双极膜电渗析分离发酵液中L-乳酸

采用三室型双极膜电渗析装置将发酵液中的L-乳酸钠转化为L-乳酸。探讨操作电压、流速、进料L-乳酸钠质量浓度等工艺参数对转化过程的影响,考察电渗析过程参数对转化率、物料损失率、电流效率和能耗等技术指标的影响。在最优操作条件下（流速40L／h,电压15V）对2L的100．25g／L乳酸钠发酵液进行分批重复电渗析处理。结果表明：整个过程的转化率为81．22％,损失率为1．5％,能耗为0．81kW·h／kg,电流效率为91．8％,得到的L-乳酸质量浓度可达144．31g／L．电渗析残液补糖后可回到发酵罐中用于发酵生产L-乳酸.     

Application of bipolar electrodialysis on recovery of free lactic acid after simultaneous saccharification and fermentation of cassava starch

The efficiency of bipolar electrodialysis (BED) for the recovery of lactic acid from fermentation broth was evaluated. Three systems of BED (bipolar-anion, bipolar-cation and bipolar-anion-cation) at fixed voltage (20 V) were compared using a model solution of ammonium lactate (100 g l(-1)). Results showed that bipolar-anion (BED-anion) was the most beneficial in terms of lactate flux, current efficiency, energy consumption and recovery ratio. Consequently, BED-anion was used to purify lactic acid from fermentation broth which had been pre-treated with mono-polar electrodialysis (MED). The final lactic acid concentration and lactate flux obtained were 144 g l(-1) and 393 g m(-2) h(-1), respectively. Using the two-step process (MED and BED-anion) the concentration of fermentation broth was increased by 33% and the total energy consumption was 2.76 kW h kg(-1).     

Recovery of lactic acid from fermentation broth by the two-stage process of nanofiltration and water-splitting electrodialysis

A two-stage process of nanofiltration and water-splitting electrodialysis was investigated for lactic acid recovery from fermentation broth. In this process, sodium lactate is isolated from fermentation broth in the first stage of nanofiltration by using an NTR-729HF membrane, and then is converted to lactic acid in the second stage by water-splitting electrodialysis. To determine the optimal operating conditions for nanofiltration, the effects of pressure, lactate concentration, pH and known added impurities were studied. Lactate rejection was less than 5%, magnesium rejection approximated 45%, and calcium rejection was at 40%. In subsequent water-splitting electrodialysis, both the sodium lactate conversion to lactic acid and sodium hydroxide recovery, were about 95%, with a power requirement of 0.9∼1.0 kWh per kg of lactate.     

Stimulation of the rate of l-lactate fermentation using Lactococcus lactis IO-1 by periodic electrodialysis

Lactic acid fermentation in glucose medium with periodic electrodialysis by Lactococcus lactis IO-1 was examined. The fermentation time was reduced considerably, compared with the time required for ordinary built-in electrodialysis fermentation with a microfilter module (ED-MF). Fermentation with an initial glucose concentration of 80 g/l was completed within 18 h, about 50% of the time required with an ED-MF. The maximum productivity of this novel system was about two-fold that of the ordinary ED-MF system even when the lactate concentration in broth was higher than in the ED-MF. The H₂ gas produced from the ED-MF made the culture redox potential (CRP) lower than in the novel system. Online culture redox potential was monitored and higher CRP indicated a higher fermentation rate.     

Process development and optimisation of lactic acid purification using electrodialysis

Cell free sodium lactate solutions were subjected to purification based on mono- and bi-polar electrodialysis. Lactate concentration in the product stream increased to a maximum of 15% during mono-polar electrodialysis. Stack energy consumption averaged 0.6 kW h kg(-1) lactate transported at current efficiencies in the 90% range. Under optimum feed concentration (125 g l(-1)) and process conditions (auto-current mode with conductivity setpoints of minimum 5 and maximum 40 mS cm(-1)), lactate flux reached 300 g m(-2) h(-1) and water flux were low for mono-polar electrodialysis averaging 0.3 kg H(2)O per M lactate transported. Glucose in the concentrate stream solutions was reduced to < 2 g l(-1). Acetate impurities enriched from about 0.5 g l(-1) in the feed stream to 1.5 g l(-1) in the concentrate stream solutions. After mono-polar electrodialysis, the concentrated sodium lactate solutions were further purified using bi-polar electrodialysis. Water transport during bi-polar electrodialysis reached figures of 0.070 - 0.222 kg H(2)O per M lactate. Free lactic acid concentration reached 16% with lactate flux of up to 300 g m(-2) h(-1). Stack energy consumption ranged from 0.6 to 1 kW h per kg lactate. Under optimised process conditions current efficiency during bi-polar electrodialysis was consistently around 90%. Glucose was further reduced from 2 to <1 g l(-1) in the free lactic acid solution. Acetic acid impurity remained at around 1 g l(-1). Significant reduction in colour and minerals in the product streams was observed during electrodialysis purification.     

