The faeA genes from Aspergillus niger and Aspergillus tubingensis encode ferulic acid esterases involved in degradation of complex cell wall polysaccharides.

We report the cloning and characterization of a gene encoding a ferulic acid esterase, faeA, from Aspergillus niger and Aspergillus tubingensis. The A. niger and A. tubingensis genes have a high degree of sequence identity and contain one conserved intron. The gene product, FAEA, was overexpressed in wild-type A. tubingensis and a protease-deficient A. niger mutant. Overexpression of both genes in wild-type A. tubingensis and an A. niger protease-deficient mutant showed that the A. tubingensis gene product is more sensitive to degradation than the equivalent gene product from A. niger. FAEA from A. niger was identical to A. niger FAE-III (C. B. Faulds and G. Williamson, Microbiology 140:779-787, 1994), as assessed by molecular mass, pH and temperature optima, pI, N-terminal sequence, and activity on methyl ferulate. The faeA gene was induced by growth on wheat arabinoxylan and sugar beet pectin, and its gene product (FAEA) released ferulic acid from wheat arabinoxylan. The rate of release was enhanced by the presence of a xylanase. FAEA also hydrolyzed smaller amounts of ferulic acid from sugar beet pectin, but the rate was hardly affected by addition of an endo-pectin lyase.     

Esterification of ferulic acid with polyols using a ferulic acid esterase from Aspergillus niger

Commercially available enzyme preparations were screened for enzymes that have a high ability to catalyze direct ester-synthesis of ferulic acid with glycerol. Only a preparation, Pectinase PL "Amano" produced by Aspergillus niger, feruloylated glycerol under the experimental conditions. The enzyme responsible for the esterification was purified and characterized. This enzyme, called FAE-PL, was found to be quite similar to an A. niger ferulic acid esterase (FAE-III) in terms of molecular mass, pH and temperature optima, substrate specificity on synthetic substrates, and the N-terminal amino acid sequence. FAE-PL highly catalyzed direct esterification of ferulic acid and sinapinic acid with glycerol. FAE-PL could feruloylate monomeric sugars including arabinose, fructose, galactose, glucose, and xylose. We determined the suitable conditions for direct esterification of ferulic acid with glycerol to be as follows: 1% ferulic acid in the presence of 85% glycerol and 5% dimethyl sulfoxide at pH 4.0 and 50 degrees C. Under these conditions, 81% of ferulic acid could be converted to 1-glyceryl ferulate, which was identified by (1)H-NMR. The ability of 1-glyceryl ferulate to scavenge 1,1-diphenyl-2-picrylhydrazyl (DPPH) radicals was higher than that of the anti-oxidant butyl hydroxytoluene.     

Influence of ferulic acid on the production of feruloyl esterases by Aspergillus niger

Extracellular feruloyl esterases from the filamentous fungus Aspergillus niger are induced by growth on oat spelt xylan (OSX), which contains no detectable esterified ferulic acid. FAE-III accounted for most of the feruloyl esterase activity. Addition of free ferulic acid to OSX at the start of the culture induced FAE-III secretion a further 2.3-fold, and also induced other feruloyl esterases which could not be ascribed to FAE-III. Wheat bran- (WB)-grown cultures, containing 1% (m/v) ester-linked ferulic acid, gave almost identical FAE-III and total feruloyl esterase activities as the cultures grown on OSX plus ferulic acid. De-esterification of WB yielded less total feruloyl esterase, and 2.4-fold less FAE-III, compared to untreated WB. A slightly modified form of FAE-III was produced on de-esterified WB. These results show that production of FAE-III does not absolutely require ferulic acid. However, production is stimulated by the presence of free ferulic acid through increased expression, and is reduced by the removal of esterified ferulic acid from the growth substrate.     

