Occurrence of fumonisin B1 and B2 in corn-based foodstuffs in Taiwan market

Corn-based human foodstuffs purchased in Taiwan were analyzed for fumonisin B₁ (FB₁) and fumonisin B₂ (FB₂) using high-performance liquid chromatography. Fifty-two (33.9%) and 32 (20.9%) of 153 samples were found to contain FB₁ (73–2395 ng/g) and FB2 (120–715 ng/g), respectively. The highest frequency of detection and also the highest FB1 concentrations were found in sweetcorn (50%, 1089 ng/g) and cornflour (50%, 608 ng/g), followed by corn snacks (33.3%, 2395 ng/g), miscellaneous corn products (33.3%, 73 ng/g), popcorn (31.8%, 1003 ng/g) and cornflakes (23.5%, 1281 ng/g). 16 corn snacks (= approximately 20.5% of the samples) had an average FB₁ and FB₂ content of 456 and 145 ng/g, respectively, while six sweetcorn (= 25%) samples were contaminated with an average of 400 ng/g of FB₁ and 65 ng/g of FB₂. Of the 22 pop-corn samples examined, 7 had an average of 347 ng/g and 116 ng/g of FB₁ and FB₂, respectively. During an analysis of the distribution pattern for the combined fumonisin levels of FB₁ and FB₂, it became apparent that more than 69% of tested samples had fumonisin concentrations below 100 ng/g, while 11.1% (or 17 samples) contained in excess of 600 ng toxins per g. These results clearly illustrated that commercially available corn-based foodstuffs for human consumption in Taiwan are frequently contaminated with FB₁ and FB₂.This revised version was published online in October 2005 with corrections to the Cover Date.     

A limited survey of fumonisins in corn and corn-based products in Asian countries

Natural occurrence of fumonisins B₁ (FB₁) and B₂ (FB₂), a promoter for hepato-carcinogenesis, was investigated in corn and corn — based products sampled in Japan, Nepal, and China by high — performance liquid chromatographic method. From the 9 imported corn kernel and 6 gluten feed samples, FB₁ was detected in 8 corn (0.6 ～ 4.1μg/g) and all gluten feed (0.3 ～ 2.4μg/g) samples, while FB₂ was found in the same corn (0.3 ～ 10μg/g) and 3 gluten feed (0.8 ～ 8.5μg/g) samples. ELISA analysis also revealed the contamination of aflatoxin B₁ in 2 corn and all gluten feed samples along with fumonisins. Of 17 corn grit samples, 14 and 5 samples were contaminated with fumonisin B₁ and B₂, with maximum levels of 2.6 and 2.8μg/g, respectively. As for corn-based foodstuffs marketed in Japan, no significant contamination of fumonisins was observed. Among 24 corn kernel samples in Nepal, 12 and 7 samples were positive for FB₁ and FB₂, and averaged to 0.6 and 1.6μg/g, respectively. One sample showed the highest fumonisin contents as 4.6 and 5.5μg/g, respectively. In corn samples harvested at Shanghai and Beijing, China, FB₁ and FB₂ were detected in various concentrations. Mycological survey has also revealed the presence of a fumonisin — producing fungus in a crop field of Japan. These findings have for the first time demonstrated high levels of contamination of fumonisins in corn and corn — based products in Asian countries. Natural co — occurrence of fumonisins and aflatoxin B₁ was also detected in raw materials for mixed feed.     

Occurrence of Fusarium Mycotoxin Fumonisin B1 and B2 in Animal Feeds in Korea

The objective of this study was to monitor the occurrence and levels of fumonisin B₁ (FB₁) and fumonisin B₂ (FB₂) in animal feeds distributed in South Korea in 2011. The contamination levels of FB₁ and FB₂ were investigated in 150 samples of compound feeds and in 40 samples of feed ingredients. The contamination rate of feed ingredients with FB₁ and FB₂ was 50 and 40 %, respectively. FB₂ was only found in samples contaminated with FB₁. Of the compound feeds, 85 % were contaminated by FB₁ and 47 % were contaminated by FB₂. The highest contamination rate of FBs was observed in compound feeds for cattle (FB₁: 100 %; FB₂: 80 %), followed by poultry feed (FB₁: 78 %; FB₂: 40 %) and swine feed (FB₁: 76 %; FB₂: 22 %). The highest contamination level (14,600 ng/g) for FB₁ were found in poultry broiler feed (early feeding period) samples, which had 82 % contamination rate (9/11), and the highest level of FB₂ (2,280 ng/g) was found in feed for fatting calves,which had a contamination rate of 100 %.     

