Gamma-Ray Sterilization and Residual Toxicity Studies of Ground Beef Inoculated with Spores of Clostridium botulinum

Inoculated packs of cooked and raw ground beef were sterilized with gamma radiation from cobalt-60. With inocula of 5,000,000 Clostridium botulinum 213B spores per g of cooked ground beef, 3.8 megarad were required for sterilization; in raw ground beef, 3.72 megarad sterilized the meat when inocula of 1,700,000 C. botulinum 213B spores were used per g. Using C. botulinum 62A spores, cooked ground beef inoculated with 5,200,000 spores per g was sterilized with 3.85 megarad; raw ground beef, inoculated with 2,670,000 spores per g, was sterilized with 3.6 megarad. Cans of meat that were considered sterile by lack of culture growth after incubation for at least 6 months and, in some instances, as long as 5 years, were tested for the presence of botulinus toxin. No toxin was found in any meat taken from inoculated packs prepared from C. botulinum 213B spores; however, all cans of meat that had been inoculated with more than 2,670,000 C. botulinum 62A spores per g of meat, contained type A toxin. It was shown that these latter inocula of heat-shocked spores, by themselves, contained sufficient toxin to kill mice. However, more toxin appeared to be present than could be ascribed to the unirradiated spores alone. This finding is discussed.     

Distribution of Clostridium botulinum Type E Strains in Nunavik,Northern Quebec,Canada

The distribution and levels of Clostridium botulinum type E were determined from field sites used by Inuit hunters for butchering seals along the coast of Nunavik. The incidence rates of C. botulinum type E in shoreline soil along the coast were 0, 50, and 87.5% among samples tested for the Hudson Strait, Hudson Bay, and Ungava Bay regions, respectively. Spores were detected in seawater or coastal rock surfaces from 17.6% of butchering sites, almost all of which were located in southern Ungava Bay. Concentrations of C. botulinum type E along the Ungava Bay coast were significantly higher than on the coasts of Hudson Strait and Hudson Bay, with the highest concentrations (270 to 1,800/kg of sample) found near butchering sites located along the mouths of large rivers. The Koksoak River contained high levels of C. botulinum type E, with the highest median concentration (270/kg) found in sediments of the marine portion of the river. C. botulinum type E was found in the intestinal contents (4.4%) and skins (1.4%) of seals. A high genetic biodiversity of C. botulinum type E isolates was observed among the 21 butchering sites and their surroundings along the Nunavik coastline, with 83% of isolates (44/53) yielding distinct pulsed-field gel electrophoresis genotypes. Multiple sources of C. botulinum type E may be involved in the contamination of seal meat during butchering in this region, but the risk of contamination appears to be much higher from environmental sources along the shoreline of southern Ungava Bay and the sediments of the Koksoak River.     

Incidence of Clostridium botulinum in honey of various origins

By the dilution-centrifugation method, 270 honey samples, both domestic and imported, were examined and Clostridium botulinum was detected in 23 samples (8.5%); type A in 11 samples, type B in two, type C in 10, and type F in one. Of 58 domestic honey samples, six (10%) were positive; three gave type A and the other two type C. Among imported honey samples, Chinese honey gave 12% positives (types A, B, and C) and Argentina honey 20% positives (types A and F). The incidence was higher with samples taken from drums (18%) and from apiaries (23%) than marketing honey (5%). It was estimated that most positive samples contained spores in one per gram or lower concentrations. One sample contained 4 type A spores per gram and another 36-60 type F spores per gram. No distinct biochemical properties were found with the honey isolates.     

