Genetic improvement of Saccharomyces cerevisiae for xylose fermentation

There is considerable interest in recent years in the bioconversion of forestry and agricultural residues into ethanol and value-added chemicals. High ethanol yields from lignocellulosic residues are dependent on efficient use of all the available sugars including glucose and xylose. The well-known fermentative yeast Saccharomyces cerevisiae is the preferred microorganism for ethanol production, but unfortunately, this yeast is unable to ferment xylose. Over the last 15 years, this yeast has been the subject of various research efforts aimed at improving its ability to utilize xylose and ferment it to ethanol. This review examines the research on S. cerevisiae strains that have been genetically modified or adapted to ferment xylose to ethanol. The current state of these efforts and areas where further research is required are identified and discussed.     

Improvement of xylose fermentation in respiratory-deficient xylose-fermenting Saccharomyces cerevisiae

Effective conversion of xylose in lignocelluloses is expected to reduce the production cost of second-generation biofuels significantly. The factors affecting xylose fermentation in Saccharomyces cerevisiae that express xylose reductase-xylitol dehydrogenase (XR-XDH) are studied. Although overproduction of non-oxidative pentose phosphate pathway significantly increased the aerobic-specific growth rate on xylose and slightly improved conversion of xylose to ethanol under oxygen-limited conditions, the elimination of respiration by deleting cytochrome C oxidase subunit IV gene impeded aerobic growth on xylose. However, the adaptive evolution of the respiratory-deficient strain with an NADP(+)-preferring XDH mutant in xylose media dramatically improved its xylose-fermenting ability. The specific growth rate, ethanol yield, and xylitol yield of the evolved strain on xylose were 0.06h(-1), 0.39gg(-1), and 0.13gg(-1) consumed xylose, respectively. Similar to anaerobic fermentation, the evolved strain exhibited accumulated ethanol rather than recycled it under aerobic conditions.     

Decreased xylitol formation during xylose fermentation in Saccharomyces cerevisiae due to overexpression of water-forming NADH oxidase

The recombinant xylose-fermenting Saccharomyces cerevisiae strain harboring xylose reductase (XR) and xylitol dehydrogenase (XDH) from Scheffersomyces stipitis requires NADPH and NAD(+), creates cofactor imbalance, and causes xylitol accumulation during growth on d-xylose. To solve this problem, noxE, encoding a water-forming NADH oxidase from Lactococcus lactis driven by the PGK1 promoter, was introduced into the xylose-utilizing yeast strain KAM-3X. A cofactor microcycle was set up between the utilization of NAD(+) by XDH and the formation of NAD(+) by water-forming NADH oxidase. Overexpression of noxE significantly decreased xylitol formation and increased final ethanol production during xylose fermentation. Under xylose fermentation conditions with an initial d-xylose concentration of 50 g/liter, the xylitol yields for of KAM-3X(pPGK1-noxE) and control strain KAM-3X were 0.058 g/g xylose and 0.191 g/g, respectively, which showed a 69.63% decrease owing to noxE overexpression; the ethanol yields were 0.294 g/g for KAM-3X(pPGK1-noxE) and 0.211 g/g for the control strain KAM-3X, which indicated a 39.33% increase due to noxE overexpression. At the same time, the glycerol yield also was reduced by 53.85% on account of the decrease in the NADH pool caused by overexpression of noxE.     

Increasing ethanol productivity during xylose fermentation by cell recycling of recombinant Saccharomyces cerevisiae

The influence of cell recycling of xylose-fermenting Saccharomyces cerevisiae TMB3001 was investigated during continuous cultivation on a xylose-glucose mixture. By using cell recycling at the dilution rate ( D) of 0.05 h(-1), the cell-mass concentration could be increased from 2.2 g l(-1) to 22 g l(-1). Consequently, the volumetric ethanol productivity increased ten-fold, from 0.5 g l(-1) h(-1) to 5.35 g l(-1) h(-1). By increasing the biomass concentration, the xylose consumption rate increased from 0.75 g xylose l(-1) h(-1) without recycling to 1.9 g l(-1) h(-1) with recycling. The specific ethanol productivity was in the range of 0.23-0.26 g g(-1) h(-1) with or without cell recycling, showing that an increased cell-mass concentration did not influence the efficiency of the yeast.     

