Treatment of winery effluent with upflow anaerobic sludge blanket (UASB) – granular sludges enriched with Enterobacter sakazakii

Three upflow anaerobic sludge blankets (UASBs) were evaluated for the treatment of winery wastewater: the first was seeded with granular sludge enriched with Enterobacter sakazakii and reached a 90% COD removal within 17 d at hydraulic retention time of 24 h; the second was seeded with brewery granules and achieved 85% COD removal within 50 d, the third was seeded with just sludge and showed the typical problems encountered with conventional sludge seeding and had continuously to be re-seeded. A PCR-based technique was developed for the rapid detection of E. sakazakii in the granular sludge.     

Microflora from leaf debris is suitable for treatment of starch industry wastewater

Biological treatment of industrial waste is a widely practiced technique that generates comparatively less environmentally hazardous waste than other chemical treatment processes. Wet milling of maize generates huge amount of wastewater (5 m³/ton) of low pH with organic matter and nutrients. Anaerobic methanogenic and aerobic bacteria are mostly highly sensitive to low pH. The treatment of wastewater causes huge cost of chemical neutralization or hydraulic recirculation for maintaining neutral pH. In the present study, different microbial consortia isolated from cow dung, active sludge from an anaerobic reactor for treatment of industrial wastewater, and leaf debris from benthic soil were screened for tolerance against low pH and for potential of chemical oxygen demand (COD) removal in order to find out an alternative microbial population for industrial water treatment at low pH. The most effective consortia found from leaf debris were further investigated for optimal operation. The microscopic analysis of leaf debris sludge showed abundance of Gram‐negative methanococci, which was found tolerant to low pH in plate culture method. On further investigation for COD removal from starch industry effluent, they were found to be most effective at pH 5 with highest COD removal rate of 70% and lowest biomass generation of 81%. Hence, it was concluded that the low pH‐tolerant methanogen bacteria, enriched from leaf debris sludge, is highly beneficial for anaerobic treatment of wastewater from several industries including corn starch industry by reducing cost of operation for neutralization to neutral pH and through reducing excess waste sludge production by the treatment system.     

Enhanced biological treatment of saline wastewater by using halophilic bacteria

Biological treatment of saline wastewater by conventional activated sludge culture usually results in low removal of chemical oxygen demand (COD) because of plasmolysis of the organisms at high salt concentrations. Since salt removal operations by physicochemical processes before biological treatment are costly, a salt-tolerant organism (Halobacter halobium) was used for effective biological treatment of saline wastewater in this study. Halobacter halobium was used in activated sludge culture for COD removal from saline wastewater (1–5% salt) by fed-batch operation of an aeration tank. Inclusion of Halobacter halobium into activated sludge culture improved the rate and extent of COD removals especially with salt above 2% (w/v).     

Evaluation of the efficacy of upflow anaerobic sludge blanket reactor in removal of colour and reduction of COD in real textile wastewater

The upflow anaerobic sludge blanket (UASB) reactor was evaluated for its efficacy in decolourization and reduction in chemical oxygen demand (COD) of real textile wastewater (RTW) under different operational conditions. The efficiency of UASB reactor in reducing COD was found to be over 90%. Over 92% of colour removal due to biodegradation was achieved. The activities of the anaerobic granules were not affected during the treatment of textile wastewater. Cocci-shaped bacteria were the dominant group over Methanothrix like bacteria in textile wastewater treatment. Alkalinity, volatile fatty acids (VFA) content and pH in effluents indicated that the anaerobic process was not inhibited by textile wastewater. It is concluded that UASB reactor system can effectively be used in the treatment of textile wastewater for the removal of colour and in the reduction of COD.     