Ear-rot fungi and mycotoxins in South African corn of the 1989 crop exported to Taiwan

A shipment of South African corn (1989) exported to Taiwan, was analyzed for various ear-rot fungi andFusarium mycotoxins. Two sets of samples, one from the points of origin in South Africa prior to shipment, and the other from the end-point distributors in Taiwan, were studied. Surface-sterilized kernels were plated onto two different agar media and the fungal colonies identified. High Performance Liquid Chromatography was used to analyze mycotoxin levels. The predominant ear-rot fungi, in decreasing order of isolation frequency, wereFusarium subglutinans, F. moniliforme, Diplodia maydis andF. graminearum. Aspergillus flavus andA. parasiticus were not isolated from samples prior to export, but a small number ofA. flavus isolates were found after shipment. The predominant mycotoxins were fumonisins B₁ (0–865 ng/g) and B₂ (0–250 ng/g). Low levels of moniliformin (390 ng/g) were detected in some samples before shipment. Zearalenone (25 ng/g), and nivalenol (120 ng/g) were detected in two out of 32 samples taken in Taiwan. The samples contained no detectable levels of either aflatoxins (>0.5 ng/g) or deoxynivalenol (>100 ng/g) before or after shipment.Abbreviations RSA South Africa(n) - FB₁ fumonisin B₁ - FB₂ fumonisin B₂ - ETVL eastern Transvaal - WTVL western Transvaal     

Production of fumonisins B1, B2 and B3 byFusarium proliferatum Isolated from rye grains

Using the seed- plate technique, we have isolated a strain ofF. proliferatum from rye grains that produces 3 fumonisins, fumonisin B₁ (FB₁), FB₂ and FB₃ on inoculated rice and corn. Inoculated corn and rice were extracted with an aqueous methanol solution and fumonisin concentrations estimated using high performance liquid chromatography. Production of all 3 fumonisins (FB₁, FB₂ and FB₃) was much higher on rice than corn; ranging from 3816, 1068 and 985 ppm to 1643, 350 and 162 ppm respectively. We conclude that all natural substrates whereF. proliferatum is present as a component of the mycoflora should be monitored for the presence of fumonisins.     

Occurrence of Fumonisin B<Subscript>1</Subscript> in Corn from the Main Corn-Producing Areas of China

Fumonisin B₁ (FB₁) is the most abundant of the fumonisin mycotoxins, mainly produced in maize by F. verticillioides and F. proliferatum. A total of 282 corn samples harvested in 2005 from six provinces, the main corn-producing areas of China, were analyzed for FB₁ using high-performance liquid chromatography. All samples except one were (99.6%) positive for FB₁ at levels varying from 3 to 71,121 ng/g with mean and median levels for all samples of 6,662 and 1,569 ng/g, respectively. During an analysis of the distribution pattern for FB₁, it became apparent that 43.6% of tested samples had FB₁ concentrations below 1,000 ng/g, while 25.2% contained in excess of 5,000 ng/g. The average exposure to FB₁ (1.1 μg/kg body weight/day) is within the provisional maximum tolerable daily intake of 2 μg/kg body weight/day set by the Joint FAO/WHO Expert Committee on Food Additives.     

Effect of<Emphasis Type="Italic">in vitro</Emphasis> digestion on fumonisin B<Subscript>1</Subscript> in corn flakes

Low levels of fumonisins have been found frequently in corn based breakfast cereals and can occur bound to protein and other matrix components.In vitro digestion of two samples of corn flakes was carried out under "fed conditions." Fumonisins were measured as o-phthaldialdehyde/mercaptoethanol derivatives by LC-fluorescence. One sample of corn flakes (FN12) had high concentrations of fumonisin B₁ (FB) (average 125 ng/g) and total bound FB₁, (TB FB₁) (average 92 ng/g) and the other (FN11) had a low level of free FB₁ (average 29 ng/g) and no detectable TB FB₁. After incubation of the samples with gastrointestinal tract solutions simulating saliva plus stomach and duodenal juices, chyme was analysed for FB₁, hydrolyzed FB₁ (HFB₁) and partially hydrolyzed fumonisin B₁ (PHFB₁). The bioaccessibility (percentage of FB₁ released from corn flakes into chyme) was 38-78% for incurred FB₁ in FN12, 8-54% for incurred plus spiked FB₁ in FN12, and 19-66% for incurred plus spiked FB₁ in FN11. HFB₁ and PHFB₁ were not detected. If free FB₁ was first extracted from sample FN12, no FB1 was detected in the chyme, indicating no contribution from TB FB₁. Concentrations were corrected for method recovery of FB₁ or, for bound FB₁, partial method recovery of HFB₁ Presented at the XIIth IUPAC International Symposium on Mycotoxins and Phycotoxins, Istanbul, Turkey, 21–25 May, 2007     

