Generation of the improved recombinant xylose-utilizing Saccharomyces cerevisiae TMB 3400 by random mutagenesis and physiological comparison with Pichia stipitis CBS 6054

The recombinant xylose-utilizing Saccharomyces cerevisiae TMB 3399 was constructed by chromosomal integration of the genes encoding D-xylose reductase (XR), xylitol dehydrogenase (XDH), and xylulokinase (XK). S. cerevisiae TMB 3399 was subjected to chemical mutagenesis with ethyl methanesulfonate and, after enrichment, 33 mutants were selected for improved growth on D-xylose and carbon dioxide formation in Durham tubes. The best-performing mutant was called S. cerevisiae TMB 3400. The novel, recombinant S. cerevisiae strains were compared with Pichia stipitis CBS 6054 through cultivation under aerobic, oxygen-limited, and anaerobic conditions in a defined mineral medium using only D-xylose as carbon and energy source. The mutation led to a more than five-fold increase in maximum specific growth rate, from 0.0255 h(-1) for S. cerevisiae TMB 3399 to 0.14 h(-1) for S. cerevisiae TMB 3400, whereas P. stipitis grew at a maximum specific growth rate of 0.44 h(-1). All yeast strains formed ethanol only under oxygen-limited and anaerobic conditions. The ethanol yields and maximum specific ethanol productivities during oxygen limitation were 0.21, 0.25, and 0.30 g ethanol g xylose(-1) and 0.001, 0.10, and 0.16 g ethanol g biomass(-1) h(-1) for S. cerevisiae TMB 3399, TMB 3400, and P. stipitis CBS 6054, respectively. The xylitol yield under oxygen-limited and anaerobic conditions was two-fold higher for S. cerevisiae TMB 3399 than for TMB 3400, but the glycerol yield was higher for TMB 3400. The specific activity, in U mg protein(-1), was higher for XDH than for XR in both S. cerevisiae TMB 3399 and TMB 3400, while P. stipitis CBS 6054 showed the opposite relation. S. cerevisiae TMB 3400 displayed higher specific XR, XDH and XK activities than TMB 3399. Hence, we have demonstrated that a combination of metabolic engineering and random mutagenesis was successful to generate a superior, xylose-utilizing S. cerevisiae, and uncovered distinctive physiological properties of the mutant.     

树干毕赤酵母和酿酒酵母混合糖发酵产乙醇

以树干毕赤酵母和酿酒酵母为发酵菌株,酸性蒸汽爆破玉米秸秆预水解液和纯糖模拟液为C源,采用固定化酵母细胞的方法,研究了酸爆玉米秸秆预水解液初始pH、N源种类及其浓度、3种发酵模式对树干毕赤酵母戊糖发酵的影响。结果表明:玉米秸秆预水解液适合发酵的初始pH范围为6.0～7.0;1.0 g/L的(NH4)2SO4作为N源,在40 g/L葡萄糖和25 g/L木糖培养基中发酵24 h,糖利用率达到99.47%,乙醇质量浓度为24.72 g/L,优于尿素和蛋白胨作为N源;3种模式的发酵体系中,以游离树干毕赤酵母和固定化酿酒酵母发酵性能最好,糖利用率和乙醇得率分别为99.43%和96.39%。     

Simultaneous saccharification and co-fermentation of glucose and xylose in steam-pretreated corn stover at high fiber content with Saccharomyces cerevisiae TMB3400

The two main sugars in the agricultural by-product corn stover are glucose and xylose. Co-fermentation of glucose and xylose at high content of water-insoluble solids (WIS) without detoxification is a prerequisite to obtain high ethanol concentration and to reduce production costs. A recombinant strain of Saccharomyces cerevisiae, TMB3400, was used in simultaneous saccharification and fermentation (SSF) of whole pretreated slurry of corn stover at high WIS. TMB3400 co-fermented glucose and xylose with relatively high ethanol yields giving high final ethanol concentration. The ethanol productivity increased with increasing concentration of pretreatment hydrolysate in the yeast production medium and when SSF was performed in a fed-batch mode.     

