29–46%), followed by SPX-D (21–28%), 13-desMeC (21–23%), and 13-desMeD (17–21%).Stable growth of A. ostenfeldii was maintained in a photobioreactor over two months, with maximum cell concentration of 7 × 10⁴ cells mL⁻¹. As in batch culture, maximum spirolide cell quota was found in lag phase and then decreased significantly throughout the exponential phase. Spirolide cell quota was negatively and significantly correlated to cell concentration according to the equation: y = 12,858x^−0.8986. In photobioreactor, spirolide profile was characterized by higher proportion of 13,19-didesMeC (60–87%) and lower proportions of SPX-D (3–12%) and 13-desMeD (1.6–10%) as compared to batch culture.     

Mating due to loss of surface exclusion as a cause for thermosensitive growth of bacteria containing the Rtsl plasmid

Summary At 25° C, Rtsl⁺ bacteria grow to about 5x10⁹ bacterial/ml before leveling off, whereas at 42° C they grow from 2.6x10⁸ bacteria/ml for only 2.3 generations after temperature shift before the growth is inhibited with a zig-zag pattern at the plateau. When diluted, Rtsl⁺ bacteria grow rapidly at 42° C, until the concentration reaches as high as the undiluted 42° C culture when growth measured by colony counts stops and the zig-zag pattern again appears. This density-dependent growth inhibition is not due to the presence of stable growth inhibitor(s). Mating experiments show that at 42° C, Rtsl⁺ bacteria retain good donor ability; at the same time, they become good recipients in mating with Hfr (Rtsl) bacteria. SDS-PAGE reveals that membranes are altered at 42° C. Examination of DNA synthesis indicates that chromosomal DNA is synthesized at both 25° C and 42° C at high bacterial concentration, but that of the Rtsl plasmid is slowed down at 42° C. The labeling experiments suggest that in 2 h there are 2 rounds of plasmid replication at 25° C, 3.5 rounds at 42° C when bacteria are diluted, and 0.6 rounds at 42° C when bacteria are not diluted. These results suggest that the growth inhibition of Rtsl⁺ bacteria at 42° C is probably the consequence of mating initiated due to loss of surface exclusion.     

Microbial consortia for the aerobic degradation of aromatic compounds in olive oil mill effluent

Aerobic consortia that grow on olive oil mill effluent (OOME) were obtained by enrichment. Several cultures were capable of metabolizing monoaromatic compounds, supplied as the sole carbon source at 2 g L^–1. Some consortia degraded mixtures of seven aromatics (4 g L^–1) after 1 week of incubation at 32°C. The consortia were also active against monoaromatics of the undiluted OOME. This reduced the inhibitory effect of phenolic compounds prior to the anaerobic digestion of OOME at batch scale. No inhibition of the anaerobic microbial populations was noticed with treated OOME. From the most active consortium, nine different bacterial strains were isolated and shown to grow on simple aromatic compounds. Removal of 50% of the initial chemical oxygen demand and degradation of almost all of the simple aromatics in undiluted OOME was obtained with reconstituted bacterial mixtures. A slight reduction in colouration was due to adsorption of coloured compounds to bacterial cells. Presumably, the consortia could not reduce and degrade the coloured compounds in OOME.     

Growth and hyoscyamine production of ‘hairy root’ cultures of Datura stramonium in a modified stirred tank reactor

Summary The growth and hyoscyamine production of transformed roots of Datura stramonium have been examined in a modified 14-1 stirred tank reactor in both batch and continuous fermentations on media containing half or full strength Gamborg's B5 salts and at three different temperatures. Under a range of conditions, roots grown on half strength B5 salts with 3% w/v sucrose had a higher dry matter content (up to 8.3% w/w) and a higher hyoscyamine content (up to 0.52 mg·g^–1 wet weight) than roots grown on full strength B5 salts with the same level of sucrose (up to 4.6% w/w dry matter and up to 0.33 mg hyoscyamine g^–1 wet weight). Growth at 30°C was initially faster than at either 25°C or 35°C and by day 12, the drained weight of roots in the fermentor at 30°C was about fourfold greater than at 25°C and twice that at 35°C. The ultimate hyoscyamine levels attained (approximately 0.5 mg·g^–1 wet weight) were similar at both 25°C and 30°C but some 40% lower at 35°C. Final packing densities of 70% w/v were achieved for roots after 37 days growth at 25°C and the highest production rate of 8.2 mg hyoscyamine l^–1 per day was obtained for roots grown at 30°C. In continuous fermentation at 25°C, the release of hyoscyamine into the culture medium was low (less than 0.5% w/w of the total) but was up to sevenfold higher in fermentors operated at 30°C or 35°C. Offprint requests to: M. G. Hilton     

