A thermostable lipase produced by a newly isolated <Emphasis Type="Italic">Geotrichum</Emphasis>-like strain,R59

Growth and production of lipase by a new Geotrichum-like strain, R59, were studied. Production of extracellular lipase was substantially enhanced when the initial pH of the culture medium, types of carbon and nitrogen sources, substances probably stimulating the lipase biosynthesis, the temperature, and time of growth were optimized. Sucrose and triolein were the most effective carbon sources for lipase production. Maximum lipase activity (146 U/ml^–1) was obtained with urea as the nitrogen source. Growth at 30°C, an initial pH of 6.0 and incubation time of 48 h were found as optimum conditions for cell growth and production of lipase by Geotrichum-like strain R59. The enzyme was thermostable and exhibited very high activity after 1 h incubation at 60°C.     

Purification of lipase from Geotrichum candidum: conditions optimized for enzyme production using Box–Behnken design

The fungus Geotrichum candidum was selected from isolates of oil-mill waste as a potent lipase producer. Factors affecting lipase production by the fungus G. candidum in yeast-extract-peptone medium have been optimized by using a Box–Behnken design with seven variables to identify the significant correlation between effects of these variables in the production of the enzyme lipase. The experimental values were found to be in accordance with the predicted values, the correlation coefficient is 0.9957. It was observed that the variables days (6), pH (7.0), temperature (30 °C), carbon (1.25%), nitrogen (2.0%), Tween (1.0%) and salt concentrations (0.5 mM) were the optimum conditions for maximum lipase production (87.7 LU/ml). The enzyme was purified to homogeneity with an apparent molecular mass of 32 kDa by SDS-PAGE. The optimum pH at 40 °C was 7.0 and the optimum temperature at pH 7.0 was 40 °C. The enzyme was stable within a pH range of 6.5 to 8.5 at 30 °C for 24 h. The enzyme activity was strongly inhibited by AgNO₃, NiCl₂, HgCl₂, and EDTA. However, the presence of Ca²⁺ and Ba²⁺ ions enhanced the activity of the enzyme.     

A novel alkaline, thermostable, protease-free lipase from Pseudomonas sp.

An extracellular, alkali-tolerant, thermostable lipase was from a Pseudomonas sp. It had optimal activity at 65 °C and retained 75% of its activity at 65 °C for 90 min. The pH optimum was 9.6 and it retained more than 70% activity between pH 5 and 9 for 2 h. The culture broth was free of protease and, at 30 °C, the culture filtrate retained all the activity for at least 7 days, without any stabilizer. In shake flask culture, addition of groundnut oil (3 g l^–1) towards the end of growth phase increased the activity from 4 U ml^–1 to 8 ml^–1.     

Optimization of a Thermostable Lipase from Bacillus stearothermophilus P1: Overexpression, Purification, and Characterization

An expression library was generated from a partial NcoI and HindIII digest of genomic DNA from the thermophilic bacterium, Bacillus stearothermophilus P1. The DNA fragments were cloned into the expression vector pQE-60 and transformed into Escherichia coli M15[EP4]. Sequence analysis of a lipase gene showed an open reading frame of 1254 nucleotides coding a 29-amino-acid signal sequence and a mature sequence of 388 amino acids. The expressed lipase was isolated and purified to homogeneity in a single chromatographic step. The molecular mass of the lipase was determined to be approximately 43 kDa by SDS-PAGE and mass spectrometry. The purified lipase had an optimum pH of 8.5 and showed maximal activity at 55°C. It was highly stable in the temperature range of 30–65°C. The highest activity was found with p-nitrophenyl ester-caprate as the synthetic substrate and tricaprylin as the triacylglycerol. Its activity was strongly inhibited by 10 mM phenylmethanesulfonyl fluoride and 1-hexadecanesulfonyl chloride, indicating that it contains a serine residue which plays a key role in the catalytic mechanism. In addition, it was stable for 1 h at 37°C in 0.1% Chaps and Triton X-100.     