酚酮类对树干毕赤酵母乙醇发酵及脂肪酸组成的影响

木质素降解产物对微生物产生的抑制作用,是燃料乙醇生物炼制的主要瓶颈之一。本文以树干毕赤酵母为发酵菌株,研究木质素降解产物中3种酚酮类(4-羟基苯乙酮、4-羟基-3-甲氧基苯乙酮、4-羟基-3,5-二甲氧基苯乙酮)对其木糖乙醇发酵及酵母细胞脂肪酸组成的影响。采用高效液相色谱(HPLC)和气相色谱-质谱联用(GC/MS)技术对乙醇发酵性能和酵母细胞脂肪酸组成进行分析。研究结果表明,酚酮类物质对乙醇发酵呈现抑制作用且其分子量越低抑制作用越明显,当4-羟基苯乙酮浓度为1.50 g/L时,发酵24 h的木糖利用率、乙醇得率和乙醇浓度分别下降了42.47%、5.30%和9.76 g/L;培养基中存在酚酮类物质时,酵母细胞中的不饱和脂肪酸的比例上升,添加1.50 g/L的3种酚酮类物质后,树干毕赤酵母细胞不饱和脂肪酸和饱和脂肪酸的比例从原来的2.58分别上升到3.03、3.06和3.61,酵母细胞膜的流动性随之上升,不稳定性提高。因此,酚酮类物质能够降低酵母生长、提高不饱和脂肪酸的比例以及降低乙醇发酵能力,有效降低或去除木质素降解产物含量是提高木质纤维原料生物炼制的关键。     

Ethanol production from hardwood spent sulfite liquor using an adapted strain of Pichia stipitis

Conditions have been optimized for fermentation of pretreated hardwood spent sulfite liquor (HSSL) using an adapted strain of Pichia stipitis. The pretreatments, consisting of boiling and overliming with Ca(OH)₂ of HSSL, to partially remove inhibitors, and adaptation of the yeast strain to HSSL, were both critical for a successful fermentation. Ethanol concentration was increased from 6.7 to 20.2 g l⁻¹ using adapted P. stipitis (A) and pretreated HSSL. The maximum ethanol yield (Y _p/s) and productivity (Q _p) were 0.41 g g⁻¹ and 0.44 g l⁻¹ h⁻¹, respectively, at an oxygen transfer rate of 2.0 mmol O₂ l⁻¹ h⁻¹. The optimized results with this strain were compared to those of other xylose-fermenting yeasts and Saccharomyces cerevisiae (SSL-acclimatized) currently used at an industrial plant for the fermentation of spent sulfite liquor. Journal of Industrial Microbiology & Biotechnology (2001) 26, 145–150. Received 23 June 2000/ Accepted in revised form 21 October 2000     

Simultaneous saccharification and fermentation of pretreated sugar cane leaves to ethanol

The simultaneous saccharification and fermentation (SSF) of pretreated sugar cane leaves to produce ethanol using a cellulolytic enzyme complex from Trichoderma reesei QM 9414 and Saccharomyces cerevisiae NRRL-Y-132 was optimized. Enzymic saccharification parameters were evaluated prior to SSF studies. A 92% conversion of 2·5% substrate (alkaline hydrogen peroxide pretreated) to sugars was achieved at 50°C and pH 4·5, using T. reesei cellulase (40 FPU/g substrate), in 48 h. The pretreated substrate was then subjected to an SSF process using the cellulase complex and S. cerevisiae cells. Optimization of the SSF system is described.     

A kinetic model for simultaneous saccharification and fermentation of Avicel with Saccharomyces cerevisiae