Metabolic and energetic aspects of the growth of Bacillus stearothermophilus in glucose-limited and glucose-sufficient chemostat culture

With a glucose-limited chemostat culture of Bacillus stearothermophilus, increasing the incubation temperature progressively from 45°C to 63°C led to a progressive marked increase in the maintenance rates of glucose and oxygen consumption. Hence, at a fixed low dilution rate the yield values with respect to glucose and oxygen decreased substantially with increased temperature. However, the apparent Y _glucose ^max and values did not decrease but actually increased with temperature, being highest at 63°C (i.e., close to the maximum growth temperature). With glucose-sufficient cultures growing at a fixed low dilution rate (0.2 h^–1) and at their optimum temperature (55°C), glucose and oxygen consumption rates invariably were higher than that of a corresponding glucose-limited culture. Cation (K⁺ or Mg²⁺)-limited cultures expressed the highest metabolic rates and with the K⁺ limited culture this rate was found to be very markedly temperature dependent. As the temperature was increased from 45°C to 63°C the rate of glucose consumption increased 1.8-fold, and that of oxygen consumption by 3.7-fold. The culture pH value also exerted a noticeable effect on the metabolic rate of a glucose-limited culture, particularly at the extremes of pH tolerance (5.5 and 8.5, respectively). A K⁺-limited culture was less affected with respect to metabolic rate by the culture pH value though the steady state bacterial concentration, and thus the cellular K⁺ content, changed substantially. These results are discussed in relation to previous findings of the behaviour of this organism in batch culture, and to the behaviour of other thermophilic Bacillus species in chemostat culture.     

Bionomics and population growth statistics of apterous virginoparae of woolly apple aphid, Eriosoma lanigerum, at constant temperatures

Development, survival, reproduction and population growth statistics of apterous virginoparae of woolly apple aphid, Eriosoma lanigerum (Hausmann) (Hemiptera: Aphididae) at constant temperatures of 10, 13, 15, 20, 25, 30 and 32°C are reported. The developmental times of all life stages were inversely related to temperature ranging from 10 to 30°C. Span of total development (time from birth to adulthood) decreased from 57.8 days at 10°C to 11.7 days at 30°C and increased to 16.8 days at 32°C. A good linear model fit (R²>0.96) between developmental rate and temperature in the range 10–25°C was observed for all life stages. The lower developmental threshold was estimated at 5.8°C for instar I, 4.8°C for instar II, 4.9° for instar III and 4.4°C for instar IV. The lower temperature threshold for total development was estimated at 5.2°C. The upper developmental limit was found to be 32°C. Mean degree-day accumulations required for completion of instars I, II, III, IV and total development were: 125.6, 51.0, 47.7, 50.7 and 267.6, respectively. Fecundity, larviposition period and adult longevity were reduced with increasing temperature. Net reproductive rate was greatest at 15°C whereas intrinsic rate of increase peaked at 25°C. Optimal performance, as measured by fecundity, survival and intrinsic rate of increase, ocurred in the range 13–25°C.     