Clostridium perfringens in Meat and Meat Products

A total of 262 specimens of meat and meat dishes were examined for the presence of Clostridium perfringens. Of this total, 161 were raw, unprocessed beef, veal, lamb, pork, or chicken; 101 were processed meats and meat dishes. C. perfringens was isolated from 113 (43.1%) of these specimens. The highest percentage of contamination (82%) was found in veal cuts, and the lowest (4.7%) in sliced sandwich meats and spreads. Only 2 of the 113 isolates were shown to produce heat-resistant spores, which indicates a very low incidence (0.8%) of contamination. These findings indicate that outbreaks of C. perfringens food-borne disease in the Cincinnati area are caused principally by the contamination of the food with vegetative cells or spores of the organism after cooking. Studies of the effects of various holding temperatures on the growth of C. perfringens indicated that, in the range of 5 to 15 C, no multiplication would occur, but that viable cells would still be present at the end of a 5-day holding period. Extremely rapid growth occurred at temperatures around 45 C, and complete inhibition of growth was accomplished between 49 and 52 C.     

Development of a Combined Selection and Enrichment PCR Procedure for Clostridium botulinum Types B, E, and F and Its Use To Determine Prevalence in Fecal Samples from Slaughtered Pigs

A specific and sensitive combined selection and enrichment PCR procedure was developed for the detection of Clostridium botulinum types B, E, and F in fecal samples from slaughtered pigs. Two enrichment PCR assays, using the DNA polymerase rTth, were constructed. One assay was specific for the type B neurotoxin gene, and the other assay was specific for the type E and F neurotoxin genes. Based on examination of 29 strains of C. botulinum, 16 strains of other Clostridium spp., and 48 non-Clostridium strains, it was concluded that the two PCR assays detect C. botulinum types B, E, and F specifically. Sample preparation prior to the PCR was based on heat treatment of feces homogenate at 70°C for 10 min, enrichment in tryptone-peptone-glucose-yeast extract broth at 30°C for 18 h, and DNA extraction. The detection limits after sample preparation were established as being 10 spores per g of fecal sample for nonproteolytic type B, and 3.0 × 10³ spores per g of fecal sample for type E and nonproteolytic type F with a detection probability of 95%. Seventy-eight pig fecal samples collected from slaughter houses were analyzed according to the combined selection and enrichment PCR procedure, and 62% were found to be PCR positive with respect to the type B neurotoxin gene. No samples were positive regarding the type E and F neurotoxin genes, indicating a prevalence of less than 1.3%. Thirty-four (71%) of the positive fecal samples had a spore load of less than 4 spores per g. Statistical analysis showed that both rearing conditions (outdoors and indoors) and seasonal variation (summer and winter) had significant effects on the prevalence of C. botulinum type B, whereas the effects of geographical location (southern and central Sweden) were less significant.     

Development and Application of a New Method for Specific and Sensitive Enumeration of Spores of Nonproteolytic Clostridium botulinum Types B,E, and F in Foods and Food Materials