Release of ferulic acid from wheat bran by a ferulic acid esterase (FAE-III) from Aspergillus niger

Ferulic acid was efficiently released from a wheat bran preparation by a ferulic acid esterase from Aspergillus niger (FAE-III) when incubated together with a Trichoderma viride xylanase (a maximum of 95% total ferulic acid released after 5 h incubation). FAE-III by itself could release ferulic acid but at a level almost 24-fold lower than that obtained in the presence of the xylanase (2 U). Release of ferulic acid was proportional to the FAE-III concentration between 0.1 U and 1.3 U, but the presence of low levels of xylanase (0.1 U) increased the amount of ferulic acid released 6-fold. Total sugar release was not influenced by the action of FAE-III on the wheat bran, but the rate of release of the apparent end-products of xylanase action (xylose and xylobiose) was elevated by the presence of the esterase. The results show that FAE-III and the xylanase act together to break down feruloylated plant cell-wall polysaccharides to give a high yield of ferulic acid.     

Oxalic acid production by Aspergillus niger

Aspergillus niger is able to produce a quite high concentration of oxalic acid using sucrose as carbon and energy source. Operating at pH higher than 6 and an enriched N and P medium is necessary in order to conduct the fermentation towards oxalic acid production. A pH?shift technique, operating at acid pH?in the first two days and then setting pH?to 6, allowed the productivity to slightly increase in shaking flasks cultures up to 3.0?kg/m³?·?d, with a final oxalic acid concentration of 29?kg/m³. When operating at more controlled conditions, in a stirred tank, both productivity and oxalic acid concentration were improved (4.1?kg/m³?·?d and 33.8?kg/m³, respectively). However the main drawback of this fermentation is the low yield attained (about 0.3?kg oxalic acid/kg sucrose) because most of glucose, resulting from the hydrolysis of sucrose by the extracellular enzymes secreted at the beginning of the fermentation, is very quickly oxidised to gluconic acid, a process which is favoured at a pH?close to 6. Milk whey was proved to be a very good substrate as it allows oxalic acid to be produced with a similar productivity (2.5?kg/m³?·?d in shaking flasks) giving excellent yields of almost 0.6?kg oxalic acid/kg lactose.     

Oxalic acid production by Aspergillus niger

Oxalic acid is formed by Aspergillus niger at nearly neutral pH values. In this study the applicability of milk whey as a carbon source was investigated, both in shaking flask experiments and in a stirred tank reactor. The influence of pH on oxalic acid formation showed that the maximum production rate and higher concentration of the product are observed at pH 6. At pH 7 the same production rate was obtained although at a lower oxalic acid concentration. The process was shown to be inhibited by product from an oxalic acid concentration of about 10?kg/m³ and its behaviour was fitted by Luong's equation. In a 10-dm³ strirred tank ferment the stirrer speed was varied in a range from 100 to 600 rpm. At values between 200 and 400 rpm, maximum production rates of oxalic acid of 6.8?kg/m³·d and 6.5?kg/m³·d were reached, respec-tively. A final concentration of 41.4?kg oxalic acid/m³ was reached operating at 400 rpm.     

Biosolubilization of poorly soluble rock phosphates by Aspergillus tubingensis and Aspergillus niger

Three isolates of Aspergillus tubingensis and two isolates of Aspergillus niger isolated from rhizospheric soils were tested on solubilization of different rock phosphates. All the isolates of Aspergillus were capable of solubilizing all the natural rock phosphates. A. tubingensis (AT1) showed maximum percent solubilization in all the rock phosphates tested in this study when compared to other isolates. This isolate also showed highest phosphorus (P) solubilization when grown in the presence of 2% of rock phosphate. A. tubingensis (AT1) seems to be more efficient in solubilization of rock phosphates compared to other isolates reported elsewhere. This is the first report of rock phosphate solubilization by A. tubingensis and might provide an efficient large scale biosolubilization of rock phosphates intended for P fertilizer.     

Heterologous expression of two Aspergillus niger feruloyl esterases in Trichoderma reesei for the production of ferulic acid from wheat bran

Bioprocess and Biosystems Engineering - Feruloyl esterase (FAE)-encoding genes AnfaeA and AnfaeB were isolated from Aspergillus niger 0913. For overexpression of the two genes in Trichoderma...     