Characterization of the bacterial flora of mass cultivated Brachionus plicatilis

Bacterial density and composition in association of mass cultivated rotifers (Brachionus plicatilis, SINTEF-strain) was investigated, during experimental conditions identical to the procedures used for preparing rotifers as live food for marine cold water fish larvae. These procedures include cultivation, enrichment with squid meal and acclimation to low temperature by storage of the rotifer culture at 6 °C. Large variations were observed in the number of rotifer associated (1.8–7.6 · 10³ colony forming units per rotifer^–1) and free-living (0.6–25 10⁷ cells·ml^–1) bacteria. An increase of 50–150% in the bacterial number was normally observed after feeding the rotifer with squid meal, but after three days of acclimation at 6 °C, the bacterial numbers decreased to the initial level.After enrichment of the cultures with squid meal, the similarity in the composition of the bacterial flora between the rotifers and water was reduced. However, acclimation of the culture at 6 °C resulted in better agreement of the rotifer associated flora and that in water. Enrichment of the cultures induced a shift in the bacterial composition from Cytophaga/Flavobacterium dominance to Pseudomonas/Alcaligenes dominance. The bacterial flora of the rotifer cultures are dominated by presumably opportunistic species after enrichment, which may have detrimental effects when rotifers are fed as live food to marine fish larvae.     

A preliminary evaluation of the use of microbial culture filtrates for the control of contaminants in plant tissue culture systems

The partitioning of carbon between reserve polysaccharide and alkaloid secondary products was investigated in batch cultures of transformed roots of Datura stramonium grown in media in which the carbon substrate concentration was held constant and the level of mineral nutrients was varied. The growth and accumulation of starch and hyoscyamine was examined in roots grown at temperatures of 20°C, 25°C or 30°C in media containing 5% sucrose and levels of mineral nutrients varying from 1/4 to twice the standard level of Gamborg's B5 salts. The dry matter content was highest (up to 15% w/w) in roots grown at either 20°C or 25°C in medium of the lowest ionic strenth (1/4 B5 salts) and decreased as the ionic strength was raised (down to 7% w/w with 2 B5 salts). Up to half of this decrease could be accounted for by loss of starch from the roots. At 20°C and 25°C, the starch content of the roots grown in medium of the lowest ionic strength (1/4 B5) was 40 mg g^-1 and 22 mg g^-1 fresh weight respectively but decreased to less than 1 mg g^-1 weight at either temperature when the ionic strength of the medium was raised to 2 B5. At 30°C, starch accumulation was severely inhibited in all media. In contrast, varying either the temperature or the ionic strength of the medium had only a small effect on hyoscyamine accumulation which remained at between 0.4–0.6 mg g^-1 fresh weight. Although increases in the level of mineral salts had little effect on the hyoscyamine content of the roots, total yields however, increased due to stimulation of growth. Time course experiments showed that cultures grown at either 20°C or 25°C continued to accumulate both starch and hyoscyamine into late stationary phase.     

Synthesis of Cyclodextrin glycosyl transferase by immobilized cells of Bacillus circulans

The cells of Bacillus circulans (ATCC 21783) immobilized in sodium alginate gel matrix were able to synthesize the extracellular enzyme, Cyclodextrin glycosyl transferase (CGTase, E.C. 2.4.1.19) which is industrially employed for the preparation of cyclodextrins. Optimization for the maximum production of enzyme was carried out by varying the cell density (3.3–53.5 kg/m³) in the gel and the incubation temperature (30°–42°C). The CGTase activity was found to be the highest (45 units/cm³) with maximum cell loading at 37°C. The reusability of immobilized cells was ascertained by repeated batch experiments. The enzyme activity exhibited was in the range of 50 to 55 units/cm³ in each batch. The continuous synthesis of CGTase by immobilized cells has been demonstrated by operating a fluidized bed reactor at a dilution rate 1.1 · 10^–4 sec^–1 for a period of 15 days. The enzyme activity has decreased to 42.5 units/cm³ from an initial value of 61 units/cm³ during continuous operation.The authors are grateful to Dr. A.D. Damodaran, Director, Regional Research Laboratory, Trivandrum for his keen interest and encouragement and to Department of Biotechnology, Government of India, New Delhi for financial support.     