A hyper-thermostable, alkaline lipase from Pseudomonas sp. with the property of thermal activation

A hyper-thermostable, alkaline lipase from a newly-isolated, mesophilic Pseudomonas sp. was optimal at pH 11 and at 90 °C. It had a half-life of more than 13 h at 90 °C. It was activated by 30% when heated at 90 °C for 2 h. The enzyme had a greater affinity for mustard oil (K _m=40 mg ml^–1) than for olive oil (K _m=140 mg ml^–1).     

Purification of lipase from Cunninghamella verticillata and optimization of enzyme activity using response surface methodology

The fungus Cunninghamella verticillata was selected from isolates of oil-mill waste as a potent lipase producer as determined by the Rhodamine-B plate method. The lipase was purified from C. verticillata by ammonium sulphate fractionation, ion exchange chromatography and gel filtration. The purified enzyme was formed from a monomeric protein with molecular masses of 49 and 42 kDa by SDS–PAGE and gel filtration, respectively. The optimum pH at 40 °C was 7.5 and the optimum temperature at pH 7.5 was 40 °C. The enzyme was stable between a pH range of 7.5 and 9.0 at 30 °C for 24 h. The enzyme activity was strongly inhibited by AgNO₃, NiCl₂, HgCl₂, CdCl₂ and EDTA. However, the presence of Ca²⁺, Mn²⁺ and Ba²⁺ ions enhanced the activity of the enzyme. The activity of purified lipase with respect to pH, temperature and salt concentration was optimized using a Box–Behnken design experiment. A polynomial regression model used in analysing this data, showed a significant lack of fitness. Therefore, quadratic terms were incorporated in the regression model through variables. Maximum lipase activity (100%) was observed with 2 mM CaCl₂, (pH 7.5) at a temperature of 40 °C. Regression co-efficient correlation was calculated as 0.9956.     

Isolation and characterization of Acinetobacter sp. ES-1 excreting a lipase with high enantioselectivity for (S)-ketoprofen ethyl ester

A new Acinetobacter sp. ES-1, grown on triolein, tryptone and Triton X-100, excreted a lipase that hydrolyzed 10m M (R,S)-ketoprofen ethyl ester into (S)-ketoprofen. The crude lipase had an activity of 10Uml^-1 and, at 30°C and pH7 over 48h, gave a conversion yield of 35% with an enantiomeric excess for the product 96%.     

Production of a thermostable extracellular lipase by Kluyveromyces marxianus

Kluyveromyces marxianus was grown in submerged culture in a complex medium with several potential inducers of lipolytic activity (triacylglycerols, fatty acids). The highest extracellular lipolytic enzyme production (about 80 U ml^–1 in 3 d) was obtained when the medium was supplemented with 2 g urea l^–1 plus 5 g tributyrin l^–1. Addition of surfactants (1 g l^–1) did not improve production. The lipase had a high thermal stability in aqueous solution (73% residual activity after 9 d at 50 °C, 16 min half-life time at 100 °C). It was also stable at acidic pH and showed good tolerance to organic solvents (70% residual activity after 2 d in n-hexane of cyclohexane).     

Investigation of lipase production by a new isolate of Aspergillus sp.

Fungi isolated from soil were screened for exogenous lipolytic activity. The highest lipase activity was found in a new soil isolate of Aspergillus sp. Some optimal cultural parameters influencing the growth and production of extracellular lipase from this Aspergillus sp. were investigated. The lipase yield was maximum on day 4 of incubation of the culture at pH 5.5 and 30 °C. When the medium was prepared using olive oil as carbon source and peptone as a nitrogen source, better lipase yields were obtained. Aeration enhanced growth and lipase production.     

Enzymatic properties of lipase and characteristics production byLactobacillus delbrueckii subsp.bulgaricus

Some properties of an extracellular lipase produced byLactobacillus delbrueckii subsp.bulgaricus were studied. Maximum enzyme activity was found against olive and butter oil as enzyme substrates. Addition of 9% acacia gum, 0.1% Na-deoxycholate and 0.01 M CaCl₂ to the enzyme reaction mixture increased-lipase activity from 5.3 to 14.5 (FFA/mg protein/minute) at pH 6.0 and at 40° C. Maximum lipase production was reached in the presence of glucose as a sole source of carbon, wheat bran as nitrogen source, olive oil as a sole lipid source and butyric acid as fatty acid supporting the growth medium. An initial pH value of the culture medium of 6.0 and a temperature of 35° C gave the highest lipolytic activity.     