The highly potent botulinum neurotoxins are responsible for botulism, a severe neuroparalytic disease. Strains of nonproteolytic Clostridium botulinum form neurotoxins of types B, E, and F and are the main hazard associated with minimally heated refrigerated foods. Recent developments in quantitative microbiological risk assessment (QMRA) and food safety objectives (FSO) have made food safety more quantitative and include, as inputs, probability distributions for the contamination of food materials and foods. A new method that combines a selective enrichment culture with multiplex PCR has been developed and validated to enumerate specifically the spores of nonproteolytic C. botulinum. Key features of this new method include the following: (i) it is specific for nonproteolytic C. botulinum (and does not detect proteolytic C. botulinum), (ii) the detection limit has been determined for each food tested (using carefully structured control samples), and (iii) a low detection limit has been achieved by the use of selective enrichment and large test samples. The method has been used to enumerate spores of nonproteolytic C. botulinum in 637 samples of 19 food materials included in pasta-based minimally heated refrigerated foods and in 7 complete foods. A total of 32 samples (5 egg pastas and 27 scallops) contained spores of nonproteolytic C. botulinum type B or F. The majority of samples contained <100 spores/kg, but one sample of scallops contained 444 spores/kg. Nonproteolytic C. botulinum type E was not detected. Importantly, for QMRA and FSO, the construction of probability distributions will enable the frequency of packs containing particular levels of contamination to be determined.Food-borne botulism is a severe and deadly intoxication caused by the consumption of food containing as little as 30 to 100 ng of preformed botulinum neurotoxin (45). More than 2,500 cases of botulism were reported in Europe in 1999 and 2000, with the majority of cases in the east of the continent (44). Currently, 25 to 50 food-borne botulism cases are diagnosed annually in the United States (27). There are seven distinct botulinum neurotoxins (types A to G) and a number of subtypes (6, 26, 45). In view of the potency of the botulinum neurotoxin and the severity of botulism, four phylogenetically distinct bacteria are grouped together as the Clostridium botulinum species, solely on the basis of their ability to form botulinum neurotoxin. The divergence between these four distinct bacteria is strong enough to merit their classification as distinct species and in some cases is significantly greater than that between bacteria belonging to different genera, e.g., Bacillus subtilis and Staphylococcus aureus (7). Two of these bacteria (proteolytic C. botulinum and nonproteolytic C. botulinum) are responsible for the majority of cases of food-borne botulism. Strains of proteolytic C. botulinum produce neurotoxins of type A, B, or F, form spores of high heat resistance, and have a minimum growth temperature of approximately 12°C (39). Strains of nonproteolytic C. botulinum produce neurotoxins of type B, E, or F, form spores of moderate heat resistance, and are able to grow and form toxin at 3°C (18, 48) and are recognized as the major hazard associated with minimally heated refrigerated foods (4, 37, 43, 44, 48). These new foods meet consumer demand for high-quality, convenient foods that are low in preservatives, and sales are presently increasing by about 10% per annum in many countries (3, 47).Quantitative microbiological risk assessment (QMRA) is now established as an important microbiology food safety tool (42). Process risk models have been used to assess the safety of specific foods with respect to nonproteolytic C. botulinum and the food-borne botulism hazard (e.g., 2, 41). These process risk models benefit from high-quality information, including that on the incidence of spores of nonproteolytic C. botulinum spores in food materials. The implementation of food safety objectives (FSO) also benefits from the availability of high-quality information on the microbial contamination of foods and food materials (24). This information is most effective in the form of probability distributions rather than as average spore concentrations or other statistics.The difficulty with enumerating nonproteolytic C. botulinum in foods is that there is no effective selective culture medium available. Surveys of the extent of contamination of foods and food materials have used a nonselective enrichment followed by either testing for neurotoxin using a mouse test or enzyme-linked immunosorbent assay (ELISA) or testing for the presence of neurotoxin genes using a PCR test (3, 10, 13, 35, 38, 39). This approach, however, is not optimized for nonproteolytic C. botulinum or proteolytic C. botulinum (therefore potentially failing to recover all spores of either organism) and may also not distinguish nonproteolytic C. botulinum from proteolytic C. botulinum. Heating at 80°C for 10 min followed by incubation at 35°C (54) may be reasonably selective for proteolytic C. botulinum, but there is no similar approach for nonproteolytic C. botulinum, although incubation at 28°C (54) may offer an element of selection. It is necessary, therefore, to develop a method to enumerate spores of nonproteolytic C. botulinum in food materials that is robust and optimized, as well as sensitive and specific for this particular pathogen (and does not also detect proteolytic C. botulinum). When enumerating bacteria in foods, it is essential to demonstrate the efficiency of the method by verifying that small concentrations (in the present study, spores of nonproteolytic C. botulinum) can be detected following addition to test samples.This paper describes the development, validation, and application of a new method to enumerate spores of nonproteolytic C. botulinum in foods and in food materials. This method has been designed to generate data for the construction of probability distributions that can be used in QMRA and FSO settings. Most of the effort has been dedicated to the development and evaluation of the enrichment procedure rather than the PCR test, as the PCR test has received much attention from others (e.g., 3, 10, 16, 36, 38). A low-temperature selective-enrichment procedure is described that has been optimized specifically for nonproteolytic C. botulinum over proteolytic C. botulinum and other bacteria. In order to detect low concentrations of spores, large quantities (200 g) of food materials and foods have been tested. Specific detection of neurotoxin genes is achieved by the use of an established multiplex PCR (36), with an internal amplification control now included (25). By the use of a set of control samples inoculated with defined concentrations of spores of nonproteolytic C. botulinum, the detection limit has been estimated for each food material and food tested. The method has been used in an extensive survey of raw materials intended for use in pasta ready meals, as well as the final meals themselves. The implications for risk assessment and risk management of chilled foods are discussed.     