Isolation of free lactic acid using electrodialysis

Summary Large scale electrodialysis was used to isolate and purify either sodium lactate or free lactic acid from the fermentation broth. In the best cases a four fold concentration was achieved. To obtain a product of a high purity, decolourization followed by a double exchange reaction is recommended.     

Acetic Acid Production by an Electrodialysis Fermentation Method with a Computerized Control System

In acetic acid fermentation by Acetobacter aceti, the acetic acid produced inhibits the production of acetic acid by this microorganism. To alleviate this inhibitory effect, we developed an electrodialysis fermentation method such that acetic acid is continuously removed from the broth. The fermentation unit has a computerized system for the control of the pH and the concentration of ethanol in the fermentation broth. The electrodialysis fermentation system resulted in improved cell growth and higher productivity over an extended period; the productivity exceeded that from non-pH-controlled fermentation. During electrodialysis fermentation in our system, 97.6 g of acetic acid was produced from 86.0 g of ethanol; the amount of acetic acid was about 2.4 times greater than that produced by non-pH-controlled fermentation (40.1 g of acetic acid produced from 33.8 g of ethanol). Maximum productivity of electrodialysis fermentation in our system was 2.13 g/h, a rate which was 1.35 times higher than that of non-pH-controlled fermentation (1.58 g/h).     

Recovery of potassium clavulanate from fermentation broth by ion exchange chromatography and desalting electrodialysis

Ion exchange chromatography (IEC) and desalting electrodialysis (DSED) processes were developed for the recovery and purification of potassium clavulanate (KCA) from fermentation broth. A strong anion exchanger, Amberlite IRA 400 resin, a potassium acetate solution as equilibrium buffer, and a potassium chloride (KCl) solution as elution buffer were used for the recovery of KCA in IEC. In order to determine optimal operating conditions, the effects of various operating parameters such as equilibrium buffer pH and concentration, elution buffer concentration, gradient length, and volumetric flow rate on KCA recovery and by-product removal were investigated using a simulated fermentation broth. In the subsequent step of DSED, employing cation (Neocepta CMS, Tokuyama, Japan) and anion (Neocepta ACS, Tokuyama, Japan) exchange membranes were carried out to remove KCl that existed in a large amount in the ion exchanged solution. The effects of operation voltage and feed composition on the performance of DSED were investigated. Based on the operating conditions determined above, IEC and DSED were applied in sequence to an ultrafiltered fermentation broth. Almost complete removal of KCl was possible with no significant loss of KCA, although the KCA recovery was slightly lower than that with the simulated fermentation broth. Based on this observation, it was concluded that IEC and DESD could be an effective process combination for the recovery of KCA from fermentation broth.     

茴香酸产生菌发酵条件的优化

为提高微生物降解反式茴脑获得茴香酸的产量,对假单胞菌Pseudomonas sp.NT2的发酵参数进行优化,以提高降解过程的转化率。利用单因素试验考察碳氮源种类及浓度、反式茴脑添加量、发酵温度、接种量、初始pH以及装液量对茴香酸生成量、反式茴脑降解率的影响,通过Plackett-Burman试验和最陡爬坡试验确定影响茴香酸生成量的显著因素并获取中心点,最后采用Box-Behnken模型进行响应面优化得到最佳发酵条件并验证。结果表明氯化铵浓度、初始pH和装液量是显著影响因素,最佳发酵条件为:柠檬酸钠10 g/L,氯化铵1.26 g/L,反式茴脑添加量1%,发酵温度30℃,接种量4%,初始pH 7.9,装液量42 mL/250 mL。优化后茴香酸生成量为7.24 g/L,为优化前的3.5倍,茴香酸摩尔生成率为80.72%,反式茴脑降解率为89.81%,分别比优化前提高了270.28%和97.78%。综上,假单胞菌NT2是生物转化生产茴香酸的潜力菌株。响应面优化可以显著提高反式茴脑的降解率和茴香酸产量,这为大规模生产茴香酸奠定了基础。     