Temperature dependency of induction of sexual agglutinability by α pheromone in the yeast Saccharomyces cerevisiae

When pheromone-pretreated cells of an inducible a strain of Saccharomyces cerevisiae carrying the inducible gene saa1 were incubated in a growth medium at 28°C, induction of sexual agglutinability began after a 10 min lag period. If the cells were incubated at 38°C during the lag period, no induction occurred even after incubation at 28°C. Contrary to this, if the cells were incubated at 28°C during the lag period, almost complete induction occurred, even after transfer to 38°C. Temperature shift experiments revealed that 5 min incubation at 28°C was necessary for the initiation of the temperature-sensitive period and further 5 min incubation for the completion of the period. The temperature-sensitive period was sensitive to phenylmethylsulfonyl fluoride.Non-common abbreviations PBS 10^-2 M phosphate buffer solution, pH 5.5 - PMSF phenylmethylsulfonyl fluoride     

Manganese superoxide dismutase from a higher plant

A manganese-containing superoxide dismutase (EC 1.15.1.1) was purified to homogeneity from a higher plant for the first time. The enzyme was isolated fromPisum sativum leaf extracts by thermal fractionation, ammonium sulfate salting out, ion-exchange and gel-filtration column chromatography, and preparative polyacrylamide gel electrophoresis. Pure manganese superoxide dismutase had a specific activity of about 3,000 U mg^-1 and was purified 215-fold, with a yield of 1.2 mg enzyme per kg whole leaf. The manganese superoxide dismutase had a molecular weight of 94,000 and contained one g-atom of Mn per mol of enzyme. No iron and copper were detected. Activity reconstitution experiments with the pure enzyme ruled out the possibility of a manganese loss during the purification procedure. The stability of manganese superoxide dismutase at-20°C, 4°C, 25°C, 50°C, and 60°C was studied, and the enzyme was found more labile at high temperatures than bacterial manganese superoxide dismutases and iron superoxide dismutases from an algal and bacterial origin.Abbreviations NBT nitro blue tetrazolium - SOD superoxide dismutase (EC 1.15.1.1)     

Microbial populations and sludge characteristics in thermophilic aerobic sewage sludge digestion

Summary Estimates of bacterial numbers from raw sewage sludge and sludge treated by thermophilic aerobic digestion were compared with simple indicators of sludge quality and concentrations of potential substrates. Significant differences were found between sludge types for all but one of the variables examined (frequency of dividing cells). During a stable period of digestor operation, the average number of viable obligate thermophiles present in digested sludge (1.63 × 10⁶ ml^–1) was approximately 10²-fold greater than in feed sludge (1.10 × 10⁴ ml^–1). Total numbers of bacteria were slightly greater in digested sludge (3.24 × 10¹⁰ ml^–1) than in feed sludge (2.39 × 10 ml^–10), as were viable counts of bacteria at incubation temperatures of 37°C and 55°C. Significant correlation was found between viable counts of bacteria at 37°C and 55°C for digested sludge, and 65°C and 55°C for feed sludge. The numbers of obligate thermophiles present and the total of bacteria present were related to the temperature and pH of the digested sludge and inversely related to the numbers ofEscherichia coli and coliforms present, which were not detected at temperatures greater than 50°C.     

Bioconversion of acid-hydrolyzed poplar hemicellulose to acetic acid byClostridium thermoaceticum

Summary Clostridium thermoaceticum was used to ferment carbohydrate released from pretreated oat splet xylan and hemicellulose isolated from hybrid poplar. Hydrolysis with dilute sulfuric acid (2.5% (v/v) for oat spelt xylan and 4.0% (v/v) for poplar hemicellulose) at 100°C for 60 min was found to release the highest concentration of fermentable substrate.C. thermoaceticum, when grown in non-pH controlled batch culture at 55°C under a headspace of 100% CO₂, typically produced 14gl^–1 acetic acid during a 48 h fermentation in medium containing 2% xylose. In fed-batch fermentations this organism was able to produce 42gl^–1 acetic acid after 116h when the concentration of xylose was maintained at approximately 2% and the pH was controlled at 7.0.     