Use of the Anaerobic Pouch in Isolating Clostridium botulinum Spores from Fresh Meats

The anaerobic film pouch was demonstrated to be an effective device for the primary isolation of Clostridium botulinum types A and B spores from raw pork, beef, and chicken. Optimal pasteurization of these meats (for reduction of nonspore microflora without affecting indigenous putrefactive anaerobic spore levels) was 50 min at 60 C. C. botulinum spores were recovered with good precision from meat samples inoculated with mixtures of C. botulinum and Putrefactive Anaerobe 3679 at 1:1 and at 1:99 ratios. Verification of C. botulinum isolates was accomplished by protection testing of subcultures in mice.     

Chemical Sensitization of Clostridium botulinum Spores to Radiation in Meat

Beef ground round inoculated with 1,000,000 spores of Clostridium botulinum 33-A per gram and containing various additives was exposed to gamma radiation. Spores were inactivated in samples (irradiated at 2.0, 2.5, and 3.0 Mrad) which contained sodium nitrate (1,000 ppm) plus sodium chloride (2.5%). Similar results were obtained when sodium nitrite (200 ppm) was substituted for sodium nitrate, except that there was evidence of spore survival in 1 of 120 cans irradiated at 2.0 Mrad. Spore destruction was based upon the absence of spores and mouse-lethal toxin in meat subcultures made from cans incubated at 35 C for 120 days. Spores were not destroyed when exposed to 2.5 or 3.0 Mrad in the absence of sodium nitrate, sodium nitrite, or sodium chloride. Furthermore, the use of these chemicals individually, together with radiation, was ineffective. The additives alone in the absence of radiation also did not cause spore destruction. Radiation levels of 2.0, 2.5, and 3.0 Mrad, when used with sodium chloride at 1.5 or 2.0% and sodium nitrate at 500 ppm or sodium nitrite at 100 ppm, were ineffective.     

Multiplex PCR Assay for Detection and Identification of Clostridium botulinum Types A, B, E, and F in Food and Fecal Material

Botulism is diagnosed by detecting botulinum neurotoxin and Clostridium botulinum cells in the patient and in suspected food samples. In this study, a multiplex PCR assay for the detection of Clostridium botulinum types A, B, E, and F in food and fecal material was developed. The method employs four new primer pairs with equal melting temperatures, each being specific to botulinum neurotoxin gene type A, B, E, or F, and enables a simultaneous detection of the four serotypes. A total of 43 C. botulinum strains and 18 strains of other bacterial species were tested. DNA amplification fragments of 782 bp for C. botulinum type A alone, 205 bp for type B alone, 389 bp for type E alone, and 543 bp for type F alone were obtained. Other bacterial species, including C. sporogenes and the nontoxigenic nonproteolytic C. botulinum-like organisms, did not yield a PCR product. Sensitivity of the PCR for types A, E, and F was 10² cells and for type B was 10 cells per reaction mixture. With a two-step enrichment, the detection limit in food and fecal samples varied from 10⁻² spore/g for types A, B, and F to 10⁻¹ spore/g of sample material for type E. Of 72 natural food samples investigated, two were shown to contain C. botulinum type A, two contained type B, and one contained type E. The assay is sensitive and specific and provides a marked improvement in the PCR diagnostics of C. botulinum.     