Kluyveromyces marxianus: a potential source of diacetyl reductase

Kluyveromyces marxianus had a higher specific activity of diacetyl reductase (EC 1.1.1.5) than all other organisms previously reported. The enzyme was NADH-dependent and irreversibly catalysed the conversion of diacetyl to acetoin with an optimum pH of 7.0. It was stable at 40°C but lost 50% of its activity at 50°C in 30 min. The K _m and V _max values for diacetyl were 1.8 mm and 0.053 mm/min, respectively.The authors are with the Department of Food Science and Technology, Comell University, Geneva, New York 14456, USA     

A thermostable,alkaline-active,keratinolytic proteinase from chrysosporium keratinophilum

Thermostable alkaline proteinase was produced by a strain of Chrysosporium keratinophilum when cultured in lactose/mineral salt medium incorporating keratin solubilized with DMSO. The proteinase, partially purified by cold-acetone precipitation followed by gel-filtration on Sephadex G-75, was optimally active at pH 9 and stable from pH 7 to 10 with over 90% relative residual activity after incubation at 25°C for 24 h. The optimum temperature for enzyme activity was 90°C at which the activity half-life was 30 min. Enzyme activity was stimulated by Fe²⁺ and inhibited by 1,10 o-phenanthroline. Gel-filtration indicated an M _r of 69 kDa.The authors are with the Department of Microbiology, Faculty of Biological Sciences, P.M. B.006, University of Nigeria, Nsukka, Enugu State, Nigeria     

A thermoalkaliphilic lipase of <Emphasis Type="Italic">Geobacillus</Emphasis> sp. T1

A thermoalkaliphilic T1 lipase gene of Geobacillus sp. strain T1 was overexpressed in pGEX vector in the prokaryotic system. Removal of the signal peptide improved protein solubility and promoted the binding of GST moiety to the glutathione-Sepharose column. High-yield purification of T1 lipase was achieved through two-step affinity chromatography with a final specific activity and yield of 958.2 U/mg and 51.5%, respectively. The molecular mass of T1 lipase was determined to be approximately 43 kDa by gel filtration chromatography. T1 lipase had an optimum temperature and pH of 70°C and pH 9, respectively. It was stable up to 65°C with a half-life of 5 h 15 min at pH 9. It was stable in the presence of 1 mM metal ions Na⁺, Ca²⁺, Mn²⁺, K⁺ and Mg²⁺ , but inhibited by Cu²⁺, Fe³⁺ and Zn²⁺. Tween 80 significantly enhanced T1 lipase activity. T1 lipase was active towards medium to long chain triacylglycerols (C10–C14) and various natural oils with a marked preference for trilaurin (C12) (triacylglycerol) and sunflower oil (natural oil). Serine and aspartate residues were involved in catalysis, as its activity was strongly inhibited by 5 mM PMSF and 1 mM Pepstatin. The T _m for T1 lipase was around 72.2°C, as revealed by denatured protein analysis of CD spectra.     

Thermotolerant strain of Bacillus licheniformis producing lipase

A thermotolerant variant of Bacillus licheniformis strain H1 (isolated from Jordan valley soil), was highly active in degrading macromolecules, and possessed a lipase activity with a half life of 30 min at 70°C. This activity was produced during exponential growth. The extracellular crude lipase showed maximal activity at pH 10, and retained 65% of its stability at pH 12.The author is with the Department of Biological Sciences, University of Jordan, P.O. Box 2686, Amman 11181, Jordan     

Purification and Characterization of an Extracellular Cold-Active Serine Protease from the Psychrophilic Bacterium <Emphasis Type="Italic">Colwellia</Emphasis> sp. NJ341

Colwellia sp. NJ341, isolated from Antarctic sea ice, secreted a cold-active serine protease. The purified protease had an apparent Mr of 60 kDa by SDS-PAGE and MALDI-TOF MS. It was active from pH 5–12 with maximum activity at 35 °C (assayed over 10 min). Activity at 0 °C was nearly 30% of the maximum activity. It was completely inhibited by phenylmethylsulfonyl fluoride.     