Ochratoxin A production and amplified fragment length polymorphism analysis of Aspergillus carbonarius, Aspergillus tubingensis, and Aspergillus niger strains isolated from grapes in Italy

Ochratoxin A is a potent nephrotoxin and a possible human carcinogen that can contaminate various agricultural products, including grapes and wine. The capabilities of species other than Aspergillus carbonarius within Aspergillus section Nigri to produce ochratoxin A from grapes are uncertain, since strain identification is based primarily on morphological traits. We used amplified fragment length polymorphisms (AFLPs) and genomic DNA sequences (rRNA, calmodulin, and beta-tubulin genes) to identify 77 black aspergilli isolated from grape berries collected in a 2-year survey in 16 vineyards throughout Italy. Four main clusters were distinguished, and they shared an AFLP similarity of <25%. Twenty-two of 23 strains of A. carbonarius produced ochratoxin A (6 to 7,500 microg/liter), 5 of 20 strains of A. tubingensis produced ochratoxin A (4 to 130 microg/liter), 3 of 15 strains of A. niger produced ochratoxin A (250 to 360 microg/liter), and none of the 19 strains of Aspergillus "uniseriate" produced ochratoxin A above the level of detection (4 microg/liter). These findings indicate that A. tubingensis is able to produce ochratoxin and that, together with A. carbonarius and A. niger, it may be responsible for the ochratoxin contamination of wine in Italy.     

Improved reproducibility of citric acid production in Aspergillus niger

Summary We report the derivation of Aspergillus niger strains having a lower standard deviation in citric acid production by the use of ⁶⁰Co gamma radiation and by the parasexual cycle. On the basis of the results obtained by isolating diploids and segregants, diploidization seems to be sufficient for reducing variability. The implications of these results in terms of improvement of industrial strains are discussed.     

Galactose inhibition of citric acid production from glucose by Aspergillus niger

Summary Previous work in this laboratory has demonstrated that although Aspergillus niger can readily utilize galactose, no citric acid is produced from this carbon source (Hossain et al. 1984). Experiments were now conducted where galactose was added at various concentrations to synthetic growth medium containing glucose as carbon source, so that the effect of galactose on citric acid production from glucose could be observed. The results showed that the presence of galactose or a product of galactose metabolism caused inhibition of citric acid production, and also reduced the rate of glucose utilization. Enzyme analyses using mycelial cell-free extracts indicated that galactose interfered with the glucose-repression of the key enzyme 2-oxoglutarate dehydrogenase.     

Citric acid production by selected mutants of Aspergillus niger from cane molasses

The present investigation deals with citric acid production by some selected mutant strains of Aspergillus niger from cane molasses in 250 ml Erlenmeyer flasks. For this purpose, a conidial suspension of A. niger GCB-75, which produced 31.1 g/l citric acid from 15% (w/v) molasses sugar, was subjected to UV-induced mutagenesis. Among the 3 variants, GCM-45 was found to be a better producer of citric acid (50.0 +/- 2a) and it was further improved by chemical mutagenesis using N-methyl, N-nitro-N-nitroso-guanidine (MNNG). Out of 3,2-deoxy-D-glucose resistant variants, GCMC-7 was selected as the best mutant, which produced 96.1 +/- 1.5 g/l citric acid 168 h after fermentation of potassium ferrocyanide and H2SO4 pre-treated blackstrap molasses in Vogel's medium. On the basis of kinetic parameters such as volumetric substrate uptake rate (Qs), and specific substrate uptake rate (qs), the volumetric productivity, theoretical yield and specific product formation rate, it was observed that the mutants were faster growing organisms and produced more citric acid. The mutant GCMC-7 has greater commercial potential than the parental strain with regard to citrate synthase activity. The addition of 2.0 x 10(-5) M MgSO4 x 5H2O into the fermentation medium reduced the Fe2+ ion concentration by counter-acting its deleterious effect on mycelial growth. The magnesium ions also induced a loose-pelleted form of growth (0.6 mm, diameter), reduced the biomass concentration (12.5 g/l) and increased the volumetric productivity of citric acid monohydrate (113.6 +/- 5 g/l).