Serum protects protein-free competent Chinese hamster ovary cells against apoptosis induced by nutrient deprivation in batch culture.

The development of serum- and protein-free Chinese hamster ovary (CHO) cell cultures is a high priority for the production of biopharmaceuticals. Protein-free competent CHO cells lines have been previously constructed by two different methods-metabolic engineering with cell-cycle regulatory proteins and long-term selective adaptation. Apoptosis was present in both cell lines during protein-free, static-batch culture as a result of nutrient deprivation, and glucose deprivation alone was a potent inducer of apoptosis compared to the depletion of other nutrients such as amino acids. By adding back serum to the cultures during batch growth or nutrient deprivation, it was shown that unidentified survival factors in serum can greatly reduce apoptosis in protein-competent cell lines in all phases of the culture. Both observations contrast to previous reports for hybridoma cells, in which amino acids were the key determinants of apoptosis and serum had no additional antiapoptotic effect. Serum's protective effect against CHO cell death in batch culture was multifaceted and complex: (1) 10% FBS increased cell viability to >99% during exponential growth from roughly 75-90%, (2) 5-10% fetal bovine serum (FBS) reduced specific glucose consumption rates in both cell lines by 40%, thereby delaying the onset of apoptosis caused by glucose deprivation, and (3) 5% FBS reduced the specific cell death rate by 65% during a 3-d lactate-consumption phase characterized by substantial abortive proliferation, in which the cells both proliferated and died at a constant rate. The benefit of serum on cell production over the various phases of batch growth was combined into a single parameter by integrating the viable cell concentration vs. time profile (termed here as cumulative volumetric viable cell-time, VCTvol). Despite the ability of both cell lines to grow indefinitely without any exogenous growth factors, the addition of serum resulted in a 2. 3-fold increase in the VCTvol. Thus, it is clear that there is much room for improvement of protein-free CHO cell lines despite their adequate growth competence, and new strategies different from those successfully used for hybridomas may be necessary to combat CHO cell apoptosis.     

Serum-free culture of tumor cells--recent problems in autocrine hypothesis]

Tumor cell lines in culture that can grow in protein-free medium are suitable for studying the mechanism of autonomous growth of tumor cells. We have studied the mechanism of autonomous growth of three cell lines which were established from human solid tumors. These cell lines produce basic fibroblast growth factor (bFGF), but it does not seem to act as an autocrine growth factor. bFGF produced by these cells is accumulated in the nuclei and may act as an autointrafactor for autonomous growth of these cells.     

Comparison of colony-formation efficiency of bovine fetal fibroblast cell lines cultured with low oxygen, hydrocortisone, L-carnosine, bFGF, or different levels of FBS

A comparison of colony-formation efficiency (CFE) was made between six independent bovine fetal fibroblast (BFF) cell lines used in somatic cell nuclear transfer. Variation in CFE was assessed under different culture conditions. The conditions examined were ambient atmosphere (approximately 20% oxygen) culture versus 5% oxygen culture, three levels of fetal bovine serum (FBS) in the medium (5%, 10% or 20%), and the amendment of 10% FBS medium with basic fibroblast growth factor (1 ng/mL), L-carnosine (20 mM), or hydrocortisone (1 microM). The six BFF cell lines showed significant differences from one another in CFE. No significant difference in CFE was found with reduced oxygen culture. L-Carnosine also had no significant effect on CFE. A FBS concentration of 10% was found to produce the best overall CFE. Hydrocortisone treatment reduced the size of colonies although the number of colonies formed was not affected. Basic FGF increased the size of colonies but the number of colonies formed was not affected. The results showed that different BFF cell lines varied significantly in their CFE. Also, some medium supplements or culture conditions that have shown positive CFE effects on the fibroblasts of other species failed to show significant positive CFE effects on the BFF cell lines tested.     

