Improved catalytic performance of GA cross-linking treated Rhizopus oryzae IFO 4697 whole cell for biodiesel production

Whole cell-mediated methanolysis of renewable oils for biodiesel production has drawn much attention in recent years since it can avoid the complex procedures of isolation, purification and immobilization required for the preparation of immobilized lipase. It has been demonstrated that Rhizopus oryzae IFO 4697 whole cell could catalyze the methanolysis of renewable oils for biodiesel production effectively and glutaraldehyde (GA) cross-linking treatment on whole cell catalyst could improve its stability in the repeated uses. The catalytic performance of cells with GA cross-linking treatment was studied systematically in this paper. The results showed that the treated cells expressed higher methanol tolerance, and high catalytic activity could be maintained with higher ratio of methanol to oil; the operational stability of whole cell catalyst and methanol utilization rate were also considered in optimization of methanol addition strategy. A novel methanol addition strategy was proposed, with which the reaction time could be shortened significantly and a biodiesel yield of 94.1% could be obtained within 24 h reaction; it was also found that with this methanol addition strategy, GA cross-linked whole cell expressed rather good operational stability; the reason for stability improvement was also investigated and should be attributed to less lipase leakage.     

Green chemistry appended synthesis,metabolic stability and pharmacokinetic assessment of medicinally important chromene dihydropyrimidinones

A green chemistry approach has been developed for the synthesis of chromene dihydropyrimidinone (CDHPM) using recyclable Fe/Al pillared clay catalyst. Pharmacokinetic parameters like aqueous solubility, lipophilicity, P-glycoprotein (P-gp) ATPase activity, permeability, plasma protein binding, red blood cell (RBC) partitioning, metabolic stability in liver microsomes and in silico computations have been studied for the most potent anticancer chromene dihydropyrimidinone hybrid 1. This compound exhibited low solubility, optimum lipophilicity, no P-gp inhibitory activity, intermediate permeability, high plasma protein binding, low RBC partitioning, acceptable metabolic stability in rat liver microsomes (RLM) as well as human liver microsomes (HLM) with transitional hepatic extraction ratio.     

Purification, Immobilization, and Some Properties of Glucose Isomerase from Streptomyces flavogriseus

Glucose isomerase (EC 5.3.1.5) produced from Streptomyces flavogriseus was purified by fractionation with (NH₄)₂SO₄ and chromatography on diethylaminoethyl (DEAE)-cellulose and DEAE-Sephadex A-50 columns. The purified enzyme was homogeneous as shown by ultracentrifugation and sodium dodecyl sulfate-polyacrylamide gel electrophoresis. Benzyl DEAE-cellulose, triethylaminoethyl-cellulose, and DEAE-cellulose were effective in the immobilization of partially purified glucose isomerase. Several differences in properties were found between purified soluble enzyme, immobilized enzyme (DEAE-cellulose-glucose isomerase), and heat-treated whole cells. Glucose and xylose served as substrate for the enzyme. Whole cells had the highest K_m values for glucose and xylose; the soluble enzyme had the lowest values. The optimum temperature for activity of the soluble and immobilized enzymes was 70°C; that for whole cells was 75°C. The pH optimum for the three enzyme preparations was 7.5. Magnesium ion or Co²⁺ was required for enzyme activity; an addition effect resulted from the presence of both Mg²⁺ and Co²⁺. The enzyme activity was inhibited by Hg²⁺, Ag⁺, or Cu²⁺. The conversion ratio of the enzyme for isomerization was about 50%. The soluble and immobilized enzymes showed a greater heat stability than whole cells. The soluble enzyme was stable over a slightly wider pH (5.0 to 9.0) range than the immobilized enzyme and whole cells (pH 5.5 to 9.0). The molecular weight of the enzyme determined by the sedimentation equilibrium method was 171,000. A tetrameric structure for the enzyme was also indicated. After operating at 70°C for 5 days, the remaining enzyme activity of the immobilized enzyme and whole cells, which were used for the continuous isomerization of glucose in a plug-flow type of column in the presence of Mg²⁺ and Co²⁺, was 75 and 55%, respectively. Elimination of Co²⁺ decreased operational stability.     