This work describes a numerical model for predicting simultaneous saccharification and fermentation of Avicel, an insoluble crystalline cellulose polymer. Separate anoxic cultivations of 40 g/L glucose and 100 g/L Avicel were conducted to verify model predictions and obtain parameters to describe the reaction kinetics. Saccharification of Avicel was achieved with Trichoderma reesei cellulases from the enzyme preparation Spezyme CP with an enzyme loading of 10 FPU/g cellulose. Cultivations were supplemented with 50 IU/g cellulose of β‐glucosidase from Novozym 188 to prevent product inhibition by cellobiose. Saccharomyces cerevisiae MH‐1000 is a robust industrial strain and was used to ferment glucose to ethanol, glycerol, and carbon dioxide. The numerical model presented in this paper differs from previous models by separating the endoglucanase and exoglucanase enzyme kinetics and allowing for inhibitive site competition. Assuming all enzymes remain active and that each enzyme complex has a corresponding constant specific activity, the model is capable of predicting adsorbed enzyme concentrations with reasonable accuracy. Comparison of predicted values to experimental measurements indicated that the numerical model was capable of capturing the significant elements involved with cellulose conversion to ethanol. Biotechnol. Bioeng. 2011; 108:924–933. © 2010 Wiley Periodicals, Inc.     

An economic comparison of different fermentation configurations to convert corn stover to ethanol using Z. mobilis and Saccharomyces

Numerous routes are being explored to lower the cost of cellulosic ethanol production and enable large‐scale production. One critical area is the development of robust cofermentative organisms to convert the multiple, mixed sugars found in biomass feedstocks to ethanol at high yields and titers without the need for processing to remove inhibitors. Until such microorganisms are commercialized, the challenge is to design processes that exploit the current microorganisms' strengths. This study explored various process configurations tailored to take advantage of the specific capabilities of three microorganisms, Z. mobilis 8b, S. cerevisiae, and S. pastorianus. A technoeconomic study, based on bench‐scale experimental data generated by integrated process testing, was completed to understand the resulting costs of the different process configurations. The configurations included whole slurry fermentation with a coculture, and separate cellulose simultaneous saccharification and fermentation (SSF) and xylose fermentations with none, some or all of the water to the SSF replaced with the fermented liquor from the xylose fermentation. The difference between the highest and lowest ethanol cost for the different experimental process configurations studied was $0.27 per gallon ethanol. Separate fermentation of solid and liquor streams with recycle of fermented liquor to dilute the solids gave the lowest ethanol cost, primarily because this option achieved the highest concentrations of ethanol after fermentation. Further studies, using methods similar to ones employed here, can help understand and improve the performance and hence the economics of integrated processes involving enzymes and fermentative microorganisms. © 2009 American Institute of Chemical Engineers Biotechnol. Prog., 2010     

Bioethanol fermentation of concentrated rice straw hydrolysate using co-culture of Saccharomyces cerevisiae and Pichia stipitis

Rice straw is one of the abundant lignocellulosic feed stocks in the world and has been selected for producing ethanol at an economically feasible manner. It contains a mixture of sugars (hexoses and pentoses).Biphasic acid hydrolysis was carried out with sulphuric acid using rice straw. After acid hydrolysis, the sugars, furans and phenolics were estimated. The initial concentration of sugar was found to be 16.8 g L⁻¹. However to increase the ethanol yield, the initial sugar concentration of the hydrolysate was concentrated to 31 g L⁻¹ by vacuum distillation. The concentration of sugars, phenols and furans was checked and later detoxified by over liming to use for ethanol fermentation. Ethanol concentration was found to be 12 g L⁻¹, with a yield, volumetric ethanol productivity and fermentation efficiency of 0.33 g L⁻¹ h⁻¹, 0.4 g g⁻¹ and 95%, respectively by co-culture of OVB 11 (Saccharomyces cerevisiae) and Pichia stipitis NCIM 3498.     

Plate ethanol-screening assay for selection of the Pichia stipitis and Hansenula polymorpha yeast mutants with altered capability for xylose alcoholic fermentation

A new method for the selection of Pichia stipitis and Hansenula polymorpha yeast mutants with altered capability to ferment xylose to ethanol was developed. The method is based on the ability of P. stipitis and H. polymorpha colonies to grow and produce ethanol on agar plates with xylose as the sole carbon and energy source. Secreted ethanol, in contrast to xylose, supports growth of cells of the indicator xylose-negative strains (the wild-type strain of Saccharomyces cerevisiae or Δxyl1 mutant of H. polymorpha) mixed with agar medium. The size of the tester culture-growth zone around xylose-grown colonies appeared to be dependent on the amount of secreted ethanol. Mutants with altered (decreased or elevated) ethanol production in xylose medium have been isolated using this method. The mutants exhibited pleiotropic alterations in enzymatic activities of the intermediary xylose metabolism.     