Development of standardized cell culture conditions for tumor cells with potential clinical application

BACKGROUND: Tumor cell lines have enormous value for the study of different aspects of cancer biology and have also recently gained great importance in autologous cell-based anti-tumor therapies. However, the use of these cells is still limited because in vitro growth is hampered by suboptimal culture conditions and current media contain fetal bovine serum (FBS), which poses serious safety concerns regarding clinical application. METHODS: To address this drawback, we aimed to develop a strategy for optimization of the culture medium for human medullary thyroid carcinoma (MTC) cell lines as a model system. We combined the general cell screening system (GCSS), which continuously measured the growth behavior of cells in a 96-well plate format, with statistically based experimental designs. RESULTS: The results obtained clearly demonstrated that, just by changing the composition of the basal medium, a significantly enhanced growth rate could be observed, and by subsequent addition of several substances a serum-free cell culture medium could be developed. This medium allowed the propagation of two MTC cell lines comparable with conventionally used serum-supplemented medium. DISCUSSION: We present a fast and easy way to screen for substances that are essential for tumor cell growth in vitro. Furthermore, these tumor cells can be adapted to culture conditions that allow the use of the cells in safe cell-based therapies. This is of utmost importance because of increasing regulatory requirements.     

Heat-inactivated coelomic fluid of the earthworm Perionyx excavatus is a possible alternative source for fetal bovine serum in animal cell culture

Fetal Bovine Serum (FBS) is used as a major supplement in culturing animal cells under in vitro conditions. Due to ethical concern, high cost, biosafety, and geographical as well as batchwise result variations, it is important to reduce or replace the use of FBS in animal cell culture. The major objective of this work is to evaluate the feasibility of heat-inactivated coelomic fluid (HI-CF) of the earthworm, Perionyx excavatus as a possible alternative for FBS in animal cell culture experiments. The coelomic fluid (CF) was extruded from the earthworm using electric shock method and used for the experiments. Electric shock method is a simple non-invasive technique, which has no harmful effect on earthworms. Mouse primary fibroblast and HeLa cell lines were used in this study. Among HI-CF, autoclaved CF and crude CF, the supplement of medium with HI-CF shows positive results. The processed HI-CF (90°C for 5 min) at 10% supplement in cell culture medium promote maximum cell growth but cells need the initial support of FBS for the attachment to the culture flask. Microscopic observation and immunofluorescence assay with actin and lamin A confirm that the cellular and molecular morphology of the cells is maintained intact. The HI-CF of earthworm, P. excavatus has shown better cellular viability when compared with FBS and making it possible as an alternative supplement to minimize the use of FBS.     

Serum-free hybridoma culture: ethical, scientific and safety considerations

Despite considerable progress in the development of cell culture techniques, including the development of the serum- and protein-free media that now routinely support hybridoma and mammalian cell growth, fetal bovine serum (FBS) supplemented media are still commonly used: a practice that raises ethical, scientific and safety concerns. The use of FBS in hybridoma culture media is examined here, with regards to the development and production of monoclonal antibodies (mAbs), and it is our recommendation that researchers adopt serum-free cell culture methods to reduce animal use in this area.     

CHO-recombinant human growth hormone as a protease sensitive reporter protein

Protein-free media are gaining more and more interest in mammalian cell culture technology. However, the range of commercially available protein-free media is wide, but lack of serum causes the lack of various substances (Keenan et al. in Cytotechnology, 50(1–3):49–56, 2006) which must be substituted case by case. Details on the composition of protein-free media are often unavailable or inaccessible in some cases, and as a consequence, there is an obvious need for testing procedures in order to evaluate the various commercialised products for their performance. Additionally, negative effects of tryptic meat digests on product quality have been reported in the literature (Gu et al. in Biotech Bioeng 56 (4):353–341, 1997). In the present studies of comparing various protein-free media for their suitability in propagation of recombinant CHO cells expressing human growth hormone (hGH), we have found somatotropin to be an excellent candidate for detection of protease activity. Somatotropin contains protease recognition sites for numerous proteases located around amino-acid residues 134–150. In this study, we demonstrate highly specific cleavage of recombinant hGH during batch cultivation. Analysis of the digested molecule was then performed by convergent methods like SDS-PAGE, HPLC and mass spectroscopy, and the results indicate hGH to be an ideal candidate for media and component screening in mammalian cell culture.     

Secretory protein enrichment and analysis: an optimized approach applied on cancer cell lines using 2D LC-MS/MS

Reliable methods for profiling secretory proteins are highly desirable for the identification of biomarkers of disease progression. Secreted proteins are often masked by high amounts of protein supplements in the culture medium. We have developed an efficient method for the enrichment and analysis of the secretome of different cancer cell lines, free of essential contaminants. The method is based on the optimization of cell incubation conditions in protein-free medium. Secreted proteins are concentrated and fractionated using a reversed-phase tC2 Sorbent, followed by peptide mass fingerprinting for protein identification. An average of 88 proteins were identified in each cancer cell line, of which more than 76% are known to be secreted, possess a signal peptide or a transmembrane domain. Given the importance of secreted proteins as a source for early detection and diagnosis of disease, this approach may help to discover novel candidate biomarkers with potential clinical significance.     