Temperature dependent (37-15°C) anaerobic digestion of a trichloroethylene-contaminated wastewater

The impact of a trichloroethylene (TCE) contaminated wastewater on the microbial community structure of an anaerobic granular biomass at 15 °C compared to 37 °C was investigated. Four expanded granular sludge bed (EGSB) bioreactors (R1-R4) were employed in pairs at 37 and 15 °C. The influents of one of each pair were supplemented with increasing concentrations of TCE (max. 60 mg l⁻¹). At 37 °C, stable operation was maintained with 88% COD removal and >99% TCE removal at maximum influent TCE concentrations. R3 performance decreased at influent TCE concentration of 60 mg l⁻¹, although TCE removal rates of >97% were recorded. Archaeal community analysis via clone library and quantitative polymerase chain reaction (qPCR) analysis, and bacterial community analysis via denaturing gradient gel electrophoresis (DGGE), indicated that temperature resulted in a greater change in community structure than the presence of TCE, and clones related to cold adaptation of biomass were identified at 15 °C.     

Analysis of the bacterial community inhabiting an aerobic thermophilic sequencing batch reactor (AT-SBR) treating swine waste

The microflora of a self-heating aerobic thermophilic sequencing batch reactor (AT-SBR) treating swine waste was investigated by a combination of culture and culture-independent techniques. The temperature increased quickly in the first hours of the treatment cycles and values up to 72°C were reached. Denaturing gradient gel electrophoresis of the PCR-amplified V3 region of 16S rDNA (PCR-DGGE) revealed important changes in the bacterial community during 3-day cycles. A clone library was constructed with the near-full-length 16S rDNA amplified from a mixed-liquor sample taken at 60°C. Among the 78 non-chimeric clones analysed, 20 species (here defined as clones showing more than 97% sequence homology) were found. In contrast to other culture-independent bacterial analyses of aerobic thermophilic wastewater treatments, species belonging to the Bacilli class were dominant (64%) with Bacillus thermocloacae being the most abundant species (38%). The other Bacilli could not be assigned to a known species. Schineria larvae was the second most abundant species (14%) in the clone library. Four species were also found among the 19 strains isolated, cultivated and identified from samples taken at 40°C and 60°C. Ten isolates showed high 16S rDNA sequence homology with the dominant bacterium of a composting process that had not been previously isolated.An erratum to this article can be found at     

Production of recombinant h-AT III with mammalian cell cultures using capillary electrophoresis for product monitoring

The importance of mammalian cell cultures for biotechnological production processes is steadily increasing, despite the high demands of these organisms on their culture conditions. Efforts towards a more efficient bioprocess generally concentrate on maximizing the culture's life time, the cell number, and the product concentration. Here recombinant BHK 21 c13 cells are used to produce rh-AT III, an anticoagulant of high therapeutic value. The influence of the process mode (batch, repeated batch, continuous perfusion) and the process temperature (30°C vs. 37°C) on the above mentioned parameters is investigated. It is possible to increase the length of the culture from 140 h (batch) to more than 500 h (continuous perfusion culture), while concomitantly increasing the cell density from 0.72 10⁶/ml (batch) to 2.27 10⁶/ml (repeated batch) and 2.87 10⁶/ml (continuous perfusion culture). The accumulation of toxic metabolites, such as lactate, can be curtailed by reducing the bioreactor temperature from 37°C to 30°C during the later part of the exponential growth phase. Fast and reliable product monitoring became essential during process optimization. Capillary zone electrophoresis (CZE) in uncoated fused silica capillaries was studied for that purpose and compared to the standard ELISA. Under optimized conditions an AT III quantification could be done within 2 min with CZE. The detection limit was 5 g/ml. A relative standard deviation of less than 0.9% was calculated. The detection limit could be lowered by one order of magnitude by using a two dimensional system, where an liquid chromatographic (LC) system is coupled to the CZE. Concomitantly the resolution is improved. The two-dimensional analysis required 5 min. Membrane adsorbers (MA) were used as stationary phase in the LC-system, to allow the application of high flow rates (5–10 ml/min). The correlation between the LC-CZE analysis and the standard AT III-ELISA was excellent, with r²: 0.965. Using the assay for at line product monitoring, it is shown, that the process temperature is of no consequence for the productivity whereas the process mode strongly influences this parameter.     