Crabtree/Warburg-like aerobic xylose fermentation by engineered Saccharomyces cerevisiae

Bottlenecks in the efficient conversion of xylose into cost-effective biofuels have limited the widespread use of plant lignocellulose as a renewable feedstock. The yeast Saccharomyces cerevisiae ferments glucose into ethanol with such high metabolic flux that it ferments high concentrations of glucose aerobically, a trait called the Crabtree/Warburg Effect. In contrast to glucose, most engineered S. cerevisiae strains do not ferment xylose at economically viable rates and yields, and they require respiration to achieve sufficient xylose metabolic flux and energy return for growth aerobically. Here, we evolved respiration-deficient S. cerevisiae strains that can grow on and ferment xylose to ethanol aerobically, a trait analogous to the Crabtree/Warburg Effect for glucose. Through genome sequence comparisons and directed engineering, we determined that duplications of genes encoding engineered xylose metabolism enzymes, as well as TKL1, a gene encoding a transketolase in the pentose phosphate pathway, were the causative genetic changes for the evolved phenotype. Reengineered duplications of these enzymes, in combination with deletion mutations in HOG1, ISU1, GRE3, and IRA2, increased the rates of aerobic and anaerobic xylose fermentation. Importantly, we found that these genetic modifications function in another genetic background and increase the rate and yield of xylose-to-ethanol conversion in industrially relevant switchgrass hydrolysate, indicating that these specific genetic modifications may enable the sustainable production of industrial biofuels from yeast. We propose a model for how key regulatory mutations prime yeast for aerobic xylose fermentation by lowering the threshold for overflow metabolism, allowing mutations to increase xylose flux and to redirect it into fermentation products.     

Fed-batch fermentation of xylose by a fast-growing mutant of xylose-assimilating recombinant Saccharomyces cerevisiae

Mutants of xylose-assimilating recombinant Saccharomyces cerevisiae carrying the xylose reductase and xylitol dehydrogenase genes on plasmid pEXGD8 were selected, after ethyl methanesulfonate treatment, for their rapid growth on xylose medium. The fastest growing strain (strain IM2) showed a lower activity of xylose reductase but a higher ratio of xylitol dehydrogenase to xylose reductase activities than the parent strain, as well as high xylulokinase activity. Southern hybridization of the chromosomal DNA indicated that plasmid pEXGD8 was integrated into the chromosome of mutant IM2, resulting in an increase in the stability of the cloned genes. In batch fermentation under O₂ limitation, the yield and production rate of ethanol were improved 1.6 and 2.7 times, respectively, compared to the parent strain. In fed-batch culture with slow feeding of xylose and appropriate O₂ supply at a low level, xylitol excreted from the cells was limited and the ethanol yield increased 1.5 times over that in the batch culture, with a high initial concentration of xylose, although the production rate was reduced. The results suggested that slow conversion of xylose to xylitol led to a lower level of intracellular xylitol, resulting in less excretion of xylitol, and an increase in the ethanol yield. It was also observed that the oxidation of xylitol was strongly affected by the O₂ supply.Correspondence to: T. Yoshida     

Metabolic engineering of a xylose-isomerase-expressing Saccharomyces cerevisiae strain for rapid anaerobic xylose fermentation