Pilot study on the upgrading configuration of UASB-MBBR with two carriers: Treatment effect,sludge reduction and functional microbial identification

Two kinds of biocarriers were adopted and a combined process of “AMC (Anaerobic microorganism carrier)-UASB and PBG (Porous bio-gel)-MBBR” was operated at the pilot scale for the treatment of real textile wastewater. The influence mechanism of the two carriers on the start-up, pollutant removal and sludge reduction were investigated within 118 days of operation. The dominant functional bacteria in anaerobic and aerobic systems were identified by high-throughput sequencing, and the possible ways and related mechanisms of nutrient removal and sludge reduction were analyzed based on the data. 37.0 ± 7.5 % and 53 ± 12.7 % of COD removal efficiencies were achieved in anaerobic system and aerobic system, respectively. Ammonia nitrogen concentration decreased from 20 to 45 to 3.49 ± 0.54 mg/L after treatment. An anaerobe was found to be closely related to color removal, which existed in both anaerobic and aerobic systems, achieving 84.0 % of color removal. With the operation of the system, the sludge yield decreased gradually. The sludge yields of anaerobic and aerobic systems were calculated individually and compared with similar studies. Aging biofilms were characterized to explore the factors associated with biofilm renewal.     

Hydrothermal Oxidation of Oily Wastes: an Alternative to Conventional Treatment Methods

Under current legislations most oils used are considered hazardous wastes and its safe collection and disposal must be ensured. Since conventional treatment methods are often inefficient or environmentally unacceptable, the development and application of new technologies is highly necessary. Wet Air Oxidation (WAO) and Supercritical Water Oxidation (SCWO) are two forms of hydrothermal oxidation that have been proved to be effective processes to treat a wide variety of industrial wastes, but they have hardly been tested for oily wastes. In this work, the suitability of hydrothermal oxidation to the treatment of oily wastewaters is described by the results obtained with three different substrates: free fatty acids, cutting oils and bilge wastes. The efficiency of the treatment process is demonstrated for the three oily wastes tested. At temperatures below 350 °C and reaction times of 40 minutes, a 70‐‐90 % of COD elimination is achieved, obtaining an effluent with low molecular weight compounds, mainly carboxylic acids. At 500 °C, a 99 % of COD removal is achieved in less than one minute. At this temperature the reaction seems to proceed mainly through total mineralization to carbon dioxide and water.     

Experimental investigation of the external nitrification biological nutrient removal activated sludge (ENBNRAS) system

A systematic lab-scale experimental investigation is reported for the external nitrification (EN) biological nutrient removal (BNR) activated sludge (ENBNRAS) system, which is a combined fixed and suspended medium system. The ENBNRAS system was proposed to intensify the treatment capacity of BNR-activated sludge (BNRAS) systems by addressing two difficulties often encountered in practice: (a) the long sludge age for nitrification requirement; and (b) sludge bulking. In the ENBNRAS system, nitrification is transferred from the aerobic reactor in the suspended medium activated sludge system to a fixed medium nitrification system. Thus, the sludge age of the suspended medium activated sludge system can be reduced from 20 to 25 days to 8 to 10 days, resulting in a decrease in reactor volume per ML wastewater treated of about 30%. Furthermore, the aerobic mass fraction can also be reduced from 50% to 60% to <30% and concommitantly the anoxic mass fraction can be increased from 25% to 35% to >55% (if the anaerobic mass fraction is 15%), and thus complete denitrification in the anoxic reactors becomes possible. Research indicates that both the short sludge age and complete denitrification could ameliorate anoxic aerobic (AA) or low food/microorganism (F/M) ratio filamentous bulking, and hence reduce the surface area of secondary settling tanks or increase the treatment capacity of existing systems. The lab-scale experimental investigations indicate that the ENBNRAS system can obtain: (i) very good chemical oxygen demand (COD) removal, even with an aerobic mass fraction as low as 20%; (ii) high nitrogen removal, even for a wastewater with a high total kjeldahl nitrogen (TKN)/COD ratio, up to 0.14; (iii) adequate settling sludge (diluted sludge volume index [DSVI] <100 mL/g); and (iv) a significant reduction in oxygen demand.     