混合糖发酵重组酿酒酵母的菌株构建和菊芋秸秆同步糖化发酵研究

【目的】构建可用于纤维素乙醇高效生产的混合糖发酵重组酿酒酵母菌株,并利用菊芋秸秆为原料进行乙醇发酵。【方法】筛选在木糖中生长较好的酿酒酵母YB-2625作为宿主菌,构建木糖共代谢菌株YB-2625 CCX。进一步通过r DNA位点多拷贝整合的方式,以YB-2625 CCX为出发菌株构建木糖脱氢酶过表达菌株,并筛选得到优势菌株YB-73。采用同步糖化发酵策略研究YB-73的菊芋秸秆发酵性能。【结果】YB-73菌株以90 g/L葡萄糖和30 g/L木糖为碳源进行混合糖发酵,乙醇产量比出发菌株YB-2625 CCX提高了13.9%,副产物木糖醇产率由0.89 g/g降低至0.31 g/g,下降了64.6%。利用重组菌YB-73对菊芋秸秆进行同步糖化发酵,48 h最高乙醇浓度达到6.10%(体积比)。【结论】通过转入木糖代谢途径以及r DNA位点多拷贝整合过表达木糖脱氢酶基因可有效提高菌株木糖发酵性能,并用于菊芋秸秆的纤维素乙醇生产。这是首次报道利用重组酿酒酵母进行菊芋秸秆原料的纤维素乙醇发酵。     

Modelling real-time simultaneous saccharification and fermentation of lignocellulosic biomass and organic acid accumulation using dielectric spectroscopy

Dielectric spectroscopy (DS) is routinely used in yeast and mammalian fermentations to quantitatively monitor viable biomass through the inherent capacitance of live cells; however, the use of DS to monitor the enzymatic break down of lignocellulosic biomass has not been reported. The aim of the current study was to examine the application of DS in monitoring the enzymatic saccharification of high sugar perennial ryegrass (HS-PRG) fibre and to relate the data to changes in chemical composition. DS was capable of both monitoring the on-line decrease in PRG fibre capacitance (C=580 kHz) during enzymatic hydrolysis, together with the subsequent increase in conductivity (G=580 kHz) resulting from the production of organic acids during microbial growth. Analysis of the fibre fractions revealed >50% of HS-PRG lignocellulose had undergone enzymatic hydrolysis. These data demonstrated the utility of DS biomass probes for on-line monitoring of simultaneous saccharification and fermentation (SSF).     

Immobilization of co-culture of Saccharomyces cerevisiae and Scheffersomyces stipitis in sodium alginate for bioethanol production using hydrolysate of apple pomace under separate hydrolysis and fermentation

Apple pomace as a substrate for bioethanol production is interesting due to its abundance and sustainable availability in varied states like Himachal Pradesh (H.P.), Jammu and Kashmir, Uttarakhand and Arunachal Pradesh, India. In the current study, apple pomace which is the main fruit industrial waste of H.P. was evaluated as feedstock for bioethanol production by the process of enzymatic saccharification using multiple carbohydrases. Microwave pretreatment of the apple pomace resulted in the efficient removal of lignin and crystalline structure of cellulose fibre. The enzymatic saccharification of the pretreated biomass was done by optimizing parameters for maximal saccharification leads to production of 27.50?mg/g of reduce, ng sugar. An enhanced ethanol yield of 44.46?g/l and fermentation efficiency of 58% by immobilized co-culture of Saccharomyces cerevisiae MTCC 3089 and Scheffersomyces stipitis NCIM 3498 under SHF as compared to fermentation performed with free yeast cells, i.e. 34.46?g/l of ethanol and 45% of fermentation efficiency.     