After an extensive selection procedure, Saccharomyces cerevisiae strains that express the xylose isomerase gene from the fungus Piromyces sp. E2 can grow anaerobically on xylose with a mu(max) of 0.03 h(-1). In order to investigate whether reactions downstream of the isomerase control the rate of xylose consumption, we overexpressed structural genes for all enzymes involved in the conversion of xylulose to glycolytic intermediates, in a xylose-isomerase-expressing S. cerevisiae strain. The overexpressed enzymes were xylulokinase (EC 2.7.1.17), ribulose 5-phosphate isomerase (EC 5.3.1.6), ribulose 5-phosphate epimerase (EC 5.3.1.1), transketolase (EC 2.2.1.1) and transaldolase (EC 2.2.1.2). In addition, the GRE3 gene encoding aldose reductase was deleted to further minimise xylitol production. Surprisingly the resulting strain grew anaerobically on xylose in synthetic media with a mu(max) as high as 0.09 h(-1) without any non-defined mutagenesis or selection. During growth on xylose, xylulose formation was absent and xylitol production was negligible. The specific xylose consumption rate in anaerobic xylose cultures was 1.1 g xylose (g biomass)(-1) h(-1). Mixtures of glucose and xylose were sequentially but completely consumed by anaerobic batch cultures, with glucose as the preferred substrate.     

Engineering of a matched pair of xylose reductase and xylitol dehydrogenase for xylose fermentation by Saccharomyces cerevisiae

Metabolic engineering of Saccharomyces cerevisiae for xylose fermentation has often relied on insertion of a heterologous pathway consisting of nicotinamide adenine dinucleotide (phosphate) NAD(P)H-dependent xylose reductase (XR) and NAD⁺-dependent xylitol dehydrogenase (XDH). Low ethanol yield, formation of xylitol and other fermentation by-products are seen for many of the S. cerevisiae strains constructed in this way. This has been ascribed to incomplete coenzyme recycling in the steps catalyzed by XR and XDH. Despite various protein-engineering efforts to alter the coenzyme specificity of XR and XDH individually, a pair of enzymes displaying matched utilization of NAD(H) and NADP(H) was not previously reported. We have introduced multiple site-directed mutations in the coenzyme-binding pocket of Galactocandida mastotermitis XDH to enable activity with NADP⁺, which is lacking in the wild-type enzyme. We describe four enzyme variants showing activity for xylitol oxidation by NADP⁺ and NAD⁺. One of the XDH variants utilized NADP⁺ about 4 times more efficiently than NAD⁺. This is close to the preference for NADPH compared with NADH in mutants of Candida tenuis XR. Compared to an S. cerevisiae-reference strain expressing the genes for the wild-type enzymes, the strains comprising the gene encoding the mutated XDH in combination a matched XR mutant gene showed up to 50% decreased glycerol yield without increase in ethanol during xylose fermentation.     

Directed evolution of xylose isomerase for improved xylose catabolism and fermentation in the yeast Saccharomyces cerevisiae

The heterologous expression of a highly functional xylose isomerase pathway in Saccharomyces cerevisiae would have significant advantages for ethanol yield, since the pathway bypasses cofactor requirements found in the traditionally used oxidoreductase pathways. However, nearly all reported xylose isomerase-based pathways in S. cerevisiae suffer from poor ethanol productivity, low xylose consumption rates, and poor cell growth compared with an oxidoreductase pathway and, additionally, often require adaptive strain evolution. Here, we report on the directed evolution of the Piromyces sp. xylose isomerase (encoded by xylA) for use in yeast. After three rounds of mutagenesis and growth-based screening, we isolated a variant containing six mutations (E15D, E114G, E129D, T142S, A177T, and V433I) that exhibited a 77% increase in enzymatic activity. When expressed in a minimally engineered yeast host containing a gre3 knockout and tal1 and XKS1 overexpression, the strain expressing this mutant enzyme improved its aerobic growth rate by 61-fold and both ethanol production and xylose consumption rates by nearly 8-fold. Moreover, the mutant enzyme enabled ethanol production by these yeasts under oxygen-limited fermentation conditions, unlike the wild-type enzyme. Under microaerobic conditions, the ethanol production rates of the strain expressing the mutant xylose isomerase were considerably higher than previously reported values for yeast harboring a xylose isomerase pathway and were also comparable to those of the strains harboring an oxidoreductase pathway. Consequently, this study shows the potential to evolve a xylose isomerase pathway for more efficient xylose utilization.     