Production of fumonisins byFusarium species of Taiwan

Twenty-nineFusarium species isolated from various sources in different districts of Taiwan were tested for their ability to produce fumonisins in corn cultures. OnlyFusarium moniliforme produced fumonisin B₁ (FB₁) and fumonisin B₂ (FB₂). The finding that the other 28Fusarium species produced neither FB₁ nor FB₂ is preliminary because only one strain per species was studied. The detection of FB₁ and FB₂ in cultures ofF. moniliforme was demonstrated by TLC and HPLC, and FB₁ was further confirmed by mass spectrometry. In a separate experiment, in which 38 strains ofF. moniliforme were tested for fumonisins, approximately 66% (25/38) produced FB₁ and/or FB₂. Of the 25 strains, 14 produced only FB₁ and 11 produced both FB₁ and FB₂, and the amounts of FB₁ and FB₂ produced by different strains varied greatly. This is the first report that fumonisins are found in corn cultures experimentally infected withF. moniliforme strains from Taiwan. It is safe to assume that fumonisin producing strains ofF. moniliforme are widely distributed among the economic crops such as corn, rice, sugarcane, and sorghum throughout the Island.Abbreviations FB₁ Fumonisin B₁ - FB₂ Fumonisin B₂ - OPA o-phthalidialdehyde     

Natural occurrence of fumonisins and their correlation to Fusarium contamination in commercial corn hybrids growth in Argentina

Fifty commercial corn hybrids with different endosperm characteristics, vegetative cycle length and cross class grown in the same geographical area (Cordoba Province, Argentina) were analysed for fumonisin accumulation. All hybrids analysed showed fumonisin B₁ and B₂ contamination ranging from 185 to 27,050 ng/g for FB₁ and from 40 to 9950 ng/g for FB₂. Although most of the hybrids analysed had flint-type endosperm, two hybrids with dent-type endosperm (e.g. Prozea 10 and AX 746) showed the highest level of fumonisin (37,000 ng/g) and more FB₂ than FB₁ (FB₂/FB₁ ratio 2.42), respectively. There was no correlation between fumonisin concentration and length of the vegetative cycle. Among 18 hybrids examined for Fusarium species contamination there was also no correlation between fumonisin contamination and the level of infection with Fusarium species (Section Liseola). Eighteen hybrids showed fumonisin levels lower than 1000 ng/g. This result suggests that there is some possibility of selecting hybrids resistant or less susceptible to fumonisin and Fusarium contamination.     

Quantitation of fumonisins in corn by HPLC with o-phthalaldehyde postcolumn derivatization and their identification by LC/MS

Fumonisins B₁(FB₁) and B₂(FB₂) were isocratically separated on a fluorocarbon column without using an ion pair reagent and nonvolatile buffer during the HPLC and were detected by an o-phthalaldehyde postcolumn derivatization system using a fluorescence detector. The minimum detectable concentrations of FB₁ and FB₂ in corn by this system were 0.01 μg/g and 0.01 μg/g, respectively. The separated fumonisins were further identified by a directly interfaced ion trap MS using electrospray ionization. FB₁ and FB₂ in naturally contaminated corn were identified in the selective ion monitoring mode at concentrations of 3.75μg/g and 1.44 μg/g, respectively. This revised version was published online in August 2006 with corrections to the Cover Date.     

Natural occurrence of fumonisins in corn puff in Argentina

Maize presents a substantial contamination by fumonisins (FB) throughout the world. In particular, Argentina presents a high frequency of positive samples and levels of up to 10,000 μg/kg of total FB, depending on the harvest campaign studied. Corn puff, an extruded product of high consumption among children and adolescent populations, was analyzed with the aim of determining the presence and levels of fumonisins B₁, B₂ and B₃. In the present study, 20 samples of different brands were collected from commercial stores. Two solvent systems, two types of agitation, and the number of extractions were tested in order to find the most suitable method to establish the level of fumonisins in corn puff. Extracts were analyzed by high performance liquid chromatography (HPLC) with fluorescence detection. A C18 column and precolumn derivatization with orthophtalaldialdehyde were utilized. The average of fumonisins found in 20 samples was 257.5 μg/kg (n?=?19), 70.4 μg/kg (n??=?14) and 73.3 μg/kg (n??=?6) for FB₁, FB₂ and FB₃, on positive samples, respectively. These are the first analyses in Argentina of this type of product, highlighting the need to continue the studies in the processing industries because, despite the extrusion process that the raw material suffers, a sample was found with a contamination of 1,649 μg/kg total fumonisins.     