NADH-cytochrome c reductase activity in cultured human lymphocytes: Similarity to the liver microsomal NADH-cytochrome b5 reductase and cytochrome b5 enzyme system

A NADH-cytochrome c reductase activity was increased upon mitogen stimulation of human lymphocytes. The activity was not inhibited by antimycin A or rotenone but was specifically inhibited by antibodies elicited against rat liver NADH-cytochrome b₅ reductase or cytochrome b₅. The activity was linear with cellular homogenates up to 5.2 × 10⁶ cells/ml and had abroad pH optimum of 7.7. The presence of 3-methylcholanthrene in mitogen stimulation media had no effect on the NADH-cytochrome c reductase activity but differentially induced the benzo(a)pyrene hydroxylase (AHH) activity. The reductase activity was present in nonstimulated cells and appears not to be significantly increased in activity per cell upon mitogen-stimulation of the peripheral lymphocyte.     

Characterization of molecular-sieve-bound inulinase

The enzyme inulinase (2,1-β-d-fructan fructanohydrolase, EC 3.2.1.7), prepared from Kluyveromyces marxianus has been immobilized using an inorganic solid support, molecular sieve 4A via the metal link method. The immobilized enzyme had around 22 units of inulinase activity per g of the support with retention of 72% of the original activity. The optimum protein to molecular sieve ratio for the maximum retention of inulinase activity was 9 mg/g molecular sieve. The properties of soluble and immobilized enzyme differed in many respects. The optimum pH of the enzyme shifted from 6 to 5 and the optimum temperature of enzyme activity changed from 50 to 55°C. K_m values were 6.7 mM for soluble enzyme and 10 mM for immobilized enzyme. The heat stability of the enzyme was improved by immobilization. Immobilized enzyme retained about 76% of the original activity after 40 days of storage at room temperature (30±2°C).     

Bacteriolytic enzymes from Staphylococcus aureus. Properties of the endo-β-N-acetylglucosaminidase

An extracellular bacteriolytic endo-β-N-acetylglucosaminidase has been purified and its specificity of action has been investigated (Wadström & Hisatsune, 1970a,b). Some enzymic properties, such as optimum pH for enzyme activity on whole cells and cell walls of Micrococcus lysodeikticus and Staphylococcus aureus and optimum pH for stability, have been studied. The activity was maximum in 0.05m-tris–hydrochloric acid buffer, pH7.0. A higher ionic strength inhibited cell-wall hydrolysis. Since the crude and purified enzymes were found to be unstable on storage, the stabilizing and inhibiting effects of several compounds were investigated. Several heavy metal ions inactivated the enzyme at very low concentrations. Thiol compounds stabilized and thiol-reacting compounds partly inhibited the activity. Crude and purified glucosaminidase was found to be heat-stable at acidic pH and unstable at alkaline pH as previously found for several lysozymes (endo-β-N-acetylmuramidases). Other properties of the staphylococcal enzyme and hen''s-egg-white lysozyme have been compared, since the modes of action of the two are quite similar (Wadström & Hisatsune, 1970b).     

Preparation,characterization and laboratory-scale application of an immobilized glucoamylase

Glucoamylase (1,4-α-d-glucan glucohydrolase, EC 3.2.1.3) has been covalently immobilized on a polyacrylamide-type support containing carboxylic groups activated by water-soluble carbodiimide. The activity was 5.5– 6.0 units g^?1solid. The optimum pH for catalytic activity was pH 3.8. The apparent optimum temperature was found at 60°C. With soluble starch as substrate the K_m value was 14 mg ml^?1. The pH for maximum stability was pH 4.0–4.5. In the presence of 8 m urea the immobilized glucoamylase retained most of its catalytic activity but it was more susceptible to guanidinium hydrochloride than the soluble enzyme. The practical applicability of immobilized glucoamylase was tested in batch process and continuous operation.     

Purification and characterization of a serine protease extracellularly produced by Aspergillus fumigatus in a shrimp and crab shell powder medium

A fungus with protease and chitinase activities was isolated from the soil. It has been identified as Aspergillus fumigatus Fresenius TKU003. A. fumigatus TKU003 produced proteases and chitinases when it was grown in a medium containing shrimp and crab shell powder (SCSP) of marine waste. An extracellular protease was purified from the culture supernatant of A. fumigatus TKU003. The molecular weight of TKU003 protease was 124 kDa by sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE). The pI for TKU003 protease was 8.3. The optimum pH, optimum temperature, pH stability, and thermal stability of TKU003 protease was pH 8, 40 °C, 6–10, and 50 °C, respectively. The activity of the enzyme was strongly inhibited by PMSF. TKU003 serine protease, same as most other serine proteases of A. fumigatus, belongs to protease with alkaline pI. The unique characteristics of TKU003 protease is its high molecular weight.     