Expression of bifunctional enzymes with xylose reductase and xylitol dehydrogenase activity in Saccharomyces cerevisiae alters product formation during xylose fermentation.

To enhance metabolite transfer in the two initial sequential steps of xylose metabolism in yeast, two structural genes of Pichia stipitis, XYL1 and XYL2 encoding xylose reductase (XR) and xylitol dehydrogenase (XDH), respectively, were fused in frame. Four chimeric genes were constructed, encoding fusion proteins with different orders of the enzymes and different linker lengths. These genes were expressed in Saccharomyces cerevisiae. The fusion proteins exhibited both XR and XDH activity when XYL1 was fused downstream of XYL2. The specific activity of the XDH part of the complexes increased when longer peptide linkers were used. Bifunctional enzyme complexes, analyzed by gel filtration, were found to be tetramers, hexamers, and octamers. No degradation products were detected by Western blot analysis. S. cerevisiae strains harboring the bifunctional enzymes grew on minimal-medium xylose plates, and oxygen-limited xylose fermentation resulted in xylose consumption and ethanol formation. When a fusion protein, containing a linker of three amino acids, was coexpressed with native XR and XDH monomers in S. cerevisiae, enzyme complexes consisting of chimerical and native subunits were formed. The total activity of these complexes showed XR and XDH activities similar to the activities obtained when the monomers were expressed individually. Strains which coexpressed chimerical subunits together with native XR and XDH monomers consumed less xylose and produced less xylitol. However, the xylitol yield was lower in these strains than in strains expressing only native XR and XDH monomers, 0.55 and 0.62, respectively, and the ethanol yield was higher. The reduced xylitol yield was accompanied by reduced glycerol and acetate formation suggesting enhanced utilization of NADH in the XR reaction.     

The role of peroxisomes in xylose alcoholic fermentation in the engineered Saccharomyces cerevisiae

Xylose is a second‐most abounded sugar after glucose in lignocellulosic hydrolysates and should be efficiently fermented for economically viable second‐generation ethanol production. Despite significant progress in metabolic and evolutionary engineering, xylose fermentation rate of recombinant Saccharomyces cerevisiae remains lower than that for glucose. Our recent study demonstrated that peroxisome‐deficient cells of yeast Ogataea polymorpha showed a decrease in ethanol production from xylose. In this work, we have studied the role of peroxisomes in xylose alcoholic fermentation in the engineered xylose‐utilizing strain of S. cerevisiae. It was shown that peroxisome‐less pex3Δ mutant possessed 1.5‐fold decrease of ethanol production from xylose. We hypothesized that peroxisomal catalase Cta1 may have importance for hydrogen peroxide, the important component of reactive oxygen species, detoxification during xylose alcoholic fermentation. It was clearly shown that CTA1 deletion impaired ethanol production from xylose. It was found that enhancing the peroxisome population by modulation the peroxisomal biogenesis by overexpression of PEX34 activates xylose alcoholic fermentation.     

Engineering redox cofactor regeneration for improved pentose fermentation in Saccharomyces cerevisiae

