Enzymatic Peptide Synthesis in Organic Media. Synthesis of CCK-8 Dipeptide Fragments

The enzymatic synthesis of the seven consecutive dipeptide fragments of the cholecysto kinin C-terminal octapeptide (CCK-8) in organic media is reported. The influence of the reaction medium composition, the protease, and the structure of N-α and C-α protecting groups of both carboxyl and amino components was evaluated. α-Chymotrypsin, papain and thermolysin adsorbed on Celite were used as catalysts, under thermodynamic and kinetic control. The carboxamidomethyl, methyl and allyl ester derivatives of acetyl, benzyloxycarbonyl, tert-butyloxycarbonyl and fluoren-9-ylmethoxycarbonyl amino acids, were assayed as carboxy components. Amino acid amide and ester derivatives were employed as nucleophiles with a preference for the latter, since the dipeptide product obtained could be used directly, without any further chemical modification, as acyl-donor in subsequent coupling steps. All dipeptides selected were successfully synthesized, using the optimal combination of protecting groups, reaction media and enzyme different for each coupling reaction. The information gained with this study should be instrumental in designing an optimal strategy for the total enzymatic synthesis of cholecystokinin C-terminal octapeptide (CCK-8).     

Regioselective Enzymatic Synthesis of Non-Steroidal Anti-Inflammatory Drugs Containing Glucose in Organic Media

Enzymatic transesterification of glucose with the vinyl ester of non-steroidal anti-inflammatory drugs (NSAIDs) was in organic media performed for synthesis of novel NSAIDs-glucose conjugates. Glucose was regioselectively acylated at the 6-hydroxyl group. The indomethacin-glucose conjugate and ketoprofen-glucose conjugate were produced by the catalysis of alkaline protease from Bacillus subtilis in the respective yields of 42% (over 48 h) and 63% (over 40 h). The etodolac-glucose conjugate was obtained in 26% yield (over 144 h) by lipase from Candida antarctica.     

微水体系中荧光假单胞菌脂肪酶催化合成单甘酯

研究了无溶剂微水体系中荧光假单胞菌脂肪酶 (PFL)催化油脂甘油解合成单甘酯的反应因素以及多温程非均相固液反应对单甘酯产率的影响。以初始体系最低共熔点 (PFL)取代临界温度学说中的油脂初熔点 ,通过考察不同IEP体系的甘油解 ,发现PFL酶促油脂甘油解时存在碳链基质特异性的函数关系 ,即反应物油脂中饱和碳残基的质量百分含量 (C₁₆+C₁₈)与单甘酯产率间符合以下多项式:Y =- 0.0006X³ +0.0592X²-0.8909X+26.753(13%<X<76.5%),式中X为C₁₆+C₁₈,Y为40℃时等温反应条件下的单甘酯产率。IEP为40℃时,最适等温反应条件如下：加水量3%～4.5%,加酶量为500μ/g油酯摩尔比1：2.5-5.0(油酯：甘油)反应温度40℃.实验条件下多步等程序降温反应48h后单甘酯最高产率为81.4%.     

有机介质中酶促合成壬酸香草醇酯的研究

壬酸香草醇酯是与天然辣椒素酯结构最接近的一个化合物,本文研究了有机相中脂肪酶催化合成这个化合物的方法,为天然辣椒素酯的酶促合成探索方法。考察了酶、溶剂、酶的用量、底物浓度、溶剂水含量以及温度等因素对反应的影响,结果表明脂肪酶Novozym e 435的活性最好,最适条件为:在1 mL脱水丙酮中,香草醇与壬酸甲酯的浓度分别为50、75 mmol/L,酶量为20 mg,30℃下反应24 h,产率可达到60%以上,产物经硅胶柱层析纯化,并以1H NMR及MS进行了表征。     

Modified Proteases for Peptide Synthesis in Organic Media

We showed that modified proteases could catalyze synthesis of a wide variety of peptides of various lengths and structures both in solution and on solid phase in organic solvents. The following modified proteases were studied as catalysts for enzymatic peptide synthesis in polar organic solvents (acetonitrile, dimethylformamide, and ethanol): pepsin sorbed on celite, a noncovalent complex of subtilisin with sodium dodecylsulfate, and subtilisin or thermolysin covalently immobilized on a cryogel of polyvinyl alcohol. The use of the noncovalent complex of subtilisin with sodium dodecylsulfate and immobilized subtilisin is especially promising for the segment condensation of peptide fragments containing residues of trifunctional amino acids with unprotected ionogenic groups in side chains, such as Lys, Arg, His, Glu, and Asp.     