Exploring the effects of oil inducer on whole cell-mediated methanolysis for biodiesel production

Whole cell-mediated methanolysis of renewable oils for biodiesel production has drawn much attention in recent years since it can avoid the complex preparation procedures of traditional immobilized lipase. During the cultivation of Rhizopus oryzae whole cell catalyst, plant oils are usually added into the medium as inducer for lipase synthesis. It was found that oil inducer not only influenced lipase production, but also led to varied whole cell's catalytic performance. In this paper, the related mechanisms were explored and it was found that the higher unsaturated fatty acid (UFA) was contained in oil inducer, the higher intracellular lipase could be obtained. Different oil inducers also resulted in varied compositions of cell membrane, which was further found to be responsible for the operational stability of the catalyst. Cells with membrane enriched with saturated fatty acid (SFA) exhibited better stability than those enriched with UFA. And further study showed that after glutaraldehyde cross-linking treatment, the operational stability of both UFA enriched cells and SFA enriched cells were enhanced greatly and no loss in cell's catalytic activity was detected after being repeatedly used for 15 batches.     

Pharmacokinetic evaluation of medicinally important synthetic N,N′ diindolylmethane glucoside: Improved synthesis and metabolic stability

An improved route for the synthesis of N,N′-diindolyl methane (DIM) glycosides has been developed by using Fe/Al pillared clay catalyst. In-silico pharmacokinetics followed by in-vitro studies like aqueous solubility, lipophilicity, P-glycoprotein (P-gp) dependent ATPase activity, permeability, plasma protein binding, RBC partitioning, metabolic stability in different liver microsomes and its in-vitro-in-vivo extrapolation were conducted for the most potent derivative namely NGD16. The compound was found to have low solubility, optimum lipophilicity, no P-gp inhibitory activity, intermediate permeability, high plasma protein binding, low RBC partitioning, acceptable metabolic stability in rat liver microsomes (RLM) as well as human liver microsomes (HLM) with intermediate hepatic extraction ratio.     

Immobilization of Escherichia coli cells containing aspartase activity with kappa-carrageenan. Enzymic properties and application for L-aspartic acid production.

Whole cells of Escherichia coli having high aspartase (L-asparate ammonialyase, EC 4.3.1.1) activity were immobilized by entrapping into a kappa-carrageenan gel. The obtained immobilized cells were treated with glutaraldehyde or with glutaraldehyde and hexamethylenediamine. The enzymic properties of three immobilized cell preparations were investigated, and compared with those of the soluble aspartate. The optimum pH of the aspartase reaction was 9.0 for the three immobilized cell preparations and 9.5 for the soluble enzyme. The optimum temperature for three immobilized cell preparations was 5--10 degrees C higher than that for the soluble enzyme. The apparent Km values of immobilized cell preparations were about five times higher than that of the soluble enzyme. The heat stability of intact cells was increased by immobilization. The operational stability of the immobilized cell columns was higher at pH 8.5 than at optimum pH of the aspartase reaction. From the column effluents, L-aspartic acid was obtained in a good yield.     

Trichloroethylene degradation by cells of a methane-utilizing bacterium,Methylocystis sp. M,immobilized in calcium alginate

When Methylocystis sp. M cells were immobilized in calcium alginate, the resulting cell beads showed optimum trichloroethylene (TCE) degradation activity at pH 7.0 and 35°C. In comparison with free cells, the immobilized cells were more stable at low pH, and to some extent, at higher temperatures. Studies on the kinetics and the influence of cell density suggest that oxygen permeation was a rate-limiting step. Investigation of the storage stability and the optimum concentration of dissolved oxygen revealed that the TCE degradability was greater under anaerobic than aerobic conditions. Although a toxic effect caused by TCE was observed, methane seemed to restore activity, suggesting that the development of a two-step reactor system might be advantageous. The finding that the immobilized cells showed TCE degradation activity in actual groundwater suggests that TCE bioremediation could be achieved through the use of bioreactors with such cells.     

Solvent free biocatalytic synthesis of isoniazid from isonicotinamide using whole cell of Bacillus smithii strain IITR6b2