Survival of Aerobic and Anaerobic Bacteria in Chicken Meat During Freeze-Dehydration, Rehydration, and Storage

Total and anaerobic counts were ascertained on boneless, cooked, cubed, frozen chicken meat. We determined survival of aerobes and anaerobes in the natural flora after the meat was freeze-dehydrated and rehydrated at room temperature for 30 min and at 50, 85, and 100 C for 10 min. Total and anaerobic counts of bacteria in the rehydrated meat were established during storage of samples at 4, 22, and 37 C-until a spoilage odor was detected. Samples were also inoculated with Clostridium sporogenes and were dried and rehydrated at 100 C and stored at 37 C. Approximately 21% of the aerobes and 37% of the anaerobes survived drying and rehydration at room temperature. Many genera of aerobes, anaerobes, and facultative anaerobes survived drying and rehydration at 50 C; only sporeformers survived rehydration at 85 or 100 C. Low-temperature (4 C) storage of rehydrated meat produced ample shelf life (over 20 days), whereas storage at the higher temperature resulted in a shelf life of less than 30 hr. Approximately 81% of the C. sporogenes cells survived rehydration at 100 C and grew to over 10(7) cells within 40 hr. Our study presents additional data for adequate microbiological control in processing of freeze-dehydrated meat. Also, it points out the natural selection for sporeformers at high temperature of rehydration, stressing the need for consumer education in product handling for safety purposes.     

Prevalence of Clostridium botulinum in Finnish Trout Farms: Pulsed-Field Gel Electrophoresis Typing Reveals Extensive Genetic Diversity among Type E Isolates

The distribution of Clostridium botulinum serotypes A, B, E, and F in Finnish trout farms was examined. A total of 333 samples were tested with a neurotoxin-specific PCR assay. C. botulinum type E was found in 68% of the farm sediment samples, in 15% of the fish intestinal samples, and in 5% of the fish skin samples. No other serotypes were found. The spore counts determined by the most-probable-number method were considerably higher for the sediments than for the fish intestines and skin; the average values were 2,020, 166, and 310 C. botulinum type E spores kg⁻¹, respectively. The contamination rates in traditional freshwater ponds and marine net cages were high, but in concrete ponds equipped with sediment suction devices the contamination rates were significantly lower. Pulsed-field gel electrophoresis (PFGE) typing of 42 isolates obtained in this survey and 12 North American reference strains generated 28 pulsotypes upon visual inspection, suggesting that there was extensive genetic diversity and that the discriminatory power of PFGE typing in C. botulinum type E was high. A numerical analysis of SmaI-XmaI macrorestriction profiles confirmed these findings, as it divided the 54 isolates into 15 clusters at a similarity level of 76%. For this material, this level of similarity corresponded to a three-band difference in the macrorestriction profiles, which indicated that there is no genotypic proof of a close epidemiological relationship among the clusters.     

Relationship of sporulation, enterotoxin formation, and spoilage during growth of Clostridium perfringens type A in cooked chicken

Sporulation and enterotoxin formation were determined for 17 strains of Clostridium perfringens type A in autoclaved chicken dark meat and in Duncan-Strong sporulation medium. The mean numbers of heat-resistant spores detected after 24 h at 37 degrees C were log10 1.13 to log10 7.64/ml in Duncan-Strong medium and log10 4.93 to log10 6.59/g in chicken. Of 17 strains, 7 formed enterotoxin in Duncan-Strong culture supernatant (1.0 to 60 microgram/ml) and 8 produced enterotoxin in chicken (0.21 to 24 microgram/g). Additional studies with chicken were conducted with C. perfringens NCTC 8239. With an inoculum of 10(6) cells per g, greater than log10 7.99 vegetative cells per g were detected by 4 h in chicken at 37 degrees C. Heat-resistant spores occurred by 4 and 6 h and enterotoxin occurred by 8 and 6 h in autoclaved chicken dark meat and barbecued chicken drumsticks, respectively. Enterotoxin was detected in autoclaved dark meat after incubation at 45 degrees C for 1.5 h followed by 37 degrees C for 4.5 h, but not after incubation at 45 degrees C for 1.5 to 8 h. With an inoculum of 10(2) cells per g in oven-cooked or autoclaved chicken, greater than log10 8.00 vegetative cells per g were detected by 6 to 8 h at 37 degrees C, heat-resistant spores were detected by 8 h, and enterotoxin was detected by 12 h. A statistical analysis of odor determinants of chicken after growth of C. perfringens indicated that, at the 95% confidence level, the product was considered spoiled (off or unwholesome odor) by the time spores or enterotoxin were formed.     