Optimization of extracellular xylanase production by Dictyoglomus sp. B1 in continuous culture

The thermophilic, xylanolytic, anaerobic organism, Dictyoglomus sp. B1, was cultivated in batch and continuous cultures in media containing insoluble beech-wood xylan. The extracellular xylanase activity levels obtained for the two cultivation methods were compared. Experiments were performed separately to determine the optimum substrate concentration, dilution rate, pH and temperature for xylanase production. Maximum xylanase activity was found at a substrate concentration of 1.5 g xylan/l, a dilution rate of 0.112 h^–1, pH 8.0 and at 7°C. Different combinations of these optimum values were used in a 2³ factorial experiment to investigate whether an increase in the xylanase production/activity could be achieved. A maximum xylanase activity of 2312 U/l was found when fermentors were operated at 73°C with a substrate concentration of 1.5 g xylan/l, pH 8.0, and a dilution rate of 0.112 h^–1. Thus, the optimum xylanase activity in the factorial experiment was obtained when the conditions that gave the maximum xylanase activities in the individual experiments were combined. Optimum xylanase activity obtained in the 2³ factorial experiment was 6.2 times higher than the activity found in the initial batch culture (373 U/l) and 3.0 times higher than the activity of a batch culture (783 U/l) grown at the same optimum conditions as the factorial experiment. The higher specific xylanase activity (217 U/mg protein) found in the 2³ factorial experiment was 4.1 times higher than the specific activity in the initial batch culture (53 U/mg protein).     

H<Subscript>2</Subscript>-Producing bacterial communities from a heat-treated soil inoculum

Hydrogen gas (60% H₂) was produced in a continuous flow bioreactor inoculated with heat-treated soil, and fed synthetic wastewater containing glucose (9.5 g l^–1). The pH in the bioreactor was maintained at 5.5 to inhibit consumption of H₂ by methanogens. The objective of this study was to characterize bacterial communities in the reactor operated under two different hydraulic retention times (HRTs of 30-h and 10-h) and temperatures (30°C and 37°C). At 30-h HRT, the H₂ production rate was 80 ml h^–1 and yield was 0.91 mol H₂/mol glucose. At 10-h HRT, the H₂ production rate was more than 5 times higher at 436 ml h^–1, and yield was 1.61 mol H₂/mol glucose. Samples were removed from the reactor under steady-state conditions for PCR-based detection of bacterial populations by ribosomal intergenic spacer analysis (RISA). Populations detected at 30-h HRT were more diverse than at 10-h HRT and included representatives of Bacillaceae, Clostridiaceae, and Enterobacteriaceae. At 10-h HRT, only Clostridiaceae were detected. When the temperature of the 10-h HRT reactor was increased from 30°C to 37°C, the steady-state H₂ production rate increased slightly to 463 ml h^–1 and yield was 1.8 mol H₂/mol glucose. Compared to 30°C, RISA fingerprints at 37°C from the 10-h HRT bioreactor exhibited a clear shift from populations related to Clostridium acidisoli (subcluster Ic) to populations related to Clostridium acetobutylicum (subcluster Ib).     

Cellulolytic properties of an extremely thermophilic anaerobe

Summary An extremely thermophilic anaerobe was isolated from a New Zealand hot spring by incubating bacterial mat strands in a medium containing xylan. The Gramreaction-negative organism that was subsequently purified had a temperature optimum of 70° C and a pH optimum of 7.0. The isolate, designated strain H173, grew on a restricted range of carbon sources. In batch culture H173 could degrade Avicel completely when supplied at 5 or 10 g l^–1. There was an initial growth phase, during which a cellulase complex was produced and carbohydrates fermented to form acetic and lactic acids, followed by a phase where cells were not metabolising but the cellulase complex actively converted cellulose to glucose. When co-cultured with strain Rt8.B1, an ethanologenic extreme thermophile, glucose was fermented to ethanol and acetate, and no reducing sugars accumulated in the medium. In pH controlled batch culture H173 produced an increased amount of lactate and acetate but there was again a phase when reducing sugars accumulated in the medium, and these were converted to ethanol by co-culture with Rt8.B1.