Enzymatic Synthesis of Various Aromatic Polyesters in Anhydrous Organic Solvents

Lipases and proteases from various sources were tested in aromatic polyester synthesis in organic solvents. A commercial protease from Bacillus licheniformis efficiently catalyzed the transesterifica-tion of a diester of terephthalic acid and 1,4-butanediol in anhydrous tetrahydrofuran (THF). This protease was used as a catalyst in the synthesis of aromatic polyesters in THF. Oligomers with average molecular weights from 400 to 1000 daltons were obtained using various diols and aromatic diesters.     

Enzymatic Peptide Synthesis with Fatty Acid-modified Chymotrypsin and Trypsin in Aqueous-organic Media

Equilibrium controlled enzymatic peptide syntheses in aqueous-organic media were done with chymotrypsin and trypsin modified with varied fatty acid. Palmitoyl-modified chymotrypsin and trypsin synthesized the peptide at 1.7 and 2.4 times higher yield than those unmodified. Since an alteration of the substrate specificity was not observed, the chemical modification did not affect the active site of the enzymes.     

Enzymatic Synthesis of Trehalose from Maltose

Synthesis of trehalose from maltose by a coupled enzyme system with trehalose Phosphorylase and maltose Phosphorylase has been studied. Trehalose Phosphorylase was partially purified from Euglena gracilis and maltose Phosphorylase was obtained from Lactobacillus brevis. The optimum pH of the reaction was 6.5~7.0 and the reaction rate was faster in the rection mixture containing a low concentration of phosphate. The final ratio of conversion (the ratio of trehalose to maltose) in the pH range between 6.0 and 8.0 was about 60%.

Immobilized maltose and trehalose Phosphorylase in κ-carageenan could be used without any appreciable loss of activity for batch reactions at least 10 times.     

产有机相催化酯合成活性的脂肪酶菌株的筛选

通过添加10g/L的甲苯作为唯一碳源进行预培养,然后以透明圈平板筛选法从土壤样品中成功地筛选到了一株耐有机溶剂的产脂肪酶的酵母菌A213,初步鉴定为耶罗威亚酵母(Yarrowia sp．)。摇瓶实验表明,A213适宜的产酶培养基为(g/L):酵母膏40g,橄榄油10g,MgSO~4·7H~2O 1g,KH_2PO_45g,最佳培养条件为27℃、初始pH 6．5。脂肪酶活力最高可达67．8 IU/mL;该酶最适作用温度为40℃,最适作用pH为6．5,在70℃以下, pH 5．5～8．5范围内稳定,能直接在叔戊醇溶剂中催化合成L-抗坏血酸棕榈酸酯。     

Dispersibility of Nanocrystalline Cellulose in Organic Solvents

Russian Journal of Bioorganic Chemistry - Aqueous suspensions of nanocrystalline cellulose (NCC) were obtained by sulfuric acid hydrolysis using the standard procedure. Suspensions, films, and...     

Synthesis of a Precursor Dipeptide of Thymopentin in Organic Solvents by an Enzymatic Method

Abstract

The protease‐catalyzed, kinetically controlled synthesis of a precursor dipeptide of thymopentin(TP‐5), Z‐Arg‐Lys‐NH₂ in organic solvents was studied. Z‐Arg‐OMe was used as the acyl donor and Lys‐NH₂ was used as the nucleophile. An industrial alkaline protease alcalase and trypsin were used to catalyze the synthesis of the target dipeptide in water‐organic cosolvent systems. The conditions of the synthesis reaction were optimized by examining the effects of several factors, including organic solvents, water content, temperature, pH, and reaction time on the yield of Z‐Arg‐Lys‐NH₂. The optimum conditions using alcalase as the catalyst are pH 10.0, 35°C, in acetonitrile/DMF/Na₂CO₃‐NaHCO₃ buffer system (80∶10∶10, V/V), 6 h, with the dipeptide yield of 71.1%. Compared with alcalase, the optimum conditions for trypsin are pH 8.0, 35°C, in ethanol/Tris‐HCl buffer system (80∶20, V/V), 4 h, with the dipeptide yield of 76.1%.     