Pentose fermentation to ethanol with recombinant Saccharomyces cerevisiae is slow and has a low yield. A likely reason for this is that the catabolism of the pentoses D-xylose and L-arabinose through the corresponding fungal pathways creates an imbalance of redox cofactors. The process, although redox neutral, requires NADPH and NAD+, which have to be regenerated in separate processes. NADPH is normally generated through the oxidative part of the pentose phosphate pathway by the action of glucose-6-phosphate dehydrogenase (ZWF1). To facilitate NADPH regeneration, we expressed the recently discovered gene GDP1, which codes for a fungal NADP+-dependent D-glyceraldehyde-3-phosphate dehydrogenase (NADP-GAPDH) (EC 1.2.1.13), in an S. cerevisiae strain with the D-xylose pathway. NADPH regeneration through an NADP-GAPDH is not linked to CO2 production. The resulting strain fermented D-xylose to ethanol with a higher rate and yield than the corresponding strain without GDP1; i.e., the levels of the unwanted side products xylitol and CO2 were lowered. The oxidative part of the pentose phosphate pathway is the main natural path for NADPH regeneration. However, use of this pathway causes wasteful CO2 production and creates a redox imbalance on the path of anaerobic pentose fermentation to ethanol because it does not regenerate NAD+. The deletion of the gene ZWF1 (which codes for glucose-6-phosphate dehydrogenase), in combination with overexpression of GDP1 further stimulated D-xylose fermentation with respect to rate and yield. Through genetic engineering of the redox reactions, the yeast strain was converted from a strain that produced mainly xylitol and CO2 from D-xylose to a strain that produced mainly ethanol under anaerobic conditions.     

Endogenous xylose pathway in Saccharomyces cerevisiae

The baker's yeast Saccharomyces cerevisiae is generally classified as a non-xylose-utilizing organism. We found that S. cerevisiae can grow on D-xylose when only the endogenous genes GRE3 (YHR104w), coding for a nonspecific aldose reductase, and XYL2 (YLR070c, ScXYL2), coding for a xylitol dehydrogenase (XDH), are overexpressed under endogenous promoters. In nontransformed S. cerevisiae strains, XDH activity was significantly higher in the presence of xylose, but xylose reductase (XR) activity was not affected by the choice of carbon source. The expression of SOR1, encoding a sorbitol dehydrogenase, was elevated in the presence of xylose as were the genes encoding transketolase and transaldolase. An S. cerevisiae strain carrying the XR and XDH enzymes from the xylose-utilizing yeast Pichia stipitis grew more quickly and accumulated less xylitol than did the strain overexpressing the endogenous enzymes. Overexpression of the GRE3 and ScXYL2 genes in the S. cerevisiae CEN.PK2 strain resulted in a growth rate of 0.01 g of cell dry mass liter(-1) h(-1) and a xylitol yield of 55% when xylose was the main carbon source.     

Arabinose and xylose fermentation by recombinant Saccharomyces cerevisiae expressing a fungal pentose utilization pathway

Background  

Sustainable and economically viable manufacturing of bioethanol from lignocellulose raw material is dependent on the availability of a robust ethanol producing microorganism, able to ferment all sugars present in the feedstock, including the pentose sugars L-arabinose and D-xylose. Saccharomyces cerevisiae is a robust ethanol producer, but needs to be engineered to achieve pentose sugar fermentation.     

Engineering Saccharomyces cerevisiae for efficient anaerobic xylose fermentation: reflections and perspectives

Conversion of the abundant lignocellulosic biomass into ethanol is an environmentally sustainable solution to the energy crisis. Fermentation of lignocellulosic hydrolysates by Saccharomyces cerevisiae is not cost-effective yet as substantial amounts of xylose in the hydrolysates cannot be utilized by native S. cerevisiae strains. Extensive studies including both metabolic and evolutionary engineering have been carried out to develop an efficient xylose-fermenting S. cerevisiae strain, yet the ethanol yield and productivity from xylose fermentation of the best one are still far below expectation. This review compares the engineering approaches and resulted anaerobic xylose fermentation performance of recently reported xylose-utilizing S. cerevisiae strains, with the aim to understand the intrinsic reason for their low xylose fermentation capabilities. These comparative analyses revealed that some of the current engineering targets and the so-called "hot issues" might be overrated. Our opinions on the underrated parts and future efforts in this field are also presented. Overall, this review serves as a comprehensive reference to understanding xylose fermentation by S. cerevisiae.     