A biocatalytic route for the synthesis of isoniazid, an important first-line antitubercular drug, in aqueous system is presented. The reported bioprocess is a greener method, does not involve any hazardous reagent and takes place under mild reaction conditions. Whole cell amidase of Bacillus smithii strain IITR6b2 having acyltransferase activity was utilized for its ability to transfer acyl group of isonicotinamide to hydrazine–2HCl in aqueous medium. B. smithii strain IITR6b2 possessed 3 folds higher acyltransferase activity as compared to amide hydrolase activity and this ratio was further improved to 4.5 by optimizing concentration of co-substrate hydrazine–2HCl. Various key parameters were optimized and under the optimum reaction conditions of pH (7, phosphate buffer 100 mM), temperature (30 °C), substrate/co-substrate concentration (100/1000 mM) and resting cells concentration (2.0 mg_dcw/ml), 90.4% conversion of isonicotinamide to isoniazid was achieved in 60 min. Under these conditions, a fed batch process for production of isoniazid was developed and resulted in the accumulation of 439 mM of isoniazid with 87.8% molar conversion yield and productivity of 6.0 g/h/g_dcw. These results demonstrated that enzymatic synthesis of isoniazid using whole cells of B. smithii strain IITR6b2 might present an efficient alternative route to the chemical synthesis procedures without the involvement of organic solvent.     

Serratia marcescens chitinase: One-step purification and use for the determination of chitin

The extracellular chitinase produced by Serratia marcescens was obtained in highly purified form by adsorption-digestion on chitin. After gel electrophoresis in a nondenaturing system, the purified preparation exhibited two major protein bands that coincided with enzymatic activity. A study of the enzyme properties showed its suitability for the analysis of chitin. Thus, the chitinase exhibited excellent stability, a wide pH optimum, and linear kinetics over a much greater range than similar enzymes from other sources. The major product of chitin hydrolysis was chitobiose, which was slowly converted into free N-acetylglucosamine by traces of β-N-acetylglucosaminidase present in the purified preparation. The preparation was free from other polysaccharide hydrolases. Experiments with radiolabeled yeast cell walls showed that the chitinase was able to degrade wall chitin completely and specifically.     

Calcium dependent,alkaline detergent-stable trypsin from the viscera of Goby (Zosterisessor ophiocephalus): Purification and characterization

An alkaline calcium dependent trypsin from the viscera of Goby (Zosterisessor ophiocephalus) was purified to homogeneity with a 16-fold increase in specific activity and 20% recovery. The purified trypsin appeared as a single band on sodium dodecyl sulphate-polyacrylamide gel (SDS-PAGE) and native-PAGE. The enzyme had an estimated molecular weight of 23.2 kDa.The optimum pH was 9.0, and the enzyme was extremely stable in various pH buffers between pH 7.0 and 11.0. The optimum temperature for enzyme activity was 60 °C, and the activity and stability of trypsin was highly dependent on the presence of calcium ion. At 60 °C, Ca²⁺ (5 mM) stimulated the protease activity by 220%. The trypsin kinetic constants, K_m and k_cat, were 0.312 mM and 2.03 s^?1.The enzyme showed high stability towards non-ionic surfactants and oxidizing agent. In addition, the enzyme showed excellent stability and compatibility with some commercial solid and liquid detergents.     

Purification and kinetic characterization of the liverwort Pallavicinia lyelli (Hook.) S. Gray. cytosolic ascorbate peroxidase

Ascorbate peroxidase (APX) of the liverwort Pallavicinia lyelli was extracted and purified through ammonium sulfate precipitation, Butyl-Toyopearl, DEAE-Cellulofine and Sephadex G-75 chromatography. The purification factor for APX was 285 with 7.9% yield. The enzyme was characterized for thermal stability, pH and kinetic parameters. The molecular mass of APX was approximately 28 kDa estimated by SDS-PAGE. The purity was checked by native PAGE, showing a single prominent band. The optimum pH was 6.0. The enzyme had a temperature optimum at 40 °C and was relatively stable at 60 °C, with 54% loss of activity. When the enzyme was diluted with the ascorbate-deleted medium, the half inactivation time was approximately 15 min. The absorption spectra of the purified enzyme and the inhibition by cyanide and azide showed that it is a hemoprotein. Spectral analysis and inhibitor studies were consistent with the presence of a heme moiety. When compared with ascorbate peroxidase activity derived from ruptured intact chloroplasts, the purified enzyme was found to have a higher stability, a broader pH optimum for activity and the capacity to utilize alternate electron donors. p-chloromercuribenzoate (pCMB), hydroxyurea and salicylic acid (SA) significantly inhibited APX activity. Ascorbate (AsA) and pyrogallol were found to be efficient substrates for Pallavicinia APX, considering the Vmax/Km ratio. We detected the activity of monodehydroascorbate reductase (MDHAR) involved in the regeneration of ascorbate, but failed to detect the dehydroascorbate reductase (DHAR) activity. The data obtained in this study may help to understand desiccation tolerance mechanism in the liverwort.     