Treatment of wastewater from abattoirs before land application--a review

Pre-treatments are screening, catch basins, flotation, equalization, and settlers for recovering proteins and fats from abattoir wastewater. With chemical addition, dissolved air flotation (DAF) units can achieve chemical oxygen demand (COD) reductions ranging from 32% to 90% and are capable of removing large amounts of nutrients. Aerobic trickling towers reduced soluble COD by additional 27% but did not reduced total COD. Chemical-DAF reduced 67% of total COD and soluble COD. About 40-60% of the solids or approximately 25-35% of the biological oxygen demand (BOD) load can be separated by pre-treatment screening and sedimentation. Anaerobic systems are lagoon, anaerobic contact (AC), up-flow anaerobic sludge blanket (UASB), anaerobic sequence batch reactor (ASBR), and anaerobic filter (AF) processes. Abattoir wastewater is well suited to anaerobic treatment because it is high in organic compounds. Typical reductions of up to 97% BOD, 95% SS and 96% COD are reported. UASB's average COD removal efficiencies are of 80-85%. UASB seems to be a suitable process for the treatment of abattoir wastewater, due to its ability to maintain a sufficient amount of viable sludge. Wastewater in abattoirs can be reduced by treatment of immersion chiller effluent by membrane filtration which can produce recyclable water. Total organic C can be reduced below 100mg/L, and bacteria can not pass through the membrane pores. The abattoir waste minimization options are also discussed.     

Comparison between a moving bed membrane bioreactor and a conventional membrane bioreactor on organic carbon and nitrogen removal

A membrane bioreactor filled with carriers instead of activated sludge named a moving bed membrane bioreactor (MBMBR) was investigated for simultaneously removing organic carbon and nitrogen in wastewater. Its performance was compared with a conventional membrane bioreactor (CMBR) at various influent COD/TN ratios of 8.9–22.1. The operational parameters were optimized to increase the treatment efficiency. COD removal efficiency averaged at 95.6% and 96.2%, respectively, for MBMBR and CMBR during the 4 months experimental period. The MBMBR system demonstrated good performance on nitrogen removal at different COD/TN ratios. When COD/TN was 8.9 and the total nitrogen (TN) load was 7.58 mg/l h, the TN and ammonium nitrogen removal efficiencies of the MBMBR were maintained over 70.0% and 80.0%, respectively, and the removed total nitrogen (TN) load reached to 5.31 mg/l h. Multifunctional microbial reactions in the carrier, such as simultaneous nitrification and denitrification (SND), play important roles in nitrogen removal. In comparison, the CMBR did not perform so well. Its TN removal was not stable, and the removed total nitrogen (TN) load was only 1.02 mg/l h at COD/TN ratio 8.9. The specific oxygen utilization rate (SOUR) showed that the biofilm has a better microbial activity than an activated sludge. Nevertheless, the membrane fouling behavior was more severe in the MBMBR than in the CMBR due to a thick and dense cake layer formed on the membrane surface, which was speculated to be caused by the filamentous bacteria in the MBMBR.     

Challenge of psychrophilic anaerobic wastewater treatment

Psychrophilic anaerobic treatment is an attractive option for wastewaters that are discharged at moderate to low temperature. The expanded granular sludge bed (EGSB) reactor has been shown to be a feasible system for anaerobic treatment of mainly soluble and pre-acidified wastewater at temperatures of 5--10 degrees C. An organic loading rate (OLR) of 10--12 kg chemical oxygen demand (COD) per cubic meter reactor per day can be achieved at 10--12 degrees C with a removal efficiency of 90%. Further improvement might be obtained by a two-module system in series. Stabile methanogenesis was observed at temperatures as low as 4--5 degrees C. The specific activity of the mesophilic granular sludge was improved under psychrophilic conditions, which indicates that there was growth and enrichment of methanogens and acetogens in the anaerobic system. Anaerobic sewage treatment is a real challenge in moderate climates because sewage belongs to the 'complex' wastewater category and contains a high fraction of particulate COD. A two-step system consisting of either an anaerobic up-flow sludge bed (UASB) reactor combined with an EGSB reactor or an anaerobic filter (AF) combined with an anaerobic hybrid reactor (AH) is successful for anaerobic treatment of sewage at 13 degrees C with a total COD removal efficiency of 50% and 70%, respectively.     