Fumonisin production by <Emphasis Type="Italic">Fusarium</Emphasis> species isolated from freshly harvested corn in Iran

Fifty-one strains of Fusarium verticillioides and F. proliferatum isolated from corn collected from four different geographic areas in Iran, namely Fars, Khuzestan, Kermanshah and Mazandaran (an endemic oesophageal cancer (OC) area) were evaluated for their ability to produce fumonisins B₁ (FB₁), B₂ (FB₂) and B₃ (FB₃) in corn culture. Fumonisin levels were determined by high-performance liquid chromatography. All tested strains of F. verticillioides and F. proliferatumproduced fumonisins within a wide range of concentrations, 197–9661 g/g, 18–1974 g/g, and 21–1725 g/g for FB₁, FB₂, and FB₃, respectively. The highest mean concentrations of FB₁, FB₂, and FB₃ were 3897, 806 and 827 g/g, respectively. Overall, 61% of the F. verticillioides and F. proliferatum strains produced higher levels of FB₃ than FB₂. The mean ratios of FB₁:FB₂, FB₁:FB₃ and FB₁:total fumonisins were 8, 7 and 0.7 for F. verticillioides and 5.7, 10.7 and 0.7 for F. proliferatum, respectively. Significant differences in some of the meteorological data (rainfall, relative humidity and minimum temperature) from the four provinces were observed. Fumonisin levels produced by F. verticillioides strains isolated from Khuzestan province (tropical zone) were significantly (P < 0.01) higher than the other three provinces. This is the first report of the fumonisin-producing ability of F.verticillioides and F. proliferatum strains isolated from corn harvested from different geographic areas in Iran.     

Determination of fumonisins in corn: Evaluation of two purification procedures

The performance of two solid phase extraction (SPE) purification procedures, used in the determination of fumonlsin B₁ (FB₁), B₂ (FB₂) and B₃ (FB₂) In corn, was evaluated using both thin-layer chromatography (TLC) and high performance liquid chromatography (HPLC). Fewer interferences were observed In extracts prepared using the strong anion exchange (SAX) media, in contrast to those purified on C₁₈ media, where on occasions, visual discernment of the TLC bands was hampered by the presence of interfering compounds. Precipitate formation, resulting In the blocking of SPE cartridges was also encountered when using the C₁₈ procedure. HPLC analyses of extracts prepared by both media indicated that they gave comparable fumonlsin recoveries from naturally contaminated corn samples. The results suggest that the C₁₈ procedure, originally developed for the TLC analyses of FB₁ in mixed feeds, may also be applied to the determination of FB₂ and FB₂. However, where TLC is used quantitatively for fumonlsin levels <1 μg/g, purification of sample extracts on SAX media is recommended.     

Mortality in broiler chicks on feed amended withFusarium proliferatum culture material or with purified fumonisin B1 and moniliformin

Two hundred twenty-eight male chicks (Columbia × New Hampshire) were given feed amended with autoclaved culture material (CM) ofFusarium proliferatum Containing fumonisin B₁ (FB₁), fumonisin B₂ (FB₂) and moniliformin in 3 separate feeding trials. Purified FB₁ and moniliformin were given separately and in combination in a fourth feeding trial. Birds were given amended rations at day 1 (Trial 1 and 4), day 7 (Trial 2), and day 21 (Trial 3) and their respective ration was given for 28 days (Trial 1), 21 days (Trial 2), 7 days (Trial 3), and 14 days (Trial 4). FB₁ concentrations were 546, 193, and 61 ppm; FB₂ were 98, 38 and 14 ppm; and moniliformin were 367, 193, and 66 ppm in the first 3 feeding trial regimens. Chicks in Trial 4 were given dietary concentrations of purified FB₁ at 274 and 125 ppm, and moniliformin at 154 and 27 ppm. FB₁ and moniliformin, both alone and in combination, produced dose-responsive clinical signs, reduced weight gains and mortality in chicks. Age of birds given amended feeds had little difference in the clinical response; however, those given the rations from days 7 or 21 were slightly less susceptible than those given rations beginning at 1 day of age. Additive effects were noted when the toxins were given in combination. When toxins were given separately, adverse effects took longer to occur. A system to monitor pattern and rate of defecation (RD) was developed for assessing the chicks' approach to feed, water and heat source as illness progressed. Our results indicate that chicks fed corn heavily infected withF. proliferatum under field conditions could suffer acute death similar to that described for spiking mortality syndrome during the first 3 weeks of age.     