The role of p21cip1 in adaptation of CHO cells to suspension and protein-free culture

The up-regulation of cyclin-dependent kinase inhibitor p21 has been shown to enhance productivity of monoclonal antibodies and has been linked to various regulatory processes. To identify the potential role of p21 in adaptation to suspension and protein-free cultures, we studied the survival and growth of anchorage- and serum-dependent CHO cell lines that differed only in the period of p21-induced arrest. p21 overexpression led to rapid adaptation of cells to suspension and protein-free cultures. The period taken to achieve adaptation was correlated with the time the cells were arrested after transfer from the monolayer and serum-fed culture. Interestingly, cell aggregation associated with protein-free suspension culture was reduced in p21 culture in response to the loss of cellular adherence. The processes of adaptation to suspension and arrest did not decrease monoclonal antibody productivity. In contrast, following adaptation to protein-free growth media, an overall increase in specific productivity was observed. The ability of cells to survive in protein-free suspension cultures was due to the requirement of G1 cells to growth factors and to their relatively high resistance to the hydrodynamic forces. This improved process has the advantage of reducing the duration of critical path activity for developing CHO commercial cell lines from 72 to 36 days.     

Hybridoma cell growth and anti-neuroblastoma monoclonal antibody production in spinner flasks using a protein-free medium with microcarriers

The main disadvantages of foetal calf serum as the world-wide common serum supplement for cell growth are its content of various proteins of variable concentrations between batches as well as its high cost. The use of serum-free and protein-free media is gradually becoming one of the goals of cell culture especially for standardizing culture conditions or for simple purification of cell products like monoclonal antibodies. The mouse hybridoma cells 14/2/1 were cultivated either in protein-free UltraDOMA medium or in serum-containing RPMI medium with and without microcarriers to generate high quantities of monoclonal antibodies against neuroblastoma tumour cells. Cell growth rate, IgG production, viability, glucose and lactate concentrations, attachment rate and doubling time have been used as investigation criteria. Modifications of culture procedures (static or stirred), inoculum density, and microcarrier concentration caused an improvement of monoclonal antibody production. The kinetics of antibody synthesis was best in spinner culture with 2 ml of microcarriers in protein-free medium. These results of short-term microcarrier culture in stirred spinner flasks indicate that IgG yields in protein-free medium 2.5-fold higher to those in serum-supplemented medium can be achieved.     

Clonal growth of chinese hamster cell lines in protein-free media

A protein-free synthetic medium, MCDB 301, has been developed for clonal growth of Chinese hamster ovary cell lines. Medium F12 was developed originally for that purpose, but later failed to support good growth without small amounts of serum protein. Growth was restored by the addition of nonphysiological amounts of commercially prepared thyroxine or smaller amounts of the trace element selenium. The thyroxine preparation was shown to contain sufficient selenium to account for all of its growth-promoting activity. MCDB 301 contains increased concentrations of calcium chloride and glutamine, and a smaller amount of cysteine than medium F12. It also has been supplemented with 19 inorganic ions, in addition to selenium and those in medium F12, in order to insure against possible future deficiencies as chemicals are purified further. A Chinese hamster lung line which will not grow in MCDB 301 alone will grow when the medium is supplemented either with methylcellulose or with insulin. The growth-promoting activity is thought to be an impurity shared in common by both substances. The probable "essential" role of impurities in cellular growth in most synthetic media and the problems involved in attempting to develop a truly "defined" medium are discussed.     

Characterization of osteoblastic properties of 7F2 and UMR-106 cultures after acclimation to reduced levels of fetal bovine serum

Estrogen plays an important role in skeletal physiology by maintaining a remodeling balance between the activity of osteoblasts and osteoclasts. In an attempt to decipher the mechanism through which estrogen elicits its action on osteoblasts, experimentation necessitated the development of a culturing environment reduced in estrogenic compounds. The selected medium (OPTI-MEM) is enriched to sustain cultures under reduced fetal bovine serum (FBS) conditions and is devoid of the pH indicator phenol red, a suspected estrogenic agent. This protocol reduced the concentration of FBS supplementation to 0% through successive 24 h incubations with diminishing amounts of total FBS (1%, 0.1%, and 0%). The protocol does not appear to alter the viability, cell morphology, or osteoblast-like phenotype of 7F2 and UMR-106 cell lines when compared with control cells grown in various concentrations of FBS. Although the rate of mitotic divisions declined, the 7F2 and UMR-106 cultures continued to express osteoblast-specific markers and exhibited estrogen responsiveness. These experimental findings demonstrate that the culture protocol developed did not alter the osteoblast nature of the cell lines and provides a model system to study estrogen's antiresorptive role on skeletal turnover.     