Process efficiency and microbial monitoring in MBR (membrane bioreactor) and CASP (conventional activated sludge process) treatment of tannery wastewater

In this study a pilot-scale membrane bioreactor (MBR) and a conventional activated sludge plant (CASP), treating the same tannery wastewaters and in the same operating conditions, have been compared in order to evaluate the overall treatment efficiency, the presence and distribution of Gram negative bacteria and the kinetics of nitrifying bacteria. Process efficiency was evaluated in terms of organic and nitrogen compounds: the MBR showed a higher COD removal (+4%) and a more stable and complete nitrification. The Gram negative bacteria were detected by fluorescent in situ hybridization (FISH) with phylogenetic probes monitoring of alpha-, beta- and gamma-Proteobacteria, of the main ammonia-oxidizing bacteria (AOB) and nitrite-oxidizing bacteria of the Nitrobacter and Nitrospira genera. The results showed that the main differences between the two sludges were: the higher abundance of alpha- and gamma-Proteobacteria in the MBR bioreactor and the presence of AOB aggregates only on the surfaces of MBR flocs. Finally, the titrimetric (pH-stat, DO-stat) tests showed similar values of the kinetic parameters of the nitrifiers both in MBR and CASP sludge.     

A novel UASB–MFC–BAF integrated system for high strength molasses wastewater treatment and bioelectricity generation

An up-flow anaerobic sludge blanket reactor–microbial fuel cell–biological aerated filter (UASB–MFC–BAF) system was developed for simultaneous bioelectricity generation and molasses wastewater treatment in this study. The maximum power density of 1410.2 mW/m² was obtained with a current density of 4947.9 mA/m² when the high strength molasses wastewater with chemical oxygen demand (COD) of 127,500 mg/l was employed as the influent. The total COD, sulfate and color removal efficiencies of the proposed system were achieved of 53.2%, 52.7% and 41.1%, respectively. Each unit of this system had respective function and performed well when integrated together. The UASB reactor unit was mainly responsible for COD removal and sulfate reduction, while the MFC unit was used for the oxidation of generated sulfide with electricity generation. The BAF unit dominated color removal and phenol derivatives degradation. This study is a beneficial attempt to combine MFC technology with conventional anaerobic–aerobic processes for actual wastewater treatment.     

Simultaneous removal of carbon and nitrogen from municipal-type synthetic wastewater using net-like rotating biological contactor (NRBC)

The treatment of municipal-type synthetic wastewater was carried out using a three stages net-like rotating biological contactor (NRBC). The results indicated that, compared with conventional rotating biological contactor (RBC), NRBC have several advantages, such as quick start-up, high biomass concentration and can handle high organic loading rates. The COD and total nitrogen removal rates achieved were 78.8–89.7% and 40.2–61.4%, respectively, in aerobic treatment of low COD municipal-type wastewater at hydraulic retention times (HRT) from 5 to 9 h. The COD removal rate achieved 80–95% when organic loading varied between 16 and 40 gCOD/m² d. A large amount of nematodes were found in the NRBC system, which made the NRBC system produce relatively low amounts of waste sludge, due to their grazing.     