Incidence of Fusarium spp. and Levels of Fumonisin B1 in Maize in Western Kenya

Maize kernel samples were collected in 1996 from smallholder farm storages in the districts of Bomet, Bungoma, Kakamega, Kericho, Kisii, Nandi, Siaya, Trans Nzoia, and Vihiga in the tropical highlands of western Kenya. Two-thirds of the samples were good-quality maize, and one-third were poor-quality maize with a high incidence of visibly diseased kernels. One hundred fifty-three maize samples were assessed for Fusarium infection by culturing kernels on a selective medium. The isolates obtained were identified to the species level based on morphology and on formation of the sexual stage in Gibberella fujikuroi mating population tests. Fusarium moniliforme (G. fujikuroi mating population A) was isolated most frequently, but F. subglutinans (G. fujikuroi mating population E), F. graminearum, F. oxysporum, F. solani, and other Fusarium species were also isolated. The high incidence of kernel infection with the fumonisin-producing species F. moniliforme indicated a potential for fumonisin contamination of Kenyan maize. However, analysis of 197 maize kernel samples by high-performance liquid chromatography found little fumonisin B₁ in most of the samples. Forty-seven percent of the samples contained fumonisin B₁ at levels above the detection limit (100 ng/g), but only 5% were above 1,000 ng/g, a proposed level of concern for human consumption. The four most-contaminated samples, with fumonisin B₁ levels ranging from 3,600 to 11,600 ng/g, were from poor-quality maize collected in the Kisii district. Many samples with a high incidence of visibly diseased kernels contained little or no fumonisin B₁, despite the presence of F. moniliforme. This result may be attributable to the inability of F. moniliforme isolates present in Kenyan maize to produce fumonisins, to the presence of other ear rot fungi, and/or to environmental conditions unfavorable for fumonisin production.     

Preliminary determination of mycotoxin binding to soil when leaching through soil with water

Mycotoxin-contaminated crops that are left in the field are potential contaminants of groundwater. Aflatoxin B₁ (AFB₁) and fumonisin B₁ (FB₁) distribution in soil-water systems and the comparative response of aflatoxin-contaminated corn and pure aflatoxin when leached through soil were investigated using columns. Each experiment was repeated once. Eluates and soil extracts were analyzed for AFB₁ and its metabolites and FB₁ along with different amounts of pure FB₁ and water mixtures. AFB₁ was detected in water samples from columns containing 10% and 20% silty clay loam soil and aflatoxin-contaminated corn mixtures and in the upper (top) 2.5 cm of soil from the 10 cm soil column. Aflatoxin B₂ (AFB₂) was detected in eluates from the column containing 10% soil and aflatoxin-contaminated corn mixture and from the column containing aflatoxin-contaminated corn alone. No AFB₂ was detected in eluates from the column containing 20% soil and aflatoxin-contaminated corn mixture. No detectable amount of aflatoxin was observed in eluates from the containing 50% silty clay loam soil and aflatoxin contaminated corn. No detectable amount of FB₁ was observed in eluates or soil extracts, but FB₁ was detected in the mixtures of pure FB₁ and water.     

Evalution of liquid media for fumonisin production byFusarium moniliforme MCR 826

Production of fumonlsins B₁ (FB₁) and B₂ (FB₂) by 5 lyophillzation batches ofFusarium moniliforme strain MRC 826 was studied in several liquid media and vermlculite supplemented with liquid media. In addition the effect of different parameters including pH, Inert material, shake versus stationary cultures as well as different carbon sources on the production of the fumonlsins were investigated. Fumonlsin production in liquid cultures was significantly (P<0.01) correlated (r=0.92–0.98) with fungal growth, which in turn is affected by the pH of the medium as well as the carbon source utilized. The highest FB₁ yields (approximately 40 mg/l) over the incubation period of 14 days were produced in a chemically defined medium with glucose as carbon source set at an initial pH value of 4. FB₁ production in “corn patty” cultures (approximately 1 to 3 g/kg), however, by far exceeded that obtained in the liquid media, while poor fungal growth and fumonlsin production was obtained in vermlculite supplemented cultures. From these studies it became clear that the ability of a culture to produce fumonlsins is determined by the interaction of a variety of physiological and nutritional factors regarding the inoculum and the culture medium.     