Relationship of sporulation, enterotoxin formation, and spoilage during growth of Clostridium perfringens type A in cooked chicken.

Sporulation and enterotoxin formation were determined for 17 strains of Clostridium perfringens type A in autoclaved chicken dark meat and in Duncan-Strong sporulation medium. The mean numbers of heat-resistant spores detected after 24 h at 37 degrees C were log10 1.13 to log10 7.64/ml in Duncan-Strong medium and log10 4.93 to log10 6.59/g in chicken. Of 17 strains, 7 formed enterotoxin in Duncan-Strong culture supernatant (1.0 to 60 microgram/ml) and 8 produced enterotoxin in chicken (0.21 to 24 microgram/g). Additional studies with chicken were conducted with C. perfringens NCTC 8239. With an inoculum of 10(6) cells per g, greater than log10 7.99 vegetative cells per g were detected by 4 h in chicken at 37 degrees C. Heat-resistant spores occurred by 4 and 6 h and enterotoxin occurred by 8 and 6 h in autoclaved chicken dark meat and barbecued chicken drumsticks, respectively. Enterotoxin was detected in autoclaved dark meat after incubation at 45 degrees C for 1.5 h followed by 37 degrees C for 4.5 h, but not after incubation at 45 degrees C for 1.5 to 8 h. With an inoculum of 10(2) cells per g in oven-cooked or autoclaved chicken, greater than log10 8.00 vegetative cells per g were detected by 6 to 8 h at 37 degrees C, heat-resistant spores were detected by 8 h, and enterotoxin was detected by 12 h. A statistical analysis of odor determinants of chicken after growth of C. perfringens indicated that, at the 95% confidence level, the product was considered spoiled (off or unwholesome odor) by the time spores or enterotoxin were formed.     

Effect of Sodium Nitrite on Toxin Production by Clostridium botulinum in bacon

Pork bellies were formulated to 0, 30, 60, 120, 170, or 340 μg of nitrite per g of meat and inoculated with Clostridium botulinum via pickle or after processing and slicing. Processed bacon was stored at 7 or 27 C and assayed for nitrite, nitrate, and botulinal toxin at different intervals. Nitrite levels declined during processing and storage. The rate of decrease was more rapid at 27 than at 7 C. Although not added to the system, nitrate was detected in samples during processing and storage at 7 and 27 C. The amount of nitrate found was related to formulated nitrite levels. No toxin was found in samples incubated at 7 C throughout the 84-day test period. At 27 C, via pickle, inoculated samples with low inoculum (210 C. botulinum per g before processing and 52 per g after processing) became toxic if formulated with 120 μg of nitrite per g of meat or less. Toxin was not detected in bacon formulated with 170 or 340 μg of nitrite per g of meat under these same conditions. Toxin was detected at all formulated nitrite levels in bacon inoculated via the pickle with 19,000 C. botulinum per g (4,300 per g after processing) and in samples inoculated after slicing. However, increased levels of formulated nitrite decreased the probability of botulinal toxin formation in bacon inoculated by both methods.     

Fate of Bacteria in Chicken Meat During Freeze-Dehydration, Rehydration, and Storage