Effect of bioaugmentation of activated sludge with white-rot fungi on olive mill wastewater detoxification

AIMS: To test the potential use of Phanerochaete chrysosporium and other white-rot fungi to detoxify olive mill wastewaters (OMW) in the presence of a complex activated sludge. To combine the aerobic with anaerobic treatment to optimize the conversion of OMW in biogas. METHODS AND RESULTS: A 25-l air lift reactor was used to pretreat OMW by white-rot fungi. Detoxification of the OMW was monitored by size exclusion HPLC analysis, chemical oxygen demand (COD)/biological oxygen demand (BOD(5)) ratio evolution, and bioluminescence toxicity test. Anaerobic treatment of OMW was performed in a 12-l anaerobic filter reactor. Efficiency of the treatment was evaluated by organic matter removal, and biogas production. By comparison with the pretreatment by activated sludge only, the bioaugmentation with Phanerochaete chrysosporium or Trametes versicolor led to high removal of organic matter, decreased the COD/BOD(5) ratio and the toxicity. The subsequent anaerobic digestion of the OMW pretreated with activated sludge-white-rot fungi showed higher biomethanization yields than that pretreated with activated sludge only. Higher loading rates (7 g COD l(-1) day(-1)) were reached without any acidification or inhibition of biomethanization. CONCLUSIONS: The use of white-rot fungi, even in the presence of complex biological consortia to detoxify OMW, proved to be possible and made the anaerobic digestion of OMW for methane production feasible. SIGNIFICANCE AND IMPACT OF THE STUDY: The use of fungi for OMW reuse and energy production could be adapted to industrial applications.     

Simultaneous nitrification, denitrification, and phosphorus removal from nutrient-rich industrial wastewater using granular sludge

The biological removal of nitrogen and phosphorus from nutrient-rich abattoir wastewater using granular sludge has been investigated. A lab-scale sequencing batch reactor, seeded with granular sludge developed using synthetic wastewater, was operated for 13 months under alternating anaerobic and aerobic conditions. It is demonstrated that the granules could be sustained and indeed further developed with the use of abattoir wastewater. The organic, nitrogen, and phosphorus loading rates applied were 2.7 gCOD L(-1) day(-1), 0.43 gN L(-1) day(-1), and 0.06 gP L(-1) day(-1), respectively. The removal efficiency of soluble COD, soluble nitrogen and soluble phosphorus were 85%, 93%, and 89%, respectively. However, the high suspended solids in the effluent limited the overall removal efficiency to 68%, 86%, and 74% for total COD, TN, and TP, respectively. This good nutrient removal was achieved through the process known as simultaneous nitrification, denitrification, and phosphorus removal, likely facilitated by the presence of large anoxic zones in the center of the granules. The removal of nitrogen was likely via nitrite optimizing the use of the limited COD available in the wastewater. Accumulibacter spp. were found to be responsible for most of the denitrification, further reducing the COD requirement for nitrogen and phosphorus removal. Mineral precipitation was evaluated and was not found to significantly contribute to the overall nutrient removal. It is also shown that the minimum HRT in a granular sludge system is not governed by the sludge settleability, as is the case with floccular sludge systems, but likely by the limitations associated with the transfer of substrates in granules.     

Intensive bioconversion of sewage sludge and food waste by Bacillus thermoamylovorans

The main aim of this work was to intensify conventional composting of a mixture of sewage sludge and solid food wastes by a one-stage thermophilic bioconversion of these wastes into an organic fertilizer. An intensive process was carried out in a closed system, with or without addition of a starter culture of Bacillus thermoamylovorans. The most effective thermophilic bioconversion of the mixture of food waste and sewage sludge, with addition of starter culture, was when the pH was buffered with calcium carbonate, or the pH drop in the material was prevented by preliminary removal of sulphides from sewage sludge by hydrogen peroxide.     