埃博霉素B小试发酵罐发酵条件研究

研究了纤维堆囊菌(Sorangium cellulosum)So F5-76在5 L发酵罐水平上发酵生产埃博霉素B的基本工艺参数,具体考察了接种量、搅拌转速、通气量、添加消泡剂及补糖等5个工艺参数对埃博霉素B发酵产量的影响。最后确定发酵罐基本发酵条件为接种量9%,搅拌转速180 r/min,空气流量3.5 L/min,消泡剂种类选择Antifoam B聚醚类消泡剂,补糖控制在发酵液糖浓度为0.2 g/L,在此条件下埃博霉素B的产量可达25.6 mg/L。     

海带发酵制取生物乙醇的影响因素与优化条件

针对海带的碳水化合物不易被单一菌株发酵转化为乙醇的难题,通过酸化、匀浆和消化等预处理和正交试验,利用多酶系多菌种微生物复合发酵剂的酿酒曲,研究海带发酵制取生物乙醇的影响因素与优化条件。结果表明:在预处理试验中,加入一定量的Na2CO3,可以提高海带液中还原性糖和总糖的含量;消化温度对总糖影响相对较大,而对还原性糖的影响较小;过滤不利于得到较高浓度的乙醇;在优化条件中,发酵液的初始酸碱度是最重要的,其次是发酵温度和基质浓度,发酵液体积的影响程度相对较小。在基质(海带)质量浓度为0.15 g/L、温度34℃、起始pH 6.5和发酵液体积200 mL时,可以获得最大的乙醇产量4.09 g(以100 g海带计)。     

The Effect of Gas Sparging in Cross‐Flow Microfiltration of 2,3‐Butanediol Fermentation Broth

Recovery of 2,3‐butanediol from a fermentation broth entails the separation of cells and other suspended solids as the initial step for subsequent separation stages. The aim of this work was to study the cross‐flow filtration of broth in the fermentation of 2,3‐butanediol from blackstrap molasses by Klebsiella oxytoca (NRRL B‐199). A plate type laboratory scale cross‐flow microfiltration unit with a 0.2‐μm cellulose acetate membrane was employed for this purpose. Preliminary results showed that the permeate flux would decline rapidly due to fouling caused by the natural impurities of blackstrap molasses, and modifications of the conventional cross‐flow filtration would be essential to achieve a filtration rate appropriate for practical purposes. In this work, the permeate flux was enhanced by air sparging, which scoured the membrane surface of colloidal deposits and allowed a practical filtration rate to be maintained. The average permeate flux increased by 39 % and 54 % for an air sparging rate of 0.5 L/min and 1.0 L/min respectively, in the case of an initial biomass concentration of 4.66 g/L. For an initial biomass concentration of 14.2 g/L, the flux increased by 105 % and 146 % for the gas rate of 0.5 and 1.0 L/min, respectively. It may be concluded that gas sparging is beneficial in cross‐flow filtration of thick suspensions like a fermentation broth.     

Optimization of Exopolysaccharide Production by Lactobacillus delbrueckii subsp. bulgaricus RR Grown in a Semidefined Medium

The optimal fermentation temperature, pH, and Bacto-casitone (Difco Laboratories, Detroit, Mich.) concentration for production of exopolysaccharide by Lactobacillus delbrueckii subsp. bulgaricus RR in a semidefined medium were determined by using response surface methods. The design consisted of 20 experiments, 15 unique combinations, and five replications. All fermentations were conducted in a fermentor with a 2.5-liter working volume and were terminated when 90% of the glucose in the medium had been consumed. The population of L. delbrueckii subsp. bulgaricus RR and exopolysaccharide content were measured at the end of each fermentation. The optimum temperature, pH, and Bacto-casitone concentration for exopolysaccharide production were 38°C, 5, and 30 g/liter, respectively, with a predicted yield of 295 mg of exopolysaccharide/liter. The actual yield under these conditions was 354 mg of exopolysaccharide/liter, which was within the 95% confidence interval (217 to 374 mg of exopolysaccharide/liter). An additional experiment conducted under optimum conditions showed that exopolysaccharide production was growth associated, with a specific production at the endpoint of 101.4 mg/g of dry cells. Finally, to obtain material for further characterization, a 100-liter fermentation was conducted under optimum conditions. Twenty-nine grams of exopolysaccharide was isolated from centrifuged, ultrafiltered fermentation broth by ethanol precipitation.     