Determination of mycobiota and mycotoxins in pig feed in central Argentina

Aims: To evaluate the mycobiota and natural levels of aflatoxins, fumonisins and zearalenone present in compound feed and home‐corn grains intended for fattening pigs. Methods and Results: Total fungi, Fusarium and Aspergillus species occurrence were examined. Aflatoxins and zearalenone were detected by thin‐layer chromatography and fumonisins by high‐pressure liquid chromatography. Fungal counts were generally higher than 1 × 10⁵ colony forming units (CFU) ml^?1. Aspergillus flavus, Aspergillus parasiticus and Fusarium verticillioides were the most prevalent species. FB₁ and FB₂ were detected in all feed and corn samples. Aflatoxin B₁ was detected in 33·33% of initial and growing feed and in 44·44% of final feed samples. It was not detected in corn samples. All feed and corn samples were negative for AFB₂, AFG₁, AFG₂ and ZEA presence during all growing stages tested. Conclusions: Fungal counts at all growing periods exceeded the levels proposed as feed hygienic quality limits. Aflatoxin levels in all feeds and fumonisin levels in many samples were higher than the established regulations. Significance and Impact of the Study: The presence of mycotoxins indicates the existence of contamination. This fact requires periodic monitoring to prevent the occurrence of mycotoxicosis in animal production, to reduce the economic losses and to minimize hazards to human health.     

Occurrence of fumonisins in asparagus (asparagus officinalis L.) and garlic (allium sativum L.) from Germany

Fusarium proliferatum is able to produce fumonisins and is considered a pathogen of many economically important plants (e.g. corn, rice, asparagus) [1]. The occurrence of fumonisin FB₁ inF. proliferatum infected asparagus spears from Germany was investigated using a liquid chromatography/electrospray ionization-mass spectrometry (LC-ESI-MS) method with isotopically labeled fumonisin FB₁-d₆ as internal standard. Asparagus samples were harvested in July 2000 and screened forFusarium species. AltogetherF. oxysporum, F. proliferatum and F. sambucinum were isolated from the spears. The samples infected with F.proliferatum were subsequently analyzed for fumonisins. FB₁ was detected in 9 of the 10 samples in amounts ranging from 36.4 ng/g to 4513.7 ng/g (based on dry weight). Fumonisins FB₂ and FB₃ were found in six samples in lower concentrations. In asparagus spears of June 2002 we could findF. proliferatum in 6% of the samples, however no fumonisins were detectable. Furthermore the capability of producing FB₁ by the fungus in garlic bulbs was investigated. Therefore garlic was cultured inF. proliferatum contaminated soil and the bulbs were screened for infection with F.proliferatum and for the occurrence of fumonisins by LC-MS. F.proliferatum was detectable in the garlic tissue and all samples contained FB₁ (26.0 ng/g to 94.6 ng/g). This is the first report of the natural occurrence of FB₁ in German asparagus spears and furthermore our findings suggest a potential for natural contamination of garlic bulbs with fumonisins. For detailed results and methods see Ref. [2].     

Thermostability of Fumonisin B1, a Mycotoxin from Fusarium moniliforme, in Corn

Fumonisin B₁ (FB₁) is a mycotoxin from Fusarium moniliforme that is frequently associated with corn. Thermal treatments are used in many processes concerning this cereal and its derivatives. The thermostability of this toxin in dry contaminated corn, resulting from F. moniliforme culture, was studied in different time-temperature combinations. FB₁ was quantified by instrumentalized thin-layer chromatography after a two-step sequential development and postchromatographic derivatization by p-anisaldehyde. The identity of FB₁ in extracts, before and after heat treatments, was confirmed by high-pressure liquid chromatography. For each temperature, the natural logarithm of the ratio of resulting FB₁ on initial content (In C/C₀) is linearly correlated to exposure time. The calculated half-lives (L₅₀), corresponding to the 50% value, were 10 min, 38 min, 175 min, and 8 h at 150, 125, 100, and 75°C, respectively. There is a linear relationship between calculated L₅₀s on a logarithmic scale and temperature. Therefore FB₁ is not significantly destroyed by the main drying processes of corn or thermal treatments used for its derivatives. Other associated means are required for detoxification.