Total plate counts were determined on boneless cooked, cubed chicken meat obtained from a commercial processor. Survival of the natural flora was determined after the meat was freeze-dehydrated and rehydrated at room temperature for 30 min and 50, 85, and 100 C for 10 min. Total counts of bacteria in the rehydrated samples were determined during storage of the meat at 4, 22, and 37 C until spoilage odor was detectable. Meat samples were inoculated with Staphylococcus aureus, then dried, rehydrated, and stored at the same temperatures. Numbers of surviving organisms in the inoculated samples were determined with use of both selective and nonselective media. Representative genera surviving the various rehydration treatments were determined. Approximately 32% of the bacteria in the meat survived during dehydration and rehydration at room temperature. Many numbers and types of vegetative bacteria also survived rehydration at 50 C. When meat was rehydrated at 85 or 100 C, the initial count was less than one per gram. The only organisms isolated from samples rehydrated at 85 or 100 C were of the genus Bacillus. S. aureus in inoculated samples survived dehydration and rehydration at 60 C. Storage of all rehydrated samples at 4 C gave a good shelf life (18 or more days). The study indicates that freeze-dehydrated meat should be produced with adequate microbiological control and that such meat should be rehydrated in very hot water.     

Intrinsic factors in meat products counteracting botulinogenic conditions

Spores ofClostridium botulinum occur in soil, dung and dirt, materials which are normally present on the skin of living pigs entering the slaughter-house. After slaughtering, the surface of the pigs may become contaminated with these materials, the chances and the level of contamination depending on the hygienic conditions in the factory.In vacuum-packed pre-cooked meat products anaerobic conditions prevail, which may allow the development of clostridia. As an example we have studied a typical Dutch smoked ring sausage: Gelderse rook-worst. The press-juice of this sausage was used as the culture medium to investigate the influence of temperature (25–37 C), of pH (5.7–7.0), of salt (2.5–5.0%) and of nitrite (0.005–0.05%) on the development ofClostridium botulinum type B, ATCC strain No. 438. Germination of spores and growth was inhibited for 4 weeks at 30 C by a combination of pH<5.8, salt>4.5% and nitrite>0.05%.These intrinsic factors in a meat product (pH, salt and nitrite) decide on germination of spores and growth ofClostridium botulinum and determine the safety of vacuum-packed products.     

Molecular characterization of Escherichia coli O157:H7 recovered from meat and meat products relevant to human health in Riyadh,Saudi Arabia

Raw meat can harbor pathogenic bacteria, potentially harmful to humans such as Escherichia coli O157:H7 causing diarrhea and hemolytic-uremic syndrome (HS). Therefore, the current study was carried out to evaluate the prevalence and the molecular detection characterization of E. coli serotype O157:H7 recovered from raw meat and meat products collected from Saudi Arabia. During the period of 25th January 2013 to 25th March 2014, 370 meat samples were collected from abattoirs and markets located in Riyadh, Saudi Arabia “200 raw meat samples and 170 meat products”. Bacteriological analysis of the meat samples and serotyping of the isolated E. coli revealed the isolation of 11 (2.97%) strains of E. coli O157:H7. Isolation of E. coli O157:H7 in raw beef, chicken and mutton were 2%, 2.5%, and 2.5%, respectively, however, there was no occurrence in raw turkey. The incidences of E. coli O157:H7 in ground beef, beef burgers, beef sausage, ground chicken and chicken burgers were 5%, 10%, 0.0%, 5% and 0.0%, respectively. The multiplex PCR assay revealed that 3 (27.27%) out of 11 E. coli O157:H7 isolates from raw beef, chicken and mutton had stx1, stx2, and eae while 5 (45.45%) E. coli O157:H7 isolates from ground beef, ground chicken, and raw beef had both stx1 and stx2. However, from beef burgers, only one E. coli O157:H7 isolate had stx1 while two were positive for hlyA gene. These results call for urgent attention toward appropriate controls and good hygienic practices in dealing with raw meat.     

Possible Origin of the High Incidence of Clostridium botulinum Type E in an Inland Bay (Green Bay of Lake Michigan)