Generating “Tide” in Pilot‐Scale Constructed Wetlands to Enhance Agricultural Wastewater Treatment

The operation of tidal flow was studied using a pilot‐scale system treating high strength piggery wastewater. Located on a farm in Staffordshire, UK, the system consisted of five wetland treatment stages vegetated with common reeds of Phragmites australis. Wastewater samples were collected from the inlet and outlet of each stage and analyzed for BOD₅, COD, NH₄‐N, NO₃‐N, NO₂‐N, SS, PO₄‐P and pH. Average hydraulic and organic loadings on the system were 0.12 m³/m² d and 240 g BOD/m² d, respectively, which is considerably higher than the typical loadings on conventional subsurface flow systems. On average, BOD₅ and COD were reduced by 82 % and 80 % from initial concentrations of 2000 mg/L and 2750 mg/L, respectively, across the whole system. The first‐order kinetics constant for BOD₅ removal (K_BOD in m/d) in this tidal flow system is approximately 2.5 times the rate constant obtainable in a typical horizontal flow system, demonstrating a more efficient removal of organic matter in tidal flow wetlands. The overall efficiency of the system was found to increase with time before stabilizing towards the end of a start‐up period. Straight‐line correlations were established between the loading and removal of BOD₅ and COD. Contributions by individual stages to the overall treatment were analyzed. SEM images of wetland media demonstrated the formation of biofilms and microbial activities inside the matrices of the wetland system, which accounted for the degradations of organic pollutants.     

Carbon source recovery from waste activated sludge by alkaline hydrolysis and gamma-ray irradiation for biological denitrification

The recovery of an organic carbon source from a waste activated sludge by using alkaline hydrolysis and radiation treatment was studied, and the feasibility of the solubilized sludge carbon source for a biological denitrification was also investigated. The effects of an alkaline treatment and gamma-ray irradiation on a biodegradability enhancement of the sludge were also studied. A modified continuous bioreactor for a denitrification (MLE reactor) was operated by using a synthetic wastewater for 47 days. Alkaline treatment of pH 10 and gamma-ray irradiation of 20 kGy were found to be the optimum carbon source recovery conditions. COD removal of 84% and T-N removal of 51% could be obtained by using the solubilized sludge carbon source through the MLE denitrification process. It can be concluded that the carbon source recovered from the waste activated sludge was successfully employed as an alternative carbon source for a biological denitrification.     

Enhancement of biological treatment performance of saline wastewater by halophilic bacteria

Performances of biological treatment processes of saline wastewater are usually low because of adverse effects of salt on microbial flora. High salt concentrations in wastewater cause plasmolysis and loss of activity of cells resulting in low COD removal efficiencies. In order to improve biological treatment performance of saline wastewater, a halophilic organism Halobacter halobium was used along with activated sludge culture.A synthetic wastewater composed of diluted molasses, urea, KH₂PO₄ and various concentrations of salt (1%–5% NaCl) was treated in an aerobic-biological reactor by fed-batch operation. Activated sludge culture with and without Halobacter were used as seed cultures. Variations of COD removal rate and efficiency with salt concentration were determined for both cultures and results were compared. Inclusion of Halobacter into activated sludge culture resulted in significant improvements in COD removal efficiency. A rate expression including salt inhibition effect was proposed and kinetic constants were determined by using experimental data.This study was supported by the Technical and Scientific Research Council of Turkey.     

好氧颗粒污泥对不同底物组成的响应

在序批式间歇反应器（R1、R2和R3）中,采用乙酸钠（R1）、蔗糖（R2）和苯酚（R3）三种不同基质作为碳源,均成功地培养出了好氧颗粒污泥;考察了不同颗粒污泥的理化性质及其对污染物的转化能力。结果表明,R1中颗粒污泥外观呈黄色,其主要的微生物菌群为细菌;R2中颗粒污泥外观呈黑色,内部含有丝状菌;而R3中颗粒污泥表面被大量丝状菌包裹,颗粒污泥呈淡黄色。在进水COD1000mg／L时R1、R2和R3中颗粒污泥比有机物的利用速率大小顺序为R3〉R1〉R2,而COD的去除率顺序却为R2〉R1〉R3。在进水氨氮40mg／L时,R1、R2和R3中氨氮的去除率分别在91％、96％和80％以上。以不同的底物培养出不同的好氧颗粒污泥可以拓展其在有毒化学物质如酚类化合物和高浓度工业废水生物处理中的应用。