Goat serum: an alternative to fetal bovine serum in biomedical research

Serum is frequently added to the defined basal medium as a source of certain nutritional and macromolecular growth factors essential for cell growth. Although a number of synthetic media have been prepared serum continues to be used in cell culture by many investigators. The best supplementation to a basal medium is fetal bovine serum (FBS) that is most frequently used for all types of cell cultures. During last four decades National Institute of Virology, Pune, has been working on isolation and identification of viruses from clinical specimens, employing tissue culture. Initially FBS was used for this purpose. However, due to its prohibitive cost and uncertain supply an alternative was sought. Commercially available sera from newborn calf, sheep, horse, human and serum obtained from goat blood (available from local abattoir) were tried. Goat serum (GS) was found to be suitable for most of the cell lines and primary cultures. Primary cultures from guinea pig embryo, monkey kidney, chick embryo, mouse peritoneal macrophages, and established cell lines were prepared and grown in growth media supplemented with GS. These cultures were studied for their morphology and growth in comparison with cultures grown in FBS containing media, and were used for mass cultivation of cells, quantitation and susceptibility of various virus strains, studies on effects of different nutrients and natural substances on cellular metabolism and virus replication, epitope analysis of various strains of Japanese encephalitis (JE) virus, strain differentiation studies, studies on antibody dependent plaque enhancement, assay of murine migration inhibition factor. Monoclonal antibodies against JE virus adapted to GS were characterised for their retention of functionalities. The results were comparable to those of cell cultures grown in FBS containing media. Similar results on chromosome studies were obtained from patient's whole blood cultures prepared in GS and FBS containing growth media. Organ cultures from mammalian, reptile and avian hosts; successfully grown in GS supplemented growth media, were used for different virological studies. Growth media supplemented with GS were used for in vitro cultivation of malarial parasites. Thus since the last three decades many scientists are using GS in place of FBS, in various fields of biomedical research. The present article reviews an account of the same.     

Medium-scale production and purification of monoclonal antibodies in protein-free medium.

Hybridoma cell lines can be adapted to grow in a totally protein-free tissue culture medium and cultured in spinner flasks to generate moderate-to-high quantities of monoclonal antibodies. Such antibodies are easily purified by ammonium sulfate precipitation. This system was shown to be useful for growth of 23 different hybridoma cell lines from different sources to yield an average of 40 mg of highly purified antibody per liter of tissue culture medium.     

Kinetic analysis of hybridoma cell culture in a protein-free medium: Substrate and agitation effects

A kinetic study of a hybridoma cell line that produces monoclonal antibodies against lactoferrin was carried out. A well defined protein-free culture medium was employed to facilitate the subsequent purification of the monoclonal antibodies. It should be highlighted that most of the existing work has been carried out employing culture media enriched with fetal bovine serum (FBS). Cell growth and monoclonal antibody production were monitored and kinetic parameters were determined. Besides, fundamental nutrients such as glucose and glutamine, inhibitory products such as ammonium and lactate, and several amino acids were followed throughout the culture. Additional experiments were carried out supplementing the medium with glutamine and ammonium, none of them resulting the key compound that halted the cell growth under the tested conditions and an unstructured model can be used to describe the system. Finally, agitation of the culture by a rocker set-up has shown high values of the specific death rate.     