Display of Clostridium cellulovorans xylose isomerase on the cell surface of Saccharomyces cerevisiae and its direct application to xylose fermentation

Xylose isomerase (XI) is a key enzyme in the conversion of d ‐xylose, which is a major component of lignocellulosic biomass, to d ‐xylulose. Genomic analysis of the bacterium Clostridium cellulovorans revealed the presence of XI‐related genes. In this study, XI derived from C. cellulovorans was produced and displayed using the yeast cell‐surface display system, and the xylose assimilation and fermentation properties of this XI‐displaying yeast were examined. XI‐displaying yeast grew well in medium containing xylose as the sole carbon source and directly produced ethanol from xylose under anaerobic conditions. © 2013 American Institute of Chemical Engineers Biotechnol. Prog., 29: 346–351, 2013     

Analysis and prediction of the physiological effects of altered coenzyme specificity in xylose reductase and xylitol dehydrogenase during xylose fermentation by Saccharomyces cerevisiae

An advanced strategy of Saccharomyces cerevisiae strain development for fermentation of xylose applies tailored enzymes in the process of metabolic engineering. The coenzyme specificities of the NADPH-preferring xylose reductase (XR) and the NAD?-dependent xylitol dehydrogenase (XDH) have been targeted in previous studies by protein design or evolution with the aim of improving the recycling of NADH or NADPH in their two-step pathway, converting xylose to xylulose. Yeast strains expressing variant pairs of XR and XDH that according to in vitro kinetic data were suggested to be much better matched in coenzyme usage than the corresponding pair of wild-type enzymes, exhibit widely varying capabilities for xylose fermentation. To achieve coherence between enzyme properties and the observed strain performance during fermentation, we explored the published kinetic parameters for wild-type and engineered forms of XR and XDH as possible predictors of xylitol by-product formation (Y(xylitol)) in yeast physiology. We found that the ratio of enzymatic reaction rates using NADP(H) and NAD(H) that was calculated by applying intracellular reactant concentrations to rate equations derived from bi-substrate kinetic analysis, succeeded in giving a statistically reliable forecast of the trend effect on Y(xylitol). Prediction based solely on catalytic efficiencies with or without binding affinities for NADP(H) and NAD(H) were not dependable, and we define a minimum demand on the enzyme kinetic characterization to be performed for this purpose. An immediate explanation is provided for the typically lower Y(xylitol) in the current strains harboring XR engineered for utilization of NADH as compared to strains harboring XDH engineered for utilization of NADP?. The known XDH enzymes all exhibit a relatively high K(m) for NADP? so that physiological boundary conditions are somewhat unfavorable for xylitol oxidation by NADP?. A criterion of physiological fitness is developed for engineered XR working together with wild-type XDH.     

Intracellular ethanol accumulation in Saccharomyces cerevisiae during fermentation

An intracellular accumulation of ethanol in Saccharomyces cerevisiae was observed during the early stages of fermentation (3 h). However, after 12 h of fermentation, the intracellular and extracellular ethanol concentrations were similar. Increasing the osmotic pressure of the medium caused an increase in the ratio of intracellular to extracellular ethanol concentrations at 3 h of fermentation. As in the previous case, the intracellular and extracellular ethanol concentrations were similar after 12 h of fermentation. Increasing the osmotic pressure also caused a decrease in yeast cell growth and fermentation activities. However, nutrient supplementation of the medium increased the extent of growth and fermentation, resulting in complete glucose utilization, even though intracellular ethanol concentrations were unaltered. These results suggest that nutrient limitation is a major factor responsible for the decreased growth and fermentation activities observed in yeast cells at higher osmotic pressures.     

Trehalose metabolism in Saccharomyces cerevisiae during alcoholic fermentation

Strains of Saccharomyces cerevisiae accumulated intracellular trehalose up to 105 mg/g cell dry wt with 90% survival. Viability could be correlated to trehalose levels during ethanol fermentation albeit the disaccharide did not seem to contribute to fermentation yields. Trehalose-6-phosphate synthase showed high activity (up to 279 mu/mg protein) even at high residual sucrose concentration (115 g/l) in the wort suggesting to be a response of yeast cells to the osmotic stress conditions.