Optimization of the Process for the Production of L(+)‐Lactic Acid from Cull Potato by Rhizopus oryzae

Cull potato is currently an under‐utilized biomass in the potato processing states of the USA. L(+)‐Lactic acid production by three Rhizopus strains and one homofermentative, facultative anaerobic Lactobacillus amylophilus strain was investigated using potatoes as the sole nutrient supply in the culture medium. Rhizopus oryzae NRRL 395 was chosen as the strain for further studies because it showed the highest lactate yield. The fermentation conditions for seed cultures were studied for three treatment structures using a completely randomized design. Optimum conditions for the seed culture were determined to be 2 % potato medium, 10⁴ spores/mL concentration, and 24 h of fermentation. Plackett‐Burman and central composite designs were used to screen and optimize the factors for lactic acid production. Substrate (potato) concentration, fermentation temperature, and shaking speed were found to be the most significant factors affecting both the yield and concentration of lactate. Optimum values for substrate concentration, fermentation temperature, and shaking speed were 10 %, 27 °C, and 170 rpm, respectively. Under these optimum conditions, the lactate concentration was predicted by the model to be 35.5 g/L, which was verified by the experimental data (33.3 g/L). The results indicate that cull potato can be an effective feedstock for R. ryzae NRRL 395 in the production of lactic acid.     

Integrated bioprocess for the simultaneous production of lactic acid and dairy sewage treatment

An integrated biological process was developed for the conversion of whey lactose to lactic acid. We report about the achievement of maximum COD reduction and thus a substantial unburdening of the environment, combined with the economic production of lactic acid, appropriate for industrial scale. The process – designed for continuous operation – consists of four main steps: (i) Protein recovery by ultrafiltration leading to the first product: protein concentrate. The resulting filtrate is the fermentation substrate acid whey permeate. (ii) Adjustment of the composition of the permeate in the medium preparation step in order to ensure the proper function of the following process steps. (iii) Conversion of the lactose to lactate by fermentation with lactic acid bacteria in a cell recycle reactor, using ceramic microfiltration membranes. (iiii) Conversion of the lactate in the cell-free permeate stream of the fermentation to free lactic acid by bipolar electrodialysis. A stable operation of the process was attained up to more than 2000?hours. Using a new selected strain of lactic acid bacteria, a lactic acid productivity of 17?g?l^?1?h^?1 is achieved at total lactose conversion without any nitrogen supplements like yeast extract. A lactic acid concentration of 190?g?l^?1 is obtained in the acidic cell of the electrodialysis unit and the COD of the remaining sewage is diminished by 92%. As an additional cost reduction item, the neutralization agent of the fermentation is recovered in the caustic cell of the bipolar electrodialysis unit. A cost evaluation for an industrial scale process (100?000?t of whey per year) resulted in a price of 0.66 $ per kg of lactic acid, which under present terms hits the goal of making this process economic for the large scale production of lactic acid as an attractive building block for various purposes in chemical industry.     

发酵液中多拉菌素的提取和萃取条件研究

采用单因素实验,分别研究提取试剂、发酵液放置时间、pH值和温度对发酵液中多拉菌素提取效果的影响;然后以乙酸乙酯为萃取试剂,研究萃取次数及萃取体积对多拉菌素萃取效果的影响。结果显示,甲醇为最佳提取试剂;发酵液在pH为3～11、温度为20～80℃的条件下放置144 h,多拉菌素均能稳定存在,提取得到的多拉菌素的质量浓度没有显著变化;浓缩提取液液经2倍体积乙酸乙酯萃取2次即可。该条件下多拉菌素的质量浓度和萃取率分别为151.78μg/mL和98.00%。     