Production of interleukin 1 by adult T cell leukemia (ATL) cell lines

The accessory function for T cell activation and the production of interleukin 1 (IL 1) of adult T cell leukemia (ATL) cell lines were studied in vitro. ATL cell lines such as Hut-102, MT-1, and MT-2 functioned as accessory cells for the stimulation of human T cell proliferative response induced with concanavalin A (Con A) and induced allogeneic mixed lymphocyte reaction. Cell lysates of three ATL cell lines and the culture supernatant of MT-2 cells had activities to stimulate murine thymocyte proliferative response. Then we studied physicochemical properties of the factors produced by MT-2 cells. The m.w. of the factors were approximately 15,000 by Sephacryl S-200 column chromatography, and their isoelectric point values were 5.4 and 4.8 by chromatofocussing technique. No fraction contained interleukin 2 (IL 2) activities to stimulate IL 2-dependent murine cytotoxic T cell line. The thymocyte-stimulating activities of the factors were absorbed with rabbit anti-IL 1 alpha antiserum, but not with anti-IL 1 beta antiserum. Furthermore, messenger RNA extracted from MT-2 cells hybridized to complementary DNA of IL 1 alpha, but not of IL 1 beta, by Northern blot hybridization analysis. The factors from MT-2 cells could stimulate the production of IL 2 and the expression of IL 2 receptors of human T cells in the presence of Con A as well as recombinant IL 1 alpha and IL 1 beta did, and these activities were also blocked by rabbit anti-IL 1 alpha antiserum, but not by anti-IL 1 beta antiserum. These results suggest that the factors produced by MT-2 cells correspond to IL 1 alpha. However, the accessory function of MT-2 cells for T cell activation was not blocked by rabbit anti-IL 1 antiserum. These results suggest that ATL cell lines produce IL 1-like factors, but the accessory function of ATL cell lines for T cell activation is mediated by some other mechanisms rather than by secreted IL 1-like factors.     

Growth of NS0 cells in protein-free, chemically defined medium

Many hybridoma and recombinant myeloma cell lines have been successfully adapted to growth in protein-free media. Compared with serum-supplemented media, use of protein-free media promotes superior cell growth and protein expression and facilitates downstream purification of the expressed product. Owing to its sterol auxotrophy, the NS0 myeloma is normally grown in either a serum-supplemented medium or a serum-free medium supplemented with an animal-derived lipoprotein. CD Hybridoma Medium (a protein-free, chemically defined formulation) grows many cell lines that do not exhibit lipid dependence, but this medium does not support growth of NS0 cells without further lipid supplementation. We tested several commercially available lipid supplements in CD Hybridoma Medium, including bovine EX-CYTE VLE. None of the tested supplements supported long-term growth of NS0 cells in CD Hybridoma Medium. Sustained long-term growth of NS0 cells was achieved in CD Hybridoma Medium supplemented with various animal- or plant-derived lipids complexed with cyclodextrin. NS0 cells adapted to CD Hybridoma Medium supplemented with cyclodextrin-lipid complex reached peak cell densities that were more than double those observed in serum-supplemented medium and were cultured for more than 15 passages. These cultures were also successfully cryopreserved and recovered in this defined medium. Through the use of cyclodextrin-based additives to CD Hybridoma Medium, it is possible to solubilize significant quantities of sterols and other lipids and to maintain a protein-free, chemically defined cultivation environment for NS0 cells. The culture system can be kept entirely free of animal-derived components if the supplement is made with plant-derived or synthetic lipids.     

Simultaneous identification and determination of major taxoids from extracts of Taxus chinensis cell cultures

Liquid chromatography electrospray ionization tandem mass spectrometry (LC/ESI-MS/ MS) and high-performance liquid chromatography (HPLC) methods have been used to identify and quantify the major taxoids from extracts of Taxus chinensis cell cultures. Chromatography was carried out on a reverse phase C18 column with isocratic-mode elution. By analytically comparing LC/ESI-MS/MS of the extracts with that of the available reference substances and literature, six taxoids were identified as taxuyunnanine C (Tc, 1), yunnanxane (2), 2alpha,5alpha10beta-triacetoxy-14beta-propionyloxytaxa-4(20),11-diene (3), 2alpha,5alpha, 10beta-triacetoxy-14beta-(2-methyl)butyryloxytaxa-4(20),11-diene (4), taxol (5), and baccatin III (B III, 6), respectively. Among them, 2, 3 and 4 were assigned in the absence of the corresponding reference substances, and 3 and 4 were detected in this cell line for the first time. The identification was validated by NMR spectra. The precise quantification of 1 and 5 was made using HPLC. The limit of detection (LOD), 0.5 microg/ml for 5, 1.5 microg/ml for 1, and the linearity and accuracy of the quantitative method were evaluated, indicating a wide linear range and satisfactory accuracy. The amounts of other identified taxoids were calculated on the basis of comparison of the absolute response factors of similar structural substances. The proposed method provides a rapid, conventional and reliable tool to characterize and study cell lines for elucidating the taxane biosynthesis.