Bottom and shoreline sediments of Green Bay, northern Lake Michigan, and rivers of the Green Bay drainage basin, as well as soils of the surrounding land mass, were examined for Clostridium botulinum type E. Detection was based on identification of type E toxin in enrichment cultures and was influenced by many factors. Testing smaller amounts of sample in multiple cultures was more productive than examining large inocula in fewer cultures. Incubation at 30 C was unsatisfactory, but 14 days at 20 C or 7 days at 25 C gave good results. Mild heating (60 C for 30 min) of specimens reduced the incidence of positive findings. Freezing enrichment cultures prior to testing for toxicity eliminated many nonbotulinal toxic substances that killed mice. A control culture inoculated with type E spores was employed to show whether a specimen contained factors which could mask the presence of type E. Samples from 708 stations were tested in 2,446 cultures. Type E was found in nearly all underwater specimens of Green Bay and northern Lake Michigan but was present less frequently in samples taken along their shores. The incidence was still lower in the rivers emptying into Green Bay with the organism being rare on the shores of these rivers and in the soils of the land mass proper. Samples from the upper reaches of the rivers practically never contained type E. Runoff could deposit type E spores in Green Bay, but this is not considered to be the major factor in the high incidence of the organism. Multiplication in the bay itself is indicated.     

Synergistic Inactivation of Spores of Proteolytic Clostridium botulinum Strains by High Pressure and Heat Is Strain and Product Dependent

The combined high pressure and heat resistances of spores of five proteolytic Clostridium botulinum strains and of the nonpathogenic surrogate strain Clostridium sporogenes PA3679 were compared with their heat-only resistances on the basis of equivalent accumulated thermal lethality, expressed as equivalent minutes at a reference temperature of 105°C (F_105°C). Comparisons were made with three model (i.e., diluted) products, namely, 30% (wt/wt) Bolognese sauce, 50% (wt/wt) cream sauce, and rice water agar. Pressure was determined to act synergistically with heat during high-pressure thermal (HPT) processing for C. botulinum FRRB 2802 (NCTC 7273) and C. botulinum FRRB 2804 (NCTC 3805 and 62A) in the Bolognese and cream sauces and for C. botulinum FRRB 2807 (213B) in the Bolognese sauce only. No synergy was observed for C. botulinum FRRB 2803 (NCTC 2916) or FRRB 2806 (62A) or C. sporogenes FRRB 2790 (NCTC 8594 and PA3679) in any of the model products. No significant protective effect of pressure against spore inactivation was determined for any Clostridium strain in any product. Because synergy was not consistently observed among strains of C. botulinum or among products, the prediction of inactivation of C. botulinum spores by HPT sterilization (HPTS) for the present must assume a complete lack of synergy. Therefore, any HPTS process for low-acid shelf-stable foods must be at least thermally equivalent to an F₀ process of 2.8 min, in line with current good manufacturing practices. The results of this study suggest that the use of C. sporogenes PA3679 as a surrogate organism may risk overestimating inactivation of C. botulinum by HPT processing.     

Influence of Limnological Conditions on Clostridium Botulinum Type E Presence in Eastern Lake Erie Sediments (Great Lakes, USA)

Avian and fish botulism outbreaks have been recorded since 1999 in eastern Lake Erie. These outbreaks are caused by Clostridium botulinum type E, a toxin-producing bacteria that is found in anoxic substrates rich in organic material. We studied the environmental conditions present in eastern Lake Erie during 2002, a year when several botulism outbreaks were observed. We also tested for the presence of C. botulinum type E in lake sediments. Samples were taken at six stations from two sites of different depths in the Dunkirk (New York, USA) area. The depth of the sampling sites influenced physico-chemical and biological processes in the sediments. We used the quantitative polymerase chain reaction (Q-PCR) to quantify the levels of C. botulinum type E in the samples. Sediment samples contained a patchy distribution of type E spore concentrations (from not detectable to 5520 DNA copies/mg). Samples of benthic invertebrates tested positive for C. botulinum type E spores in tissues (Gammarus 2028 DNA copies/mg, oligochaetes 428 DNA copies/mg, chironomids 148 DNA copies/mg and dreissenid mussels 715 DNA copies/mg). Principal components analysis (PCA) from inshore stations indicated that a decrease in dissolved oxygen, pH and redox potential near the sediment was associated to an increase in specific conductance and the type E toxin gene in sediments. We also found that C. botulinum type E spores are present in sediments at different depths and at different times through the ice-free season.