Self-immobilized recombinant Acetobacter xylinum for biotransformation

Biofilms have been successfully applied for biotransformation for decades, especially in the area of bioremediation due to the feature of harsh reaction condition resistance. Acetobacter xylinum is known for its cellulose pellicle forming capability. Like biofilm, A. xylinum cells are immobilized by simultaneously produced cellulose nanofibers in the pellicle. A recombinant A. xylinum was constructed with the expectation that the cells could be self-immobilized and achieve a desired and stable biotransformation. d-Amino acid oxidase (DAAO) of Rhodosporidium toruloides was used as the model enzyme to be expressed in the recombinant A. xylinum. The constructed recombinant A. xylinum not only successfully produced DAAO activity but also self-immobilized by cellulose nanofibers in both the static and shaken culture. Although self-immobilized cells demonstrated a DAAO activity approximately 10% of the cell crude extract activity, it provided the benefits of improved thermal stability, operational stability, and easy retrieval for repeated use.     

Isolation and characterization of extracellular glucose oxidase from Penicillium adametzii LF F-2044.1

Hydroxides of magnesium and zinc, aluminum oxide, zinc phosphate, and co-precipitated Ca₃(PO₄)₂ and Mg(OH)₂ were efficient in binding extracellular glucose oxidase (GO) of P. adametzii LF F-2044.1 in a culture liquid filtrate (CLF). Basic Al₂O₃ was the most appropriate adsorbent for GO isolation from the CLF of the fungus. A GO isolation method was developed, which allowed for obtaining an enzyme with a high degree of purification. Spectral properties of the enzyme, its catalytic activity, and stability were characterized. The GO of P. adametzii LF F-2044.1 exhibited high pH stability, retaining activity within the range 4.5–9.0. The rate that GO-catalyzed D-glucose oxidation increased as the temperature increased (up to approximately 60°C). The catalytic activity and thermal stability of GO depended on its concentration in the medium. Under optimum conditions, the fractions GO-1 and GO-2 were characterized by K _M values of 1.56 × 10^?2 and 2.19 × 10^?2 M, respectively; the corresponding values of k _cat equaled 235.1 and 318.2 s^?1.     

Biochemical characterization of a recombinant thermostable β-mannosidase from Thermotoga maritima with transglycosidase activity

A β-mannosidase gene (TM1624) from Thermotoga maritima MSB8, the hyperthermophilic bacterium was expressed as a soluble C-terminal His-tagged protein in E. coli. Heat treatment of cell lysate followed by metal affinity- and anion-exchange chromatographic techniques the recombinant β-mannosidase was purified to apparent homogeneity. The recovery of the purified protein from the crude lysate was 23%. Results of SDS-PAGE analysis (96.8 kDa) and gel permeation chromatography (93.2 kDa) indicated monomeric nature of the β-mannosidase protein. The enzyme displayed its maximal activity at pH 7.0 with pH stability over a range of pH 5.0–9.0. Similarly, the optimum temperature for maximal activity was found to be 95 °C and thermostability of up to 85 °C. The substrate specificity and kinetics of the enzyme was studied using different mannooligosaccharides and pNP-β-d-mannopyranoside. The K_m value of the purified enzyme for pNPM was 0.49 mM. Different mannooligosaccharides tested as enzyme substrates were hydrolysed in an exo-wise manner when checked by thin-layer chromatography (TLC). The enzyme also exhibited transglycosidase activity when the reaction was carried out with 10% (w/v) of mannobiose in the presence of alcohols or galactose. Because of extreme thermostability and transglyocosylation properties of β-mannosidase from T. maritima, the enzyme may be of industrial applications in future. This is the first report on the purification and characterization of a β-mannosidase from T. maritima.     

An investigation into the pectolytic activity of the yeast Saccharomycopsis fibuliger

Saccharomycopsis fibuliger cells produce an inducible hydrolase, tentatively characterized as a polygalacturonase [poly(1,4-α-d-galacturonide) glycanohydrolase, EC 3.2.1.15], which is associated with the yeast cells and which causes the partial hydrolysis of pectin or poly-d-galacturonic acid. No evidence of pectinesterase (pectin pectyl hydrolyase, EC 3.1.1.11) or pectate lyase [poly(1,4-α-d-galacturonide) lyase, EC 4.1.1.1] activity has been found. Enzyme production took place at an optimum temperature of 28°C, whereas optimum activity was at ～45°C. The optimum pH for pectolytic activity was similar to the optimum pH for cell growth. A reduction in the concentration of dissolved oxygen in the culture medium and an increase in cell age caused an increase in the rate of pectin decomposition within the limits employed. Products of pectin decomposition consisted of a mixture of uronides including d-galacturonic acid.