Loosening Xyloglucan Accelerates the Enzymatic Degradation of Cellulose in Wood

In order to create trees in which cellulose, the most abundant component in biomass, can be enzymatically hydrolyzed highly for the production of bioethanol, we examined the saccharification of xylem from several transgenic poplars, each overexpressing either xyloglucanase, cellulase, xylanase, or galactanase. The level of cellulose degradation achieved by a cellulase preparation was markedly greater in the xylem overexpressing xyloglucanase and much greater in the xylems overexpressing xylanase and cellulase than in the xylem of the wild-type plant. Although a high degree of degradation occurred in all xylems at all loci, the crystalline region of the cellulose microfibrUs was highly degraded in the xylem overexpressing xyloglucanase. Since the complex between microfibrils and xyloglucans could be one region that is particularly resistant to cellulose degradation, loosening xyloglucan could facilitate the enzymatic hydrolysis of cellulose in wood.     

Enzymatic transformations in supersaturated substrate solutions: II. Synthesis of disaccharides via transglycosylation

Enzymatic transglycosylation in supersaturated solutions of substrates was investigated using crude glycosidase preparations from barley, snail, and coffee beans. It was shown that the use of supersaturated glycoside solutions as media for transglycosylation reactions offers considerable advantages over conventional aqueous systems. These advantages include higher yields, more efficient use of the donor glycosides and improved volumetric productivity, especially in the case of poorly water-soluble substrates. The regioselectivity of the glycosylation was not significantly affected by high concentrations of acceptor glycosides. It was also shown that the regioselectivity of transfer could be directed towards secondary hydroxyl groups by the use of methyl 6-O-acetyl-alpha-galactopyranoside as acceptor. The value of these approaches was demonstrated by the synthesis of methyl 3- and 4-O-beta-D-galactopyranosyl-alpha-D-galactopyranosides and methyl 3-O-beta-D-galactopyranosyl-alpha-L-fucopyranoside on a preparative scale.     

Structural Stability of Myoglobin in Organic Media

The structural stability of metmyoglobin in organic solvents and cosolvents was investigated aiming the choice of a suitable medium to perform its dissolution with maintenance of the native folding. The spectroscopic behavior of metmyoglobin solution in UV–Visible and circular dichroism was used to evaluate the solubility and the secondary structure. The results were dependable of the chemical structure of the organic compounds, their polarity and content, in the case of cosolvents. Protic solvents showed better ability than the aprotic ones for the biomolecule dissolution, since they are able to establish hydrogen bonds. Solvents with high polarity usually damage the secondary structure of the protein. Myoglobin was dissolved in pure methanol, ethylene glycol and glycerol. The secondary structure was retained in some extent. The controlled addition of sodium dodecyl sulfate to myoglobin aqueous solution changed the surface moiety of the protein. The complex was extracted to hexane with efficiency of 77%.     

酶法合成中色氨酸的分离

本文对酶法合成中色氨酸的分离进行了研究,筛选出两种合适的树脂:~#330和~#732。实验数据表明:两种树脂串联能有效地将残留的底物吲哚去除,并且对色氨酸总的分离回收率大于70％。这就为今后酶法合成色氨酸工艺产业化提供了必要的数据。     

酶法合成中丙氨酸的检测

本文建立了丙氨酸在醋酸缓冲液中形成丙氨酸-铜配离子及其十二烷基磺酸配离子对,使其紫外无吸收的丙氨酸在230nm处于有强紫外吸收,从而对酶法合成中的丙氨酸进行定量分析．该法在0～50mg／L范围内有良好的线性关系,直线方程为A(230)=0.01712·C（n=5）C：mg／L）。相关系数为0．9994,回收率为96．8％～104．0％,且该法不受酶反应液的影响,实验结果证明该检测体系简单、实用、测定结果可靠。