Development of novel carrier using natural zeolite and continuous ethanol fermentation with immobilized Saccharomyces cerevisiae in a bioreactor

A natural zeolite, easily vitrified and blown at 1300 °C with a high porosity and diam. of 5–100 m, was used to immobilize Saccharomyces cerevisiae at 3.6 × 10⁸ cells ml^–1 carrier. When the abilities of natural zeolite carrier were compared with glass beads, the capacity for immobilization and alcohol fermentation activity were, respectively, 2-fold higher and 1.2-fold higher than that of glass beads. Continuous alcohol fermentation was stable for over 21 d without breakage of the carrier.     

Repeated-batch fermentation of lignocellulosic hydrolysate to ethanol using a hybrid Saccharomyces cerevisiae strain metabolically engineered for tolerance to acetic and formic acids

A major challenge associated with the fermentation of lignocellulose-derived hydrolysates is improved ethanol production in the presence of fermentation inhibitors, such as acetic and formic acids. Enhancement of transaldolase (TAL) and formate dehydrogenase (FDH) activities through metabolic engineering successfully conferred resistance to weak acids in a recombinant xylose-fermenting Saccharomyces cerevisiae strain. Moreover, hybridization of the metabolically engineered yeast strain improved ethanol production from xylose in the presence of both 30 mM acetate and 20 mM formate. Batch fermentation of lignocellulosic hydrolysate containing a mixture of glucose, fructose and xylose as carbon sources, as well as the fermentation inhibitors, acetate and formate, was performed for five cycles without any loss of fermentation capacity. Long-term stability of ethanol production in the fermentation phase was not only attributed to the coexpression of TAL and FDH genes, but also the hybridization of haploid strains.     

Simultaneous saccharification and co‐fermentation of paper sludge to ethanol by Saccharomyces cerevisiae RWB222. Part II: Investigation of discrepancies between predicted and observed performance at high solids concentration

The simultaneous saccharification and co‐fermentation (SSCF) kinetic model described in the companion paper can predict batch and fed batch fermentations well at solids concentrations up to 62.4 g/L cellulose paper sludge but not in batch fermentation at 82.0 g/L cellulose paper sludge. Four hypotheses for the discrepancy between observation and model prediction at high solids concentration were examined: ethanol inhibition, enzyme deactivation, inhibition by non‐metabolizable compounds present in paper sludge, and mass transfer limitation. The results show that mass transfer limitation was responsible for the discrepancy between model and experimental data. The model can predict the value of high paper sludge SSCF in the fermentation period with no mass transfer limitation. The model predicted that maximum ethanol production of fed‐batch fermentation was achieved when it was run as close to batch mode as possible with the initial solids loading below the mass transfer limitation threshold. A method for measuring final enzyme activity at the end of fermentation was also developed in this study. Biotechnol. Bioeng. 2009; 104: 932–938. © 2009 Wiley Periodicals, Inc.     

Alcoholic fermentation of xylose and mixed sugars using recombinant <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis> engineered for xylose utilization

Previously, a Saccharomyces cerevisiae strain was engineered for xylose assimilation by the constitutive overexpression of the Orpinomyces xylose isomerase, the S. cerevisiae xylulokinase, and the Pichia stipitis SUT1 sugar transporter genes. The recombinant strain exhibited growth on xylose, under aerobic conditions, with a specific growth rate of 0.025 h⁻¹, while ethanol production from xylose was achieved anaerobically. In the present study, the developed recombinant yeast was adapted for enhanced growth on xylose by serial transfer in xylose-containing minimal medium under aerobic conditions. After repeated batch cultivations, a strain was isolated which grew with a specific growth rate of 0.133 h⁻¹. The adapted strain could ferment 20 g l⁻¹ of xylose to ethanol with a yield of 0.37 g g⁻¹ and production rate of 0.026 g l⁻¹ h⁻¹. Raising the fermentation temperature from 30°C to 35°C resulted in a substantial increase in the ethanol yield (0.43 g g⁻¹) and production rate (0.07 g l⁻¹ h⁻¹) as well as a significant reduction in the xylitol yield. By the addition of a sugar complexing agent, such as sodium tetraborate, significant improvement in ethanol production and reduction in xylitol accumulation was achieved. Furthermore, ethanol production from xylose and a mixture of glucose and xylose was also demonstrated in complex medium containing yeast extract, peptone, and borate with a considerably high yield of 0.48 g g⁻¹.