产酸丙酸杆菌生长特性及5L罐发酵动力学研究

论文在摇瓶水平对产酸丙酸杆菌基本生长特性（温度、pH、摇床转速、接种量、种龄等）、碳源、氮源利用情况、产物抑制及5 L罐发酵动力学进行了研究。结果表明,该菌在32℃,初始pH 6．5,摇床转速150 r/min,接种24 h的种子液,接种量为5％条件下,产酸丙酸杆菌生长及产酸水平达最高值;该菌可利用碳源十分广泛,但对氮源要求比较高,只可利用有机氮源;在不同初始葡萄糖浓度下,产酸丙酸杆菌生长及产酸水平差异不大,无明显底物抑制现象;在2g/L的初始丙酸盐浓度下,该菌生长受到明显抑制;在5L发酵罐中,初始葡萄糖浓度为58．8 g/L,发酵72 h,葡萄糖消耗完全,丙酸终浓度达22．4 g/L,丙酸得率和产率分别达0．381 g/g和0．295 g/（L·h）,丙酸占总酸比例达72．10％。     

Recovery of ammonium lactate and removal of hardness from fermentation broth by nanofiltration

Nanofiltration (NF) was investigated as an alternative to desalting electrodialysis (ED) and ion exchange for the recovery of ammonium lactate from fermentation broth. Three commercial NF membranes, NF45, NF70, and NTR-729HF, were characterized with 50 mM NaCl, MgSO(4), and glucose solutions. NF45 membrane was selected because it showed the lowest rejection of monovalent ion, the highest rejection of divalent ion, and the highest rejection of nonpolar molecule. Effects of the operating pressure were investigated in a range of 100-400 psig, on the flux, lactate recovery, and glucose and magnesium removal from a real fermentation broth containing about 1.0 M of ammonium lactate. The flux and recovery rate increased linearly with the pressure. However, lactate rejection also increased with the pressure, lowering the recovery yield. More magnesium ions and glucose were rejected as the pressure was increased, and at 400 psig, for example, magnesium ion was almost completely rejected, highlighting the chance of obviating the necessity of ion exchange to remove hardness, by using NF instead of desalting ED. Membrane fouling was not so severe as expected, considering the complex nature and a rather high concentration of the fermentation broth treated.     

海洋中海藻糖产生菌的筛选及发酵条件优化

从180余份海水、海泥样品中筛选得到60株产海藻糖较高的菌株,编号为2-14的菌株海藻糖产量最高,为127.9mg/g cell。对2-14菌株进行形态特征、培养特征及生理生化试验,鉴定该菌株为红酵母属(Rhodotorula sp.)。研究摇瓶发酵条件对红酵母海藻糖产量的影响,结果为:初始pH5.5,发酵温度28℃,装液量75mL(250mL三角瓶中)。采用优化后发酵条件红酵母海藻糖产量为193.3mg/g cell,优化前对照值为132.1mg/g cell,优化后的结果是优化前的1.46倍。在5L发酵罐中培养得到最佳发酵时间为54h,发酵罐培养发酵液中海藻糖含量最高达2.5g/L,为摇瓶培养的1.6倍。     

Optimization of citric acid production from a carrot juice-based medium by <Emphasis Type="Italic">Yarrowia lipolytica</Emphasis> using response surface methodology

In this study, diluted and fortified carrot juice was used for modelling and optimization of citric acid production by a new mutant strain, Yarrowia lipolytica K-168. Protein concentrate obtained from fine flour -a byproduct of semolina production- was used as a nitrogen source in the fermentation medium. Interactive effects of selected independent variables, initial total sugar concentration, initial pH, initial concentration of protein concentrate obtained from fine flour of semolina and temperature, on the growth and citric acid production of the yeast were investigated. An experimental design including 30 experiments was conducted by using the method of central composite design. Modelling the effects of these independent variables on maximum citric acid concentration, maximum citric acid production rate, citric acid yield, the ratio of maximum citric acid concentration to maximum isocitric acid concentration and specific growth rate were performed by response surface methodology. The variations of all of the responses with the independent variables were defined by a quadratic model. Numeric optimization was performed by using the desireability function. The conditions with 190.83 g/L initial sugar concentration, 5.90 initial pH, 0.07 g/L initial concentration of fine flour protein concentrate and 27.86 °C were determined as optimal conditions for citric acid production. The maximum citric acid concentration reached to 80.53 g/L in optimal conditions.