Production and characterization of extracellular lipase from Calvatia gigantea

Summary A number of factors affecting production of extracellular lipase by the edible fungus Calvatia gigantea were investigated. Consecutive optimization of carbon and nitrogen sources, initial pH of culture medium and growth temperature resulted in an increase in lipase activity of 87%. Under optimum conditions, activities as high as 22.4 units ml^–1 of culture medium were obtained, competing favourably with most activities reported for other lipase hyperproducing microorganisms. The enzyme was optimally active at pH 7.0 and 30°C and had, at optimum pH, half-lives of 75.7 and 22.9 min at 45 and 55°C. Both high activity and kinetic characteristics of the enzyme make this process worthy of further investigation.Correspondence to: B. J. Macris     

A colorimetric method for the determination of lipase activity in soil

A colorimetric method for the determination of lipase activity in soil has been developed. Using p-nitrophenyl butyrate as substrate, soil samples are incubated at 30°C and pH 7.25 for 10 min. After cooling on ice and centrifugation, the released p-nitrophenol is determined at 400 nm. To allow for the adsorption of p-nitrophenol onto soil, a calibration curve is prepared in the presence of soil.     

Characterization of two bacteriocins produced by Leuconostoc mesenteroides L124 and Lactobacillus curvatus L442, isolated from dry fermented sausages

Leuconostoc mesenteroides L124 and Lactobacillus curvatus L442, isolated from dry fermented sausages, produce bacteriocins antagonistic towards closely related species and pathogens, such as Listeria monocytogenes. The bacteriocins were inactivated by proteolytic enzymes and lipase but not by catalase and lysozyme. They were also heat stable, retaining activity after heating at 100 °C for 60 min. The bacteriocins were stable at pH values ranging from 2.0 to 8.0. Bacteriocin production was observed at low temperatures (10 and 4 °C) and in meat juice. The maximum bacteriocin activity was observed at the end of the exponential growth phase. The bacteriocins were produced in media with initial pH values ranging from 5.0 to 7.5, but not in media with a pH lower than 5.0 (weak bacteriocin activity of the antibacterial compound produced by Ln. mesenteroides L124 was observed at pH 4.5). Both bacteriocins exhibited strong bactericidal activity following cell/bacteriocin contact.     

Two acidothermotolerant lipases from new variants of Bacillus spp.

Two acidothermotolerant lipases from new isolates of Bacillus stearothermophilus SB-1 and Bacillus licheniformis SB-3 are reported. In addition, a thermotolerant, neutral lipase from Bacillus atrophaeus SB-2 that hydrolyses castor oil is also reported. The lipase from B. stearothermophilus SB-1 retained 70% activity and that from B. licheniformis SB-3 retained 50% activity at pH 3.0 at 50 °C. In addition, at 100 °C B. stearothermophilus SB-1 lipase had a half life of 25 min at pH 3.0 and 15 min at pH 6.0. Lipase activity was markedly stimulated by glycerol in case of B. stearothermophilus SB-1 and by diethylether in cases of B. atrophaeus SB-2 and B. licheniformis SB-3. The lipases varied in their substrate specificity towards triacylglycerols. The rate of hydrolysis of neem oil with B. stearothermophilus SB-1 and B. atrophaeus SB-2 lipases was, respectively, nearly 4-fold and 2-fold more than with olive oil.     

Optimization of extracellular psychrophilic alkaline lipase produced by marine Pseudomonas sp. (MSI057)

An endosymbiotic Pseudomonas sp. (MSI057), which could produce high yields of lipase, was isolated from marine sponge Dendrilla nigra, collected from the peninsular coast of India. Maximum production of enzyme was obtained in minimal medium supplemented with 1% tributyrin. Catabolite repression was observed when the medium was supplemented with readily available carbon sources. The optimum temperature and pH for the enzyme production was 30 degrees C and 9.0, respectively. The enzyme exhibited maximum activity in pH range of 8-9 with an optimum pH 9.0. The activity of purified enzyme was optimum at 37 degrees C and showed 80% activity at 20 degrees C and the enzyme activity decreased dramatically above 50 degrees C. Based on the present findings, the enzyme was characterized as psychrophilic alkaline lipase, which can be developed for industrial applications.